Regulation of fermentative capacity and levels of glycolytic enzymes in chemostat cultures of Saccharomyces cerevisiae

Regulation of fermentative capacity was studied in chemostat cultures of two Saccharomyces cerevisiae strains: the laboratory strain CEN.PK113-7D and the industrial bakers’ yeast strain DS28911. The two strains were cultivated at a fixed dilution rate of 0.10 h⁻¹ under various nutrient limitation regimes: aerobic and anaerobic glucose limitation, aerobic and anaerobic nitrogen limitation on glucose, and aerobic ethanol limitation. Also the effect of specific growth rate on fermentative capacity was compared in glucose-limited, aerobic cultures grown at dilution rates between 0.05 h⁻¹ and 0.40 h⁻¹. Biomass yields and metabolite formation patterns were identical for the two strains under all cultivation conditions tested. However, the way in which environmental conditions affected fermentative capacity (assayed off-line as ethanol production rate under anaerobic conditions) differed for the two strains. A different regulation of fermentative capacity in the two strains was also evident from the levels of the glycolytic enzymes, as determined by in vitro enzyme assays. With the exception of phosphofructokinase and pyruvate decarboxylase in the industrial strain, no clear-cut correlation between the activities of glycolytic enzymes and the fermentative capacity was found. These results emphasise the need for controlled cultivation conditions in studies on metabolic regulation in S. cerevisiae and demonstrate that conclusions from physiological studies cannot necessarily be extrapolated from one S. cerevisiae strain to the other.     

The response of the yeast Saccharomyces cerevisiae to sudden vs. gradual changes in environmental stress monitored by expression of the stress response protein Hsp12p

The response of the yeast Saccharomyces cerevisiae to sudden vs. gradual changes in different environmental stress conditions during both respiratory growth and aerobic fermentative growth in the presence of excess glucose was investigated by monitoring the level and rate of expression of the stress response protein Hsp12p using the fluorescent fusion construct Hsp12p-Gfp2p. The initial expression level and the rate of Hsp12p synthesis was significantly greater under glucose-limited conditions in the chemostat ( D <0.14 h⁻¹) compared with when excess glucose was present in the auxostat. Decreasing the dilution rate and the glucose concentration further in the A-stat resulted in increased Hsp12p expression, which was more marked when a rapid rather than a gradual change was affected. Common stress factors such as NaCl, ethanol and elevated temperature caused stress responses in both D-stat and auxo-accelerostat culture. The magnitude of the stress response depended on the stress factor, cultivation conditions as well as the rate of change of the stress factor. The rate of Hsp12p synthesis increased due to all applied stresses, with the observed increase between 2 and 20 times lower when the stress was applied gradually rather than rapidly. The results suggested that the Hsp12p expression rate is a good indicator of applied stress in S. cerevisiae .     

Disruption of hexokinase II (HXK2) partly relieves glucose repression to enhance production of human kringle fragment in gratuitous recombinant Saccharomyces cerevisiae

The GAL1 gene encoding galactokinase was disrupted in a recombinant Saccharomyces cerevisiae strain in which production of LK8 protein, a kringle fragment of human apolipoprotein, is under the control of GAL1 promoter. Null mutation of the HXK2 gene was introduced further in the gal1Delta strain to relieve glucose repression. A pattern for LK8 expression was compared for the two recombinant S. cerevisiae systems in continuous and fed-batch cultivations. A critical dilution rate in continuous cultivation that repressed LK8 expression was significantly higher for the gal1Deltahxk2Delta strain than that for the gal1Delta strain to sustain the LK8 production even at high glucose consumption rate. Expressed LK8 for the gal1Delta strain was not detectable when the dilution rate exceeded 0.05 h(-1). Maximum LK8 concentration of 57 mgl(-1) was obtained in glucose-limited fed-batch cultivation of the gal1Deltahxk2Delta strain, corresponding to a 13.8-fold enhancement compared with the gal1Delta strain grown under the same conditions.     

Cloning of a second gene encoding 6-phosphofructo-2-kinase in yeast, and characterization of mutant strains without fructose-2,6-bisphosphate

We have identified a new gene, PFK27, that encodes a second inducible 6-phosphofructo-2-kinase in the yeast Saccharomyces cerevisiae. Sequencing shows an open reading frame of 397 amino acids and 45.3 kDa. Amino acid sequence comparisons with other bifunctional 6-phosphofructo-2-kinase/fructose-2,6-bisphosphatase isoenzymes of various organisms revealed similarities only to the kinase domains. Expression of PFK27 was induced severalfold by glucose and sucrose, but not by galactose or maltose, suggesting that sugar transport might be involved in triggering the induction signal. We have constructed a mutant strain devoid of any fructose-2,6-bisphosphate. The mutant strain grew well on several kinds and concentrations of carbon sources. The levels of hexose phosphates in the cells were increased, but flux rates for glucose utilization and ethanol production were similar to the wild-type strain. However, after the transfer of the mutant cells from respiratory to fermentative growth conditions, growth, glucose consumption and ethanol production were delayed in a transition phase. Our results show that fructose-2,6-bisphosphate is an important effector in vivo of the 6-phosphofructo-1-kinase/fructose-1,6-bisphospha-tase enzyme pair, and is involved in the initiation of glycolysis during the transition to a fermentative mode of metabolism. Nevertheless, it can be effectively replaced by other effectors and regulatory mechanisms during growth on glucose.     

Overexpression of Mal61p in Saccharomyces cerevisiae and characterization of maltose transport in artificial membranes.

For maltose uptake in Saccharomyces cerevisiae, multiple kinetic forms of transport as well as inhibition of transport by high concentrations of maltose at the trans side of the plasma membrane have been described. Most of these studies were hampered by a lack of genetically well-defined mutants and/or the lack of an artificial membrane system to study translocation catalysis in vitro. A genetically well-defined S. cerevisiae strain lacking the various MAL loci was constructed by gene disruption. Expression of the maltose transport protein (Mal61p) was studied by using various plasmid vectors that differed in copy number and/or type of promoter. The expression levels were quantitated by immunoblotting with antibodies generated against the N-terminal half of Mal61p. The levels of expression as well as the initial uptake rates were increased 20-fold compared with those in a yeast strain carrying only one chromosomal MAL locus. Similar results were obtained when the transport activities were compared in hybrid membranes of the corresponding strains. To generate a proton motive force, isolated membranes were fused with liposomes containing cytochrome c oxidase as a proton pump. Fusion was achieved by a cycle of freeze-thawing, after which the hybrid membranes were passed through a filter with a defined pore size to obtain unilamellar membrane vesicles. Proton motive force-driven maltose uptake, maltose efflux down the concentration gradient, and equilibrium exchange of maltose in the hybrid membranes vesicles have been analyzed. The data indicate that maltose transport by the maltose transporter is kinetically monophasic and fully reversible under all conditions tested.     

Catabolite repression mutants of Saccharomyces cerevisiae show altered fermentative metabolism as well as cell cycle behavior in glucose-limited chemostat cultures

In glucose-limited continuous cultures, a Crabtree positive yeast such as Saccharomyces cerevisiae displays respiratory metabolism at low dilution rates (D) and respiro-fermentative metabolism at high D. We have studied the onset of ethanol production and cell cycle behavior in glucose-limited chemostat cultures of the wild type S. cerevisiae strain CEN.PK122 (WT) and isogenic mutants, snf1 (cat1) and snf4 (cat3) defective in proteins involved in catabolite derepression and the mutant in glucose repression mig1 (cat4). The triggering of fermentative metabolism was dependent upon catabolite repression properties of yeast and was coincident with a significant decrease of G1 length. WT cells of the strain CEN.PK122 displayed respiratory metabolism up to a D of 0.2 h-1 and exhibited longer G1 lengths than the snf1 and snf4 mutants that started fermenting after a D of 0.1 and 0.15 h-1, respectively. The catabolite derepression mutant snf4 showed a significant decrease in the duration of G1 with respect to the WT. An increase of 300% to 400% in the expression of CDC28 (CDC28-lacZ) with a noticeable shortening in G1 to values lower than approximately 150 min, was detected in the transformed wild type CEN.SC13-9B in glucose-limited chemostat cultures. The expression of CDC28-lacZ was analyzed in the wild type and isogenic mutant strains growing at maximal rate on glucose or in the presence of ethanol or glycerol. Two- to three-fold lower expression of the CDC28-lacZ fusion gene was detected in the snf1 or snf4 disruptants with respect to the WT and mig1 strains in the presence of all carbon sources. This effect was further shown to be growth rate-dependent exhibiting apparently, a threshold effect in the expression of the fusion gene with respect to the length of G1, similar to that shown in chemostat cultures. At the onset of fermentation, the control of the glycolytic flux was highly distributed between the uptake, hexokinase, and phosphofructokinase steps. Particularly interesting was the fact that the snf1 mutant exhibited the lowest fluxes of ethanol production, the highest of respiration and correspondingly, the branch to the tricarboxylic acid cycle was significantly rate-controling of glycolysis.     

产氢菌Enterobacter sp.和Clostridium sp.的分离鉴定及产氢特性

在高温水体中分离得到2株具有较高产氢活性的微生物菌株Z-16和C-32。根据两菌株的16SrDNA序列分析,初步鉴定菌株Z-16为Enterobactersp.,菌株C-32为Clostridiumsp.。研究了起始pH值、反应温度、碳源等对菌株放氢活性的影响。菌株Z-16的最适产氢条件为:反应系统起始pH7·0,反应温度35℃,以蔗糖为产氢底物。在最适条件下,菌株Z-16的氢转化率为2·68molH2/mol蔗糖。菌株C-32的最适产氢条件为:反应系统起始pH8·0,反应温度35℃,以麦芽糖为产氢底物。在最适条件下,菌株C-32的氢转化率为2·71molH2/mol麦芽糖。以葡萄糖为碳源时,菌株Z-16和菌株C-32的氢转化率分别为2·35和2·48molH2/mol葡萄糖。     

Regulation of lactate dehydrogenase and change of fermentation products in streptococci.

Streptococcus mutans JC 2 produced mainly lactate as a fermentation product when grown in nitrogen-limited continuous culture in the presence of an excess of glucose and produced formate, acetate, and ethanol, but no lactate, under glucose-limited conditions. The levels of lactate dehydrogenase (LDH) in these cultures were of the same order of magnitude, and the activity of LDH was completely dependent on fructose-1,6-diphosphate (FDP). The intracellular level of FDP was high and the level of phosphoenolpyruvate (PEP) was low under the glucose-excess conditions. In the glucose-limited cultures, all glycolytic intermediates studied, except PEP, were low. S. mutans FIL, which had an FDP-independent LDH and similar levels of glycolytic intermediates as S. mutans JC2, produced mainly lactate under glucose-excess or under glucose-limited conditions. LDH of Streptococcus bovis ATCC 9809 was dependent on FDP for activity at a low concentration of pyruvate but had a significant activity without FDP at a high concentration of pyruvate. This strain also produced mainly lactate both under glucose-excess and glucose-limited conditions. The levels and characteristics of these LDHs were not changed by the culture conditions. These results indicate that changes in the intracellular level of FDP regulate LDH activity, which in turn influences the type of fermentation products produced by streptococci. PEP, adenosine 5'-monophosphate, adenosine 5'-diphosphate, and inorganic phosphate significantly inhibited LDH activity from S. mutans JC 2 and may also participate in the regulation of LDH activity in other streptococci.     

Improved production of viable cells of the salt-tolerant yeast Zygosaccharomyces rouxii by continuous culture

Summary A continuous culture system of the salt-tolerant yeast Zygosaccharomyces rouxii (soy yeast) was investigated in order to obtain high production efficiency of viable cells. The optimum pH and C/N ratio of the feed medium for cell production were about 5.0 and 16–20, respectively. About a fivefold increase in viable cell number and cell productivity (viable cell number per litre per hour) were obtained in glucose-limited culture at a dilution rate (D) of 0.06 h^–1 as compared with batch culture. However, the fermentative activity of the cells from glucose-limited culture was significantly lower than those from batch and dissolved-oxygen (DO)-limited cultures, and the former cells showed lower specific activity of glycolytic enzymes. On the other hand, at the boundary conditions between glucose and DO limitation almost the same cell productivity and higher fermentative activity of the cell were obtained as compared with glucose-limited conditions. The cultivation continued for about 60 days without any problems even if the D was altered. It was found that the continuous cultivation method was suitable for industrial production of viable cells of soy yeasts. Offprint requests to: T. Hamada     

Steady-state and transient-state analysis of growth and metabolite production in a Saccharomyces cerevisiae strain with reduced pyruvate-decarboxylase activity

Pyruvate decarboxylase is a key enzyme in the production of low-molecular-weight byproducts (ethanol, acetate) in biomass-directed applications of Saccharomyces cerevisiae. To investigate whether decreased expression levels of pyruvate decarboxylase can reduce byproduct formation, the PDC2 gene, which encodes a positive regulator of pyruvate-decarboxylase synthesis, was inactivated in the prototrophic strain S. cerevisiae CEN. PK113-7D. This caused a 3-4-fold reduction of pyruvate-decarboxylase activity in glucose-limited, aerobic chemostat cultures grown at a dilution rate of 0.10 h(-1). Upon exposure of such cultures to a 50 mM glucose pulse, ethanol and acetate were the major byproducts formed by the wild type. In the pdc2Delta strain, formation of ethanol and acetate was reduced by 60-70%. In contrast to the wild type, the pdc2Delta strain produced substantial amounts of pyruvate after a glucose pulse. Nevertheless, its overall byproduct formation was ca. 50% lower. The specific rate of glucose consumption after a glucose pulse to pdc2Delta cultures was about 40% lower than in wild-type cultures. This suggests that, at reduced pyruvate-decarboxylase activities, glycolytic flux is controlled by NADH reoxidation. In aerobic, glucose-limited chemostat cultures, the wild type exhibited a mixed respiro-fermentative metabolism at dilution rates above 0.30 h(-1). Below this dilution rate, sugar metabolism was respiratory. At dilution rates up to 0.20 h(-1), growth of the pdc2Delta strain was respiratory and biomass yields were similar to those of wild-type cultures. Above this dilution rate, washout occurred. The low micro(max) of the pdc2Delta strain in glucose-limited chemostat cultures indicates that occurrence of respiro-fermentative metabolism in wild-type cultures is not solely caused by competition of respiration and fermentation for pyruvate. Furthermore, it implies that inactivation of PDC2 is not a viable option for reducing byproduct formation in industrial fermentations.