l-Homoserine Fermentation

In the course of studies on “negative feedback control” mechanisms caused by threonine and methionine in l-homoserine fermentation with Micrococcus glutamicus 534-Co147 culture, l-homoserine dehydrogenase was first found to occur in the culture, and effects of various amino acids on the formation and action of the enzyme were then investigated. The result was that l-homoserine dehydrogenase of the culture was repressed by methionine on the one hand, and inhibited by threonine on the other. β-Aspartokinase was found not to be repressed by methionine. From these findings, the sites at which the “negative feedback control” mechanisms work were discussed.     

l-Tryptophan Production by 5-Methyltryptophan-resistant Mutants of Glutamate-producing Bacteria

1. Some of 5-methyltrypotophan (5MT)-resistant mutants derived from glutamate-producing bacteria such as Brevibacterium flavum, Corynebacterium acetoglutamicum and Micrococcus glutamicus produced a small amount of l-tryptophan, while tyrosine and phenylalanine auxotrophs of B. flavum did not.

2. 5-MT-resistant mutant derived from the auxotroph for tyrosine and phenylalanine produced 390 mg/liter of l-tryptophan at most. A mutant resistant to a higher concentration of 5MT, which was derived from a tyrosine and phenylalanine auxotrophic mutant which was resistant to a low concentration of 5MT, produced 660 mg/liter of l-tryptophan. Using this mutant, the effects of the concentrations of components of the culture medium on the l-tryptophan production were examined. The high concentration of l-tyrosine, but not l-phenylalanine, inhibited the l-tryptophan production. Using the improved culture medium, this strain produced 1.9 g/liter of l-tryptophan.     

Production of l-Threonine by Analog-resistant Mutants

Mutants resistant to α-amino-β-hydroxyvaleri0c acid (AHV) were derived from various bacteria which belong to Corynebacterium, Brevibacterium, Arthrobacter, Microbacterium, or Bacillus by mutational treatment with N-methyl-N′-nitro-N-nitrosoguanidine(NTG), and screened for their ability to produce l-threonine. A number of l-threonine producers were obtained from each group of bacteria. Among them, the mutants derived from C. glutamicum KY9159(Met^?) were further mutagenized with NTG to derive thialysine(S-Lys)-resistant mutants. An AHV-resistant mutant, KY10484 was proved to be much more sensitive to the growth inhibition by thialysine than the parent strain, KY9159. From KY10484, a number of AHV- and thialysine-resistant mutants were derived. Approximately a half of these mutants were found to produce more l-threonine than KY10484. Among these mutants, KY10440 (Met^?, AHV^R, s-Lys^R) was used to investigate the cultural conditions for l-threonine production. The growth of KY10440 decreased largely with addition of l-homoserine, a threonine precursor. l-Asparagine, l-cystine, l-glutamine or l-arginine partially reversed the inhibitory effect of l-homoserine. Addition of these amino acids at low level led to increase l-threonine production. The amount of l-threonine accumulation reached to a level of 14mg/ml with a medium containing 10% glucose and to a level of 10 mg/ml with a medium containing 5% molasses (as glucose).

Another AHV- and thialysine-resistant mutant, KY10251 which was also derived from KY9159 was found to produce both 9 mg/ml of l-threonine and 5.5 mg/ml of l-lysine in a culture broth.     

Production of O-Acetyl-l-homoserme by Methionine Analogresistant Mutants and. Regulation of Homosenne-O-transacetylase in Gorynebacterium glutamicum

A large amount of O-acetyl-l-homoserine (OAH) was found to be produced by trifluo-romethionine-resistant mutants derived from Corynebacterium glutamicum ESLR–146 (Thr?,ethionine^R, selenomethionine^R) and ET_zR–606(Thr?,ethionine^R, 1,2,4-triazole^R) by mutational treatment with ethyl methanesulfonate. Some cultural conditions for OAH production were examined with one of the mutants, ESLFR-736, which was derived from ESLR–146. Addition of l-methionine or l-serine decreased OAH production. Optimal level of l-threo- nine, a growth factor in ESLFR–736, for OAH production was about 200 μg/ml, and further addition of excess l-threonine repressed OAH production. Corn steep liquor (CSL) and yeast extract added simultaneously enhanced OAH production to a great extent. Thus, the amount of OAH production reached to a level of 10.5 mg/ml with a medium containing 10% glucose and 0.01 % of both CSL and yeast extract after 2 days incubation.

Cell-free extract of C. glutamicum catalyzed the formation of OAH from acetyl CoA and l-homoserine, while a corresponding reaction with succinyl CoA was hardly detected. These observations indicate that OAH but not O-succinyl-l-homoserine is an intermediate of l-methionine biosynthesis in C. glutamicum.

The regulation of homoserine-O-transacetylase was examined in a methionine requiring mutant of C. glutamicum. The enzyme activity was not inhibited by l-methionine, S-adenosyl-methionine and S-adenosylhomocysteine, separately or in combination. The synthesis of homoserine-O-transacetylase was strongly repressed by l-methionine. The enzyme level in an OAH producer, ESLFR–736, increased to about 2-fold of that in ESLR–146, the parental strain.     

Studies on the Synthesis of l-Amino Acids

l-Homoserine was prepared by the reduction of l-aspartic acid β-methyl ester with sodium borohydride in water solution without any racemization. The yield of l-homoserine was about 25% of the theoretical amount, and no product other than l-homoserine, l-aspartic acid and l-aspartic acid β-methyl ester was present in the reaction mixture. The low yield of l-homoserine was ascribed to the hydrolysis of the ester.

l-Azetidine-2-carboxylic acid could not be detected in the reaction mixture. In contrast with the reduction of l-glutamic acid γ-esters, the reduction of l-aspartic acid β-ester was not accompanied by the cyclization.     

Microbial Production of l-Threonine

l-Threonine production by strain BB-69, which was derived from Brevibacterium flavum No. 2247 as a α-amino-β-hydroxyvaleric acid resistant mutant and produced about 12 g/liter of l-threonine, was reduced by the addition of l-lysine or l-methionine in the culture medium. Many of lysine auxotrophs but not methionine auxotrophs derived from strain B–2, which produced about 7 g/liter of l-threonine, produced more l-threonine than the parental strain. Except only one methionine auxotroph (BBM–21), none of lysine and methionine auxotrophs derived from BB–69 produced more l-threonine than the parental strain. Homoserine dehydrogenase of crude extract from strain B–2 was inhibited by l-threonine more strongly than that from BB–69. Strain BBM–21, a methionine auxotroph derived from BB–69, produced about 18 g/liter of l-threonine, 50% more than BB–69, while accumulation of homoserine decreased remarkably as compared with BB–69. l-Threonine production by BBM–21 was increased by the addition of l-homoserine, a precursor of l-threonine, while that by BB–69 was not. No difference was found among BBM–21, BB–69 and No. 2247 in the degree of inhibition of homoserine kinase by l-threonine. l-Threonine production by revertants of BBM–21, that is, mutants which could grow without methionine, were all lower than that of BBM–21. Correlation between l-threonine production and methionine or lysine auxotrophy was discussed.     

Synthesis of γ-Glutamylpeptides by γ-Glutamylcysteine Synthetase from Proteus mirabilis

Syntheses of various γ-glutamylpeptides were examined taking use of the highly purified γ-glutamylcysteine synthetase from Proteus mirabilis. The accumulation of each peptide was measured after long time incubation, and good formation was observed in the synthesis of peptides of following amino acids, l-cysteine, l-α-aminobutyrate, l-serine, l-homoserine, glycine, l-alanine, l-norvaline, l-lysine, l-threonine, taurine and l-valine. Peptide syntheses were confirmed by analyses of the component amino acids, after hydrolysis of the peptides.

The structure of the glutamylpeptides, especially the peptide-linkage at the γ-carbonyl residue of l-glutamate, was determined by mass spectrometry of the N-trifluoroacetyl methylester derivatives of the glutamylpeptides. Enzymatic synthesis of γ-glutamyl-l-α-aminobutyrate was also confirmed by PMR spectrometry in the comparison with chemically synthesized compound.     

Studies on l-Glutamic Acid Fermentation

Micrococcus glutamicus, a glutamate-produeing bacterium, is known to have strong activity of l-glutamic acid dehydrogenase which requires NADP as co-enzyme. In this paper, the NADP-speeifie l-glutamic acid dehydrogenase was purified from M. glutamicus by means of heat treatment with sodium sulfate, precipitation with acetic acid and diethyl-amino-ethyl (DEAE) cellulose column chromatography. The activity of the purified enzyme preparation reached 200-fold as high as that of the crude extract. Some properties of the purified enzyme were investigated. As a result, it was found that the highly purified enzyme preparation acted not only on l-glutamic acid (l-GA) but also on α, ε-diaminopimelic acid (α, ε-DAP) in the presence of NADP. Some of the probable consideration for the dehydrogenation of l-GA and α, ε-DAP are noted.     

Production of l-DOPA by Mutants of Pseudomonas melanogenum

Several kinds of mutants of Pseudomonas melanogenum were derived by mutational treatment with N-methyl-N’-nitro-N-nitrosoguanidine, and selected for 3,4-dihydroxyphenyl-l-alanine (l-DOPA) production by newly devised screening method which was carried out on agar plates based on violet-black colour formation by the reaction of l-DOPA with iron ion. Mutants tested were; glucose-insensitive mutant, cysteine-insensitive mutant, 3-amino-tyrosine-resistant mutant and p-fluorophenylalanine-resistant mutant. Some colonies isolated by monocolony procedure without mutagenic treatment were also tested. Among the 3-aminotyrosine-resistant mutants many good l-DOPA producers were found.

An 3-aminotyrosine-resistant mutant, strain ATN–36, produced 14 to 15 mg/ml of l-DOPA from 26 mg/ml of l-tyrosine (68 % in molar conversion ratio). When the cell concentration in reaction mixture was increased to 4-times the concentration of culture broth, l-DOPA production reached to 21 mg/ml from 52 mg/ml of tyrosine. An enzymatic basis of the high l-DOPA productivity of the improved mutants was found to be due to the increased tyrosinase activity (150 to 160% of the parental strain) of the mutants.     

Cultural Conditions for l-Leucine Production by Strain No. 218, a Mutant of Brevibacterium lactofermentum 2256

The excellent l-leucine producing mutant No. 218, derived from a biotin requiring glutamic acid producing strain, is methionine and isoleucine auxotrophic. A suboptimum growth condition made by adding a limiting amount of isoleucine was necessary for the maximum production of l-leucine. On the other hand, methionine was indifferent to the productivity if sufficiently supplied for growth.

Biotin of more than 50 μg/liter caused the accumulation of l-leucine; less than 50 μg/liter, however, gave a drastic change in accumulation pattern from l-leucine to l-glutamic acid. Strain No. 218 produced 28 mg/ml of l-leucine after 72 hr cultivation when 13 % glucose was supplied as a carbon source, thus giving the yield of 21.6%.

Effects on l-leucine production of concentrations of inorganic salts, pH, temperature and aeration were also investigated.     

An Improved Synthesis of DL-Canavanine

Excellent l-proline producers were screened for among sulfaguanidine resistant mutants derived from three typical l-glutamic acid-producing bacteria: Brevibacterium flavum, B. lactofermentum, and C. glutamicum.

The best strain, No. 199, is a sulfaguanidine resistant mutant derived from an isoleucine auxotroph of B. flavum 2247 by nitrosoguanidine. Strain No. 199 produced 35 mg/ml of l-proline after 72 hr of cultivation with 10% glucose as a carbon source. The strain also accumulated purine bases such as adenine, guanine, and hypoxanthine, i.e., degradation products of purine nucleotides. In the mutant, 1.6 ~ 2.0 fold more intracellular ATP was found than that in the parent strain; it is a substrate of glutamate kinase relating to l-proline biosynthesis.

On the contrary, the levels of intracellular glutamic acid, a substrate of glutamate kinase, were similar among these strains.

It was confirmed that the increment of internal ATP, which was important in the l-proline production mechanism, was very effective in the improvement of l-proline producers.     

l-Isoleucine Production by Analog-resistant Mutants Derived from Threonine-producing Strain of Corynebacterium glutamicum

A thiaisoleucine-resistant mutant, ASAT–372, derived from a threonine producer of Corynebacterium glutamicum, KY 10501, produced 5 mg/ml each of l-isoleucine and l-threonine. l-Isoleucine productivity of ASAT–372 was improved stepwise, with concurrent decrease in threonine production, by successively endowing it with resistivity to such substances as ethionine, 4-azaleucine and α-aminobutyric acid. The mutant strain finally selected, RAM–83, produced 9.7 mg/ml of l-isoleucine with a medium containing 10% (as sugar) molasses.

l-Isoleucine production was significantly affected by the concentration of ammonium sulfate in the fermentation medium. At 4% ammonium sulfate l-isoleucine production was enhanced whereas l-threonine production was suppressed. At 2% ammonium sulfate l-threonine production was stimulated while l-isoleucine production decreased.     

l-Glutamate Formation from Hydrocarbons by Microorganisms

Large quantities of l-glutamic acid from liquid paraffins by microorganisms were produced with an addition of penicillin to the growing culture, and the action of penicillin to the glutamate production was studied. One of main effects of penicillin seems to exist in the cellular permeability of l-glutamic acid.     

Fermentative Production of l-Arginine

Most of the bacteria, which were examined for the sensitivity to l-arginine analogs (l-canavanine, l-homoarginine, d-arginine and arginine hydroxamate), were insensitive to the analogs at a concentration of 8 mg/ml. Corynebacterium glutamicum DSS-8 isolated as d-serine-sensitive mutant from an isoleucine auxotroph KY 10150, was found to be sensitive to d-arginine and arginine hydroxamate. Furthermore, DSS-8 produced l-arginine in a cultural medium. l-Arginine analog-resistant mutants were derived from DSS-8 by N-methyl-N′-nitro-N-nitrosoguanidine (NTG) treatment. Most of them were found to produce a large amount of l-arginine. An isoleucine revertant from one of these mutants produced 19.6 mg/ml of l-arginine in the medium containing 15% (as sugar) of molasses.

The mechanism of the sensitivity to l-arginine analogs and that of the production of l-arginine in the d-serine-sensitive mutant, DSS-8, were investigated. DSS-8 seems to be a mutant having increased permeability to d- and l-arginine.     

Conversion of the Extracellular Dextransucrase Isoenzymes from Leuconostoc mesenteroides NRRL B-1299

Effect of oxygen tension on l-lysine, l-threonine and l-isoleucine accumulation was investigated. Sufficient supply of oxygen to satisfy the cell’s oxygen demand was essential for the maximum production in each fermentation. The dissolved oxygen level must be controlled at greater than 0.01 atm in every fermentation, and the optimum redox potentials of culture media were above ?170 mV in l-lysine and l-threonine and above ?180 mV in l-isoleucine fermentations. The maximum concentrations of the products were 45.5 mg/ml for l-lysine, 10.3 mg/ml for l-threonine and 15.1 mg/ml for l-isoleucine. The degree of the inhibition due to oxygen limitation was slight in the fermentative production of l-lysine, l-threonine and l-isoleucine, whose biosynthesis is initiated with l-aspartic acid, in contrast to the accumulation of l-proline, l-glutamine and l-arginine, which is biosynthesized by way of l-glutamic acid.     

Biochemical Aspects of 2-Keto-l-gulonate Accumulation from 2,5-Diketo-d-gluconate by Corynebacterium sp. and Its Mutants

Corynebacterium sp. SHS 0007 accumulated 2-keto-l-gulonate and 2-keto-d-gluconate simultaneously with 2,5-diketo-d-gluconate utilization. This strain, however, possibly metabolized 2,5- diketo-d-gluconate through two pathways leading to d-gluconate as a common intermediate: via 2- keto-d-gluconate, and via 2-keto-l-gulonate, l-idonate and 5-keto-d-gluconate. A polysaccharide- negative, 2-keto-l-gulonate-negative and 5-keto-d-gluconate-negative mutant produced only calcium 2-keto-l-gulonate from calcium 2,5-diketo-d-gluconate, in a 90.5 mol% yield. The addition of a hydrogen donor such as d-glucose was essential for its production. This mutant possessed the direct oxidation route of d-glucose to d-gluconate, the pentose cycle pathway and a possible Embden-Meyerhof-Parnas pathway, indicating that d-glucose was metabolized through these three pathways and provided NADPH for the reduction of 2,5-diketo-d-gluconate.     

The Biosynthetic Control in Aromatic Amino Acid Producing Mutants of Corynebacterium glutamicum

Regulatory properties of the enzymes involved in aromatic amino acid biosynthesis in the mutant of Corynebacterium glutamicum which produces a large amount of aromatic amino acids were examined. A phenylalanine auxotrophic l-tyrosine producer, pr-20, had a 3-deoxy-d-arabinoheptulosonate-7-phosphate (DAHP) synthetase released from the feedback inhibition by l-phenylalanine, l-tyrosine and l-tryptophan and had a two-fold derepressed chorismate mutase. A pair of l-phenylalanine and l-tyrosine still strongly inhibited the chorismate mutase activity, though the enzyme was partially released from the inhibition by l-phenylalanine alone. A tyrosine auxotrophic l-phenylalanine producer, PFP-19-31, had a DAHP synthetase sensitive to the feedback inhibition by l-phenylalanine, l-tyrosine and l-tryptophan and had a prephenate dehydratase and a chorismate mutase both partially released from the feedback inhibition by l-phenylalanine. The mutant produced a large amount of prephenate as well as l-phenylalanine. A phenylalanine and tyrosine double auxotrophic l-tryptophan producer, Px-115-97, had an anthranilate synthetase partially released from the feedback inhibition by l-tryptophan and had a DAHP synthetase sensitive to the feedback inhibition. These data explained the mechanism of the production of aromatic amino acids by these mutants and supported the in vivo functioning of the control mechanisms of aromatic amino acid biosynthesis in C. glutamicum previously elucidated in vitro experiments.     

Taurine Levels in Some Tissues of Yellowtail (Seriola quinqueradiata) and Mackerel (Scomber japonicus)

The mechanism of stereospecific production of l-amino acids from the corresponding 5-substituted hydantoins by Bacillus brevis AJ-12299 was studied. The enzymes involved in the reaction were partially purified by DEAE-Toyopearl 650M column chromatography and their properties were investigated. The conversion of dl-5-substituted hydantoins to the corresponding l-amino acids consisted of the following two successive reactions. The first step was the ring-opening hydrolysis to N-carbamoyl amino acids catalyzed by an ATP dependent l-5-substituted hydantoin hydrolase. This reaction was stereospecific and the N-carbamoyl amino acid produced was exclusively the l-form. N-Carbamoyl-l-amino acid was also produced from the d-form of 5-substituted hydantoin, which suggests that spontaneous racemization occurred in the reaction mixture. In the second step, N-carbamoyl-l-amino acid was hydrolyzed to l-amino acid by an N-carbamoyl-l-amino acid hydrolase, which was also an l-specific enzyme. The ATP dependency of the l-5-substituted hydantoin hydrolase was supposed to be the limiting factor in the production of l-amino acids from the corresponding 5-substituted hydantoins by this bacterium.     

Mechanism of l-Threonine and l-Lysine Production by Analog-resistant Mutants of Corynebactemum glutamicum

Homoserine dehydrogenases and aspartokinases in l-threonine- or l-threonine and l-lysine-producing mutants derived from Corynebacterium glutamicum KY 9159 (Met^?) were studied with respect to the sensitivity to the inhibition by end products, l-threonine and l-lysine. The activities of homoserine dehydrogenases in the mutants which produced l-threonine or l-threonine and l-lysine were slightly less susceptible to the inhibition by l-threonine than the activity in the parent strain, KY 9159. The aspartokinases in the threonine-producing mutants, KY 10484 and KY 10230, which were resistant to α-amino-β-hydroxylvaleric acid (AHV, a threonine analog) and more sensitive to thialysine (a lysine analog) than the parent, were sensitive to the concerted feedback inhibition by l-lysine and l-threonine by about the same degree as KY 9159. The aspartokinase in an AHV- and thialysine-resistant mutant, KY 10440, which was derived from KY 10484 and produced about 14 mg/ml of l-threonine in a medium containing 10% glucose was less susceptible to the concerted feedback inhibition than KY 10484 or KY 9159, although the activity was still under the feedback control. In the parent strain, l-threonine activated aspartokinase activity in the absence of ammonium sulfate, an activator of the enzyme, but partially inhibited the activity in the presence of the salt. On the other hand, the enzyme of KY 10440 was activated by l-threonine either in the presence or in the absence of the salt. In another AHV- and thialysine-resistant mutant, KY 10251, which was derived from KY 10230 and produced both 9 mg/ml of l-threonine and 5/5 mg/ml of l-lysine, l-threonine and l-lysine simultaneously added hardly inhibited the activity of aspartokinase.

Implications of these results are discussed in relation to l-threonine or l-lysine production, AHV or thialysine resistance and regulation of l-threonine biosynthesis in these mutants.     

Regulatory Properties of Prephenate Dehydrogenase and Prephenate Dehydratase from Corynebacterium glutamicum

Regulatory properties of the enzymes in l-tyrosine and l-phenyalanine terminal pathway in Corynebacterium glutamicum were investigated. Prephenate dehydrogenase was partially feedback inhibited by l-tyrosine. Prephenate dehydratase was strongly inhibited by l-phenylalanine and l-tryptophan and 100% inhibition was attained at the concentrations of 5 × 10^?2mm and 10^?1mm, respectively. l-Tyrosine stimulated prephenate dehydratase activity (6-fold stimulation at 1 mm) and restored the enzyme activity inhibited by l-phenylalanine or l-tryptophan. These regulations seem to give the balanced synthesis of l-tyrosine and l-phenyl-alanine. Prephenate dehydratase from C. glutamicum was stimulated by l-methionine and l-leucine similarly to the enzyme in Bacillus subtilis and moreover by l-isoleucine and l-histidine. C. glutamicum mutant No. 66, an l-phenylalanine producer resistant to p-fluorophenyl-alanine, had a prephenate dehydratase completely resistant to the inhibition by l-phenylalanine and l-tryptophan.