Excessive excretion of cyclic beta-(1,2)-glucan by Rhizobium trifolii TA-1

At 25 degrees C, the optimal temperature for growth of Rhizobium trifolii TA-1, extracellular and capsular polysaccharide (EPS and CPS) were the main carbohydrate products synthesized in mannitol-rich medium (10 g of mannitol and 1 g of glutamic acid per liter). In the same medium at 33 degrees C, EPS and CPS production was inhibited, and up to 3.9 g of cyclic beta-(1,2)-glucan was produced during an incubation period of 20 days with a total biomass of 0.55 g of protein. In a medium containing 50 g of mannitol and 10 g of glutamic acid per liter, high cell densities (3.95 g of protein) were obtained at 25 degrees C. This biomass excreted 10.9 g of cyclic beta-(1,2)-glucan within 10 days. Concomitantly, 4.8 g of EPS were synthesized, while CPS production was strongly suppressed. The excreted cyclic beta-(1,2)-glucans were neutral and had degrees of polymerization ranging from 17 to 25, with a degree of polymerization of 19 as the major glucan cycle.     

Osmotically-regulated trehalose accumulation and cyclic β-(1,2)-glucan excretion by Rhizobium leguminosarum biovar trifolii TA-1

Rhizobium leguminosarum biovar trifolii TA-1 produced high molecular weight extracellular (EPS) and capsular polysaccharides (CPS) as the main carbohydrate products in a medium (10 g of mannitol and 1 g of glutamic acid per liter) with low osmotic pressure of 0.20 MPa. By increasing the osmotic pressure of the medium with the addition of NaCl or other osmolytes up to 1.44 MPa, the synthesis of EPS and CPS was suppressed. Cyclic -(1,2)-glucans were excreted instead. Concentrations of over 1500 mg of glucans/l medium were produced by a biomass of 520 mg protein at 200 mM NaCl (1.20 MPa). Intracellular cyclic -(1,2)-glucan concentrations remained at 45 to 100 mg/g protein during the stationary phase, independent of the osmotic strength of the medium. Parallel to the increasing osmotic pressure of the medium, the disaccharide trehalose accumulated in the cells as osmo-protectant. Concentrations of up to 130 mg/g protein were reached. Strain TA-1 could tolerate 350 mM NaCl.Abbreviations CPS capsular polysaccharide - EPS extracellular polysaccharide - LM_r low molecular weight - HM_r high molecular weight     

Influence of growth conditions on production of capsular and extracellular polysaccharides byRhizobium leguminosarum

The influence of growth rate and medium composition on exopolymer production byRhizobium leguminosarum was studied. When grown in medium containing 10g/l mannitol and 1g/l glutamic acid,Rhizobium leguminosarum biovartrifolii TA-1 synthesized up to 2.0g/l of extracellular polysaccharide (EPS), and up to 1.6g/l of capsular polysaccharide (CPS). Under non-growing cell conditions in medium without glutamic acid, CPS synthesis by strain TA-1 could proceed to 2.1g/l, while EPS-production remained relatively low (0.8g/l). Maximal CPS-yield was 2.9g CPS/l medium in a medium containing 20g/l mannitol and 2g/l glutamic acid. TheEPS-deficient strain R. leguminosarum RBL5515,exo4::Tn5 was able to produce CPS to similar levels as strain TA-1, but CPS-recovery was easier because of the low viscosity of the medium and growth of the cells in pellets. With strain TA-1 in nitrogen-limited continuous cultures with a constant biomass of 500mg cell protein/l, EPS was the most abundant polysaccharide present at every dilution rate D (between 0.12 and 0.02 h^–1). The production rates were 50–100mg/g protein/h for EPS and 15–20mg/g protein/h for CPS. Only low amounts of cyclic -(1,2)-glucans were excreted (10–30 mg/l) over the entire range of growth rates.Abbreviations bv biovar - CPS capsular polysaccharide - EPS extracellular polysaccharide - HM_r high molecular mass - LM_r low molecular mass - YEMCR Yeast Extract-Mannitol-Congo Red agar     

Synthesis of cyclic beta-(1,2)-glucans by Rhizobium leguminosarum biovar trifolii TA-1: factors influencing excretion.

The synthesis of cyclic beta-(1,2)-glucans from UDP-[14C]glucose by a crude membrane preparation and whole cells of Rhizobium leguminosarum bv. trifolii TA-1 was investigated. The crude membrane system needed Mn2+, ATP, and NAD+ for optimal activity. Hardly any difference in biosynthetic activity between membrane fractions of TA-1 cells grown in the presence (200 mM) or absence of NaCl was observed. Whole TA-1 cells grown in the presence of NaCl excreted labeled, neutral cyclic beta-(1,2)-glucan during incubation with added UDP-[14C]glucose. With NaCl-free cultured TA-1 cells, no excretion was observed; however, after these cells were alternately frozen and thawed eight times, they excreted glucans. Glucan formation in vitro and glucan excretion by whole cells were strongly inhibited in the presence of 50 mg of cyclic glucan per ml (about 15 mM), indicating that biosynthesis of cyclic beta-(1,2)-glucans in strain TA-1 is controlled by end-product inhibition. These observations indicate that TA-1 cells become more permeable to cyclic glucans at high NaCl concentrations. The constant loss of glucans from cells grown in the presence of 200 mM NaCl prevented end-product inhibition and resulted in glucan accumulation of up to 1,600 mg/liter in the medium.     

Selective synthesis of polysaccharides by Rhizobium trifolii, strain TA-1

Abstract Rhizobium trifolii strain TA-1, produces one of each of the exocellular polysaccharides EPS, CPS and β-1,2-glucans as a major product during cultivation in glutamic acid-mannitol-salts (GMS) medium at 25°. In batch culture, the major exocellular polysaccharide product was acidic exopolysaccharide (EPS) under conditions of air saturation; capsular polysaccharide (CPS) under conditions of N-limitation and moderate oxygen supply; and cyclic β-1,2-glucans at high cell density and severe oxygen limitation.     

Mechanism of action of cyclic beta-1,2-glucan synthetase from Agrobacterium tumefaciens: competition between cyclization and elongation reactions.

We have examined some aspects of the mechanism of cyclic beta-1,2-glucan synthetase from Agrobacterium tumefaciens (235-kDa protein, gene product of the chvB region). The enzyme produces cyclic beta-1,2-glucans containing 17 to 23 glucose residues from UDP-glucose. In the presence of added cyclic beta-1,2-glucans (> 0.5 mg/ml) (containing 17 to 23 glucose residues), the enzyme instead synthesizes larger cyclic beta-1,2-glucans containing 24 to 30 glucose residues. This is achieved by de novo synthesis and not by disproportion reactions with the added product. This is interpreted as inhibition of the specific cyclization reaction for the synthesis of cyclic beta-1,2-glucans containing 17 to 23 glucose residues but with no concomitant effect on the elongation (polymerization) reaction. Temperature and detergents both affect the distribution of sizes of cyclic beta-1,2-glucans, but glucans containing 24 to 30 glucose residues are not produced. We suggest that the size distribution of cyclic beta-1,2-glucan products depends on competing elongation and cyclization reactions.     

Effects of Ionic and Osmotic Strength on the Glucosyltransferase of Rhizobium meliloti Responsible for Cyclic beta-(1,2)-Glucan Biosynthesis

The cyclic beta-(1,2)-glucans of Rhizobium meliloti and Agrobacterium tumefaciens play an important role during hypoosmotic adaptation, and the synthesis of these compounds is osmoregulated. Glucosyltransferase, the enzyme responsible for cyclic beta-(1,2)-glucan biosynthesis, is present constitutively, suggesting that osmotic regulation of the biosynthesis of these glucans occurs through modulation of enzyme activity. In this study, we examined regulation of cyclic glucan biosynthesis in vitro with membrane preparations from R. meliloti. The results show that ionic solutes inhibit glucan synthesis, even when they are present at low concentrations (e.g., 10 mM). In contrast, neutral solutes (glucose, sucrose, and the compatible solutes glycine betaine and trehalose) were found to stimulate glucan synthesis in vitro when they were present at high concentrations (e.g., 1 M). Furthermore, high concentrations of these neutral solutes were shown to compensate for the inhibition of glucosyltransferase activity by ionic solutes. Consistent with their ionic character, the compatible solute potassium glutamate and the osmoprotectant choline chloride inhibited glucosyltransferase activity in vitro. The results suggest that intracellular ion concentrations, intracellular osmolarity, and intracellular concentrations of nonionic compatible solutes all act as important determinants of glucosyltransferase activity in vivo. Additional experiments were performed with an ndvA mutant defective for transport of cyclic glucans and an ndvB mutant that produces a C-terminal truncated glucosyltransferase. Cyclic beta-(1,2)-glucan biosynthesis, although reduced, was found to be osmoregulated in both mutants. These results reveal that NdvA and the C terminus of NdvB are not required for osmotic regulation of cyclic beta-(1,2)-glucan biosynthesis.     

Synthesis of glycerophosphorylated cyclic beta-(1,2)-glucans by Rhizobium meliloti ndv mutants.

The periplasmic cyclic beta-(1,2)-glucans of Rhizobium spp. are believed to provide functions during hypoosmotic adaptation and legume nodulation. In Rhizobium meliloti, cyclic beta-(1,2)-glucans are synthesized at highest levels when cells are grown at low osmolarity, and a considerable fraction (> or = 35%) of these glucans may become substituted with phosphoglycerol moieties. Thus far, two chromosomally encoded proteins, NdvA and NdvB, have been shown to function during cyclic beta-(1,2)-glucan biosynthesis; however, the precise roles for these proteins remain unclear. In the present study, we show that R. meliloti mutants lacking up to one-third of the downstream region of ndvB synthesize cyclic beta-(1,2)-glucans similar to those produced by wild-type cells with respect to size and phosphoglycerol substituent profile. In contrast, no phosphoglycerol substituents were detected on the cyclic beta-(1,2)-glucans synthesized by an R. meliloti ndvA mutant.     

A comparative study on the production of exopolysaccharides between two entomopathogenic fungi Cordyceps militaris and Cordyceps sinensis in submerged mycelial cultures

AIMS: The present study comparatively investigates the optimal culture conditions for the production of exopolysaccharides (EPS) and cordycepin during submerged mycelial culture of two entomopathogenic fungi Cordyceps militaris and Cordyceps sinensis. METHODS AND RESULTS: Fermentations were performed in flasks and in 5-l stirred-tank fermenters. In the case of C. militaris, the highest mycelial biomass (22.9 g l(-1)) and EPS production (5 g l(-1)) were achieved in a medium of 40 g l(-1) sucrose, 5 g l(-1) corn steep powder at 30 degrees C, and an initial pH 8.0. The optimum culture conditions for C. sinensis was shown to be (in g l(-1)) 20 sucrose, 25 corn steep powder, 0.78 CaCl2, 1.73 MgSO4.7H2O at 20 degrees C, and an initial pH 4.0, where the maximum mycelial biomass and EPS were 20.9 and 4.1 g l(-1) respectively. Cordycepin, another bioactive metabolite, was excreted at low levels during the early fermentation period (maximum 38.8 mg l(-1) in C. militaris; 18.2 mg l(-1) in C. sinensis). CONCLUSIONS: The two fungi showed different nutritional and environmental requirements in their submerged cultures. Overall, the concentrations of mycelial biomass, EPS and cordycepin achieved in submerged culture of C. militaris were higher than those of C. sinensis. SIGNIFICANCE AND IMPACT OF THE STUDY: C. militaris and C. sinensis are representative insect-born fungi which have been longstanding and widely used as traditional medicines in eastern Asia. Comparative studies between two fungi are currently not available and this is the first report on the optimum medium composition for submerged culture of C. sinensis.     

The Brucella abortus cyclic beta-1,2-glucan virulence factor is substituted with O-ester-linked succinyl residues

Brucella periplasmic cyclic beta-1,2-glucan plays an important role during bacterium-host interaction. Nuclear magnetic resonance spectrometry analysis, thin-layer chromatography, and DEAE-Sephadex chromatography were used to characterize Brucella abortus cyclic glucan. In the present study, we report that a fraction of B. abortus cyclic beta-1,2-glucan is substituted with succinyl residues, which confer anionic character on the cyclic beta-1,2-glucan. The oligosaccharide backbone is substituted at C-6 positions with an average of two succinyl residues per glucan molecule. This O-ester-linked succinyl residue is the only substituent of Brucella cyclic glucan. A B. abortus open reading frame (BAB1_1718) homologous to Rhodobacter sphaeroides glucan succinyltransferase (OpgC) was identified as the gene encoding the enzyme responsible for cyclic glucan modification. This gene was named cgm for cyclic glucan modifier and is highly conserved in Brucella melitensis and Brucella suis. Nucleotide sequencing revealed that B. abortus cgm consists of a 1,182-bp open reading frame coding for a predicted membrane protein of 393 amino acid residues (42.7 kDa) 39% identical to Rhodobacter sphaeroides succinyltransferase. cgm null mutants in B. abortus strains 2308 and S19 produced neutral glucans without succinyl residues, confirming the identity of this protein as the cyclic-glucan succinyltransferase enzyme. In this study, we demonstrate that succinyl substituents of cyclic beta-1,2-glucan of B. abortus are necessary for hypo-osmotic adaptation. On the other hand, intracellular multiplication and mouse spleen colonization are not affected in cgm mutants, indicating that cyclic-beta-1,2-glucan succinylation is not required for virulence and suggesting that no low-osmotic stress conditions must be overcome during infection.     

Cyclic beta-(1,2)-glucan synthesis in Rhizobiaceae: roles of the 319-kilodalton protein intermediate.

Cyclic beta-(1,2)-glucans are synthesized by members of the Rhizobiaceae family through protein-linked oligosaccharides as intermediates. The protein moiety is a large inner membrane molecule of about 319 kDa. In Agrobacterium tumefaciens and in Rhizobium meliloti the protein is termed ChvB and NdvB, respectively. Inner membranes of R. meliloti 102F34 and A. tumefaciens A348 were first incubated with UDP-[14C]Glc and then solubilized with Triton X-100 and analyzed by polyacrylamide gel electrophoresis under native conditions. A radioactive band corresponding to the 319-kDa protein was detected in both bacteria. Triton-solubilized inner membranes of A. tumefaciens were submitted to native electrophoresis and then assayed for oligosaccharide-protein intermediate formation in situ by incubating the gel with UDP-[14C]Glc. A [14C]glucose-labeled protein with an electrophoretic mobility identical to that corresponding to the 319-kDa [14C]glucan protein intermediate was detected. In addition, protein-linked radioactivity was partially chased when the gel was incubated with unlabeled UDP-Glc. A heterogeneous family of cyclic beta-(1,2)-glucans was formed upon incubation of the gel portion containing the 319-kDa protein intermediate with UDP-[14C]Glc. A protein with an electrophoretic behavior similar to the 319-kDa protein intermediate was "in gel" labeled by using Triton-solubilized inner membranes of an A. tumefaciens exoC mutant, which contains a protein intermediate without nascent glucan. These results indicate that initiation (protein glucosylation), elongation, and cyclization were catalyzed in situ. Therefore, the three enzymatic activities detected in situ reside in a unique protein component (i.e., cyclic beta-(1,2)-glucan synthase). It is suggested that the protein component is the 319-kDa protein intermediate, which might catalyze the overall cyclic beta-(1,2)-glucan synthesis.     

Osmosensitivity phenotypes of Agrobacterium tumefaciens mutants that lack periplasmic beta-1,2-glucan.

The periplasmic cyclic beta-1,2-glucan of Agrobacterium tumefaciens is believed to maintain high osmolarity in the periplasm during growth of the bacteria on low-osmotic-strength media. Strains with mutations in the chvA or chvB gene do not accumulate beta-1,2-glucan in their periplasm and exhibit pleiotropic phenotypes, including inability to form crown gall tumors on plants. We examined the effects of medium osmolarity to determine whether some or all of these phenotypes result from suboptimal periplasmic osmolarity. The mutants grew more slowly than wild-type cells and exhibited altered periplasmic and cytoplasmic protein content when cultured in low-osmotic-strength media, but not when cultured in high-osmotic-strength media. These observations support a role for periplasmic glucan in osmoadaptation. However, the mutants were avirulent and exhibited reduced motility regardless of the osmolarity of the medium. Therefore, beta-1,2-glucan may play roles in virulence and motility that are unrelated to its role in osmoadaptation.     

Enhanced production of exopolysaccharides by fed-batch culture of Ganoderma resinaceum DG-6556

The objectives of this study were to optimize submerged culture conditions of a new fungal isolate, Ganorderma resinaceum, and to enhance the production of bioactive mycelial biomass and exopolysaccharides (EPS) by fed-batch culture. The maximum mycelial growth and EPS production in batch culture were achieved in a medium containing 10 g/l glucose, 8 g/l soy peptone, and 5 mM MnCl(2) at an initial pH 6.0 and temperature 31 degrees C. After optimization of culture medium and environmental conditions in batch cultures, a fed-batch culture strategy was employed to enhance production of mycelial biomass and EPS. Five different EPS with molecular weights ranging from 53,000 to 5,257,000 g/mole were obtained from either top or bottom fractions of ethanol precipitate of culture filtrate. A fed-batch culture of G. resinaceum led to enhanced production of both mycelial biomass and EPS. The maximum concentrations of mycelial biomass (42.2 g/l) and EPS (4.6 g/l) were obtained when 50 g/l of glucose was fed at day 6 into an initial 10 g/l of glucose medium. It may be worth attempting with other mushroom fermentation processes for enhanced production of mushroom polysaccharides, particularly those with industrial potential.     

Rhicadhesin-mediated attachment and virulence of an Agrobacterium tumefaciens chvB mutant can be restored by growth in a highly osmotic medium.

Cyclic beta-1,2-glucan is considered to play a role in osmoadaptation of members of the family Rhizobiaceae in hypotonic media. Agrobacterium tumefaciens chvB mutants, lacking beta-1,2-glucan, exhibit a pleiotropic phenotype, including nonmotility, attachment deficiency, and avirulence. Here we report that by growth of chvB mutant cells in tryptone-yeast extract medium supplemented with 7 mM CaCl2 and 100 mM NaCl, the mutant cells become motile, attach to pea root hair tips, and are virulent on Kalanchoë leaves. Moreover, whereas chvB mutants grown in tryptone-yeast extract medium containing 7 mM CaCl2 do not produce active rhicadhesin, addition of 100 mM NaCl to this medium resulted in restoration of rhicadhesin activity. The presence of CaCl2 appeared to be required for attachment, virulence, and activity of rhicadhesin. The results support a role for cyclic beta-1,2-glucan in osmoadaptation and strengthen the notion that rhicadhesin is required for attachment and virulence of A. tumefaciens.     

Synthesis of a low-molecular-weight form of exopolysaccharide by Bradyrhizobium japonicum USDA 110

A novel extracellular low-molecular-weight polysaccharide was detected as a contaminant within extracellular cyclic beta-1,6-beta-1,3-glucan preparations from Bradyrhizobium japonicum USDA 110 cultures. Compositional analysis, methylation analysis, and nuclear magnetic resonance analysis revealed that this low-molecular-weight polysaccharide was composed of the same pentasaccharide repeating unit previously described for the high-molecular-weight form of the exopolysaccharide (EPS) synthesized by B. japonicum strains. Mass spectrometry analysis indicated that the size of this low-molecular-weight form of EPS was consistent with a dimeric form of the pentasaccharide repeating unit.     

Acetolysis of Pichia pastoris IFO 0948 strain mannan containing alpha-1,2 and beta-1,2 linkages using acetolysis medium of low sulfuric acid concentration

To obtain manno-oligosaccharides containing beta-1,2-linked nonreducing terminal groups from the mannan of Pichia pastoris IFO 0948 strain by acetolysis, an attempt was made to establish the reaction conditions under which cleavage of the alpha-1,6 linkage took place preferentially leaving manno-oligosaccharides composed largely of beta-1,2 linkages. By the action of an ordinary acetolysis medium, a 10/10/1 (v/v) mixture of acetic anhydride, acetic acid, and sulfuric acid at 40 degrees C for 13 h or at 25 degrees C for 120 h, the O-acetyl derivative of this mannan gave mannose, mannobiose, mannotriose, and mannopentaose. However, treatment of the same O-acetyl mannan with a 50/50/1 (v/v) acetolysis medium at 40 degrees C for 15 h gave a mannotetraose in addition to mannose, mannobiose, mannotriose, and mannopentaose. Use of a 100/100/1 (v/v) acetolysis medium at 40 degrees C for 36 h gave a more satisfactory result, a mixture of oligosaccharides, from mannose to mannopentaose, which contained more mannotetraose than mannopentaose. Because both mannotetraose and mannopentaose contained alpha-1,2 and beta-1,2 linkages, it was concluded that an acetolysis medium containing a low concentration of sulfuric acid, up to 0.5% (v/v), facilitates the preferential cleavage of the alpha-1,6 linkage, leaving manno-oligosaccharides containing the beta-1,2 linkage which was found to be labile to the action of the 10/10/1 (v/v) acetolysis medium.     

Effects of nutrients on exopolysaccharide production and surface properties of Aeromonas salmonicida.

Extracellular polysaccharide (EPS) and capsular polysaccharide (CPS) production by Aeromonas salmonicida A450 and the influence of the capsule on cell surface properties were studied. A. salmonicida did not produce CPS or EPS when glucose, phosphate, magnesium chloride, or trace mineral components were absent from the medium. The addition of yeast extract improved capsule production. Neither EPS nor CPS formation depended on the C/N ratio, although it appeared to be influenced by the level of carbon and nitrogen in the culture. Both EPS and CPS production started at the end of the logarithmic growth phase. The amounts of EPS and CPS produced were not influenced by temperature changes between 15 and 20 degrees C and was maximal from pH 7 to 7.5. Cell surface properties were strongly influenced by capsule production; high CPS production was associated with enhanced cell hydrophilicity and autoagglutination. The effect of CPS on cell surface properties was independent of the presence of the surface protein array (A-layer).     

Role for [corrected] Agrobacterium tumefaciens ChvA protein in export of beta-1,2-glucan.

Functional chvA and chvB genes are required for attachment of Agrobacterium tumefaciens to plant cells, an early step in crown gall tumor formation. Strains defective in these loci do not secrete normal amounts of cyclic beta-1,2-glucan. Whereas chvB is required for beta-1,2-glucan synthesis, the role of chvA in glucan synthesis or export has not been clearly defined. We found that cultures of chvA mutants contained as much neutral beta-1,2-glucan in the cell pellets as did the wild type, with no detectable accumulation of glucan in the culture supernatant. The cytoplasm of chvA mutant cells contained over three times more soluble beta-1,2-glucan than did the cytoplasm of the wild-type parent. Unlike the wild type, chvA mutants contained no detectable periplasmic glucan. The amino acid sequence of chvA is highly homologous to the sequences of bacterial and eucaryotic export proteins, as observed previously in the case of ndvA, a rhizobial homolog of chvA. Strong sequence homology within this family of export proteins is concentrated in the carboxy-terminal portions of the proteins, but placement of consensus ATP-binding sites, internal signal sequences, and hydrophobic domains are conserved over their entire lengths. These data suggest a model for beta-1,2-glucan synthesis in A. tumefaciens in which glucan is synthesized inside the inner membrane with the participation of ChvB and transported across the inner membrane with the participation of ChvA.     

A novel cyclic beta-1,2-glucan mutant of Rhizobium meliloti.

The periplasmic cyclic beta-1,2-glucans produced by bacteria within the Rhizobiaceae family provide functions during hypo-osmotic adaptation and plant infection. In Rhizobium meliloti, these molecules are highly modified with phosphoglycerol and succinyl substituents, and it is possible that the anionic character of these glucans is important for their functions. In the present study, we have used a thin-layer chromatographic screening method to identify a novel R. meliloti mutant specifically blocked in its ability to transfer phosphoglycerol substituents to the cyclic beta-1,2-glucan backbone. Further analysis revealed that the cyclic glucans produced by this mutant contained elevated levels of succinyl substituents. As a result, the overall anionic charge on the cyclic beta-1,2-glucans was found to be similar to that of wild-type cells. Despite this difference in cyclic beta-1,2-glucan structure, the mutant was shown to effectively nodulate alfalfa and to grow as well as wild-type cells in hypo-osmotic media.     

Optimization of submerged culture process for the production of mycelial biomass and exo-polysaccharides by Cordyceps militaris C738

AIMS: The objective of the present study was to determine the optimal culture conditions for mycelial biomass and exo-polysaccharide (EPS) by Cordyceps militaris C738 in submerged culture. METHODS AND RESULTS: The optimal temperatures for mycelial biomass and EPS production were 20 degrees C and 25 degrees C, respectively, and corresponding optimal initial pHs were found to be 9 and 6, respectively. The suggested medium composition for EPS production was as follows: 6% (w/v) sucrose, 1% (w/v) polypeptone, and 0.05% (w/v) K2HPO4. The influence of pH on the fermentation broth rheology, morphology and EPS production of C. militaris C738 was carried out in a 5-l stirred-tank fermenter. The morphological properties were comparatively characterized by pellet roughness and compactness by use of image analyser between the culture conditions with and without pH control. The roughness and compactness of the pellets indicated higher values at pH-stat culture (pH 6.0), suggesting that larger and more compact pellets were desirable for polysaccharide production (0.91 g g(-1) cell d(-1). CONCLUSIONS: Under the optimized culture conditions (with pH control at 6), the maximum concentration of biomass and EPS were 12.7 g l(-1) and 7.3 g l(-1), respectively, in a 5-l stirred-tank fermenter. SIGNIFICANCE AND IMPACT OF THE STUDY: The critical effect of pH on fungal morphology and rheology presented in this study can be widely applied to other mushroom fermentation processes.