Purification and partial characterization of a myofibril-bound serine protease from ostrich skeletal muscle

A myofibril-bound serine protease (MBSP) was partially purified from ostrich (Struthio camelus) skeletal muscle. MBSP was dissociated from the myofibrillar fraction by ethylene glycol treatment at pH 8.5, followed by partial purification via Toyopearl Super Q 650 S and p-aminobenzamidine column chromatographies. Ostrich MBSP revealed a major protein band of approximately 21 kDa on SDS-PAGE, showing proteolytic activity after casein zymography. Optima pH and temperature of ostrich MBSP were 8 and 40 °C, respectively. Substrate specificity analysis revealed that the enzyme cleaved synthetic fluorogenic substrates at the carboxyl side of arginine residues. Kinetic parameters (K_m and V_max values) were calculated from Lineweaver–Burk plots. The kinetic characteristics of ostrich MBSP were compared to values obtained for commercial bovine trypsin in this study, as well as those obtained for MBSP from mouse and various fish species. The results suggest that ostrich MBSP is a tryptic-like serine protease. Ostrich MBSP exhibited low sequence identity to commercial bovine trypsin (44%), MBSP from lizard fish skeletal muscle (33%) and trypsinogen from ostrich pancreas (22%).     

A novel type of myofibril-bound serine protease from white croaker (Argyrosomus argentatus)

Myofibril-bound serine protease (MBSP) was purified from the myofibril fraction of white croaker (Argyrosomus argentatus) muscle and its enzymatic properties were compared with other fish MBSPs. White croaker MBSP was extracted by the heat treatment of myofibrils and then purified by a series of column chromatographies on Q-Sepharose, Sephacryl S-300, hydroxyapatite and Benzamidine Sepharose. The purified MBSP migrated as a single protein band at 67 kDa in SDS-PAGE under both reducing and non-reducing conditions. It was inhibited by Pefabloc SC, soybean trypsin inhibitor (STI), aprotinin and benzamidine, and was not affected by E-64, pepstatin A and EDTA. The enzyme was most active against Boc-Phe-Ser-Arg-MCA at pH 7.0 and 50 degrees C, and preferentially hydrolyzed Boc-Val-Pro-Arg-MCA and Boc-Asp-Pro-Arg-MCA. Unlike other marine fish MBSPs, white croaker MBSP considerably hydrolyzed Boc-Val-Leu-Lys-MCA and Boc-Glu-Lys-Lys-MCA. Some enzymatic characteristics including the molecular structure and the substrate specificity for a lysine residue at the P(1) position are quite different not only from other fish MBSPs but also from soluble serine protease obtained from white croaker muscle (MSSP). White croaker MBSP could be therefore classified into a novel type of fish muscle MBSP.     

Identification of a myofibril-bound serine proteinase (MBSP) in the skeletal muscle of lizard fish Saurida wanieso which specifically cleaves the arginine site

A myofibril-bound serine proteinase (MBSP) from the skeletal muscle of lizard fish (Saurida wanieso) was purified to homogeneity by a heating treatment followed by a series of column chromatographies on DEAE-Sephacel, Sephacryl S-200, Q-Sepharose, Hydroxyapatite and Benzamidine-Sepharose 6B, and characterized enzymatically. On SDS-poly-acrylamide gel electrophoresis (SDS-PAGE), the purified enzyme showed a band with molecular mass of approximately 29 kDa under reducing conditions, while 60 kDa under non-reducing conditions. The optimum temperature of the enzyme was 50 degrees C using t-butyloxycarbonyl-Phe-Ser-Arg-4-methylcoumaryl-7-amide (Boc-Phe-Ser-Arg-MCA) as a substrate. Substrate specificity analysis both using MCA-substrates and peptides showed that MBSP specifically cleaved at the carboxyl side of the arginine residue. Inhibitor susceptibility analysis revealed that MBSP was inhibited effectively by Pefabloc SC, soybean trypsin inhibitor (STI) and aprotinin, indicating the characteristic of a serine proteinase. When myofibril was incubated with the enzyme, it optically degraded myosin heavy chain at 55-60 degrees C, while alpha-actinin and actin were not at all hydrolyzed as detected by immunoblotting. The N-terminal amino acid sequence of MBSP was partially determined as IVGGAEXVPY- and was very homologous to other serine proteases.     

A novel serine protease complexed with alpha2-macroglobulin from skeletal muscle of lizard fish (Saurida undosquamis)

A novel fish muscle serine protease named muscle soluble serine protease (MSSP) was purified from the soluble fraction of lizard fish (Saurida undosquamis: Synodontidae) muscle by ammonium sulfate fractionation followed by four steps of column chromatographies. In native-PAGE, the purified enzyme appeared as a single band with an estimated mol. mass of approximately 380 kDa by gel filtration. In SDS-PAGE under reducing conditions, the purified enzyme migrated as two protein bands at 110 and 100 kDa, named subunits A and B, respectively. The 20 residues of N-terminal amino acid sequence of subunit B showed 70% of homology to beta-chain of carp alpha(2)-macroglobulin-1. Moreover, both subunits A and B showed immunoreactivity with anti carp alpha(2)-macroglobulin antibody. Purified MSSP was inactivated by Pefabloc SC, aprotinin, benzamidine and TLCK, but not by alpha(1)-antitrypsin. After acid treatment (pH 2, 24 h), however, the enzyme activity eluted at 14 kDa from Sephacryl S-200 carried out under acidic conditions was inhibited by alpha(1)-antitrypsin. Lizard fish MSSP most rapidly hydrolyzed Boc-Val-Pro-Arg-MCA and Boc-Gln-Arg-Arg-MCA, but did not hydrolyzed Suc-Leu-Leu-Val-Tyr-MCA and Suc-Ala-Ala-Pro-Phe-MCA, and was not suppressed either by E-64, pepstatin A and ethylenediaminetetraacetic acid (EDTA). These results indicate that the purified MSSP is a serine protease complexed with alpha(2)-macroglobulin, and the entrapped protease was dissociated by the acid treatment. Purified and free MSSPs were most active at pH 10.0 and 9.0, respectively. Purified MSSP degraded myofibrillar proteins and casein but time courses of degradation of these substrates by the enzyme differed.     

Purification of a novel serine proteinase inhibitor from the skeletal muscle of white croaker (Argyrosomus argentatus)

A novel serine proteinase inhibitor has been purified to homogeneity from the skeletal muscle of white croaker (Argyrosomus argentatus). The purification was carried out by ammonium sulfate fractionation, DEAE-Sephacel, heating treatment followed by column chromatographies on SP-Sepharose, Sephadex G-150 and gel-filtration high performance liquid chromatography. The molecular mass of the inhibitor was 55 kDa as estimated by SDS-PAGE and gel filtration. It specifically inhibited a myofibril-bound serine proteinase (MBSP) isolated from the skeletal muscle of lizard fish (Saurida wanieso). No inhibition, however, was detected toward other serine proteinases such as bovine trypsin, bovine chymotrypsin and a myofibril-bound serine proteinase from carp (Cyprinus carpio) muscle. Interestingly, the sequences of tryptic digested peptide fragments of MBSPI revealed high identity to that of porcine phosphoglucose isomerase (PGI) (76%) and other PGIs. Furthermore, purified MBSPI exhibits PGI activity, suggesting the inhibitor is a protein closely related to PGI. When rabbit muscle PGI was investigated, it also specifically suppressed the activity of MBSP. It thus strongly suggests that MBSPI is actually PGI and conversely, PGI is a specific inhibitor toward myofibril-bound serine proteinase(s).     

Purification of a novel myofibril-bound serine proteinase inhibitor (MBSPI) from the skeletal muscle of lizard fish

A novel myofibril-bound serine proteinase inhibitor (MBSPI) was purified to homogeneity from the skeletal muscle of lizard fish (Saurida wanieso). Purification was carried out by ammonium sulfate fractionation, followed by column chromatographies on DEAE-Sephacel, SP-Sepharose and Sephadex G-150. MBSPI was purified 7.7-fold starting from the DEAE-Sephacel fraction, with a yield of 0.2%. It is a monomeric protein with the molecular mass of 50 kDa as estimated by SDS-PAGE and gel filtration. MBSPI reveals high inhibition specificity toward a myofibril-bound serine proteinase (MBSP) purified from lizard fish muscle. No inhibition is detected toward bovine trypsin, bovine chymotrypsin, two trypsins from carp hepatopancreas and a serine proteinase isolated from the sarcoplasmic fraction of white croaker muscle. It does not exert any inhibitory activity toward a myofibril-bound serine proteinase from carp muscle.     

A novel serine protease complexed with α2-macroglobulin from skeletal muscle of lizard fish (Saurida undosquamis)

A novel fish muscle serine protease named muscle soluble serine protease (MSSP) was purified from the soluble fraction of lizard fish (Saurida undosquamis: Synodontidae) muscle by ammonium sulfate fractionation followed by four steps of column chromatographies. In native-PAGE, the purified enzyme appeared as a single band with an estimated mol. mass of approximately 380 kDa by gel filtration. In SDS-PAGE under reducing conditions, the purified enzyme migrated as two protein bands at 110 and 100 kDa, named subunits A and B, respectively. The 20 residues of N-terminal amino acid sequence of subunit B showed 70% of homology to β-chain of carp α₂-macroglobulin-1. Moreover, both subunits A and B showed immunoreactivity with anti carp α₂-macroglobulin antibody. Purified MSSP was inactivated by Pefabloc SC, aprotinin, benzamidine and TLCK, but not by α₁-antitrypsin. After acid treatment (pH 2, 24 h), however, the enzyme activity eluted at 14 kDa from Sephacryl S-200 carried out under acidic conditions was inhibited by α₁-antitrypsin. Lizard fish MSSP most rapidly hydrolyzed Boc-Val-Pro-Arg-MCA and Boc-Gln-Arg-Arg-MCA, but did not hydrolyzed Suc-Leu-Leu-Val-Tyr-MCA and Suc-Ala-Ala-Pro-Phe-MCA, and was not suppressed either by E-64, pepstatin A and ethylenediaminetetraacetic acid (EDTA). These results indicate that the purified MSSP is a serine protease complexed with α₂-macroglobulin, and the entrapped protease was dissociated by the acid treatment. Purified and free MSSPs were most active at pH 10.0 and 9.0, respectively. Purified MSSP degraded myofibrillar proteins and casein but time courses of degradation of these substrates by the enzyme differed.     

A study of extracellular alkaline protease from Bacillus subtilis NCIM 2713

An alkaline protease was isolated from culture filtrate of B. subtilis NCIM 2713 by ammonium sulphate precipitation and was purified by gel filtration. With casein as a substrate, the proteolytic activity of the purified protease was found to be optimal at pH 8.0 and temperature 70 degrees C. The purified protease had molecular weight 20 kDa, Isoelectric point 5.2 and km 2.5 mg ml(-1). The enzyme was stable over the pH range 6.5-9.0 at 37 degrees C for 3 hr. During chromatographic separation this protease was found to be susceptible to autolytic degradation in the absence of Ca2+. Ca2+ was not only required for the enzyme activity but also for the stability of the enzyme above 50 degrees C. About 62% activity was retained after 60 min at pH 8.0 and 55 degrees C. DFP and PMSF completely inhibited the activity of this enzyme, while in the presence of EDTA only 33% activity remained. However, it was not affected either by sulfhydryl reagent, or by divalent metal cations, except SDS and Hg2+. The results indicated that this is a serine protease.     

A serine protease from a detergent-soluble extract of Leishmania (Leishmania) amazonensis

Proteases mediate important crucial functions in parasitic diseases, and their characterization contributes to the understanding of host-parasite interaction. A serine protease was purified about 43-fold with a total recovery of 60% from a detergent-soluble extract of promastigotes of Leishmania amazonensis. The purification procedures included aprotinin-agarose affinity chromatography and gel filtration high performance liquid chromatography. The molecular mass of active enzyme was 110 kDa by native gel filtration HPLC and by SDS-PAGE gelatin under non-reducing conditions. Under conditions of reduction using SDS-PAGE gelatin analyses the activity of enzyme was observed in two proteins of 60 and 45 kDa, suggesting that the enzyme may be considered as a dimer. The Leishmania protease was not glycosylated, and its isoelectric point (pI) was around 4.8. The maximal protease activity was at pH 7.0 and 28 degrees C, using a-N-o-tosyl-L-arginyl-methyl ester (L-TAME) as substrate. Assays of thermal stability indicated that this enzyme was totally denatured after pre-treatment at 42 degrees C for 12 min and preserved only 20% of its activity after pre-treatment at 37 degrees C for 24 h, in the absence of substrate. Hemoglobin, bovine serum albumin (BSA), ovalbumin and gelatin were hydrolyzed by Leishmania protease. Inhibition studies indicated that the enzyme belonged to a serine protease class because of a significant impediment by serine protease inhibitors such as benzamidine, aprotinin, and antipain. The activity of the present serine protease is negatively modulated by calcium and zinc and positively modulated by manganese ions. This is the first study that reports the purification of a protease from a detergent-soluble extract of Leishmania species.     

Identification, purification, and characterization of a secretory serine protease in an Indian strain of Leishmania donovani

An aprotinin sensitive serine protease was identified in the culture supernatant of the Indian strain of Leishmania donovani (MHOM/IN/1983/AG83). The protease was subsequently purified and characterized. The apparent molecular mass of the enzyme was 115 kDa in SDS-PAGE under non-reducing condition, while on reduction it showed a 56 kDa protein band indicating that the protease is a dimeric protein. The purified enzyme was optimally active at the pH and temperature of 7.5 and 28 degrees C, respectively. Assays of thermal stability indicated that the enzyme preserved 59% of activity even after pretreatment at 42 degrees C for 1 h. The purified protease was not glycosylated and its isoelectric pI was 5.0. N-alpha-p-tosyl-L-arginine methylester (TAME) appeared to be relatively better substrate among the commonly used synthetic substrates. The enzyme was inhibited by Ca(2+) and Mn(2+), but activated by Zn(2+). The protease could play important role(s) in the pathogenesis of visceral leishmaniasis or kala-azar.     

Purification and characterization of a thermostable alkaline protease from alkalophilic Bacillus pumilus

AIMS: An investigation was carried out on the purification and characterization of an alkaline protease from Bacillus pumilus MK6-5. METHODS AND RESULTS: An alkalophilic Bacillus pumilus MK6-5 was grown in a laboratory fermenter containing 1% reverse osmosis concentrated cheese whey powder, 0.25% corn steep liquor, 1% glucose, 0.5% tryptone, 1% sodium citrate, 0.02% MgSO4.7H2O and 0.65% Na2CO3 at 35 degrees C and pH 9.6, agitation at 250 rev min(-1) and aeration of 1 vvm for 60 h. When the enzyme was purified using ammonium sulphate precipitation, ion exchange and gel filtration chromatographies, a 26.2% recovery of enzyme with 36.6-fold purification was recorded. The purified protease was found to be homogenous by SDS-PAGE with molecular mass estimate of 28 kDa. The enzyme was optimally active at pH 11.5 and temperature of 55-60 degrees C. The Km and kcat values observed with synthetic substrates at 37 degrees C and pH 8.0 were 1.1 mmol l(-1) and 624 s(-1) for Glu-Gly-Ala-Phe-pNA and 3.7 mmol l(-1) and 826 s(-1) for Glu-Ala-Ala-Ala-pNA, respectively. The kinetic data revealed that small aliphatic and aromatic residues were the preferred residues at the P1 position. Inhibition profile exhibited by PMSF suggested the B. pumilus protease to be an alkaline serine protease. CONCLUSIONS: Bacillus pumilus MK6-5 produced a calcium-dependent, thermostable alkaline serine protease. SIGNIFICANCE AND IMPACT OF THE STUDY: The thermostable alkaline protease from Bacillus pumilus MK6-5 will be extremely useful in ultrafiltration membrane cleaning due to its ability to work in broad pH and temperature ranges, and tolerance to detergents, unlike the mesophilic proteases which face these limitations.     

Purification and characterization of alkaline protease with novel properties from Bacillus cereus strain S8

Proteases are the hydrolytic enzymes which hydrolyzes peptide bond between proteins with paramount applications in pharmaceutical and industrial sector. Therefore production of proteases with efficient characteristics of biotechnological interest from novel strain is significant. Hence, in this study, an alkaline serine protease produced by Bacillus cereus strain S8 (MTCC NO 11901) was purified and characterized. The alkaline protease was purified by ammonium sulfate precipitation (50%), ion exchange (DEAE-Cellulose) and gel filtration (Sephadex G-100) chromatographic techniques. As a result of this purification, a protein with specific activity of 300U/mg protein was obtained with purification fold 17.04 and recovery percentage of 34.6%. The molecular weight of the purified protease was determined using SDS-PAGE under non-reducing (71?kDa) and reducing conditions (35?kDa and 22?kDa). Zymogram analysis revealed that proteolytic activity was only associated with 22?kDa. These results indicate that existence of the enzyme as dimer in its native state. The molecular weight of the protease (22?kDa) was also determined by gel filtration (Sephadex G-200) chromatography and it was calculated as 21.8?kDa. The optimum activity of the protease was observed at pH 10.0 and temperature 70?°C with great stability towards pH and temperature with casein as a specific substrate. The enzyme was completely inhibited by PMSF and TLCK indicating that it is a serine protease of trypsin type. The enzyme exhibits a great stability towards organic solvents, oxidizing and bleaching agents and it is negatively influenced by Li²⁺ and Co²⁺ metal ions. The purified protein was further characterized by Matrix Assisted Laser Desorption Ionization/Mass Spectroscopy (MALDI/MS) analysis which reveals that total number of amino acids is 208 with isoelectric point 9.52.     

Purification and characterization of a proteinase inhibitor from white croaker skeletal muscle (Micropogon opercularis)

A trypsin proteinase inhibitor has been purified to homogeneity from the skeletal muscle of white croaker (Micropogon opercularis). Previously, we had described the occurrence in fish muscle of a serine protease (proteinase I) which showed a great capacity to degrade whole myofibrils in vitro and an endogenous inhibitor that prevented the action of the protease, both on natural and artificial substrates. In this paper, we report the purification and further biochemical characterization of the endogenous trypsin inhibitor. The purification was carried out by DEAE-Sephacel, Con A-Sepharose, Sephacryl S-300 and Mono Q. Throughout the purification procedure, trypsin inhibitory activity was assayed using azocasein as substrate. The molecular mass of the inhibitor was 65 kDa, as estimated by SDS-PAGE and gel filtration. The trypsin inhibitor is a glycoprotein, as deduced by the fact that it binds to Con A-Sepharose and stains with PAS and showed a wide range of pH stability (from 5 to 11). The thermal stability of the inhibitor considerably decreased at temperatures >60 degrees C. Assays of the inhibitor against various proteases indicated that it is highly specific for serine proteases, since it did not inhibit proteases belonging to any other groups. The inhibitor was able to inhibit the endogenous target enzyme (proteinase I) in a dose-dependent manner, with a 50% inhibition at a molar ratio close to 1. The present work contributes to improving our understanding of the physiological role of the proteinase I-inhibitor system in muscle protein breakdown, as well as its influence on post mortem proteolysis.     

Purification and characterization of an extracellular protease from Penicillium chrysogenum Pg222 active against meat proteins

An extracellular protease from Penicillium chrysogenum (Pg222) isolated from dry-cured ham has been purified. The purification procedure involved several steps: ammonium sulfate precipitation, ion-exchange chromatography, filtration, and separation by high-performance liquid chromatography. Based on sodium dodecyl sulfate-polyacrylamide gel electrophoresis (SDS-PAGE) analysis and gel filtration, the purified fraction showed a molecular mass of about 35 kDa. The hydrolytic properties of the purified enzyme (EPg222) on extracted pork myofibrillar proteins under several conditions were evaluated by SDS-PAGE. EPg222 showed activity in the range of 10 to 60 degrees C in temperature, 0 to 3 M NaCl, and pH 5 to 7, with maximum activity at pH 6, 45 degrees C, and 0.25 M NaCl. Under these conditions the enzyme was most active against tropomyosin, actin, and myosin. EPg222 showed collagenolytic activity but did not hydrolyze myoglobin. EPg222 showed higher activity than other proteolytic enzymes like papain, trypsin, and Aspergillus oryzae protease. The N-terminal amino acid sequence was determined and was found to be Glu-Asn-Pro-Leu-Gln-Pro-Asn-Ala-Pro-Ser-Trp. This partial amino acid sequence revealed a 55% homology with serine proteases from Penicillium citrinum. The activity of this novel protease may be of interest in ripening and generating the flavor of dry-cured meat products.     

Isolation and purification of an extracellular protease from a new strain of Bacillus subtilis, viz.NCIM 2711

A new extracellular protease having a prospective application in the food industry was isolated from Bacillus sUbtilis NCIM 2711 by (NH4)2SO4 precipitation from the cell broth. It was purified using DEAE-Cellulose and CM-Sephadex C-50 ion-exchange chromatography. With casein as a substrate, the proteolytic activity of the purified protease was found to be optimal at pH 7.0 and temperature 55 degrees C with Km 1.06 mg/ml. The enzyme was stable over a pH range 6.5-8.0 at 30 degrees C for 1 hr in presence of CaCl2 x 2H2O. At 55 degrees C, the enzyme retained 60% activity up to 15 min in presence of CaCl2 x 2H2O. EDTA and o-phenanthroline (OP) completely inhibited the enzyme activity while DFP, PMSF and iodoacetamide were ineffective. The enzyme was completely inhibited by Hg2+ and partially by Cd2+, Cu2+, Ni2+, Pb2+ and Fe2+. The OP inhibited enzyme could be reactivated by Zn2+ and Co2+ up to 75% and 69% respectively. It is a neutral metalloprotease showing a single band of 43 kDa on SDS-PAGE.     

Purification and characterization of a novel protease from the latex of Pedilanthus tithymaloids

A novel protease was purified to homogeneity from the latex of Pedilanthus tithymaloids by a simple purification procedure involving ammonium sulfate precipitation and cation-exchange chromatography. The molecular weight of the protease was estimated to be approximately 63.1 kDa and the extinction coefficient (epsilon(1%)(280nm)) was 28.4. The enzyme hydrolyzes denatured natural substrates like casein, azoalbumin and azocasein with a high specific activity but little activity towards synthetic substrates. The pH and temperature optima were pH 8.0-9.5 and 65-70 degrees C, respectively. The proteolytic activity of the enzyme was inhibited by different protease-specific inhibitors (e.g., thiol, serine, metallo, etc.) up to a certain extent but not completely by any class of inhibitors. The enzyme was relatively stable towards pH change, temperature, denaturants and organic solvents. The enzyme consists of five disulfide bridges compared to three observed in most plant cysteine proteases. Overall, the striking features of this protease are its high molecular weight, high cysteine content and only partial inhibition of activity by different classes of protease inhibitors contrary to known proteases from other plant sources. The enzyme is named as pedilanthin as per the protease nomenclature.     

Purification and characterization of a digestive alkaline protease from the larvae of Spilosoma obliqua

A digestive protease from Spilosoma obliqua (Lepidoptera: Arctiidae) fifth instar larval guts was purified and characterized. The protease was purified using ammonium sulfate fractionation, ion-exchange chromatography, and hemoglobin-sepharose affinity chromatography. The purification procedure resulted in a 37-fold increase in the specific activity of the protease. Protease thus obtained was found to be electrophoretically pure under native and denaturing conditions. The purified protease had a molecular mass of 90 kDa as determined by gel filtration, and a pH optimum of 11.0. The purified protease optimally hydrolyzed casein at 50 degrees C. A Km of 2 x10(-6) M was obtained using BApNA as a substrate for the purified alkaline protease. The ability of S. obliqua protease and bovine trypsin to hydrolyze various synthetic substrates (BApNA, BAEE, and BAME), and the inhibition patterns of S. obliqua and bovine trypsin with "classical" trypsin inhibitors are also reported.     

Production, purification, and characterization of a novel thermostable serine protease from soil isolate, Streptomyces tendae

An isolate of Streptomyces tendae produced a extracellular protease which was purified to apparent homogeneity giving a single band on SDS-PAGE with a molecular mass of 21 kDa. Optimum activity was at 70 degrees C and pH 6. It was stable at 55 degrees C for 30 min and between pH 4 and 9. It was resistant to neutral detergents and organic solvents such as Triton X-100, Tween 80, methanol, ethanol, acetone, and 2-propanol at 5% (v/v). The enzyme was completely inhibited by 5 mM PMSF, indicating it to be a serine protease. N-terminal amino acid sequence did not show any homology with other known proteolytic enzymes. The protease may therefore be a novel neutral serine protease, which is stable at high temperature and over a broad range of pH.     

Purification and biochemical characterization of a protease secreted by the <Emphasis Type="Italic">Salinivibrio</Emphasis> sp. strain AF-2004 and its behavior in organic solvents

A metalloprotease secreted by the moderately halophilic bacterium Salinivibrio sp. strain AF-2004 when the culture reached the stationary growth phase. This enzyme was purified to homogeneity by acetone precipitation and subsequent Q-Sepharose anion exchange and Sephacryl S-200 gel filtration chromatography. The apparent molecular mass of the protease was 31 kDa by SDS-PAGE, whereas it was estimated as approximately 29 kDa by Sephacryl S-200 gel filtration. The purified protease had a specific activity of 116.8 mumol of tyrosine/min per mg protein on casein. The optimum temperature and salinity of the enzyme were at 55 degrees C and 0-0.5 M NaCl, although at salinities up to 4 M NaCl activity still remained. The protease was stable and had a broad pH profile (5.0-10.0) with an optimum of 8.5 for casein hydrolysis. The enzyme was strongly inhibited by phenylmethyl sulfonylfluoride (PMSF), Pefabloc SC, chymostatin and also EDTA, indicating that it belongs to the class of serine metalloproteases. The protease in solutions containing water-soluble organic solvents or alcohols was more stable than that in the absence of organic solvents. These characteristics make it an ideal choice for applications in industrial processes containing organic solvents and/or salts.     

Purification and characterization of an intracellular chymotrypsin-like serine protease from Thermoplasma volcanium

An intracellular serine protease produced by Thermoplasma (Tp.) volcanium was purified using a combination of ammonium sulfate fractionation, ion exchange, and alpha-casein agarose affinity chromatography. This enzyme exhibited the highest activity and stability at pH 7.0, and at 50 degrees C. The purifed enzyme hydrolyzed synthetic peptides preferentially at the carboxy terminus of phenylalanine or leucine and was almost completely inhibited by PMSF, TPCK, and chymostatin, similarly to a chymotrypsin-like serine protease. Kinetic analysis of the Tp. volcanium protease reaction performed using N-succinyl-L-phenylalanine-p-nitroanilide as substrate revealed a Km value of 2.2 mM and a Vmax value of 0.045 micromol(-1) ml(-1) min(-1). Peptide hydrolyzing activity was enhanced by >2-fold in the presence of Ca2+ and Mg2+ at 2-12 mM concentration. The serine protease is a monomer with a molecular weight of 42 kDa as estimated by sodium dodecyl sulfate-polyacrylamide gel electrophoresis and zymogram activity staining.