Changes in metabolism of the rumen bacterium Streptococcus bovis H13/1 resulting from alteration in dilution rate and glucose supply per unit time

Streptococcus bovis H13/1 was grown in a glucose-limited chemostat. A concomitant increase in dilution rate and glucose supply per unit time caused both an increase in lactate production per mole of glucose fermented and a linear increase in growth yield over the dilution rate range 0.052 to 0.141/h. When the dilution rate was increased with no change in glucose supply per unit time there was a reduction in lactate production and an increase in that of acetate and ethanol coinciding with a non-linear increase in growth yield. Y_glu^Max= 38.6 and a maintenance coefficient, m_s= 0.290 mmol/l glucose/g cells/h were calculated. The results also suggested an interaction between the formate and CO₂ pools.     

Metabolism of the rumen bacterium Selenomonas ruminantium grown in continuous culture

Selenomonas ruminantium 0078A was grown in a glucose-limited chemostat over a dilution rate range of 0.049-0-137/h. Fermentation products were acetate, propionate, succinate, lactate and C0₂; traces of ethanol were also detected. Succinate accounted for up to 52% of the substrate glucose carbon. When dilution rate was increased without a concomitant increase in glucose supply per unit time there were changes in the fermentation pattern which were not apparent when both dilution rate and glucose supply were simultaneously increased; the molar proportion of acetate increased at the expense of propionate.     

The effect of the dilution rate on CHO cell physiology and recombinant interferon-gamma production in glucose-limited chemostat culture

The physiology of a recombinant Chinese hamster ovary cell line in glucose-limited chemostat culture was studied over a range of dilution rates (D = 0.008 to 0.20 h(-1)). The specific growth rate (mu) deviated from D at low dilution rates due to an increased specific death rate. Extrapolation of these data suggested a minimum specific growth rate of 0.011 h(-1) (mu(max) = 0.025 h(-1)) The metabolism at each steady state was characterized by determining the metabolic quotients for glucose, lactate, ammonia, amino acids, and interferon-gamma (IFN-gamma). The specific rate of glucose uptake increased linearly with mu, and the saturation constant for glucose (K(s)) was calculated to be 59.6 muM. There was a linear increase in the rate of lactate production with a higher yield of lactate from glucose at high growth rates. The decline in the rate of production of lactate, alanine, and serine at low growth rate was consistent with the limitation of the glycolytic pathway by glucose. The specific rate of IFN-gamma production increased with mu in a manner indicative of a growth-related product. Despite changes in the IFN-gamma production rate and cell physiology, the pattern of IFN-gamma glycosylation was similar at all except the lowest growth rates where there was increased production of nonglycosylated IFN-gamma. (c) 1993 John Wiley & Sons, Inc.     

The role of oxygen limitation in the formation of poly-β-hydroxybutyrate during batch and continuous culture of Azotobacter beijerinckii

Azotobacter beijerinckii was grown in ammonia-free glucose-mineral salts media in batch culture and in chemostat cultures limited by the supply of glucose, oxygen or molecular nitrogen. In batch culture poly-beta-hydroxybutyrate was formed towards the end of exponential growth and accumulated to about 74% of the cell dry weight. In chemostat cultures little poly-beta-hydroxybutyrate accumulated in organisms that were nitrogen-limited, but when oxygen limited a much increased yield of cells per mol of glucose was observed, and the organisms contained up to 50% of their dry weight of poly-beta-hydroxybutyrate. In carbon-limited cultures (D, the dilution rate,=0.035-0.240h(-1)), the growth yield ranged from 13.1 to 19.8g/mol of glucose and the poly-beta-hydroxybutyrate content did not exceed 3.0% of the dry weight. In oxygen-limited cultures (D=0.049-0.252h(-1)) the growth yield ranged from 48.4 to 70.1g/mol of glucose and the poly-beta-hydroxybutyrate content was between 19.6 and 44.6% of dry weight. In nitrogen-limited cultures (D=0.053-0.255h(-1)) the growth yield ranged from 7.45 to 19.9g/mol of glucose and the poly-beta-hydroxybutyrate content was less than 1.5% of dry weight. The sudden imposition of oxygen limitation on a nitrogen-limited chemostat culture produced a rapid increase in poly-beta-hydroxybutyrate content and cell yield. Determinations on chemostat cultures revealed that during oxygen-limited steady states (D=0.1h(-1)) the oxygen uptake decreased to 100mul h(-1) per mg dry wt. compared with 675 for a glucose-limited culture (D=0.1h(-1)). Nitrogen-limited cultures had CO(2) production values in situ ranging from 660 to 1055mul h(-1) per mg dry wt. at growth rates of 0.053-0.234h(-1) and carbon-limited cultures exhibited a variation of CO(2) production between 185 and 1328mul h(-1) per mg dry wt. at growth rates between 0.035 and 0.240h(-1). These findings are discussed in relation to poly-beta-hydroxybutyrate formation, growth efficiency and growth yield during growth on glucose. We suggest that poly-beta-hydroxybutyrate is produced in response to oxygen limitation and represents not only a store of carbon and energy but also an electron sink into which excess of reducing power can be channelled.     

Cultivation of hybridoma cells in continuous cultures: kinetics of growth and product formation

Mouse hybridoma cells were grown in suspension in continuous stirred bioreactors. Cell growth, substrate utilization, and monoclonal antibody (MAb) production were studied using serum-free medium. Steady-state data were obtained at different dilution rates, between 0.012 and 0.039 h(-1) Viability was profoundly affected by dilution rate, particularly near the lower end of the dilution-rate range investigated. MAb concentration and productivity went through a maximum with respect to dilution rate. Lactate yield on glucose declined with in creasing dilution rate. Experiments were carried out to study the effects of medium glucose concentration on cell growth, product formation, and lactate yield on glucose. Reduction of glucose concentration in the feed medium did not considerably affect cell density and MAb concentration in the culture, but lactate levels dropped sharply; lactate yield on glucose declined substantially, indicating alterations in cell metabolic path ways for energy metabolism. Optimization strategy for continuous cell culture is discussed.     

Growth of Bacteroides fragilis in Continuous Culture and in Batch Cultures at Controlled pH

Bacteroides fragilis NCTC 9343 has been grown in continuous cultures with glucose as growth-limiting factor. At pH 7.0 and at a dilution rate of 0.07 per h, glucose limited growth in concentrations up to 0.6%. Maximal cell yield and productivity were obtained with 0.87% glucose in the inflowing medium. A pH of 7.0 was optimal for growth. With 0.6% glucose in the fresh medium and at pH 7.0, cell yield and productivity were highest at a dilution rate of 0.07 per h and 0.11 per h, respectively. At dilution rates higher than 0.07 per h, glucose was no longer growth limiting, and at dilution rates above 0.11 per h, another compound seemed to have replaced glucose also as energy source. When grown in batch cultures at pH 7.0, the best yields of B. fragilis was achieved with 0.6% glucose in the fresh medium. The highest specific growth rate (mum) determined from viable counts was 0.45, corresponding to a mean generation time of 92 min.     

Influence of CO(2)-HCO(3) Levels and pH on Growth, Succinate Production, and Enzyme Activities of Anaerobiospirillum succiniciproducens

Growth and succinate versus lactate production from glucose by Anaerobiospirillum succiniciproducens was regulated by the level of available carbon dioxide and culture pH. At pH 7.2, the generation time was almost doubled and extensive amounts of lactate were formed in comparison with growth at pH 6.2. The succinate yield and the yield of ATP per mole of glucose were significantly enhanced under excess-CO(2)-HCO(3) growth conditions and suggest that there exists a threshold level of CO(2) for enhanced succinate production in A. succiniciproducens. Glucose was metabolized via the Embden-Meyerhof-Parnas route, and phosphoenolpyruvate carboxykinase levels increased while lactate dehydrogenase and alcohol dehydrogenase levels decreased under excess-CO(2)-HCO(3) growth conditions. Kinetic analysis of succinate and lactate formation in continuous culture indicated that the growth rate-linked production rate coefficient (K) cells was much higher for succinate (7.2 versus 1.0 g/g of cells per h) while the non-growth-rate-related formation rate coefficient (K') was higher for lactate (1.1 versus 0.3 g/g of cells per h). The data indicate that A. succiniciproducens, unlike other succinate-producing anaerobes which also form propionate, can grow rapidly and form high final yields of succinate at pH 6.2 and with excess CO(2)-HCO(3) as a consequence of regulating electron sink metabolism.     

Kinetics of product formation in batch and continuous culture of Clostridium barkeri

Summary The main fermentation end products in batch culture (unlimited glucose supply) of Clostridium barkeri were butyrate and lactate. The specific rate of butyrate production was linearly proportional to the growth rate while the specific rate of lactate production increased at low growth rates. In a glucose limited chemostat culture butyrate production was partly growth associated while acetate and lactate production was growth associated. Lactate was, however, only produced at high dilution rates. By varying the glucose concentration in the inflowing medium it was shown that lactate production was stimulated by a high feeding rate of the carbon source. These results are discussed in view of the fructose-1,6-diphosphate dependent lactate dehydrogenase activity in many other organisms.     

Physiological behaviour of Hanseniaspora guilliermondii in aerobic glucose-limited continuous cultures

The physiology of Hanseniaspora guilliermondii was studied under aerobic glucose-limited conditions using the accelerostat procedure (continuous acceleration of dilution rate) and classical chemostat cultures. By both cultivation techniques this yeast was found to be Crabtree-positive. Up to a dilution rate of 0.25 h(-1), glucose was completely metabolised into biomass, glycerol and carbon dioxide. Above this value, an increase in the dilution rate was accompanied by the production of other metabolites like ethanol, acetic and malic acids. Biomass yield during the purely oxidative growth was 0.49 g g(-1) and decreased to 0.26 g g(-1) for D=0.34 h(-1). A maximal specific ethanol production rate of 1.36 mmol g(-1) h(-1) and a maximal ethanol yield of 0.05 g g(-1) were achieved at D=0.34 h(-1).     

Production of extracellular protease and glucose uptake in Bacillus clausii in steady-state and transient continuous cultures

The production of the extracellular alkaline protease Savinase (EC 3.4.21.62) and glucose uptake in a non-sporulating strain of Bacillus clausii were investigated by analysing steady-state and transients during continuous cultivations. The specific production rate was found to have an optimum at a dilution rate between 0.14 and 0.17 h(-1), whereas the yield of Savinase on glucose was found to increase with decreasing specific growth rate. A linear relationship between the ribosomal RNA content and the specific production rate was found, indicating that the translational capacity may be limiting for product formation. The dynamics of the production of Savinase were studied during step changes in the dilution rate. During a step down in the dilution rate the specific production rate decreased immediately until it reached a new steady value. During a step-up an initial cease in the production rate was observed, but when glucose stopped to accumulate the production rate was regained. The glucose uptake was further investigated when chemostat cultures growing at different dilution rates were exposed to glucose pulses. The maximal glucose uptake capacity was found to be dependent on the initial specific growth rate. Furthermore, the adaptation to high glucose concentrations was faster at high dilution rates than at low dilution rates.     

The kinetics of glucose fermentation bySelenomonas ruminantium HD4 grown in continuous culture

Summary The production of organic acids (acetate, lactate, and propionate) by the anaerobic, ruminal bacteriumSelenomonas ruminantium HD4 was investigated in both glucose-limited and glucose-sufficient (phosphate-limited) continuous cultures. The fermentation pattern of products exhibited a shift upon release of glucose limitation from acetate and propionate to lactate at a dilution rate of 0.2 h^–1. Glucose sufficiency brought about two-to fourfold increase in specific glucose utilization rate, lactate productivity, and lactate yield relative to glucose-limited growth conditions. The increased lactate production under glucose-sufficient growth conditions was attributed to the overutilization of excess glucose.The mention of firm names or trade products does not imply that they are endorsed or recommended by the U.S. Department of Agriculture over other firms or similar products not mentioned.     

Continuous cultivation of the yeastSaccharomyces cerevisiae at different dilution rates and glucose concentrations in nutrient media

The influence of glucose concentration in nutrient media on the specific growth rate and biomass yield in the course of continuous fermentation ofSaccharomyces cerevisiae was investigated. An increase of glucose content in media decreased the specific growth rate and the biomass yield. Glucose concentration had significant effects on protein and phosphate contents of cells. However, an increased glucose concentration increased the fermentative power ofS. cerevisiae (SJA-method). An increase of the dilution rate decreased the cell concentration in the fermentor. Specific growth rate approached the values of the dilution rate. The best agreement has been obtained at a dilution rate of 0.20/h. This dilution rate proved to be most convenient for the investigated microorganism and cultivation conditions (media composition, pH, aeration intensity and temperature). Biomass yield proved to be decreased by an increase of the dilution rate.     

Evidence for cytochrome involvement in fumarate reduction and adenosine 5'-triphosphate synthesis by Bacteroides fragilis grown in the presence of hemin.

Growth of Bacteroides fragilis subsp. fragilis on glucose was very much stimulated by the addition of hemin (2 mg/liter) to the medium. The generation time decreased from 8 to 2 h, and the molar growth yield increased from YM = 17.9 to YM = 47 g (dry weight) of cells per mol of glucose. In the absence of hemin, glucose was fermented to fumarate, lactate, and acetate. The cells did not contain detectable amounts of cytochromes or fumarate reductase. In the presence of hemin, the major products of fermentation were succinate, propionate, and acetate. A b-type cytochrome, possibly a c-type cytochrome, and a very active fumarate reductase were present in the cells. It is concluded from these results that hemin is required by B. fragilis to synthesize a functional fumarate reductase and that the hemin-dependent, enormous increase of the growth yield may be due to adenosine 5'-triphosphate production during reduction of fumarate to succinate.     

Control of lactate production by Selenomonas ruminantium: homotropic activation of lactate dehydrogenase by pyruvate.

Selenomonas ruminantium produced one mole of D(-)-lactate per mole of glucose used at all dilution rates in ammonia-limited continuous culture. In contrast, lactate production varied according to the dilution rate when glucose was the limiting nutrient. At dilution rates of less than 0.2 h-1, acetate and propionate were the main fermentation products and lactate production was low. At dilution rates above 0.2 h-1, the pattern changed to one of high lactate production similar to that under ammonia limitation. Experiments with cell-free extracts of S. ruminantium showed that D(-)-lactate dehydrogenase had sigmoidal kinetics consistent with homotropic activation of the enzyme by its substrate, pyruvate. This feature allows S. ruminantium to amplify the effects of relatively small changes in the intracellular concentration of pyruvate to cause much larger changes in the rate of production of lactate. Some confirmation that this mechanism of control occurs under physiological conditions was obtained in glucose-limited culture, in which the sigmoidal increase in lactate production was accompanied by a linear increase in pyruvate excretion as the dilution rate increased.     

Metabolic and kinetic studies of hybridomas in exponentially fed-batch cultures using T-flasks

Exponentially fed-batch cultures (EFBC) of a murine hybridoma in T-flasks were explored as a simple alternative experimental tool to chemostats for the study of metabolism, growth and monoclonal antibody (MAb) production kinetics. EFBC were operated in the variable volume mode using an exponentially increasing and predetermined stepwise feeding profile of fresh complete medium. The dynamic and steady-state behaviors of the EFBC coincided with those reported for chemostats at dilution rates below the maximum growth rate. In particular, steady-state for growth rate and concentration of viable cells, glucose, and lactate was attained at different dilution rates between 0.005 and 0.05 h^–1. For such a range, the glucose and lactate metabolic quotients and the steady-state glucose concentration increased, whereas total MAb, volumetric, and specific MAb production rates decreased 65-, 6-, and 3-fold, respectively, with increasing dilution rates. The lactate from glucose yield remained relatively constant for dilution rates up to 0.03 h^–1, where it started to decrease. In contrast, viability remained above 80% at high dilution rates but rapidly decreased at dilution rates below 0.02 h^–1. No true washout occurred during operation above the maximum growth, as concluded from the constant viable cell number. However, growth rate decreased to as low as 0.01 h^–1, suggesting the requirement of a minimum cell density, and concomitant autocrine growth factors, for growth. Chemostat operation drawbacks were avoided by EFBC in T-flasks. Namely, simple and stable operation was obtained at dilution rates ranging from very low to above the maximum growth rate. Furthermore, simultaneous operation of multiple experiments in reduced size was possible, minimizing start-up time, media and equipment costs.Abbreviations EFBC exponentially-fed batch culture - CSC continuous suspended culture - MAb monoclonal antibody - D dilution rate - q _i metabolic quotient or specific rate of consumption or production of i     

Scale-up and optimization of culture conditions of a human heterohybridoma producing serotype-specific antibodies to Pseudomonas aeruginosa

Summary Three different stirred bioreactors of 0.5 to 12 l volume were used to scale up the production of a human monoclonal antibody. Inoculation density and stirrer speed were evaluated in batch cultures, whereas dilution rate and pH were optimized in chemostat cultures with respect to high specific antibody production rate and high antibody yield per time and reactor volume. The cell line used for the experiments was a heterohybridoma, producing immunoglobulin M (IgM) against lipopolysaccharide of Pseudomonas aeruginosa. Cells were cultured in spinner flasks of 500 ml liquid volume for adaptation to stirred culture conditions. Subsequently cells were transferred to the 1.5-1 KLF 2000 bioreactor and to the 12-1 NLF 22 bioreactor for pilot-scale cultures. Chemostat experiments were done in the 1.5-1 KLF bioreactor. Cell density, viability, glucose and lactate and antibody concentration were measured during culture experiments. In batch cultures in all three stirred bioreactors, comparable maximal cell densities and specific growth rates were achieved. Chemostat experiments showed that at a pH of 6.9 and a dilution rate of 0.57 per day the specific antibody production rate was threefold higher than similar experiments done at pH 7.2 with a dilution rate of 0.36 per day. By optimizing pH and dilution rate in chemostat cultures the daily yield of human IgM increased nearly threefold from 6 to 16 mg/day and per litre of reactor volume. The yield per litre of medium increased twofold. Correspondence to: U. Schürch     

Kinetics of substrate utilization in adenine-limited chemostat cultures of Bacillus subtilis KYA741.

The specific rates of limiting substrate utilization were investigated in adenine- or glucose-limited chemostat cultures of Bacillus subtilis KYA741, an adenine-requiring strain, at 37 degrees C. With the glucose-limited cultures, the specific rate of glucose consumption versus dilution rate gave a linear relationship from which the true growth yield and maintenance coefficient were determined to be 0.09 mg of bacteria per mg of glucose and 0.2 mg of glucose per mg of bacteria per h, respectively. With the adenine-limited cultures, adenine as the limiting substrate was not completely consumed at lower dilution rates (e.g., D less than 0.1), unlike in the glucose-limited cultures. When a linear relationship of specific rate of adenine consumption versus dilution rate was extrapolated to zero dilution rate, a negative value for the specific rate of adenine consumption, -0.01 mg of adenine per mg of bacteria per h, was obtained, giving a true growth yield for adenine of 5.2 mg of bacteria per mg of adenine. On the other hand, the maintenance coefficient of oxygen uptake gave a positive value of 8.1 x 10(-3) mmol/mg of bacteria per h. Based on previous results showing that adenine is resupplied by lysing cells, we developed kinetic models of adenine utilization and cell growth that gave a good estimation of the peculiar behavior of cell growth and adenine utilization in adenine-limited chemostat cultures.     

Influence of CO2-HCO3− Levels and pH on Growth, Succinate Production, and Enzyme Activities of Anaerobiospirillum succiniciproducens

Growth and succinate versus lactate production from glucose by Anaerobiospirillum succiniciproducens was regulated by the level of available carbon dioxide and culture pH. At pH 7.2, the generation time was almost doubled and extensive amounts of lactate were formed in comparison with growth at pH 6.2. The succinate yield and the yield of ATP per mole of glucose were significantly enhanced under excess-CO₂-HCO₃⁻ growth conditions and suggest that there exists a threshold level of CO₂ for enhanced succinate production in A. succiniciproducens. Glucose was metabolized via the Embden-Meyerhof-Parnas route, and phosphoenolpyruvate carboxykinase levels increased while lactate dehydrogenase and alcohol dehydrogenase levels decreased under excess-CO₂-HCO₃⁻ growth conditions. Kinetic analysis of succinate and lactate formation in continuous culture indicated that the growth rate-linked production rate coefficient (K) cells was much higher for succinate (7.2 versus 1.0 g/g of cells per h) while the non-growth-rate-related formation rate coefficient (K′) was higher for lactate (1.1 versus 0.3 g/g of cells per h). The data indicate that A. succiniciproducens, unlike other succinate-producing anaerobes which also form propionate, can grow rapidly and form high final yields of succinate at pH 6.2 and with excess CO₂-HCO₃⁻ as a consequence of regulating electron sink metabolism.     

Adenylate energy charge in Acholeplasma laidlawii.

Adenosine 5'-triphosphate, adenosine 5'-diphosphate, and adenosine 5'-monophosphate were produced by Acholeplasma laidlawii B-PG9 growing in modified Edward medium. The adenylate energy charge was calculated to be 0.84 +/- 0.07 and ranged from 0.91 to 0.78 during exponential growth (12 to 24 h). During exponential growth, A. laidlawii contained, at 17.5 h, 2.3 X 10(-17) mol of adenosine 5'-triphosphate per colony-forming unit and, at 16 h, 27.3 nmol of adenosine 5'-triphosphate per mg (dry weight). The medium supported a doubling time of 0.95 h. The molar growth yields (Yglucose = grams [dry weight] per mole of glucose used) were 40.2 +/- 3.4 (16 h) and 57.1 +/- 9.7 (20 h) during midexponential growth. A maximum yield of 8.3 X 10(9) colony-forming units was reached at 24 h, when 56% of the initial concentration of glucose had been used. At 40 h, during the stationary phase, 14.95 +/- 3.75 mumol of glucose per ml of medium had been used. At this time, the culture fluids contained 21.86 +/0 mumol of lactate per ml and 3.14 +/- 0.13 mumol of pyruvate per ml.     

Effects of ammonia and lactate on hybridoma growth, metabolism, and antibody production

The influence of ammonia and lactate on cell growth, metabolic, and antibody production rates was investigated for murine hybridoma cell line 163.4G5.3 during batch culture. The specific growth rate was reduced by one-half in the presence of an initial ammonia concentration of 4 mM. Increasing ammonia levels accelerated glucose and glutamine consumption, decreased ammonia yield from glutamine, and increased alanine yield from glutamine. Although the amount of antibody produced decreased with increasing ammonia concentration, the specific antibody productivity remained relatively constant around a value of 0.22 pg/cell-h. The specific growth rate was reduced by one-half at an initial lactate concentration of 55 mM. Although specific glucose and glutamine uptake rates were increased at high lacatate concentration, they showed a decrease after making corrections for medium osmolarity. The yield coefficient of lactate from glucose decreased at high lactate concentrations. A similar decrease was observed for the ammonia yield coefficient from glutamine. At elevated lactate concentrations, specific antibody productivities increased, possibly due to the increase in medium osmolarity. The specific oxygen uptake rate was insensitive to ammonia and lactate concentrations. Addition of ammonia and lactate increased the calculated metabolic energy production of the cells. At high ammonia and lactate, the contribution of glycolysis to total energy production increased. Decreasing external pH and increasing ammonia concentrations caused cytoplasmic acidification. Effect of lactate on intracellular pH was insignificant, whereas increasing osmolarity caused cytoplasmic alkalinization.