Optimization of a new heteropolysaccharide production by a native isolate of Leuconostoc sp. CFR-2181

Aim:  This work is aimed at optimizing the production of a new heteropolysaccharide (HePS) of Leuconostoc sp. CFR-2181 by standardizing the fermentation conditions in a low cost semi-synthetic medium.
Methods and Results:  Both nutritional and cultural parameters, such as carbon source and its concentration, initial pH of the exopolysaccharide (EPS) medium, fermentation temperature and fermentation period were optimized. Fermentation of the EPS medium (pH 6·7), containing sucrose at 5% (w/v) and 5% (v/v) inoculum, at 25 ° C resulted in maximum production of HePS (18·38 g l⁻¹) by the isolate in 4 h of fermentation.
Conclusions:  The isolate was found to produce good amount of HePS in just 4 h in a low cost semi-synthetic EPS medium.
Significance and Impact of the Study:  This is the first report on rapid production of HePS by any lactic culture, which can significantly reduce the cost of the EPS.     

A simple test tube screening method for identifying aflatoxin-producing strains of Aspergillus sp. using coconut milk agar medium

Most agricultural commodities are susceptible to Aspergillus sp. infestation and aflatoxin elaboration. A simple test-tube screening procedure using fresh coconut milk agar medium (CMAM), for identifying toxigenic strains of Aspergillus sp., based on u.v. fluorescence (365 nm) and visual detection has been proposed and evaluated.     

Biodegradation of nicotine by a newly isolated Agrobacterium sp. strain S33

Aims: To isolate and characterize bacteria capable of degrading nicotine from the rhizospheric soil of a tobacco plant and to use them to degrade the nicotine in tobacco solid waste. Methods and Results: A bacterium, strain S33, was newly isolated from the rhizospheric soil of a tobacco plant, and identified as Agrobacterium sp. based on morphology, physiological tests, Biolog MicroLog3 4·20 system and 16S rRNA gene sequence. Using nicotine as the sole source of carbon and nitrogen in the medium, it grew optimally with 1·0 g l^?1 of nicotine at 30°C and pH 7·0, and nicotine was completely degraded within 6 h. The resting cells prepared from the glucose‐ammonium medium or LB medium could not degrade nicotine within 10 h, while those prepared from the nicotine medium could completely degrade 3 g l^?1 of nicotine in 1·5 h at a maximal rate of 1·23 g nicotine h^?1 g^?1 dry cell. Using the medium containing nicotine, glucose and ammonium simultaneously to cultivate strain S33, the resting cells could degrade 98·87% of nicotine in tobacco solid waste with the concentration as 30 mg nicotine g^?1 dry weight tobacco solid waste within 7 h at a maximal rate of 0·46 g nicotine h^?1 g^?1 dry cell. Conclusions: This is the first report that Agrobacterium sp. has the ability to degrade nicotine. Agrobacterium sp. S33 could use nicotine as the sole source of carbon and nitrogen. The use of resting cells of the strain S33 prepared from the nicotine–glucose–ammonium medium was an effective method to degrade nicotine and detoxify tobacco solid waste. Significance and Impact of the Study: Nicotine in tobacco wastes is both toxic and harmful to human health and the environment. This study showed that Agrobacterium sp. S33 may be suitable for the disposal of tobacco wastes and reducing the nicotine content in tobacco leaves.     

Production of curdlan using sucrose or sugar cane molasses by two-step fed-batch cultivation of Agrobacterium species

Maltose and sucrose were efficient carbon sources for the production of curdlan by a strain of Agrobacterium sp. A two-step, fed-batch operation was designed in which biomass was first produced, followed by curdlan production which was stimulated by nitrogen limitation. There exists an optimal timing for nitrogen limitation for curdlan production in the two-step, fed-batch operation. Maximum curdlan production (60 g L⁻¹) was obtained from sucrose with a productivity of 0.2 g L⁻¹ h⁻¹ when nitrogen was limited at a cell concentration of 16.0 g L⁻¹. It was also noted that the curdlan yield from sucrose was as high as 0.45 g curdlan g⁻¹ sucrose, and the highest specific production rate was 1.0 g curdlan g⁻¹ cells h⁻¹ right after nitrogen limitation. Of particular importance was the use of molasses as a cheap carbon source to produce curdlan in the two-step, fed-batch cultivation. As high as 42 g L⁻¹ of curdlan with a yield of 0.35 g curdlan g⁻¹ total sugar was obtained after 120 h of fed-batch cultivation. Received 20 August 1996/ Accepted in revised form 26 November 1996     

Favoring the birth of female puppies after artificial insemination using chilled semen diluted with powdered coconut water (ACP-106c)

The objective was to determine the effect of powdered coconut water extender (ACP-106c) on the proportion of female puppies born. Twenty French Bulldog bitches were subjected to natural mating (NM) and, during the subsequent two estrus periods, were bred by intravaginal artificial insemination (AI), using chilled semen (from the same males) diluted in Tris-egg yolk (AI-Tris) or ACP-106c (AI-ACP-106c). Fresh semen was cooled to 5 °C and maintained at that temperature for 6 h, rewarmed (37 °C for 30 s), and used for AI. Pregnancy and whelping rates following NM were both 100% and were both 90.0% following AI with either extender. Litter size (mean ± SD) was 5.4 ±1.1, 4.7 ± 2.0, and 5.1 ± 2.0 (P > 0.05) for NM, AI-Tris, and AI-ACP-106c, respectively. Furthermore, for these groups, the number of female vs. male puppies born were 2.6 ± 0.6 vs. 2.8 ± 1.0, 2.2 ± 1.0 vs. 2.5 ± 1.1, and 3.4 ± 1.6 vs. 1.8 ± 1.2 (P < 0.05 for AI-ACP-106c only). In conclusion, our hypothesis was supported; AI of semen in ACP-106c extender resulted in a significantly higher proportion of female puppies. Furthermore, this extender yielded acceptable litter size and rates of pregnancy and whelping.     

Production of Bacillus thuringiensis subsp. israelensis and Bacillus sphaericus strain 1593 on media using a byproduct from a monosodium glutamate factory

Two newly developed media, H4 and H7, were found to be highly suitable for culturing Bacillus thuringiensis subsp. israelensis and B. sphaericus, respectively. These media contained 0.05% K₂HPO₄ and 4% HDL (H4 medium) or 0.05% K₂HPO₄ and 7% HDL (H7 medium); HDL is the by-product from a monosodium glutamate factory. Tests to compare endospore formation and toxicity values of B. thuringiensis subsp. israelensis in H4 medium and nutrient broth supplemented with salts and glucose (NBSG) medium were carried out in a 3-liter fermentor. The viable cell count and LC₅₀ value of B. thuringiensis subsp. israelensis in H4 medium at 48 hr were 2.5 × 10⁸ cells/ml and 10^?7.2 (dilution), respectively, while those in NBSG medium were 1.6 × 10⁸ cells/ml and 10^?6.5, respectively. In the case of B. sphaericus grown in H7 medium, the number of cells and LC₅₀ value were found to be 1.4 × 10⁹ cells/ml and 10^?7.8, respectively. B. sphaericus grown in nutrient broth supplemented with salt and yeast extract (NBSY) were found to produce 6.4 × 10⁸ cells/ml and an LC₅₀ value of 10^?6.8. The toxicity of B. thuringiensis subsp. israelensis was tested against Aedes aegypti larvae, while that of B. sphaericus was tested against Culex quinquefasciatus. The cost of 10 liters of medium for production of B. thuringiensis subsp. israelensis and in B. sphaericus and H4 and H7 was $0.02 and $0.03, respectively. The cost of these newly developed media was much less than that of NBSG medium ($7.05 per 10 liters) for cultivation of B. thuringiensis subsp. israelensis and NBSY medium ($11.67 per 10 liters) for cultivation of B. sphaericus.     

Production of hairy roots in Aconitum heterophyllum wall. using Agrobacterium rhizogenes

Summary A method for the production of hairy roots of Aconitum heterophyllum wall. is reported for the first time. Embryogenic callus cultures were successfully transformed using Agrobacterium rhizogenes strains viz. LBA 9402, LBA 9360, and A4 for the induction of hairy roots. The transgenic nature of hairy roots was confirmed by mannopine assay using paper electrophoresis. Best growth of transformed roots was obtained on 1/4 MS (Murashige and Skoog, 1962) medium with 3% sucrose. Total alkaloid (aconites) content of transformed roots was 2.96%, which was 3.75 times higher compared to 0.79% in the nontransformed (control) roots. Thin layer chromatography (TLC) analysis of the components of aconites in the transformed roots revealed the presence of heteratisine, atisine, and hetidine.     

Production of l-carnitine from d-carnitine by dried cells of Agrobacterium sp. 525a

d-Carnitine was converted into l-carnitine with dried cells of Agrobacterium sp. 525a grown on d-carnitine medium. During the conversion reaction, NAD⁺ concentration decreased. o-Phenanthroline inhibited the NAD⁺ degrading activity in dried cells, and the formation of l-carnitine increased 2.8 times. About 190 mM of l-carnitine was converted from 0.5 M of d-carnitine under the best conditions.     

假丝酵母99-125脂肪酶的发酵工艺研究

对假丝酵母99-125脂肪酶的发酵工艺条件进行了一系列研究。选择了合适的培养基成分并进行优化 ,获得了最优的摇瓶培养基配方 (% ,W/V) :豆油 4.0 ,全脂豆粉 4.0 ,K₂HPO₄0.1,KH₂PO₄ 0.1。产酶水平能达到 5000IU/mL。在 30L发酵罐上进行初步放大实验 ,其产酶水平能达到 8100IU/mL。在1m³发酵罐上进行中试放大 ,产酶水平可达到 8000IU/mL。     

纤维素降解菌青霉T24-2的分离及产酶特性

从稻田腐烂秸秆中分离到一批纤维素分解菌株。通过滤纸崩解测试、刚果红纤维素平板识别,以及产酶鉴定,筛选得到一株分解纤维素能力较强的真菌。经形态观察和18S r DNA基因片断分析,鉴定该菌株为青霉。对菌株的液态发酵条件进行研究,该菌株培养基含3%稻草粉、0.25%尿素和无机盐营养液,最佳产酶条件为:自然pH,30℃,130r/min发酵4d。该菌株的CMC酶活和滤纸酶活最高分别达到45.01I U/mL和6.89I U/mL。随后对该菌酶解稻草粉进行研究,糖化率达到40.17%。研究表明,青霉T24-2菌株在秸秆综合利用上具有良好的应用前景。     

Production and partial characterization of lipases from a newly isolated Penicillium sp. using experimental design

Aims:  The objective of this work was to investigate the lipase production by a newly isolated Penicillium sp . , using experimental design technique, in submerged fermentation using a medium based on peptone, yeast extract, NaCl and olive oil, as well as to characterize the crude enzymatic extracts obtained.
Methods and Results:  Lipase activity values of 9·5 U ml⁻¹ in 96 h of fermentation was obtained at the maximized operational conditions of peptone, yeast extract, NaCl and olive oil concentrations (g l⁻¹) of 20·0, 5·0, 5·0 and of 10·0 respectively. The partial characterization of crude enzymatic extract obtained by submerged fermentation showed optimum activity at pH range from 4·9 to 5·5 and temperature from 37°C to 42°C. The crude extract maintained its initial activity at freezing temperatures up to 100 days.
Conclusions:  A newly isolated strain of Penicillium sp . used in this work yielded good lipase activities compared to the literature.
Significance and Impact of the Study:  The growing interest in lipase production is related to the potential biotechnological applications that these enzymes present. New lipase producers are relevant to finding enzymes with different catalytic properties of commercial interest could be obtained, without using genetically modified organisms (GMO).     

Mineralization of 4-aminobenzenesulfonate (4-ABS) by Agrobacterium sp. strain PNS-1

A bacterial strain, PNS-1, isolated from activated sludge, could utilize sulphanilic acid (4-ABS) as the sole organic carbon and energy source under aerobic conditions. Determination and comparison of 16S r DNA sequences showed that the strain PNS-1 is closely related to the species of Agrobacterium genus. Growth on 4-ABS was accompanied with ammonia and sulfate release. TOC results showed complete mineralization of sulphanilic acid. This strain was highly specific for 4-ABS as none of the sulphonated aromatics used in the present study including other ABS isomers were utilized. Strain PNS-1 could, however, utilize all the tested monocyclic aromatic compounds devoid of a sulfonate group. No intermediates could be detected either in the growth phase or with dense cell suspensions. Presence of chloramphenicol completely inhibited 4-ABS degradation by cells pregrown on succinate, indicating that degradation enzymes are inducible. No plasmid could be detected in the Agrobacterium sp. Strain PNS-1 suggesting that 4-ABS degradative genes may be chromosomal encoded.     

Production of medium-chain-length PHA in octanoate-fed enrichments dominated by Sphaerotilus sp.

Medium-chain-length polyhydroxyalkanoate (mcl-PHA) production by using microbial enrichments is a promising but largely unexplored approach to obtain elastomeric biomaterials from secondary resources. In this study, several enrichment strategies were tested to select a community with a high mcl-PHA storage capacity when feeding octanoate. On the basis of analysis of the metabolic pathways, the hypothesis was formulated that mcl-PHA production is more favorable under oxygen-limited conditions than short-chain-length PHA (scl-PHA). This hypothesis was confirmed by bioreactor experiments showing that oxygen limitation during the PHA accumulation experiments resulted in a higher fraction of mcl-PHA over scl-PHA (i.e., a PHA content of 76 wt% with an mcl fraction of 0.79 with oxygen limitation, compared to a PHA content of 72 wt% with an mcl-fraction of 0.62 without oxygen limitation). Physicochemical analysis revealed that the extracted PHA could be separated efficiently into a hydroxybutyrate-rich fraction with a higher M_w and a hydroxyhexanoate/hydroxyoctanoate-rich fraction with a lower M_w. The ratio between the two fractions could be adjusted by changing the environmental conditions, such as oxygen availability and pH. Almost all enrichments were dominated by Sphaerotilus sp. This is the first scientific report that links this genus to mcl-PHA production, demonstrating that microbial enrichments can be a powerful tool to explore mcl-PHA biodiversity and to discover novel industrially relevant strains.     

Produced by a Strain of Unidentified Actinomycetes sp.

The possibility of using two kinds of sorghum as raw materials in consolidated bioprocessing bioethanol production using Flammulina velutipes was investigated. Enzymatic saccharification of sweet sorghum was not as high as in brown mid-rib (bmr) mutated sorghum, but the amount of ethanol production was higher. Ethanol production from bmr mutated sorghum significantly increased when saccharification enzymes were added to the culture.     

Identification of metabolites from degradation of naphthalene by a Mycobacterium sp.

A Mycobacterium sp. isolated from oil-contaminated sediments was previously shown to mineralize 55% of the added naphthalene to carbon dioxide after 7 days of incubation. In this paper, we report the initial steps of the degradation of naphthalene by a Mycobacterium sp. as determined by isolation of metabolites and incorporation of oxygen from ¹⁸O₂ into the metabolites. The results indicate that naphthalene is initially converted to cis- and trans-1,2-dihydroxy-1,2-dihydronaphthalene by dioxygenase and monooxygenase catalyzed reactions, respectively. The ratio of the cis to trans-naphthalene dihydrodiol isomers was approximately 25:1. Thin layer and high pressure liquid chromatographic and mass spectrometric techniques indicated that besides the cis- and trans-1,2-dihydroxy-1,2-dihydronaphthalene, minor amounts of ring cleavage products salicylate and catechol were also formed. Thus the formation of both cis and trans-naphthalene dihydrodiols by the Mycobacterium sp. is unique. The down-stream reactions to ring cleavage products proceed through analogous dioxygenase reactions previously reported for the bacterial degradation of naphthalene.     

链霉菌发酵麦草产木聚糖酶的试验研究

通过正交设计试验 ,找出利用链霉菌和麦草基质发酵生产木聚糖酶的试验条件。培养基 (g/L) :麦草粉 ,4 5 ;(NH4 ) 2 SO4 ,7.5 ;酵母膏 ,8;K2 HPO4 ·3H2 O ,1;MgSO4 ·7H2 O ,0 .5 ;NaCl,0 .3。接种量为 5 .0× 10 8个孢子 / 5 0mL培养基 ,振荡培养 (12 0r/min) 5d     

Regeneration of NADPH by Frozen-thawed Cells of a Blue-green Alga,Synechococcus sp.

The photoreduction of NADP ⁺ and its associated reactions were studied in a blue-green algal preparation that was frozen in liquid nitrogen and thawed at room temperature. The preparation was capable of photoreducing exogeneous NADP⁺. Water was the ultimate electron donor for the reduction. The optimum pH was 7.5 ~ 8.0, and optimum temperature, around 50°C. Light saturation for NADP⁺ photoreduction was reached at 50 μEinstein/m²/sec. Factors limiting the stability of the preparation were examined and a possible application of this cofactor regeneration system is discussed.