Rhamnolipid biosurfactant production by strains of Pseudomonas aeruginosa using low-cost raw materials

This study was aimed at the development of economical methods for higher yields of biosurfactant by suggesting the use of low-cost raw materials. Two oil-degrading strains, Pseudomonas aeruginosa GS9-119 and DS10-129, were used to optimize a substrate for maximum rhamnolipid production. Among the two strains, the latter produced maxima of 4.31, 2.98, and 1.77 g/L rhamnolipid biosurfactant using soybean oil, safflower oil, and glycerol, respectively. The yield of biosurfactant steadily increased even after the bacterial cultures reached the stationary phase of growth. Characterization of rhamnolipids using mass spectrometry revealed the presence of dirhamnolipids (Rha-Rha-C(10)-C(10)). Emulsification activity of the rhamnolipid biosurfactant produced by P. aeruginosa DS10-129 was greater than 70% using all the hydrocarbons tested, including xylene, benzene, hexane, crude oil, kerosene, gasoline, and diesel. P. aeruginosa GS9-119 emulsified only hexane and kerosene to that level.     

Enhanced Biodegradation of Casablanca Crude Oil by A Microbial Consortium in Presence of a Rhamnolipid Produced by Pseudomonas Aeruginosa AT10

The biodegradation of oil products in the environment is often limited by their low water solubility and dissolution rate. Rhamnolipids produced by Pseudomonas aeruginosa AT10 were investigated for their potential to enhance bioavailability and hence the biodegradation of crude oil by a microbial consortium in liquid medium. The characterization of the rhamnolipids produced by strain AT10 showed the effectiveness of emulsification of complex mixtures. The addition of rhamnolipids accelerates the biodegradation of total petroleum hydrocarbons from 32% to 61% at 10 days of incubation. Nevertheless, the enhancement of biosurfactant addition was more noticeable in the case of the group of isoprenoids from the aliphatic fraction and the alkylated polycyclic aromatic hydrocarbons (PHAS) from the aromatic fraction. The biodegradation of some targeted isoprenoids increased from 16% to 70% and for some alkylated PAHs from 9% to 44%.     

Cell surface properties of Pseudomonas stutzeri in the process of diesel oil biodegradation

Pseudomonas stutzeri, isolated from crude oil-contaminated soil, was used to degrade diesel oil. Of three surfactants, 120?mg rhamnolipids 1(-1) significantly increased degradation of diesel oil giving 88% loss after 14?days compared to 54% loss without the surfactant. The system with rhamnolipids was characterised by relatively high particle homogeneity. However, the addition of saponins to diesel oil caused the cells to aggregate (the polydispersity index: 0.542) and the biodegradation of diesel oil was only 46%. The cell yield was 0.22?g?l(-1).     

Isolation and Characterization of Novel Strains of <Emphasis Type="Italic">Pseudomonas aeruginosa</Emphasis> and <Emphasis Type="Italic">Serratia marcescens</Emphasis> Possessing High Efficiency to Degrade Gasoline,Kerosene, Diesel Oil,and Lubricating Oil

Bacteria possessing high capacity to degrade gasoline, kerosene, diesel oil, and lubricating oil were screened from several areas of Hokkaido, Japan. Among isolates, two strains, WatG and HokM, which were identified as new strains of Pseudomonas aeruginosa and Serratia marcescens species, respectively, showed relatively high capacity and wide spectrum to degrade the hydrocarbons in gasoline, kerosene, diesel, and lubricating oil. About 90-95% of excess amount of total diesel oil and kerosene added to mineral salts media as a sole carbon source could be degraded by WatG within 2 and 3 weeks, respectively. The same amount of lubricating oil was 60% degraded within 2 weeks. Strain HokM was more capable than WatG in degrading aromatic compounds in gasoline. This strain could also degrade kerosene, diesel, and lubricating oil with a capacity of 50-60%. Thus, these two isolates have potential to be useful for bioremediation of sites highly contaminated with petroleum hydrocarbons.     

Oil wastes as unconventional substrates for rhamnolipid biosurfactant production by Pseudomonas aeruginosa LBI

Oil wastes were evaluated as alternative low-cost substrates for the production of rhamnolipids by Pseudomonas aeruginosa LBI strain. Wastes obtained from soybean, cottonseed, babassu, palm, and corn oil refinery were tested. The soybean soapstock waste was the best substrate, generating 11.7 g/L of rhamnolipids with a surface tension of 26.9 mN/m, a critical micelle concentration of 51.5 mg/L, and a production yield of 75%. The monorhamnolipid RhaC(10)C(10) predominates when P. aeruginosa LBI was cultivated on hydrophobic substrates, whereas hydrophilic carbon sources form the dirhamnolipid Rha(2)C(10)C(10) predominantly.     

Isolation and characterization of biosurfactant producing <Emphasis Type="Italic">Bacillus</Emphasis> sp. from diesel fuel-contaminated site

Among hydrocarbon pollutants, diesel oil is a complex mixture of alkanes and aromatic compounds which are often encountered as soil contaminants leaking from storage tanks and pipelines or as result of accidental spillage. One of the best ecofriendly approaches is to restore contaminated soil by using microorganisms able to degrade those toxic compounds in a bioremediation process. In the present study, nineteen bacteria were isolated by enrichment culture technique from diesel spilled soil collected from electric generator shed of NBAIM, Mau. All the isolates were subjected to screening for lipase production and twelve isolates were found to be positive for lipase. When the isolates were screened for biosurfactant production using CTAB-methylene blue agar plates, only one isolate viz. 2NBDSH3 was found positive which was found to be phylogenetically closely related with Bacillus flexus. Despite having low emulsification index, the bacterium could degrade 88.6% of diesel oil in soil. Biosurfactant from the isolate was extracted and characterized through infra-red spectroscopy which indicated its possible lipopeptide nature which was further supported by strong absorption in UV range in the UV-Vis spectrum. The results of the present study indicated that the isolate either does not produce any bioemulsifier or produces very low amount of emulsifier rather it produces a lipopeptide biosurfactant which helps in degradation of diesel oil by lowering the surface tension. The bacterium thus isolated and characterized can serve as a promising solution for ecofriendly remediation of bacterium diesel contaminated soils.     

Production of biosurfactant using different hydrocarbons by Pseudomonas aeruginosa EBN-8 mutant

The present investigation dealt with the use of previously isolated and studied gamma-ray mutant strain Pseudomonas aeruginosa EBN-8 for the production of biosurfactant by using different hydrocarbon substrates viz. n-hexadecane, paraffin oil and kerosene oil, provided in minimal medium, as the sole carbon and energy sources. The batch experiments were conducted in 250 mL Erlenmeyer flasks, containing 50 mL minimal salt media supplemented with 1% (w/v) hydrocarbon substrate, inoculated by EBN-8 and incubated at 37 degrees C and 100 rpm in an orbital shaker. The sampling was done on 24 h basis for 10 d. The surface tension of cell-free culture broth decreased from 53 to 29 mN/m after 3 and 4 d of incubation when the carbon sources were paraffin oil and n-hexadecane, respectively. The largest reduction in interfacial tension from 26 to 0.4 mN/m was observed with n-hexadecane, while critical micelle dilution was obtained as 50 x CMC for paraffin oil as carbon source. When grown on n-hexadecane and paraffin oil, the EBN-8 mutant strain gave 4.1 and 6.3 g of the rhamnolipids/L, respectively. These surface-active substances subsequently allowed the hydrocarbon substrates to disperse readily as emulsion in aqueous phase.     

The Influence of Rhamnolipids on Aliphatic Fractions of Diesel Oil Biodegradation by Microorganism Combinations

Twelve different bacteria–yeast combinations were tested for determination of their ability to biodegrade diesel oil. The cell surface properties of the bacterial and yeast strains were correlated with the type of carbon source used in the experiments. The highest biodegradation of diesel oil after 7 days was obtained for the following combinations: Aeromonas hydrophila MR4–Yarrowia lipolytica EH 56 (87 %) and Xantomonas maltophila MRP7–Candida maltosa EH15 (90 %). Degradation performances of 10 of 12 combinations were enhanced by the presence of rhamnolipids. The highest increases were observed for A. hydrophila MR4–C. maltosa EH15 (from 34 to 67 %), A. hydrophila MR4–C. maltosa EH60 (from 47 to 76 %) and for Pseudomonas stutzeri MR7–C. maltosa EH60 (from 29 to 79 %). The addition of rhamnolipids to the system reduces the removal time of diesel oil from the contaminated water and changes the microbial adhesion to hydrocarbons. Modification of the cell surface of the tested strain during biodegradation is a very important factor determining the removal of hydrophobic compounds.     

Isolation and characterization of biosurfactant production under extreme environmental conditions by alkali-halo-thermophilic bacteria from Saudi Arabia

Twenty three morphologically distinct microbial colonies were isolated from soil and sea water samples, which were collected from Jeddah region, Saudi Arabia for screening of the most potent biosurfactant strains. The isolated bacteria were selected by using different methods as drop collapse test, oil displacement test, blue agar test, blood hemolysis test, emulsification activity and surface tension. The results showed that the ability of Virgibacillus salarius to grow and reduce surface tension under a wide range of pH, salinities and temperatures gives bacteria isolate an advantage in many applications such as pharmaceutical, cosmetics, food industries and bioremediation in marine environment. The biosurfactant production by V. salarius decreased surface tension and emulsifying activity (30 mN/m and 80%, respectively). In addition to reducing the production cost of biosurfactants by tested several plant-derived oils such as jatropha oil, castor oils, jojoba oil, canola oil and cottonseed oil. In this respect the feasibility to reusing old frying oil of sunflower for production rhamnolipids and sophorolipids, their use that lead to solve many ecological and industrial problems.     

不同结构配比的鼠李糖脂乳化活性与油泥清洗效果

以大庆油田原油和含油污泥为对象,研究不同结构配比鼠李糖脂表面活性剂乳化活性及其对含油污泥清洗效果的影响,并优化清洗工艺参数。结果表明:单鼠李糖脂比例越高,其表面活性越好;双鼠李糖脂比例越高,其对原油的乳化能力越强;临界胶束浓度随着双鼠李糖脂比例的增加而逐渐加大;单、双鼠李糖脂配比不同的表活剂对油泥的清洗效果也不同,质量比为50∶50时清洗效率最高;鼠李糖脂浓度为1.0 g·L^-1、热洗时间为1.5h、热洗温度为65℃、洗脱强度为220 r·min^-1、固液质量比为1∶5条件下,油泥的清洗效率最高,可达81.3%;含油率为29.6%的落地油泥,经一级洗涤后油泥残油率降至5.5%,原油回收率达到87.3%,清洗出的原油无明显乳化,易于分离。由此可知,鼠李糖脂的单、双糖脂比例不同对其理化性质和清洗含油污泥的效果均有不同程度的影响。     

Sunflower seed oil and oleic acid utilization for the production of rhamnolipids by Thermus thermophilus HB8

The potential production of rhamnolipids was demonstrated using the thermophilic eubacterium Thermus thermophilus HB8 and sunflower seed oil or oleic acid as carbon sources. Sunflower seed oil was directly hydrolyzed by secretion of lipase and became a favorable carbon source for rhamnolipids production. Rhamnolipids levels were attainted high values, comparable to those produced by Pseudomonas strains from similar sources. Rhamnolipids synthesis in oleic acid exhibited a long period of induction, while in sunflower seed oil, the synthesis is more rapid. Glucose resulted in a more protracted period of rhamnolipids production after exhaustion of each or both carbon sources. Both mono- and di-rhamnolipids were identified by thin-layer chromatography (TLC) in the total rhamnolipids extract. The molecular composition of the produced biosurfactant was evaluated by Fourier transform infrared (FTIR) and attenuated total reflection Fourier transform infrared (ATR-FTIR) spectroscopy and LC-MS analysis. Furthermore, secretion of rhamnolipids was confirmed on agar plates. The antimicrobial activity of rhamnolipids was detected against the bacterium Micrococcus lysodeikticus using a lysoplate assay. These results demonstrate that rhamnolipids produced in these substrates can be useful in both environmental and food industry applications by using cheap oil wastes. The alternative use of this thermophilic microorganism opens a new perspective concerning the valorization of wastes containing plant oils or frying oils to reduce the cost of rhamnolipids production.     

Isolation and characterization of rhamnolipid-producing bacterial strains from a biodiesel facility

Novel strains of rhamnolipid-producing bacteria were isolated from soils at a biodiesel facility on the basis of their ability to grow on glycerol as a sole carbon source. Strains were identified as Acinetobacter calcoaceticus , Enterobacter asburiae , Enterobacter hormaechei , Pantoea stewartii , and Pseudomonas aeruginosa . The strains of the former five species were found to produce rhamnolipids in quantities the same as, or similar to, coisolated strains of P. aeruginosa . Measurements of surface tension revealed that that emulsifying properties of these strains were similar to levels displayed by rhamnolipids produced by P. aeruginosa . Results of matrix-assisted laser desorption/ionization time-of-flight MS analyses revealed that the predominant compounds made by all strains were C₁₀–C₁₀ mono- and dirhamnolipids. Notably, E. hormaechei and one strain of A. calcoaceticus produced rhamnolipids in amounts similar to the pseudomonads. As all strains examined were from the same taxonomic class of Proteobacteria , further examination of this group may reveal many additional species not previously known to produce rhamnolipids in addition to novel strains of species currently known to produce rhamnolipids.     

Biosurfactant Production by <Emphasis Type="Italic">Pseudomonas aeruginosa</Emphasis> from Renewable Resources

This study deals with production and characterization of biosurfactant from renewable resources by Pseudomonas aeruginosa. Biosurfactant production was carried out in 3L fermentor using waste motor lubricant oil and peanut oil cake. Maximum biomass (11.6 mg/ml) and biosurfactant production (8.6 mg/ml) occurred with peanut oil cake at 120 and 132 h respectively. Characterization of the biosurfactant revealed that, it is a lipopeptide with chemical composition of protein (50.2%) and lipid (49.8%). The biosurfactant (1 mg/ml) was able to emulsify waste motor lubricant oil, crude oil, peanut oil, kerosene, diesel, xylene, naphthalene and anthracene, comparatively the emulsification activity was higher than the activity found with Triton X-100 (1 mg/ml). Results obtained in the present study showed the possibility of biosurfactant production using renewable, relatively inexpensive and easily available resources. Emulsification activity found with the biosurfactant against different hydrocarbons showed its possible application in bioremediation of environments polluted with various hydrocarbons.     

Simultaneous production of polyhydroxyalkanoates and rhamnolipids by Pseudomonas aeruginosa

The feasibility of the simultaneous production of polyhydroxyalkanoates (PHAs) and rhamnolipids, as a novel approach to reduce their production costs, was demonstrated by the cultivation of Pseudomonas aeruginosa IFO3924. Fairly large amounts of PHAs and rhamnolipids were obtained from the bacterial cells and the culture supernatant, respectively. Decanoate was a more suitable carbon source than ethanol and glucose for the simultaneous production, although glucose was suitable for cell growth without an induction period under pH control. The kind of carbon source affected PHA monomer composition markedly and PHA molecular weight slightly. Monorhamnolipids and dirhamnolipids were included in the rhamnolipids extracted from the culture supernatant using decanoate, glucose, or ethanol as the carbon source. Both PHAs and rhamnolipids were synthesized after the growth phase. PHA content in the cell reached a maximum when the carbon source was exhausted. After exhaustion of the carbon source, PHA content decreased rapidly, but rhamnolipid synthesis, which followed PHA synthesis, continued. This resulted in a time lag for the attainment of maximum levels of PHAs and rhamnolipids. The reusability of the cells used in rhamnolipid production was evaluated in the repeated batch culture of P. aeruginosa IFO3924 for the simultaneous production of PHAs and rhamnolipids. High concentrations of rhamnolipids in the culture supernatant were attained at the end of both the first and second batch cultures. High PHA content was achieved in the resting cells that were finally harvested after the second batch. Simultaneous production of PHAs and rhamnolipids will enhance the availability of valuable biocatalysts of bacterial cells, and dispel the common belief that the production cost of PHAs accumulated intracellularly is almost impossible to become lower than that of cells themselves.     

生物表面活性剂产生菌的筛选

从１０００份土壤和水等样品中,经富集培养、血平板分离、摇瓶培养和排油活性测定等方法筛选出１０株能产生各种生物表面活性剂的菌株（包括细菌,酵母和霉菌）。其中一株细菌产海藻糖脂,一株细菌产鼠李糖脂,两株细菌分别产长碳链不饱和脂肪酸和壬二酸,两株酵母产生的脂多糖具有良好的乳化性能     

The Potential of Bacterial Isolates for Emulsification with a Range of Hydrocarbons

A study was undertaken to investigate the distribution of biosurfactant producing and crude oil degrading bacteria in the oil contaminated environment. This research revealed that hydrocarbon contaminated sites are the potent sources for oil degraders. Among 32 oil degrading bacteria isolated from ten different oil contaminated sites of gasoline and diesel fuel stations, 80% exhibited biosurfactant production. The quantity and emulsification activity of the biosurfactants varied. Pseudomonas sp. DS10‐129 produced a maximum of 7.5 ± 0.4 g/l of biosurfactant with a corresponding reduction in surface tension from 68 mN/m to 29.4 ± 0.7 mN/m at 84 h incubation. The isolates Micrococcus sp. GS2‐22, Bacillus sp. DS6‐86, Corynebacterium sp. GS5‐66, Flavobacterium sp. DS5‐73, Pseudomonas sp. DS10‐129, Pseudomonas sp. DS9‐119 and Acinetobacter sp. DS5‐74 emulsified xylene, benzene, n‐hexane, Bombay High crude oil, kerosene, gasoline, diesel fuel and olive oil. The first five of the above isolates had the highest emulsification activity and crude oil degradation ability and were selected for the preparation of a mixed bacterial consortium, which was also an efficient biosurfactant producing oil emulsifying and degrading culture. During this study, biosurfactant production and emulsification activity were detected in Moraxella sp., Flavobacterium sp. and in a mixed bacterial consortium, which have not been reported before.     

Degradation of anthracene by bacteria isolated from oil polluted tropical soils

Four bacteria, identified as Pseudomonas aeruginosa, Alcaligenes eutrophus, Bacillus subtilis and Micrococcus luteus were isolated from crude oil polluted soils using anthracene as the sole carbon and energy source. All the organisms utilized n-hexadecane, n-tetradecane, diesel oil, engine oil and naphthalene as sole carbon sources. None could utilize hexane, cycloheptane, xylene, benzene, toluene, phenol, fluoranthene,and kerosene as carbon sources. Highest cell density obtained with 0.1% (w/v) anthracene were 4.5 x 10(7) (cfu/ml), 8.6 x 10(6) (cfu/ml), 5.4 x 10(6) and 2.4 x 10(6) (cfu/ml) respectively, for P. aeruginosa, A. eutrophus, B. subtilis and M. luteus after 30 days incubation. Growth of the organisms on a Nigerian crude oil resulted in a residual oil concentration of 22.2%, 33.3%, 39.3%, 44% and 91.7% respectively, for P. aeruginosa, A. eutrophus, B. subtilis, M. luteus and the noninoculated control on the 14 th day. Ring fission enzymes of the meta pathway were detected in induced cells of P. aeruginosa and A. eutrophus while ortho pathway enzymes were detected in B. subtilis and M. luteus. P. aeruginosa and A. eutrophus had specific catechol-2,3-dioxygenase activities of 3.8 +/- 0.183 and 0.64 +/- 0.032 micromol/min x mg protein respectively while catechol-1,2-dioxygenase activities of 1.95 +/- 0.029 and 1.89 +/- 0.026 micromol/min x mg protein were detected in B. subtilis and M. luteus respectively. This work, highlights the capability of these unreported tropical strains of A. eutrophus, B. subtilis and M. luteus as anthracene degraders.     

Isolation and Characterization of Biosurfactant-Producing Bacteria from Oil-Contaminated Soil

Two biosurfactant-producing Pseudomonas aeruginosa strains (KISR C1 and KISR B1) were isolated from Kuwaiti oil-contaminated soil, which resulted from the Gulf War. The optimum environmental conditions that supported the growth and surfactant production of both isolates were examined. The two isolates differed in their biosurfactant-stimu-lating carbon source, nitrogen concentration, and the pH of the medium. C-1 isolate produced two types of rhamnolipids with a final concentration of 98.4?g/l after spiking the nitrogen-limited medium with 10?mg/ml olive oil. The other isolate (B-1) produced only one type of rhamnolipid (5.9?g/l) after spiking the medium with crude oil. The biosurfactant produced by this strain was found to be very effective in the emulsifica-tion of crude oil. The result suggests that this isolate can potentially be used to enhance bioremediation of oil-contamination and enhanced oil recovery.     

Identification of small RNAs involved in nitrogen fixation in Anabaena sp. PCC 7120 based on RNA-seq under steady state conditions

The aim of the present study was to investigate the tolerance of five new Achromobacter and Pseudomonas strains to kerosene and to establish if the production of several secondary metabolites increases or not when these bacteria were grown in the presence of kerosene. The biodegradation of kerosene by isolated bacteria was also investigated in this study. Five Proteobacteria were isolated from different samples polluted with petroleum and petroleum products. Based on their morphological, biochemical, and molecular characteristics, isolated bacteria were identified as Achromobacter spanius IBBPo18 and IBBPo21, Pseudomonas putida IBBPo19, and Pseudomonas aeruginosa IBBPo20 and IBBPo22. All these bacteria were able to tolerate and degrade kerosene. Higher tolerance to kerosene and degradation rates were observed for P. aeruginosa IBBPo20 and IBBPo22, compared with that observed for A. spanius IBBPo18 and IBBPo21, and P. putida IBBPo19. All these bacteria were able to produce several secondary metabolites, such as surfactants and pigments. Glycolipid surfactants produced by P. aeruginosa IBBPo20 and IBBPo22, A. spanius IBBPo18 and IBBPo21, and P. putida IBBPo19 have a very good emulsification activity, and their activity increased when they were grown in the presence of kerosene. The production of rhamnolipid surfactants by P. aeruginosa IBBPo20 and IBBPo22 was confirmed by detection of rhlAB gene involved in their biosynthesis. Pyocyanin and pyoverdin pigments were produced only by P. aeruginosa IBBPo20 and IBBPo22, while carotenoid pigments were produced by all the isolated bacteria. Significant changes in pigments production were observed when P. aeruginosa IBBPo20 and IBBPo22, A. spanius IBBPo18 and IBBPo21, and P. putida IBBPo19 were grown in the presence of kerosene. Due to their ability to tolerate and degrade kerosene, and also to produce several secondary metabolites, the isolated bacteria could be used in the bioremediation of kerosene-polluted environments.     

Positive control of swarming, rhamnolipid synthesis, and lipase production by the posttranscriptional RsmA/RsmZ system in Pseudomonas aeruginosa PAO1

In Pseudomonas aeruginosa, the small RNA-binding, regulatory protein RsmA is a negative control element in the formation of several extracellular products (e.g., pyocyanin, hydrogen cyanide, PA-IL lectin) as well as in the production of N-acylhomoserine lactone quorum-sensing signal molecules. RsmA was found to control positively the ability to swarm and to produce extracellular rhamnolipids and lipase, i.e., functions contributing to niche colonization by P. aeruginosa. An rsmA null mutant was entirely devoid of swarming but produced detectable amounts of rhamnolipids, suggesting that factors in addition to rhamnolipids influence the swarming ability of P. aeruginosa. A small regulatory RNA, rsmZ, which antagonized the effects of RsmA, was identified in P. aeruginosa. Expression of the rsmZ gene was dependent on both the global regulator GacA and RsmA, increased with cell density, and was subject to negative autoregulation. Overexpression of rsmZ and a null mutation in rsmA resulted in quantitatively similar, negative or positive effects on target genes, in agreement with a model that postulates titration of RsmA protein by RsmZ RNA.