The treatment of cheese whey wastewater by sequential anaerobic and aerobic steps in a single digester at pilot scale

The treatment of reconstituted whey wastewater was performed in a 400 L digester at 20 °C, with an anaerobic digestion step, followed by a step of aerobic treatment at low oxygen concentration in the same digester. In a first set of 48 cycles, total cycle time (T_C) of 2, 3 and 4 days were tested at varying organic loading rates (OLR). The COD removal reached 89 ± 4, 97 ± 3 and 98 ± 2% at T_C of 2, 3 and 4 days and OLR of 0.56, 1.04 and 0.78 gCOD L⁻¹ d⁻¹, respectively. The activity of the biomass decreased for the methanogenic population, while increasing by 400% for the acidogens, demonstrating a displacement in the predominant trophic group in the biomass bed. A second set of 16 cycles was performed with higher soluble oxygen concentration in the bulk liquid (0.5 mg L⁻¹) during the aerobic treatment at a T_C of 2 days and an OLR of 1.55 gCOD L⁻¹ d⁻¹, with a soluble COD removal of 88 ± 3%. The biomass specific activities showed a compartmentalization of the trophic group with methanogenic activity maintained in the biomass bed and a high acidogenic activity in the suspended flocs.     

Potential for methane production from anaerobic co-digestion of swine manure with winery wastewater

This work examines the methane production potential for the anaerobic co-digestion of swine manure (SM) with winery wastewater (WW). Batch and semi-continuous experiments were carried out under mesophilic conditions. Batch experiments revealed that the highest specific methane yield was 348 mL CH₄ g⁻¹ COD added, obtained at 85.4% of WW and 0.7 g COD g⁻¹ VS. Specific methane yield from SM alone was 27 mL CH₄ g⁻¹ COD added d⁻¹. Furthermore, specific methane yields were 49, 87 and 107 mL CH₄ g⁻¹ COD added d⁻¹ for the reactors co-digesting mixtures with 10% WW, 25% WW and 40% WW, respectively. Co-digestion with 40% WW improved the removal efficiencies up to 52% (TCOD), 132% (SCOD) and 61% (VSS) compared to SM alone. These results suggest that methane can be produced very efficiently by the co-digestion of swine manure with winery wastewater.     

Mesophilic batch anaerobic co-digestion of pulp and paper sludge and monosodium glutamate waste liquor for methane production in a bench-scale digester

This paper presented results from anaerobic co-digestion of pulp and paper sludge (PPS) and monosodium glutamate waste liquor (MGWL). A bench-scale anaerobic digester, 10 L in volume was developed, to operate under mesophilic (37 ± 2 °C) batch condition. Under versatile and reliable anaerobic conduct, high efficiency for bioconversion of PPS and MGWL were obtained in the system. The accumulative methane yield attained to 200 mL g⁻¹ VS_added and the peak value of methane daily production was 0.5 m³/(m³ d). No inhibitions of volatile fatty acids (VFAs) and ammonia on anaerobic co-digestion were found. pH 6.0-8.0 and alkalinity 1000-4000 mg CaCO₃/L were got without adjustment. This work showed that there was a good potential to the use of PPS and MGWL to anaerobic co-digestion for methane production.     

Influence of substrate concentration and moisture content on the specific methanogenic activity of dry mesophilic municipal solid waste digestate spiked with propionate

The objective of this study was to evaluate the influence of substrate concentration and moisture content on the specific methanogenic activity (SMA) of a fresh dry mesophilic digestate from a municipal solid waste digester plant. For this purpose, SMA tests were performed under mesophilic conditions into glass bottles of 500 mL volume used as batch reactors, during a period of 20-25 days. Propionate was used as substrate at concentrations ranging from 1 to 10 gCOD/kg. Four moisture contents were studied: 65%, 75%, 80% and 82%. Experimental results showed that propionate concentration and moisture content strongly influenced the SMA. The highest SMA was observed at a substrate concentration of 10 gCOD/kg (11.3 mgCOD gVS⁻¹ d⁻¹ for the second dose of propionate) and at a moisture content of 82% (7.8 mgCOD gVS⁻¹ d⁻¹ for the second dose of propionate, at a concentration of 5 gCOD/kg). SMA was found to decrease linearly when decreasing the moisture content.     

Feasibility of biogas production from anaerobic co-digestion of herbal-extraction residues with swine manure

The objective of this work was to examine the feasibility of biogas production from the anaerobic co-digestion of herbal-extraction residues with swine manure. Batch and semi-continuous experiments were carried out under mesophilic anaerobic conditions. Batch experiments revealed that the highest specific biogas yield was 294 mL CH₄ g⁻¹ volatile solids added, obtained at 50% of herbal-extraction residues and 3.50 g volatile solids g⁻¹ mixed liquor suspended solids. Specific methane yield from swine manure alone was 207 mL CH₄ g⁻¹ volatile solid added d⁻¹ at 3.50 g volatile solids g⁻¹ mixed liquor suspended solids. Furthermore, specific methane yields were 162, 180 and 220 mL CH₄ g⁻¹ volatile solids added d⁻¹ for the reactors co-digesting mixtures with 10%, 25% and 50% herbal-extraction residues, respectively. These results suggested that biogas production could be enhanced efficiently by the anaerobic co-digestion of herbal-extraction residues with swine manure.     

The effect of electrodialytic treatment and Na2H2EDTA addition on methanogenic activity of copper-amended anaerobic granular sludge: treatment costs and energy consumption

The effect of electrodialytic treatment in terms of a current density, pH and Na₂H₂EDTA addition on the methanogenic activity of copper-amended anaerobic granular sludge taken from the UASB reactor from paper mill was evaluated. Moreover, the specific energy consumption and simplified operational and treatment costs were calculated. Addition of Na₂H₂EDTA (at pH 7.7) to copper-amended sludge resulted in the highest microbial activity (62 mg CH₄-COD g VSS⁻¹ day⁻¹) suggesting that Na₂H₂EDTA decreased the toxic effects of copper on the methanogenic activity of the anaerobic granular sludge. The highest methane production (159 %) was also observed upon Na₂H₂EDTA addition and simultaneous electricity application (pH 7.7). The energy consumption during the treatment was 560, 840, 1400 and 1680 kW h m⁻³ at current densities of 0.23, 0.34, 0.57 and 0.69 mA cm⁻², respectively. This corresponded to a treatment costs in terms of electricity expenditure from 39.2 to 117.6 € per cubic meter of sludge.     

The role of phase separation and feed cycle length in leach beds coupled to methanogenic reactors for digestion of a solid substrate (Part 2): Hydrolysis, acidification and methanogenesis in a two-phase system

The effect of phase separation and batch duration on the trophic stages of anaerobic digestion was assessed for the first time in leach beds coupled to methanogenic reactors digesting maize (Zea mays). The system was operated for consecutive batches of 7, 14 and 28 days for ∼120 days. Hydrolysis rate was higher the shorter the batch, reaching 8.5 gTS_destroyed d⁻¹ in the 7-day system. Phase separation did not affect acidification but methanogenesis was enhanced in the short feed cycle leach beds. Phase separation was inefficient on the 7-day system, where ∼89% of methane was produced in the leach bed. Methane production rate increased with shortening the feed cycle, reaching 3.523 l d⁻¹ average in the 7-day system. Low strength leachate from the leach beds decreased methanogenic activity of methanogenic reactors’ sludges. Enumeration of cellulolytic and methanogenic microorganisms indicated a constant inoculation of leach beds and methanogenic reactors through leachate recirculation.     

Effect of seed sludge and operation conditions on performance and archaeal community structure of low-temperature anaerobic solvent-degrading bioreactors

Two laboratory-scale expanded granular sludge bed (EGSB) anaerobic bioreactors (R1 and R2) were inoculated with biomass from different mesophilic (37 °C) treatment plants, and used for the treatment of an organic solvent-based wastewater at 9–14 °C at applied organic loading rates (OLRs) of 1.2–3.6 kg chemical oxygen demand (COD) m⁻³ d⁻¹. Replicated treatment performance was observed at 10–14 °C, which suggested the feasibility of the process at pilot-scale. Stable and efficient COD removal, along with high methane productivity, was demonstrated at 9 °C at an applied OLR of 2.4 kg COD m⁻³ d⁻¹. Clonal libraries and fluorescence in situ hybridization (FISH) indicated that the seed sludges were dominated (>60%) by acetoclastic Methanosaeta-like organisms. Specific methanogenic activity (SMA) profiles indicated shifts in the physiological profiles of R1 and R2 biomass, including the development of psychrotolerant methanogenic activity. Acetoclastic methanogenesis represented the primary route of methane production in R1 and R2, which is in contrast with several previous reports from low-temperature bioreactor trials. A reduction in the abundance of Methanosaeta-like clones (R2), along with the detection of hydrogenotrophic methanogenic species, coincided with altered granule (sludge) morphology and the development of hydrogenotrophic SMA after prolonged operation at 9 °C.     

Anaerobic co-digestion of sewage sludge and grease trap: Assessment of enzyme addition

Anaerobic co-digestion of grease trap and sewage sludge from a wastewater treatment plant is evaluated. Enzyme-lipase application, both addition and dosage, are evaluated by fitting the methane production of biochemical potential tests with the first order model. The enzyme addition effect, at 2, 5 and 10% of grease trap (%GT VS_FED^?1) and the enzymes doses, between 0.25 and 1.67% (v/v), without and with grease trap presence were studied. Grease trap addition showed a negative effect on the waste biodegradability, which was completely overcome by the addition of lipase. Enzyme addition improved notably the methane production for all grease trap fractions studied. In regards to the dosage, the best result was achieved between 0.33 and 0.83% (v/v) of enzyme. The co-digestion of sewage sludge and grease trap may be a feasible process by using lipases due to the saving in operational costs and the increase in the biogas production     

Anaerobic co-digestion of food waste and piggery wastewater: focusing on the role of trace elements

The objective of this study was to evaluate the feasibility of anaerobic co-digestion of food waste and piggery wastewater, and to identify the key factors governing the co-digestion performance. The analytical results indicated that the food waste contained higher energy potential and lower concentrations of trace elements than the piggery wastewater. Anaerobic co-digestion showed a significantly improved biogas productivity and process stability. The results of co-digestion of the food waste with the different fractions of the piggery wastewater suggested that trace element might be the reason for enhancing the co-digestion performance. By supplementing the trace elements, a long-term anaerobic digestion of the food waste only resulted in a high methane yield of 0.396 m³/kg VS_added and 75.6% of VS destruction with no significant volatile fatty acid accumulation. These results suggested that the typical Korean food waste was deficient with some trace elements required for anaerobic digestion.     

A comparison study on the high-rate co-digestion of sewage sludge and food waste using a temperature-phased anaerobic sequencing batch reactor system

Assessing contemporary anaerobic biotechnologies requires proofs on reliable performance in terms of renewable bioenergy recovery such as methane (CH₄) production rate, CH₄ yield while removing volatile solid (VS) effectively. This study, therefore, aims to evaluate temperature-phased anaerobic sequencing batch reactor (TPASBR) system that is a promising approach for the sustainable treatment of organic fraction of municipal solid wastes (OFMSW). TPASBR system is compared with a conventional system, mesophilic two-stage anaerobic sequencing batch reactor system, which differs in operating temperature of 1st-stage. Results demonstrate that TPASBR system can obtain 44% VS removal from co-substrate of sewage sludge and food waste while producing 1.2 m³CH₄/m³_system/d (0.2 m³CH₄/kgVS_added) at organic loading rate of 6.1 gVS/L/d through the synergy of sequencing-batch operation, co-digestion, and temperature-phasing. Consequently, the rapid and balanced anaerobic metabolism at thermophilic stage makes TPASBR system to afford high organic loading rate showing superior performance on OFMSW stabilization.     

Optimising the biogas production from leather fleshing waste by co-digestion with MSW

Waste from the leather industry, known as limed leather fleshing (LF), has a low C:N (3.2) and an alkaline pH of 11.4. This is a major disadvantage for anaerobic digestion due to ammonia toxicity for methanogenesis. This study describes co-digestion of LF with biodegradable fraction of municipal solids waste optimised over a range of C:N and pH to minimise ammonia and to maximise biogas yield. The optimum conditions were found with a blend that provided C:N of 15 and pH of 6.5 and the cumulative biogas yield increased from 560 mL using LF fraction alone, to 6518 mL with optimum blend. At higher pH of 8.5, unionised ammonia was high (2473 mg L⁻¹) coincided with poor biogas yield (47 mL d⁻¹) that confirms ammonia toxicity. By contrast at a pH of 4.5 the ammonia was minimum (510 mg L⁻¹), but high VFA (26,803 mg L⁻¹) inhibited the methanogens. Biomass activity measured using ATP correlated well with biogas yield as reported previously.     

Degradation pathway, toxicity and kinetics of 2,4,6-trichlorophenol with different co-substrate by aerobic granules in SBR

The present study deals with cultivation of 2,4,6-trichlorophenol (TCP) degrading aerobic granules in two SBR systems based on glucose and acetate as co-substrate. Biodegradation of TCP containing wastewater starting from 10 to 360 mg L⁻¹ with more than 90% efficiency was achieved. Sludge volume index decreases as the operation proceeds to stabilize at 35 and 30 mL g⁻¹ while MLVSS increases from 4 to 6.5 and 6.2 g L⁻¹ for R1 (with glucose as co-substrate) and R2 (with sodium acetate as co-substrate), respectively. FTIR, GC and GC/MS spectral studies shows that the biodegradation occurred via chlorocatechol pathway and the cleavage may be at ortho-position. Haldane model for inhibitory substrate was applied to the system and it was observed that glucose fed granules have a high specific degradation rate and efficiency than acetate fed granules. Genotoxicity studies shows that effluent coming from SBRs was non-toxic.     

Methane dynamics across wetland plant species

We examined patterns of methane flux, plant biomass, and microbial methanogenic populations in nine wetland plant species. Methane dynamics varied across plant functional groupings, with patterns distinctive among forbs, clonal dominants, and tussock/clump-forming graminoids. Carex stricta and Scirpus atrovirens showed the highest emissions (31.7 and 20.6 mg CH₄-C m⁻² h⁻¹), followed by other tussock- or clump-forming graminoids that averaged 11.0 mg CH₄-C m⁻² h⁻¹ (Scirpus cyperinus, Glyceria striata, and Juncus effusus). The clonal dominants (Phalaris arundinacea and Typha angustifolia) had the lowest methane emissions (1.3 and 3.4 mg CH₄-C m⁻² h⁻¹) of all seven graminoid species, and the forbs (Mimulus ringens and Verbena hastata) emitted no detectable methane flux from their leaves. In general, methane emissions decreased with greater plant biomass. Terminal restriction fragment analysis (T-RFLP) of archaeal 16S rRNA revealed that the structure of the soil methanogen communities isolated from plant rhizospheres had no effect on methane flux. The relative proportions of the different terminal fragments were not correlated with either methane emissions or plant biomass. Methanogen populations from J. effusus soils were dominated by acetoclastic archaea of the Methanosarcinaceae and Methanosaetaceae families, while all other graminoid soils were colonized primarily by hydrogenotrophic archaea of the Methanobacteriaceae family. The results indicate that plant functional groups and plant biomass are useful in predicting methane flux differences across plant species, while soil methanogen community structure showed no distinguishable patterns.     

Two-stage anaerobic digestion of biodegradable municipal solid waste using a rotating drum mesh filter bioreactor and anaerobic filter

A rotating drum mesh filter bioreactor (RDMFBR) with a 100 μm mesh coupled to an anaerobic filter was used for the anaerobic digestion of biodegradable municipal solid waste (BMW). Duplicate systems were operated for 72 days at an organic loading rate (OLR) of 7.5 gVS l⁻¹ d⁻¹. Early in the experiment most of the methane was produced in the 2nd stage. This situation gradually reversed as methanogenesis became established in the 1st stage digester, which eventually produced 86–87% of the total system methane. The total methane production was 0.2 l g⁻¹ VS_added with 60–62% volatile solids destruction. No fouling was experienced during the experiment at a transmembrane flux rate of 3.5 l m⁻² h⁻¹. The system proved to be robust and stably adjusted to a shock loading increase to 15 gVS l⁻¹ d⁻¹, although this reduced the overall methane production to 0.15 l g⁻¹ VS_added.     

Overyielding and the role of complementary use of nitrogen in wetland plant communities

Biodiversity and ecosystem functioning experiments have demonstrated that plant biomass of species grown in mixtures is often greater than plant biomass of monocultures (i.e., mixtures over yield). While we understand that plant species utilize resources differently, how a combination of species increases resource use and productivity is not well known, especially in wetland ecosystems. Here, we used a mesocosm experiment to explore diversity effects on plant biomass production and to examine the role of N partitioning as a mechanism for overyielding in wetland ecosystems. Plant functional groups (FGs) represented the unit of diversity, and we included five levels of diversity (0-4 FGs). To test for N partitioning, we used a stable isotope technique to determine niche breadth and proportion similarity of inorganic N use (NO₃⁻ and NH₄⁺) for individual FGs as well as mixtures containing 3 and 4 FGs. We found that total plant biomass increased in the first season from an average of 290 ± 60 SE g ash-free dry mass (AFDM) m⁻² at the 1 FG level to 490 ± 70 g AFDM m⁻² at the 4 FG level and in the second season from an average of 560 ± 80 g AFDM m⁻² at the 1 FG level to 1000 ± 90 g AFDM m⁻² at the 4 FG level indicating overyielding. Plant species comprising the majority of mesocosm biomass demonstrated preferential uptake of ¹⁵NO₃⁻, while species with relatively less biomass (e.g., Acorus calamus and Carex crinita) preferred ¹⁵NH₄⁺. Concentrations of ¹⁵N in biomass increased with FG richness, but only in the ¹⁵NO₃⁻ treatment. Niche breadth did not vary among levels of FG richness. We observed a greater niche overlap with an increase of FGs, with species taking up greater proportion of ¹⁵NO₃⁻ than ¹⁵NH₄⁺. Our results indicate that plant overyielding in wetland mesocosms is not the result of niche partitioning of N chemical forms, but is associated with greater uptake of NO₃.     

Optimization of growth media for obtaining high-cell density cultures of halophilic archaea (family Halobacteriaceae) by response surface methodology

Optimization of media components for the growth and biomass production of Halobacterium salinarum VKMM 013 was carried out using response surface methodology. A second order quadratic model was estimated and media components were determined based on quadratic regression equation generated by model. These were 6.35 g L⁻¹ of KCl, 9.70 g L⁻¹ of MgSO₄, 13.38 g L⁻¹ of gelatin and 12.00 g L⁻¹ of soluble starch in nutrient broth supplemented with artificial seawater with 20% (w/v) of NaCl. In these optimal conditions, the obtained cell concentration of 0.746 g L⁻¹ dry weight was in agreement with the predicted cell concentration. The optimized media significantly shortened the time required for cell culture to reach the stationary phase while providing a nearly 2.4-fold increase in biomass production. Furthermore, in cell cultures of three other halophilic archaea the use of optimized media enhanced growth rate and provided high-cell density.     

Reduction of ammonia and volatile organic compounds from food waste-composting facilities using a novel anti-clogging biofilter system

The performance of a pilot-scale anti-clogging biofilter system (ABS) was evaluated over a period of 125 days for treating ammonia and volatile organic compounds emitted from a full-scale food waste-composting facility. The pilot-scale ABS was designed to intermittently and automatically remove excess biomass using an agitator. When the pressure drop in the polyurethane filter bed was increased to a set point (50 mm H₂O m⁻¹), due to excess biomass acclimation, the agitator automatically worked by the differential pressure switch, without biofilter shutdown. A high removal efficiency (97-99%) was stably maintained for the 125 days after an acclimation period of 1 week, even thought the inlet gas concentrations fluctuated from 0.16 to 0.55 g m⁻³. Due the intermittent automatic agitation of the filter bed, the biomass concentration and pressure drop in the biofilter were maintained within the ranges of 1.1-2.0 g-DCW g PU⁻¹ and below 50 mm H₂O m⁻¹, respectively.     

Responses of Gmelina arborea, a tropical deciduous tree species, to elevated atmospheric CO2: Growth, biomass productivity and carbon sequestration efficacy

The photosynthetic response of trees to rising CO₂ concentrations largely depends on source-sink relations, in addition to differences in responsiveness by species, genotype, and functional group. Previous studies on elevated CO₂ responses in trees have either doubled the gas concentration (>700 μmol mol⁻¹) or used single large addition of CO₂ (500-600 μmol mol⁻¹). In this study, Gmelina arborea, a fast growing tropical deciduous tree species, was selected to determine the photosynthetic efficiency, growth response and overall source-sink relations under near elevated atmospheric CO₂ concentration (460 μmol mol⁻¹). Net photosynthetic rate of Gmelina was ∼30% higher in plants grown in elevated CO₂ compared with ambient CO₂-grown plants. The elevated CO₂ concentration also had significant effect on photochemical and biochemical capacities evidenced by changes in F_V/F_M, ABS/CSm, ET₀/CSm and RuBPcase activity. The study also revealed that elevated CO₂ conditions significantly increased absolute growth rate, above ground biomass and carbon sequestration potential in Gmelina which sequestered ∼2100 g tree⁻¹ carbon after 120 days of treatment when compared to ambient CO₂-grown plants. Our data indicate that young Gmelina could accumulate significant biomass and escape acclimatory down-regulation of photosynthesis due to high source-sink capacity even with an increase of 100 μmol mol⁻¹ CO₂.     

Growth characteristics of Botryococcus braunii 765 under high CO2 concentration in photobioreactor

To understand the potential of cultivating Botryococcus braunii with flue gas (normally containing high CO₂) for biofuel production, growth characteristics of B. braunii 765 with 2-20% CO₂ aeration were investigated. The results showed that the strain could grow well without any obvious inhibition under all tested CO₂ concentrations with an aeration rate of 0.2 vvm, even without any culture pH adjustment (ranged from 6.0 to 8.0). The maximum biomass among all conditions was 2.31 g L⁻¹ on 25th day at 20% CO₂. Hydrocarbon content and algal colony size increased with the increase of CO₂ concentration. A negative correlation between algal biomass and culture total phosphorus was observed (from −0.828 to −0.911, P < 0.01). Additionally, 2% sodium hypochlorite solution was used for photobioreactor sterilization to cultivate B. braunii.