Continuous anaerobic phenol degradation using an adapted mixed culture

A mixed culture derived from cow dung and sewage sludge and adapted to phenol was used for anaerobic phenol degradation. The phenol degradation rate depended on the period of adaptation of the mixed culture to phenol. In the continuous process, a higher degradation rate (2500 mg.1^-1 d^-1) and better reactor stability was achieved with a granular activated-carbon-packed bed reactor than with a stirred tank reactor.The authors are with the Department of Biochemical Engineering & Biotechnology, Indian Institute of Technology, Delhi Hauz Khas, New Delhi, India.     

The production of hemicellulose-degrading enzymes byBacillus macerans in anaerobic culture

Summary The cell-associated and exocellular hemicellulolytic polysaccharide depolymerase and glycoside hydrolase activity ofBacillus macerans NCDO 1764 was monitored over a range of anaerobic growth conditions in batch and continuous culture. The enzymes were detectable throughout the complete growth cycle in batch culture reaching and maintaining maximum levels in the stationary phase. In continuous culture enzyme activity was largely independent of growth rate (D=0.025–0.1 h^-1) although the activity was reduced at higher dilution rates (0.125–0.15 h^-1). Although activity was detectable over a wide pH range (pH 5.5–7.5) it was pH dependent, and maximum activities of both the cell-associated and exocellular enzymes were measured in cultures maintained at pH 6.5–7.0±0.1.The principal metabolites formed anaerobically from xylose byB. macerans in batch and continuous culture were acetic acid, formic acid and ethanol which represented 95–99% of the products formed. Smaller amounts of acetone,d,l-lactic acid and succinic acid were formed together with traces of butyric acid (<5 nmol/ml) and isovaleric acid (<25 nmol/ml). The proportions of the metabolites produced varied with growth conditions and were influenced by the pH of the culture and the rate and stage of growth of the microorganism.     

Continuous beer fermentation by high cell-density culture of bottom brewer's yeast

Continuous beer production was investigated in a high cell-density culture system which consisted of two stages for the fermentation and sedimentation of yeast cells. The continuous culture was carried out for a fermentation time of 5,500 h without contamination, at varying dilution rates and fermentation temperatures in the ranges of 0.017-0.033 h⁻¹ and 6.5–8.5°C, respectively. This process was found to be suitable for continuous and stable beer brewing. Under these conditions, the cell concentration in the first stage was about 80 times as high as that in the exit of the second stage. Concentrations of viable cells, sugar and ethanol were maintained at 1.3 × 10⁹ cells/ml, 25 and 36 g/l, respectively, and were hardly affected by fermentation temperature. Concentrations of ethyl acetate, isoamyl alcohol and isoamyl acetate were similar in the fermentation temperature ranges of 6.5–8.5°C, and the amounts at a fermentation temperature of 7°C were comparable to those of lager-type beer. Diacetyl flavor, which is known to be an effluent component that causes deterioration in the second stag e (young beer), was maintained at 1.2 ppm at a dilution rate and fermentation temperature of 0.022 h⁻¹ and 7°C, respectively. The diacetyl flavor was due to the accumulation of vicinal diketone, the precursor of which is acetohydroxy acid. The acetohydroxy acid was converted to vicinal diketone by pretreatment at 60°C for 30 min. The vicinal diketone was then consumed by the yeast during after-fermentation at a fermentation temperature of 3°C. Using this method, total vicinal diketone decreased below 0.3 ppm for an after-fermentation time of 6.8 h, which was 225 times as fast as that of after-fermentation without the pretreatment. This process may make it possible to achieve continuous beer fermentation from the fermentation stage to after-fermentation for diacetyl removal.     

Identification of enzymes involved in anaerobic benzene degradation by a strictly anaerobic iron‐reducing enrichment culture

Anaerobic benzene degradation was studied with a highly enriched iron‐reducing culture (BF) composed of mainly Peptococcaceae‐related Gram‐positive microorganisms. The proteomes of benzene‐, phenol‐ and benzoate‐grown cells of culture BF were compared by SDS‐PAGE. A specific benzene‐expressed protein band of 60 kDa, which could not be observed during growth on phenol or benzoate, was subjected to N‐terminal sequence analysis. The first 31 amino acids revealed that the protein was encoded by ORF 138 in the shotgun sequenced metagenome of culture BF. ORF 138 showed 43% sequence identity to phenylphosphate carboxylase subunit PpcA of Aromatoleum aromaticum strain EbN1. A LC/ESI‐MS/MS‐based shotgun proteomic analysis revealed other specifically benzene‐expressed proteins with encoding genes located adjacent to ORF 138 on the metagenome. The protein products of ORF 137, ORF 139 and ORF 140 showed sequence identities of 37% to phenylphosphate carboxylase PpcD of A. aromaticum strain EbN1, 56% to benzoate‐CoA ligase (BamY) of Geobacter metallireducens and 67% to 3‐octaprenyl‐4‐hydroxybenzoate carboxy‐lyase (UbiD/UbiX) of A. aromaticum strain EbN1 respectively. These genes are proposed as constituents of a putative benzene degradation gene cluster (～17 kb) composed of carboxylase‐related genes. The identified gene sequences suggest that the initial activation reaction in anaerobic benzene degradation is probably a direct carboxylation of benzene to benzoate catalysed by putative anaerobic benzene carboxylase (Abc). The putative Abc probably consists of several subunits, two of which are encoded by ORFs 137 and 138, and belongs to a family of carboxylases including phenylphosphate carboxylase (Ppc) and 3‐octaprenyl‐4‐hydroxybenzoate carboxy‐lyase (UbiD/UbiX).     

The induction of D-xylose catabolizing enzymes inPachysolen tannophilus and the relationship to anaerobic D-xylose fermentation

Summary Aerobic cultures harvested from the lag and early exponential growth phases fermented D-xylose poorly under anaerobic conditions whereas fermentation by late exponential and stationary phase cultures was rapid. These differences could be related to the ratios of NADH- to NADPH-linked xylose reductase (XR) and the levels of NADH-linked XR and NAD-linked xylitol dehydrogenase (XD) present. Under aerobic conditions, induction of NADPH-linked XR preceded NADH-linked XR which suggested the presence of two separate XR't's. Induction of XR and XD was more rapid under aerobic than anaerobic conditions.     

Pectinolytic enzymes of anaerobic fungi

Pectinolytic enzymes of four rumen fungi have been described. Three fungal species were monocentric Neocallimastix spp. H15, JL3 and OC2, and one isolate was a polycentric strain of Orpinomyces joyonii , A4. They differed in degree of pectin degradation and utilization. Only the strain Neocallimastix sp. H15 and partially Orpinomyces joyonii A4 were able to utilize pectin to a higher extent. The most important pectinolytic activity in all these isolates represented pectin lyase (EC 4.2.2.10) and polygalacturonase (EC 3.2.1.15). Their specific activities were in the range of 100–900 and 10–450 μg galacturonic acid h^-1 mg protein^-1 for pectin lyase and polygalacturonase, respectively. Polygalacturonase, located mainly in the endocellular fraction, was inhibited by calcium ions and had the main pH optimum at pH 6.0. All strains produced pectate lyase (EC 4.2.2.2). None of the strains tested produced pectinesterase (EC 3.1.1.11).     

Dilution rate increases production of plant cell-wall degrading enzymes by anaerobic fungi in continuous-flow culture

The gut anaerobic fungi,Neocallimastix hurleyensis and aOrpinomyces sp., were grown in 100 mL batch and continuous-flow cultures on wheat straw at a concentration of 80 g dry matter/L of culture liquid. In batch cultures,N. hurleyensis and Orpinomyces sp. degraded only ca. 9% and 5% of the wheat straw, respectively. In continuous-flow cultures, however, the two fungi degraded 52-56% of the apparent dry matter of wheat straw. Both fungi were able to produce greater quantities (up to x 30) of cell-wall degrading enzymes (CMCase, xylanase, beta-glucosidase and beta-xylosidase) in continuous-flow cultures than in the corresponding batch cultures. Increasing the dilution rate in continuous-flow culture resulted in the production of increased enzyme activity for all the measured cell-wall degrading enzymes, with proportional relationships between dilution rate and the cumulative activities of beta-glucosidase and beta-xylosidase. Dilution rates, however, had no consistent effect on the cumulative production of the fermentation end-products, acetate, formate, D- and L-lactate from both fungi. In addition to acetate and formate,N. hurleyens is produced D- and L-lactate in both batch and continuous-flow cultures, whereas only trace amounts of L-lactate were detected in the Orpinomyces sp. cultures.     

Differential induction of enzymes involved in anaerobic metabolism of aromatic compounds in the denitrifying bacterium Thauera aromatica

Differential induction of enzymes involved in anaerobic metabolism of aromatic substrates was studied in the denitrifying bacterium Thauera aromatica. This metabolism is divided into (1) peripheral reactions transforming the aromatic growth substrates to the common intermediate benzoyl-CoA, (2) the central benzoyl-CoA pathway comprising ring-reduction of benzoyl-CoA and subsequent β-oxidation to 3-hydroxypimelyl-CoA, and (3) the pathway of β-oxidation of 3-hydroxypimelyl-CoA to three acetyl-CoA and CO₂. Regulation was studied by three methods. 1. Determination of protein patterns of cells grown on different substrates. This revealed several strongly substrate-induced polypeptides that were missing in cells grown on benzoate or other intermediates of the respective metabolic pathways. 2. Measurement of activities of known enzymes involved in this metabolism in cells grown on different substrates. The enzyme pattern found is consistent with the regulatory pattern deduced from simultaneous adaptation of cells to utilisation of other aromatic substrates. 3. Immunological detection of catabolic enzymes in cells grown on different substrates. Benzoate-CoA ligase and 4-hydroxybenzoate-CoA ligase were detected only in cells yielding the respective enzyme activity. However, presence of the subunits of benzoyl-CoA reductase and 4-hydroxybenzoyl-CoA reductase was also recorded in some cell batches lacking enzyme activity. This possibly indicates an additional level of regulation on protein level for these two reductases. Received: 22 December 1997 / Accepted: 12 May 1998     

Aerobic induction of respiro-fermentative growth by decreasing oxygen tensions in the respiratory yeast Pichia stipitis

The fermentative and respiratory metabolism of Pichia stipitis wild-type strain CBS 5774 and the derived auxotrophic transformation recipient PJH53 trp5-10 his3-1 were examined in differentially oxygenated glucose cultures in the hermetically sealed Sensomat system. There was a good agreement of the kinetics of gas metabolism, growth, ethanol formation and glucose utilisation, proving the suitability of the Sensomat system for rapid and inexpensive investigation of strains and mutants for their respiratory and fermentative metabolism. Our study revealed respiro-fermentative growth by the wild-type strain, although the cultures were not oxygen-limited. The induction of respiro-fermentative behaviour was obviously due to the decrease in oxygen tension but not falling below a threshold of oxygen tension. The responses differed depending on the velocity of the decrease in oxygen tension. At high oxygenation (slow decrease in oxygen tension), ethanol production was induced but glucose uptake was not influenced. At low oxygenation, glucose uptake and ethanol formation increased during the first hours of cultivation. The transformation recipient PJH53 most probably carries a mutation that influences the response to a slow decrease in oxygen tension, since almost no ethanol formation was found under these conditions.     

Starch-degrading enzymes from anaerobic non-clostridial bacteria

Summary A number of meso- and thermophilic anaerobic starch-degrading non-spore-forming bacteria have been isolated. All the isolates belonging to different genera are strictly anaerobic, as indicated by a catalase-negative reaction, and produce soluble starch-degrading enzymes. Compared to enzymes of aerobic bacteria, those of anaerobic origin mainly show low molecular mass of about 25 000 daltons. Some of the enzymes may have useful applications in the starch industry because of their unusual product pattern, yielding maltotetraose as the main hydrolysis product. Offprint requests to: W. Trösch