Identification of xylanase-producing fungi EIM-30 and its optimization of submerged fermentation conditions

通过对木聚糖酶高产菌株EIM-30基于形态学和18S rDNA序列的系统发育进化分析,鉴定为里氏木霉Trichoderma reesei.在单因子实验确定EIM-30产木聚糖酶的最适碳源和氮源的基础上,通过Plackett-Burman实验对影响其产酶的相关因素进行评估并筛选出3个显著效应因子,然后应用最陡爬坡实验和响应面分析确定最适产酶培养基配方为:酵母浸膏1.50％,蛋白胨1.00％,NaCl 0.50％,PPG-2000 0.10％,MgSO4 1.20％,CaCl2 0.18％,(NH4)2 SO4 0.45％,甘油4.18％,乳糖3.05％,K2HPO41.59％.优化后Trichoderma reesei EIM-30的液体发酵产木聚糖酶的活力可达9.857×105 U/mL,较优化前提高1.98倍.     

果胶酶高产菌株EIM-4的鉴定及其液体发酵条件优化

目的：通过了解高产果胶酶菌株EIM-4的背景信息及优化其最适的产酶条件,为下一步工业化生产提供依据。方法：通过基于18S rDNA序列的系统发育进化分析对果胶酶高产菌进行鉴定,通过单因素试验和均匀设计获得最适产酶条件。结果：通过对18SrRNA基因的分子系统进化分析,菌株EIM-4被鉴定为黑曲霉（Aspergillus niger）。通过单因素和均匀设计试验确定最佳产酶培养基为（g/L）：橘皮粉32.9,黄豆粉10.7,（NH4）SO42.1,CaCO31.0,pH自然。结论：Aspergillus niger EIM-4的液体发酵产果胶酶的活力可达15159.82U/mL。     

响应面分析优化产木聚糖酶毕赤酵母基因工程菌培养条件

研究不同碳源、氮源和无机盐对毕赤酵母AX181菌株产木聚糖酶的影响。实验表明,分别采用葡萄糖和玉米浆干粉为碳源和氮源可以明显提高木聚糖酶的产量。无机盐单因子优化实验显示添加适量的（NH4）2SO4、KH2PO4、MnSO4·H2O、FeSO4·7H2O也可以部分提高木聚糖酶产量。在此基础上利用响应面法优化毕赤酵母产木聚糖酶培养基,利用12次实验的Plackett—Burman设计实验筛选出影响产木聚糖酶的3个主要因素,即玉米浆干粉、MnSO4·H2O和FeSO4·7H20。并进一步通过最陡爬坡路径逼近最大响应区域,采用中心组合实验设计确定最佳条件。优化后的产木聚糖酶培养基组分为（g/L）：葡萄糖40．00,玉米浆干粉80．84,（NH4）2SO46．25,KH2PO41．25、MnSO4·H2O0．35,FeS04-7H2O1．31。培养基优化后,实际产酶2883．86u／mL,是优化前YPD培养基产酶的2．51倍。     

黑曲霉A3菌株木聚糖酶粗酶制剂的制备和性质

本文研究了黑曲霉（AspergillusnigerA3）菌株固体发酵培养的产酶过程,发酵3d产木聚糖酶活最高,固体曲最适浸提比为1：7（W／V）,通过60％～65％饱和度的硫酸按盐析,获得的木聚糖酶活力最高。冻干酶粉活力为15400u/g,得率为71％,40℃烘干酶粉活力为15395U／g,得率为51％,酶反应最适温度55℃,最适pH4．6,保温1h半失活温度（t1／2）为54℃,酶对四种不同底物半纤维素水解作用的亲合性为鼓皮最强,稻草最弱。     

纤维素酶液体发酵最佳培养基的确定

用响应面法对里氏木霉WX—112液体发酵产纤维素酶的培养基进行了优化。首先用快速登高路径逼近最大产酶区域,然后根据快速登高法的实验结果进行响应面实验。运用逐步回归分析法,获得滤纸酶活与豆饼粉、麸皮、KH2PO4、微晶纤维素粉（Avicel）的最优回归方程,且分析了各因子间的交互效应。最后,通过岭脊分析确定了滤纸酶活达最大值10．53IU／mL时的最佳组合条件：豆饼粉3．18％、麸皮2．95％、KH2PO4 0．25％、Avicel 3．79％。     

里氏木霉GXC木聚糖酶的研究

研究了里氏木霉GXC产木聚糖酶的条件和酶学性质。结果表明,适宜产酶碳源为乳糖、甘露糖、棉子糖、木聚糖和麸皮,氮源为牛肉膏和酵母膏;产酶的最适初始pH为4．0,30℃培养60h。对以麸皮为碳源的培养液进行纯化的酶特性研究表明,木聚糖酶的最适反应温度为50℃,pH为5．5,该酶在pH5．0－7．0和40℃以下相对稳定。Fe^2 和Mn^2 对木聚糖酶有较大的促进作用,Cu^2 、Fe^2 具有抑制作用。     

木聚糖酶高产菌株Bacillus pumilus H—101的筛选及产酶条件的研究

从34株细菌中筛选到一株木聚糖酶高产菌株BacilluspumilusH－101。适宜的产酶培养基含2．0％小麦秸半纤维素、0．2％（NH4）2SO4、0．1％NH4NO3、0.1％K2HPO4、0．01％MgSO4·7H2O、0.02％NaC1、0.02％CaCl2·2H2O和1.0％的酵母膏。在上述培养基中,32℃振荡培养48h,总半纤维素酶活力达235．6u／ml,木聚精酶活力达1164．2u／ml酶反应的最适温度为50℃,最适酸碱度为pH6．5;Na 、Mg2 等离子可提高木聚精酶的水解活性,而Zn2 、Cu2 等离子则对木聚糖酶活性有明显的抑制作用。     

响应面法优化有机溶剂极端耐受性菌株Burkholderia sp．ZYB002产脂肪酶条件

Burkholderia sp．脂肪酶具有较高的有机溶剂耐受性和转酯活性,广泛应用于手性化合物的拆分。本研究利用统计学方法对一株具有有机溶剂极端耐受性的脂肪酶高产茵株Burkholderia sp．ZYB002在摇瓶培养条件下产脂肪酶条件进行了优化。通过单因素实验,首先确定了最适碳源、氮源、诱导荆等。以Plackett—Burrman设计筛选影响Burkholderia sp．ZYB002产酶的主要因素,通过最陡爬坡实验和响应面分析法确定产酶最适条件。K2HP04、大豆油乳化液和起始RH确定为影响菌株产酶的3个主效因素。最佳产酶条件为：糊精0．3％（W／V）,牛肉膏2．0％（W／V）,MgSO4．7H2O．075％（W／V）,K2HPO4 0．14％（W／V）,大豆油乳化液4．89％（V／V）,pH8．11,玻璃珠10颗／瓶,接种量2．0％（V／V）,30℃,250r／min,发酵时间22h。在此条件下,发酵液脂肪酶酶活最高达45．6U／mL,较发酵基本培养基发酵液的脂肪酶酶活提高了3．44倍。     

产木聚糖酶菌株的选育及其液体发酵条件

从土壤中筛出一株生长快产木聚糖酶活力较高的黑曲霉(Aspergillus niger)C—2菌株,经紫外线和甲基磺酸乙酯诱变,获得一突变株An—76,其生长减缓,孢子形成能力减弱,产生的术聚糖酶和β—木糖苷酶活力分别可达353．61U／ml和4．51U／ml。测定了An—76的正常产酶曲线,研究了麸皮、氮源、碳源及半纤维素浓度对产酶的影响。最适培养条件为：起始pH6.0、28℃、96h。酶的最适作用条件为50—55℃,pH4．8,在pHl．2—11．4范围内稳定。酶的热稳定性较差,55℃保温1小时,剩余活力为40％。只有在含木糖苷类物质存在时,An—76才大量合成木聚糖酶。     

一株霉菌产木聚糖酶固态发酵培养基的优化及酶学性质研究

对一株霉菌B45固态发酵产木聚糖酶的培养基组分进行优化,通过单因素实验观察了不同碳源、氮源、无机盐、水料比4种因素对产木聚糖酶的影响,确定了4种最佳的单因素成分。在单因素的基础上,再通过正交实验确定了所试因素的最佳组合,并对其粗酶的酶学性质进行了研究。结果表明,在培养基组分为玉米芯与麸皮的比例=7∶3,硫酸铵为1.5%,KH2PO4为0.8%,水料比为2.1∶1时,得到的酶活力最高,产酶量可达1 079.93 U/g。其粗酶液的最适反应温度为60℃,最适反应pH为5,在pH5～pH6的范围内酶活性较稳定。但粗酶液的热稳定较差,在40℃条件下酶活力开始下降,当温度升至70℃时酶活力损失85%以上。     

Xylanase production by Trichoderma reesei Rut C-30 grown on L-arabinose-rich plant hydrolysates

The suitability of L-arabinose-rich plant hydrolysates as carbon sources and inducers of xylanase production in Trichoderma reesei Rut C-30 was tested. Significantly higher xylanase activities were obtained in cultures on oat husk and sugar beet pulp hydrolysates than on lactose. In batch culture with oat husk hydrolysate and lactose, the xylanase activity was about 9 times higher ( approximately 510 IU/ml) than in lactose ( approximately 60 IU/ml). Even higher xylanase activity ( approximately 630 IU/ml) was obtained when the batch cultivations were done on sugar beet pulp hydrolysate and lactose. In a fed-batch culture using oat husk hydrolysate-lactose the xylanase activity was as high as 1350 IU/ml in 4 days. The cellulase production clearly decreased when T. reesei was cultured on both hydrolysates compared to the cultivation on lactose. Moreover, the relative amounts of the xylanases I-III were similar regardless the used carbon source.     

Expression and processing of a major xylanase (XYN2) from the thermophilic fungus Humicola grisea var. thermoidea in Trichoderma reesei

AIMS: To express a gene encoding a heterologous fungal xylanase in Trichoderma reesei. METHODS AND RESULTS: Humicola grisea xylanase 2 (xyn2) cDNA was expressed in Trichoderma reesei under the main cellobiohydrolase I (cbh1) promoter (i) as a fusion to the cellobiohydrolase I (CBHI) secretion signal and (ii) the mature CBHI core-linker. The recombinant xylanase (HXYN2) was secreted into the cultivation medium and processed in a similar fashion to the endogenous T. reesei xylanases, resulting in an active enzyme. CONCLUSIONS, SIGNIFICANCE AND IMPACT OF THE STUDY: HXYN2 was successfully processed in T. reesei. Composition of the culture medium affected the HXYN2 yields, favouring Avicel-lactose as a carbon source. Best yields (about 0.5 g l(-1)) in shake flask cultivations were obtained from a transformant where xyn2 was fused directly to the CBHI secretion signal.     

The enzymatic hydrolysis and fermentation of pretreated wood substrates

Aspenwood chips were pretreated by steam explosion. The various wood fractions obtained were assayed for their ability to act as substrates for growth and cellulase production of different Trichoderma and Clostridium thermocellum species. Steam exploded aspenwood was as efficiently utilized as solka floc and correspondingly high cellulase activities were detected in the various culture filtrates. When T. harzianum E58 was grown on increasing concentrations of solka floc, highest cellulase and xylanase activities were detected at 1% substrate concentrations while high substrate concentrations (10-20%) inhibited growth and enzyme production. When the cellulosic substrates were supplemented with increasing amounts of glucose, cellulase and xylanase production were inhibited when the glucose concentration exceeded 0.1%. Highest xylanase activities were detected after growth of T. reesei C30 and T. harianum E58 on xylan and solka floc respectively. All of the steam exploded fractions were at least partially hydrolyzed by the T. harzianum E58 cellulase system. The extent of the pretreatment also influenced the ability of Zymomonas mobilis and Saccharomyces cerevisiae to ferment the liberated sugars to ethanol. About 85% of the theoretical yield of ethanol from cellulose could be obtained from the combined hydrolysis and fermentation of pretreated aspenwood.     

碱性蛋白酶高产菌株EIM-8的筛选鉴定及其液体发酵条件优化

筛选分离得到一株高产碱性蛋白酶菌株EIM-8,并基于16S序列进行分子系统进化分析,鉴定该菌株为枯草芽孢杆菌(Bacillus subtilis).同时,采用响应面法对Bacillus subtilis EIM-8的产酶条件进行了优化.首先通过单因素试验,筛选出最适碳源为玉米淀粉,最适氮源为牛肉膏.在此基础上,采用Pl...     

Construction of a recombinant Trichoderma reesei strain expressing Aspergillus aculeatus β-glucosidase 1 for efficient biomass conversion

To develop a Trichoderma reesei strain appropriate for the saccharification of pretreated cellulosic biomass, a recombinant T. reesei strain, X3AB1, was constructed that expressed an Aspergillus aculeatus β-glucosidase 1 with high specific activity under the control of the xyn3 promoter. The culture supernatant from T. reesei X3AB1 grown on 1% Avicel as a carbon source had 63- and 25-fold higher β-glucosidase activity against cellobiose compared to that of the parent strain PC-3-7 and that of the T. reesei recombinant strain expressing an endogenous β-glucosidase I, respectively. Further, the xylanase activity was 30% lower than that of PC-3-7 due to the absence of xyn3. X3AB1 grown on 1% Avicel-0.5% xylan medium produced 2.3- and 3.3-fold more xylanase and β-xylosidase, respectively, than X3AB1 grown on 1% Avicel. The supernatant from X3AB1 grown on Avicel and xylan saccharified NaOH-pretreated rice straw efficiently at a low enzyme dose, indicating that the strain has good potential for use in cellulosic biomass conversion processes.     

里氏木霉GXC木聚糖酶的研究

研究了里氏木霉GXC产木聚糖酶的条件和酶学性质。结果表明,适宜产酶碳源为乳糖、甘露糖、棉子糖、木聚糖和麸皮,氮源为牛肉膏和酵母膏;产酶的最适初始pH为4.0,30℃培养60h。对以麸皮为碳源的培养液进行纯化的酶特性研究表明,木聚糖酶的最适反应温度为50℃,pH为5.5,该酶在pH5.0(7.0和40℃以下相对稳定。Fe3+和Mn2+对木聚糖酶有较大的促进作用,Cu～2+、Fe～2+和Ca～2+ 具有抑制作用。     

里氏木霉GXC木聚糖酶的研究*

研究了里氏木霉GXC产木聚糖酶的条件和酶学性质。结果表明,适宜产酶碳源为乳糖、甘露糖、棉子糖、木聚糖和麸皮,氮源为牛肉膏和酵母膏;产酶的最适初始pH为4.0,30℃培养60h。对以麸皮为碳源的培养液进行纯化的酶特性研究表明,木聚糖酶的最适反应温度为50℃,pH为5.5,该酶在pH5.0(7.0和40℃以下相对稳定。Fe3+和Mn2+对木聚糖酶有较大的促进作用,Cu～2+、Fe～2+和Ca～2+ 具有抑制作用。