Improved method for purification of Xenopus laevis vitellogenin and demonstration of cross-reactivity among wide-range species by radioimmunoassay

This study was performed to improve the purification of Xenopus vitellogenin and establish the radioimmunoassay. The procedure of purification consisted of ammonium precipitation, DEAE-Sephadex chromatography and Sephadex G-200 gel chromatography. Using this procedure, 934 mg vitellogenin was purified from 49 ml of estradiol treated female Xenopus plasma (about 19 mg/ml). Vitellogenins purified from male and female plasma after a single injection of estradiol showed good correspondence in electrophoretic patterns and amino acid compositions, indicating that vitellogenin synthesis in the male occurs in four different genes as in the female. The radioimmunoassay for vitellogenin was established using an antibody in the plasma obtained from rabbits injected with purified Xenopus female vitellogenin. The titer was 20,000 times dilution of the plasma, and the minimum detectable amount of vitellogenin was 0.1 microgram. The cross-reactivity of this antibody with newt vitellogenin was about 65% and that of chick 6%. The cross-reaction was also observed in female bullfrog plasma. Vitellogenin content was increased gradually during the first 6 days after injection of estradiol in female and the elevated level of vitellogenin dropped afterward.     

小麦长蠕孢菌毒素

小麦长蠕孢菌(Helminthosporium sativum)在21—25℃的Fries溶液中振荡培养时产生的毒素,易引起与病原菌感染小麦类似的特征性病状。培养滤液的浓缩物,经丙酮沉淀,正丁醇-氯仿萃取,二次硅胶柱层析等程序,将毒素部分纯化,毒素的硅胶TLC层析表明,毒素层离组分至少为6种,在紫外灯下和碘蒸气中观察,显蓝紫色光斑和棕黄色斑,它们的Rf值依次为0.12,0.16,0.25,0.36,0.43,0.54,并具有倍半萜类化合物特有的紫外吸收带,它们的最大吸收值(max)分别为270,285,287,290,287,287nm,与国外报道乙醚提取物的紫外吸收特性相近(sommereyns & Closset,1978)。生物检测结果表明,上述组分均为毒素活性部分,它除能溶于ε为10以上的溶剂外,对热和光稳定,最适pH 4—7,极端pH下,毒素活性被钝化,回调最适pH后,活性仍可恢复,即令高温蒸煮也不丧失活性。毒素对小麦叶组织伤害能力及其活性与温度,毒素浓度和剂量,作用时间的变化呈正相关。     

The crystalline yolk-platelet proteins and their soluble plasma precursor in an amphibian, Xenopus laevis

A single lipophosphoprotein complex, vitellogenin, was isolated and purified from the plasma of oestrogen-stimulated female toads by preparative ultracentrifugation and chromatography on TEAE-cellulose (triethylaminoethylcellulose). The protein contains 12% lipid, 1.5% phosphorus, 1.6% calcium and smaller amounts of carbohydrates and biliverdin. In amino acid composition it is identical with total yolk-platelet protein. The platelet protein, however, is fractionated on TEAE-cellulose into two components, a high-molecular-weight lipovitellin and a smaller phosvitin. Analyses of the soluble plasma vitellogenin suggest that it is a complex of two phosvitin molecules covalently bound to one lipovitellin dimer, and that it is the immediate precursor of the yolk proteins, into which it is converted by a molecular rearrangement. Uptake of vitellogenin from the plasma into the growing oocyte, and its subsequent crystallization as a yolk platelet, appear to be enhanced by gonadotrophic hormones.     

High‐efficiency affinity precipitation of multiple industrial mAbs and Fc‐fusion proteins from cell culture harvests using Z‐ELP‐E2 nanocages

Affinity precipitation using Z‐elastin‐like polypeptide‐functionalized E2 protein nanocages has been shown to be a promising alternative to Protein A chromatography for monoclonal antibody (mAb) purification. We have previously described a high‐yielding, affinity precipitation process capable of rapidly capturing mAbs from cell culture through spontaneous, multivalent crosslinking into large aggregates. To challenge the capabilities of this technology, nanocage affinity precipitation was investigated using four industrial mAbs (mAbs A–D) and one Fc fusion protein (Fc A) with diverse molecular properties. A molar binding ratio of 3:1 Z:mAb was sufficient to precipitate >95% mAb in solution for all molecules evaluated at ambient temperature without added salt. The effect of solution pH on aggregation kinetics was studied using a simplified two‐step model to investigate the protein interactions that occur during mAb–nanocage crosslinking and to determine the optimal solution pH for precipitation. After centrifugation, the pelleted mAb–nanocage complex remained insoluble and was capable of being washed at pH ≥ 5 and eluted with at pH < 4 with >90% mAb recovery for all molecules. The four mAbs and one Fc fusion were purified from cell culture using optimal process conditions, and >94% yield and >97% monomer content were obtained. mAb A–D purification resulted in a 99.9% reduction in host cell protein and >99.99% reduction in DNA from the cell culture fluids. Nanocage affinity precipitation was equivalent to or exceeded expected Protein A chromatography performance. This study highlights the benefits of nanoparticle crosslinking for enhanced affinity capture and presents a robust platform that can be applied to any target mAb or Fc‐containing proteins with minimal optimization of process parameters.     

Studies on the galactomannan-degrading enzymes produced bySporotrichum cellulophilum

Summary Extracellular mannanase activity produced bySporotrichum cellulophilum was purified into two components using acetone precipitation, SP-Sephadex C50 ion exchange chromatography and preparative polyacrylamide gel electrophoresis. The purified mannanse components, M1 and M2, had molecular weights of 108 000–112 000 and 32 200–36 000 respectively. Component M1 was shown to contain 2 subunits having molecular weights of 62 000 and 50 000. M1 and M2 had similar pH-activity profiles with pH optima of 5.5 and 6.0 respectively. M1 was more thermostable than M2: half lives of the enzymes at 70°C were 30 and 9 min for M1 and M2 respectively.     

Development of an enzyme-linked immunosorbent assay for vitellogenin of Morelet's crocodile (Crocodylus moreletii)

The purpose of this study was to develop an immunoassay for vitellogenin in Morelet's crocodile (Crocodylus moreletii). Blood was collected from wild-caught crocodiles in Belize. Plasma samples from adult females taken during the breeding season were used for vitellogenin purification and samples from adult males were used for comparison. No differences were detected between males and females for plasma total protein concentration, as measured by Coomassie assay. However, denaturing polyacrylamide gel electrophoresis (SDS-PAGE) revealed that female plasma contained a 210-kDa protein, presumably the vitellogenin monomer, that was absent in adult male plasma. The identity of the putative vitellogenin was confirmed by its cross-reactivity in Western blots with a vitellogenin antiserum that was generated against a conserved vitellogenin peptide sequence. Crocodile vitellogenin was purified by two successive rounds of DEAE chromatography. The purified protein had an apparent molecular mass of 450 kDa, as determined by gel filtration chromatography, and 210 kDa on SDS-PAGE. An indirect enzyme-linked immunosorbent assay (ELISA) was then developed for C. moreletii vitellogenin. The detection limit of the assay was 20.0 ng/mL. The intra- and inter-assay coefficients of variation were 5.3% and 9.8%, respectively. The recovery of vitellogenin diluted into male plasma was 94.7%. The ELISA assay revealed that vitellogenin levels of adult female plasma during the breeding season ranged from 1.8 to 3.1 mg/mL with a mean of 2.5+/-0.25 mg/mL. No vitellogenin was detected in adult male plasma. Induction of vitellogenin in Morelet's crocodile may be a useful model system for field studies of crocodile reproduction and for investigations of endocrine disruption in this species.     

Composition of Acid-sensitive Fraction in Soybean Proteins

An acid-sensitive fraction (ASF) was prepared from defatted soybean meals by two procedures. ASF1 was prepared by precipitation at pH 4.5 followed by removal of 1 m NaCl-soluble materials from the precipitate. ASF2 was prepared by precipitation in solution containing 1 m NaCl at pH 4.5. The protein components of the two fractions were analyzed by gel electrophoresis in a dissociating-buffer system and found to contain β-conglycinin, glycinin and whey proteins. In addition to these, several other bands appeared.

Appreciable amounts of lipid (8.2% in ASF1 and 8.8% in ASF2) were also found in the fractions. They were separated by column chromatography and thin-layer chromatography. Glycolipids were the major components of the lipids. Both glycolipid and phospholipid fractions contained slower-moving materials on thin-layer chromatography.     

Purification of human erythropoietin.

Human erythropoietin, derived from urine of patients with aplastic anemia, has been purified to apparent homogeneity. The seven-step procedure, which included ion exchange chromatography, ethanol precipitation, gel filtration, and adsorption chromatography, yielded a preparation with a potency of 70,400 units/mg of protein in 21% yield. This represents a purification factor of 930. The purified hormone has a single electrophoretic component in polyacrylamide gels at pH 9, in the presence of sodium dodecylsulfate at pH 7, and in the presence of Triton X-100 at pH 6. Two fractions of the same potency and molecular size, by sodium dodecyl sulfate gel electrophoresis, but differing slightly in mobility at pH 9, were obtained at the last step of fractionation. The nature of the difference between these two components is not yet understood.     

Caprylic acid precipitation method for impurity reduction: An alternative to conventional chromatography for monoclonal antibody purification

We report the use of caprylic acid based impurity precipitation as (1) an alternative method to polishing chromatography techniques commonly used for monoclonal antibody purification and (2) an impurity reduction step prior to harvesting the bioreactor. This impurity reduction method was tested with protein A purified antibodies and with cell culture fluid. First, the operational parameters influencing precipitation of host cell proteins and high molecular weight aggregate in protein A pools were investigated. When used as a polishing step, the primary factor affecting purification and yield was determined to be pH. Caprylic acid precipitation was comparable to polishing IEX chromatography in reducing host cell protein and aggregate levels. A virus reduction study showed complete clearance of a model retrovirus during caprylic acid precipitation of protein A purified antibody. Caprylic acid mediated impurity precipitation in cell culture showed that the impurity clearance was generally insensitive to pH and caprylic acid concentration whereas yield was a function of caprylic acid concentration. Protein A purification of caprylic acid precipitated cell culture fluid generated less turbid product pool with reduced levels of host cell proteins and high molecular weight aggregate. The results of this study show caprylic acid precipitation to be an effective purification method that can be incorporated into a production facility with minimal cost as it utilizes existing tanks and process flow. Eliminating flow through chromatography polishing step can provide process intensification by avoiding the process tank volume constraints for high titer processes. Biotechnol. Bioeng. 2012; 109: 2589–2598. © 2012 Wiley Periodicals, Inc.     

One-step, non-denaturing purification method of carp (Cyprinus carpio) vitellogenin

A new single-step purification procedure was developed to purify carp (Cyprinus carpio) vitellogenin (VTG), from estradiol-treated carp plasma. This method was performed by high performance liquid weak anion-exchange chromatography, using a discontinuous elution gradient of NaCl (0-0.5 M, steps of 12.5 mM/4 min). SDS and native-PAGE analysis, of treated-fish plasma and purified solution, showed the appearance of a 370 kDa phospholipoprotein, composed of two 130 kDa monomers, with all VTG characteristics. The sequencing of a 130 kDa monomer confirmed that it was carp VTG. Consequently, this procedure is a rapid method, permitting high quantities of non-denatured carp VTG to be obtained.     

Purification of vitellogenin from the plasma of Indian freshwater murrel, Channa punctatus (Bloch) by different methods: a comparative study

Plasma from estrogenized, [32P] NaH2PO4-injected murrel, Channa punctatus was collected in the presence of proteolytic inhibitors and subjected to different separation procedures singly or in combination, viz., gel filtration chromatography on Ultrogel AcA 34, ion-exchange chromatography on DEAE sephacel, or selective precipitation with dimethylformamide or with Mg2+: EDTA in order to isolate vitellogenin from other plasma proteins. The results show that chromatography on Ultrogel or DEAE sephacel yields intact vitellogenin whereas prior precipitation with DMF or with Mg2+: EDTA results in either co-precipitation of other plasma proteins or in the cleavage of phosvitin-like material from the native vitellogenin molecule.     

Heterogeneity of streptococcus group A cell wall protein components

Cell wall surface proteins of group A streptococcus (M 29) were isolated by mild chemical extraction with 1 M hydroxylamine pH 6.0 (37 degrees C). The proteins were purified by ammonium sulfate fractionation, gel filtration on Sephadex G-150 and ion-exchange chromatography on DEAE-Trisacryl M. Using two independent methods (disc electrophoresis in 7.5% PAAG pH 8.9 and high pressure gel filtration), it was shown that after chromatography on Sephadex G-150 the original protein fraction contains up to 8 protein components, while SDS-PAAG electrophoresis performed according to Laemmli revealed up to 25 protein components in the same fraction. During SDS-PAAG electrophoresis six protein fractions performed after ion-exchange chromatography were resolved into 40 protein components whose molecular masses vary from 13 to 80 kDa. Possible reasons for the heterogeneity of surface proteins of group A streptococcus cell wall are discussed.     

Purification and characterization of honey bee vitellogenin

A protocol has been developed for the purification of vitellogenin from the honey bee, Apis mellifera. Purification allows for the first characterization of a vitellogenin from the large order Hymenoptera. Hymenopteran vitellogenins are unusual among insect vitellogenins in that they contain only one type of apoprotein. The honey bee vitellogenin was isolated from hemolymph of honey bee queens by a combination of density gradient ultracentrifugation, ion-exchange chromatography, and affinity chromatography. The native vitellogenin particle is a very high density glycolipoprotein containing approximately 91% protein, 7% lipid, and 2% carbohydrate. Phospholipid and diacylglycerol are the major lipid components. The equilibrium density (1.28 g/ml) is the same as that for Manduca sexta vitellogenin, which contains a much higher proportion of lipid. The covalently bound carbohydrate moiety of the particle is high in mannose. The amino acid composition of vitellogenin is similar to those of vitellogenins from other insect species. The N-terminal amino acid sequence of the apoprotein was determined, the first such sequence for any insect vitellogenin. When analyzed by sodium dodecyl sulfate (SDS)-gel electrophoresis, A. mellifera vitellogenin resolved into a single band with an apparent Mr of 180,000. Gel filtration under reducing and native conditions yielded estimated Mr values of about 300,000.     

短小芽孢杆菌2080碱性蛋白酶的纯化与性质

短小芽孢杆菌（Bacillus pumilus）2080碱性蛋白酶的发酵液经超滤、硫酸铵沉淀、CM Sepharose Fast Flow和DEAE Sepharose Fast Flow离子交换层析得到了纯化的组分。SDS-PAGE电泳分析显示其分子量约为61kDa。酶学性质研究表明,该纯化酶的最适pH为10．5,最适温度为50℃。     

Isolation of restriction enzyme EcoVIII, an isoschizomer of HindIII, produced by Escherichia coli E1585-68

A restriction endonuclease designated EcoVIII, an isoschizomer of HindIII, was isolated from Escherichia coli E1585-68 and purified by dextran-polyethylene glycol (DPG) phase partition, ammonium sulfate precipitation, phospho- and DEAE-cellulose chromatography, and hydroxylapatite chromatography. The purified EcoVIII was stable during the purification procedure and its high specific activity required 10 mM Mg²⁺. Unlike HindIII, Eco VIII exhibited a high specific activity even at low pH (pH 6.3) and showed the highest activity at 48° C. Transformation of purified plasmid DNA from E. coli E1585-68 into K-12 indicated that the EcoVIII gene was carried on a multicopy 4.4-kb miniplasmid. EcoVIII seems to be preferable to HindIII for its production and use because of easier handling of producer cells and a wider range of activity.     

Purification and Properties of Three Pig Erythrocyte Carronic Anhydrases

Three distinct forms of the zinc containing enzyme carbonic anhydrase were isolated from pig erythrocytes. One low activity type enzyme and two genetic variants of the high activity type enzyme with identical CO2 hydratase activities which were 8 times as high were isolated from Danish Black and White Swine. In the isolation procedure described, the hemoglobin was eliminated by precipitation with chloroform-ethanol, and the isoenzymes were separated by DEAE-Sephadex chromatography. A number of enzymatically active minor components were separated. They were apparently all genetically linked to one of the three major components. The three purified isoenzymes behaved as homogeneous components during isoelectric focusing and electrophoresis at different pH values. They were characterized in terms of molecular weight, isoelectric pH, zinc content, amino acid composition, and enzymatic activity against CO2, p-nitrophenyl acetate, and β-napthyl acetate. The circular dichroism of the enzymes in the ultraviolet region was studied. The properties of the enzymes were similar to those of carbonic anhydrases of corresponding types isolated from other mammalian species. Sulphur containing amino acid residues were absent in the low activity type enzyme. The amino acid composition of the two high activity mutants deviated only in that an arginine residue in the most widespread genetic variant was replaced by a histidine residue in the less frequent variant. Otherwise the two mutants showed identical properties.     

Induction, isolation and a characterization of the lipid content of plasma vitellogenin from two Salmo species: rainbow trout (Salmo gairdneri) and sea trout (Salmo trutta)

Vitellogenin synthesis is induced in juvenile rainbow trout (Salmo gairdneri) and juvenile sea trout (Salmo trutta) by estradiol-17 beta. A purification procedure for vitellogenin from trout plasma by precipitation with MgCl2-EDTA and subsequent anion exchange chromatography on DEAE-Sephacel is described. The total lipid contents of purified rainbow trout and sea trout vitellogenins are 18 and 19%, respectively. Approximately 2/3 of the lipids are phospholipids, while the remainder consists of triglycerides and cholesterol. Phosphorus determinations on delipidated vitellogenin yield a phosphorus content of 0.63% in rainbow trout and 0.58% in sea trout vitellogenin. Native (dimeric) vitellogenins from rainbow trout and sea trout both have an apparent molecular weight of 440,000, when estimated by gel filtration on Sepharose 6B.     

Vitellogenesis-related ovary cathepsin D from Xenopus laevis: Purification and properties in comparison with liver cathepsin D

Cathepsin D was purified from ovaries of Xenopus laevis by both QAE-cellulose and pepstatin-Sepharose chromatography and then characterized and compared with Xenopus liver cathepsin D. Ovary cathepsin D appeared predominantly as a 43-kilodalton (kDa) molecular mass, as revealed by SDS-polyacrylamide gel electrophoresis, whereas the liver enzyme was obtained exclusively as a 36-kDa protein. The purified 43-kDa ovary enzyme cleaved vitellogenin limitedly to produce yolk proteins at pH 5.6. The specific activity of ovary cathepsin D was five to six times lower than that of the liver enzyme, as measured by hemoglobin-hydrolysis at pH 3, but the ovary enzyme was shown to be superior to the liver enzyme in terms of vitellogenin-cleaving activity, as examined at pH 5.6. Ovarian enzyme preparations contained variable amounts of 36-kDa species; this form was considered to be an autolytic product of the 43-kDa form arising during purification, because it was not detected in oocyte extracts but was generated by incubation of the purified 43-kDa enzyme alone in an acid solution. The conversion of the 43-kDa form by hepatic factors was accompanied by a marked increase in hemoglobin-hydrolytic activity.     

A chromatographic method for the purification of K99 pili from enterotoxigenic Escherichia coli

Details of a relatively inexpensive method for the purification of K99 pili in their native conformation are reported. The method involved sequential precipitation of K99 pili with (NH4)2SO4, followed by precipitation in 12% (w/v) mannose or sorbitol solution. The crude pili preparation was adsorbed with Bio-Gel A-5m and subjected to sequential gel filtration on Bio-Gel A-5m equilibrated with Tris/EDTA/NaN3/NaCl buffer and KSCN/KCl solution, respectively. The K99 containing peak was subjected to sequential ion-exchange chromatography on DEAE-Bio-Gel A equilibrated with 0.02 M-Tris/HCl, pH 8.6 containing 0.05 M-NaCl and DEAE-Sephadex A-50 equilibrated with 0.05 M-phosphate buffer, pH 7.2. The purified pili yielded a single band on SDS-PAGE with an estimated molecular weight of 13000. Attempts to purify pili by other methods evaluated, viz. MgCl2 precipitation and chromatofocusing were unsuccessful. While the amino acid composition of purified K99 pili was similar to that reported previously the N-terminal amino acid was apparently blocked.     

正辛酸沉淀在单克隆抗体纯化中的工艺优化与应用

为应对治疗性抗体快速增长的市场需求,抗体上游细胞培养规模和表达量水平已显著提高,而下游纯化工艺的生产效率则相对落后,下游处理能力已成为限制抗体产能的瓶颈。本研究以单克隆抗体mab-X为实验材料,优化了细胞培养液、低pH病毒灭活收集液2种模式的正辛酸(caprylic acid,CA)沉淀工艺条件,并研究了CA处理去除聚体、CA处理灭活病毒等2种应用,在小试的基础上,采用低pH病毒灭活收集液CA沉淀的模式进行了500 L细胞培养规模生产放大研究,对沉淀前后的产品质量和收率进行了检测和对比。结果显示,两种模式的CA沉淀均可显著降低宿主细胞蛋白(host cell protein,HCP)残留和聚体含量,在聚体去除实验中CA沉淀可去除约15%的聚体,病毒灭活研究显示CA对逆转录模型病毒具有完全的病毒灭活能力。在放大生产规模中,下游依次进行了深层过滤收获、亲和层析、低pH病毒灭活、CA沉淀及深层过滤、阳离子交换层析,CA沉淀过程中混合时间和搅拌速度显著影响CA沉淀效果,CA沉淀处理后低pH病毒灭活液中的HCP残留量降低了895倍,沉淀后产品纯度和HCP残留均已控制在单克隆抗体质量要求范围内,CA沉淀可以减少传统纯化工艺中的一个精纯步骤。总之,下游工艺中采用CA沉淀,能够精简传统纯化工艺,并完全满足mab-X的纯化质量要求,而且能提高生产效率、降低生产成本。本研究结果将推动CA沉淀在单克隆抗体下游纯化生产中的应用,为解决目前传统纯化工艺的问题提供参考。