Optimization of MM9 Medium Constituents for Enhancement of Siderophoregenesis in Marine Pseudomonas putida Using Response Surface Methodology

Pseudomonasputida (CMMB2) was isolated from open ocean water of Gulf of Mannar. The isolate was identified based on 16S rRNA gene sequencing and phylogenetic analysis. Chrome azurol sulphonate assay confirms siderophore production by the isolate. Nature of siderophore produced by the isolate was found to be of mixed type. Siderophore production was found to be inversely proportional to iron concentration of the medium. Maximum siderophore production was observed with MM9 medium. Siderophore production was found to be influenced by different carbon, nitrogen and amino acid sources. Optimization of MM9 medium nutrient composition by response surface methodology (RSM) enhances siderophore production. Application of RSM is one of the strategic attempts in cost effective siderophore production process. Presence of aromatic ring in the siderophore with (C–O) and (C=C) stretching was ascertained by FTIR spectral analysis. Mass spectral analysis revealed the presence of chromophore in the pyoverdine siderophore. Cell free supernatant and purified siderophore was found to inhibit the growth of bacterial and fungal pathogens.     

Isolation and characterization of siderophore from cowpeaRhizobium (peanut isolate)

In an iron-depleted broth culture of cowpeaRhizobium (a peanut isolate), phenolate type of compounds were detected. Chemical characterization showed the presence of 2,3-dihydroxy benzoic acid (DHBA) and 3,4-DHBA in the siderophore extract. Lysine and alanine were identified as conjugated amino acids of the siderophore. Maximum concentration of the siderophore in the culture supernatant was found after 24 h of growth. The compounds in the extracted siderophore induced growth ofRhizobium in a medium containing EDTA. Addition of lysine and alanine in the growth medium (20 mM each) led to a fourfold increase in siderophore production.     

Effect of iron limitation on growth, siderophore production, and expression of outer membrane proteins of Vibrio cholerae.

Vibrio cholerae strains secrete a phenolate-type siderophore when grown in low-iron medium. The siderophore was detected as early as 3.5 h after downshift to iron-poor medium, and it continued to accumulate in the medium as the cells entered stationary phase. Two clinical isolates and an environmental isolate were examined for the amount of siderophore produced. The environmental isolate produced more siderophore and continued to secrete it at concentrations of iron that repressed synthesis in the clinical isolates. Concomitant with production of siderophore, at least six new proteins were seen in the outer membranes of iron starved cells. One of the proteins was large (200,000 Mr [220K]) and appeared to be loosely associated with the outer membrane. The other five proteins had approximate Mr values of 77K, 76K, 75K, 73K, and 62K. The 62K protein, like the 40K major outer membrane protein, was heat modifiable. One or more of these proteins may be a component of the receptor for the iron-siderophore complex.     

Increase in spermine content coordinated with siderophore production in Paracoccus denitrificans.

Spermine is present in relatively low amounts in Paracoccus denitrificans cultured aerobically in an ammonium succinate minimal salts medium supplemented with 50 microM iron(III). However, in iron-deprived cultures [minimal salts medium containing 0.5 microM iron(III)], spermine content increases by an order of magnitude in coordination with the well-known responses to iron derivation, e.g., derepression of siderophore synthesis and siderophore excretion. When iron-deprived cultures exhibiting both high spermine content and strong siderophore production are reseeded into fresh minimal salts medium containing 50 microM iron[III], both siderophore production and spermine content fall rapidly. Five hours after iron supplementation, spermine is below limits of detection. These results suggest a specific role for spermine in the response of P. denitrificans to low-iron stress.     

Genetic algorithm-based medium optimization for enhanced production of fluorescent pseudomonad R81 and siderophore

Fluorescent pseudomonad R81, a root-colonizing bacterium, is a potential bio-inoculant due to its plant growth promoting characteristics. It produces hydroxamate-type siderophore which is involved in disease suppression in plants. Genetic algorithm (GA) methodology was applied for the optimization of siderophore and cell mass production simultaneously in shake flask experiments. A total of 10 medium components were optimized within 80 experiments. A high siderophore concentration of 1.9 g/L and cell mass concentration of 2.8 g/L was achieved in the optimized medium. The application of GA was well suited for determination of optimum concentration levels of the medium constituents for a bi-objective function. GA was able to increase the siderophore concentration by 2.8-fold when compared to RSM-based optimization. Further, the batch fermentation of the GA-optimized medium in 14 L bioreactor without pH control produced 2.2 g/L siderophore in 36 h, the highest reported so far. GA was also successfully used to estimate the kinetic parameters of the mathematical models of the batch fermentation.     

Genetic algorithm-based medium optimization for enhanced production of fluorescent pseudomonad R81 and siderophore

Fluorescent pseudomonad R81, a root-colonizing bacterium, is a potential bio-inoculant due to its plant growth promoting characteristics. It produces hydroxamate-type siderophore which is involved in disease suppression in plants. Genetic algorithm (GA) methodology was applied for the optimization of siderophore and cell mass production simultaneously in shake flask experiments. A total of 10 medium components were optimized within 80 experiments. A high siderophore concentration of 1.9 g/L and cell mass concentration of 2.8 g/L was achieved in the optimized medium. The application of GA was well suited for determination of optimum concentration levels of the medium constituents for a bi-objective function. GA was able to increase the siderophore concentration by 2.8-fold when compared to RSM-based optimization. Further, the batch fermentation of the GA-optimized medium in 14 L bioreactor without pH control produced 2.2 g/L siderophore in 36 h, the highest reported so far. GA was also successfully used to estimate the kinetic parameters of the mathematical models of the batch fermentation.     

Relationship ofAzotobacter chrooccum siderophores with nitrogen fixation

In iron-limited medium, a siderophore producing soil isolate ofAzotobacter chroococcum showed a high level of hydroxamate with relatively low level of nitrogen fixation. Inclusion of iron in the medium resulted in increased nitrogen fixation with decreased hydroxamate production. Under shake culture conditions, the level of both hydroxamate and catechol type of siderophores decreased after 2 d of incubation in iron-deficient medium. However, under iron-sufficient conditions, both siderophore production and nitrogen fixation increased with time although the level of siderophore was quite low. A number of soil isolates and mutants ofA. chrococcum were tested for nitrogen fixation, hydroxamate and catechol type of siderophore production. Wide variation was observed in the siderophore level and nitrogen fixation in the cultures tested. Nitrogen fixation was higher in the iron-sufficient medium than in iron-limited one while hydroxamate yield was higher in iron-limited medium than in the iron-sufficient one in all the cultures. Inclusion of ammonium acetate in the medium induced catechol synthesis in more than 60% of the cultures.     

Combat of iron-deprivation through a plant growth promoting fluorescent Pseudomonas strain GRP3A in mung bean (Vigna radiata L. Wilzeck)

Microorganisms and plants sustain themselves under iron-deprived conditions by releasing siderophores. Among others, fluorescent pseudomonads are known to exert extensive biocontrol action against soil and root borne phytopathogens through release of antimicrobials and siderophores. In this study, production and regulation of siderophores by fluorescent Pseudomonas strain GRP3A was studied. Among various media tested, standard succinate medium (SSM) promoted maximum siderophore production of 56.59 mg l(-1). There were low levels of siderophore in complex media like King's B medium, trypticase soya medium and nutrient medium (41.27, 29.86 and 27.63 mg l(-1)), respectively. In defferrated SSM, siderophore level was quantified to be 68.74 mg l(-1). Supplementation with iron (FeCl3) resulted in decreased siderophore levels depending on concentration. Siderophore production was promoted by Zn2+ (78.94 mg l(-1)), Cu2+ (68.80 mg l(-1)) whereas Co2+ (57.33 mg l(-1)) and Fe3+ reduced siderophore production (37.44 mg l(-1) as compared to control (55.97 mg l(-1)). Strain GRP3A showed plant growth promotion under iron limited conditions.     

Incorporation of l-lysine and 2,2′-dipyridyl in the growth media promotes desferrioxamine E production by an actinobacterium

The study describes the use of the chelating agent 2,2′-dipyridyl in conjunction with lysine to increase the production of the siderophore desferrioxamine E by a previously described actinobacterium 23F. Desferrioxamine E is a type of siderophore known to be produced by Streptomycete species. Lysine is a precursor of the siderophore and its presence in the culture medium is known to promote desferrioxamine E synthesis. The further addition of 2,2′-dipyridyl was found to enhance production of the siderophore in the presence of lysine (5 g l^?1) nearly twofold when incorporated at a concentration of 200 μM. Increasing the concentration of the chelating agent above 200 μM resulted in a decrease in siderophore production. The role of the chelating agent was thought to be in creating iron-limiting conditions in the culture medium and so promoting the induction of the desferrioxamine E biosynthetic pathway. This medium is likely to be a useful tool in the screening for producers of desferrioxamine E.     

Isolation and partial characterization of phenolate siderophore from Rhizobium leguminosarum IARI 102

Abstract Rhizobium leguminosarum IARI 102 produced 2,3-dihydroxy benzoic acid, a type of phenolate siderophore, under iron-starved conditions. Hydroxamic acids were not detected. Maximum production of siderophore was found at 26 h of growth in a chemically defined medium at 28°C with shaking. Threonine was detected as the amino acid conjugate of the siderophore. Addition of Fe³⁺ to the culture medium increased the growth yield significantly, but depressed the production of the iron chelating compound.     

铁限制条件下东海原甲藻分泌铁载体

在铁限制条件下,进行东海原甲藻分泌铁载体的动态研究。对藻类在富铁与缺铁条件下生长状况、生长过程中分泌铁载体的情况以及海藻接种量对铁载体分泌的影响进行了连续观测,结果表明:东海原甲藻在缺铁条件下生长状况远不如在富铁条件下;随着藻类的生长,分泌铁载体不断增多,达指数生长期时,其分泌量也达到了最大值,之后藻类的生长和铁载体分泌都呈现下降趋势;高接种量东海原甲藻能分泌较多的铁载体,并在较短时间到达峰值。     

Use of CAS-agar plate modified to study the effect of different variables on the siderophore production by Aspergillus

AIMS: To evaluate the suitability of chrome azurol S (CAS) agar plate assay as a quantitative methodology for siderophore production. METHODS AND RESULTS: Aspergillus species (A. flavus, A. niger, A. tamarii) were inoculated in the CAS-agar plates and the siderophores production was determined and expressed as CAS-reaction rate (mm per day). All the species showed positive CAS reaction with different rates depending on culture conditions and A. flavus showed the highest CAS-reaction rate. The siderophore production in solid medium expressed as CAS-reaction rate was correlated with siderophore production in liquid medium. CONCLUSIONS: The use of CAS-agar plate assay was modified and the evaluation of CAS reaction in mm per day made it possible to study and quantify the effect of several variables on the siderophore production by Aspergillus fungi. SIGNIFICANCE AND IMPACT OF THE STUDY: We describe the CAS-agar plate assay as a quantitative methodology, which make it possible to select and evaluate the siderophore production by several microorganisms (fungi and bacteria) according to different culture conditions.     

A simple agar plate assay for screening siderophore producer yeasts.

Yeasts produce hydroxamate-type siderophores (iron-binding compounds) in response to Fe-stress conditions. Because these siderophores are important to the biocontrol of postharvest diseases of apple and pears, a method for screening siderophore producer yeast was developed.The screening method was carried out in special Petri dishes with eight or nine wells (25-mm diameter). These wells were filled with siderophore production medium and seeded with yeasts isolated from epiphytic apple microflora. After yeasts grew (24-48 h), holes (2-mm diameter) were made in the agar of each well. Holes were filled with an acid solution of ferric perchlorate. After 10-15 min, reddish halos appeared in the bottom of the plate and their intensities were compared with standards. Standards were prepared in the same special dish with rhodotorulic acid solutions (concentrations between 0.05 and 1 g/l) plus 2% agar. When agar solidified into wells, holes were made and filled with ferric perchlorate solution. Color intensities of reddish halos were proportional to siderophore concentration and the detection limit was 0.1 g/l. It was possible to correlate the production of siderophore in solid medium with the results obtained in liquid medium. The methodology was also a useful tool for making a preliminary assessment of the influence of different factors on the siderophore production.     

镍胁迫下产铁载体细菌对花生的促生性

【目的】挖掘镍耐受性强、产铁载体活性高的植物根际促生细菌,研究镍胁迫下产铁载体细菌对花生的促生作用及其对花生吸收镍的影响。【方法】利用CAS(Chrome azurol S)培养基对花生根际产铁载体细菌定性筛选及定量测试获得产铁载体能力强的菌株,16S r RNA基因相似性及系统进化分析鉴定产铁载体细菌,并用含Ni~(2+)牛肉膏蛋白胨培养基测试细菌对Ni的耐受性;通过花生盆栽实验,测试花生的株高、根长、生物量、氮磷钾含量及镍含量来分析镍胁迫下产铁载体细菌对花生的影响。【结果】从花生根际分离筛选产铁载体芽孢杆菌5株,其中HSGJ1产铁载体能力最强,培养2 d后产156.56 mg/L的铁载体。HSGJ1对Ni~(2+)具有较强的耐受性,最小致死浓度为150 mg/L。在50、100 mg/kg的Ni~(2+)盆栽基质中,HSGJ1能够有效地促进花生的生长、增加花生的生物量及氮磷钾含量,并使花生根部和地上部分的镍含量降低。【结论】产铁载体芽孢杆菌HSGJ1是一株优良的植物根际促生细菌,可应用于镍污染农耕土壤的作物种植中,以提高作物在镍胁迫下的抗逆性,降低作物对镍的富集量,具有较好的应用价值。     

Bacterial growth stimulation with exogenous siderophore and synthetic N-acyl homoserine lactone autoinducers under iron-limited and low-nutrient conditions

The growth of marine bacteria under iron-limited conditions was investigated. Neither siderophore production nor bacterial growth was detected for Pelagiobacter sp. strain V0110 when Fe(III) was present in the culture medium at a concentration of <1.0 microM. However, the growth of V0110 was strongly stimulated by the presence of trace amounts of exogenous siderophore from an alpha proteobacterium, V0902, and 1 nM N-acyl-octanoylhomoserine lactone (C(8)-HSL), which is known as a quorum-sensing chemical signal. Even though the iron-binding functionality of a hydroxamate siderophore was undetected in the supernatant of V0902, a hydroxamate siderophore was detected in the supernatant of V0110 under the above conditions. These results indicated that hydroxamate siderophore biosynthesis by V0110 began in response to the exogenous siderophore from V0902 when in the presence of C(8)-HSL; however, C(8)-HSL production by V0110 and V0902 was not detected. Direct interaction between V0902 and V0110 through siderophore from V0902 was observed in the dialyzing culture. Similar stimulated growth by exogenous siderophore and HSL was also observed in other non-siderophore-producing bacteria isolated from marine sponges and seawater. The requirement of an exogenous siderophore and an HSL for heterologous siderophore production indicated the possibility that cell-cell communication between different species was occurring.     

Hydroxamate siderophore effect on growth of enterococci]

In eleven strains of genus Enterococcus relation between hydroxamate siderophore production and growth in iron-restricted liquid medium was investigated. Fe(III) deficiency caused moderate decrease of growth rate: the exponential growth phase was prolonged and yield of bacterial mass was lower. The hydroxamate siderophore was produced by all strains but occurred at different phase of growth. Only part of strains showed classical pattern of growth kinetic and siderophore synthesis.     

Effect of temperature on siderophore production by Candida albicans

The purpose of this study was to examine the effect of elevated temperature on growth and siderophore production by Candida albicans. The results showed that an increase in incubation temperature from 37 degrees C to 41 degrees C produced a marked decrease in both the rate and quantity of siderophore production. Elevated temperature was unable to suppress growth of C. albicans in either a control culture medium or a deferrated culture medium. A significant suppression of growth compared to the controls was observed in the deferrated media at both 37 degrees C and 41 degrees C. However with time, the growth of cells in the deferrated media showed partial recovery which was followed by an increase in siderophore production. Thus, elevation of temperature to suppress growth and siderophore production by C. albicans appears to be an ineffective host defense mechanism.     

Effect of iron on siderophore production and on outer membrane proteins ofRhizobium leguminosarum IARI 102

Rhizobium leguminosarum IARI 102 produced a phenolate type siderophore (a derivative of 2,3-DHBA) under iron-limited conditions. Addition of Fe³⁺ to the culture medium increased the growth yield significantly, but repressed the production of the iron-chelating compound. Iron level of culture medium also had a significant role in the composition of outer membrane proteins ofR. leguminosarum IARI 102. Maximum iron uptake was observed only in the presence of its own siderophore.