Survival of Listeria monocytogenes in milk during high-temperature, short-time pasteurization

Milk from cows inoculated with Listeria monocytogenes was pooled for 2 to 4 days and then heated at 71.7 to 73.9 degrees C for 16.4 s or at 76.4 to 77.8 degrees C for 15.4 s in a high-temperature, short-time plate heat exchanger pasteurization unit. L. monocytogenes was isolated from milk after heat treatment in six of nine pasteurization trials done at 71.7 to 73.9 degrees C and in none of three trials done at 76.4 to 77.8 degrees C. An average of 1.5 to 9.2 L. monocytogenes cells was seen in each milk polymorphonuclear leukocyte before heat treatment in 11 of 12 pasteurization trials. Noticeable degradation of leukocytes with intracellular listeria was detected in unpasteurized milk after 3 days of storage at 4 degrees C, and by 4 days of storage leukocytes had deteriorated to cellular debris, suggesting that holding unpasteurized milk refrigerated for 4 or more days would eliminate a protective effect leukocytes may provide for increasing heat resistance of L. monocytogenes. Results indicate that under the conditions of this study, L. monocytogenes can survive the minimum high-temperature, short-time treatment (71.7 degrees C, 15 s) required by the U.S. Food and Drug Administration for pasteurizing milk.     

Thermotolerance of heat-shocked Listeria monocytogenes in milk exposed to high-temperature, short-time pasteurization.

The effect of prior heat shock (48 degrees C for 15 min) on the thermotolerance of Listeria monocytogenes at the minimal high-temperature, short-time (71.7 degrees C for 15 s) parameters required by the Pasteurized Milk Ordinance was examined. The mean D71.7 degrees C value for heat-shocked L. monocytogenes was 4.6 +/- 0.5 s (control D = 3.0 +/- 1.0 s); the ratio of D to control D was 1.5. The increased thermotolerance of heat-shocked Listeria cells was not significant and appeared unlikely to have practical implications, in terms of risk assessment, for the safety of pasteurized milk.     

Thermotolerance of heat-shocked Listeria monocytogenes in milk exposed to high-temperature, short-time pasteurization.

The effect of prior heat shock (48 degrees C for 15 min) on the thermotolerance of Listeria monocytogenes at the minimal high-temperature, short-time (71.7 degrees C for 15 s) parameters required by the Pasteurized Milk Ordinance was examined. The mean D71.7 degrees C value for heat-shocked L. monocytogenes was 4.6 +/- 0.5 s (control D = 3.0 +/- 1.0 s); the ratio of D to control D was 1.5. The increased thermotolerance of heat-shocked Listeria cells was not significant and appeared unlikely to have practical implications, in terms of risk assessment, for the safety of pasteurized milk.     

Effect of commercial-scale high-temperature, short-time pasteurization on the viability of Mycobacterium paratuberculosis in naturally infected cows' milk

Raw cows' milk naturally infected with Mycobacterium paratuberculosis was pasteurized with an APV HXP commercial-scale pasteurizer (capacity 2,000 liters/h) on 12 separate occasions. On each processing occasion, milk was subjected to four different pasteurization treatments, viz., 73 degrees C for 15 s or 25 s with and without prior homogenization (2,500 lb/in(2) in two stages), in an APV Manton Gaulin KF6 homogenizer. Raw and pasteurized milk samples were tested for M. paratuberculosis by immunomagnetic separation (IMS)-PCR (to detect the presence of bacteria) and culture after decontamination with 0.75% (wt/vol) cetylpyridinium chloride for 5 h (to confirm bacterial viability). On 10 of the 12 processing occasions, M. paratuberculosis was detectable by IMS-PCR, culture, or both in either raw or pasteurized milk. Overall, viable M. paratuberculosis was cultured from 4 (6.7%) of 60 raw and 10 (6.9%) of 144 pasteurized milk samples. On one processing day, in particular, M. paratuberculosis appeared to have been present in greater abundance in the source raw milk (evidenced by more culture positives and stronger PCR signals), and on this occasion, surviving M. paratuberculosis bacteria were isolated from milk processed by all four heat treatments, i.e., 73 degrees C for 15 and 25 s with and without prior homogenization. On one other occasion, surviving M. paratuberculosis bacteria were isolated from an unhomogenized milk sample that had been heat treated at 73 degrees C for 25 s. Results suggested that homogenization increases the lethality of subsequent heat treatment to some extent with respect to M. paratuberculosis, but the extended 25-s holding time at 73 degrees C was found to be no more effective at killing M. paratuberculosis than the standard 15-s holding time. This study provides clear evidence that M. paratuberculosis bacteria in naturally infected milk are capable of surviving commercial high-temperature, short-time pasteurization if they are present in raw milk in sufficient numbers.     

Effect of high-temperature, short-time (HTST) pasteurization on milk containing low numbers of Mycobacterium paratuberculosis

The efficacy of high-temperature, short-time (HTST) pasteurization (72 °C/15 s) when low numbers (≤ 10³ cfu ml ⁻¹ ) of Mycobacterium paratuberculosis are present in milk was investigated. Raw cows' milk spiked with Myco. paratuberculosis (10³ cfu ml⁻¹, 10² cfu ml⁻¹, 10 cfu ml⁻¹, and 10 cfu 50 ml⁻¹) was subjected to HTST pasteurization using laboratory pasteurizing units. Ten bovine strains of Myco. paratuberculosis were tested in triplicate. Culture in BACTEC Middlebrook 12B radiometric medium detected acid-fast survivors in 14·8% and 10% of HTST-pasteurized milk samples at the 10³ and 10² cfu ml⁻¹ inoculum levels, respectively, whereas conventional culture on Herrold's egg yolk medium containing mycobactin J detected acid-fast survivors in only 3·7% and 6·7% of the same milk samples. IS900-based PCR confirmed that these acid-fast survivors were Myco. paratuberculosis . No viable Myco. paratuberculosis were isolated from HTST-pasteurized milk initially containing either 10 cfu ml⁻¹ or 10 cfu 50 ml⁻¹.     

Listeria monocytogenes in pasteurized milk

An haemolytic Listeria monocytogenes strain pathogenic to mice was isolated from 6 out of 28 (21.4%) pasteurized milk samples (3.2% fat milk treated at 78 degrees C for 15 s) marketed by a Madrid processing plant. Listeria grayi was recovered from 25 of the samples (89.2%) and L. innocua from 3 samples (10.7%). One milk sample was contaminated with L. welshimeri. No strains of L. ivanovii, L. seeligeri, L. murrayi, or L. denitrificans were isolated. These results show that pathogenic Listeria strains can be isolated from pasteurized milk and reinforce the hypothesis that this food product may be the source of numerous human listeriosis.     

Isolation of Listeria monocytogenes from raw milk.

During a recent outbreak of listeriosis, we examined 121 raw milk samples and 14 milk socks (filters). Listeria monocytogenes was recovered from 15 (12%) of 121 milk specimens and 2 (14%) of 14 milk socks. The optimal processing method consisted of cold enriching diluted milk for 1 month with culture to selective broth, followed by plating.     

Survival of Listeria monocytogenes in raw milk treated in a pilot plant size pasteurizer

The survival of Listeria monocytogenes in raw milk treated in a pilot plant size pasteurizer was investigated. Raw milk was inoculated with different initial concentrations of L. monocytogenes and heated at temperatures ranging from 69 degrees to 73 degrees C. Listerias were not isolated from any of the milk samples immediately after thermal treatment. They were isolated, however, from 46.6% of heated samples (none from samples heated at 73 degrees C) after variable periods at refrigeration temperature. The results suggest that a low number of listerias survive some thermal treatments, but a cold enrichment is necessary to repair the thermally injured cells and detect these organisms in milk. The importance of the isolation technique in the recovery of listerias from pasteurized milk samples is discussed.     

Survival of Listeria monocytogenes in raw milk treated in a pilot plant size pasteurizer

The survival of Listeria monocytogenes in raw milk treated in a pilot plant size pasteurizer was investigated. Raw milk was inoculated with different initial concentrations of L. monocytogenes and heated at temperatures ranging from 69° to 73°C. Listerias were not isolated from any of the milk samples immediately after thermal treatment. They were isolated, however, from 46.6% of heated samples (none from samples heated at 73°C) after variable periods at refrigeration temperature. The results suggest that a low number of listerias survive some thermal treatments, but a cold enrichment is necessary to repair the thermally injured cells and detect these organisms in milk. The importance of the isolation technique in the recovery of listerias from pasteurized milk samples is discussed.     

Effects of growth temperature and strictly anaerobic recovery on the survival of Listeria monocytogenes during pasteurization.

Listeria monocytogenes F5069 was suspended in either Trypticase soy broth-0.6% yeast extract (TSBYE) or sterile, whole milk and heated at 62.8 degrees C in sealed thermal death time tubes. Severely heat-injured cells were recovered in TSBYE within sealed thermal death time tubes because of the formation of reduced conditions in the depths of the TSBYE. Also, the use of strictly anaerobic Hungate techniques significantly increased recovery in TSBYE containing 1.5% agar compared with aerobically incubated controls. The exogenous addition of catalase, but not superoxide dismutase, slightly increased the recovery of heat-injured cells in TSBYE containing 1.5% agar incubated aerobically. Growth of cells at 43 degrees C caused a greater increase in heat resistance as compared with cells heat shocked at 43 degrees C or cells grown at lower temperatures. Growth of L. monocytogenes at 43 degrees C and enumeration by the use of strictly anaerobic Hungate techniques resulted in D62.8 degrees C values that were at least sixfold greater than those previously obtained by using cells grown at 37 degrees C and aerobic plating. Results indicate that, under the conditions of the present study, high levels of L. monocytogenes would survive the minimum low-temperature, long-time treatment required by the U.S. Food and Drug Administration for pasteurizing milk. The possible survival of low levels of L. monocytogenes during high-temperature, short-time pasteurization and enumeration of injured cells by recovery on selective media under strictly anaerobic conditions are discussed.     

Enumeration of Listeria monocytogenes in raw milk

Enumeration of Listeria monocytogenes in raw milk was compared by direct plating and Most Probable Number (MPN) techniques involving both direct and two-stage enrichments. Direct plating was found to lack sensitivity for the enumeration of low numbers of listerias found in milk but an MPN technique with direct selective enrichment was found to be more suitable than one with two-stage enrichment.     

Survival of Listeria monocytogenes in Experimentally Infected Mice

Physiological saline was found to be very detrimental to the viability of Listeria monocytogenes. The LD(50) value was substantially reduced when peptone was used as the suspending fluid rather than saline. Normal splenic tissue was not inhibitory to the survival of Listeria. In experimentally infected mice, L. monocytogenes survived for 8 days in the peritoneal cavity and for at least 11 days in the spleen.     

Effects of growth temperature and strictly anaerobic recovery on the survival of Listeria monocytogenes during pasteurization

Listeria monocytogenes F5069 was suspended in either Trypticase soy broth-0.6% yeast extract (TSBYE) or sterile, whole milk and heated at 62.8 degrees C in sealed thermal death time tubes. Severely heat-injured cells were recovered in TSBYE within sealed thermal death time tubes because of the formation of reduced conditions in the depths of the TSBYE. Also, the use of strictly anaerobic Hungate techniques significantly increased recovery in TSBYE containing 1.5% agar compared with aerobically incubated controls. The exogenous addition of catalase, but not superoxide dismutase, slightly increased the recovery of heat-injured cells in TSBYE containing 1.5% agar incubated aerobically. Growth of cells at 43 degrees C caused a greater increase in heat resistance as compared with cells heat shocked at 43 degrees C or cells grown at lower temperatures. Growth of L. monocytogenes at 43 degrees C and enumeration by the use of strictly anaerobic Hungate techniques resulted in D62.8 degrees C values that were at least sixfold greater than those previously obtained by using cells grown at 37 degrees C and aerobic plating. Results indicate that, under the conditions of the present study, high levels of L. monocytogenes would survive the minimum low-temperature, long-time treatment required by the U.S. Food and Drug Administration for pasteurizing milk. The possible survival of low levels of L. monocytogenes during high-temperature, short-time pasteurization and enumeration of injured cells by recovery on selective media under strictly anaerobic conditions are discussed.     

Isolation of Listeria monocytogenes from raw milk

During a recent outbreak of listeriosis, we examined 121 raw milk samples and 14 milk socks (filters). Listeria monocytogenes was recovered from 15 (12%) of 121 milk specimens and 2 (14%) of 14 milk socks. The optimal processing method consisted of cold enriching diluted milk for 1 month with culture to selective broth, followed by plating.     

Survival of Listeria monocytogenes in yogurt during storage at 4°C

Cows' milk was inoculated with ca 10³and 10⁷cfu/ml Listeria monocytogenes. After fermentation at 42°C for 0–5 h, the yogurt was stored at 4°C. Low and high inocula survived for 48 h and 7 d, respectively; L. monocytogenes cells were not detectable by direct plating or cold-enrichment after 5 and 15 d, respectively. In low inoculum samples, initial pH at the time of refrigeration was 4·9; the final pH at the time of last sampling was 4·2. In the samples with high inoculum the pH decreased from 5·0 to 4·2.     

Sensitization of heat-treated Listeria monocytogenes to added lysozyme in milk.

Listeria monocytogenes was highly resistant to hen egg white lysozyme in whole milk but was sensitive in media and in phosphate buffer. Methods to sensitize the pathogen to lysozyme in milk were investigated. Treatment of whole milk by cation exchange to remove minerals, particularly Ca2+ and Mg2+, slightly promoted inactivation of L. monocytogenes by lysozyme at 4 degrees C over a period of 6 days. Heat treatment (62.5 degrees C for 15 s) strongly sensitized L. monocytogenes to lysozyme in demineralized milk and in MES [2-(N-morpholino)ethanesulfonic acid] buffer. Addition of Ca2+ or Mg2+ to the demineralized milk restored resistance to lysozyme. Cells were more rapidly heat inactivated at 55 degrees C in demineralized milk containing lysozyme, and addition of Ca2+ to the demineralized milk restored the resistance to heat. The results indicate that minerals or mineral-associated components protect L. monocytogenes from inactivation by lysozyme and heat in milk, probably by increasing cell surface stability. The heat treatment of foods containing added lysozyme can probably play a significant role in producing microbiologically safe foods.     

Method for flow cytometric detection of Listeria monocytogenes in milk.

This report describes a method for the detection of Listeria monocytogenes in raw milk by flow cytometric analysis of fluorescently labeled bacterial populations. The use of immunofluorescence in combination with measures of DNA content by propidium iodide labeling and size by light scattering enabled specific identification of L. monocytogenes from Streptococcus faecalis, Streptococcus agalactiae, Streptococcus uberis, Staphylococcus epidermidis, and Staphylococcus hyicus. Additional specific resolution of L. monocytogenes populations was achieved through selective enrichment of raw milk in Listeria enrichment broth. These procedures should permit the rapid screening of milk and other food samples for L. monocytogenes and eliminate many of the short-comings associated with conventional fluorescent-antibody procedures.     

Thermal inactivation of Listeria monocytogenes within bovine milk phagocytes.

Thermal resistance of intracellular and freely suspended Listeria monocytogenes that was associated with a milkborne outbreak of listeriosis was studied by using the sealed tube and slug flow heat exchanger methods. Test temperatures for the former method were 57.8, 62.8, 66.1, and 68.9 degrees C (136, 145, 151, and 156 degrees F, respectively); whereas those for the latter method were 66.1, 68.9, 71.7, and 74.4 degrees C (151, 156, 161, and 166 degrees F, respectively). The heating menstruum was sterile, whole milk. The intracellular inoculum was generated from an in vitro phagocytosis reaction by using endotoxin-induced bovine milk phagocytes. The phagocyte population consisted of 88% neutrophils, 8% macrophages, and 4% lymphocytes. Neutrophils harbored the majority of intracellular L. monocytogenes. The mean level of infectivity in the phagocyte population was 43%, and there were 26.1 +/- 19.3 bacteria per cell (10(4) viable cells per ml of test milk). Initial bacterial counts for the freely suspended and intracellular experiments (the latter was based on a sonically disrupted sample) were 10(6) L. monocytogenes cells per ml. Heat-stressed bacteria were recovered by direct plating in parallel with recovery from an enrichment broth; both methods gave comparable results. The predicted D62.8 degrees C (145 degrees F) value for intracellular sealed tube studies was 53.8 s (ZD = 5.6 degrees C [10.0 degrees F]), indicating a safe 33.4 D margin of inactivation for vat pasteurization (62.8 degrees C for 30 min).(ABSTRACT TRUNCATED AT 250 WORDS)