Effects of pressed beet pulp silage inclusion in maize-based rations on performance of high-yielding dairy cows and parameters of rumen fermentation

Beet pulp contains high amounts of pectins that can reduce the risk of rumen disorders compared to using feedstuffs high in starch. The objective was to study the effects of inclusion of ensiled pressed beet pulp in total mixed rations (TMR) for high-yielding dairy cows. Two TMR containing no or about 20% (on dry matter (DM) basis) beet pulp silage were used. The beet pulp silage mainly replaced maize silage and corn cob silage. The TMR were intentionally equal in the concentrations of energy and utilisable crude protein (CP) at the duodenum. TMR were fed to 39 and 40 dairy cows, respectively, for 118 days. The average daily milk yield was about 43 kg/day. No significant differences in milk yield and milk fat or milk protein content were detected. DM intake of cows was significantly reduced by the inclusion of beet pulp silage (23.0 v. 24.5 kg/day). However, a digestibility study, separately conducted with sheep, showed a significantly higher organic matter digestibility and metabolisable energy concentration for the TMR that contained beet pulp silage. In vitro gas production kinetics indicated that the intensity of fermentation was lower in the TMR that contained beet pulp silage. In vitro production of short-chain fatty acids, studied using a Rusitec, did not differ between the TMR. However, the inclusion of beet pulp silage in the ration caused a significant reduction in the efficiency of microbial CP synthesis in vitro. The amino acid profile of microbial protein remained unchanged. It was concluded that beet pulp silage has specific effects on ruminal fermentation that may depress feed intake of cows but improve digestibility. An inclusion of beet pulp silage of up to 20% of DM in rations for high-yielding dairy cows is possible without significant effects on milk yield and milk protein or milk fat.     

Dried sugar beet pulp as a high energy feed for beef cattle

Digestibility trials with 8 lots of pelleted dried sugar beet pulp, carried out with wethers, demonstrated that dried sugar beet pulp is a highly digestible energy source for ruminants. From the digestion coefficients obtained, and a value number of 95, the starch equivalent of the dry matter of dried sugar beet pulp was calculated to be 73.3, while the net energy expressed in EF_r was 619 EF_r per kg dry matter. This is about 90% of the net energy content of barley containing 4% crude fibre in the dry matter.Beef production trials were carried out with 702 young bulls fed on complete dry rations based on dried sugar beet pulp. Two categories of animals were used: 322 baby-beef bulls (intensive system) slaughtered at 13 months of age at an average live-weight of 480 kg; and 380 young bulls coming from pasture (semi-intensive system) at about 250 kg live-weight, and fattened indoors up to at least 550 kg live-weight. With each category, three different rations have been studied. These contained respectively, 50, 60 or 70% pelleted dried sugar beet pulp; the remainder of the rations consisted of respectively 50, 40 or 30% concentrates. The diets were fed ad libitum; straw and water were always available. The three complete dry rations proved to be equally successful for intensive beef production. The carcass quality was good for all animals. The average daily gain obtained with the baby-beef bulls for the three rations respectively was 1 207 g, 1 274 g and 1 172 g; for the second category of bulls the mean growth rates were generally slightly higher: 1 281 g, 1 309 g and 1 357 g.The feed efficiency was higher with the younger animals: the baby-beef bulls (live-weight interval: 150–480 kg) consumed about 2.5 kg protein supplement and 3.5 kg dried sugar beet pulp per kg live-weight gain; while the intake per kg live-weight gain with the bulls of the second category (live-weight interval: 250–560 kg) amounted approximately to 2.75 kg protein supplement and 4 kg dried sugar beet pulp. Within each category of bulls, the feed cost per kg live-weight gain decreased with increasing amounts of dried sugar beet pulp in the rations.     

Utilization of agro-industrial orange peel and sugar beet pulp wastes for fungal endo- polygalacturonase production

The pectinase enzymes are involved in several industrial applications, and industrial waste is one of the largest environmental pollutants, so this study aims to Endo-polygalacturonase (endo-PG) producing using Aspergillus niger AUMC 4156, Penicillium oxalicum AUMC 4153 and P. variotii AUMC 4149 by using some agro-industrial wastes (dried orange peel and sugar beet pulp) as a sole raw carbon source for degradation these waste in the process of urban wastes disposal. The fermentation process was carried out as a submerged culture technique under both shaken and static culture conditions. A. niger AUMC 4156 was the most promising producer of endo-PG under static conditions while P. oxalicum AUMC 4153 was the highest producer of endo-PG under shaken conditions. Sugar beet pulp proved to be the most preferable to orange peel as the only source of carbon in both shaken and static cultures. The medium that encompassing orange peel as a single carbon source afforded the highest protein content with all tested fungal strains in stirred and static cultures in comparison with sugar beet pulp. The highest activity of endo-polygalacuronase that produced using A. niger AUMC 4156 and P. oxalicum AUMC 4153 was achieved by using sugar beet pulp at 3% concentration under static cultures, meanwhile maximal enzyme activity produced by both fungal strains required 2% sugar beet pulp under shaken cultures. Sugar beet pulp showed promised potential as a good inducer for endo-polygalacturoase production, and enzymes production depended on fungal strains, culture medium, and submerged fermentation conditions.     

Release of ferulic acid from agroindustrial by-products by the cell wall-degrading enzymes produced by Aspergillus niger I-1472

Aspergillus niger I-1472 was grown on sugar beet pulp to produce cell wall polysaccharide-degrading enzymes, including feruloyl esterases. Compared to enzymatic activities measured in commercially available mixtures previously used for the release of ferulic acid, the A. niger enzymes were more various. These enzymes were tested to release ferulic acid from sugar beet pulp, maize bran, or autoclaved maize bran. They were as efficient as the commercial mixture to release ferulic acid from sugar beet pulp. On the other hand, they were much more efficient to release ferulic acid from maize bran after autoclaving pretreatment, as 95% of ferulic acid ester were solubilized. Thus, A. niger enzymes exhibited a high interest in the release of ferulic acid from various agro-industrial by-products.     

Fractionation of sugar beet pulp into pectin, cellulose, and arabinose by arabinases combined with ultrafiltration.

Incubation of beet pulp with two arabinases (alpha-L-arabinofuranosidase and endo-arabinase), used singularly or in combination at different units of activity per gram of beet pulp, caused the hydrolysis of arabinan, which produced a hydrolyzate consisting mainly of arabinose. Pectin and a residue enriched with cellulose were subsequently separated from the incubation mixture. The best enzymatic hydrolysis results were obtained when 100 U/g of beet pulp of each enzyme worked synergistically with yields of 100% arabinose and 91.7% pectin. These yields were higher than those obtained with traditional chemical hydrolysis. The pectin fraction showed a low content of neutral sugar content and the cellulose residue contained only a small amount of pentoses. Semicontinuous hydrolysis with enzyme recycling in an ultrafiltration unit was also carried out to separate arabinose, pectin, and cellulose from beet pulp in 7 cycles of hydrolysis followed by ultrafiltration. The yields of separation were similar to those obtained in batch experiments, with an enzyme consumption reduced by 3.5 times and some significant advantages over batch processes.     

The Microflora and Concentrations of Volatile Fatty Acids in The Rumen of Cattle Fed on Single Component Rations

The composition of the rumen microflora and the volatile fatty acids were examined in cattle free-grazing on grass or stall-fed on hay, grass pellets, oats or dried beet pulp with molasses. Total and viable counts of anaerobic bacteria were highest on the grass feeding, but viable counts as a percentage of total counts were highest when oats or beet pulp with molasses were fed. Counts of cellulolytic bacteria were lowest on these latter 2 diets, and highest on grass or grass pellet diets. Studies of the anaerobic flora showed that the composition in animals fed on grass pellets resembled more that found in animals free-grazing on grass than in those fed on hay. Counts of aerotolerant bacteria were only a small percentage of the total count, but were highest on the hay diet. On this latter diet and on grass-feeding the streptococci (identified as Streptococcus bovis) were predominant, but contrary to expectation, streptococci were found only in small numbers on the oats diet, where coryneform rods were the major type present. Although a period of 4–6 weeks was allowed for the animals to adapt to the feeds, the 2 periods of feeding on oats and dried beet pulp with molasses markedly affected the composition of the rumen flora in the subsequent periods of feeding grass pellets and hay. Ruinen volatile fatty acid analysis showed a propionogenic effect of oats and the highest percentage of butyric acid when beet pulp with molasses was fed. The expected propionogenic effect of grass pellets was not observed.     

Adsorption of Basic violet 16 from aqueous solutions by waste sugar beet pulp: kinetic,thermodynamic, and equilibrium isotherm studies

Waste sugar beet pulp has been used as adsorbent for the removal of a hazardous cationic dye, Basic violet 16, from its aqueous solution. Adsorption of the dye was studied as function of time, pH of the solution, dosage of the adsorbent, sieve size of the particles, concentration of the dye, and temperature. The initial pH of the dye solution did not affect the chemistry of the dye molecule and the surface of beet pulp. Langmuir and Freundlich adsorption isotherms were successfully employed, and on the basis of these models, the thermodynamic parameters were evaluated. Adsorption of Basic violet 16 on beet pulp was found to be an exothermic reaction. Time contact studies showed that more than 80% adsorption of the dye is achieved in less than 1 h. Kinetics investigations confirmed both pseudo-first-order and pseudo-second-order behaviors; on the other hand, it shows that the intraparticle diffusion step is not the only rate-controlling step in all concentrations.     

Pectolytic clostridia isolated from sugar beet pulp silages in Italy

Twenty-eight strains of pectolytic clostridia were isolated from sugar beet pulp silages. Seventeen non-pigmented strains were presumed to be Clostridium acetobutylicum ; the remaining 11 pigmented strains were similar to Cl. felsineum. The addition of molasses to sugar beet pulps favoured the growth of other bacteria, particularly lactic acid organisms, whereas pectolytic clostridia were only occasionally found. The pectolytic clostridia promoted the structure loss of simulated silages. The use of molasses in sugar beet pulp ensiling was suggested to prevent texture loss of the ensiled mass.     

Influence of different fibre sources on digestibility and nitrogen and energy balances in growing pigs

The present study was undertaken to investigate how three different fibre sources, sugar beet pulp, soya bean hulls and pectin residue, constituting 15% of diets for growing pigs, influenced daily body gain, feed conversion, apparent faecal digestibility and nitrogen and energy balances. Eight castrated crossbreed pigs (30-80 kg live weight) were used in a replicated 4 x 4 Latin-square design with one control diet and three fibre containing diets. Daily body weight gain and feed conversion were not affected by the dietary treatments. The apparent faecal digestibility of organic matter (OM) and energy were significantly lower for the fibre diets (OM: 0.81-0.85; energy: 0.78-0.83) compared to the control diet (OM: 0.88; energy: 0.86). The apparent faecal digestibility of crude protein (CP) was lower for the fibre diets (0.71-0.78) compared to the control diet (0.83), although it was only significantly lower for the sugar beet pulp and pectin residue diets. The pectin residue diet, which contained the highest amount of dietary fibre, lignin and insoluble non-starch polysaccharides, had the lowest digestibility of OM, CP and energy. There was a tendency (p = 0.07) for a diet effect on retained nitrogen in proportion to digested nitrogen, where the sugar beet pulp and pectin residue diets had numerically the highest values. Heat production and retained energy in proportion to metabolizable energy intake were not affected by fibre inclusion. It was concluded that the inclusion of sugar beet pulp, soya bean hulls and pectin residue in diets for growing pigs decreased the apparent faecal digestibility and in the diets with sugar beet pulp and pectin residue higher utilization of digested nitrogen for retention compensated for the lower amount of digested nitrogen.     

Decolorization of sugar syrups using commercial and sugar beet pulp based activated carbons

Sugar syrup decolorization was studied using two commercial and eight beet pulp based activated carbons. In an attempt to relate decolorizing performances to other characteristics, surface areas, pore volumes, bulk densities and ash contents of the carbons in the powdered form; pH and electrical conductivities of their suspensions and their color adsorption properties from iodine and molasses solution were determined. The color removal capabilities of all carbons were measured at 1/100 (w/w) dosage, and isotherms were determined on better samples. The two commercial activated carbons showed different decolorization efficiencies; which could be related to their physical and chemical properties. The decolorization efficiency of beet pulp carbon prepared at 750 degrees C and activated for 5h using CO2 was much better than the others and close to the better one of the commercial activated carbons used. It is evident that beet pulp is an inexpensive potential precursor for activated carbons for use in sugar refining.     

Aspergillus niger I-1472 and Pycnoporus cinnabarinus MUCL39533, selected for the biotransformation of ferulic acid to vanillin, are also able to produce cell wall polysaccharide-degrading enzymes and feruloyl esterases

The filamentous fungal strains Aspergillus niger I-1472 and Pycnoporus cinnabarinus MUCL39533, previously selected for the bioconversion of ferulic acid to vanillic acid and vanillin respectively, were grown on sugar beet pulp. A large spectrum of polysaccharide-degrading enzymes was produced by A. niger and very few levels of feruloyl esterases were found. In contrast, P. cinnabarinus culture filtrate contained low amount of polysaccharide-degrading enzymes and no feruloyl esterases. In order to enhance feruloyl esterases in A. niger cultures, feruloylated oligosaccharide-rich fractions were prepared from sugar beet pulp or cereal bran and used as carbon sources. Number of polysaccharide-degrading enzymes were induced. Feruloyl esterases were much higher in maize bran-based medium than in sugar beet pulp-based medium, demonstrating the ability of carbon sources originating from maize to induce the synthesis of feruloyl esterases. Thus, A. niger I-1472 could be interesting to release ferulic acid from sugar beet pulp or maize bran.     

甜菜纤维的制备及其性质

甜菜纤维的制备及其性质樊志和周人纲王占武李晓芝韩炜（河北省农林科学院农业物理生理生化研究所,石家庄０５００５１）Ａｐｒａｃｔｉｃａｌｐｒｅｐａｒａｔｉｏｎａｎｄｃｈａｒａｃｔｅｒｉｚａｔｉｏｎｏｆｄｉｅｔａｒｙｆｉｂｅｒｆｒｏｍｓｕｇａｒ┐ｂｅｅｔｐ...     

Solid substrate fermentation of leached beet pulp withTrichoderma aureoviride

Optimum production of cellulases on leached beet pulp by native and mutant strains ofTrichoderma aureoviride in column-type, solid-substrate fermenters, at controlled temperature and aeration rate, was with a mutant strain, that produced 11 and 29 filter paper units of activity/g solids on raw and acid pre-treated leached beet pulp, respectively. The former value was 40% higher than in the native strain and 70% higher than in the reference strain. protein enrichment of residual solid was significant in all cases, with values up to 40% of total dry weight. Results are suitable for scale-up to pilot level.     

甜菜渣纤维素乙醇研究进展与展望

纤维素乙醇具有清洁、安全、可再生等优点,是新能源发展的重要方向,受到各国政府、企业的广泛关注。论文首先介绍了甜菜生物学特性,随后重点阐述甜菜及其副产物甜菜渣在三代生物乙醇开发中的优越性及应用进展。在此基础上提出了甜菜渣纤维素转化乙醇及组分分离综合利用的研究思路,认为甜菜渣将会作为一种重要原料在纤维素乙醇开发中发挥作用。     

The effect of diet in late pregnancy on progesterone concentration and colostrum yield in ewes

In the ewe, high level feeding is associated with low levels of circulating progesterone and that progesterone withdrawal is a prerequisite for lactogenesis and the onset of copious milk secretion. A total of 108 ewes was allocated to a 3 x 2 factorial experiment to determine the effect of diet on serum progesterone (P4) concentration and colostrum yield. On D 96 of pregnancy, the ewes were offered either grass silage, molassed sugar beet pulp (beet pulp) silage or grass silage supplemented with beet pulp. All ewes were given ad libitum access to silage. From D 126 of pregnancy, half the diets were supplemented with soybean meal with the aim of achieving a total crude protein intake of 220 g/ewe/day. Blood samples were taken on D 142 of pregnancy and at 1, 10 and 18 h post lambing for P4 determination. Metabolizable energy intakes (Mega Joules/ewe/day) of 9.1, 11.2 and 12.1 (SEM 0.37) and crude protein intakes (g/ewe/day) of 142.8, 167.4 and 162.0 (SEM 3.46) were recorded for grass silage, beet pulp ensiled and beet pulp supplemented silages, respectively, from D 126 to D 147 of pregnancy. Soybean meal supplementation increased the crude protein intake from 97.1 to 217.0 g/ewe/day (SEM 2.86) and Metabolisable Energy intake from 9.0 to 12.6 Mega Joules/ewe/day (SEM 0.31). Supplementation with soybean meal decreased P4 concentration (ng/ml) on D 142 (P < 0.05) and at 1 h (P < 0.01), 10 h (P < 0.01) and 18 h post lambing (P < 0.01). Ewes offered grass silage had higher P4 concentrations on D 142 (P < 0.01) and at 1 h after lambing (P < 0.05) than the beet pulp-supplemented ewes. There were negative linear relationships between P4 concentration at D 142 and colostrum yield at 1 h (P < 0.01) and between P4 concentration at 1 h and colostrum yield at 1 h (P < 0.001) and total yield at 18 h (P < 0.001). In conclusion, ewes which were underfed had higher P4 concentrations at all times, and there were negative linear relationships between colostrum yield and P4 concentrations on D 142 of pregnancy and at 1 h post lambing.     

Enzymic saccharification of sugar beet pulp

Culture filtrates of Talaromyces emersonii UCG 208 grown on beet pulp can convert the polysaccharide components of this agricultural waste to soluble sugars. The saccharification process is facilitated if the pulp is milled or incubated with alkali or peracetic acid before addition of enzyme. However, treatment of unmilled pulp with commercial pectinase prior to incubation with Talaromyces filtrate is also very effective; under suitable conditions, complete hydrolysis of total polysaccharides has been achieved.     

Anaerobic biodegradation of sugar beet pulp

Sugar beet pulp is a by-product of sugar production and consists mainly of cellulose, hemicellulose and pectin. Its composition is suitable for biological degradation. A possible alternative for the utilization of this material (besides cattle feeding) can be anaerobic methanogenic degradation. It has an additional advantage – biogas production. Beet pulp was treated by a two-step anaerobic process. The first step consisted of hydrolysis andacidification. The second step was methanogenesis. In this paper, observation ofthe process of anaerobic degradation and determination of optimal parameters is discussed. A laboratory-scale model for sugar beet pulp anaerobic biodegradation was operated. Results of model performance have shown very good pulp digestion characteristics. In addition, high efficiency removal of organic matter was achieved. Methane yield was over 0.360 m³ kg^-1 dried pulp and excess sludge production was 0.094 g per gram COD added.     

Influence of different fibre sources on digestibility and nitrogen and energy balances in growing pigs

Abstract

The present study was undertaken to investigate how three different fibre sources, sugar beet pulp, soya bean hulls and pectin residue, constituting 15% of diets for growing pigs, influenced daily body gain, feed conversion, apparent faecal digestibility and nitrogen and energy balances. Eight castrated crossbreed pigs (30 – 80 kg live weight) were used in a replicated 4 × 4 Latin-square design with one control diet and three fibre containing diets. Daily body weight gain and feed conversion were not affected by the dietary treatments. The apparent faecal digestibility of organic matter (OM) and energy were significantly lower for the fibre diets (OM: 0.81 – 0.85; energy: 0.78 – 0.83) compared to the control diet (OM: 0.88; energy: 0.86). The apparent faecal digestibility of crude protein (CP) was lower for the fibre diets (0.71 – 0.78) compared to the control diet (0.83), although it was only significantly lower for the sugar beet pulp and pectin residue diets. The pectin residue diet, which contained the highest amount of dietary fibre, lignin and insoluble non-starch polysaccharides, had the lowest digestibility of OM, CP and energy. There was a tendency (p = 0.07) for a diet effect on retained nitrogen in proportion to digested nitrogen, where the sugar beet pulp and pectin residue diets had numerically the highest values. Heat production and retained energy in proportion to metabolizable energy intake were not affected by fibre inclusion. It was concluded that the inclusion of sugar beet pulp, soya bean hulls and pectin residue in diets for growing pigs decreased the apparent faecal digestibility and in the diets with sugar beet pulp and pectin residue higher utilization of digested nitrogen for retention compensated for the lower amount of digested nitrogen.     

Effects of organic matter on sulphur oxidation in soil and influence of sulphur oxidation on soil nitrification

Summary The effects of wheat straw and pressed sugar beet pulp on sulphur oxidation were determined in a loam soil amended with 1% (w/w) elemental sulphur. Wheat straw stimulated the oxidation of elemental sulphur over the first 2 to 3 weeks of the incubation period, resulting in an increase in LiCl-extractable sulphate. After 4 to 7 weeks incubation however, the only significant increase in soil sulphate followed the 1% straw addition, while at week 7 sulphate concentrations in the 0.25% and 5.0% straw amended soils were lower than the control. Pressed sugar beet pulp (1% w/w) initially stimulated the oxidation of elemental sulphur in the soil, but by weeks 3 to 7 of the incubation period rates of oxidation in pulp-amended soils were lower than the control. Towards the end of the incubation period however, sulphate concentrations in the amended soils exceeded the control values, significantly so by week 11. The concentration of thiosulphate and tetrathionate also increased in soils receiving sugar beet pulp. Nitrification was inhibited in soils in which sulphur oxidation was actively occurring. Although possible alternatives are mentioned, such inhibition appears to result from a decrease in soil pH brought about by the oxidation of elemental sulphur to sulphuric acid.     

Feeding Value of Dried Sugar Beet Pulp from Egyptian Production

Abstract

Dried sugar beet pulp was fed to sheep in mixture with molasses (BPM), molasses plus urea (BPMU) or with hay (BPH) in comparison to whole diet of hay (H) in four metabolic trials.

There were no significant differences among the four rations although BPMU reflected the highest digestibility of nutrients. The BPH had the highest feeding value (total digestible nutrients “TDN” and metabolizable energy) and caused the highest retention of nitrogen.

Blood profile revealed that there were no significant effect of the rations on packed cell volume, haemoglobin, activity of glutamic pyruvic transaminase, Mg and Na. Whereas glucose, total N, Ca, P and K significantly affected.

The BPMU and BPH were found to be the best mixtures of the four tested rations in respect to the digestibility, feeding value and blood picture. Thus, dried sugar beet pulp could be offerred to animals in a mixture with molasses and urea or with hay according to the availability and price of the other ingredients than beet pulp, i.e. molasses and urea or hay.