氯苯降解菌的筛选及降解条件研究

从活性污泥中筛选到一株具有降解氯苯功能的菌株JH02,依据菌落特征形态和生理生化反应鉴定该菌株属于链球菌属(Streptococcus)。分别考察培养温度、培养时间、氯苯浓度、pH值、菌悬液接种量及摇床转速等因素对菌株降解性能的影响。确定菌株StreptococcusJH02的对氯苯的最适降解条件为:培养温度为37℃,培养时间24 h,菌悬液接种量体积分数为4%,pH8.0,摇床转速140 r.min-1,此条件下氯苯的降解率可达94.7%。     

Reductive dechlorination of hexachlorocyclohexane (HCH) isomers in soil under anaerobic conditions

The biological anaerobic reductive dechlorination of beta-hexachlorocyclohexane under methanogenic conditions was tested in a number of contaminated soil samples from two locations in the Netherlands. Soils from a heavily polluted location showed rapid dechlorination of beta-hexachlorocyclohexane to benzene and chlorobenzene with lactate as electron donor. Soils from an adjacent slightly polluted location did not show substantial dechlorination of beta-hexachlorocyclohexane within 4 months. A heavily polluted sample was selected to optimise the dechlorination. All tested hexachlorocyclohexane isomers (alpha-, beta-, gamma-, and delta-), either added separately or simultaneously, were dechlorinated in this soil sample. The most rapid dechlorination was observed at a temperature of 30 degrees C. Dechlorination of beta-hexachlorocyclohexane was observed with acetate, propionate, lactate, methanol, H2, yeast extract and landfill leachate as electron donors. In a soil percolation column, packed with a selected heavily polluted soil sample, the presence of 10 mM sulphate in the influent led to simultaneous dechlorination of beta-hexachlorocyclohexane and sulphate reduction. When the column was fed with 10 mM nitrate instead of sulphate, dechlorination ceased immediately. After omitting nitrate from the influent, dechlorination activity recovered in about 1 month. Also in a separate column, the addition of nitrate from the start of the experiment did not result in dechlorination of beta-HCH. The significance of these experiments for in situ bioremediation of polluted soils is discussed.     

Expression,purification, and refolding of a recombinant human bone morphogenetic protein 2 in vitro

In this work, the recombinant human bone morphogenetic protein 2 (rhBMP-2) gene was cloned from MG-63 cells by RT-PCR, and the protein was expressed in Escherichia coli expression system, purified by Ni–NTA column under denaturing conditions and refolded at 4 °C by urea gradient dialysis. We found that the protein refolding yield was increased with the increase of pH value from pH 6.0 to pH 9.0. The yield was 42% and 96% at pH 7.4 and pH 9.0, respectively, while that at pH 6.0 was only 3.4%. The cell culture results showed that the rhBMP-2 refolded at pH 7.4 urea gradient dialysis had higher biological activity for MG-63 cell proliferation and differentiation than that refolded at pH 9.0 since pH 7.4 is closer to the conditions in vivo leading to the formation of dimers through the interchain disulfide bond. Moreover, the biological activity for MG-63 was promoted with the increase of rhBMP-2 concentration in the cell culture medium. This work may be important for the in vitro production and biomedical application of rhBMP-2 protein.     

Microbial metabolism of haloaromatics: isolation and properties of a chlorobenzene-degrading bacterium.

A chlorobenzene-degrading bacterium was isolated by continuous enrichment from a mixture of soil and sewage samples. This organism, strain WR1306, was grown in a chemostat on a mineral medium with chlorobenzene being supplied through the vapor phase with a critical Dc value at a dilution rate of 0.55 h-1. Maximum growth rates in batch culture were accomplished at substrate concentrations of less than or equal to 0.5 mM in the culture medium. During growth on chlorobenzene, stoichiometric amounts of chloride were released. Respiration data and enzyme activities in cell extracts as well as the isolation of 3-chlorocatechol from the culture fluid are consistent with the degradation of chlorobenzene via 3-chloro-cis-1,2-dihydroxycyclohexa-3,5-diene, 3-chlorocatechol, 2-chloro-cis,cis-muconate, trans-4-carboxymethylenebut-2-en-4-olide, maleylacetate, and 3-oxoadipate.     

The formation of chlorobenzene and benzene by the reductive metabolism of lindane in rat liver microsomes

The major metabolite produced by incubating [14C]lindane with rat liver microsomes under anaerobic conditions was determined to be chlorobenzene, with lesser amounts of benzene also being formed. Using relatively high lindane concentrations (250 microM), four nonvolatile metabolites of lindane were also produced anaerobically, the predominant one being identified by mass spectrometry as tetrachlorocyclohexene (TCCH). TCCH, likewise, was reduced to chlorobenzene and benzene in microsomes under anaerobic conditions. Binding of [14C]lindane to microsomal protein occurred under aerobic as well as anaerobic incubation conditions; however, lindane protein binding was greatest in anaerobic incubations compared to those containing an atmosphere of air or 100% oxygen. Hemin reduced by dithionite also readily produced chlorobenzene and benzene from lindane. These results indicate that lindane interacts readily with heme and heme proteins, including cytochrome P-450, in the absence of oxygen to undergo multiple chloride eliminations forming chlorobenzene and benzene as end products.     

固相萃取-气相色谱法测定水和废水中四种氯苯类有机污染物

研究了用固相萃取技术结合氢火焰气相色谱法测定水和废水中四种氯苯类有机污染物。通过实验比较Sdex C18,Sep-Park Vac Silica,Bond Elut CARBON,Bond Elut SI和Bond Elut PLEXA五种SPE小柱对四种氯苯类的萃取效率,发现Dionex的Sdex C18柱有很好的回收率。系统研究了最佳萃取条件,甲醇洗脱体积为4.0 mL,且洗脱液不可通过氮吹浓缩;四种氯苯类化合物除氯苯外穿透体积都在1.0 L以上,而氯苯的穿透体积为300 mL,表明Sdex C18柱对二氯苯和三氯苯有很强的吸附性。在最佳萃取和测定条件下,方法线性范围为20.0~400μg/L,检出限为0.383~0.635μg/L,完全满足日常环境监测分析要求。     

一株虫草头孢菌深层培养条件的研究

采用摇瓶培养的方法,以菌丝体收率为指标,通过单因子实验和正交实验确定了虫草头孢菌最佳培养条件和最佳发酵培养基配方。在相同条件下,优化培养基比原培养基的菌丝体收率提高了31.75%。     

Rapid determination of nitrite by reversed-phase high-performance liquid chromatography with fluorescence detection

Measurement of nitrite and nitrate, the stable oxidation products of nitric oxide (NO), provides a useful tool to study NO synthesis in vivo and in cell cultures. A simple and rapid fluorometric HPLC method was developed for determination of nitrite through its derivatization with 2,3-diaminonaphthalene (DAN). Nitrite, in standard solution, cell culture medium, or biological samples, readily reacted with DAN under acidic conditions to yield the highly fluorescent 2,3-naphthotriazole (NAT). For analysis of nitrate, it was converted to nitrite by nitrate reductase, followed by the derivatization of nitrite with DAN to form NAT. NAT was separated on a 5-μm reversed-phase C₈ column (150×4.6 mm, I.D.) guarded by a 40-μm reversed-phase C₁₈ column (50×4.6 mm, I.D.), and eluted with 15 mM sodium phosphate buffer (pH 7.5) containing 50% methanol (flow-rate, 1.3 ml/min). Fluorescence was monitored with excitation at 375 nm and emission at 415 nm. Mean retention time for NAT was 4.4 min. The fluorescence intensity of NAT was linear with nitrite or nitrate concentrations ranging from 12.5 to 2000 nM in water, cell culture media, plasma and urine. The detection limit for nitrite and nitrate was 10 pmol/ml. Because NAT is well separated from DAN and other fluorescent components present in biological samples, our HPLC method offers the advantages of high sensitivity and specificity as well as easy automation for quantifying picomole levels of nitrite and nitrate in cell culture medium and biological samples.     

Improved production of phenylethanoid glycosides by Cistanche deserticola cells cultured in an internal loop airlift bioreactor with sifter riser

An internal loop airlift bioreactor with sifter riser (ILABSR) was composed of a bubble column and a draught-tube rolled with 40-mesh sifter that placed 5 cm above the bottom at the center of the column. A 2 L ILABSR was used for the suspension cultivation of Cistanche deserticola cells and its performance was compared with shake flask culture and a bubble column. Under the optimum culture conditions with the air flowrate of 0.075 m³/h and the inoculation size of 4.7%, about one-fifth cells were attached to the sifter draught-tube. PeG content in these cells was 16.3%, which was 104% higher than that of suspension cells. The production of phenylethanoid glycosides reached 0.85 g/L, which was 102 and 4% higher than those cultured in a 2 L bubble column and shake flasks respectively under their optimal culture conditions.     

Biodegradation, sorption, and transport of 2,4-dichlorophenoxyacetic acid in saturated and unsaturated soils.

The fate of an organic contaminant in soil depends on many factors, including sorption, biodegradation, and transport. The herbicide 2,4-dichlorophenoxyacetic acid (2,4-D) was used as a model compound to illustrate the impact of these interacting factors on the fate of an organic contaminant. Batch and column experiments performed with a sandy loam soil mixture under saturated and unsaturated conditions were used to determine the effects of sorption and biodegradation on the fate and transport of 2,4-D. Sorption of 2,4-D was found to have a slight but significant effect on transport of 2,4-D under saturated conditions (retardation factor, 1.8) and unsaturated conditions (retardation factor, 3.4). Biodegradation of 2,4-D was extensive under both batch and column conditions and was found to have a significant impact on 2,4-D transport in column experiments. In batch experiments, complete mineralization of 2,4-D (100 mg kg-1) occurred over a 4-day period following a 3-day lag phase under both saturated and unsaturated conditions. The biodegradation rate parameters calculated for batch experiments were found to be significantly different from those estimated for column experiments.     

Purification and subunit structure of hepatocyte growth factor from rat platelets

A hepatocyte growth factor (HGF) that stimulates DNA synthesis of adult rat hepatocytes in primary culture was purified as a homogeneous material from platelets of 1000 rats by a four-step procedure: stimulation of its release from platelets by thrombin, cation-exchanger fast protein liquid chromatography (FPLC) on a Mono S column, heparin-Sepharose CL-6B chromatography, and reverse-phase HPLC on a C4 column. The purified HGF stimulated DNA synthesis of adult rat hepatocytes in primary culture at 1 ng/ml and was maximally effective at 5 ng/ml, being about twice as potent as EGF at this concentration. HGF did not stimulate DNA synthesis of Swiss 3T3 cells. It was found to be a heat- and acid-labile protein that was inactivated by reduction with dithiothreitol. The purified HGF had a molecular mass of 82 kDa, as estimated by SDS-PAGE, and was found to be a heterodimer which dissociated into a large subunit of 69 kDa and a small one of 34 kDa by SDS-PAGE under reducing conditions. These biological and chemical properties showed that HGF was not identical with any known growth factors, including platelet-derived growth factor (PDGF).     

The Azure Dyes their Purification and Physicochemical properties. II. Purification of Azure B

A method is described for the purification of the dye azure B in quantities sufficient for biological staining experiments on a larger scale. The method is based on the use of column chromatography. Two columns are employed. In column A with silica gel as adsorbent the azure B fraction is isolated from a suitable substrate ('technical' azure B gained by a modification of Bernthsen's synthesis of methylene blue, or plychrome methylene blue) using an acetate-formate mixture as eluent. In column B, on an Amberlite polyineric adsorbent (XAD-2) the acetate-formate anions are exchanged for chloride. Regeneration of both columns is possible: KMnO₄, Na₂S₂O₄ and water are run through column A, 5% NaOH, methanol and water through column B. Purification of azure B on economic terms is thus attained. The opinion is expressed that this method is also applicable to the purification of other cationic dyes.     

The azure dyes: their purification and physicochemical properties. II. Purification of azure B.

A method is described for the purification of the dye azure B in quantities sufficient for biological staining experiments on a larger scale. The method is based on the use of column chromatography. Two columns are employed. In column A with silica gel as adsorbent the azure B fraction is isolated from a suitable substrate ('technical' azure B gained by a modification of Bernthsen's synthesis of methylene blue, or polychrome methylene blue) using an acetate-formate mixture as eluent. In column B, on an Amberlite polymeric adsorbent (XAD-2) the acetate-formate anions are exchanged in chloride. Regeneration of both columns is possible: KMnO4, Na2S2O4 and water are run through column A; 5% NaOH, methanol and water through column B. Purification of azure B on economic terms is thus attained. The opinion is expressed that this method is also applicable to the purification of other cationic dyes.     

一株凝结芽孢杆菌的分离筛选及产孢条件优化

【背景】凝结芽孢杆菌除了具有一般乳酸菌的益生功能外,还具较强的耐酸、耐胆盐、耐高温、易贮存等生物特性。【目的】从泡菜中筛选一株性能优良的凝结芽孢杆菌用于微生态制剂的制备,并对其产孢率进行优化,为该菌株的进一步工业化生产提供参考依据。【方法】采用选择性培养基通过特定的培养条件,筛选到一株抑菌效果良好的产酸芽孢杆菌,并对其进行特异性引物的鉴定、16S rRNA基因序列分析及生理生化实验。通过单因素及正交试验对菌株的产芽孢条件进行优化。【结果】筛选得到一株凝结芽孢杆菌BC01,该菌株对大肠杆菌(Escherichia coli CVCC 1527)、鼠伤寒沙门氏菌(Salmonella typhimurium CVCC 2228)、产气荚膜梭菌(Clostridium perfringens CVCC 46)、猪霍乱沙门氏菌(Salmonella choleraesuis CVCC 503)等均有较强的抑制作用;模拟胃液处理120 min存活率达到94%;0.3%的胆盐存活率达到84.3%。单因素及正交试验优化后的最适培养基配方:糖蜜10.0 g/L,酵母浸出粉20.0 g/L,NaCl 5.0 g/L,K_2HPO_4 5.0 g/L,MnSO_4 10.0 mg/L;最适培养条件:接种量4%,温度45°C,初始pH 7.0,转速200 r/min,培养时间36 h。在该优化条件下,其活菌数最高达到6.7×10~9 CFU/mL,产孢率达到89.2%。【结论】筛选得到一株可用于微生态制剂的菌株——凝结芽孢杆菌BC01,对其产孢率进行了优化,为工业化生产奠定了基础。     

Glyphosate degradation by immobilized bacteria: laboratory studies showing feasibility for glyphosate removal from waste water.

To evaluate immobilized bacteria technology for the removal of low levels of glyphosate (N-phosphonomethylglycine) from aqueous industrial effluents, microorganisms with glyphosate-degrading activity obtained from a fill and draw enrichment reactor inoculated with activated sludge were first exposed to glyphosate production wastes containing 500-2000 mg glyphosate/L. The microorganisms were then immobilized by adsorption onto a diatomaceous earth biocarrier contained in upflow Plexiglas columns. The columns were aerated, maintained at pH 7.0-8.0, incubated at 25 degrees C, supplemented with NH4NO3 (50 mg/L), and exposed to glyphosate process wastes pumped upflow through the biocarrier. Glyphosate degradation to aminomethylphosphonic acid was initially > 96% for 21 days of operation at flows yielding hydraulic residence times (HRTs) as short as 42 min. Higher flow rate studies showed > 98% removal of 50 mg glyphosate/L from the waste stream could be achieved at a HRT of 23 min. Glyphosate removal of > 99% at a 37-min HRT was achieved under similar conditions with a column inoculated with a pure culture of Pseudomonas sp. strain LBr, a bacterium known to have high glyphosate-degrading activity. After acid shocking (pH 2.8 for 18 h) of a column of immobilized bacteria, glyphosate-degrading activity was regained within 4 days without reinoculation. Although microbial growth and glyphosate degradation were not maintained under low organic nutrient conditions in the laboratory, the low levels of degradable carbon (45-94 mg/L) in the industrial effluent were sufficient to support prolonged glyphosate-degrading activity. The results demonstrated that immobilized bacteria technology is effective in removing low levels of glyphosate in high-volume liquid waste streams.     

Elucidation of metabolic pathways in glycogen-accumulating organisms with in vivo 13C nuclear magnetic resonance

Glycogen-accumulating organisms (GAOs) are found in enhanced biological phosphorus removal systems where they compete with polyphosphate-accumulating organisms for external carbon substrates. (13)C nuclear magnetic resonance ((13)C-NMR) was used to elucidate the metabolic pathways operating in an enriched GAO culture dominated by two known GAOs (81.2%). The experiments consisted of adding (13)C-acetate (labelled on position 1 or 2) to the culture under anaerobic conditions, and operating the culture through a cycle consisting of an anaerobic, an aerobic and a further anaerobic phase. The carbon transformations over the cycle were monitored using in vivo(13)C-NMR. The two-carbon moieties in hydroxybutyrate and hydroxyvalerate were derived from acetate, while the propionyl precursor of hydroxyvalerate was primarily derived from glycogen, with only a small fraction originating from acetate. Comparison of the labelling patterns in hydroxyvalerate at the end of the first and the second anaerobic periods in pulse experiments with 2-(13)C-acetate showed that the Entner-Doudoroff (ED) pathway was used for the breakdown of glycogen. This conclusion was further supported by the labelling pattern on glycogen observed in the pulse experiments with 1-(13)C-acetate, which can only be explained by the operation of ED with recycling of pyruvate and glyceraldehyde 3-phosphate via gluconeogenesis. The activity of the ED pathway for glycogen degradation by GAOs is demonstrated here for the first time. In addition, the decarboxylating part of the tricarboxylic acid cycle was confirmed to operate also under anaerobic conditions.     

An improved method for labeling carboxyatractyloside by [3H]KBH4

Carboxyatractyloside was labeled with [3H]KBH4 after oxidation of the primary alcohol of the glucose disulfate moiety by dicyclohexylcarbodiimide and P2O5 under anhydrous conditions in a dimethylsulfoxide medium. The 3H-labeled product was purified by DE 52 column chromatography followed by Cellulofine GCL 25 column chromatography. The final 3H-labeled product gave a single spot on a thin-layer chromatogram, and its Rf value was the same as that of authentic carboxyatractyloside. The biological activities (such as inhibition of state 3 respiration and binding to the adenine nucleotide carrier) were also comparable with those of authentic carboxyatractyloside.     

Integrated bioprocess for the production and isolation of urokinase from animal cell culture using supermacroporous cryogel matrices

An integrated cell cultivation and protein product separation process was developed using a new type of supermacroporous polyacrylamide gel, called cryogel (pAAm-cryogel) support matrix. Human fibrosarcoma HT1080 and human colon cancer HCT116 cell lines were used to secrete urokinase (an enzyme of immense therapeutic utility) into the culture medium. The secreted protein was isolated from the circulating medium using a chromatographic capture column. A pAAm cryogel support with covalently coupled gelatin (gelatin-pAAm cryogel) was used for the cultivation of anchorage dependent cells in the continuous cell culture mode in 5% carbon dioxide atmosphere. The cells were attached to the matrix within 4-6 h of inoculation and grew as a tissue sheet inside the cryogel matrix. Continuous urokinase secretion into the circulating medium was monitored as a parameter of growth and viability of cells inside the bioreactor. No morphological changes were observed in the cells eluted from the gelatin-cryogel support and re-cultured in T-flask. The gelatin-pAAm cryogel bioreactor was further connected to a pAAm cryogel column carrying Cu(II)-iminodiacetic acid (Cu(II)-IDA)-ligands (Cu(II)-IDA-pAAm cryogel), which had been optimized for the capture of urokinase from the conditioned medium of the cell lines. Thus an automated system was built, which integrated the features of a hollow fiber reactor with a chromatographic protein separation system. The urokinase was continuously captured by the Cu(II)-IDA-pAAm cryogel column and periodically recovered through elution cycles. The urokinase activity increased from 250 PU/mg in the culture fluid to 2,310 PU/mg after recovery from the capture column which gave about ninefold purification of the enzyme. Increased productivity was achieved by operating integrated bioreactor system continuously for 32 days under product inhibition free conditions during which no backpressure or culture contamination was observed. A total 152,600 Plough units of urokinase activity was recovered from 500 mL culture medium using 38 capture columns over a period of 32 days.     

Complete anaerobic mineralization of pentachlorophenol (PCP) under continuous flow conditions by sequential combination of PCP‐dechlorinating and phenol‐degrading consortia

Complete mineralization of 50 µM of pentachlorophenol (PCP) was achieved anaerobically under continuous flow conditions using two columns connected in series with a hydraulic retention time of 14.2 days, showing the highest reported mineralization rate yet of 3.5 µM day^?1. The first column, when injected with a reductive PCP dechlorinating consortium, dechlorinated PCP to mainly phenol and traces of 3‐chlorophenol (3‐CP) using lactate supplied continuously as an electron donor. The second column, with an anaerobic phenol degrading consortium, decomposed phenol and 3‐CP under iron‐reducing conditions with substantial fermentative degradation of organic compounds. When 20 mM of lactate was introduced into the first column, the phenol degradation activity of the second column was lost in a short period of time, because the amorphous Fe(III) oxide (FeOOH) that had been packed in the column before use was depleted by lactate metabolites, such as acetate and propionate, flowing into the second column from the first column. The complete mineralization of PCP was maintained for a long period by reducing the lactate concentration to 4 mM, effectively extending the longevity of second‐column activity with no depletion of FeOOH for more than 200 pore volumes (corresponding to 3,000 days). The carbon balance showed that 50 µM PCP and 4 mM lactate in the influent had transformed to CO₂ (81%) and CH₄ (3%) and had contributed to biomass growth (8%). A comparison of the microbial consortia introduced into the columns and those flowing out from the columns suggested that the introduced population did not flow out during the experiments, although the microbial composition of the phenol column was considered to be affected by the inflow of microbes from the PCP dechlorination column. These results suggest that a sequential combination of reductive dechlorinating and anaerobic oxidizing consortia is useful for anaerobic remediation of chlorinated aromatic compounds in a microbial permeable reactive barrier. Biotechnol. Bioeng. 2010;107: 775–785. © 2010 Wiley Periodicals, Inc.     

Effects of stirring and sparging on cultured hybridoma cells

The response of hybridoma cells to fluid shear caused by stirring and sparging has been investigated in a 2-L turbine-agitated bioreactor. Viable cell count, lactate dehydrogenase (LDH) release, and antibody secretion were measured over the course of batch culture experiments under varied conditions of stirring and gas sparging. The effectiveness of Pluronic F68 as a protective agent in sparged cultures was also studied. Growth was found to be unaffected by stirring of the culture under surface aerated conditions, but gas sparging had a significant detrimental effect on growth and antibody production. The effect of sparging was reduced when cultures were supplemented with Pluronic at a level of 0.4% (w/v). Experimental data were analyzed through formulation of models for LDH release and antibody production. Rates of cell lysis could be estimated by correlating extracellular LDH levels through the model for LDH release. The lysis rate estimated for sparged conditions was sufficiently large to approximately account for the observed decrease in the specific growth rate of the culture. The presence of Pluronic apparently interfered with the LDH release mechanism, so precise estimation of lysis rates under these conditions was not possible. Sparging was found not to have a detrimental effect on antibody production in cultures without Pluronic added. Specific antibody production rates in cultures supplemented with Pluronic were about 25% higher than in sparged cultures without Pluronic added.