Kinetic analysis of a tod-lux bacterial reporter for toluene degradation and trichloroethylene cometabolism

Kinetics of toluene and trichloroethylene (TCE) degradation and bioluminescence from the bioreporter Pseudomonas putida B2 and TVA8 were investigated utilizing batch and continuous culture, respectively. Degradation was modeled using a Michaelis-Menten expression for the competition of two substrates for a single enzyme system, and bioluminescence was modeled assuming a luciferase enzyme saturational dependence on toluene as the inducer and growth substrate. During the batch experiments, bioluminescence increased at approximately 90 namp/min for initial toluene concentrations of 10 to 50 mg/L, but more slowly at higher toluene concentrations, suggesting maximum promoter induction at below 10 mg/L and toxic effects above 50 mg/L toluene. TCE degradation did not occur until toluene depletion, presumably due to competition between toluene and TCE for the toluene dioxygenase enzyme. During continuous culture, bioluminescence transiently increased, then gradually decreased in response to increasing step changes in toluene feed concentration. Bioluminescence in the CSTR appeared to be limited by growth substrate and/or inducer.     

Effect of Trichloroethylene on the Competitive Behavior of Toluene-Degrading Bacteria

The influence of trichloroethylene (TCE) on a mixed culture of four different toluene-degrading bacterial strains (Pseudomonas putida mt-2, P. putida F1, P. putida GJ31, and Burkholderia cepacia G4) was studied with a fed-batch culture. The strains were competing for toluene, which was added at a very low rate (31 nmol mg of cells [dry weight]⁻¹ h⁻¹). All four strains were maintained in the mixed culture at comparable numbers when TCE was absent. After the start of the addition of TCE, the viabilities of B. cepacia G4 and P. putida F1 and GJ31 decreased 50- to 1,000-fold in 1 month. These bacteria can degrade TCE, although at considerably different rates. P. putida mt-2, which did not degrade TCE, became the dominant organism. Kinetic analysis showed that the presence of TCE caused up to a ninefold reduction in the affinity for toluene of the three disappearing strains, indicating that inhibition of toluene degradation by TCE occurred. While P. putida mt-2 took over the culture, mutants of this strain which could no longer grow on p-xylene arose. Most of them had less or no meta-cleavage activity and were able to grow on toluene with a higher growth rate. The results indicate that cometabolic degradation of TCE has a negative effect on the maintenance and competitive behavior of toluene-utilizing organisms that transform TCE.     

A Chromosomally Based tod-luxCDABE Whole-Cell Reporter for Benzene, Toluene, Ethybenzene, and Xylene (BTEX) Sensing

A tod-luxCDABE fusion was constructed and introduced into the chromosome of Pseudomonas putida F1, yielding the strain TVA8. This strain was used to examine the induction of the tod operon when exposed to benzene, toluene, ethylbenzene, and xylene (BTEX) compounds and aqueous solutions of JP-4 jet fuel constituents. Since this system contained the complete lux cassette (luxCDABE), bacterial bioluminescence in response to putative chemical inducers of the tod operon was measured on-line in whole cells without added aldehyde substrate. There was an increasing response to toluene concentrations from 30 μg/liter to 50 mg/liter, which began to saturate at higher concentrations. The detection limit was 30 μg/liter. There was a significant light response to benzene, m- and p-xylenes, phenol, and water-soluble JP-4 jet fuel components, but there was no bioluminescence response upon exposure to o-xylene. The transposon insertion was stable and had no negative effect on cell growth.     

Toluene-Degrading Bacteria Are Chemotactic towards the Environmental Pollutants Benzene, Toluene, and Trichloroethylene

The bioremediation of polluted groundwater and toxic waste sites requires that bacteria come into close physical contact with pollutants. This can be accomplished by chemotaxis. Five motile strains of bacteria that use five different pathways to degrade toluene were tested for their ability to detect and swim towards this pollutant. Three of the five strains (Pseudomonas putida F1, Ralstonia pickettii PKO1, and Burkholderia cepacia G4) were attracted to toluene. In each case, the response was dependent on induction by growth with toluene. Pseudomonas mendocina KR1 and P. putida PaW15 did not show a convincing response. The chemotactic responses of P. putida F1 to a variety of toxic aromatic hydrocarbons and chlorinated aliphatic compounds were examined. Compounds that are growth substrates for P. putida F1, including benzene and ethylbenzene, were chemoattractants. P. putida F1 was also attracted to trichloroethylene (TCE), which is not a growth substrate but is dechlorinated and detoxified by P. putida F1. Mutant strains of P. putida F1 that do not oxidize toluene were attracted to toluene, indicating that toluene itself and not a metabolite was the compound detected. The two-component response regulator pair TodS and TodT, which control expression of the toluene degradation genes in P. putida F1, were required for the response. This demonstration that soil bacteria can sense and swim towards the toxic compounds toluene, benzene, TCE, and related chemicals suggests that the introduction of chemotactic bacteria into selected polluted sites may accelerate bioremediation processes.     

Quantification of toluene dioxygenase induction and kinetic modeling of TCE cometabolism by Pseudomonas putida TVA8.

As measured by the toluene-induced bioluminescent response of Pseudomonas putida TVA8 in batch experiments, toluene dioxygenase (Tod) enzyme activities are dependent on toluene concentration between 0 and 30 mg/L. To provide a measure of the Tod activity for use in Michaelis-Menten competitive-inhibition kinetics, a correlation between toluene concentration and induced Tod activity as measured by an induced bioluminescent response of P. putida TVA8 is presented as a nondimensional Tod activity parameter. A packed-bed, radial-flow bioreactor (RFB) using the bioreporter P. putida TVA8A serves as the model system for studying the effect of the enzyme activity parameter on model predictions of vapor-phase toluene oxidation and trichloroethylene (TCE) cometabolism. Mass balances were performed on a differential section of the RFB to describe the radial transport of vapor-phase toluene and TCE through a bulk gas phase and the concomitant biological reaction in a stationary biofilm phase. The finite-element Galerkin weak-statement formulation with first-order basis functions was used to find the optimum solution to the highly nonlinear, coupled equations. For this RFB system with toluene concentrations less than 1 mg/L in the bulk gas phase, the Tod activity parameter enables accurate predictions of steady-state TCE degradation rate (0.27 microg TCE/min).     

Co-metabolic degradation of trichloroethylene by Pseudomonas putida in a fibrous bed bioreactor

Co-metabolic degradation of trichloroethylene (TCE) by Pseudomonas putida F1 was investigated in a novel bioreactor with a fibrous bed. A pseudo-first-order rate constant for TCE degradation was 1.4 h^–1 for 2.4 to 100 mg TCE l^–1. Competitive inhibition of toluene on TCE removal could be prevented in this bioreactor. 90% TCE was removed over 4 h when 95 mg toluene l^–1 was presented simultaneously.     

Benzene, toluene, and o-xylene degradation by free and immobilized P. putida F1 of postconsumer agave-fiber/polymer foamed composites

Benzene, toluene, and o-xylene (BTX) degradation by immobilized Pseudomonas putida F1 of postconsumer agave-fiber/polymer foamed-composites (AFPFC) and suspended cultures was studied under controlled conditions. Analyses using FTIR-ATR and SEM showed that P. putida F1 adhered onto the composite surface and developed a biofilm. In this sense, the AFPFC were successfully used as a support for bacterial immobilization. Both systems, immobilized and suspended cells of P. putida F1, were able to completely degrade benzene and toluene from initial concentrations of 15, 30, 60, and 90 mg l⁻¹. An inhibitory effect of the intermediary catechol from benzene degradation was observed in suspended cultures but it was not presented in the immobilized system. The degradation of o-xylene was partially accomplished in both systems. The Monod equation was used to model the experimental data obtained from the biodegradation kinetics, and they were adequately described with this model.     

Addition of Aromatic Substrates Restores Trichloroethylene Degradation Activity in Pseudomonas putida F1

The rate of trichloroethylene (TCE) degradation by toluene dioxygenase (TDO) in resting cells of Pseudomonas putida F1 gradually decreased and eventually stopped within 1.5 h, as in previous reports. However, the subsequent addition of toluene, which is the principal substrate of TDO, resulted in its immediate degradation without a lag phase. After the consumption of toluene, degradation of TCE restarted at a rate similar to its initial degradation, suggesting that this degradation was mediated by TDO molecules that were present before the cessation of TCE degradation. The addition of benzene and cumene, which are also substrates of TDO, also caused restoration of TCE degradation activity: TCE was degraded simultaneously with cumene, and a larger amount of TCE was degraded after cumene was added than after toluene or benzene was added. But substrates that were expected to supply the cells with NADH or energy did not restore TCE degradation activity. This cycle of pseudoinactivation and restoration of TCE degradation was observed repeatedly without a significant decrease in the number of viable cells, even after six additions of toluene spread over 30 h. The results obtained in this study demonstrate a new type of restoration of TCE degradation that has not been previously reported.     

Recovery of trichloroethylene removal efficiency through short-term toluene feeding in a biofilter enriched withPseudomonas putida F1

Trichloroethylene (TCE) is an environmental contaminant provoking genetic mutation and damages to liver and central nerve system even at low concentrations. A practical scheme is reported using toluene as a primary substrate to revitalize the biofilter column for an extended period of TCE degradation. The rate of trichloroethylene (TCE) degradation byPseudomonas putida F1 at 25°C decreased exponentially with time, without toluene feeding to a biofilter column (11 cm I.D.×95 cm height). The rate of decrease was 2.5 times faster at a TCE concentration of 970 μg/L compared to a TCE concentration of 110 μg/L. The TCE itself was not toxic to the cells, but the metabolic intermediates of the TCE degradation were apparently responsible for the decrease in the TCE degradation rate. A short-term (2 h) supply of toluene (2,200 μg/L) at an empty bed residence time (EBRT) of 6.4 min recovered the relative column activity by 43% when the TCE removal efficiency at the time of toluene feeding was 58%. The recovery of the TCE removal efficiency increased at higher incoming toluene concentrations and longer toluene supply durations according to the Monod type of kinetic expression. A longer duration (1.4∼2.4 times) of toluene supply increased the recovery of the TCE removal efficieny by 20% for the same toluene load.     

Gene expression profiling of Pseudomonas putida F1 after exposure to aromatic hydrocarbon in soil by using proteome analysis

Pseudomonas putida F1 can metabolize toluene, ethylbenzene, and benzene for growth. Previously, we identified proteins involved in the utilization of these compounds by P. putida F1 through culture in liquid media. However, it was unclear whether laboratory analysis of bacterial activity and catabolism accurately reflected the soil environment. We identified proteins involved in the degradation of toluene, ethylbenzene, and benzene growth in soil using two-dimensional gel electrophoresis (2-DE) or standard SDS-PAGE combined with liquid chromatography–tandem mass spectrometry (LC–MS/MS). According to 2-DE/LC–MS/MS analysis, 12 of 22 key enzymes involved in the degradation of toluene, ethylbenzene, and benzene were detected. In standard SDS-PAGE/LC–MS/MS analysis of soil with ethylbenzene, approximately 1,260 cellular proteins were identified in P. putida F1. All key enzymes and transporter and sensor proteins involved in ethylbenzene degradation were up-regulated similar to that noted in liquid cultures. In P. putida F1, aromatic hydrocarbon response in soil is the same as that observed in liquid media.     

Biodegradation of benzene,toluene, ethylbenzene,and o-xylene by a coculture of Pseudomonas putida and Pseudomonas fluorescens immobilized in a fibrous-bed bioreactor

A fibrous-bed bioreactor containing the coculture of Pseudomonas putida and P. fluorescens immobilized in a fibrous matrix was developed to degrade benzene (B), toluene (T), ethylbenzene (E), and o-xylene (X) in synthetic waste streams. The kinetics of BTEX biodegradation by immobilized cells adapted in the fibrous-bed bioreactor and free cells grown in serum bottles were studied. In general, the BTEX biodegradation rate increased with increasing substrate concentration and then decreased after reaching a maximum, showing substrate-inhibition kinetics. However, for immobilized cells, the degradation rate was much higher than that of free cells. Compared to free cells, immobilized cells in the bioreactor tolerated higher concentrations (>1000 mg l⁻¹) of benzene and toluene, and gave at least 16-fold higher degradation rates for benzene, ethylbenzene, and o-xylene, and a 9-fold higher degradation rate for toluene. Complete and simultaneous degradation of BTEX mixture was achieved in the bioreactor under hypoxic conditions. Cells in the bioreactor were relatively insensitive to benzene toxicity; this insensitivity was attributed to adaptation of the cells in the bioreactor. Compared to the original seeding culture, the adapted cells from the fibrous-bed bioreactor had higher specific growth rate, benzene degradation rate, and cell yield when the benzene concentration was higher than 100 mg l⁻¹. Cells in the fibrous bed had a long, slim morphology, which is different from the normal short-rod shape found for suspended cells in solution.     

Influence of nanophase titania topography on bacterial attachment and metabolism

Surfaces with nanophase compared to conventional (or nanometer smooth) topographies are known to have different properties of area, charge, and reactivity. Previously published research indicates that the attachment of certain bacteria (such as Pseudomonas fluorescens 5RL) is higher on surfaces with nanophase compared to conventional topographies, however, their effect on bacterial metabolism is unclear. Results presented here show that the adhesion of Pseudomonas fluorescens 5RL and Pseudomonas putida TVA8 was higher on nanophase than conventional titania. Importantly, in terms of metabolism, bacteria attached to the nanophase surfaces had higher bioluminescence rates than on the conventional surfaces under all nutrient conditions. Thus, the results from this study show greater select bacterial metabolism on nanometer than conventional topographies, critical results with strong consequences for the design of improved biosensors for bacteria detection.     

Model based evaluation of a contaminant plume development under aerobic and anaerobic conditions in 2D bench-scale tank experiments

The influence of transverse mixing on competitive aerobic and anaerobic biodegradation of a hydrocarbon plume was investigated using a two-dimensional, bench-scale flow-through laboratory tank experiment. In the first part of the experiment aerobic degradation of increasing toluene concentrations was carried out by the aerobic strain Pseudomonas putida F1. Successively, ethylbenzene (injected as a mixture of unlabeled and fully deuterium-labeled isotopologues) substituted toluene; nitrate was added as additional electron acceptor and the anaerobic denitrifying strain Aromatoleum aromaticum EbN1 was inoculated to study competitive degradation under aerobic / anaerobic conditions. The spatial distribution of anaerobic degradation was resolved by measurements of compound-specific stable isotope fractionation induced by the anaerobic strain as well as compound concentrations. A fully transient numerical reactive transport model was employed and calibrated using measurements of electron donors, acceptors and isotope fractionation. The aerobic phases of the experiment were successfully reproduced using a double Monod kinetic growth model and assuming an initial homogeneous distribution of P. putida F1. Investigation of the competitive degradation phase shows that the observed isotopic pattern cannot be explained by transverse mixing driven biodegradation only, but also depends on the inoculation process of the anaerobic strain. Transient concentrations of electron acceptors and donors are well reproduced by the model, showing its ability to simulate transient competitive biodegradation.     

Cytotoxicity Associated with Trichloroethylene Oxidation in Burkholderia cepacia G4

The effects of trichloroethylene (TCE) oxidation on toluene 2-monooxygenase activity, general respiratory activity, and cell culturability were examined in the toluene-oxidizing bacterium Burkholderia cepacia G4. Nonspecific damage outpaced inactivation of toluene 2-monooxygenase in B. cepacia G4 cells. Cells that had degraded approximately 0.5 μmol of TCE (mg of cells⁻¹) lost 95% of their acetate-dependent O₂ uptake activity (a measure of general respiratory activity), yet toluene-dependent O₂ uptake activity decreased only 35%. Cell culturability also decreased upon TCE oxidation; however, the extent of loss varied greatly (up to 3 orders of magnitude) with the method of assessment. Addition of catalase or sodium pyruvate to the surfaces of agar plates increased enumeration of TCE-injured cells by as much as 100-fold, indicating that the TCE-injured cells were ultrasensitive to oxidative stress. Cell suspensions that had oxidized TCE recovered the ability to grow in liquid minimal medium containing lactate or phenol, but recovery was delayed substantially when TCE degradation approached 0.5 μmol (mg of cells⁻¹) or 66% of the cells' transformation capacity for TCE at the cell density utilized. Furthermore, among B. cepacia G4 cells isolated on Luria-Bertani agar plates from cultures that had degraded approximately 0.5 μmol of TCE (mg of cells⁻¹), up to 90% were Tol⁻ variants, no longer capable of TCE degradation. These results indicate that a toxicity threshold for TCE oxidation exists in B. cepacia G4 and that once a cell suspension has exceeded this toxicity threshold, the likelihood of reestablishing an active, TCE-degrading biomass from the cells will decrease significantly.     

Whole-Cell Kinetics of Trichloroethylene Degradation by Phenol Hydroxylase in a Ralstonia eutropha JMP134 Derivative

The rate, progress, and limits of trichloroethylene (TCE) degradation by Ralstonia eutropha AEK301/pYK3021 whole cells were examined in the absence of aromatic induction. At TCE concentrations up to 800 μM, degradation rates were sustained until TCE was no longer detectable. The K_s and V_max for TCE degradation by AEK301/pYK3021 whole cells were determined to be 630 μM and 22.6 nmol/min/mg of total protein, respectively. The sustained linear rates of TCE degradation by AEK301/pYK3021 up to a concentration of 800 μM TCE suggest that solvent effects are limited during the degradation of TCE and that this construct is little affected by the formation of toxic intermediates at the TCE levels and assay duration tested. TCE degradation by this strain is subject to carbon catabolite repression.     

Trichloroethylene mineralization in a fixed-film bioreactor using a pure culture expressing constitutively toluene ortho -monooxygenase

An aerobic, single-pass, fixed-film bioreactor was designed for the continuous degradation and mineralization of gas-phase trichloroethylene (TCE). A pure culture of Burkholderia cepacia PR1(23)(TOM(23C)), a Tn5transposon mutant of B. cepacia G4 that constitutively expresses the TCE-degrading enzyme, toluene ortho-monooxygenase (TOM), was immobilized on sintered glass (SIRANtrade mark carriers) and activated carbon. The inert open-pore structures of the sintered glass and the strongly, TCE-absorbing activated carbon provide a large surface area for biofilm development (2-8 mg total cellular protein/mL carrier with glucose minimal medium that lacks chloride ions). At gas-phase TCE concentrations ranging from 0.04 to 2.42 mg/L of air and 0.1 L/min of air flow, initial maximum TCE degradation rates of 0.007-0.715 nmol/(min mg protein) (equivalent to 8.6-392.3 mg TCE/L of reactor/day) were obtained. Using chloride ion generation as the indicator of TCE mineralization, the bioreactor with activated carbon mineralized an average of 6.9-10.3 mg TCE/L of reactor/day at 0.242 mg/L TCE concentration with 0.1 L/min of air flow for 38-40 days. Although these rates of TCE degradation and mineralization are two- to 200-fold higher than reported values, TOM was inactivated in the sintered-glass bioreactor at a rate that increased with increasing TCE concentration (e.g., in approximately 2 days at 0.242 mg/L and <1 day at 2.42 mg/L), although the biofilter could be operated for longer periods at lower TCE concentrations. Using an oxygen probe and phenol as the substrate, the activity of TOM in the effluent cells of the bioreactor was monitored; the loss of TOM activity of the effluent cells corroborated the decrease in the TCE degradation and mineralization rates in the bioreactor. Repeated starving of the cells was found to restore TOM activity in the bioreactor with activated carbon and extended TCE mineralization by approximately 34%. (c) 1997 John Wiley & Sons, Inc. Biotechnol Bioeng 55: 674-685, 1997.     

Pseudomonas putida Strains Which Constitutively Overexpress Mercury Resistance for Biodetoxification of Organomercurial Pollutants

Improved biocatalysts for mercury (Hg) remediation were generated by random mutagenesis of Pseudomonas putida with a minitransposon containing merTPAB, the structural genes specifying organomercury resistance. Subsequent selection for derivatives exhibiting elevated resistance levels to phenylmercury allowed the isolation of strains that constitutively express merTPAB at high levels, conferring the ability to cleave Hg from an organic moiety and reduce the freed Hg(II) to the less toxic elemental form, Hg⁰, at greater rates. Constitutive overexpression of merTPAB had no apparent effect on culture growth rates, even when Hg(II) was initially present at otherwise toxic concentrations. These properties were also combined with benzene and toluene catabolism, allowing detoxification of the metal component of phenyl mercuric acetate, as well as degradation of its aromatic moiety.     

Biodegradation of toluene in a trickling filter

A trickling filter packed with PVC 16?mm Raschig rings was used to study the degradation of toluene in a polluted air stream, by means of a bacterial biofilm of Pseudomonas putida ATCC 17484. A polluted stream was simulated by blending air with a controlled amount of toluene. The mixing was accomplished in a special mixing chamber designed for that purpose. Induction of the enzymes of the toluene degradative pathway and adaptation of the inoculum were done in batch cultures with minimum mineral media and phenol. The continuous experiments were monitored by mass spectrometry for the quantification of the various gases and of toluene removal. A 94% toluene removal was achieved with contacting times above one minute and toluene concentrations up to 400?ppm.     

Genetic Engineering of a Highly Solvent-Tolerant Pseudomonas putida Strain for Biotransformation of Toluene to p-Hydroxybenzoate

The solvent-tolerant strain Pseudomonas putida DOT-T1E has been engineered for biotransformation of toluene into 4-hydroxybenzoate (4-HBA). P. putida DOT-T1E transforms toluene into 3-methylcatechol in a reaction catalyzed by toluene dioxygenase. The todC1C2 genes encode the α and β subunits of the multicomponent enzyme toluene dioxygenase, which catalyzes the first step in the Tod pathway of toluene catabolism. A DOT-T1EΔtodC mutant strain was constructed by homologous recombination and was shown to be unable to use toluene as a sole carbon source. The P. putida pobA gene, whose product is responsible for the hydroxylation of 4-HBA into 3,4-hydroxybenzoate, was cloned by complementation of a Pseudomonas mendocina pobA1 pobA2 double mutant. This pobA gene was knocked out in vitro and used to generate a double mutant, DOT-T1EΔtodCpobA, that was unable to use either toluene or 4-HBA as a carbon source. The tmo and pcu genes from P. mendocina KR1, which catalyze the transformation of toluene into 4-HBA through a combination of the toluene 4-monoxygenase pathway and oxidation of p-cresol into the hydroxylated carboxylic acid, were subcloned in mini-Tn5Tc and stably recruited in the chromosome of DOT-T1EΔtodCpobA. Expression of the tmo and pcu genes took place in a DOT-T1E background due to cross-activation of the tmo promoter by the two-component signal transduction system TodST. Several independent isolates that accumulated 4-HBA in the supernatant from toluene were analyzed. Differences were observed in these clones in the time required for detection of 4-HBA and in the amount of this compound accumulated in the supernatant. The fastest and most noticeable accumulation of 4-HBA (12 mM) was found with a clone designated DOT-T1E-24.