Biodegradation of different molecular-mass polyphenols derived from olive mill wastewaters by Geotrichum candidum

The decolourisation of fresh and stored olive mill wastewaters (OMW) and the biodegradation of three groups (F1, F2 and F3) of phenolic compounds by Geotrichum candidum were investigated. Separated phenolic compounds derived from natural OMW ultrafiltration using membranes with a cutoff 2and 100 kDa. G. candidum growth on fresh OMW decreased pH and reduced COD and colour of 75% and 65%, respectively. However, on the stored-black OMW a failure of COD and colour removal were observed. G. candidum activity on this later substrate was enhanced by the addition of a carbon source easily metabolised, misleading an improvement of the COD reduction and decolourization that reached 58% and 48%, respectively. Growth of G. candidum in the presence of F2 or F3 polyphenolic fractions induced high decolourisation and depolymerisation of phenolic compounds. Whereas, very week decolourisation and biodegradation were observed with F1 fraction. Moreover, the highest levels of lignin peroxidase (LiP) and manganese peroxidase (MnP) activities were obtained in the presence of F2 fraction. These results showed that increasing of molecular-mass of aromatics led to an increase in levels of depolymerisation, decolourisation and COD removal by G. candidum culture.     

Olive mill wastewater treatment in single-chamber air-cathode microbial fuel cells

Olive mill wastewaters create significant environmental issues in olive-processing countries. One of the most hazardous groups of pollutants in these wastewaters is phenolic compounds. Here, olive mill wastewater was used as substrate and treated in single-chamber air-cathode microbial fuel cells. Olive mill wastewater yielded a maximum voltage of 381 mV on an external resistance of 1 kΩ. Notable decreases in the contents of 3,4-dihydroxybenzoic acid, tyrosol, gallic acid and p-coumaric acid were detected. Chemical oxygen demand removal rates were 65 % while removal of total phenolics by the process was lower (49 %). Microbial community analysis during the olive mill wastewater treating MFC has shown that both exoelectrogenic and phenol-degrading microorganisms have been enriched during the operation. Brevundimonas-, Sphingomonas- and Novosphingobium-related phylotypes were enriched on the anode biofilm, while Alphaproteobacteria and Bacteriodetes dominated the cathode biofilm. As one of the novel studies, it has been demonstrated that recalcitrant olive mill wastewaters could be treated and utilized for power generation in microbial fuel cells.     

Use of Geotrichum candidum for olive mill wastewater treatment in submerged and static culture

The production of lignin peroxidase (LiP), manganese peroxidase (MnP) and lipases by Geotrichum candidum were performed in order to control the decolourisation and biodegradation of olive mill wastewater (OMW). Optimisation of different factors showed that dilution, carbon and ammonium concentrations significantly affected decolourisation and activities of ligniolytic peroxidases (LiP and MnP) on OMW. Moreover, addition of olive oil and agitation improved the lipase production. Batch and continuous OMW treatments in settler or bubble column bioreactors showed high COD and colour removal efficiencies of 60% and 50%, respectively. Lipolytic activity was greater in the batch bubble column whereas, LiP and MnP productions were improved in the settler. The performance of the continuous processes decreased with the decrease of hydraulic retention time (HRT). It has been shown that decolourisation and biodegradation decreased with an average of 40% and 45%, respectively, by decreasing the HRT from 4 d to 1.7 d.     

Phenolic removal in olive oil mill wastewater using loofah-immobilized Phanerochaete chrysosporium

Summary Olive oil mill wastewater (OMW) has a high organic load, and this is a serious concern of the olive industry. Conventional biological wastewater treatments, despite their simplicity and suitable performance are ineffective for OMW treatment since phenolics possess antimicrobial activity. In order to carry out a proper treatment of OMW, use of a microorganism able to degrade the phenolics is thus necessary. In this study the ability of Phanerochaete chrysosporium to degrade the phenolic compounds of OMW and to decrease the chemical oxygen demand (COD) using cells immobilized on loofah was examined. The basal mineral salt solution along with glucose, ammonium sulfate and yeast extract was used to dilute the OMW appropriately. The fungus did not grow on the concentrated OMW. The extent of removal in this bio-treatment, of total phenols (TP) and the COD were 90 and 50%, respectively, while the color and aromaticity decreased by 60 and 95%, respectively. The kinetic behavior of the loofah-immobilized fungus was found to follow the Monod equation. The maximum growth rate μ_max was 0.045 h⁻¹ while the Monod constant based on the consumed TP and COD were (mg/l) 370 and 6900, respectively.     

Biodegradation of polyphenols with immobilized Candida tropicalis under metabolic induction

During olive oil production, large quantities of olive mill wastewater (OMW) are produced. This wastewater material, containing a high level of phenolic compounds, poses a serious environmental problem in almost all Mediterranean countries. Candida tropicalis YMEC14 was used as an extremophile strain to design an aerobic biotreatment process to detoxify OMW and reduce its polluting organic load. The process was enhanced by directing yeast metabolism towards biodegradation pathways using hexadecane as co-metabolite and by immobilizing yeast cells in calcium alginate beads. Under immobilization conditions, C. tropicalis YMEC14 grown at 40 degrees C in OMW supplemented with hexadecane resulted in 69.7%, 69.2% and 55.3% reduction of chemical oxygen demand, monophenols and polyphenols, respectively, after a 24-h fermentation cycle.     

Olive mill wastes: Biochemical characterizations and valorization strategies

The olive mill waste generated from olive oil extraction is a major environmental issue, particularly in Mediterranean areas. The extraction of olive oil is achieved through discontinuous or continuous processes. The two processes yield three fractions: a solid residue and two liquid phases (oil and olive mill wastewater). The characterization of these two by-products showed that they are mainly composed of phenolic compounds, carbohydrates, organic acids and mineral nutrients variably distributed depending on the process employed and the agronomic practices. Untreated olive by-products discharged between November and March into the environment are a major ecological issue for olive oil-producing countries due to their high toxic organic loads, low pH, and high chemical and biological demands. In this context, recent research studies highlight on the treatment approaches and valorization options for dealing with olive mill waste residues, predominantly those allowing for the recovery of valuable natural components such as phenolic compounds, dietary fibers, animal feed, biofuel, biogaz, enzymes, polymers and other. The impact of the chemical heterogeneity and water content of olive mill by-products about these processes of valorization and bioconversion is discussed.     

Biological treatment of olive mill wastewater by non-conventional yeasts

The ability of lipolytic yeasts to grow on olive mill wastewater (OMW)-based medium and to produce high-value compounds while degrading this waste, was tested. OMW collected from three-phase olive mills from the North region of Portugal were characterized and used. OMW with COD ranging from 100 g L⁻¹ to 200 g L⁻¹ were supplemented with yeast extract and ammonium chloride. Studies of OMW consumption were carried out in batch cultures of Candida rugosa, Candida cylindracea and Yarrowia lipolytica. All strains were able to grow in the OMW-based media, without dilution, to consume reducing sugars and to reduce COD. C. cylindracea was the best strain concerning the lipase production and the reduction of phenolic compounds and COD. For all strains, the phenols degradation was quite difficult, mostly when more easily degradable carbon source is still present in the medium. Among the phenolic compounds tested catechol is the most inhibitory to the cells.     

Phenolic removal in olive oil mill wastewater by strains of Pleurotus spp. in respect to their phenol oxidase (laccase) activity

The ability of several Pleurotus spp. strains to remove phenolic compounds from an olive oil mill wastewater (OMW) was studied. All strains tested in this work were able to grow in OMW without any addition of nutrients and any pre-treatment, except sterilization. High laccase activity was measured in the growth medium, while 69-76% of the initial phenolic compounds were removed. The black color of OMW became yellow-brown and brighter as the strains grew. The lowest phenolic concentrations were reached after 12/15 days. A decrease of the phytotoxicity, as described by the parameter Germination Index, was noticed in the OMW treated with some Pleurotus spp strains, although this decrease was not proportional to the phenolic removal. A new parameter, namely Phenol-toxicity Index, was considered in the present paper. Using this parameter it was found that the remaining phenolics and/or some of the oxidation products of the laccase reaction in the treated OMW were more toxic than the original phenolic compounds.     

Decolourisation and dephenolisation potential of selected <Emphasis Type="Italic">Aspergillus</Emphasis> section <Emphasis Type="Italic">Nigri</Emphasis> strains – <Emphasis Type="Italic">Aspergillus tubingensis</Emphasis> in olive mill wastewater

Aspergillus section Nigri strains Aspergillus aculeatus Ege-K 258, A. foeditus var. pallidus Ege-K156, A. niger Ege-K 4 and A. tubingensis Ege-K 265 were used to treat olive mill wastewater (OMW) in an investigation aimed at exploring their dephenolisation and decolourisation ability and, consequently, the economic feasibility of using any or all of these strains in a pre-treatment step in the processing of OMW. Of these strains A. tubingensis Ege-K 265 resulted in an 80% decolourisation of twofold-diluted OMW and a 30% decolourisation of undiluted OMW; in addition, it was able to remove approximately 30% of all phenolic compounds in both twofold-diluted and undiluted OMW. We conclude that A. tubingensis Ege-K 265 could be effectively used in the pre-treatment step of a combined aerobic-anaerobic process to solve the environmental problems caused by OMW in Mediterranean countries.     

Improvement of fermentative decolorization of olive mill wastewater by Lactobacillus paracasei by cheese whey's addition

The effect of the cheese whey's (CW) addition on the fermentative decolorization of olive mill wastewater (OMW) by Lactobacillus paracasei, with and without pH adjustment by lime, was investigated. Mixtures OMW/CW at different proportions were fermented. The highest colour removal (47%) and total phenolic reduction (22.7%) of OMW were obtained after cofermentation of OMW/CW at proportions of 10/90, respectively. The decrease of pH after cofermentation of the two wastewaters, induced the precipitation of whey proteins with phenolic compounds and, so, improves decolorization. These removal yields reached 64% and 34%, respectively after precipitation by adjustment of pH at 7 with lime at the end of cofermentation. These improvements were correlated to a clarification of wastewaters by precipitation of whey proteins with phenolic compounds. An enhanced decolorization (up to 93%) and a total phenolic reduction (50%) of the mixture were obtained when cofermentation sequentially pH corrected by lime addition was investigated.     

Influence of salts and phenolic compounds on olive mill wastewater detoxification using superabsorbent polymers

For a selection of nine commercially available superabsorbent polymers, the absorption capacity was evaluated for the principal absorption-inhibition constituent of OMW, mineral salts and for phytotoxic-components, the phenolic compounds. A double exponential model was established for electrical conductivities ranging 4.2-25,000 microS cm(-1). For solutions of phenolic compounds ranging 0-0.5 g l(-1), a distribution coefficient near unit was achieved, while for OMW, the phenolic compounds were concentrated inside the gel as the distribution coefficient was 1.4. Correction of OMW pH towards neutrality was found to increase the absorption capacity by up to 35%. The phytotoxicity was assessed by the germination of Lepidium sativum. Inhibition in plant growth occurred for all OMW dilutions without superabsorbent polymers application. For 5% of OMW (COD 5 gl(-1) and 200 ppm of phenolic compounds) immobilised in PNa2 (1 gl(-1)), plant growth was promoted being observed a 120% growth germination, thus indicating that olive mill wastewater detoxification occurred.     

Involvement of lignin peroxidase in the decolourization of black olive mill wastewaters by Geotrichum candidum

AIM: Decolourization of black olive mill wastewaters (OMW) by depolymerization of phenolic compounds by Geotrichum candidum. METHODS AND RESULTS: Our results show that G. candidum is able to grow on black OMW supplemented with carbon source and nitrogen. The Geotrichum growth decreased the pH and induced a 49% of colour removal when the black OMW was supplemented with glycerol and diammonium tartrate (20 mm ammonium). An improvement of 10% of colour removal was observed when the culture was supplemented with veratryl alcohol. The decolourization was inhibited with glutamate as nitrogen source. CONCLUSION: Our results suggest the potential use of G. candidum in black OMW decolourization and support the concept that lignin peroxidase (LiP) of G. candidum is involved in the depolymerization of phenolic compounds. Significance and Impact of the Study: This is the first report of LiP production by G. candidum on OMW.     

Screening of fungal isolates and properties of Ganoderma applanatum intended for olive mill wastewater decolourization and dephenolization

AIMS: To investigate different autochthonous isolates of wood-rotting fungi for the removal of both colour and phenolic compounds from olive mill wastewaters (OMW). METHODS AND RESULTS: The isolates Bjerkandera adusta Ba-100, Fomes fomentarius Ff-106, Ganoderma applanatum Ga-20, Irpex lacteus Il-3, Trametes versicolor Tv-101 and Tv-103 were preliminarily screened for their OMW-decolourizing potential on potato dextrose agar supplemented with different OMW concentrations. A further screening of batch cultures under different agitation speeds, to test the effect of shear stress, resulted in the selection of isolate G. applanatum Ga-20. Batch cultures grown in OMW-based medium exhibited strong laccase induction and significant decrease in the values of phenols, colour and chemical oxygen demand. Concomitant onset of laccase activity and colour removal was observed, and apart from laccase, neither lignin peroxidase nor manganese-dependent peroxidase activities were detected. Moreover, the depletion of aromatic compounds with high and low apparent molecular mass was observed by chromatographic analysis. CONCLUSIONS: Isolate G. applanatum Ga-20 exhibited interesting properties for its use in bioremediation of OMW, namely high removal of recalcitrant phenolic compounds and strong colour abatement. SIGNIFICANCE AND IMPACT OF THE STUDY: For the first time, the white-rot fungus G. applanatum proves to be effective for the decolourization and dephenolization of OMW.     

Degradation of waste waters from olive oil mills by Yarrowia lipolytica ATCC 20255 and Pseudomonas putida

Waste waters from olive oil processing may cause severe pollution in the Mediterranean area, since they have a high level of chemical oxygen demand (COD) (100–200 g/l) and contain other organic and inorganic compounds. In all olive oil producing countries, the reduction of pollution in olive oil mill waste waters at reasonable costs and using techniques suitable for most industrial applications is an unsolved problem. For this paper, the yeast Yarrowia lipolytica ATCC 20255 was grown on waste waters from an olive oil mill in a 3.5 1 fermenter under batch culture conditions. The results showed that the yeast was capable of reducing the COD value by 80% in 24 h. In this way, a useful biomass of 22.45 g/l as single cell protein (SCP) and enzyme lipase were produced. During this process, most of the organic and inorganic substances were consumed, only aromatic pollutants were still present in the fermentation effluents. Therefore, we used a phenol degrader, namely Pseudomonas putida, to reduce phenolic compounds in the fermentation effuents after removing Yarrowia lipolytica cells. P. putida was effective in reducing phenols in only 12 h.     

The effect of pretreatment on anaerobic activity of olive mill wastewater using batch and continuous systems

This study was focused on several physico-chemical and biological treatment methods that may affect the reduction of the organic load in olive mill wastewater (OMW). In this study, removal of 95% of the phenolic compounds present in OMW was achieved using sand filtration and subsequent treatment with powdered activated carbon in a batch system. This pretreatment for OMW was found to enhance the anaerobic activity of the sludge in the batch system significantly. The efficiency of organic load removal achieved by the anaerobic treatment of untreated OMW in batch reactors with tap water dilution factors below 1:10, reached approximately 65% chemical oxygen demand (COD) removal. However, in the up-flow sludge anaerobic blanket (UASB) reactor, COD removal efficiency of 80–85% was reached at a hydraulic retention time (HRT) of 5 days with an influent COD concentration of 40 g l⁻¹ and organic loading rate (OLR)=8 g⁻¹ COD l⁻¹ per day.     

Decolourisation of mushroom farm wastewater by <Emphasis Type="Italic">Pleurotus ostreatus</Emphasis>

Mushroom production on coffee pulp as substrate generates an intense black residual liquid, which requires suitable treatment. In the present study, Pleurotus ostreatus growth in wastewater from mushroom farm was evaluated as a potential biological treatment process for decolourisation as well as to obtain biomass (liquid inoculum). Culture medium components affecting mycelial growth were determined, evaluating colour removal. Laccase activity was monitored during the process. P. ostreatus was able to grow in non diluted WCP. Highest biomass yield was obtained when glucose (10 g/l) was added. The addition of this carbon source was necessary for efficient decolourisation. Agitation of the culture improved biodegradation of WCP as well as fungal biomass production. Laccase and manganese-independent peroxidase activities were detected during fungal treatment of the WCP by P. ostreatus CCEBI 3024. The laccase enzyme showed good correlation with colour loss. Both wastewater colour and pollution load (as chemical oxygen demand) decreased more than 50% after 10 days of culture. Phenols were reduced by 92%.     

Use of <Emphasis Type="Italic">Pichia fermentans</Emphasis> and <Emphasis Type="Italic">Candida</Emphasis> sp. strains for the biological treatment of stored olive mill wastewater

Of 105 isolates screened for growth on plates containing olive mill wastewater (OMW), five were selected and identified as Pichia fermentans (Y1, Y4) and Candida sp. (Y2, Y11, and Y18). On the basis of their ability to use phenol at 716 mg l⁻¹, strains Y2 (15% reduction) and Y4 (18% reduction) were then used to detoxify stored OMW under various operational conditions. Yeast treatment of OMW increased the pH and, in the best conditions (aeration and no glucose addition), the COD decreased (47%) and phytotoxicity was also decreased (56%) probably due to the changes in the composition of phenolic compounds.     

Detoxification of olive mill wastewaters by Moroccan yeast isolates

A total of 105 yeast strains were isolated from Moroccan olive oil production plants and evaluated for their ability to grow in olive oil mill wastewaters (OMW). The 9 isolates that grew best on OMW were selected for further study to evaluate their effect on removal of organic pollutants and OMW phytotoxicity (barley seed germination test). The results showed that at least four yeast isolates effectively lowered the toxicity of this effluent in addition to providing very useful materials in terms of both yeast biomass (6 g/l DW) and an irrigation fluid. This group of yeast isolates significantly reduced the concentration of total phenols (44% removal) and Chemical Oxygen Demand, COD (63% removal). The best germination rate of 80% for undiluted OMW was obtained for strain Candida holstii that also increased the pH from 4.76 to 6.75. Principal component analysis of the results obtained for the best yeast strains confirmed the importance of COD and total phenol reduction along with increase of organic nitrogen and final pH for the improvement of germination rates and phytotoxic reduction. This study has highlighted the potential of indigenous yeasts in detoxification of olive mill wastewaters.     

Selection of Diazotrophic Bacterial Communities in Biological Sand Filter Mesocosms Used for the Treatment of Phenolic-Laden Wastewater

Agri effluents such as winery or olive mill wastewaters are characterized by high phenolic concentrations. These compounds are highly toxic and generally refractory to biodegradation. Biological sand filters (BSFs) represent inexpensive, environmentally friendly, and sustainable wastewater treatment systems which rely vastly on microbial catabolic processes. Using denaturing gradient gel electrophoresis and terminal-restriction fragment length polymorphism, this study aimed to assess the impact of increasing concentrations of synthetic phenolic-rich wastewater, ranging from 96 mg L^?1 gallic acid and 138 mg L^?1 vanillin (i.e., a total chemical oxygen demand (COD) of 234 mg L^?1) to 2,400 mg L^?1 gallic acid and 3,442 mg L^?1 vanillin (5,842 mg COD L^?1), on bacterial communities and the specific functional diazotrophic community from BSF mesocosms. This amendment procedure instigated efficient BSF phenolic removal, significant modifications of the bacterial communities, and notably led to the selection of a phenolic-resistant and less diverse diazotrophic community. This suggests that bioavailable N is crucial in the functioning of biological treatment processes involving microbial communities, and thus that functional alterations in the bacterial communities in BSFs ensure provision of sufficient bioavailable nitrogen for the degradation of wastewater with a high C/N ratio.     

Yeast strains from the endogenous microflora of the olive fliesBactrocera oleae larvae which could degrade the olive oil mill wastewaters polyphenols

Worldwide, wastewaters constitute a major environmental pollutant. They are very toxic against a wide range of plants and soil microorganisms. Their toxicity is due to the presence of compounds such as polyphenols. In this study, we have isolated yeast strains from the endogenous microflora of the olive fliesBactrocera oleae larvae that were capable of degrading the olive oil mill wastewater polyphenols. The results obtained showed the presence, in the digestive tract of the larvae, of yeast strains resisting to polyphenols. Two resistant strains were isolated and have shown variable capacity of polyphenols degradation that could reach up to 72%. The two isolated strains were identified by two methods: conventional technique and molecular method associating PCR amplification and DNA sequencing of the 5.8S ribosomal RNA gene. Both techniques showed that the two isolated strains corresponded to theCandida diddensiae specie. Related to its capacity to degrade polyphenols, this specie would be a potential candidate for wastewater treatment and environmental protection.