Purification and Some Properties of Crystalline Acid Protease from Acrocylindrium sp.

A crystalline acid protease produced by a strain of Acrocylindrium in a submerged culture was prepared by treatment with acetone (60%), salting out with ammonium sulfate (saturated) and, after chromatography on Duolite GS-101 column, dialysis against distilled water. This preparation was homogeneous on sedimentation analysis, starch-gel electrophoresis and gel filtration with Sephadex G-75. The optimum pH was 2.0 for milk casein digestion and the pH stability was for 2.0~5.0 at 30°C for one day. The crystalline enzyme was completely stable below 50°C, but lost the activity at 70°G in ten minutes. The acid protease was almost equal to pepsin on specific activity when milk casein solution (pH 2.0) was used as substrate.     

Studies on Tannin Acyl Hydrolase of Microorganisms

Tannin acyl hydrolase (Tannase) from Asp. oryzae No. 7 was purified. The purified enzyme was homogenous on column chromatography (DEAE-Sephadex A50, Sephadex G100), ultra centrifugation and electrophoresis.

The molecular weight of the enzyme estimated by gel filtration method was about 200,000.

The enzyme was stable in the range of pH 3 to 7.5 for 12 hr at 5°C, and for 25 hr at the same temperature in the range of pH 4.5 to 6. The optimum pH for the reaction was 5.5. It was stable under 30°C (over one day, in 0.05 M-citrate buffer of pH 5.5), and the optimum temperature was 30~40°C (reaction for 20min). The activity was lost completely at 55°C in 20 min at pH 5.5, or at 85°C in 10 min at the same pH.

Any metal salt tested did not activate the enzyme, Zink chloride and cupric chloride inhibited the activity or denatured the enzyme. The activity was lost completely by dialysis against EDTA-solution at pH 7.25, although it was not affected by dialysis against deionized water.     

Production and Purification of a New Chillproofing Enzyme and Its Properties

Chillproofing enzyme was obtained from broth cultures of Serratia marcescens B–103. This extracellular enzyme, tentatively, named the S-enzyme was highly purified from the culture supernatant by ammonium sulfate precipitation, ethanol fractionation, gel filtration on Sephadex G–200 and column chromatography on DEAE-Sephadex A–50.

The purified preparation appeared homogeneous on a ultracentrifugation with a sedimentation coefficient of 3.14 S and a molecular weight of 38,000~45,000 determined by the method of Whitaker.

The S-enzyme hydrolyzed various proteins at pH 4~6 and at low temperature hydrolyzed nitrogenous substances which may cause chill haze in beer. So the chillproofing activity of the S-enzyme may be due to its proteolytic activity.

The S-enzyme was stable at 4°C at pH 5~10.5. It was completely inactivated by heating at 60°C for 10 min, and was inactivated by Hg²⁺ and Pb²⁺ and activated by Mn²⁺, Ca²⁺. Mg²⁺ and Zn²⁺     

Crystallization and Some Properties of Alkaline Proteinase from Aspergillus sulphureus

An alkaline proteinase of Aspergillus sulphureus (Fresenius) Thorn et Church has been purified in good yields from wheat bran culture by fractionation with ammonium sulfate, treatment with acrynol, and DEAE-Sephadex A-50 column chromatography. The crystalline preparation was homogeneous on sedimentation analysis and polyacrylamide gel zone electrophoresis. The molecular weight was calculated to be 23,000 by gel filtration. The amino acid composition of the enzyme was determined. The enzyme did not precipitate with acrynol. Optimum pH for the hydrolysis of casein was 7 to 10 at 35°G for 15 min. Optimum temperature was 50°C at pH 7 for 10 min. The enzyme was highly stable at the range of pH 6 to 11 at 5°C, whereas relatively stable at pH 6 to 7 at 35°C. Metalic salts tested did not affect activity. Chelating agents, sulfhydryl reagents, TPCK, and oxidizing or reducing reagents tested, except iodine, had no effect on the activity. Diisopro-pylfluorophosphate and N-bromosuccinimide almost completely inactivated the proteinase.     

Purification and Properties of 7β-(4-Carboxybutanamido)-cephalosporanic Acid Acylase Produced by Mutants Derived from Pseudomonas

7β-(4-Carboxybutanamido)cephalosporanic acid acylase (penicillin amidohydrolase, EC 3.5.1.11) was crystallized from cell-free extracts of a mutant derived from Pseudomonas SY-77-1. Purification of the enzyme was performed by a procedure involving ammonium sulfate fractionation and column chromatographies on DEAE-Sephadex, TEAE-cellulose and Sephadex G-200. The crystalline enzyme was homogeneous on polyacrylamide gel disc electrophoresis. The molecular weight of the acylase was estimated to be 1.3 × 10⁵ by gel filtration. The enzyme was fully active at pH above 6.5 and was highly stable at a pH range of 6.0 to 8.0 and below 38°C. The Michaelis-Menten constant (Km) and V_max for 7β-(4-carboxybutanamido)cephalosporanic acid were 0.16mM and 4.91 μmol/min/mg-protein, respectively. It was also indicated that this enzyme-protein occupied 2.3% of the dry-cell weight.     

Studies on Pectic Enzymes of Microorganisms

Endo-polygalacturonase (endo-PG) of Aspergillus saitoi was purified through ammonium sulfate fractionation, Amberlite IRC-50 column chromatography, and several combinations of Sephadex column chromatography.

The purified endo-PG, which was almost homogeneous ultracentrifugally and electrophoretically, had the sedimentation constant of 2.2 S and the absorption maximum at 277 mμ. Its optimum pH and temperature were 4.8~5.0 and 45°C, respectively, and it was most stable between pH 4.0 and 6.0, but over 90% of the activity was lost at 50°G for 10 min.

The purified enzyme was a typical endo-PG, and hydrolyzed about 60% and 17% of glycosidic linkage of polygalacturonic acid and pectin, respectively. This enzyme preparation had no pectinesterase, trans-eliminase, and apple juice-clarifying activities, but macerated potato tuber slices singly.     

Purification,Crystallization and Some Properties of Extracellular Pullulanase from Aerobacter aerogenes

Extracellular pullulanase was purified and crystallized from the culture fluid of Aerobacter aerogenes. Pullulanase was purified by means of ammonium sulfate fraction, DEAE-cellulose column chromatography and Sephadex column chromatography. Crystalline pullulanase was formed when saturated ammonium sulfate solution was added to the purified enzyme solution. The crystalline enzyme appeared as colorless fine rods. On ultracentrifugation analysis, the enzyme showed a single sharp and symmetrical Schlieren peak. The sedimentation coefficient, s_20,w was 4.39S. Polyacrylamide gel electrophoresis at pH 8.4 gave a main band with two sub-bands and the molecular weight of the main enzyme was estimated to be 66,000 from Polyacrylamide gel electrophoresis and to be 58,000 from sedimentation equilibrium. The optimum pH and temperature for the enzyme action were pH 6.5 and 50°C, respectively.     

Purification and Properties of Neutral-cyclodextrin Glycosyl-transferase of an Alkalophilic Bacillus sp.

Neutral-cyclodextrin glycosyltransferase (EC 3.2.1.19) of alkalophilic Bacillus sp. (ATCC 21783) was purified by starch adsorption, DEAE-cellulose chromatography and Sephadex G–150 gel filtration chromatography followed by preparative polyacrylamide gel electrophoresis. Molecular weight of the purified enzyme was 85,000-88,000 by SDS-disc gel electrophoresis. The enzyme was most active at pH 7 and 50°C, and stable up to 60°C at pH 7 and in the range of pH 6~8 at 60°C by 30 min incubation. The apparent V_max and Km values for α- and β-cyclodextrin at a constant concentration of sucrose were 417, 70 µmoles glucose/min · mg protein and 10, 0.83 nm, respectively. About 85~90% of amylose, 75~80% of potato starch, 65~70% of amylopectin, 55~60% of glycogen, 45~50% of amylopectin β-limit dextrin, 20~25% of maltotriose and 10~15% of maltose were converted to cyclodextrins with 0.5~1% (w/v) of each substrate.

Schardinger β-dextrin was preferentially produced from starch, and α- or γ-dextrin was gradually formed after prolonged incubation. After 20 min incubation, about 0.4, 14 and 2.5% of α-, β- and γ-dextrin were formed from starch, respectively.     

Synthesis of (±)-Xanthoxins

The enzymatic properties of P2-2 enzyme were determined by using cells of M. radiodurans. The enzyme was: most active at 60°C incubation temperature, stable at 40°C in neutral buffer, and inactivated by heating at 80°C for 15min. Maximal lytic activity occurred at pH 8.5 in Tris-HCl buffer. The range of enzyme stability was between pH 5.5 and 8. Bivalent metal ions, p-chloromercuribenzoate and monoiodo acetate inhibited lytic activity. The molecular weight was estimated to be 16,000 daltons by gel filtration on Sephadex G-75. The enzymatic digestion of peptidoglycans from the cell walls of M. radiodurans and M. lysodeikticus liberated free amino groups, but neither reducing groups nor N-acetylhexosamine, indicating that the enzyme was an endopeptidase. From analysis of the N-terminal amino acids of the digests, it is suggested that the P2-2 enzyme cleaves the peptide bond at the carboxyl group of D-alanine in peptidoglycan.     

Konjac-mannanase from the Tubers of Amorphophallus konjac C. Koch

A crude enzyme preparation hydrolyzing konjac mannan was extracted from germinating konjac tubers, and purified by chromatography with DEAE-cellulose and alkali-swollen cellulose, and by gel-filtration on Sephadex G-100. The purified enzyme preparation showed optimal activity at pH 4.7, optimum temperature at 40°C. It was considerably stable at pH’s between 4.0 and 8.0, but inactivated rapidly by temperaters above 50°C. Hydrolysis of the mannan by this enzyme proceeded by typical random mechanism, and the rate was in agreement with an empirical equation, p=0.43 E^0.77 to^0.5. As the Km and V_max values for mannan, 7.14×10^-2(%)and 23.8×10^-3 (ΔOD_500nm) were obtained, respectively.     

Serratia Protease

A strain of Serratia, isolated from an intestinal canal of a silkworm, produced a large quantity of protease. The enzyme was extracellular and was named Serratiopeptidase, tentatively. Protease production of this strain was over 3 times as much as that of Serratia marcescens which was known as a protease-producing organism. The highly purified enzyme was prepared from the culture supernatant through ammonium sulfate precipitation, acetone fractionation, DEAE-cellulose column chromatography and gel filtration on Sephadex G-75.

The purified enzyme moved homogeneously with a sedimentation constant, s_20,w of 3.8 S in ultracentrifugation and the molecular weight was determined to be 6.0 × 10₄ by the Archibald method. Determination of the ultraviolet absorption spectrum indicated the E^1%_{280 mμ,1 cm} was 13.0. Neither carbohydrate nor sulfur-containing amino acid was detected in the purified enzyme preparation. The enzyme showed maximal activity at pH 9.0 and at 40°C, and was stable under lower temperatures over the pH range from 5 to 10, whereas it was unstable at 37°C in alkaline conditions. The enzyme was completely inactivated by heating at 55°C for 15 min.     

Purification and Some Properties of ATP: Nucleotide Pyrophospho-transferase of Streptomyces adephospholyticus

ATP: nucleotide pyrophosphotransferase was purified from culture filtrate of Streptomyces adephospholyticus A–4668 about 13,000 fold by the method including ammonium sulfate fractionation, Amberlite IRC–50 treatment and column chromatography with DEAE-cellulose, DEAE-Sephadex A–25, SP-Sephadex C–25 and Sephadex G–75. The purified enzyme was homogenous on disk gel electrophoresis and ultracentrifugation and the specific activity was 915 units per mg protein, The molecular weight was determined as 28,000 by gel filtration on Sephadex G–75. The enzyme was found to be stable in the pH range of 5.5 to 10.5. More than 80% of the activity was remained after heating at 60°C for 30 min. The enzyme exhibited maximum activity at 50°C.     

Formation of ε-(2-Formyl-5-hydroxy-methyl-pyrrol-1-yl)-l-norleucine in the Maillard Reaction between d-Glucose and l-Lysine

An exo-β-1,3-glucanase was purified from the commercial enzyme preparation “Kitalase” which is a yeast cell wall lytic enzyme preparation. The purification procedures consisted of following steps: ammonium sulfate fraction, SP-Sephadex C-50 and CM-Cellulose C-32 column chromatography, and Sephadex G-100 gel filtration. The optimum pH value was 5.8, and the optimum temperature was 55°C. The enzyme was stable in the pH range of 5.1 to 9.8 and at temperatures below 53°C. The isoelectric point and the molecular weight were estimated to be pH 9.3 and 73000, respectively. The enzyme was shown to bypass β-1,6-linkaged branches to cleave β-1,3-linkages when scleroglucan was used as substrate. The Km values for laminariri, laminari-pentaose, laminaritetraose and laminaritriose were 0.16, 2.01, 2.24 and 1.34 mM, respectively.     

Purification and Characterization of a Thermostable Alkaline Protease from Alkalophilic Thermoactinomyces sp. H8682

Protease secreted into the culture medium by alkalophilic Thermoactinomyces sp. HS682 was purified to an electrophoretically homogeneous state through only two chromatograhies using Butyl-Toyopearl 650M and SP-Toyopearl 650S columns. The purified enzyme has an apparent relative molecular mass of 25, 000 according to gel filtration on a Sephadex G-75 column and SDS-PAGE and an isoelectric point above 11.0.

Its proteolytic activity was inhibited by active-site inhibitors of serine protease, DFP and PMSF, and metal ions, Cu²⁺ and Hg²⁺. The enzyme was stable toward some detergents, sodium perborate, sodium triphosphate, sodium-n-dodecylbenzenesulfonate, and sodium dodecyl sulfate, at a concentration of 0.1% and pH 11.5 and 37°C for 60 min. The optimum pH was pH 11.5–13.0 at 37°C and the optimum temperature was 70°C at pH 11.5. Calcium divalent cation raised the pH and heat stabilities of the enzyme. In the presence of 5 mM CaCl₂, it showed maximum proteolytic activity at 80°C and stability from pH 4–12.5 at 60°C and below 75°C at pH 11.5. The stabilization by Ca²⁺ was observed in secondary conformation deduced from the circular dichroic spectrum of the enzyme. The protease hydrolyzed the ester bond of benzoyl leucine ester well. The amino acid terminal sequence of the enzyme showed high homology with those of Microbiol serine protease, although alanine of the NH₂-terminal amino acid was deleted.     

Purification and Properties of an Aminopeptidase from Rabbit Skeletal Muscle

An aminopeptidase active on l-Val-l-Val-l-Val-l-Ala was purified from rabbit skeletal muscle by the method including ammonium sulfate precipitation, DEAE-cellulose chromatography, gel-filtration on Sephadex G–200, rechromatography on DEAE-cellulose, hydroxylapatite chromatography and rechromatography on Sephadex G–200. Polyacrylamide gel disc electrophoresis showed that the enzyme thus obtained was homogeneous. The specific activity of the purified enzyme was 1500 times that of the original muscle extract. The enzyme had an optimal pH in a range of 6.0~7.6 and was stable in pH 6.1~8.1. Molecular weight of the enzyme was estimated to be 160,000 from the result of gel-filtration on Sephadex G–200. The enzyme showed specificity for tri-, tetra-, penta-, and hexapeptides. The analytical data of liberated amino acids showed that the enzyme was an aminopeptidase active on these oligopeptides. The enzyme was strongly inhibited by N-ethyl-maleimide and EDTA.     

Preparation of Zeaxanthin from Berries of Boxthorn,Lycium chinensis

Purification and properties of a new alkaline protease of rat skeletal muscle have been reported. The purification procedure of the enzyme is as follows: skeletal muscle tissue was extracted successively with Hasselbach-Schneider solution, 5 m urea solution and 2% sodium deoxycholate solution. After then, the enzyme was extracted from the residue with 1.1 m potassium iodide solution. This enzyme solution was treated with n-butanol, and dialyzed against water. The enzyme precipitated during dialysis was collected and dissolved in 1.1 m potassium iodide solution. The enzyme solution was fractionated with acetone, and chromatographed on Sephadex G-200. The final preparation showed over 20,000 times of purity.

The optimum pH range of the enzyme activity is 9.5~10.5, and the maximum reaction rate occurs at 47~57°C. The enzyme is stable below 47°C at pH 7.3. At 37°C, the enzyme is stable during 30 min at least, in the pH range of 5.5~10.0. Below pH 5.0, it is relatively labile. Hg²⁺, Ca²⁺, Mg²⁺, Mn²⁺, Co²⁺, and Zn²⁺ scarcely affect the enzyme activity at the concentration of 1 mm. Ethylenediaminetetraacetate shows little effect on the activity at the concentration of 10 mm, and iodoacetamide, 2,4-dinitrophenol, p-chloromercuribenzoate show the similar effect at the concentration of 1 mm. Diisopropyl-flurophosphate inhibits the enzyme activity. From the results obtained, this enzyme is presumed to be responsible for the activity of autolytic breakdown of rat skeletal muscle proteins in the alkaline pH range.     

Chemical and Physicochemical Properties of Phytase from Aspergillus terreus

Some chemical and physicochemical properties of the purified phytase preparation produced by Asp. terreus were investigated. From the results of the examination of amino acid analysis, it was suggested that there existed some components other than amino acids in the purified enzyme. Examination of the neutral sugar analysis, therefore, was made by gaschromatography, and it was found that the purified enzyme preparation contained mannose, galactose and a small amount of inositol.

The molecular weight of the enzyme was found to be 214,000 by the Archibald method, and 2.2~2.3×10⁵ by gel-filtration on a Sephadex G–200 column. It was found that by guanidine hydrochloride or by urea, the purified enzyme preparation was dissociated into only one kind of subunit. The native enzyme was supposed to be a homohexamer of the subunits whose molecular weight is 37,000.     

Quinolizine Alkaloids from the African Medicinal Plant Calpurnia aurea: Molluscicidal Activity and Structural Study by 2D-NMR

l-Phenylalanine ammonia-lyase was crystallized for the first time from a cell-free extract of Rhodosporidium toruloides IFO 0559. Heat treatment at 50°C for 5 min was a smart step for enzyme purification. Column chromatographies with DEAE-cellulose and hydroxyapatite, and gel filtration on a Sephadex G-200 column were used in the subsequent purification. The enzyme was purified to a homogeneous state and crystallized as fine needles with ammonium sulfate. The crystalline enzyme was pure by both analytical ultracentrifugation and polyacrylamide gel electrophoresis. The enzyme had a 8.2 s sedimentation velocity. The molecular weight of the enzyme was 165,000 by the dual methods of sedimentation equilibrium and gel filtration. The enzyme was composed of two identical subunits with a molecular weight of 80,000.     

Purification,Crystallization and Some Enzymatic Properties of Acid Protease of Cladosporium sp. No. 45–2

An acid protease of Cladosporium sp. No. 45–2 was purified and crystallized by precipitation with ammonium sulfate, fractional precipitation with acetone, and pH adjustment. About 600 mg of third crystallized preparation was obtained from one liter of culture broth. The purified enzyme was chromatographically homogeneous and confirmed to be monodispersive by physicochemical criteria such as uhracentrifugal and electrophoretical analysis. The enzyme was most active at pH values between 2.5 and 2.7 toward both casein and hemoglobin and was stable at pH values from 2.5 to 7.0 on twenty hour incubation at 30°C.

Millimolar concentration of sodium lauryl sulfate markedly inhibited the enzyme, wheares diisopropyl phosphorofluoridate, sulfhydryl reagents, ethylenediaminetetra acetic acid, and divalent metal ion relatively little affected the activity. The enzyme was most resistant toward S-PI among the acid proteases tested.     

Purification and Properties of Phospholipase D from Streptomyces antibioticus

Phospholipase D was purified from Streptomyces antibioticus by column chromatography and chromatofocusing. The enzyme preparation was electrophoretically homogeneous and the molecular weight of the enzyme was estimated to be 64,000. Its isoelectric point was around pH 6.5. The enzyme was most active at pH 5.5 and at around 60°C. It was stable between pH 4 and 8, and below 50°C.