重组大肠杆菌碱裂解方法的改进

为了降低质粒DNA的生产成本,对经典碱裂解法中的溶液III进行了改进,以表达溶菌酶基因的pcDNKLYZ重组质粒转化的大肠杆菌DH5α为指示菌,用标准碱裂解和改进碱裂解法提取质粒pcDNKLYZ,以提取的质粒产量和质量为指标,判断优化碱性裂解法的性价比,结果显示,用改进后的碱裂解法裂解重组菌,提取的pcDNKLYZ质粒产量和质量等指标与标准方法接近,而成本仅为标准方法的1/4,可用于重组质粒的大规模制备。     

蛋白A信号肽引导的E.coli外泌高表达异源蛋白

利用葡萄球菌ｐｒｏｔｅｉｎ Ａ信号序列（ＳＰＡ）,我们构建了不同启动子控制的分泌表达质粒。经表达研究,获得了可控性好、表达量高的ＰＬ启动子控制的分泌表达载体。通过菌种的筛选、培养条件和诱导条件的摸索,获得了能将表达产物的绝大部分分泌到培养液中的大肠杆菌高效外泌表达系统,外泌表达量可达１００ｍｇ／Ｌ（菌浓度为１Ａ６００／ｍｌ）以上,如此高的分泌表达量尚未见文献报道。利用该系统成功、高效地外泌表达了ｐ     

How to trigger periplasmic release in recombinant Escherichia coli: A comparative analysis

Recombinant protein production in Escherichia coli usually leads to accumulation of the product inside the cells. To capture the product, cells are harvested, resuspended, and lysed. However, in cases where the product is transported to the periplasm, selective disruption of the outer membrane leads to much purer crude extracts compared to complete cell lysis, as only 4–8% of the native E. coli host cell proteins are located in the periplasmic space. A variety of different strategies to enable selective release of the product from the periplasm is available. However, in most of these studies cells are harvested before they are resuspended in permeabilization agent and no differentiation between leakiness and lysis is made. Here, we tested and compared different strategies to trigger leakiness. In contrast to other studies, we performed these experiments during cultivation and quantified both leakiness and lysis. In summary, we recommend incubation with 350 mM TRIS at constant pH for several hours followed by a mild heat treatment up to 38°C to trigger leakiness with only minimal lysis. This study represents a comparative summary of different strategies to trigger E. coli leakiness and describes a solid basis for further experiments in this field.     

Extracellular recombinant protein production from an Escherichia coli lpp deletion mutant

E. coli is one of the most commonly used host strains for recombinant protein production. However, recombinant proteins are usually found intracellularly, in either cytoplasm or periplasmic space. Inadequate secretion to the extracellular environment is one of its limitations. This study addresses the outer membrane barrier for the translocation of recombinant protein directed to the periplasmic space. Specifically, using recombinant maltose binding protein (MalE), xylanase, and cellulase as model proteins, we investigated whether the lpp deletion could render the outer membrane permeable enough to allow extracellular protein production. In each case, significantly higher excretion of recombinant protein was observed with the lpp deletion mutant. Up to 90% of the recombinant xylanase activity and 70% of recombinant cellulase activity were found in the culture medium with the deletion mutant, whereas only 40-50% of the xylanase and cellulase activities were extracellular for the control strain. Despite the weakened outer membrane in the mutant strain, cell lysis did not occur, and increased excretion of periplasmic protein was not due to cell lysis. The lpp deletion is a simple method to generate an E. coli strain to effect significant extracellular protein production. The phenotype of extracellular protein production without cell lysis is useful in many biotechnological applications, such as bioremediation and plant biomass conversion.     

大肠杆菌周质蛋白提取工艺的研究

研究了精氨酸缓冲液在不同浓度、pH值及提取时间下的周质蛋白提取率,并以溶菌酶法、渗透压休克法作为对比。结果表明浓度0.4 mol/L,pH值8.0,提取时间为45 min时,周质目的蛋白达到0.89 mg/g湿菌,相比其他方法,周质蛋白提取率分别提高93%、187%。实验得到一种高效、方便的大肠杆菌周质蛋白提取工艺,为周质表达的重组蛋白大规模生产奠定了基础。     

重组大肠杆菌生产谷胱甘肽发酵条件的研究

研究了重组Ｅ．Ｃｏｌｉ产ＧＳＨ的发酵条件,重点考察了添加酵母膏、前体氨基酸和ＡＴＰ的影响。结果发现,前体氨基酸和ＡＴＰ均能促进胞内ＧＳＨ的积累,若在发酵０ｈ和１２ｈ分别加入２０ｇ／ＬＡＴＰ和９ｍｍｏｌ／Ｌ前体氨基酸,则细胞干重和胞内ＧＳＨ含量可分别比对照提高２４％和１４倍。应用正交试验得出的针对细胞干重和ＧＳＨ总量的最佳组合,最大细胞干重和ＧＳＨ总量比原试验中的最好结果分别提高了１０％和２６％。在分析了该菌对葡萄糖利用情况的基础上,对该菌进行了指数流加培养,２５ｈ细胞干重与发酵液内ＧＳＨ总量分别达到８０ｇ／Ｌ和８８０ｍｇ／Ｌ,比摇瓶最好结果分别提高了８３和４６倍。     

Characterization of adhesion zones in E. coli cells

After plasmolysis of Escherichia coli cells, the adhesion zones were characterized using the cytochemical PTA and SP procedures which stain peptidoglycan and lipopolysaccharides (LPS) respectively. A PTA-stained layer was detected at the adhesion sites. This layer was visualized irrespective of the electron microscopy procedure used. Also, using SP staining an outer membrane in which LPS molecules were asymmetrically distributed, was observed.     

大肠杆菌蛋白酶系统的研究进展

基因工程菌大肠杆菌细胞中含有多种蛋白酶,具有重要的生理功能,同时也是影响外源蛋白表达水平的重要因素,大肠杆菌蛋白酶系统的研究是工程菌改良的基础。为减少蛋白酶对外源蛋白的降解,从不同的角度做了大量工作,其中利用反义RNA技术控制蛋白酶活性是一条值得探索的思路。     

Antibody analysis of the localisation, expression and stability of HlyD, the MFP component of the E. coli haemolysin translocator

HlyD has a single transmembrane domain (residues 59-80) and a large periplasmic domain, and is essential for the secretion of haemolysin from Escherichia coli. Using an antibody raised against HlyD, the protein was localised to the cell envelope by immunofluorescence and to the cytoplasmic membrane by sucrose gradient analysis. We have examined the stability of this protein in the presence and absence of other putative components of the translocator, HlyB and TolC. HlyD is normally highly stable but in the absence of TolC, the steady-state level of HlyD is greatly reduced and the protein has a half-life at 37° C of 36 min. In the absence of HlyB, HlyD is also unstable and specific degradation products are detected, which co-fractionate with the inner membrane, indicating in this case limited cleavage at specific sites. However, the effect of removing both HlyB and TolC is not additive. On the contrary, in the absence of both HlyB and TolC the half-life of HlyD is approximately 110 min. This result shows that in the presence of HlyB removal of TolC renders HlyD more unstable than it is in the absence of both HlyB and TolC. This suggests that the presence of HlyB induces a structural change in HlyD. In addition, HlyB itself appears to be less stable in the absence of HlyD. These results are consistent with an interaction between HlyD/TolC and HlyB/HlyD. A derivative of HlyD, HlyD22, lacking the 40 N-terminal residues of HlyD assembles into the inner membrane displaying the same stability with and without HlyB as wild type HlyD does. This N-terminal region therefore appears to play no role in stable localisation but is involved in secretion, since HlyD22 is completely secretion defective. Modification of the C-terminus on the other hand completely destabilised the molecule and HlyD was not detectable in the envelope. Secretion of active haemolysin is limited to a brief period during mid to late exponential phase. In contrast, HlyD is apparently synthesised constitutively throughout the growth phase, demonstrating that the production of this component of the translocator is not the limiting factor for growth phase-dependent secretion. Received: 10 July 1998 / Accepted: 19 October 1998     

Inactivation of the Escherichia coli K-12 twin-arginine translocation system promotes increased hydrogen production

The effect of deleting the genes encoding the twin-arginine translocation (Tat) system on H2 production by Escherichia coli strain MC4100 and its formate hydrogenlyase upregulated mutant (DeltahycA) was investigated. H2 evolution tests using two mutant strains defective in Tat transport (DeltatatC and DeltatatA-E) showed that the rate doubled from 0.88+/-0.28 mL H2 mg dry weight-1 L culture-1 in the parental strain, to 1.70+/-0.15 and 1.75+/-0.18 mL H2 mg dry weight-1 L culture-1, respectively, in the DeltatatC and DeltatatA-E strains. This increase was comparable to that of a previously characterized hydrogen over-producing E. coli strain carrying a DeltahycA allele. Construction of a tatC, DeltahycA double deletion strain did not increase hydrogen production further. Inactivation of the Tat system prevents correct assembly of the uptake hydrogenases and formate dehydrogenases in the cytoplasmic membrane and it is postulated that the subsequent loss of basal levels of respiratory-linked hydrogen and formate oxidation accounts for the observed increases in formate-dependent hydrogen evolution.     

Penicillin-binding proteins of pathogenic Escherichia coli strains

The penicillin-binding proteins of 11 pathogenic Escherichia coli strains, including enteropathogenic, enterotoxigenic, enteroinvasive, enteroaggregative, and enterohemorrhagic E. coli, were detected in gels following the labeling of isolated cell envelopes with [³H]benzylpenicillin. The electrophoretic profiles, sensitivities to and morphological changes induced by β-lactam antibiotics showed that the penicillin-binding proteins of most pathogenic E. coli possess structural and physiological functions similar to those of E. coli K12.     

Pseudomonas aeruginosa amidase: aggregation in recombinant Escherichia coli

The effect of cultivation parameters such as temperature incubation, IPTG induction and ethanol shock on the production of Pseudomonas aeruginosa amidase (E.C.3.5.1.4) in a recombinant Escherichia coli strain in LB ampicillin culture medium was investigated. The highest yield of soluble amidase, relatively to other proteins, was obtained in the condition at 37°C using 0.40 mM IPTG to induce growth, with ethanol. Our results demonstrate the formation of insoluble aggregates containing amidase, which was biologically active, in all the tested growth conditions. Addition of ethanol at 25°C in the culture medium improved amidase yield, which quantitatively aggregated in a biological active form and exhibited in all conditions an increased specific activity relatively to the soluble form of the enzyme. Non-denaturing solubilization of the aggregated amidase was successfully achieved using L-arginine. The aggregates obtained from conditions at 37°C by FTIR analysis demonstrated a lower content of intermolecular interactions which facilitated the solubilization step applying non-denaturing conditions. The higher interactions exhibited in aggregates obtained at suboptimal conditions compromised the solubilization yield. This work provides an approach for the characterization and solubilization of novel reported biologically active aggregates of this amidase.     

大肠杆菌I型分泌表达系统研究进展及提高蛋白表达量的策略

大肠杆菌是表达重组蛋白最常用的宿主之一。利用大肠杆菌分泌途径胞外表达重组蛋白具有可促进蛋白正确折叠,有效减少包涵体形成,简化纯化工序等诸多优势,近年来备受关注。其中,大肠杆菌I型分泌途径具有分泌表达速度快,蛋白活性高,对宿主代谢无影响等特点,是目前应用最广泛的分泌途径之一。综述了大肠杆菌I型分泌系统的元件组成和分泌机理及提高I型分泌系统蛋白表达量的有效策略,为重组蛋白生产应用提供了理论依据。     

Incompatibility of outer membrane proteins OmpA and OmpF of Escherichia coli with secretion in Bacillus subtilis: Fusions with secretable peptides

The secretion of the outer membrane proteins OmpA and OmpF of Escherichia coli has previously been found to be blocked at an early intracellular step, when these proteins were fused to a bacillar signal sequence and expressed in Bacillus subtilis. We have now fused these proteins to long secretable polypeptides, the amino-terminal portions of alpha-amylase or beta-lactamase. In spite of this, no secretion of the fusion proteins was detected in B. subtilis. With the exception of a small fraction of the beta-lactamase fusion, the proteins were cell-bound with uncleaved signal sequences. Protease accessibility indicated that the fusion proteins were not even partially exposed on the outer surface of the cytoplasmic membrane. Thus there was no change of the location compared to the OmpA or OmpF fused to the signal sequence only. We conclude that, like OmpA and OmpF, the fusion proteins fold into an export-incompatible conformation in B. subtilis before the start of translocation, which we postulate to be a late post-translational event.     

Connection between gene dosage and protein stability revealed by a high-yield production of recombinant proteins in an E. coli LexA1(Ind-) background

Bacterial production of a plasmid-encoded bacteriophage P22 tailspike protein shows different yield and impact on cell viability in RecA+ LexA+, RecA- LexA+ and RecA+ LexA1(Ind-) backgrounds. In a LexA1(Ind-) context, we have observed lesser toxicity and higher productivity than in the wild-type strain, in which the bacterial growth was inhibited after induction of recombinant gene expression. Also, a negative effect of the incubation temperature on the growth of producing cells was also detected. By exploring the molecular basis of these inhibitory events, we found a connection between the dosage of the recombinant gene and the proteolytic stability of the encoded protein. Under both genetic and environmental conditions favoring higher plasmid copy number and consequently increasing the synthesis rate of the recombinant protein, enhanced protein degradation was observed in parallel with an important growth inhibition. Altogether, the obtained data suggest the existence of a critical concentration of recombinant protein over which cell proteolysis is stimulated at rates not compatible with optimal physiological conditions for bacterial growth.     

Tuning different expression parameters to achieve soluble recombinant proteins in E. coli: advantages of high-throughput screening

Proteins are the main reagents for structural, biomedical, and biotechnological studies; however, some important challenges remain concerning protein solubility and stability. Numerous strategies have been developed, with some success, to mitigate these challenges, but a universal strategy is still elusive. Currently, researchers face a plethora of alternatives for the expression of the target protein, which generates a great diversity of conditions to be evaluated. Among these, different promoter strength, diverse expression host and constructs, or special culture conditions have an important role in protein solubility. With the arrival of automated high-throughput screening (HTS) systems, the evaluation of hundreds of different conditions within reasonable cost and time limits is possible. This technology increases the chances to obtain the target protein in a pure, soluble, and stable state. This review focuses on some of the most commonly used strategies for the expression of recombinant proteins in the enterobacterium Escherichia coli, including the use of HTS for the production of soluble proteins.     

大肠杆菌高效表达重组蛋白策略

大肠杆菌表达系统是基因表达技术中发展最早和目前应用最广的经典表达系统。利用该系统表达重组蛋白具有许多优越性,但其表达效率受诸多因素的影响。本文综述国内外利用大肠杆菌表达系统高效表达外源蛋白的策略,主要包括选择合适的启动子、改变信号肽结构、提高mRNA稳定性、提高翻译效率、表达稀有密码子、降低包涵体形成及蛋白降解,利用融合蛋白与分子伴侣、调控发酵条件实现高密度培养等。