Keratinolytic activity of Bacillus megaterium F7-1, a feather-degrading mesophilic bacterium

The aim of this study was to investigate environmental conditions affecting chicken feather degradation and keratinolytic enzyme production by Bacillus megaterium F7-1, a feather-degrading mesophilic bacterium. B. megaterium F7-1 degraded whole chicken feather completely within 7 days. The bacterium grew with an optimum at pH 7.0–11.0 and 25–40 °C, where maximum keratinolytic activity was also observed. The production of keratinolytic enzyme by B. megaterium F7-1 was inducible with feather. Keratinolytic enzyme production by B. megaterium F7-1 at 0.6% (w/v) skim milk was 468 U/ml, which was about 9.4-fold higher than that without skim milk. The amount of keratinolytic enzyme production depended on feather concentrations. The degradation rate of autoclaved chicken feathers by cell-free culture supernatant was 26% after 24 h of incubation, but the degradation of untreated chicken feathers was unsuccessful. B. megaterium F7-1 effectively degraded feather meal, duck feather and human nail, whereas human hair and sheep wool showed relatively low degradation rates. B. megaterium F7-1 presented high keratinolytic activity and was very effective in feather degradation, providing potential use for biotechnological processes of keratin hydrolysis.     

Production of Penicillin G acylase from Bacillus sp.: Effect of medium components

A Bacillus sp. producing a high level of intracellular penicillin G acylase (PAC) was isolated. The PAC production in this strain was induced by phenylacetic acid. Various carbon and nitrogen sources were evaluated for their effect on growth and PAC production at 28 °C and pH 7.0. Cells grown in medium supplemented with sucrose as carbon source and tryptone as nitrogen source produced maximum activity of 6.45 and 8.92 U mg^–1, respectively. Maximum concentration of PAC (10.1 Umg^–1) was produced by the cells grown in the medium containing sucrose and tryptone, which was twofold higher than the production in basal medium.     

Regulation of the formation of protease inBacillus megaterium

During the growth of the asporogenous variant ofBacillus megaterium KM in medium containing NO₃ ⁻ as nitrogen source, the relative rate of extracellular protease synthesis is higher than in the presence of NH₄ ⁺. It approaches the relative rate of enzyme synthesis at the incubation of cells in nitrogen-free medium with glucose. This supports the suggestion that even amino acids which are synthesized endogenously slow down the protease production. In the postlogarithmic or stationary phase the protease production stops. The interruption of enzyme production does not appear as a result of insufficient aeration in a dense suspension, or of accumulation of amino acids or their metabolites in cells. The non-growing cells retain their ability to renew the enzyme synthesis when transferred into a fresh medium, even into a medium without nitrogen source. In the same way it is possible to “induce” the protease production, if Ca²⁺ is added to cells in the stationary phase when the population was grown in the Ca²⁺ free medium. The amount of enzyme produced at the expense of protein turnover by the non-growing populations is sufficient for the fast hydrolysis of exogenous protein in the medium and for assuring the influx of a sufficient amount of peptides into the cells. In such a case the growth of the culture is therefore very quickly renewed.     

Anaerobic degradation of phenylacetic acid by mixed and pure cultures

Summary A phenylacetic acid-degrading mixed culture was enriched from effluent of an anaerobic reactor for the treatment of waste water from cellulose bleaching. From this consortium a phenylacetic acid-degrading pure culture, strain DSU3, was isolated and, due to its typical morphology and substrate spectrum, tentatively classified as a Desulfosarcina sp. It could grow on and degrade phenylacetic acid, cyclohexane carboxylate, cyclohexylacetate, benzoate, fumaric acid and several volatile fatty acids, while phenol, o-hydroxybenzoate, p-hydroxybenzoate and glucose were not utilized. Production of mandelic acid from phenylacetic acid by the enrichment culture and utilization of benzoate, an intermediate of the mandelic acid pathway, by strain DSU3 may presumably indicate degradation of phenylacetic acid via the mandelic acid pathway.     

CHANGES IN DOMOIC ACID PRODUCTION AND CELLULAR CHEMICAL COMPOSITION OF THE TOXIGENIC DIATOM PSEUDO-NITZSCHIA MULTISERIES UNDER PHOSPHATE LIMITATION1

Production of domoic acid (DA), a neurotoxin, by the diatom Pseudo-nitzschia multiseries (previously Nitzschia pungens f. multiseries) Hasle and its cellular chemical composition were studied in phosphate-limited chemostat continuous cultures and in subsequent batch cultures. Under steady-state chemostat conditions, DA production increased from 0.01 to 0.26 pg DA · cell^?1· d^?1 as the growth rate decreased. When the nutrient supply was discontinued (to produce a batch culture), DA production was enhanced by a factor of ca. 3. DA production was temporarily suspended upon addition of phosphate to the batch cultures but resumed 1 d later at a higher rate coincident with the decline of phosphate uptake. In both steady-state continuous culture and batch culture, more DA was produced when alkaline phosphatase activity (APA) was high. The association of high DA production with high levels of APA and high cellular N:P ratios strongly suggests that phosphate limitation enhances DA production. Also, DA production was high when other primary metabolism (e.g. uptake of carbon, nitrogen, phosphorus and silicon, and cell division) was low, but chlorophyll a and adenosine triphosphate were generally high. This suggests that the synthesis of DA requires a substantial amount of biogenic energy.     

Continuous 2-Keto-l-gulonic acid fermentation by mixed culture of Ketogulonicigenium vulgare DSM 4025 and Bacillus megaterium or Xanthomonas maltophilia

The fermentation process of 2-keto-L-gulonic acid (2KGA) from L-sorbose was developed using a two-stage continuous fermentation system. The mixed culture of Ketogulonicigenium vulgare DSM 4025 and Bacillus megaterium DSM 4026 produced 90 g/L of 2KGA from 120 g/L of L-sorbose at the dilution rate of 0.01 h⁻¹ in a single-stage continuous fermentation process. But after the production period was beyond 150 h, the significant decrease of 2KGA productivity was observed. When the non-spore forming bacteria Xanthomonas maltophilia IFO 12692 was used instead of B. megaterium DSM 4026 as a partner strain for K. vulgare DSM 4025, the 2KGA productivity was significantly improved in a two-stage continuous culture mode, in which two fermentors of the same size and volume were connected in series. In this mode, with two sets of 3-L jar fermentors, the steady state could be continued to over 1,331.5 h at least, when the dilution rates were 0.0382 h⁻¹ and 0.0380 hour⁻¹, respectively, for the first and second fermentors. The overall productivity was calculated to be 2.15 g/L/h at 113.1 g/L and a molar conversion yield of 90.1%. In the up-scaling fermentation to 30-L jar fermentors, 118.5 g/L of 2KGA was produced when dilution rates in both stages were 0.0430 hour⁻¹, and the overall productivity was calculated to be 2.55 g/L/h.     

A T7 RNA polymerase-dependent gene expression system for Bacillus megaterium

Gene expression systems based on the RNA polymerase of the bacteriophage T7 are often the ultimate choice for the high level production of recombinant proteins. During the last decade, the Gram-positive bacterium Bacillus megaterium was established as a useful host for the intra- and extracellular production of heterologous proteins. In this paper, we report on the development of a T7 RNA polymerase-dependent expression system for B. megaterium. The system was evaluated for cytosolic and secretory protein production with green fluorescent protein (GFP) from Aequoria victoria as intracellular and Lactobacillus reuteri levansucrase as extracellular model protein. GFP accumulated rapidly at high levels up to 50 mg/l shake flask culture intracellularly after induction of T7 RNA polymerase gene expression. The addition of rifampicin for the inhibition of B. megaterium RNA polymerase led to an increased stability of GFP. L. reuteri levansucrase was also successfully produced and secreted (up to 20 U/l) into the culture supernatant. However, parallel intracellular accumulation of the protein indicated limitations affiliated with the Sec-dependent protein translocation process.     

The production of protease by dense suspensions ofBacillus megaterium KM Sp−

The synthesis and secretion of extracellular protease was demonstrated during the incubation of dense susponsions of the asporogenicBacillus megaterium KM. The overall production of the enzyme by cells incubated with glucose in a nitrogen-free medium was found to be only slightly lower than that in the presence of an inorganic nitrogen source. The capacity to form protease decreased exponentially with increasing density of the bacterial suspension. The synthesis of the enzyme was interrupted after the exhaustion of glucose. A repeated exchange of the medium made it possible to reach relatively high and continuous production of protease for several hours. The total amount of extracellular proteins synthesized during incubation of the dense suspension in media with or without a nitrogen source was less than 2% of a total of newly formed proteins. The amount of these extracellular proteins was slightly lower in the absence of Ca²⁺ being considerably decreased when the dense suspension was incubated with chloramphenicol.     

The kinetics and physiology of stipitatic acid and gluconate production by carbon sufficient cultures of Penicillium stipitatum growing in continuous culture

The yield from glucose of ammonia-grown carbon-limited continuous cultures of Penicillium stipitatum was ca. 20% higher than that of nitrate-grown cultures at all growth rates examined. However, the yield from oxygen was similar during growth on both nitrogen sources. Under phosphate limitation the specific rate of gluconic acid and stipitatic acid production increased with growth rate, but the former product accounted for virtually 100% of the excreted carbon. Stipitatic acid was not produced under nitrogen limitation, and glucose supplied to the culture in excess of that required for growth was virtually quantatively converted into gluconic acid. Productivities of 11.4 g gluconic acid/L/h were stably maintained in continuous culture. Under conditions of glucose excess the enzyme glucose oxidase was excreted into the culture. The specific activity of this extracellular enzyme increased when the input glucose concentration to the culture was progressively increased. The excretion of a protein under nitrogen limitation suggests that this enzyme plays an important role under these conditions. Indeed, it was demonstrated that nitrogen-limited cultures did not overmetabolize gluconate at either pH 6.5 or 3.5, although up to 29 g/L gluconate was present in the culture. The Y(gluconate) and YO(2) of C- and N-limited gluconate-grown cultures were similar indicating that the rapid conversion of glucose to gluconate probably affords a means of regulating carbon flow in this organism. Nitrogen-limited cultures of P. stipitatum overmetabolized glucose to a much greater extent than acetate, fructose, or gluconate.     

Identification and Antimicrobial Activity of Phenylacetic Acid Produced by <Emphasis Type="Italic">Bacillus licheniformis</Emphasis> Isolated from Fermented Soybean,Chungkook-Jang

A bacterial strain, B65-1, which showed strong antimicrobial activity, was isolated from Chungkook-Jang, a traditional Korean fermented-soybean food with antimicrobial properties. Based on carbon utilization pattern and partial 16S rRNA sequence analysis, the B65-1 strain was identified as Bacillus licheniformis. An antibiotic compound, active against bacteria and yeast such as Staphylococcus aureus, Escherichia coli, and Candida albicans, was isolated by various chromatographic procedures from culture filtrates of B. licheniformis B65-1. The purified antibiotic was identified to be phenylacetic acid, with the molecular formula C₈H₈O₂ by analyses of EI-MS and NMR. The phenylacetic acid was detected in fermented soybean made with the strain B65-1 as a starter, but was not present in extracts of nonfermented soybean. Our results indicated that the phenylacetic acid produced by B. licheniformis during fermentation of soybean is one of the main compounds of antimicrobial activity of Chungkook-Jang.     

Production and characterization of the agarase ofCytophaga flevensis

Cytophaga flevensis produced an inducible agarase which was extracellular under most conditions tested. The effect of cultural conditions on the production of enzyme was studied in batch and continuous culture. In batch culture, production was optimal whenCytophaga flevensis was incubated at 20C in a mineral medium with agar as the sole carbon source and ammonium nitrate as the nitrogen source at an initial pH of 6.6–7.0. The enzyme appeared to be subject to catabolite repression, since its synthesis was repressed when glucose was added to the medium in batch culture. Furthermore, in continuous culture, enzyme production decreased with increasing growth rate. Extracellular agarase was partially purified and the enzyme preparation obtained was very stable. The enzyme has a molecular weight of 26000 daltons. It is a β-agarase which is highly specific for polysaccharides containing neoagarobiose units. The final products of hydrolysis of agarose by the endo-acting enzyme were neoagarotetraose and neoagarobiose. Optimal conditions for its activity were pH 6.3 and 30C. When agarose was used as a substrate, an apparent temperature optimum of 35C was found, due to gelling of the substrate during the assay procedure.     

Enzymatic properties of lipase and characteristics production byLactobacillus delbrueckii subsp.bulgaricus

Some properties of an extracellular lipase produced byLactobacillus delbrueckii subsp.bulgaricus were studied. Maximum enzyme activity was found against olive and butter oil as enzyme substrates. Addition of 9% acacia gum, 0.1% Na-deoxycholate and 0.01 M CaCl₂ to the enzyme reaction mixture increased-lipase activity from 5.3 to 14.5 (FFA/mg protein/minute) at pH 6.0 and at 40° C. Maximum lipase production was reached in the presence of glucose as a sole source of carbon, wheat bran as nitrogen source, olive oil as a sole lipid source and butyric acid as fatty acid supporting the growth medium. An initial pH value of the culture medium of 6.0 and a temperature of 35° C gave the highest lipolytic activity.     

The consequence of stimulating glucose dehydrogenase activity by the addition of PQQ on metabolite production by Agrobacterium radiobacter NCIB 11883

Summary Agrobacterium radiobacter NCIB 11 883 does not produce gluconate under conditions of glucose excess in batch or continuous culture. However, the addition of micromolar concentrations of pyrrolo quinoline quinone (PQQ) to fermentation media resulted in rapid excretion of gluconate by batch and continuous cultures. This rapid dehydrogenation of glucose was found in cells grown under carbon and nitrogen limitation and is constitutive which suggests that the only reason why this activity is not normally expressed is due to the inability of the organism to synthesize the prosthetic group (PQQ) of the glucose dehydrogenase enzyme.Although the addition of PQQ to batch and continuous cultures caused a very rapid specific rate of gluconate production (0.6–1.1 g gluconate g^-1 dry wt. h^-1) the rate of exopolysaccharide production remained unaltered. Indeed, when the rates of substrate and oxygen uptake are corrected for the rate of gluconate production in the presence of PQQ there appears to be little physiological consequence as a result of this oxidation.     

Some factors affecting production of pectic enzymes by Aspergillus niger

The effects of varying cultural conditions were assessed for the production of pectic enzymes in a strain of Aspergillus niger, isolated from decaying orange fruit. Polygalacturonase and pectinmethylesterase were found to be inducible by polygalacturonic acid and pectin in the medium, respectively. Ammonium sulphate was the best nitrogen source for the production of both enzymes. There were variations in enzyme levels produced in culture filtrates with age of the culture, the highest levels being in 4-day-old cultures. The temperature and pH also had marked effects on the production of pectic enzymes with the best conditions being 40°C and pH 5, respectively. Surface culture technique gave appreciable enzyme yield, while agitation had an inhibitory effect on enzyme production.     

High yield production of extracellular recombinant levansucrase by Bacillus megaterium

In this study, a high yield production bioprocess with recombinant Bacillus megaterium for the production of the extracellular enzyme levansucrase (SacB) was developed. For basic optimization of culture parameters and nutrients, a recombinant B. megaterium reporter strain that produced green fluorescent protein under control of a vector-based xylose-inducible promoter was used. It enabled efficient microtiter plate-based screening via fluorescence analysis. A pH value of pH?6, 20 % of dissolved oxygen, 37 °C, and elevated levels of biotin (100 μg?L^?1) were found optimal with regard to high protein yield and reduced overflow metabolism. Among the different compounds tested, fructose and glycerol were identified as the preferred source of carbon. Subsequently, the settings were transferred to a B. megaterium strain recombinantly producing levansucrase SacB based on the plasmid-located xylose-inducible expression system. In shake flask culture under the optimized conditions, the novel strain already secreted the target enzyme in high amounts (14 U?mL^?1 on fructose and 17.2 U?mL^?1 on glycerol). This was further increased in high cell density fed-batch processes up to 55 U?mL^?1, reflecting a levansucrase concentration of 0.52 g?L^?1. This is 100-fold more than previous efforts for this enzyme in B. megaterium and more than 10-fold higher than reported values of other extracellular protein produced in this microorganism so far. The recombinant strain could also handle raw glycerol from biodiesel industry which provided the same amount and quality of the recombinant protein and suggests future implementation into existing biorefinery concepts.     

Production of citric acid in continuous culture

Work has been carried out on the production of citric acid by Aspergillus foetidus in single-stage continuous culture, operated under nitrogen-limiting conditions at dilution rates between 0.04 to 0.21 hr^?1. Citric acid concentration increased rapidly as the dilution rate decreased and appears to be critically dependent on the pH in the culture vessel and the nitrogen concentration in the feed. A mathematical model based on a distinction between basic cells, which require nitrogen but do not produce citric acid, and stroage cells, which accumulate carbon and simultaneously produce citric acid, is proposed.     

Studies on Metabolism of Pyrrolidone Carboxylic Acid in Bacteria

The present investigation is concerned with l-glutamic acid production in the presence of pyrrolidone carboxylic acid and glucose in Bacillus megaterium st. 6126. This strain does not grow on dl-pyrrolidone carboxylic acid (dl-PCA)¹⁾ as the sole source of carbon and nitrogen. The optimal concentration of yeast extract required for the maximal production of l-glutamic acid was 0.005% under the conditions used. As the yeast extract concentration was increased, growth increased proportionally; but the l-glutamic acid production did not exceed the control’s to which glucose and ammonium chloride had been added. l-Glutamic acid produced by both growing cultures and resting cells was derived from glucose and ammonium salt of dl-PCA. Isotope experiments suggested that the l-glutamic acid produced was partially derived from ammonium salt of dl-PCA in the growing culture which had been supplemented with d-glucose-U-¹⁴C or dl-PCA-1-¹⁴C and that ammonium salt of dl-PCA was consumed as the source of nitrogen and carbon for l-glutamic acid.     

Cloning and expression of penicillin acylase genes from overproducing strains of Escherichia coli and Bacillus megaterium

Summary Penicillin acylase genes from Escherichia coli 194, of an overproducing mutant (194-3) of this strain, and of a similar overproducing mutant of Bacillus megaterium UN1 were cloned in E. coli DH1 on the plasmid vector pACYC184. The sizes of chromosomal DNA fragments essential for penicillin acylase production were found by Tn1000 mutagenesis and in vitro deletions to be between 2.2 and 2.5 kb in the case of both E. coli genes and between 2.3 and 2.7 kb in the case of the mutant Bacillus gene. Restriction mapping indicated substantial sequence differences between the E. coli and B. megaterium penicillin acylase genes. Enzyme production in E. coli recombinants from both overproducing mutants was found to be constitutive and higher than in the original strains. The Bacillus penicillin acylase was produced intracellularly in E. coli recombinants, which is in contrast to the normal extracellular production of this enzyme in B. megaterium. Recombinant plasmids containing penicillin acylase genes from either source were found to be unstable in the absence of selection pressure for retention of the vector.     

Stimulation of Plant Growth and Drought Tolerance by Native Microorganisms (AM Fungi and Bacteria) from Dry Environments: Mechanisms Related to Bacterial Effectiveness

In this study we tested whether rhizosphere microorganisms can increase drought tolerance to plants growing under water-limitation conditions. Three indigenous bacterial strains isolated from droughted soil and identified as Pseudomonas putida, Pseudomonas sp., and Bacillus megaterium were able to stimulate plant growth under dry conditions. When the bacteria were grown in axenic culture at increasing osmotic stress caused by polyethylene glycol (PEG) levels (from 0 to 60%) they showed osmotic tolerance and only Pseudomonas sp. decreased indol acetic acid (IAA) production concomitantly with an increase of osmotic stress (PEG) in the medium. P. putida and B. megaterium exhibited the highest osmotic tolerance and both strains also showed increased proline content, involved in osmotic cellular adaptation, as much as increased osmotic stress caused by NaCl supply. These bacteria seem to have developed mechanisms to cope with drought stress. The increase in IAA production by P. putida and B. megaterium at a PEG concentration of 60% is an indication of bacterial resistance to drought. Their inoculation increased shoot and root biomass and water content under drought conditions. Bacterial IAA production under stressed conditions may explain their effectiveness in promoting plant growth and shoot water content increasing plant drought tolerance. B. megaterium was the most efficient bacteria under drought (in successive harvests) either applied alone or associated with the autochthonous arbuscular mycorrhizal fungi Glomus coronatum, Glomus constrictum or Glomus claroideum. B. megaterium colonized the rhizosphere and endorhizosphere zone. We can say, therefore, that microbial activities of adapted strains represent a positive effect on plant development under drought conditions.