初始条件对高浓度乙醇连续发酵过程的影响及振荡行为提高发酵效率的机理分析

前期实验在稀释速率为0.027h-1的高浓度乙醇连续发酵过程中,发现了一种长周期、宽振幅的参数振荡现象。本实验进一步考察了不同稀释速率下的连续发酵过程,发现在稀释速率为0.04h-1条件下,也能出现类似的振荡现象;在稀释速率为0.027h-1或0.04h-1的条件下,改变系统的初始状态可以得到振荡和稳态两种不同的发酵过程。比较振荡和稳态过程的实验数据后,发现在稀释速率为0.04h-1的条件下,与稳态过程相比,振荡过程的平均残糖浓度降低了14.8%,平均乙醇浓度提高了12.6%,平均设备生产强度提高了12.3%。进一步分析表明:与稳态过程相比,振荡过程动力学行为不仅存在滞后,而且在相同残糖和乙醇浓度条件下,所对应的平均比生长速率提高了53.8%。     

温度对超高浓度酒精生料发酵体系的影响

通过对超高底物浓度生料发酵中温度的影响研究发现,采用温度梯度的方法可大幅提高酵母的生产效率。以高粱为例,采用35%绝对干物浓度,在新型生料水解酶的配合下,通过合适的逐级降温培养方式,使用普通酒精干酵母,在90h内发酵醪液酒精浓度可达20%(V/V)以上。     

Parameter oscillations in a very high gravity medium continuous ethanol fermentation and their attenuation on a multistage packed column bioreactor system

The quasi-steady-states, marked by small fluctuations of residual glucose, ethanol, and biomass concentrations, and sustainable oscillations marked by big fluctuations of these monitored fermentation parameters were observed during the continuous ethanol fermentation of Saccharomyces cerevisiae when very high gravity media were fed and correspondingly high ethanol concentrations reached. A high ethanol concentration was shown to be one of the main factors that incited these oscillations, although the residual glucose level affected the patterns of these oscillations to some extent. The lag response of S. cerevisiae to high ethanol stress that causes the shifts of morphology, viability loss, and death of yeast cells is assumed to be one of the probable mechanisms behind these oscillations. It was predicted that the longer the delay of this response was, the longer the oscillation periods would be, which was validated by the experimental data and the comparison with the oscillatory behaviors reported for the ethanologen bacterium, Zymomonas mobilis. Furthermore, three tubular bioreactors in series were arranged to follow a stirred tank bioreactor to attenuate these oscillations. However, exaggerated oscillations were observed for the residual glucose, ethanol, and biomass concentrations measured in the broth from these tubular bioreactors. After the tubular reactors were packed with Intalox ceramic saddle packing, these oscillations were effectively attenuated and quasi-steady-states were observed during which there were very small fluctuations of residual glucose, ethanol, and biomass within the entire experimental run.     

Acceleration of high gravity yeast fermentations by acetaldehyde addition

In high gravity Saccharomyces cerevisiae fermentations containing 300 g glucose l^–1, daily addition of acetaldehyde to a total of 93 mM shortened the time required to ferment the first 250 g glucose l^–1 from 790 h to 585 h. Acetaldehyde feeding had no effect on the ethanol yield but increased by 135%, 78% and 77% the final concentrations of 2,3-butanediol, 2-methylpropanol and acetate, while decreasing that of glycerol by 14%. Controlled acetaldehyde feeding has potential as a technique for accelerating high gravity fuel or industrial ethanol fermentations and may be useful in preventing incomplete fermentations.     

超高浓度培养基条件下酵母细胞生长及酒精生成的准稳态动力学研究

在1．5L搅拌式发酵罐中,使用葡萄糖质量浓度分别为120、200、280g／L的培养基进行酿酒酵母Saccharomyces cerevisiae连续发酵生成酒精的动力学研究。研究发现,当培养基中葡萄糖浓度为200和280g／L时,发酵液中残糖浓度、酒精浓度以及菌体生物量从小幅度波动的准稳态发展到大幅度波动的振荡状态。提出了伴有周期性振荡现象准稳态过程的概念,并针对该过程,建立了兼有底物和产物抑制的酵母细胞生长和产物酒精生成动力学模型。     

Improvement of ethanol production in very high gravity fermentation by horse gram (Dolichos biflorus) flour supplementation

AIMS: To determine the effect of osmotic stress on yeast and to investigate the protective role of horse gram flour during very high gravity (VHG) ethanol fermentation. METHODS AND RESULTS: Saccharomyces cerevisiae was inoculated into high sugar (30-40%, w/v) containing medium with and without supplementation of horse gram flour. The fermentation experiments were carried out in batch mode. The effect of 4 or 6% of horse gram flour to the medium on the metabolic behaviour and viability of yeast was studied. Significant increase in ethanol yield up to 50% and dramatic decrease in glycerol production up to 100% was observed in the presence of horse gram flour. The fermentation rate was increased from 3 to 5 days with increased viable cell count. The physical and chemical factors of horse gram flour may aid in reducing the osmotic stress of high gravity fermentation of ethanol as well as enhancing ethanol yield. CONCLUSIONS: It was found that horse gram flour not only reduced fermentation time but also enhanced ethanol production by better utilization of sugar. SIGNIFICANCE AND IMPACT OF THE STUDY: Production of high ethanol concentration by using VHG sugar fermentation eliminates the expensive steps in the conventional process and saves time.     

响应面法优化耐高温酵母生产高浓度乙醇

利用耐高温酵母GXASY-10菌株对木薯粉同步糖化(SSF)法生产高浓度乙醇的发酵条件进行了优化。在单因素实验的基础上,首先应用Plackett-Burman试验设计筛选影响酒精高温高浓度发酵的重要参数,采用最陡爬坡实验逼近最大酒精生产区域后,利用Box-Behnken设计确定重要参数的最佳水平。筛选结果表明,影响酒精产量的重要参数是液化时间、糖化酶用量和初始木薯粉(底物)浓度。最佳工艺条件为:液化时间为35min,糖化酶添加量为1.21AGU/g底物,底物浓度为37.62%。20L发酵罐在此条件下(发酵温度37℃,转速100r/min)经过48h发酵,酒精浓度可达16.07%(V/W)。优化条件与初始条件相比较,酒精浓度提高了33%。     

Metabolite profiling of recombinant CHO cells: Designing tailored feeding regimes that enhance recombinant antibody production

Chinese hamster ovary (CHO) cells are the primary platform for commercial expression of recombinant therapeutic proteins. Obtaining maximum production from the expression platform requires optimal cell culture medium (and associated nutrient feeds). We have used metabolite profiling to define the balance of intracellular and extracellular metabolites during the production process of a CHO cell line expressing a recombinant IgG4 antibody. Using this metabolite profiling approach, it was possible to identify nutrient limitations, which acted as bottlenecks for antibody production, and subsequently develop a simple feeding regime to relieve these metabolic bottlenecks. This metabolite profiling‐based strategy was used to design a targeted, low cost nutrient feed that increased cell biomass by 35% and doubled the antibody titer. This approach, with the potential for utilization in non‐specialized laboratories, can be applied universally to the optimization of production of commercially important biopharmaceuticals. Biotechnol. Bioeng. 2011;108: 3025–3031. © 2011 Wiley Periodicals, Inc.     

鹰嘴豆孢克鲁维酵母利用菊芋原料同步糖化与发酵生产乙醇

菊芋含有大量的菊粉多糖,且种植简单、产量高,是极具开发价值的替代玉米等粮食作物生产燃料乙醇的原料。文中研究了鹰嘴豆孢克鲁维酵母Y179利用菊芋原料同步糖化与发酵生产乙醇。鹰嘴豆孢克鲁维酵母Y179具有高效分泌菊粉酶的能力,摇瓶试验显示Y179酵母能够利用完全由菊芋原料配制而成的培养基良好生长并发酵产生乙醇。通气及温度对乙醇产量影响明显,相对厌氧环境对Y179酵母发酵产乙醇具有促进作用,30℃发酵温度相对37℃和42℃更有利于乙醇产量提高。种子液培养时间及接种量对乙醇产量影响较小。在5 L发酵罐中以10%(V/V)量接入预培养36 h的Y179种子液,发酵液完全由菊芋干粉配制而成,总糖含量22%(W/V),30℃不通气,300 r/min搅拌,发酵144 h时,乙醇浓度达到12.3%(V/V),糖醇转化效率86.9%,糖利用率大于93.6%。初步研究结果显示鹰嘴豆孢克鲁维酵母Y179在利用菊芋原料生产乙醇方面具有良好应用前景。     

Impact of an acid fungal protease in high gravity fermentation for ethanol production using indian sorghum as a feedstock

This study evaluated the conventional jet cooking liquefaction process followed by simultaneous saccharification and fermentation (SSF) at 30% and 35% dry solids (DS) concentration of Indian sorghum feedstock for ethanol production, with addition of acid fungal protease or urea. To evaluate the efficacy of thermostable α‐amylase in liquefaction at 30% and 35% DS concentration of Indian sorghum, liquefact solubility, higher dextrins, and fermentable sugars were analyzed at the end of the process. The liquefact was further subjected to SSF using yeast. In comparison with urea, addition of an acid fungal protease during SSF process was observed to accelerate yeast growth (μ), substrate consumption (Q_s), ultimately ethanol yield based on substrate (Y_p/s) and ethanol productivity based on fermentation time (Q_p). The fermentation efficiency and ethanol recovery were determined for both concentrations of Indian sorghum and found to be increased with use of acid fungal protease in SSF process. © 2013 American Institute of Chemical Engineers Biotechnol. Prog., 29: 329–336, 2013     

Simultaneous saccharification and ethanol fermentation at high corn stover solids loading in a helical stirring bioreactor

The higher ethanol titer inevitably requires higher solids loading during the simultaneous enzymatic saccharification and fermentation (SSF) using lignocellulose as the feedstock. The mixing between the solid lignocellulose and the liquid enzyme is crucially important. In this study, a bioreactor with a novel helical impeller was designed and applied to the SSF operation of the steam explosion pretreated corn stover under different solids loadings and different enzyme dosages. The performances using the helical impeller and the common Rushton impeller were compared and analyzed by measuring rheological properties and the mixing energy consumption. The results showed that the new designed stirring system had better performances in the saccharification yield, ethanol titer, and energy cost than those of the Rushton impeller stirring. The mixing energy consumption under different solids loadings and enzyme dosages during SSF operation were analyzed and compared to the thermal energy in the ethanol produced. A balance for achieving the optimal energy cost between the increased mixing energy cost and the reduced distillation energy cost at the high solids loading should be made. The potentials of the new bioreactor were tested under various SSF conditions for obtaining optimal ethanol yield and titer. Biotechnol. Bioeng. 2010. 105: 718–728. © 2009 Wiley Periodicals, Inc.     

High solid simultaneous saccharification and fermentation of wet oxidized corn stover to ethanol

In this study ethanol was produced from corn stover pretreated by alkaline and acidic wet oxidation (WO) (195 degrees C, 15 min, 12 bar oxygen) followed by nonisothermal simultaneous saccharification and fermentation (SSF). In the first step of the SSF, small amounts of cellulases were added at 50 degrees C, the optimal temperature of enzymes, in order to obtain better mixing condition due to some liquefaction. In the second step more cellulases were added in combination with dried baker's yeast (Saccharomyces cerevisiae) at 30 degrees C. The phenols (0.4-0.5 g/L) and carboxylic acids (4.6-5.9 g/L) were present in the hemicellulose rich hydrolyzate at subinhibitory levels, thus no detoxification was needed prior to SSF of the whole slurry. Based on the cellulose available in the WO corn stover 83% of the theoretical ethanol yield was obtained under optimized SSF conditions. This was achieved with a substrate concentration of 12% dry matter (DM) acidic WO corn stover at 30 FPU/g DM (43.5 FPU/g cellulose) enzyme loading. Even with 20 and 15 FPU/g DM (corresponding to 29 and 22 FPU/g cellulose) enzyme loading, ethanol yields of 76 and 73%, respectively, were obtained. After 120 h of SSF the highest ethanol concentration of 52 g/L (6 vol.%) was achieved, which exceeds the technical and economical limit of the industrial-scale alcohol distillation. The SSF results showed that the cellulose in pretreated corn stover can be efficiently fermented to ethanol with up to 15% DM concentration. A further increase of substrate concentration reduced the ethanol yield significant as a result of insufficient mass transfer. It was also shown that the fermentation could be followed with an easy monitoring system based on the weight loss of the produced CO2.     

Effect of the size of yeast flocs and zinc supplementation on continuous ethanol fermentation performance and metabolic flux distribution under very high concentration conditions

Taking continuous ethanol fermentation with the self‐flocculating yeast SPSC01 under very high concentration conditions as an example, the fermentation performance of the yeast flocs and their metabolic flux distribution were investigated by controlling their average sizes at 100, 200, and 300 µm using the focused beam reflectance online measurement system. In addition, the impact of zinc supplementation was evaluated for the yeast flocs at the size of 300 µm grown in presence or absence of 0.05 g L^?1 zinc sulfate. Among the yeast flocs with different sizes, the group with the average size of 300 µm exhibited highest ethanol production (110.0 g L^?1) and glucose uptake rate (286.69 C mmol L^?1 h^?1), which are in accordance with the increased flux from pyruvate to ethanol and decreased flux to glycerol. And in the meantime, zinc supplementation further increased ethanol production and cell viability comparing with the control. Zinc addition enhanced the carbon fluxes to the biosynthesis of ergosterol (28.6%) and trehalose (43.3%), whereas the fluxes towards glycerol, protein biosynthesis, and tricarboxylic acid cycle significantly decreased by 37.7%, 19.5%, and 27.8%, respectively. This work presents the first report on the regulation of metabolic flux by the size of yeast flocs and zinc supplementation, which provides the potential for developing engineering strategy to optimize the fermentation system. Biotechnol. Bioeng. 2010;105: 935–944. © 2009 Wiley Periodicals, Inc.     

高温高浓发酵工业啤酒酵母菌种的构建

高温高浓发酵技术作为一项新兴的啤酒生产技术,它为啤酒生产带来诸多利益的同时,也存在着发酵结束后酵母絮凝性下降、高级醇生成量过高等系列问题。为提高高温高浓发酵条件下酿酒酵母的絮凝性同时降低高级醇的合成能力,首先构建了以酿酒酵母BAT2基因为整合位点过表达FLO5基因的菌株,重组菌株S6-BF的絮凝性达到67.67%,比出发菌株S6提高了29%,而高级醇生成量仅降低5.9%;进一步构建以BAT2基因为整合位点再次过表达FLO5基因的菌株,与出发菌株S6相比,重组菌株S6-BF2的絮凝性提高了63%,达到85.44%,高级醇生成量下降至159.58 mg/L,降低了9.0%;通过弱化线粒体支链氨基酸转氨酶(BAT1)的表达,高级醇的生成量得到进一步的降低,达到142.13 mg/L,比原始菌株S6降低了18.4%,同时重组菌株S6-BF2B1的絮凝性没有受到影响;风味物质的测定结果表明啤酒中醇酯比例较为合理。研究结果对工业啤酒酵母发酵后的沉降分离和提高啤酒风味品质有着重要的意义。     

木薯纤维素乙醇发酵的纤维素酶成本评价

木薯中的纤维素成分约占木薯干重的10％(W/W).文中以木薯燃料乙醇生产的木薯纤维素酒渣为原料,从纤维素酶成本角度评估了三种利用木薯纤维素组分发酵生产乙醇的方法,包括木薯纤维素酒渣的直接糖化和乙醇发酵、木薯纤维素酒渣预处理后的糖化与乙醇发酵、木薯乙醇发酵中同步淀粉与纤维素糖化以及乙醇发酵.结果表明,前两种方法的纤维素利用效率不高,酶成本分别达到13602、11659元/吨乙醇.第三种方法,即在木薯乙醇发酵过程同时加入糖化酶和纤维素酶,进行同步淀粉与纤维素糖化,进而进行乙醇发酵,木薯纤维素乙醇的收益最高.发酵结束时的乙醇浓度从101.5g/L提高到107.0g/L,纤维素酶成本为3 589元/吨乙醇.此方法利用木薯纤维素与木薯淀粉同时进行,不会带来额外的设备及操作投入,酶成本低于产品乙醇价格,可实现盈利,因此第三种方法为木薯纤维用于乙醇发酵的最适方法,本研究结果将为木薯乙醇产业深度利用木薯纤维提供依据.     

Continuous ethanol production and evaluation of yeast cell lysis and viability loss under very high gravity medium conditions

A combined bioreactor system, composed of a stirred tank and a three-stage tubular bioreactor in series and with a total working volume of 3260 ml, was established. Continuous ethanol production was carried out using Saccharomyces cerevisiae and a very high gravity (VHG) medium containing 280 g l⁻¹ glucose. An average ethanol concentration of 124.6 g l⁻¹ or 15.8% (v) was produced when the bioreactor system was operated at a dilution rate of 0.012 h⁻¹. The yield of ethanol to glucose consumed was calculated to be 0.484 or 94.7% of its theoretical value of 0.511 when ethanol entrapped in the exhaust gas was incorporated. Meanwhile, quasi-steady states and non-steady oscillations were observed for residual glucose, ethanol and biomass concentrations for all of these bioreactors during their operations. Models that can be used to predict yeast cell lysis and viability loss were developed.     

Biological pretreatment of corn stover with Phlebia brevispora NRRL‐13108 for enhanced enzymatic hydrolysis and efficient ethanol production

Biological pretreatment of lignocellulosic biomass by white‐rot fungus can represent a low‐cost and eco‐friendly alternative to harsh physical, chemical, or physico‐chemical pretreatment methods to facilitate enzymatic hydrolysis. In this work, solid‐state cultivation of corn stover with Phlebia brevispora NRRL‐13018 was optimized with respect to duration, moisture content and inoculum size. Changes in composition of pretreated corn stover and its susceptibility to enzymatic hydrolysis were analyzed. About 84% moisture and 42 days incubation at 28°C were found to be optimal for pretreatment with respect to enzymatic saccharification. Inoculum size had little effect compared to moisture level. Ergosterol data shows continued growth of the fungus studied up to 57 days. No furfural and hydroxymethyl furfural were produced. The total sugar yield was 442 ± 5 mg/g of pretreated corn stover. About 36 ± 0.6 g ethanol was produced from 150 g pretreated stover per L by fed‐batch simultaneous saccharification and fermentation (SSF) using mixed sugar utilizing ethanologenic recombinant Eschericia coli FBR5 strain. The ethanol yields were 32.0 ± 0.2 and 38.0 ± 0.2 g from 200 g pretreated corn stover per L by fed‐batch SSF using Saccharomyces cerevisiae D5A and xylose utilizing recombinant S. cerevisiae YRH400 strain, respectively. This research demonstrates that P. brevispora NRRL‐13018 has potential to be used for biological pretreatment of lignocellulosic biomass. This is the first report on the production of ethanol from P. brevispora pretreated corn stover. © 2017 American Institute of Chemical Engineers Biotechnol. Prog., 33:365–374, 2017     

Observed quasi-steady kinetics of yeast cell growth and ethanol formation under very high gravity fermentation condition

Using a generalSaccharomyces cerevisiae as a model strain, continuous ethanol fermentation was carried out in a stirred tank bioreactor with a working volume of 1,500 mL. Three different gravity media containing glucose of 120, 200 and 280 g/L, respectively, supplemented with 5 g/L yeast extract and 3 g/L peptone, were fed into the fermentor at different dilution rates. Although complete steady states developed for low gravity medium containing 120 g/L glucose, quasi-steady states and oscillations of the fermented parameters, including residual glucose, ethanol and biomass were observed when high gravity medium containing 200 g/L glucose and very high gravity medium containing 280 g/L glucose were fed at the designated dilution rate of 0.027 h⁻¹. The observed quasi-steady states that incorporated these steady states, quasi-steady states and oscillations were proposed as these oscillations were of relatively short periods of time and their averages fluctuated up and down almost symmetrically. The continuous kinetic models that combined both the substrate and product inhibitions were developed and correlated for these observed quasi-steady states.     

Metabolite profiling analysis of Methylobacterium extorquens AM1 by comprehensive two-dimensional gas chromatography coupled with time-of-flight mass spectrometry

Methylobacterium extorquens AM1 is a facultative methylotroph, which is a potential candidate to be used in commercial processes to convert simple one-carbon compounds to a variety of multicarbon chemicals and products. To better understand C(1) metabolism in M. extorquens AM1 at the systems level, metabolite profiling tools were developed and applied in this bacterium. Comprehensive two-dimensional gas chromatography coupled with time-of-flight mass spectrometry (GC x GC-TOFMS) was used to obtain metabolite profiles of M. extorquens AM1 (primarily organic acids) and to identify the metabolite differences between cells grown on methanol (C(1) substrate) and succinate (multicarbon substrate). In this study, a list of compounds that included amino acids and major intermediates of central C(1) and multicarbon metabolism were studied as target metabolites. For these, calibration curves were obtained for absolute quantification by spiking different amounts of standard mixtures to cell cultures. Parallel factor analysis (PARAFAC) was used for accurate peak quantification. Unknown chemical differences between cells grown on methanol and succinate were identified by applying Fisher ratio analysis at a selective mass channel (m/z 147). Thirty-six compounds were discovered to be statistically differentially expressed between C(1) and multicarbon metabolism. Among these, 13 were identified by matching to library mass spectra, and the rest were novel compounds that were not included in libraries. These differentially expressed compounds have provided clues to new pathways that are specifically linked to C(1) metabolism.     

Simultaneous saccharification and co‐fermentation of paper sludge to ethanol by Saccharomyces cerevisiae RWB222. Part II: Investigation of discrepancies between predicted and observed performance at high solids concentration

The simultaneous saccharification and co‐fermentation (SSCF) kinetic model described in the companion paper can predict batch and fed batch fermentations well at solids concentrations up to 62.4 g/L cellulose paper sludge but not in batch fermentation at 82.0 g/L cellulose paper sludge. Four hypotheses for the discrepancy between observation and model prediction at high solids concentration were examined: ethanol inhibition, enzyme deactivation, inhibition by non‐metabolizable compounds present in paper sludge, and mass transfer limitation. The results show that mass transfer limitation was responsible for the discrepancy between model and experimental data. The model can predict the value of high paper sludge SSCF in the fermentation period with no mass transfer limitation. The model predicted that maximum ethanol production of fed‐batch fermentation was achieved when it was run as close to batch mode as possible with the initial solids loading below the mass transfer limitation threshold. A method for measuring final enzyme activity at the end of fermentation was also developed in this study. Biotechnol. Bioeng. 2009; 104: 932–938. © 2009 Wiley Periodicals, Inc.