Fermentation of cellulose and cellobiose by Clostridium thermocellum in the absence of Methanobacterium thermoautotrophicum.

The fermentation of cellulose and cellobiose by Clostridium thermocellum monocultures and C. thermocellum/Methanobacterium thermoautotrophicum cocultures was studied. All cultures were grown under anaerobic conditions in batch culture at 60 degrees C. When grown on cellulose, the coculture exhibited a shorter lag before initiation and growth and celluloysis than did the monoculture. Cellulase activity appeared earlier in the coculture than in the monoculture; however, after growth had ceased, cellulase activity was greater in the monoculture. Monocultures produced primarily ethanol, acetic acid, H2 and CO2. Cocultures produced more H2 and acetic acid and less ethanol than did the monoculture. In the coculture, conversion of H2 to methane was usually complete, and most of the methane produced was derived from CO2 reduction rather than from acetate conversion. Agents of fermentation stoppage were found to be low pH and high concentrations of ethanol in the monoculture and low pH in the coculture. Fermentation of cellobiose was more rapid than that of cellulose. In cellobiose medium, the methanogen caused only slight changes in the fermentation balance of the Clostridium, and free H2 was produced.     

Ethanol Production by Thermophilic Bacteria: Fermentation of Cellulosic Substrates by Cocultures of Clostridium thermocellum and Clostridium thermohydrosulfuricum

The fermentation of various saccharides derived from cellulosic biomass to ethanol was examined in mono- and cocultures of Clostridium thermocellum strain LQRI and C. thermohydrosulfuricum strain 39E. C. thermohydrosulfuricum fermented glucose, cellobiose, and xylose, but not cellulose or xylan, and yielded ethanol/acetate ratios of >7.0. C. thermocellum fermented a variety of cellulosic substrates, glucose, and cellobiose, but not xylan or xylose, and yielded ethanol/acetate ratios of ~1.0. At nonlimiting cellulosic substrate concentrations (~1%), C. thermocellum cellulase hydrolysis products accumulated during monoculture fermentation of Solka Floc cellulose and included glucose, cellobiose, xylose, and xylobiose. A stable coculture that contained nearly equal numbers of C. thermocellum and C. thermohydrosulfuricum was established that fermented a variety of cellulosic substrates, and the ethanol yield observed was twofold higher than in C. thermocellum monoculture fermentations. The metabolic basis for the enhanced fermentation effectiveness of the coculture on Solka Floc cellulose included: the ability of C. thermocellum cellulase to hydrolyze α-cellulose and hemicellulose; the enhanced utilization of mono- and disaccharides by C. thermohydrosulfuricum; increased cellulose consumption; threefold increase in the ethanol production rate; and twofold decrease in the acetate production rate. The coculture actively fermented MN300 cellulose, Avicel, Solka Floc, SO₂-treated wood, and steam-exploded wood. The highest ethanol yield obtained was 1.8 mol of ethanol per mol of anhydroglucose unit in MN300 cellulose.     

The characteristics of a new non-spore-forming cellulolytic mesophilic anaerobe strain CM126 isolated from municipal sewage sludge

A new mesophilic anaerobic cellulolytic bacterium, CM126, was isolated from an anaerobic sewage sludge digester. The organism was non-spore-forming, rod-shaped, Gram-negative and motile with peritrichous flagella. It fermented microcrystalline Avicel cellulose, xylan, Solka floc cellulose, filter paper, L-arabinose, D-xylose, β-methyl xyloside, D-glucose, cellobiose and xylitol and produced indole. The % G + C content was 36. Acetic acid, ethanol, lactic acid, pyruvic acid, carbon dioxide and hydrogen were produced as metabolic products. This strain could grow at 20–44·5°C and at pH values 5·2–7·4 with optimal growth at 37–41·5°C and pH 7. Both endoglucanase and xylanase were detected in the supernatant fluid of a culture grown on medium containing Avicel cellulose and cellobiose. Exoglucanase could not be found in either supernatant fluid or the cell lysate. When cellulose and cellobiose fermentation were compared, the enzyme production rate in cellobiose fermentation was higher than in cellulose fermentation. The optimum pH for both enzyme activities was 5·0, the optimum temperature was 40°C for the endoglucanase and 50°C for the xylanase. Both enzyme activities were inhibited at 70°C. Co-culture of this organism with a Methanosarcina sp. (A145) had no effect on cellulose degradation and both endoglucanase and xylanase were stable in the co-culture.     

The characteristics of a new non-spore-forming cellulolytic mesophilic anaerobe strain CM126 isolated from municipal sewage sludge

A new mesophilic anaerobic cellulolytic bacterium, CM126, was isolated from an anaerobic sewage sludge digester. The organism was non-spore-forming, rod-shaped, Gram-negative and motile with peritrichous flagella. It fermented microcrystalline Avicel cellulose, xylan, Solka floc cellulose, filter paper, L-arabinose, D-xylose, beta-methyl xyloside, D-glucose, cellobiose and xylitol and produced indole. The % G + C content was 36. Acetic acid, ethanol, lactic acid, pyruvic acid, carbon dioxide and hydrogen were produced as metabolic products. This strain could grow at 20-44.5 degrees C and at pH values 5.2-7.4 with optimal growth at 37-41.5 degrees C and pH 7. Both endoglucanase and xylanase were detected in the supernatant fluid of a culture grown on medium containing Avicel cellulose and cellobiose. Exoglucanase could not be found in either supernatant fluid or the cell lysate. When cellulose and cellobiose fermentation were compared, the enzyme production rate in cellobiose fermentation was higher than in cellulose fermentation. The optimum pH for both enzyme activities was 5.0, the optimum temperature was 40 degrees C for the endoglucanase and 50 degrees C for the xylanase. Both enzyme activities were inhibited at 70 degrees C Co-culture of this organism with a Methanosarcina sp. (A145) had no effect on cellulose degradation and both endoglucanase and xylanase were stable in the co-culture.     

Competition for cellulose among three predominant ruminal cellulolytic bacteria under substrate-excess and substrate-limited conditions.

Three predominant ruminal cellulolytic bacteria (Fibrobacter succinogenes S85, Ruminococcus flavefaciens FD-1, and Ruminococcus albus 7) were grown in different binary combinations to determine the outcome of competition in either cellulose-excess batch culture or in cellulose-limited continuous culture. Relative populations of each species were estimated by using signature membrane-associated fatty acids and/or 16S rRNA-targeted oligonucleotide probes. Both F. succinogenes and R. flavefaciens coexisted in cellulose-excess batch culture with similar population sizes (58 and 42%, respectively; standard error, 12%). By contrast, under cellulose limitation R. flavefaciens predominated (> 96% of total cell mass) in coculture with F. succinogenes, regardless of whether the two strains were inoculated simultaneously or whether R. flavefaciens was inoculated into an established culture of F. succinogenes. The predominance of R. flavefaciens over F. succinogenes under cellulose limitation is in accord with the former's more rapid adherence to cellulose and its higher affinity for cellodextrin products of cellulose hydrolysis. In batch cocultures of F. succinogenes and R. albus, the populations of the two species were similar. However, under cellulose limitation, F. succinogenes was the predominant strain (approximately 80% of cell mass) in cultures simultaneously coinoculated with R. albus. The results from batch cocultures of R. flavefaciens and R. albus were not consistent within or among trials: some experiments yielded monocultures of R. albus (suggesting production of an inhibitory agent by R. albus), while others contained substantial populations of both species. Under cellulose limitation, R. flavefaciens predominated over R. albus (85 and 15%, respectively), as would be expected by the former's greater adherence to cellulose. The retention of R. albus in the cellulose-limited coculture may result from a combination of its ability to utilize glucose (which is not utilizable by R. flavefaciens), its demonstrated ability to adapt under selective pressure in the chemostat to utilization of lower concentrations of cellobiose, a major product of cellulose hydrolysis, and its possible production of an inhibitory agent.     

Effect of coculture of anaerobic fungi isolated from ruminants and non-ruminants with methanogenic bacteria on cellulolytic and xylanolytic enzyme activities

Neocallimastix strain N1, an isolate from a ruminant (sheep), was cocultured with three Methanobacterium formicicum strains, Methanosarcina barkeri, and Methanobrevibacter smithii. The coculture with Methanobacterium formicicum strains resulted in the highest production of cellulolytic and xylanolytic enzymes. Subsequently four anaerobic fungi, two Neocallimastix strains (N1 and N2) from a ruminant and two Piromyces species from non-ruminants (E2 and R1), were grown in coculture with Methanobacterium formicicum DSM 3637 on filter paper cellulose and monitored over a 7-day period for substrate utilisation, fermentation products, and secretion of cellulolytic and xylanolytic enzymes. Methanogens caused a shift in fermentation products to more acetate and less ethanol, lactate and succinate. Furthermore the cellulose digestion rate increased by coculture. For cocultures of Neoallimastix strains with Methanobacterium formicicum strains the cellulolytic and xylanolytic enzyme production increased. Avicelase, CMCase and xylanase were almost completely secreted into the medium, while 40–60% of the -glucosidase was found to be cell bound. Coculture had no significant effect on the location of cellulolytic and xylanolytic enzymes.     

Characterization of a Symbiotic Coculture of Clostridium thermohydrosulfuricum YM3 and Clostridium thermocellum YM4

Clostridium thermohydrosulfuricum YM3 and C. thermocellum YM4 were isolated from a coculture which was obtained from an enrichment culture inoculated with volcanic soil in Izu Peninsula, Japan. Strain YM3 had advantages over reported C. thermohydrosulfuricum strains in that it fermented inulin and could accumulate ethanol up to 1.3% (wt/vol). The highest ethanol yield obtained was 1.96 mol/mol of anhydroglucose unit in cellobiose. Strain YM4 had features different from those reported in C. thermocellum strains: it formed spores rarely (at a frequency of <10^-5), it required CO₂ and Na₂CO₃ for growth, and it fermented sucrose. Strain YM4 completely decomposed 1% Avicel within 25 h when the inoculum constituted 2% of the culture medium volume, and it produced 0.22 U of Avicelase and 2.21 U of carboxymethylcellulase per ml of the medium. The doubling times on Avicel, cellobiose, and glucose were 2.7, 1.1, and 1.6 h, respectively. Reconstructed cocultures of strains YM3 and YM4 were very stable and degraded Avicel more rapidly than did strain YM4 monoculture. Without yeast extract, neither microorganism was able to grow. However, the coculture grew on cellulose without yeast extract and produced ethanol in high yield. Moreover, cell-free spent culture broth of strain YM3 could replace yeast extract in supporting the growth of strain YM4. The symbiotic relationship of the two bacteria in cellulose fermentation is probably a case of mutualism.     

Characterization of the cellulolytic activity of a Bacillus isolate

A group I Bacillus strain, DLG, was isolated and characterized as being most closely related to Bacillus subtilis. When grown on any of a variety of sugars, the culture supernatant of this isolate was found to possess cellulolytic activity, as demonstrated by degradation of trinitrophenyl-carboxymethyl cellulose. Growth in medium containing cellobiose or glucose resulted in the greatest production of cellulolytic activity. The cellulolytic activity was not produced until the stationary phase of growth, and the addition of glucose or cellobiose to a culture in this phase had no apparent effect on enzyme production. Fractionation of the culture supernatant showed that the molecular weight of the enzymatic activity was less than 100,000. Maximum cellulolytic activity in assays was observed at pH 4.8 and at 58C, although maximum thermal stability of the activity. Kinetic experiments suggested that more than one enzyme was acting upon trinitrophenyl-carboxymethyl cellulose. Exocellular protein produced by this Bacillus isolate showed roughly one-fifth the cellulolytic activity displayed by Trichoderma reesei C30 on noncrystalline, cellulosic substrates. In contrast to T. reesei cellulase, the Bacillus enzymatic activity showed no ability to degrade crystalline forms of cellulose, nor was cellobiase activity detectable.     

Characterization of the cellulolytic activity of a Bacillus isolate.

A group I Bacillus strain, DLG, was isolated and characterized as being most closely related to Bacillus subtilis. When grown on any of a variety of sugars, the culture supernatant of this isolate was found to possess cellulolytic activity, as demonstrated by degradation of trinitrophenyl-carboxymethyl cellulose. Growth in medium containing cellobiose or glucose resulted in the greatest production of cellulolytic activity. The cellulolytic activity was not produced until the stationary phase of growth, and the addition of glucose or cellobiose to a culture in this phase had no apparent effect on enzyme production. Fractionation of the culture supernatant showed that the molecular weight of the enzymatic activity was less than 100,000. Maximum cellulolytic activity in assays was observed at pH 4.8 and at 58C, although maximum thermal stability of the activity. Kinetic experiments suggested that more than one enzyme was acting upon trinitrophenyl-carboxymethyl cellulose. Exocellular protein produced by this Bacillus isolate showed roughly one-fifth the cellulolytic activity displayed by Trichoderma reesei C30 on noncrystalline, cellulosic substrates. In contrast to T. reesei cellulase, the Bacillus enzymatic activity showed no ability to degrade crystalline forms of cellulose, nor was cellobiase activity detectable.     

Cellobiose-oxidizing enzyme from a newly isolated cellulolytic bacterium Cytophaga sp. LX-7

Summary The cellobiose oxidizing enzyme of the newly isolated cellulolytic bacterium Cytophaga sp. LX-7 was produced extracellularly when grown on cellulose or other saccharides, which was previously noted only in fungi. The enzyme could use not only cellobiose, maltose, glucose and other saccharides but also cellulose as substrates, and use dichlorophenol indophenol and oxygen as electron acceptors.     

Continuous Cellulosic Bioethanol Fermentation by Cyclic Fed-Batch Cocultivation

Cocultivation of cellulolytic and saccharolytic microbial populations is a promising strategy to improve bioethanol production from the fermentation of recalcitrant cellulosic materials. Earlier studies have demonstrated the effectiveness of cocultivation in enhancing ethanolic fermentation of cellulose in batch fermentation. To further enhance process efficiency, a semicontinuous cyclic fed-batch fermentor configuration was evaluated for its potential in enhancing the efficiency of cellulose fermentation using cocultivation. Cocultures of cellulolytic Clostridium thermocellum LQRI and saccharolytic Thermoanaerobacter pseudethanolicus strain X514 were tested in the semicontinuous fermentor as a model system. Initial cellulose concentration and pH were identified as the key process parameters controlling cellulose fermentation performance in the fixed-volume cyclic fed-batch coculture system. At an initial cellulose concentration of 40 g liter⁻¹, the concentration of ethanol produced with pH control was 4.5-fold higher than that without pH control. It was also found that efficient cellulosic bioethanol production by cocultivation was sustained in the semicontinuous configuration, with bioethanol production reaching 474 mM in 96 h with an initial cellulose concentration of 80 g liter⁻¹ and pH controlled at 6.5 to 6.8. These results suggested the advantages of the cyclic fed-batch process for cellulosic bioethanol fermentation by the cocultures.     

Fermentation of methylcellulose by a cellulolytic and a non-cellulolytic marine bacteria

Summary Two microorganisms originally existing in cellulose enrichmet cultures obtained from lagoon sediments, were isolated for mono-and cocultures studies. Methylcellulose was degraded faster with the coculture than with the cellulolytic bacterium alone, and with a product pattern reflecting the non-cellulolytic bacterium.     

Study of cellulases from a newly isolated thermophilic and cellulolytic <Emphasis Type="Italic">Brevibacillus</Emphasis> sp. strain JXL

A potentially novel aerobic, thermophilic, and cellulolytic bacterium designated as Brevibacillus sp. strain JXL was isolated from swine waste. Strain JXL can utilize a broad range of carbohydrates including: cellulose, carboxymethylcellulose (CMC), xylan, cellobiose, glucose, and xylose. In two different media supplemented with crystalline cellulose and CMC at 57°C under aeration, strain JXL produced a basal level of cellulases as FPU of 0.02 IU/ml in the crude culture supernatant. When glucose or cellobiose was used besides cellulose, cellulase activities were enhanced ten times during the first 24 h, but with no significant difference between these two simple sugars. After that time, however, culture with glucose demonstrated higher cellulase activities compared with that from cellobiose. Similar trend and effect on cellulase activities were also obtained when glucose or cellobiose served as a single substrate. The optimal doses of cellobiose and glucose for cellulase induction were 0.5 and 1%. These inducing effects were further confirmed by scanning electron microscopy (SEM) images, which indicated the presence of extracellular protuberant structures. These cellulosome-resembling structures were most abundant in culture with glucose, followed by cellobiose and without sugar addition. With respect to cellulase activity assay, crude cellulases had an optimal temperature of 50°C and a broad optimal pH range of 6–8. These cellulases also had high thermotolerance as evidenced by retaining more than 50% activity at 100°C after 1 h. In summary, this is the first study to show that the genus Brevibacillus may have strains that can degrade cellulose.     

The implications of the loss and regain of cotton-degrading activity for the degradation of straw by Ruminococcus flavefaciens strain 007

Cultivation of the cellulolytic anaerobe Ruminococcus flavefaciens strain 007 on a nutrient medium containing cellobiose as energy source resulted in a four- to five-fold reduction in the cotton-degrading activity of the strain after 15–18 subcultures. Two single colony re-isolations also lost cotton-degrading activity after repeated cultivation on cellobiose. When the form with poor cotton-degrading activity (007S) was serially subcultured on cotton fibres, high cotton-degrading activity was recovered after 7–13 subcultures. One (of three) single colony re-isolations of 007S also recovered cotton-degrading activity under these conditions. The time course of these changes in activity suggests that they resulted from mutations. The cotton degrader (007C) was slightly more active against Avicel, Sigmacell and filter paper than was 007S, but 007S and 007C showed similar activity against acid-swollen cellulose. Strain 007C was not significantly more active than 007S in degrading barley straw (with or without ammonia treatment) or wheat straw. The property that enables strain 007C to degrade cotton appears to play at most a minor role in the degradation of straw. and accepted 5 July 1989     

Improved fermentation of cellobiose,glucose, and xylose to ethanol by Zymomonas anaerobia and a high ethanol tolerant strain of Clostridium saccharolyticum

Summary To improve single step conversion of sugar mixtures containing cellobiose, glucose, and xylose to ethanol by a coculture of Zymomonas anaerobia and Clostridium saccharolyticum, an ethanol tolerant mutant of C. saccharolyticum was obtained. The mutant obtained by the enrichment procedure was able to grow in the presence of 75 g·l^-1 ethanol, with improved ability to utilize cellobiose, and little or no change in its ability to convert xylose to ethanol. This mutant in coculture with Zymomonas anaerobia produced over 50 g·l^-1 ethanol in media containing 130 g·l^-1 total sugars comprising of 60% glucose, 20% cellobiose, and 20% xylose.Issued as NRCC No. 23936     

Isolation and characterization of Shigella flexneri G3, capable of effective cellulosic saccharification under mesophilic conditions

A novel Shigella strain (Shigella flexneri G3) showing high cellulolytic activity under mesophilic, anaerobic conditions was isolated and characterized. The bacterium is Gram negative, short rod shaped, and nonmotile and displays effective production of glucose, cellobiose, and other oligosaccharides from cellulose (Avicel PH-101) under optimal conditions (40°C and pH 6.5). Approximately 75% of the cellulose was hydrolyzed in modified ATCC 1191 medium containing 0.3% cellulose, and the oligosaccharide production yield and specific production rate reached 375 mg g Avicel(-1) and 6.25 mg g Avicel(-1) h(-1), respectively, after a 60-hour incubation. To our knowledge, this represents the highest oligosaccharide yield and specific rate from cellulose for mesophilic bacterial monocultures reported so far. The results demonstrate that S. flexneri G3 is capable of rapid conversion of cellulose to oligosaccharides, with potential biofuel applications under mesophilic conditions.     

Characterization of the cellulolytic enzyme system from the brown-rot fungus Coniophora puteana

Summary The cellulolytic enzymes of various strains of the brown-rot fungus Coniophora puteana were studied. The organism was grown in an air-lift fermentor in mineral medium containing glucose, cellobiose or amorphous cellulose. The specific growth rate varied between 0.082 and 0.062 h^–1. On amorphous cellulose as sole carbon source, the organism secreted various proteins, some of which were characterized. The mixture contained inter alia four endocellulases, two exo-cellobiohydrolases and a cellobiose dehydrogenase. Three endocellulases (named type I) were active on soluble cellulose derivatives but inactive on p-nitrophenyllactoside (p-NPL), whereas a fourth endocellulase (named type II) was active on both. The two exo-cellobiohydrolases released cellobiose from amorphous cellulose; they were inactive on soluble cellulose derivatives but hydrolyzed p-NPL with strong cellobiose inhibition. A cellobiose dehydrogenase having spectral characteristics compatible with a flavo b-cytochrome was also identified. Neither the exo-cellobiohydrolase nor the type II endocellulase were secreted during growth on cellobiose whereas type I endocellulases and cellobiose dehydrogenase were formed at a reduced rate. No formation of cellulolytic enzymes was observed during growth on glucose alone. Correspondence to: G. Canevascini     

Synergistic saccharification, and direct fermentation to ethanol, of amorphous cellulose by use of an engineered yeast strain codisplaying three types of cellulolytic enzyme

A whole-cell biocatalyst with the ability to induce synergistic and sequential cellulose-degradation reaction was constructed through codisplay of three types of cellulolytic enzyme on the cell surface of the yeast Saccharomyces cerevisiae. When a cell surface display system based on alpha-agglutinin was used, Trichoderma reesei endoglucanase II and cellobiohydrolase II and Aspergillus aculeatus beta-glucosidase 1 were simultaneously codisplayed as individual fusion proteins with the C-terminal-half region of alpha-agglutinin. Codisplay of the three enzymes on the cell surface was confirmed by observation of immunofluorescence-labeled cells with a fluorescence microscope. A yeast strain codisplaying endoglucanase II and cellobiohydrolase II showed significantly higher hydrolytic activity with amorphous cellulose (phosphoric acid-swollen cellulose) than one displaying only endoglucanase II, and its main product was cellobiose; codisplay of beta-glucosidase 1, endoglucanase II, and cellobiohydrolase II enabled the yeast strain to directly produce ethanol from the amorphous cellulose (which a yeast strain codisplaying beta-glucosidase 1 and endoglucanase II could not), with a yield of approximately 3 g per liter from 10 g per liter within 40 h. The yield (in grams of ethanol produced per gram of carbohydrate consumed) was 0.45 g/g, which corresponds to 88.5% of the theoretical yield. This indicates that simultaneous and synergistic saccharification and fermentation of amorphous cellulose to ethanol can be efficiently accomplished using a yeast strain codisplaying the three cellulolytic enzymes.     

Influence of the presence of Zymomonas anaerobia on the conversion of cellobiose, glucose, and xylose to ethanol by Clostridium saccharolyticum

To convert sugar mixtures containing cellobiose, glucose, and xylose to ethanol in a single step, the possibility of using a coculture consisting of Clostridium saccharolyticum and Zymomonas anaerobia was studied. In monoculture, C. saccharolyticum utilized all three sugars; however, it preferentially utilized glucose and produced acetic acid in addition to ethanol. The formation of acetic acid from the metabolism of glucose inhibited the growth of C. saccharolyticum and, consequently, the utilization of cellobiose and xylose. In monoculture, Z. anaerobia utilized glucose at a rate of 50 g/L day, but it did not ferment cellobiose or xylose. In coculture, Z. anaerobia converted most of the glucose to ethanol during the lag phase of growth of C. saccharolyticum, which then converted cellobiose and xylose to ethanol. The use of this coculture increased both the rate and the efficiency of the conversion of these three sugars to ethanol, and produced relatively small amounts of acetic acid.     

Bioconversion of Cellulose to Acetate with Pure Cultures of Ruminococcus albus and a Hydrogen-Using Acetogen

Bioconversion of cellulose to acetate was accomplished with cocultures of two organisms. One was the cellulolytic species Ruminococcus albus. It ferments crystalline cellulose (Avicel) to acetate, ethanol, CO(inf2), and H(inf2). The other organism (HA) obtains energy for growth by using H(inf2) to reduce CO(inf2) to acetate. HA is a gram-negative coccobacillus that was isolated from horse feces. Coculture of R. albus with HA in batch or continuous culture alters the fermentation products formed from crystalline cellulose by the ruminococcus via interspecies H(inf2) transfer. The major product of the fermentation by R. albus and HA coculture is acetate. High concentrations of acetate (333 mM) were obtained when batch cocultures grown on 5% cellulose were neutralized with Ca(OH)(inf2). Continuous cocultures grown at retention times of 2 and 3.1 days produced 109 and 102 mM acetate, respectively, when fed 1% cellulose with utilization of 84% of the substrate.