Fungal rock phosphate solubilization using sugarcane bagasse

The effects of different doses of rock phosphate (RP), sucrose, and (NH₄)₂SO₄ on the solubilization of RP from Araxá and Catal?o (Brazil) by Aspergillus niger, Penicillium canescens, Eupenicillium ludwigii, and Penicillium islandicum were evaluated in a solid-state fermentation (SSF) system with sugarcane bagasse. The factors evaluated were combined following a 2³?+?1 factorial design to determine their optimum concentrations. The fitted response surfaces showed that higher doses of RP promoted higher phosphorus (P) solubilization. The addition of sucrose did not have effects on P solubilization in most treatments due to the presence of soluble sugars in the bagasse. Except for A. niger, all the fungi required high (NH₄)₂SO₄ doses to achieve the highest level of P solubilization. Inversely, addition of (NH₄)₂SO₄ was inhibitory to P solubilization by A. niger. Among the fungi tested, A. niger stood out, showing the highest solubilization capacity and for not requiring sucrose or (NH₄)₂SO₄ supplementation. An additional experiment with A. niger showed that the content of soluble P can be increased by adding higher RP doses in the medium. However, P yield decreases with increasing RP doses. In this experiment, the maximal P yield (approximately 60?%) was achieved with the lower RP dose (3?g?L^?1). Our results show that SSF can be used to obtain a low cost biofertilizer rich in P combining RP, sugarcane bagasse, and A. niger. Moreover, sugarcane bagasse is a suitable substrate for SSF aiming at RP solubilization, since this residue can supply the C and N necessary for the metabolism of A. niger within a range that favors RP solubilization.     

Microbial solubilization of rock phosphate on media containing agro-industrial wastes and effect of the resulting products on plant growth and P uptake

Four agro-industrial wastes were assayed as substrates for microbial solubilization of rock phosphate (RP). Sugar beet wastes (SB), olive cake (OC) and olive mill wastewaters (OMWW) were treated by Aspergillus niger, and dry olive cake (DOC) was treated by Phanerochaete chrysosporium. In conditions of solid-state fermentation 46% of SB and 21% of OC were mineralized by A. niger while 16% of DOC was mineralized by P. chrysosporium. Repeated-batch mode of fermentation was employed for treatment of OMWW by immobilized A. niger, which resulted in conversion of 80% of the fermentable sugars. Acidification of all media treated by A. niger was registered with a simultaneous solubilization of 59.7% (SB), 42.6% (OC), and 36.4% (OMWW) of the total P present in the RP. The same mechanism of RP solubilization was observed in DOC-based medium inoculated with P. chrysosporium but other mechanisms were probably involved during the process. A series of microcosm experiments were then performed in the greenhouse to evaluate the effectiveness of the resulting fermented products. All amendments improved plant growth and P acquisition, which were further enhanced by mycorrhizal inoculation. The level of all studied parameters including the root mycorrhizal colonization depended on the substrate characteristics. The reported biotechnological schemes offer a potential application particularly for degraded soils.     

Optimization of Aspergillus niger rock phosphate solubilization in solid-state fermentation and use of the resulting product as a P fertilizer

A biotechnological strategy for the production of an alternative P fertilizer is described in this work. The fertilizer was produced through rock phosphate (RP) solubilization by Aspergillus niger in a solid-state fermentation (SSF) with sugarcane bagasse as substrate. SSF conditions were optimized by the surface response methodology after an initial screening of factors with significant effect on RP solubilization. The optimized levels of the factors were 865 mg of biochar, 250 mg of RP, 270 mg of sucrose and 6.2 ml of water per gram of bagasse. At this optimal setting, 8.6 mg of water-soluble P per gram of bagasse was achieved, representing an increase of 2.4 times over the non-optimized condition. The optimized SSF product was partially incinerated at 350°C (SB-350) and 500°C (SB-500) to reduce its volume and, consequently, increase P concentration. The post-processed formulations of the SSF product were evaluated in a soil–plant experiment. The formulations SB-350 and SB-500 increased the growth and P uptake of common bean plants (Phaseolus vulgaris L.) when compared with the non-treated RP. Furthermore, these two formulations had a yield relative to triple superphosphate of 60% (on a dry mass basis). Besides increasing P concentration, incineration improved the SSF product performance probably by decreasing microbial immobilization of nutrients during the decomposition of the remaining SSF substrate. The process proposed is a promising alternative for the management of P fertilization since it enables the utilization of low-solubility RPs and relies on the use of inexpensive materials.     

Biochar Enhances Aspergillus niger Rock Phosphate Solubilization by Increasing Organic Acid Production and Alleviating Fluoride Toxicity

During fungal rock phosphate (RP) solubilization, a significant quantity of fluoride (F⁻) is released together with phosphorus (P), strongly inhibiting the process. In the present study, the effect of two F⁻ adsorbents [activated alumina (Al₂O₃) and biochar] on RP solubilization by Aspergillus niger was examined. Al₂O₃ adsorbed part of the F⁻ released but also adsorbed soluble P, which makes it inappropriate for microbial RP solubilization systems. In contrast, biochar adsorbed only F⁻ while enhancing phosphate solubilization 3-fold, leading to the accumulation of up to 160 mg of P per liter. By comparing the values of F⁻ measured in solution at the end of incubation and those from a predictive model, it was estimated that up to 19 mg of F⁻ per liter can be removed from solution by biochar when added at 3 g liter⁻¹ to the culture medium. Thus, biochar acted as an F⁻ sink during RP solubilization and led to an F⁻ concentration in solution that was less inhibitory to the process. In the presence of biochar, A. niger produced larger amounts of citric, gluconic, and oxalic acids, whether RP was present or not. Our results show that biochar enhances RP solubilization through two interrelated processes: partial removal of the released F⁻ and increased organic acid production. Given the importance of organic acids for P solubilization and that most of the RPs contain high concentrations of F⁻, the proposed solubilization system offers an important technological improvement for the microbial production of soluble P fertilizers from RP.     

Decreased mineral availability enhances rock phosphate solubilization efficiency in <Emphasis Type="Italic">Aspergillus niger</Emphasis>

Microbial solubilization of rock phosphate (RP) is mainly achieved by the production of organic acids and medium acidification through H⁺ release. During RP solubilization, mineral nutrient availability is likely to be critical for determining how much carbon is channeled either for metabolite synthesis or for microbial growth, influencing organic acid release by microorganisms. Thus, the objective of this work was to study the relationships between the concentration of mineral nutrients in the growth medium and the efficiency of RP solubilization by Aspergillus niger FS1. For this, the fungus was grown in Czapek medium containing 0, 1, 2, 10, 50, and 100 % of its original concentration of mineral nutrients. Decreasing mineral availability in the growth medium led to decreases in fungal biomass and solubilized P, and increases in titratable acidity and solubilization efficiency as expressed by mg solubilized P per g fungal biomass (Y_P/B), indicating a shift in fungal metabolism from biomass production to organic acid release. The transfer of pre-grown biomass to media with or without added minerals confirmed that lower mineral availability increases Y_P/B and led to the solubilization of 76 % of P present in Patos RP. These observations open new perspectives on improving RP solubilization systems by manipulating mineral nutrient availability in the medium, with consequent gains in cost reduction.     

Enhanced solubilization of rock phosphate by Penicillium bilaiae in pH-buffered solution culture

Little is known about how pH-buffering capacity affects phosphorus (P) solubilization by Penicillium bilaiae. This study compared solubilization of rock phosphate (RP) by P. bilaiae in nonbuffered (pH 5.0) and buffered (pH 7.0) media. Fungal growth reached the stationary phase around day 12 and was slightly enhanced in the buffered medium. The fungus reduced solution pH from 5.0 to 4.1 in the nonbuffered medium and from 7.0 to 4.9 in the buffered medium by day 12. Phosphorus concentrations increased after day 9 more in the buffered than in the nonbuffered media (53 and 5 mg P x L(-1), respectively, on day 12). On day 12, higher concentrations of citric and oxalic acids were detected in the buffered (2.0 and 1.2 g x L(-1), respectively) than nonbuffered media (0.5 and 0.04 g x L(-1), respectively). Solubilization of RP was simulated without P. bilaiae in solutions equivalent to the nonbuffered and buffered cultures of P. bilaiae grown with RP. After a 24 h incubation, the P concentrations were of similar magnitudes to those observed in the P. bilaiae culture (18 and 47 mg P x L(-1), respectively, in the nonbuffered and buffered media). Under increased pH-buffering conditions, the enhanced production of citric and oxalic acids led to significant RP solubilization.     

Isolation of Phosphate Solubilizing Bacteria from Maize Rhizosphere and Their Potential for Rock Phosphate Solubilization–Mineralization and Plant Growth Promotion

Phosphate solubilizing bacteria (PSB) play a significant role in plant P nutrition by their effect on soil P dynamics and their subsequent ability to make P available to plants via solubilization and mineralization processes. This study aimed to evaluate the effect of separate and combined use of indigenous PSB, poultry manure (PM) and compost on solubilization and mineralization of rock phosphate (RP) and their subsequent effect on growth and P accumulation of maize (Zea mays L.). A group of fifty seven bacteria were isolated from the rhizosphere/rhizoplane of maize that had been grown in soils collected from varying altitudes (655–2,576 m) of the mountain region of Rawalakot, Azad Jammu and Kashmir, Pakistan. After screening, the capacity of eleven isolates to solubilize mineral phosphate was quantitatively evaluated using insoluble Ca₃(PO₄)₂ in culture medium as a time course study through spectrometer. The growth hormone producing (IAA) capacity of the isolates was also determined. Furthermore, five potential isolates were tested for their ability to increase P release capacity (mineralization) of insoluble RP in an incubation study. The effect of PSB inoculation on maize was determined in a completely randomized greenhouse experiment where root and shoot biomass and P accumulation in plants were assessed. The P solubilization index of selected isolates varied from 1.94 to 3.69, while the P solubilization efficiency ranged between 94.1% and 269.0%. The isolates MRS18 and MRS27 displayed the highest values. The P solubilization in the liquid medium was maximum at 6 and 9 days of incubation ranging between 9.91 and 44.04 µgmL^?1 and the isolates MRS27 and MRS34 exhibited the highest solubilization. Six isolates showed additional capability of producing IAA ranging between 2.66 and 28.41 µgmL^?1. Results of the incubation study indicated that P release capacity (P mineralization) of RP-amended soil varied between 6.0 and 11.8 µgPg^?1 that had been significantly increased to 30.6–36.3 µgPg^?1 (maximum value) when PSB were combined with RP. The combined application of PSB and organic amendments (PM, compost) with RP further increased P mineralization by releasing a maximum of 37.7 µgPg^?1 compared with separate application of RP (11.8 µgPg^?1) and organic amendments (21.5 and 16.5 µgPg^?1). The overall effect of PSB (as a group) with RP over RP alone on maize growth showing a relative increase in shoot length 21%, shoot fresh weight 42%, shoot dry weight 24%, root length 11%, root fresh weight 59%, root dry weight 35% and chlorophyll content 32%. This study clearly indicates that use of PSB, and organic amendments with insoluble RP could be a promising management strategy to enhance P availability in soil pool and improve plant growth in intensive cropping systems.     

Increased Phosphorus Uptake by Wheat and Field Beans Inoculated with a Phosphorus-Solubilizing Penicillium bilaji Strain and with Vesicular-Arbuscular Mycorrhizal Fungi

Greenhouse and field experiments were conducted to test the effect of a P-solubilizing isolate of Penicillium bilaji on the availability of Idaho rock phosphate (RP) in a calcareous soil. Under controlled greenhouse conditions, inoculation of soils with P. bilaji along with RP at 45 μg of P per g of soil resulted in plant dry matter production and P uptake by wheat (Triticum aestivum) and beans (Phaseolus vulgaris) that were not significantly different from the increases in dry matter production and P uptake caused by the addition of 15 μg of P per g of soil as triple superphosphate. Addition of RP alone had no effect on plant growth. Addition of vesicular-arbuscular mycorrhizal fungi was necessary for maximum effect in the sterilized soil in the greenhouse experiment. Under field conditions, a treatment consisting of RP (20 kg of P per ha of soil) plus P. bilaji plus straw resulted in wheat yields and P uptake equivalent to increases due to the addition of monoammonium phosphate added at an equivalent rate of P. RP added alone had no effect on wheat growth or P uptake. The results indicate that a biological system of RP solubilization can be used to increase the availability of RP added to calcareous soils.     

Rock phosphate solubilization by psychrotolerant Pseudomonas spp. and their effect on lentil growth and nutrient uptake under polyhouse conditions

Psychrotolerant Pseudomonas isolates (RT5RP2 and RT6RP) isolated from the rhizoplane of wild grass at 3,100 and 3,800 m above mean sea level, respectively, from Rudraprayag district of Uttarakhand (India), were found to solubilize Udaipur rock phosphate (URP). Both isolates grew at temperatures ranging from 4 to 30 °C. Kinetics of phosphate solubilization by the bacterial strains showed a nonlinear regression of the rate of P solubilization, which fitted best in the power model, and showed a declining trend across three different temperatures. Under pot culture conditions, bacterization of lentil seeds (cv. VL Masoor 507) with the psychrotolerant Pseudomonas strains when combined with URP as a sole source of phosphorus resulting in significant enhancement in P uptake of the plants, compared to the application of rock phosphate alone.     

Evaluation of shelf life and rock phosphate solubilization of Burkholderia sp. in nutrient-amended clay, rice bran and rock phosphate-based granular formulation

Five phosphate-solubilizing bacteria (PSB) used in this study were isolated based on their ability to solubilize tricalcium phosphate (TCP) in Pikovskaya’s medium. Among the tested bacterial strains Burkholderia sp. strain CBPB-HIM showed the highest solubilization (363 μg of soluble P ml⁻¹) activity at 48 h of incubation. Further, this strain has been selected to assess its shelf life in nutrient-amended and -unamended clay, rice bran and rock phosphate (RP) pellet-based granular formulation. The results showed that the maximum viability of bacterium was observed in clay and rice bran (1:1) + 10% RP pellets than clay-RP pellets, irrespective of tested storage temperatures. Further, clay and rice bran (1:1) + 10% RP pellets amended with 1% glucose supported the higher number of cells compared to glycerol-amended and nutrient-unamended pellets. In this carrier solubilization of Morocco rock phosphate (MRP) by Burkholderia sp. strain CBPB-HIM was also investigated. The maximum of water and bicarbonate extractable P (206 and 245 μg P g⁻¹ of pellet respectively) was recorded in clay and rice bran (1:1) + 10% RP pellets amended with 1% glucose and glycerol respectively on day 5 of incubation. Therefore, this study proved the possibility of developing granular inoculant technology combining clay, rice bran and RP as substrates with phosphate-solubilizing Burkholderia.     

Mechanisms of phosphate solubilization by fungal isolates when exposed to different P sources

The use of phosphate-solubilizing fungi is a promising biotechnological strategy in the management of phosphorus (P) fertilization, as it enables the utilization of rock phosphates (RP) or the recovery of P fixed in soil particles. The objective of our study was to evaluate fungal isolates for mechanisms of solubilization of P-bearing compounds, such as AlPO₄, FePO₄, Ca₃(PO₄)₂, Araxá RP, and Catalão RP. Four fungal isolates obtained from Brazilian soils were characterized in liquid media: Aspergillus niger FS1, Penicillium canescens FS23, Eupenicillium ludwigii FS27, and Penicillium islandicum FS30. A. niger FS1 was the only isolate able to solubilize all of the P sources, solubilizing 71, 36, 100, and 14 % of the P from AlPO₄, FePO₄, Ca₃(PO₄)₂, and RPs, respectively. Medium acidification was an effective solubilization mechanism, particularly for Ca₃(PO₄)₂. The other P sources were mainly solubilized through organic acids produced by the fungi. Oxalic acid, produced exclusively by A. niger FS1, and citric acid were decisive factors in the solubilization of AlPO₄ and FePO₄. Penicillium isolates produced more gluconic acid than A. niger FS1 in all treatments. However, this higher production did not result in higher solubilization for any of the P sources, showing that gluconic acid contributes little to the solubilization of the P sources evaluated. The higher capacity of medium acidification and the production of organic acids with stronger metal-complexation activity are characteristics that confer to A. niger FS1 a wider action on insoluble P sources. Consequently, this isolate qualifies as a promising candidate for application in the management of P fertilization.     

Improvement of Arbuscular Mycorrhiza Development by Inoculation of Soil with Phosphate-Solubilizing Rhizobacteria To Improve Rock Phosphate Bioavailability ((sup32)P) and Nutrient Cycling

The interactive effect of phosphate-solubilizing bacteria and arbuscular mycorrhizal (AM) fungi on plant use of soil P sources of low bioavailability (endogenous or added as rock phosphate [RP] material) was evaluated by using soil microcosms which integrated (sup32)P isotopic dilution techniques. The microbial inocula consisted of the AM fungus Glomus intraradices and two phosphate-solubilizing rhizobacterial isolates: Enterobacter sp. and Bacillus subtilis. These rhizobacteria behaved as "mycorrhiza helper bacteria" promoting establishment of both the indigenous and the introduced AM endophytes despite a gradual decrease in bacterial population size, which dropped from 10(sup7) at planting to 10(sup3) CFU g(sup-1) of dry rhizosphere soil at harvest. Dual inoculation with G. intraradices and B. subtilis significantly increased biomass and N and P accumulation in plant tissues. Regardless of the rhizobacterium strain and of the addition of RP, AM plants displayed lower specific activity ((sup32)P/(sup31)P) than their comparable controls, suggesting that the plants used P sources not available in their absence. The inoculated rhizobacteria may have released phosphate ions ((sup31)P), either from the added RP or from the less-available indigenous P sources, which were effectively taken up by the external AM mycelium. Soluble Ca deficiency in the test soil may have benefited P solubilization. At least 75% of the P in dually inoculated plants derived from the added RP. It appears that these mycorrhizosphere interactions between bacterial and fungal plant associates contributed to the biogeochemical P cycling, thus promoting a sustainable nutrient supply to plants.     

Enhanced stability of a rumen-derived xylanase using SpyTag/SpyCatcher cyclization

A phosphate solubilizing bacterium ZB was isolated from the rhizosphere soil of Araucaria, which falls into the species Pantoea agglomerans. Optimization for phosphate solubilization by strain ZB was performed. At optimum culture conditions, the isolate showed great ability of solubilizing different insoluble inorganic phosphate sources viz. Ca₃(PO₄)₂ (TCP), Hydroxyapatite (HP), CaHPO₄, AlPO₄, FePO₄ along with rock phosphates (RPs). Inoculation with planktonic cells was found to enhance dissolved phosphorous as compared to that achieved by symplasma inoculation. Besides inoculation with different status of cells, pre-incubation could also exert a great effect on phosphate solubilization ability of P. agglomerans. When isolate ZB was cultured with glucose as carbon sources, phosphorous was more efficiently dissolved from HP and RP without pre-incubation in comparison to that obtained with pre-cultivation. Pre-cultivation, however, was more suitable for P solubilization than no pre-cultivation when bacteria were grown with xylose. A positive correlation was detected between the production of organic acids and phosphate solubilization. P. agglomerans ZB possessed many plant growth promotion traits such as N₂ fixation and production of indole 3-acetic acid, phytase, alkaline phosphatase. Pot experiment showed inoculation with single isolate ZB or biofertilizer prepared from semi-solid fermentation of isolate ZB with spent mushroom substrate (SMS) compost could enhance plant growth with respect to number of leaves, plant leave area, stem diameter, root length, root dry mass, shoot dry mass and biomass when compared to the abiotic control, revealing strain ZB could be a promising environmental-friendly biofertilizer to apply for agricultural field.

     

Characterization of the Mineral Phosphate-Solubilizing Activity of <Emphasis Type="Italic">Pantoea aglomerans</Emphasis> MMB051 Isolated from an Iron-Rich Soil in Southeastern Venezuela (Bolívar State)

The mineral phosphate-solubilizing (MPS) activity of a Pantoea agglomerans strain, namely MMB051, isolated from an iron-rich, acidic soil near Ciudad Piar (Bolívar State, Venezuela), was characterized on a chemically defined medium (NBRIP). Various insoluble inorganic phosphates, including tri-calcium phosphate [Ca₃(PO₄)₂], iron phosphate (FePO₄), aluminum phosphate (AlPO₄), and Rock Phosphate (RP) were tested as sole sources of P for bacterial growth. Solubilization of Ca₃(PO₄)₂ was very efficient and depended on acidification of the external milieu when MMB051 cells were grown in the presence of glucose. This was also the case when RP was used as the sole P source. On the other hand, the solubilization efficiency toward more insoluble mineral phosphates (FePO₄ and AlPO₄) was shown to be very low. Even though gluconic acid (GA) was detected on culture supernatants of strain MMB051, a consequence of the direct oxidation pathway of glucose, inorganic-P solubilization seemed also to be related to other processes dependent on active cell growth. Among these, proton release by ammonium (NH₄⁺) fixation appeared to be of paramount importance to explain inorganic-P solubilization mediated by strain MMB051. On the contrary, the presence of nitrate (NO₃^–) salts as the sole N source affected negatively the ability of MMB051 cells to solubilize inorganic P.     

Stabilization of dextransucrase from <Emphasis Type="Italic">Leuconostoc mesenteroides</Emphasis> NRRL B-640

Phosphate solubilizing yeast (PSY) were isolated from rhizosphere, non-rhizosphere and fruits from Bhavnagar district. The potential of 25 yeasts were analyzed on the basis of phosphate solubilizing zone to growth on solid medium denoted as solubilization index (SI) which ranged from 1.10 to 1.50. Among 25 yeast isolates, 6 yeast belonging to genus Saccharomyces (2), Hansenula, Klockera, Rhodotorula and Debaryomyces exhibited highest SI (1.33–1.50) were further examined for in vitro tricalcium phosphate (TCP) and low grade rock phosphate (RP) solubilization. TCP proved superior to RP with all the yeasts. Within low grade RPs tested, except isolate Y5, all isolates showed maximum solubilization with Hirapur RP (HRP) ranging from 7.24 to 19.30 mg% P₂O₅. Among six PSY screened, Debaryomyces hansenii showing maximal HRP solubilization was chosen for further physiological studies. Maximum HRP solubilization was expressed in following condition: pH optima 7.0, temperature optima 28°C and optimal period of incubation were 15 days. Acidic pH of the spent media was a constant feature in all the cases. No correlation could be established between final acidity produced by yeasts and the quantity of phosphate liberated.     

Rock phosphate solubilization by four yeast strains

The solubilization of rock phosphate (RP) by four yeast strains, Rhodotorula sp., Candida rugosa, Saccharomyces cerevisiae and Saccharomyces rouxii, which were isolated from wheat rhizospheric soils, was investigated in this study. The yeast isolates demonstrated diverse levels of soluble phosphate releasing abilities in modified Pikovskaya liquid medium containing RP as sole phosphate source. C. rugosa was the most effective solubilizer under different conditions, followed by Rhodotorula sp., S. rouxii and S. cerevisiae. Acidification of the broth seemed to be the major mechanism for RP solubilization by the yeast isolates, and the increase in soluble phosphate released was correlated significantly with an increase in titratable acidity and a drop in pH. The optimal composition for the solubilization of RP by the yeast isolates in the broth was 20 g L^?1 glucose, 1 g L^?1 yeast extract, 0.5 g L^?1 (NH₄)₂SO₄, and 5 g L^?1 RP, respectively. The yeast isolates were able to solubilize RP at wide range of temperature and initial pH, with the maximum percentage of soluble phosphate released being recorded at 30–35 °C and pH 5–6, respectively.     

Conversion for Avicel and AFEX pretreated corn stover by Clostridium thermocellum and simultaneous saccharification and fermentation: insights into microbial conversion of pretreated cellulosic biomass

In this study, efforts were taken to compare solubilization of Avicel and AFEX pretreated corn stover (AFEX CS) by SSF and Clostridium thermocellum fermentation, with an aim to gain insights into microbial conversion of pretreated cellulosic biomass. Solubilization rates for AFEX CS are comparable for the two systems while solubilization of Avicel is much faster by C. thermocellum. Initial catalyst loading impacts final cellulose conversion for SSF but not for C. thermocellum. Hydrolysis of the two substrates using cell-free C. thermocellum fermentation broth revealed much smaller difference in cellulose conversion than the difference observed for growing cultures. Tests on hemicellulose removal and particle size reduction for AFEX CS indicated that substrate accessibility is very important for enhanced solubilization by C. thermocellum.     

The Attractive Serratia plymuthica BMA1 Strain With High Rock Phosphate-Solubilizing Activity and Its Effect on the Growth and Phosphorus Uptake by Vicia faba L. Plants

Abstract

The present work aims to investigate the attractive ability of the newly isolated bacterium Serratia plymuthica BMA1, to release phosphorus (P) from rock phosphate (RP) and also to assess its beneficial effect in promoting the growth of Vicia faba. This strain exhibited the highest RP-solubilization activity ever reported, with 450?mg l^?1 of soluble P at 30?°C. At 10 and 20?°C, its RP-solubilization was estimated at 100 and 200?mg l^?1, respectively. HPLC analysis revealed that RP-solubilizing activity was associated with the release of gluconic acid. The hydroxyapatite (HA) solubilization activity concomitantly occurred with the secretion of gluconic acid and lactic acid. Under greenhouse conditions, application of BMA1 strain as an inoculant in presence of RP as the sole P source, considerably increased phosphorus uptake by V. faba L. and upgraded its overall growth in terms of dry weight and length by 76% and 39%, respectively. This growth promoting effect was accompanied by a substantial increase in chlorophyll contents. Additionally, phosphorus levels within roots and shoots of S. plymuthica BMA1-treated plants were approximately three times greater, compared to the non-inoculated control plants. When HA was used instead of RP, bacterization with BMA1 strain also enhanced the plant growth parameters and P contents, but significantly less than RP. These findings revealed that S. plymuthica BMA1 could be a potential candidate to improve the agronomic effectiveness of RP, toward a clean P-nutrition through the formulation of bio-phosphate fertilizers for plant growth promotion.     

Solubilization of Morocco phosphorite by Aspergillus niger

Phosphorus containing fertilizers have an important role in agriculture. Conventionally phosphate fertilizers are obtained by rock phosphate (RP) dissolution using mineral acids. Biotechnological methods can be a promising alternative in RP processing. The influence of Aspergillus niger strain, the composition of a nutritive medium, Morocco phosphorite (MP) concentration in the liquid medium, the time of bioconversion and the preliminary mechanical activation (PMA) of MP on the phosphorite microbial solubilization has been presented. The phosphorus concentration (as P2O5), citric acid production, glucose concentration and pH in the cultural medium were monitored. The phosphate concentration was expressed as water soluble - alpha1 (in the native cultural liquid), citrate soluble - alpha2 (after treating the biomass and remaining mineral mass with citric acid) and biomass available phosphorus - alpha3. Phosphate dissolution was not strongly correlated both with the citric acid production and the incubation period. When the fungi were grown without water soluble phosphorus compounds the MP solubilization had higher values. A maximum of 94.80% total P2O5 extraction was achieved. The PMA activity does not facilitate MP dissolution during the bioconversion.     

Organic acids associated with saccharification of cellulosic wastes during solid-state fermentation

Saccharification of five cellulosic wastes, i.e. rice husks, wheat bran, corn cobs, wheat straw and rice straw by three cellulytic fungi, i.e. Aspergillus glaums MN1, Aspergillus oryzae MN2 and Penicillium purpurogenum MN3, during solid-state fermentation (SSF) was laboratory studied. Rice husks, wheat bran, and corn cobs were selected as inducers of glucose production in the tested fungi. An incubation interval of 10 days was optimal for glucose production. Maximal activities of the cellulases FP-ase, CMC-ase, and p-glucosidase were detected during SSF of rice husks by P. purpurogenum; however, a-amylase activity (7.2 U/g) was comparatively reduced. Meanwhile, the productivities of FP-ase, CMC-ase, and β-glucosidase were high during SSF of rice husks by A glaucus; however, they decreased during SSF of corn cobs by P. purpurogenum. Addition of rock phosphate (RP) (75 mg P₂O₅) decreased the pH of SSF media. (NH₄)₂SO₄ was found to be less inducer of cellulytic enzymes, during SSF of rice husks by A. glaucus or A. oryzae; it also induced phytase production and solubilization of RP. The organic acids associated with saccharification of the wastes studied have also been investigated. The highest concentration of levulinic acid was detected (46.15 mg/g) during SSF of corn cobs by P. purpurogenum. Likewise, oxalic acid concentration was 43.20 mg/g during SSF of rice husks by P. purpurogenum.