l-Glutamic Acid Fermentation with Molasses

When an l-Glutamic acid (l-GA)-forming bacterium, Microbacterium ammoniaphilum, was cultured in the molasses medium with the addition of penicillin to accumulate large quantity of l-GA extracellularly, no significant differences were observed in the phospholipid quantity and the fatty acid composition which were found between the l-GA-accumulating cells grown either in the molasses medium with addition of polyoxyethylene fatty acid ester (POEFE) or in the glucose medium with the addition of biotin.

Moreover, it was shown that, in the molasses-POEFE system, the amount of l-GA accumulated was nearly constant, independent of the extracellular osmotic pressure caused by the presence of NaNO₃ or β-alanine, while, in the molasses-penicillin system, the amount varied inversely to the osmotic pressure.

From these results, it is assumed that either chemical or mechanical process can eliminate the permeability barrier in the cell membrane, thus allowing the extracellular accumulation by l-GA-forming bacteria.     

l-Glutamic Acid Fermentation

Structure of a sugar lipid produced by an oleic acid-requiring mutant of Brevibacterium thiogenitalis was studied and established as (I).

Relation between biotin and oleic acid was studied using a biotin-requiring organism accumulating l-glutamic acid and its blocked mutants lacking the biosynthetic system of biotin or/and oleic acid. The results support the following considerations. Biotin is not formed from oleic acid and does not substantially affect the growth of l-glutamic acid-accumulating bacteria and their productivity of l-glutamic acid.

Consequently, biotin serves only for the synthesis of fatty acids in the present organisms. The essential factor for their growth and metabolism is an unsaturated fatty acid like oleic acid and not biotin. And also, saturated fatty acids have substantially no relation with their growth and metabolism like accumulation of l-glutamic acid.     

Studies on l-Glutamic Acid Fermentation

Micrococcus glutamicus, a glutamate-produeing bacterium, is known to have strong activity of l-glutamic acid dehydrogenase which requires NADP as co-enzyme. In this paper, the NADP-speeifie l-glutamic acid dehydrogenase was purified from M. glutamicus by means of heat treatment with sodium sulfate, precipitation with acetic acid and diethyl-amino-ethyl (DEAE) cellulose column chromatography. The activity of the purified enzyme preparation reached 200-fold as high as that of the crude extract. Some properties of the purified enzyme were investigated. As a result, it was found that the highly purified enzyme preparation acted not only on l-glutamic acid (l-GA) but also on α, ε-diaminopimelic acid (α, ε-DAP) in the presence of NADP. Some of the probable consideration for the dehydrogenation of l-GA and α, ε-DAP are noted.     

Studies on the Polymorphism of l-Glutamic Acid

The effects on the polymorphic crystallization of l-glutamic acid were examined of many substances including amino acids, inorganic salts, surface active agents, and sodium salt or hydrochloride of l-glutamic acid, when contained in the mother liquor.

The co-existence of amino acids, especially of l-aspartic acid, l-phenylalanine, l-tyrosine, l-lcucine and l-cystine contributed to the crystallization of l-glutamic acid in α-form, and these amino acid showed an inhibitory action on the transition of α-crystals as the solid phase in the aqueous solution, to β-crystals.

In the presence of a large amount of l-glutamate or the hydrochloride at the time of nucleation of l-glutamic acid, mostly β-crystals appeared even in the presence of the amino acids named above.     

Induction of Antibiotic Formation in Streptomyces sp. No. 362 by the Change of Cellular Fatty Acid Spectrum

Microorganisms which require oleic acid for the formation of antibiotics were screened. Streptomyces sp. No. 362, one of the selected organisms, produced antimicrobial substances only when oleic acid, palmitic acid or the high concentration of l-glutamic acid (or l-glutamine) was supplemented to the medium. The cellular fatty acid composition was changed by the supplement of these fatty acids, but not by l-glutamic acid (or l-glutamine). Antibiotic-producing cells had about 4 to 10 times larger amino acid pools, especially l-glutamic acid pool, and hexosamine pools. The ability for l-glutamate uptake of cells grown in the oleic or palmitic acid supplemented medium was markedly enhanced and the efflux of the accumulated l-glutamate was reduced. The antibiotic produced by this strain was identified as one of the streptothricin-group antibiotics and the role of these additives in the antibiotic formation is discussed.     

l-Glutamic Acid Fermentation with Molasses

Conditions suitable for the cell wall lysis of a l-glutamate-producing bacterium, Microbacterium ammoniaphilum, by egg white lysozyme were studied, in order to make clear the correlation of the fatty acid composition of the cellular fractions and the extracellular accumulation of l-glutamate,

The cell wall of a phage-resistant strain was recognized to be almost completely lyzed by the lysozyme.

Using this result, the relationship between the fatty acid composition of each fraction and extracellular accumulation of l-glutamate was investigated, and the following thesis was proposed: The extracellular accumulation of l-glutamate in large quantity took place when the molar ratio of saturated/unsaturated fatty acid in the cell membrane fraction was above 1.     

Relation between Fatty Acid Composition of Cellular Phospholipids and the Excretion of L-Glutamic Acid by a Glycerol Auxotroph of Corynebacterium alkanolyticum

Relation between fatty acid composition of cellular phospholipids and the excretion of L-glutamic acid was investigated using Corynebacterium alkanolyticum GL–21 (a glycerol auxotroph).

When grown on n-hexadecane, the proportion of unsaturated fatty acids was higher in L-glutamic acid-accumulating cells than in L-glutamic acid-nonaccumulating cells. When grown on fructose or acetic acid, the reverse relation was observed. Moreover, cells containing no oleic acid produced L-glutamic acid from n-pentadecane.

These results suggest that the membrane permeability to L-glutamic acid is not always controlled by the cellular content of unsaturated fatty acids.     

Change in Permeability to l-Glutamic Acid in the Glycerol Auxotroph GL-21

In this study, the mechanism of the extracellular accumulation of l-glutamic acid by the glycerol auxotroph was partially clarified. Whenever Corynebacterium alkanolyticum GL–21 (glycerol auxotroph) accumulated a large amount of l-glutamic acid in the fermentation broth, the content of its cellular phospholipids was not more than 50% of that of C. alkanolyticum No. 314 (prototroph).

Moreover, biotin, oleic acid or thiamine had no influence on the cellular phospholipid content of the auxotroph.

Under limited supply of glycerol, the efflux of l-glutamic acid in the auxotroph was extremely enhanced, but its enzyme activities participating in l-glutamic acid biosynthesis remained at the same level as those of the prototroph.

From the results, it is considered that the regulation of phospholipid content gave rise to the destruction of the permeability barrier to l-glutamic acid in the cell membrane.     

Studies on Metabolism of Pyrrolidone Carboxylic Acid in Bacteria

The present investigation is concerned with l-glutamic acid production in the presence of pyrrolidone carboxylic acid and glucose in Bacillus megaterium st. 6126. This strain does not grow on dl-pyrrolidone carboxylic acid (dl-PCA)¹⁾ as the sole source of carbon and nitrogen. The optimal concentration of yeast extract required for the maximal production of l-glutamic acid was 0.005% under the conditions used. As the yeast extract concentration was increased, growth increased proportionally; but the l-glutamic acid production did not exceed the control’s to which glucose and ammonium chloride had been added. l-Glutamic acid produced by both growing cultures and resting cells was derived from glucose and ammonium salt of dl-PCA. Isotope experiments suggested that the l-glutamic acid produced was partially derived from ammonium salt of dl-PCA in the growing culture which had been supplemented with d-glucose-U-¹⁴C or dl-PCA-1-¹⁴C and that ammonium salt of dl-PCA was consumed as the source of nitrogen and carbon for l-glutamic acid.     

Studies on Oxidation-Reduction Potentials (ORP) of Microbial Cultures

At maximum production of l-glutamic acid, the oxidation-reduction potential of the culture broth in l-glutamic acid fermentation showed a stable value of 9.0 to 9.6 as rH value. When biotin concentration in the medium was high (40γ/liter), the production of l-glutamic acid decreased, and the rH was 8.0 and it was out of accordance with that of the control (biotin-poor; 2γ/liter). Under “less-aerobic” conditions, its rH rose to 10.4.

From these results, it was concluded that the rH during maximum production of l-glutamic acid showed a stable value affected actively by the redox system, l-glutamic acid/α-ketoglutaric acid and      

Fermentative Production of l-Glutamine by Sulfaguanidine Resistant Mutants Derived from l-Glutamate Producing Bacteria

Excellent l-glutamine producers were screened for among sulfaguanidine resistant mutants derived from the wild type l-glutamic acid-producing bacteria, Brevibacterium flavum, Brevibacterium lac to fermentum, Corynebacterium glutamicum and Microbacterium ammoniaphilum.

The best strain, No. 1~60, was a sulfaguanidine resistant mutant derived from B. flavum 2247 by mutation. Strain No. 1~60 accumulated 41.0 mg/ml of l-glutamine after 48 hr of cultivation from 10% glucose as a carbon source. This yield was the highest among those so far reported.

The addition of Mn^{2 +} (2 ppm) to the standard medium for B. flavum 2247 decreased the l- glutamine production and increased the l-glutamic acid excretion markedly. On the contrary, strain 1 —60 was not affected the Mn²⁺ (2 ppm) addition at all.

Glutamate kinase activity and the intracellular content of ATP in sulfaguanidine resistant mutant No. 1~60 were higher than those in the parent strain, B. flavum 2247.

It was confirmed that the increase in glutamate kinase and the increase in internal ATP, which were important for the l-glutamine synthesis, were very effective for the improvement of l-glutamine-producing mutants.     

Studies on the Synthesis of l-Amino Acids

l-Homoserine was prepared by the reduction of l-aspartic acid β-methyl ester with sodium borohydride in water solution without any racemization. The yield of l-homoserine was about 25% of the theoretical amount, and no product other than l-homoserine, l-aspartic acid and l-aspartic acid β-methyl ester was present in the reaction mixture. The low yield of l-homoserine was ascribed to the hydrolysis of the ester.

l-Azetidine-2-carboxylic acid could not be detected in the reaction mixture. In contrast with the reduction of l-glutamic acid γ-esters, the reduction of l-aspartic acid β-ester was not accompanied by the cyclization.     

Culture Conditions for the Production of l-Glutamic Acid from n-Paraffins by Glycerol Auxotroph GL-21

A novel process for the microbial production of l-glutamic acid on an industrial scale was successfully established by using a glycerol auxotroph.

The most suitable carbon source for producing L-glutamic acid was n-paraffins (C₁₃–C₁₅). The production of L-glutamic acid was not affected by a large amount of biotin or oleic acid in the absence of penicillin, and occurred maximally at the glycerol concentration of 0.02% at pH 6.6. The most effective temperature was 28°C.

Under optimal conditions in a 200 liter fermentor, the mutant produced 72 g/liter of L-glutamic acid. On the other hand, the parent produced 53 g/liter of L-glutamic acid in the presence of penicillin.

It is believed that the low productivity of L-glutamic acid by the parent strain was mainly due to the occurrence of the marked decrease in the viable cell counts at the later phase of the fermentation caused by the action of penicillin added.     

Studies on l-Glutamic Acid Fermentation

The authors have carried out a series of studies on l-glutamic acid fermentation with a strain of Brevibacterium divaricatum nov. sp. in the previous papers.

In this paper, some metabolism of l-glutamic acid and oxidative decomposition of several organic acids concerning the tricarboxylic acid cycle by the resting cells have been studied. The results suggest that l-glutamic acid is one of the final fermentative products of this bacterium, and the tricarboxylic acid cycle is working as a glutamic acid forming cycle.

The presence of glucokinase, phosphoglucoisomerase, phosphofructokinase, aldolase, DPN-linked glyceraldehyde-3-phosphate dehydrogenase, and TPN-linked glucose-6-phosphate dehydrogenase in cell-free extracts of this bacterium was also demonstrated.     

Isolation and Identification of O-Acetyl and 12-Hydroxyradiclonic Acids

An N-acetylglutamate-acetylornithine acetyltransferase-deficient arginine-requiring mutant AA–1, was derived from an l-arginine producer of Corynebacterium glutamicum. It accumulated a large amount (30 mg per ml) of l-glutamic acid and a small amount (1.2 mg per ml) of N^α-acetylornithine, an intermediate of arginine biosynthesis, in the culture medium.

The production of N^α-acetylornithine by AA–1 was not affected by the concentration of l-arginine in the medium, whereas that of l-glutamic acid was inhibited by a high concentration of l-arginine in the medium containing excess biotin.     

Cultural Conditions for l-Leucine Production by Strain No. 218, a Mutant of Brevibacterium lactofermentum 2256

The excellent l-leucine producing mutant No. 218, derived from a biotin requiring glutamic acid producing strain, is methionine and isoleucine auxotrophic. A suboptimum growth condition made by adding a limiting amount of isoleucine was necessary for the maximum production of l-leucine. On the other hand, methionine was indifferent to the productivity if sufficiently supplied for growth.

Biotin of more than 50 μg/liter caused the accumulation of l-leucine; less than 50 μg/liter, however, gave a drastic change in accumulation pattern from l-leucine to l-glutamic acid. Strain No. 218 produced 28 mg/ml of l-leucine after 72 hr cultivation when 13 % glucose was supplied as a carbon source, thus giving the yield of 21.6%.

Effects on l-leucine production of concentrations of inorganic salts, pH, temperature and aeration were also investigated.     

l-Glutamic Acid Fermentation

It is well known that biotin has a marked effect on l-glutamic acid fermentation.

The authors have intended to find strains which are independent of the amounts of biotin in the culture medium. As a result, oleic acid-requiring mutants were obtained from a strain of Brevibacterium thiogenitalis which is an auxotroph for biotin. The growth of the mutant was remarkably stimulated by Tween 20, 40, 60, Ca ions and a small amount of corn steep liquor. And also, the mutant was found to have lost its requirement for biotin and showed growth response only to oleic acid or unsaturated fatty acids.

The effect of biotin, oleic acid and other unsaturated fatty acids on the production of l-glutamic acid was investigated by using an oleic acid-requiring mutant of Brevibacterium thiogenitalis No. 653. The results described in the present paper showed that the oleic acid-requiring mutant D-248 produced a large amount of l-glutamic acid in the excess biotin-contaming media, and that oleic acid seemed to be completely replaced by other unsaturated fatty acids such as palmitoleic acid and linoleic acid.     

Metabolism of l-Theanine,d-Theanine and the Related Compounds in Bacteria

Some strains of Pseudomonas was found capable of utilizing l-theanine or d-theanine as a sole nitrogen and carbon source. The cell-free extract catalyzes the hydrolysis of the amide group of the compounds and the hydrolase activity was influenced remarkably by the nitrogen source in the medium. l-Theanine and d-theanine were hydrolyzed to yield stoichiometrically l-glutamic acid and d-glutamic acid, respectively, and ethylamine, which were isolated from the reaction mixture and identified.

The theanine hydrolase of Pseudomonas aeruginosa was purified approximately 200-fold. It was shown that the activities of l-theanine hydrolase, d-theanine hydrolase and the heat-stable l-glutamine hydrolase and d-glutamine hydrolase are ascribed to a single enzyme, which may be regarded as a γ-glutamyltransferase from the point of view of the substrate specificity and the properties. This theanine hydrolase catalyzed the transfer of γ-glutamyl moiety of the substrates and glutathione to hydroxylamine. l-Glutamine and d-glutamine were hydrolyzed by the theanine hydrolase and also by the heat-labile enzyme of the same strain of Pseudomonas aeruginosa, whose properties resembled the common glutaminase.     

Utilization of Hydrocarbons by Microorganisms

As already reported, strain S1OB1 was found to accumulate l-glutamic acid in a thiamine-deficient medium at the sole expense of hydrocarbon. In order to elucidate the biosynthetic pathway of l-glutamic acid, first of all, the incorporation of molecular oxygen into l-glutamic acid was examined. l-Glutamic acid accumulated under ¹⁸O-enriched atmosphere was separated, purified, identified and found to have been enriched with ¹⁸O. This results indicate the occurrence of oxygenase reaction involving addition of molecular oxygen. From a postulated biosynthetic pathway of l-glutamic acid, theoretical ¹⁸O content was calculated and compared with experimental one. ¹⁸O content of cells grown on n-alkane or glucose was also examined.     

Conversion of the Extracellular Dextransucrase Isoenzymes from Leuconostoc mesenteroides NRRL B-1299

Effect of oxygen tension on l-lysine, l-threonine and l-isoleucine accumulation was investigated. Sufficient supply of oxygen to satisfy the cell’s oxygen demand was essential for the maximum production in each fermentation. The dissolved oxygen level must be controlled at greater than 0.01 atm in every fermentation, and the optimum redox potentials of culture media were above ?170 mV in l-lysine and l-threonine and above ?180 mV in l-isoleucine fermentations. The maximum concentrations of the products were 45.5 mg/ml for l-lysine, 10.3 mg/ml for l-threonine and 15.1 mg/ml for l-isoleucine. The degree of the inhibition due to oxygen limitation was slight in the fermentative production of l-lysine, l-threonine and l-isoleucine, whose biosynthesis is initiated with l-aspartic acid, in contrast to the accumulation of l-proline, l-glutamine and l-arginine, which is biosynthesized by way of l-glutamic acid.