Purification and properties of mannanase from Bacillus subtilis

Extracellular mannanase from Bacillus subtilis NM-39, an isolate from Philippine soil, was purified about 240-fold with a yield of 7.3% by ammonium sulphate fractionation, DEAE-Toyopearl chromatography and Sephacryl S-200 gel filtration. Its M _r was 38 kDa and it had a pI of 4.8 and optimum activity at pH 5.0 and 55°C. It was stable at pH 4 to 9 and below 55°C. The amino acid composition of the enzyme was in the order Gly>Glx>Ser and Asx>Ala.N.S. Mendoza and L.M. Joson are with Industrial Technology Development Institute, Department of Science and Technology, Manila, Philippines. M. Arai and T. Kawaguchi are with Department of Agricultural Chemistry, College of Agriculture, University of Osaka Prefecture, Sakai, Osaka 593, Japan; T. Yoshida is with Faculty of Engineering, Osaka University, Suita, Osaka 565, Japan.     

Purification and some properties of endopolygalacturonase from Rhizopus sp. LKN

An endopolygalacturonase of Rhizopus sp. strain LKN, one of several isolates from tempe starter (ragi), was purified 235-fold by CM-Sephadex C-50, DEAE-Sephadex A-50 ion exchange chromatographies and Sephadex G-75 gel filtration. The purified enzyme was homogeneous by SDS-PAGE with a M _r of 38.5 kDa. Its K _m value for pectic acid was 2 mg/ml. It was stable at pH 4.5 to 11 and up to 50°C, with optimum activity at pH 4.5 to 4.75 and 55 to 60°C. Some ionic compounds enhanced the enzyme activity, whereas tannic acid at 0.5 mm caused about 90% inhibition.The authors are with the Department of Food Science and Technology, Faculty of Agriculture, Kyushu University, Hakozaki, Fukuoka 812, Japan.     

Kluyveromyces marxianus: a potential source of diacetyl reductase

Kluyveromyces marxianus had a higher specific activity of diacetyl reductase (EC 1.1.1.5) than all other organisms previously reported. The enzyme was NADH-dependent and irreversibly catalysed the conversion of diacetyl to acetoin with an optimum pH of 7.0. It was stable at 40°C but lost 50% of its activity at 50°C in 30 min. The K _m and V _max values for diacetyl were 1.8 mm and 0.053 mm/min, respectively.The authors are with the Department of Food Science and Technology, Comell University, Geneva, New York 14456, USA     

Effect of inulin on yeast inulinase production in sauerkraut brine

Kluyveromyces marxianus NRRL Y-1196 produced the highest inulinase activity (38 U/mg protein) of six yeasts examined after 24 h growth in sauerkraut brine in shaking flasks at 30°C with 0.3% inulin as an enzyme inducer. The enzyme was recovered by acetone fractionation, with a yield of 81%. It had maximum activity at pH 4.4 and 55°C with K _m values for inulin and sucrose of 3.92 mm and 11.9 mm, respectively. The yeast raised the pH from 3.4 to above 7.0, using all the lactic acid in the brine. Growth of K. marxianus in sauerkraut brine with a small amount of inulin may usefully decrease the BOD and concomitantly produce inulinase.The authors are with the Department of Food Science and Technology, Cornell University, Geneva, New York 14456, USA     

Effects of initial sucrose concentration on excretion of anthocyanin pigments in suspended cultures of Perilla frutescens cells

Cell cultures of Perilla frutescens, growing on Linsmaier and Skoog medium, released more anthocyanin with 40 to 50 g sucrose/l compared with the control of 30 g sucrose/l of medium. More proteins were also released into the medium with the higher sucrose concentration and the cell volume was smaller, suggesting that the higher osmotic pressure, caused by the high sucrose concentration, may cause these releases. The capacitance of the cultured cells indicated a difference in membrane structure between the cells cultivated with different sucrose concentrations, supporting the hypothesis that cell permeabilization is increased at higher sucrose concentrations.J.-J. Zhong is with the Research Institute of Biochemical Engineering, East China University of Science and Technology, 130 Meilong Road, Shanghai 200237, China, G.-R. Xu is with the Department of Fermentation Technology, Wuxi Institue of Light Industry, Jiangsu 214036, China. T. Yoshida is with the International Center of Cooperative Research in Biotechnology, Faculty of Engineering. Osaka University, Osaka 565, Japan.     

Catechol 2,3-oxygenase production by genetically engineered Escherichia coli and its application to catechol determination

Catechol 2,3-oxygenase was produced by Escherichia coli, harbouring the recombinant plasmid pBH100 which contained the pheB gene cloned from phenol-degrading Pseudomonas putida BH, and was applied for the determination of catechol in the liquor. E. coli JM103 (pBH100) and C600 (pBH100) showed, respectively, about 5 and 8.5 times higher activities than that of P. putida BH. Using the crude extract prepared from the culture broth of the recombinant, catechol between 0.1 and 3.0 g/ml could be determined quantitatively in phosphate buffer, synthetic sewage and in mixtures of phenol, benzoate and sallcylate, and also in sodium pyruvate solution. In addition to catechol, 3-methylcatechol, 4-methylcatechol and 4-chlorocatechol could be determined. Oxygenase activity of the crude extract was maintained completely during the 100-day storage at –20°C after being freeze-dried with 10% acelone.M. Fujita, M. Ike, Y. Kawagoshi and N. Shinohara are with the Department of Environmental Engineering, Osaka University, 2-1, Yamadaoka, Suita, Osaka 565, Japan. T. Kamiya is with the Central Research Laboratory of Mitsubishi Electric Co., Amagasaki, Hyogo 661, Japan.     

Production and characterization of xylanase from a Streptomyces species grown on agricultural wastes

Alkali-treated corn stalk gave maximum xylanase production at supporting growth of Streptomyces HM-15. Xylanase was stable for 24 h over a pH range of 5.0 to 7.0, had optimal activity between 50 and 60°C and a halflife of 5 h at 60°C. Xylanase production and activity were inhibited by xylose.The authors are with Department of Biosciences, Sardar Patel University. Vallabh Vidyanagar-388120, Gujarat, India.     

Production and characterization of a xylanase from Cyathus stercoreus

Cyathus stercoreus grown on wheat straw had a higher xylanase activity than when it was grown on rice husk or extracted hemicellulose. Inclusion of casein hydrolysate, Tween 80 and Mn²⁺ (at 0.02%, 0.2% and 0.075%, respectively) increased the production of extracellular xylanase. Optimal yield of xylanase (0.73 U/ml) was at pH 5.6 after 9 to 12 days at 30°C. The xylanase was stable at pH 4.5 to 7.5 for 2h but above 50°C its stability fell sharply.The authors are with the Department of Microbiology, University of Delhi South Campus, Benito Juarez Road, New Delhi-110021, India;     

Production of cellulase-free thermostable xylanases by an isolated strain of Aspergillus niger PPI, utilizing various lignocellulosic wastes

A strain of Aspergillus niger PPI having prolific xylanolytic potential was isolated and the optimum conditions for maximum xylanase production was studied, resulting in the following: 4% substrate concentration, 10% v/v inoculum size, 72 h of incubation and pH 3.5–4.5 at 28 °C. The production profile of xylanase was examined with various lignocellulosics and maximum yield was achieved with oat. The hemicellulose content of wastes was also determined and oatmeal was found to have maximum hemicellulose content followed by wheat straw, sugarcane bagasse, rice husk and gram residue respectively. The enzyme showed maximum activity at pH 4 and temperature 60 °C. However, maximum stability was achieved at pH 3.5 and temperature 55 °C. Cellulase activity was found altogether absent in the enzyme broth.     

Protein enrichment of lignocellulose resulting from the growth of two Streptomyces strains

Two Streptomyces strains were grown on sugarcane bagasse and groundnut hulls lignocelluloses in semi-solid state culture at 37°C for 12 weeks. Best results gave a 45% depletion of sugarcane bagasse lignocellulose with a 21% crude protein content of final material. The possibility of using S. viridosporus to improve the protein content of both lignocelluloses for use as an animal feedstock supplement is discussed.At the time of this research the authors were with the Department of Biological Sciences, Rivers State University of Science & Technology, PMB 5080, Port Harcourt, Nigeria and the Department of Biological Sciences, University of Calabar, PMB 1115, Calabar, Nigeria. Dr lyo is now with the Department of Microbiology, University of Guelph, Guelph, Ontario N1G 2W1, Canada.     

A thermostable,alkaline-active,keratinolytic proteinase from chrysosporium keratinophilum

Thermostable alkaline proteinase was produced by a strain of Chrysosporium keratinophilum when cultured in lactose/mineral salt medium incorporating keratin solubilized with DMSO. The proteinase, partially purified by cold-acetone precipitation followed by gel-filtration on Sephadex G-75, was optimally active at pH 9 and stable from pH 7 to 10 with over 90% relative residual activity after incubation at 25°C for 24 h. The optimum temperature for enzyme activity was 90°C at which the activity half-life was 30 min. Enzyme activity was stimulated by Fe²⁺ and inhibited by 1,10 o-phenanthroline. Gel-filtration indicated an M _r of 69 kDa.The authors are with the Department of Microbiology, Faculty of Biological Sciences, P.M. B.006, University of Nigeria, Nsukka, Enugu State, Nigeria     

Emulsifying property of a viscous exopolysaccharide fromSphingomonas paucimobilis

A viscous exopolysaccharide fromSphingomonas paucimobilis-GS1, emulsified xylene, benzene, 2-methylnaphthalene, hexadecane, hexane, kerosene and paraffin oil as well as castor, coconut and olive oils when used at 1 mg/ml. It stabilized the emulsions more efficiently than commercial gums such as arabic, tragacanth, karaya and xanthan. Emulsions were stable for 6 months, from 4 to 40°C and pH 4 to 10 and in the presence of NaCl up to 50 g/l. The polysaccharide had no discernible toxicity towards mice when tested using World Health Organization guidelines.The authors are with the Department of Microbiology and Biotechnology Centre, M. S. University of Baroda, Baroda 390 002, India     

Continuous production ofL-malic acid by immobilizedBrevibacterium ammoniagenes cells

Summary Continuous production ofL-malic acid from fumaric acid using immobilized microbial cells was investigated. Several microorganisms having fumarase activity were immobilized into a polyacrylamide gel lattice. Among the microorganisms tested, immobilizedBrevibacterium ammoniagenes IAM 1645 showed the highest enzyme activity, but produced an unwanted by-product, succinic acid. Conditions for suppression of this side reaction were investigated, and bile extract treatment of immobilized cells was found to be effective.The bile extract treatment of immobilized cells also resulted in a marked increase of reaction rate forL-malic acid formation.No difference was observed between the native enzyme and immobilized cells in optimal pH and temperature of the enzyme reaction.The effect of temperature on the reaction rate and the stability of fumarase activity of an immobilized cell column were investigated under conditions of continuous enzyme reaction. The decay of enzyme activity during continuous enzyme reaction was expressed by an exponential relationship. Half-life of the fumarase activity of the immobilized cell column at 37°C was calculated to be 52.5 days.Presented at the Annual Meeting of the Society of Fermentation Technology, Japan, Osaka, Japan, October 30, 1975.     

Production of alkaline protease by a new Bacillus subtilis isolate for use as a bating enzyme in leather treatment

Bacillus subtilis, isolated from tannery waste, produced an alkaline protease at optimal activity when grown in a casein/gelatine medium in a stirred tank fermenter at 37°C with the dissolved oxygen tension at 40% air saturation. Optimum protease activity (223 U ml^-1) was at pH 8.5 and was stable for 1 h up to 45°C but at 60°C lost 80% activity. Use of the crude protease as a bating agent for producing high quality leather is indicated. Tensile strength, bursting strength, tear strength and elongation at break of prepared leather were increased with increasing amounts of protease used for bating.A. Hameed and M.A. Natt are with the Department of Biological Sciences, Quaid-i-Azam University, Islamabad. Pakistan. C.S. Evans is with the School of Biological and Health Sciences, University of Westminster, London. UK.     

Purification and properties of β-amylase from Bacillus circulans S31

A thermotolerant -amylase was purified from Bacillus circulans S31 isolated from soil in Hong Kong. The purified enzyme has an M _r of 64 kDa and was stable at 50°C and pH 7.0 for 30 min. Its K _m for starch was 0.9 mg/ml with a V _max of 0.3 mg/min. It was not activated by any metal ion although sulphydrys reagents were inhibitory.H.S. Kwan, K.H. So and K.Y. Chan are with the Department of Biology, The Chinese University of Hong Kong, Shatin, N.T., Hong Kong S.C. Cheng is with the Department of Applied Biology and Chemical Technology, Hong Kong Polytechnic, Hung Hom, Hong Kong.     

Thermotolerant strain of Bacillus licheniformis producing lipase

A thermotolerant variant of Bacillus licheniformis strain H1 (isolated from Jordan valley soil), was highly active in degrading macromolecules, and possessed a lipase activity with a half life of 30 min at 70°C. This activity was produced during exponential growth. The extracellular crude lipase showed maximal activity at pH 10, and retained 65% of its stability at pH 12.The author is with the Department of Biological Sciences, University of Jordan, P.O. Box 2686, Amman 11181, Jordan     

Solubilization of coal by an extracellular product fromStreptomyces setonii 75Vi2

Summary Several low-ranked coals were solubilized when placed on the surface of agar cultures ofStreptomyces viridosporous T7A andS. setonii 75Vi2. When grown in submerged cultureS. setonii 75Vi2 produced an extracellular component that was capable of solubilizing coals. The extracellular coal solubilizing component had a molecular weight of <10000 and was heat stable since, after 1h at 121°C, only 30–40% of the activity was lost. Treatment with any of three proteases also appeared to be ineffective in decreasing activity. These results suggest that coal solubilization byS. setonii 75Vi2 is nonenzymatic.Research supported by the Fossil Energy Advances Research and Technology Program, managed by the Pittsburg Energy Technology Center, U.S. Department of Energy, under Contract No. DE-AC05-840R21400 with Martin Marietta Energy Systems, Inc.     

Bacillus fermentation of soybeans

Kinema fermentations of Indian and Canadian No. 1 soybeans by Bacillus sp. DK-W1 and by mixed cultures of Bacillus sp. DK-W1 and Enterococcus faecium DK-C1 were essentially identical. The viable cell count of Bacillus increased from an initial 10⁵ to 10¹⁰ c.f.u./g wet wt after 48 h incubation at 37°C. The pH of the fermentation dropped from an initial 6.9 to about 6.4 after 8 h and then rose to 8.6 after 32 h, with a coincident increase in proteolytic activity and ammonia concentration. The fermentations containing E. faecium and Bacillus exhibited a greater initial pH decline and a slightly retarded subseqent increase in pH compared with fermentations with Bacillus only. The presence of E. faecium had no detectable effects on growth of the Bacillus, proteolytic activity, ammonia production or the final pH of the fermentations.P.K. Sarkar was and P.E. Cook and J.D. Owens are with the Food Microbial Interactions Laboratory, Department of Food Science and Technology, University of Reading, Reading RG6 2AP, UK; P.K. Sarkar is now with the Microbiology Laboratory, Centre for Life Sciences, University of North Bengal, Siliguri 734430, India.     

Partial purification and some properties of an alkaline cellulase from an alkalophilic Bacillus sp.

A newly isolated Bacillus species, which grew optimally at 30°C and pH 10, produced a carboxymethylcellulase in a medium containing 10 g CM-cellulose/l. The enzyme, when partially purified by gel filtration, had a mass of about 29 kDa as determined by both SDS-PAGE and gel filtration chromatography. It was optimally active at pH 9.5 and 40°C, and was stable from pH 7 to 11 at 4°C for 24 h. The enzyme was stimulated by Ca²⁺ (1mm) but was completely inhibited by Hg²⁺ (1mm). Neither EDTA nor EGTA (10mm) affected the activity.The author is with the Department of Biological Sciences, University of Jordan. PO Box 2686, Amman 11181, Jordan     

Purification and some properties of β-mannanase from Bacillus sp.

-Mannanase produced by Bacillus sp. W-2, isolated from decayed commercial konjak cake, was purified from the culture supernatant by (NH₄)₂ SO₄ precipitation, adsorption to konjak gel, and column chromatography with DEAE-cellulose, Sephadex G-100 and Sephacryl S-200. Its molecular size was estimated by SDS-PAGE as 40 kDa, and by gel filtration as 36 kDa. The enzyme was most active at pH 7 and 70°C and was stable for at least 1 h between pH 5 and 10 and below 60°C. Its activity was completely inhibited by Hg²⁺. The enzyme hydrolysed galactomannan better than glucomannan and mainly produced mannose and mannobiose.The authors are with the Department of Bioproductive Science, Faculty of Agriculture, Utsunomiya University. Utsunomiya, Tochigi 321, Japan