Mutants of Pachysolen tannophilus with Improved Production of Ethanol from d-Xylose

The conversion of d-xylose to ethanol by the yeast Pachysolen tannophilus is relatively inefficient in batch culture. The inefficiency has been attributed in part to concurrent utilization of ethanol in the presence of appreciable concentrations of d-xylose and to the formation of xylitol and other by-products. To increase the concentration of ethanol accumulated in batch cultures, UV-induced mutants of P. tannophilus were selected on the basis of diminished growth on ethanol. Eleven independent mutant loci that conferred the ethanol-defective phenotype were identified. Three led to a greater yield and volumetric rate of production of ethanol than the wild type. One also produced less xylitol and was characterized by a deficiency in activity for malate dehydrogenase.     

Peculiarities of hybrid formation and copulation activity in the yeast <Emphasis Type="Italic">Pachysolen tannophilus</Emphasis>

The copulation activity and hybrid formation efficiency have been studied in the xylose-assimilating yeast Pachysolen tannophilus. It was shown that the presence of 2% D-glucose, 0.5% yeast extract, and 2% agarose in the growth medium provided for the highest frequencies of hybrid formation. Atypical hybrid cultures similar in morphophysiological characteristics to native haploid strains of P. tannophilus were revealed in the course of hybridization. The genesis mechanism of such culture and the reasons for the restricted applicability of hybridological analysis to genetic studies of P. tannophilus are discussed.     

Isolation of a nucleotide activated disaccharide pentapeptide precursor from Methanobacterium thermoautotrophicum

The yeasts Pachysolen tannophilus and Pichia stipitis differed in their ability to utilize D-xylose in the presence of D-fructose. When P. tannophilus was grown aerobically in fructose-xylose mixture, the ketohexose was utilized preferentially over the pentose. However, in P. stipitis cultures, the converse was observed. The effect was associated with the ability of D-fructose to repress the induction of xylose reductase and xylitol dehydrogenase activities in P. tannophilus but not in P. stipitis. Both yeasts grew on D-fructose and fermented it to ethanol when it was supplied as the sole carbon source. The results suggest that there may exist some fundamental difference in the regulation of D-fructose metabolism between P. tannophilus and P. stipitis.     

Conditions favoring differentiation and stabilization of the life cycle of the yeast Pachysolen tannophilus

Conditions favoring differentiation and stabilization of the life cycle of the yeast Pachysolen tannophilus have been studied. When concentrations of the carbon source in the medium were lower than 100 g/l, it was found to be favorable to the mating of vegetative cells, both haploid and diploid. The addition of nitrogen and sulfur sources to the medium influenced the life phases of haploid cells and partially stabilized the vegetative growth of diploid cells. Enrichment of the nutrient medium with potassium, vitamins, and microelements was shown to be necessary for the formation and maturation of conjugated ascospores. Microelements, vitamins, and phosphorus in excessive amounts activated conjugation but did not provide for the distinct phases of formation of unconjugated asci and spores in the diploid cells. Possible reasons for the unstable diplophase in the yeast P. tannophilus are discussed.     

Existence of Cyanide-Insensitive Respiration in the Yeast Pichia stipitis and Its Possible Influence on Product Formation during Xylose Utilization

A cyanide-insensitive and salicyl hydroxamic acid-sensitive respiration (CIR) was found in the yeast Pichia stipitis in contrast to Candida utilis, Pachysolen tannophilus, and Saccharomyces cerevisiae. During xylose utilization in the presence of either salicyl hydroxamic acid or cyanide, P. stipitis formed xylitol, arabitol, and ribitol. The existence of CIR is discussed in terms of a redox sink preventing xylitol formation in P. stipitis.     

Conversion of D-xylose to ethanol by the yeast Pachysolen tannophilus

The yeast Pachysolen tannophilus was found to be capable of converting D-xylose to ethanol. Batch cultures initially containing 50 g/L D-xylose yielded 0.34 g of ethanol per gram of pentose consumed. Aerobic conditions were required for cell growth but not for ethanol production. Both alcohol formation and growth were optimum when incubation temperature was 32 degrees C, when pH was near 2.5, and when D-xylose and ethanol concentrations did not exceed 50 and 20 g/L, respectively.     

Induction of Xylose Reductase and Xylitol Dehydrogenase Activities in Pachysolen tannophilus and Pichia stipitis on Mixed Sugars

The induction of xylose reductase and xylitol dehydrogenase activities on mixed sugars was investigated in the yeasts Pachysolen tannophilus and Pichia stipitis. Enzyme activities induced on d-xylose served as the controls. In both yeasts, d-glucose, d-mannose, and 2-deoxyglucose inhibited enzyme induction by d-xylose to various degrees. Cellobiose, l-arabinose, and d-galactose were not inhibitory. In liquid batch culture, P. tannophilus utilized d-glucose and d-mannose rapidly and preferentially over d-xylose, while d-galactose consumption was poor and lagged behind that of the pentose sugar. In P. stipitis, all three hexoses were used preferentially over d-xylose. The results showed that the repressibility of xylose reductase and xylitol dehydrogenase may limit the potential of yeast fermentation of pentose sugars in hydrolysates of lignocellulosic substrates.     

Concurrent Production and Consumption of Ethanol by Cultures of Pachysolen tannophilus Growing on d-Xylose

Growing cultures of Pachysolen tannophilus concurrently consumed and produced ethanol in the presence of substantial concentrations of d-xylose. Ethanol was also assimilated in the presence of other sugars, the amount depending on the sugar. Less ethanol assimilation occurred with d-glucose than with d-xylose. The rate of ethanol consumption decreased as the concentration of glucose was increased, but some consumption still occurred when 2% glucose was present. The rate increased with the amount of oxygen available to the culture when d-xylose or ethanol was the carbon source. In most instances, estimates of consumption were based on the extent of incorporation of C from [1-C]ethanol into trichloroacetic acid-insoluble material. The results are pertinent to the use of P. tannophilus for the production of ethanol from d-xylose.     

Effects of Glutathione Modulation on Oxidative Stress and Enzymatic Antioxidant Defence in Yeast Pachysolen tannophilus

The aim of this study was to explore the relationship of intracellular glutathione with various oxidative stress markers and the stress protectant marker trehalose. In the first group of yeast cells, diethyl maleate was used for depletion of glutathione. A second group of yeast cells were incubated with amino acids constituting glutathione (GIu, Cys, Gly) to increase glutathione level. Increased level of oxidative stress marker like ROS, protein carbonyl formation and lipid peroxidation and decreased viability in glutathione-depleted cells were observed in the present study. The increased activity of antioxidant enzymes SOD and CAT in the glutathione depleted group suggests the interaction of different antioxidant defence system in Pachysolen tannophilus. Furthermore, the increased levels of trehalose in glutathione-depleted group shows that trehalose acts as a stress reducer in glutathione depleted Pachysolen tannophilus.     

Fluorescence measurements under aerobic and anaerobic conditions on Pichia stipitis,Pachysolen tannophilus and Candida utilis grown on D-xylose

Batch growth of the yeasts Candida utilis, Pachysolen tannophilus and Pichia stipitis on 1% D-xylose was monitored using a commercial fluorosensor with an excitation wavelength of 340 nm and a detection wavelength of 460 nm. Step changes in oxygen concentration were made and in the presence of 0.3 g/l of xylose, step changes from aerobic to anaerobic conditions resulted in an increase of the fluorescence level by about 40% for the non-fermentative yeast C. utilis. However, the increases of the fluorescence levels for P. tannophilus and P. stipitis stayed below 10%. These measurements indicate better control of (or better redox balance for) intracellular NADH concentration in P. tannophilus and P. stipitis than in C. utilis.List of Symbols F NFU fluorescence - F ₀ NFU initial fluorescence - F NFU final fluorescence difference - t s time - s time constant     

Xylitol dehydrogenase from Pachysolen tannophilus

Abstract NAD-xylitol-dehydrogenase (EC 1.1.1.9) from Pachysolen tannophilus was investigated in relation to xylitol byproduction during xylose fermentation by this yeast. For this purpose the enzyme was partially purified by a combination of affinity chromatography and fast liquid protein chromatography. The enzyme catalyzes an equilibrium reaction which at physiological pH values favours the accumulation of xylitol. The kinetics of the enzyme were shown to be Michaelis-Menten type with respect to both reaction directions. The activity of the enzyme was shown to be under the influence of the 'catabolic reduction charge' (NADH/NAD + NADH) and ATP. The apparent equilibrium constant of the enzyme may explain the considerable byproduction of xylitol during xylose fermentation by P. tannophilus .     

A new type of antagonistic activity of Saccharomycetes yeasts and its mode of inheritance

New type of killer activity of Saccharomyces cerevisiae was found. About 40% of this yeast strains tested formed growth inhibition zones on the lawn of the sensitive yeast Pachysolen tannophilus (Boldin et Adzet) BKM y-274. As shown by crossing these killers with non-killers and the tetrad analysis of hybrids obtained, 2 killer: 2 non-killer segregation took place, indicating the chromosomal mode of inheritance of the character. Mutants with weak expression of this killer activity were obtained after treating with 5-fluorouracil and cycloheximide.     

Potential utilization of sorghum field waste for fuel ethanol production employing Pachysolen tannophilus and Saccharomyces cerevisiae

In this study, we demonstrate that the sorghum field waste, sorghum stover could be used to produce fuel grade ethanol. The alkaline treatment of 2% NaOH for 8h removed 64% of lignin from sorghum stover. Maximum of 68 and 56 g/L of ethanol yield were obtained by Saccharomyces cerevisiae (MTCC 173) and Pachysolen tannophilus (MTCC 1077) from sorghum stover under optimized condition, respectively. pH and temperature were optimized for the better growth of S. cerevisiae and P. tannophilus. A total of 51% and 48% more ethanol yield was obtained at initial sugar concentration of 200 g/L than 150 g/L by P. tannophilus and S. cerevisiae, respectively. Respiratory deficiency and ethanol tolerance of the organisms were studied. This investigation showed that sorghum field waste could be effectively used for the production of fuel ethanol to avoid conflicts between human food use and industrial use of crops.     

Induction of NADPH-linked D-xylose reductase and NAD-linked xylitol dehydrogenase activities in Pachysolen tannophilus by D-xylose, L-arabinose, or D-galactose

Considerable interest in the D-xylose catabolic pathway of Pachysolen tannophilus has arisen from the discovery that this yeast is capable of fermenting D-xylose to ethanol. In this organism D-xylose appears to be catabolized through xylitol to D-xylulose. NADPH-linked D-xylose reductase is primarily responsible for the conversion of D-xylose to xylitol, while NAD-linked xylitol dehydrogenase is primarily responsible for the subsequent conversion of xylitol to D-xylulose. Both enzyme activities are readily detectable in cell-free extracts of P. tannophilus grown in medium containing D-xylose, L-arabinose, or D-galactose and appear to be inducible since extracts prepared from cells growth in media containing other carbon sources have only negligible activities, if any. Like D-xylose, L-arabinose and D-galactose were found to serve as substrates for NADPH-linked reactions in extracts of cells grown in medium containing D-xylose, L-arabinose, or D-galactose. These L-arabinose and D-galactose NADPH-linked activities also appear to be inducible, since only minor activity with L-arabinose and no activity with D-galactose is detected in extracts of cells grown in D-glucose medium. The NADPH-linked activities obtained with these three sugars may result from the actions of distinctly different enzymes or from a single aldose reductase acting on different substrates. High-performance liquid chromatography and gas-liquid chromatography of in vitro D-xylose, L-arabinose, and D-galactose NADPH-linked reactions confirmed xylitol, L-arabitol, and galactitol as the respective conversion products of these sugars. Unlike xylitol, however, neither L-arabitol nor galactitol would support comparable NAD-linked reaction(s) in cellfree extracts of induced P. tannophilus. Thus, the metabolic pathway of D-xylose diverges from those of L-arabinose or D-galactose following formation of the pentitol.     

Ethanol production from d-galactose and glycerol by Pachysolen tannophilus

Pachysolen tannophilus has recently been shown to be able to convert d-xylose, a pentose, to ethanol. Previously, d-xylose had been considered to be nonfermentable by yeasts. The present study shows that the organism can be used to obtain ethanol from other carbohydrates previously considered as nonfermentable, either by P. tannophilus in particular, d-galactose, or by yeasts in general, glycerol. Such identification for d-galactose allows P. tannophilus to be considered for fermentation of four of the five major plant monosaccharides: d-glucose, d-mannose, d-galactose and d-xylose. The ability to ferment glycerol is of potential use, in part, for the conversion of glycerol derived from algae into ethanol.     

Microaerophilic metabolism of Pachysolen tannophilus at different pH values

Microaerophilic production of xylitol by Pachysolen tannophilus from detoxified hemicellulose hydrolyzate was optimal between pH values 6.0 to 7.5 when about 90% of xylose was utilized for xylitol production, the rest being fermented to ethanol. At pH values of 3.0 and 12.0, respiration became important, consuming up to 30% of available xylose. A graphic procedure suggests that histamine and cysteine are at the active site of xylose reductase in this yeast.     

Cultivation and Lyophilization of Mastigina sp.

SYNOPSIS Mastigina sp. is an amoeboid flagellate isolated from pine frass collected in the Guadarrama Mountains in Spain. It feeds on bacteria and yeasts. It prefers yeasts that produce extracellular polysaccharides, and the 2 species that have been used predominantly for cultivation of the flagellate are Pachysolen tannophilus and Hansenula holstii. Mastigina sp. is easily isolated in axenic culture and grows abundantly therein. Its locomotive form, averaging 27 μ in length, resembles that of a limax amoeba, with a vesiculate nucleus at the anterior end. Cells are capable of simultaneous movement by pseudopodia and flagella. It develops rapidly on dead or living yeast cells in shaken cultures and the trophozoites may convert quantitatively to cysts. The cysts remain viable for long periods of time in refrigerated suspensions and in the lyophilized state. They are spherical or ovoid and smooth-walled cysts; the trophozoite emerges from them by breaking the wall.     

Effect of glucose supplements on the fermentation of xylose by Pachysolen tannophilus

Hemicellulosic sugars, predominantly D-xylose, comprise about one-half the total carbohydrate that can be obtained from hardwoods and agricultural residues through dilute acid hydrolysis. Because rates and yields in the xylose fermentation are low, economic utilization of these materials as fermentation feedstocks is difficult. Pachysolen tannophilus formed 5.5% ethanol from 12% glucose but only 2% ethanol from 12% xylcose. Aeration doubled the specific rate of D-glucose fermentation by P. tannophilus, as compared to anaerobic fermentation, but the specific rate of the xylose fermentation remained unchanged. Periodic additions of 0.5% D-glucose to aerobic fermentations of 3% xylose increased the yield of ethanol from 0.28 g/g xylose to greater than 0.41 g/g xylose utilized. The rate of xylose utilization remained unchanged, and radiotracer studies showed that addition of 0.5% glucose did not inhibit xylose utilization under aerobic or anaerobic conditions. No enhancement was observed anaerobically, nor was enhancement observed with acid hydrolysates, apparently because of the presence of acetic acid which inhibited growth and fermentation.     

Citric acid cycle in the hyperthermophilic archaeon Pyrobaculum islandicum grown autotrophically, heterotrophically, and mixotrophically with acetate

The hyperthermophilic archaeon Pyrobaculum islandicum uses the citric acid cycle in the oxidative and reductive directions for heterotrophic and autotrophic growth, respectively, but the control of carbon flow is poorly understood. P. islandicum was grown at 95 degrees C autotrophically, heterotrophically, and mixotrophically with acetate, H2, and small amounts of yeast extract and with thiosulfate as the terminal electron acceptor. The autotrophic growth rates and maximum concentrations of cells were significantly lower than those in other media. The growth rates on H2 and 0.001% yeast extract with and without 0.05% acetate were the same, but the maximum concentration of cells was fourfold higher with acetate. There was no growth with acetate if 0.001% yeast extract was not present, and addition of H2 to acetate-containing medium greatly increased the growth rates and maximum concentrations of cells. P. islandicum cultures assimilated 14C-labeled acetate in the presence of H2 and yeast extract with an efficiency of 55%. The activities of 11 of 19 enzymes involved in the central metabolism of P. islandicum were regulated under the three different growth conditions. Pyruvate synthase and acetate:coenzyme A (CoA) ligase (ADP-forming) activities were detected only in heterotrophically grown cultures. Citrate synthase activity decreased in autotrophic and acetate-containing cultures compared to the activity in heterotrophic cultures. Acetylated citrate lyase, acetate:CoA ligase (AMP forming), and phosphoenolpyruvate carboxylase activities increased in autotrophic and acetate-containing cultures. Citrate lyase activity was higher than ATP citrate synthase activity in autotrophic cultures. These data suggest that citrate lyase and AMP-forming acetate:CoA ligase, but not ATP citrate synthase, work opposite citrate synthase to control the direction of carbon flow in the citric acid cycle.     

Induction of phytoalexin formation in crown gall and hairy root culture of Salvia miltiorrhiza by methyl viologen

Methyl viologen (MV) (20–150 M), a generator of superoxide anion (O₂ ^–), but not hydrogen peroxide (H₂O₂) (10 M–2 mM) triggered the formation of cryptotanshinone (a phytoalexin) in cultures of both crown galls and hairy roots of Salvia miltiorrhiza. MV also inhibited the biomass formation and decreased the contents of phenolic acids in both cultures whereas H₂O₂ did not. In addition, MV and yeast elicitor induced cryptotanshinone formation synergistically only in crown gall cultures. Treatment of the cultures with 3.3 M diphenylene iodonium, an inhibitor of NAD(P)H oxidase, did not exhibit any detrimental effect on the yeast elicitor-induced cryptotanshinone formation in hairy root cultures whereas 1 M diphenylene iodonium was inhibitory on yeast elicitor-induced cryptotanshinone formation in crown gall cultures.