Production of O-Succinyl-l-homoserine by Auxotrophic Mutants of Aerobacter aerogenes

Ten of Nineteen methionine-requiring mutants isolated from Aerobacter aerogenes ATCC 8308 by treatment with N-methyl-N′-nitro-N-nitrosoguanidine were found to accumulate in a culture broth a large amount of O-succinyl-l-homoserine (OSH) which was an intermediate in the biosynthesis of methionine in Escherichia coli and Salmonella typhimurium. OSH was isolated from the culture broth and identified by the behavior in paper chromatography, elementary analysis, melting point, optical density and infrared spectrum. Among these mutants, A. aerogenes KY 7056 which responds to methionine, homocysteine or systathionine was used to investigate culture conditions for OSH production. The amount of OSH accumulation reached a level of 8.36 mg/ml with the medium containing 10% fructose and 1% ammonium sulfate. Addition of l-homoserine (10 mg/ml) increased the amount of OSH accumulation to a level of 15.8 mg/ml. Methionine or cystathionine suppressed the accumulation of OSH. Addition of δ-hydroxylysine to the fermentation medium almost abolished the OSH accumulation.     

Production of 2-Ketogluconic Acid by Serratia marcescens

Production of 2-ketogluconic acid from glucose by fermentation with Serratia marcescens NRRL B-486 was studied in 20-liter stainless-steel fermentors. Conditions for 2-ketogluconic acid production included the following: glucose-salt medium, aeration rate of 0.75 volumes per volume per minute, agitation rate of 400 rev/min, temperature of 30 C, CaCO₃ to neutralize the acid formed, and a 5% (v/v) inoculum. Foaming was controlled with an antifoam agent added at intervals during the fermentation. When 120 g per liter of glucose were supplied, 95 to 100% yields of 2-ketogluconic acid were obtained in 16 hr. Larger amounts of glucose could be used in the fermentation provided that the carbohydrate was fed continuously. Continuous feeding of glucose to a total amount of 180 g per liter gave 95 to 100% yields of 2-ketogluconic acid in 24 hr; feeding glucose to a total amount of 240 g per liter gave 85 to 90% yields in 32 to 40 hr.     

粘质沙雷氏菌发酵生产D-乳酸的研究

本文对粘质沙雷氏菌发酵生产D-乳酸进行了研究。以粘质沙雷氏菌G1(Serratia marcescens G1)为出发菌种,摇瓶试验确定了发酵培养方式:前12 h为菌体生长阶段,有氧培养,温度28℃,pH值7.0;后36 h为D-乳酸合成积累阶段,无氧培养,温度44℃,pH值6.0。且发现使用葡萄糖为碳源时更有利于D-乳酸的合成积累。采用缺失2,3-丁二醇合成能力的基因工程菌株R1为出发株,经筛选后得到耐受较高浓度乳酸盐的菌株R150,以R150为发酵菌种,在3.7 L发酵罐上采用两阶段发酵法,并通过增加起始菌体浓度的方法,发酵生成的D-乳酸浓度达到83.5 g/L,光学纯度达到98.9%。本研究成果为使用粘质沙雷氏菌发酵生产D-乳酸的深入研究打下了基础。     

Production of l-Threonine by Auxotrophic Mutants of Escherichia coli

Two auxotrophic mutants of Escherichia coli have been shown to accumulate significant amounts of l-threonine in the culture medium. One mutant, 13071, is deficient in α,ε-diaminopimelic acid (DAP), and the other, 13070, is deficient in both DAP and methionine.     

Histidine Production by Auxotrophic Histidine Analog-resistant Mutants of Corynebacterinm glutamicum

Corynebacterium glutamicum mutants carrying both auxotrophy and histidine analog-resistance were derived by a mutagenic treatment, and their histidine productivity was compared with that of a triazolealanine (TRA)-resistant histidine producer, C. glutamicum KY-10260. As a result, a leucine auxotrophic TRA-resistant mutant, Rα-88 was selected out of 164 auxotrophic derivatives of KY-10260. It produced histidine at a distinctly higher concentration than the parent strain under every condition tested. The concentration reached 11 mg/ml or 5.8% (w/w) of the initial sugar. Addition of an excessive amount of leucine to the medium inhibited the histidine production together with the by-production of valine by this mutant. Thiazolealanine-resistant mutants derived from a tyrosine auxotroph, a phenylalanine auxotroph and a tryptophan auxotroph gave the same or lower production in comparison with KY-10260.     

Mutants of Aerobacter aerogenes capable of utilizing xylitol as a novel carbon

Wild-type Aerobacter aerogenes 1033 is unable to utilize xylitol. A succession of mutants was isolated capable of growth on this compound (0.2%) at progressively faster rates. Whereas the ability to utilize xylitol was achieved in the first-stage mutant (X1) by constitutive production of ribitol dehydrogenase (for which xylitol is a substrate but not an inducer), the basis for enhanced utilization of xylitol in the second-stage mutant (X2) was an alteration of ribitol dehydrogenase. This enzyme was purified from the various mutants. The apparent K(m) for xylitol was 0.12 m with X2 enzyme and 0.29 m with X1 enzyme. The X2 enzyme was also less heat stable and, at 0.05 m substrate concentration, had a higher ratio of activity with xylitol compared to ribitol than did the X1 enzyme. The third mutant (X3), with an even faster growth rate on xylitol, produced a ribitol dehydrogenase indistinguishable physically or kinetically from that of X2. However, X3 produced constitutively an active transport system which accepts xylitol. The usual function of this system is apparently for the transport of d-arabitol since the latter is not only a substrate but also an inducer of the transport system in parental strains of X3. The sequence of mutations described herein illustrates how genes belonging to different metabolic systems can be mobilized to serve a new biochemical pathway.     

Pyruvate metabolism by aminopterin-inhibited Aerobacter aerogenes

1. The synthesis and utilization of both alanine (by reductive amination, oxidative deamination and transamination) and valine (by transamination only) in Aerobacter aerogenes are unaffected by aminopterin. These amino acids, which accumulate in aminopterin-treated cultures of this organism, are therefore considered to be formed as secondary products from the excess of pyruvate that also accumulates. 2. Oxidative metabolism of pyruvate and the synthesis of acetylmethylcarbinol by A. aerogenes cells are unaltered by growth in the presence of aminopterin. 3. Cells from static and anaerobic cultures that have been treated with the folic acid antagonist in the early exponential phase have a decreased ability to cleave pyruvate to acetate and formate, and to effect the exchange of formate with the carboxyl group of pyruvate. 4. 3-Methyl-2-oxobutanoate, the keto acid precursor of valine, cannot replace pyruvate as substrate in either the phosphoroclastic or the exchange reaction.     

Direct Colony Thin-Layer Chromatography and Rapid Characterization of Serratia marcescens Mutants Defective in Production of Wetting Agents

A bacterial mass (ca. 1 mg) was placed directly on a thin-layer chromatography plate and developed shortly in chloroform-methanol (2:1, vol/vol). After being dried, the bacterial mass was developed in chloroform-methanol-5 M ammonia (80:25:4, vol/vol). The obtained chromatogram indicated the characteristic lipid compositions of the bacteria. So, it became possible to examine bacterial colonies at once for the identification of mutants defective in the production of specific lipids.     

Production of Tumor-Inhibitory L-Asparaginase by Submerged Growth of Serratia marcescens

Production of a tumor-inhibitory asparaginase by submerged fermentation with Serratia marcescens ATCC 60 was studied to ascertain optimal nutritional conditions for large-scale production leading to enzyme purification studies. Five strains of S. marcescens were screened in shake-flask studies and were found to produce 0.8 to 3.7 IU/ml 48 hr after inoculation. The requirements for asparaginase production with S. marcescens ATCC 60, the high producing strain, included the following: 4% autolyzed yeast extract medium (initial pH 5.0), an incubation temperature of 26 C, and limited aeration for a zero level of dissolved oxygen during the fermentation. Addition of various carbohydrates to the fermentation medium did not enhance yields. The peak cell population in the fermentation medium and the maximal asparaginase yields occurred simultaneously. Highest enzyme yields were found when the pH of the fermentation cycle rose to approximately 8.5. Yields of 4 IU of asparaginase/ml of cell suspension have been obtained consistently in 40 to 42 hr from 10-liter volumes (500 ml/4-liter bottle) produced on a reciprocating shaker. Scale-up to a 60-liter fermentor yielded 3.1 IU/ml in 35 hr.     

Epidemiological Differentiation of Serratia marcescens: Typing by Bacteriocin Production

A new method for comparing and differentiating strains of S. marcescens is described which has proved useful in determining the epidemiology of hospital infections. Strains were grown in Trypticase soy broth, and bacteriocin production was induced with mitomycin C for 5 hr. The bacteriocin lysates were then spotted onto nine standard indicator strains, which were chosen with the aid of computer analysis from the 118 indicators tested. After 24 hr at 37 C, zones of inhibition due to bacteriocins were recorded. One hundred twentynine strains were differentiated into 72 different bacteriocin production patterns, but 11 strains were nontypable. None of the 45 other strains of Enterobacteriaceae produced bacteriocins. Bacteriocin production was a stable epidemiological marker. Colonial mutants always had identical patterns, as did the same strain which has passed from patient to patient through cross-infection. The new technique does not require any specialized equipment and can be used in laboratories with limited budgets. The applications of the new method in cross-infection studies and as a supplement to serological typing are discussed.     

Sex-Linked Auxotrophic and Putative Auxotrophic Mutants of DROSOPHILA MELANOGASTER

Thirty-two mutants with improved growth response on a yeast-sucrose compared with a defined medium have been characterized with respect to ribonucleoside supplementability. Twenty mutants respond to either pyrimidine ribonucleoside. Four mutants respond to one or both purine ribonucleosides. Eight mutants ("putative" auxotrophs) do not respond to dietary RNA supplementation. Mapping and complementation studies suggest that eleven loci are represented: one, rudimentary, probably accounts for all pyrimidine requirers; there are three purine loci and seven at which the putative auxotrophs are found.