Bioproduction of hydrolytic enzymes using apple pomace waste by A. niger: applications in biocontrol formulations and hydrolysis of chitin/chitosan

Studies were carried out for β-glucosidase production using apple pomace (AP) in solid-state fermentation using 2⁴ factorial design and response surface methodology. The influence of four independent variables including initial moisture level and inducers [veratryl alcohol (VA), lactose (LAC) and copper sulfate (CS)] was studied. The experimental design showed that initial moisture level had significant negative effect on the response. Higher β-glucosidase activity of 64.18 IU/gram fermented substrate (gfs) was achieved in solid-state tray fermentation with optimum conditions having initial moisture level 55% (v/w), pH 4.5, 2 mM/kg VA, 2% (w/w) LAC and 1.5 mM/kg CS concentration, respectively,. The non-specific chitinase 70.28 ± 6.34 IU/gfs and chitosanase activities 60.18 ± 6.82 to 64.20 ± 7.12 IU/gfs were observed. The study demonstrated that AP can be potentially used for the β-glucosidase production by Aspergillus niger. Moreover, β-glucosidase can be used for the hydrolysis of chitin/chitosan to depolymerized products and in the formulation of biocontrol agents for enhanced entomotoxicity levels.     

Production of cellulases and hemicellulases by Aspergillus niger KK2 from lignocellulosic biomass

To investigate the production of cellulases and hemicellulases from Aspergillus niger KK2, solid state fermentation (SSF) was performed by using different ratios of rice straw and wheat bran. When A. niger KK2 was grown on rice straw alone as a solid support in SSF, the maximum FPase activity was 19.5 IU g(-1) in 4 days. Also, CMCase (129 IU g(-1)), beta-glucosidase (100 IU g(-1)), xylanase (5070 IU g(-1)) and beta-xylosidase (193 IU g(-1)) activities were concurrently obtained after 5-6 days of fermentation. The higher enzyme activities produced by A. niger KK2 is a significant advantage from the viewpoint of practical saccharification reaction. Cellulases and hemicellulases produced by A. niger KK2 might be applied to pulp and paper industry, feed industry and chemical industry.     

培养条件对棘孢曲霉SM-L22所产纤维素酶系组成的影响*

本文研究了影响棘孢曲霉SM-L22纤维素酶系组成的培养条件。研究结果表明,碳源、氮源和初始pH对棘孢曲霉所产生纤维素酶的内、外切酶组分的比例有明显的影响。在2%麸皮,1%CF11,0.5%尿素或含尿素的复合氮源为氮源,初始pH为4.5时,28℃培养120h后,内、外切酶的比值最大,内切酶活可达到3.1 IU/ml,FPA为0.105 IU/ml,CMCase/FPase的比值为30.6。     

Effective production of chitinase and chitosanase byStreptomyces griseus HUT 6037 using colloidal chitin and various degrees of deacetylation of chitosan

The advantages of the organismStreptomyces griseus HUT 6037 is that the chitinase and chitosanase using chitinaceouse substrate are capable of hydrolyzing both amorphous and crystalline chitin and chitosan. We attempted to investigate the optimization of induction protocol for high-level production and secretion of chitosanase and the influence of chitin and partially deacetylated chitosan sources (75–99% deactylation). The maximum specific activity of chitinase has been found at 5 days cultivation with the 48 hours induction time using colloidal chitin as a carbon source. To investigate characteristic of chitosan activity according to substrate, we used chitosan with various degree of deacetylation as a carbon source and found that this strain accumulates chitosanase in the culture medium using chitosanaceous substrates rather than chitinaceous substrates. The highest chitosanase activity was also presented on 4 days with 99% deacetylated chitosan. The partially 53% deacetylated chitosan can secrete both chitinase and chitosanase which was defined as a soluble chitosan. The specific activities of chitinase and chitosanase were 0.89 at 3 days and 1.33 U/mg protein at 5 days, respectively. It indicate that chitosanase obtained fromS. griseus HUT 6037 can hydrolyze GlcNAc-GlcN and GlcN-GlcN linkages by exo-splitting manner. This activity increased with increasing degree of deacetylation of chitosan. It is the first attempt to investigate the effects of chitosanase on various degrees of deacetylations of chitosan byS. griseus HUT 6037. The highest specific activity of chitosanase was obtained with 99% deacetylated chitosan.     

Effect of chitin sources on production of chitinase and chitosanase byStreptomyces griseus HUT 6037

The advantage of usingStreptomyces griseus HUT 6037 in the production of chitinase or chitosanase is that the organism is capable of hydrolyzing amorphous or crystal-line chitin and chitosan according to the type of the substrate used. We investigated the effects of the enzyme induction time and chitin sources, CM-chitosan and deacetylated chitosan (degree of deacetylation 75–99%), on production of chitosanase. We found that this strain accumulated chitosanase when cells were grown in the culture medium containing chitosanaceous substrates instead of chitinaceous substrates. The highest chitosanase activity was obtained at 4 days of cultivation with 99% deacetylated chitosan. Soluble chitosan (53% deacetylated chitosan) was found to induce chitinase as well as chitosanase. The specific activities of chitinase and chitosanase were 0.91 and 1.33 U/mg protein at 3 and 5 days, respectively. From the study of the enzymatic digestibility of various degrees of deacetylated chitosan, it was found that (GlcN)₃, (GlcN)₄ and (GlcN)₅ were produced during the enzymatic hydrolysis reaction. The results of this study suggested that the sugar composition of (GlcN)₃ was homogeneous and those of (GlcN)₄ and (GlcN)₅ were heterogeneous.     

培养条件对棘孢曲霉SM-L22所产纤维素酶系组成的影响

本文研究了影响棘孢曲霉SM-L22纤维素酶系组成的培养条件。研究结果表明,碳源、氮源和初始pH对棘孢曲霉所产生纤维素酶的内、外切酶组分的比例有明显的影响。在2%麸皮,1%CF11,0.5%尿素或含尿素的复合氮源为氮源,初始pH为4.5时,28℃培养120h后,内、外切酶的比值最大,内切酶活可达到3.1 IU/ml,FPA为0.105 IU/ml,CMCase/FPase的比值为30.6。     

Optimization of cellulase production by a brown rot fungus Fomitopsis sp. RCK2010 under solid state fermentation

Culture conditions for enhanced cellulase production from a newly isolated brown rot fungus, Fomitopsis sp. RCK2010 were optimized under solid state fermentation. An initial pH of 5.5 and moisture ratio of 1:3.5 (solid:liquid) were found to be optimal for maximum enzyme production. Of the different carbon sources tested wheat bran gave the maximum production of CMCase (71.526 IU/g), FPase (3.268 IU/g), and β-glucosidase (50.696 IU/g). Among the nitrogen sources, urea caused maximum production of CMCase (81.832 IU/g), where as casein and soyabean meal gave the highest FPase (4.682 IU/g) and β-glucosidase (69.083 IU/g) production, respectively. Among amino acids tested glutamic acid gave the highest production for CMCase (84.127 IU/g); however 4-hydroxy-l-proline stimulated maximum FPase production (6.762 IU/g). Saccharification of pretreated rice straw and wheat straw by crude enzyme extract from Fomitopsis sp. RCK2010 resulted in release of 157.160 and 214.044 mg/g of reducing sugar, respectively.     

Chitin/chitosan transformation by thermo-mechano-chemical treatment including characterization by enzymatic depolymerization

Chitosan, the deacetylated derivative of chitin, was until recently produced by hydrolysis in 50% (w/v) NaOH. Application of thermo-mechano-chemical technology to chitin deacetylation was evaluated as an alternative method of chitosan production. This process consists of a cascade reactor unit operating under reduced alkaline conditions of 10% (w/v) NaOH. Prior mercerization of chitin at 4 degrees C for 24 h was required for high deacetylation yields. Sudden decompression of the aqueous alkaline suspension of mercerized chitin resulted in near complete deacetylation of chitin. Reactor residence time was 90 s at 230 degrees C prior to decompression. The chitosan produced was characterized by elemental analysis, (13)C-NMR and enzymatic depolymerization. Enzymatic determination of the degree of acetylation of chitin/chitosan mixtures was also investigated. Relative chitinase and/or chitosanase digestibilities were shown to be strongly dependent on chitin deacetylation. Based on enzymatic digestibilities, the alkaline aqueous high shear process does not appear to produce significant secondary products. Correlation of chitosanase digestibility with percentage of deacetylation provides a simple biological assay to study chitosan composition.     

Chitosan depolymerization by enzymes from hepatopancreas of the crab Paralithodes camtschaticus

An enzyme preparation was isolated from the Paralithodes camtschaticus hepatopancreas that exhibited chitinase and chitosanase activities. Treatment of chitin and chitosan with this preparation decreased their viscosity-average molecular weights by 96 and 41%, respectively. The chromatographic profiles of the products of chitin and chitosan hydrolysis suggested that the crab hepatopancreas in rich in endochitinases. Enzymatic digestion of chitosan increased its solubility and moderately reduced the extent of its acetylation. A mathematical approach was proposed for calculating the molecular weights of chitosan fractions from weight-average molecular weights determined viscometrically.     

Production of multi-fiber modifying enzyme from Mamillisphaeria sp. for refining of recycled paper pulp

Enzymatic modification of pulp is receiving increasing interest for energy reduction at the refining step of the paper-making process. In this study, the production of a multi-fiber modifying enzyme from Mamillisphaeria sp. BCC8893 was optimized in submerged fermentation using a response-surface methodology. Maximal production was obtained in a complex medium comprising wheat bran, soybean, and rice bran supplemented with yeast extract at pH 6.0 and a harvest time of 7 d, resulting in 9.2 IU/mL of carboxymethyl cellulase (CMCase), 14.9 IU/mL of filter paper activity (FPase), and 242.7 IU/mL of xylanase. Treatment of old corrugated container pulp at 0.2-0.3 IU of CMCase/g of pulp led to reductions in refining energy of 8.5-14.8%. The major physical properties were retained, including tensile and compression strength. Proteomic analysis showed that the enzyme was a complex composite of endo-glucanases, cellobiohydrolases, beta-1,4-xylanases, and beta-glucanases belonging to various glycosyl hydrolase families, suggestive of cooperative enzyme action in fiber modification, providing the basis for refining efficiency.     

Chitosan Depolymerization by Enzymes from the Hepatopancreas of the Crab Paralithodes camtschaticus

An enzyme preparation was isolated from the hepatopancreas of Paralithodes camtschaticus thatexhibited chitinase and chitosanase activities. Treatment of chitin and chitosan with this preparation decreased their viscosity-average molecular weights by 96 and 41%, respectively. The chromatographic profiles of the products of chitin and chitosan hydrolysis suggested that the crab hepatopancreas is rich in endochitinases. Enzymatic digestion of chitosan increased its solubility and moderately reduced the extent of its acetylation. A mathematical approach was proposed for calculating the molecular weights of chitosan fractions from weight-average molecular weights determined viscometrically.     

The extracellular constitutive production of chitin deacetylase in Metarhizium anisopliae: possible edge to entomopathogenic fungi in the biological control of insect pests

The possible contribution of extracellular constitutively produced chitin deacetylase by Metarhizium anisopliae in the process of insect pathogenesis has been evaluated. Chitin deacetylase converts chitin, a beta-1,4-linked N-acetylglucosamine polymer, into its deacetylated form chitosan, a glucosamine polymer. When grown in a yeast extract-peptone medium, M. anisopliae constitutively produced the enzymes protease, lipase, and two chitin-metabolizing enzymes, viz. chitin deacetylase (CDA) and chitosanase. Chitinase activity was induced in chitin-containing medium. Staining of 7.5% native polyacrylamide gels at pH 8.9 revealed CDA activity in three bands. SDS-PAGE showed that the apparent molecular masses of the three isoforms were 70, 37, and 26 kDa, respectively. Solubilized melanin (10microg) inhibited chitinase activity, whereas CDA was unaffected. Following germination of M. anisopliae conidia on isolated Helicoverpa armigera, cuticle revealed the presence of chitosan by staining with 3-methyl-2-benzothiazoline hydrazone. Blue patches of chitosan were observed on cuticle, indicating conversion of chitin to chitosan. Hydrolysis of chitin with constitutively produced enzymes of M. anisopliae suggested that CDA along with chitosanase contributed significantly to chitin hydrolysis. Thus, chitin deacetylase was important in initiating pathogenesis of M. anisopliae softening the insect cuticle to aid mycelial penetration. Evaluation of CDA and chitinase activities in other isolates of Metarhizium showed that those strains had low chitinase activity but high CDA activity. Chemical assays of M. anisopliae cell wall composition revealed the presence of chitosan. CDA may have a dual role in modifying the insect cuticular chitin for easy penetration as well as for altering its own cell walls for defense from insect chitinase.     

Comprehensive studies on optimization of cellulase and xylanase production by a local indigenous fungus strain via solid state fermentation using oil palm frond as substrate

The high cost of cellulases remains the most significant barrier to the economical production of bio-ethanol from lignocellulosic biomass. The goal of this study was to optimize cellulases and xylanase production by a local indigenous fungus strain (Aspergillus niger DWA8) using agricultural waste (oil palm frond [OPF]) as substrate. The enzyme production profile before optimization indicated that the highest carboxymethyl cellulose (CMCase), filter paper (FPase), and xylanase activities of 1.06 U/g, 2.55 U/g, and 2.93 U/g were obtained on day 5, day 4, and day 5 of fermentation, respectively. Response surface methodology was used to study the effects of several key process parameters in order to optimize cellulase production. Of the five physical and two chemical factors tested, only moisture content of 75% (w/w) and substrate amount of 2.5 g had statistically significant effect on enzymes production. Under optimized conditions of 2.5 g of substrate, 75% (w/w) moisture content, initial medium of pH 4.5, 1 × 10⁶ spores/mL of inoculum, and incubation at ambient temperature (±30°C) without additional carbon and nitrogen, the highest CMCase, FPase, and xylanase activities obtained were 2.38 U/g, 2.47 U/g, and 5.23 U/g, respectively. Thus, the optimization process increased CMCase and xylanase production by 124.5 and 78.5%, respectively. Moreover, A. niger DWA8 produced reasonably good cellulase and xylanase titers using OPF as the substrate when compared with previous researcher finding. The enzymes produced by this process could be further use to hydrolyze biomass to generate reducing sugars, which are the feedstock for bioethanol production.     

Chitinolytic enzymes from<Emphasis Type="Italic">Clostridium aminovalericum</Emphasis>: Activity screening and purification

A strain isolated from the feces of takin was identified as Clostridium aminovalericum. In response to various types of chitin used as growth substrates, the bacterium produced a complete array of chitinolytic enzymes: chitinase ('endochitinase'), exochitinase, beta-N-acetylglucosaminidase, chitosanase and chitin deacetylase. The highest activities of chitinase (536 pkat/mL) and exochitinase (747 pkat/mL) were induced by colloidal chitin. Fungal chitin also induced high levels of these enzymes (463 pkat/mL and 502 pkat/mL, respectively). Crab shell chitin was the best inducer of chitosanase activity (232 pkat/mL). The chitinolytic enzymes of this strain were separated from culture filtrate by ion-exchange chromatography on the carboxylic sorbent Polygran 27. At pH 4.5, some isoforms of the chitinolytic enzymes (30% of total enzyme activity) did not bind to Polygran 27. The enzymes were eluted under a stepwise pH gradient (pH 5-8) in 0.1 mol/L phosphate buffer. At merely acidic pH (4.5-5.5), the adsorbed enzymes were co-eluted. However, at pH close to neutral values, the peaks of highly purified isoforms of exochitinases and chitinases were isolated. The protein and enzyme recovery reached 90%.     

The role of carboxyl groups on the chitosanase and CMCase activity of a bifunctional enzyme purified from a commercial cellulase with EDC modification

The carboxyl groups of the bifunctional cellulase–chitosanase (CCBE), purified from a commercial cellulase prepared from Trichoderma viride were modified using the water-soluble carbodiimide 1-ethyl-3-(3-dimethyl-aminopropyl) carbodiimide (EDC). The EDC modified CCBE lost 80–90% of its chitosnase activity and 20% of its carboxylmethyl cellulase (CMCase) activity; meanwhile, its conformation changed slightly, which altered the substrate binding affinity to chitosan, without affecting its binding to CMC. However, the modification did not alter the structure integrity. The dynamic analysis of modification indicated that the CCBE possessed two carboxylates essential for its chitosanase activity and one carboxyl group for its CMCase activity. One of the two carboxylates involved in chitosanase activity was deduced to be the proton donator, and the other may function for substrate recognition, while the only catalytic carboxyl group for CMCase activity probably also acted as a proton donator.     

Utilization of commercial non-chitinase enzymes from fungi for preparation of 2-acetamido-2-deoxy-D-glucose from beta-chitin

Commercial non-chitinase enzymes from Aspergilus niger, Acremonium cellulolyticus and Trichoderma viride were investigated for potential utilization in the preparation of 2-acetamido-2-deoxy-D-glucose (N-acetyl-D-glucosamine, GlcNAc) from chitin. Among the tested enzymes, cellulase A. cellulolyticus exhibited highest chitinolytic activity per weight toward amorphous chitin and beta-chitin from squid pen. The optimum pH of the enzyme was 3 where it produced two major hydrolytic products, GlcNAc and N,N'-diacetylchitobiose ([GlcNAc](2)). The product ratio, GlcNAc:[GlcNAc](2), increased while the total yield decreased as the pH was raised from 3. All of the [GlcNAc](2) produced at pH 3 can be converted in situ to GlcNAc by mixing cellulase A. cellulolyticus with one of several other enzymes from A. niger resulting in a higher yield of GlcNAc. An appropriate mixing ratio of cellulase A. cellulolyticus to another enzyme was 9:1 (w/w) and an optimum substrate concentration was 20 mg/mL.     

Effect of Host Diet and Hindgut Microbial Composition on Cellulolytic Activity in the Hindgut of the American Cockroach, Periplaneta americana

Cellulase activity measured as filter paper digesting activity (FPase) and carboxymethyl cellulase (CMCase) was demonstrated in hindgut extracts of the cockroach Periplaneta americana. The highest activities measured amounted to 0.89 and 0.12 U · ml^-1 for CMCase and FPase, respectively. The cellulolytic capacity of the hindgut population increased dramatically when protozoa were present, and the activities were found to vary depending on the feeding regimen. Cellulose-rich diets induced high protozoal numbers, resulting in a high cellulase activity. A close correlation was found between the number of Nyctotherus ovalis organisms, the major protozoans in the hindgut, and both FPase and CMCase activity. Since the numbers of this protozoan also correlated with the methane production of the insect, it appears that N. ovalis is responsible for the major part of cellulolytic and methanogenic activity found in the hindgut of P. americana.     

Polarized light-stimulated enzymatic hydrolysis of chitin and chitosan

Illumination with white linearly polarized light (WLPL) stimulated chitinase and chitosanase in their degradation of chitin and chitosan, respectively. Enzymes were illuminated at room temperature in separate vessels, then admixed in reactors containing polysaccharides. Hydrolysis of chitosan to glucosamine followed first order kinetics whereas hydrolysis of chitin to N-acetylglucosamine deviated from the first order kinetics. In both cases, an increase in the rate of hydrolysis depended on the illumination time. Efficient degradation required up to 60 min exposure of the enzyme to WLPL.     

Cost-effective production of cellulose hydrolysing enzymes from <Emphasis Type="Italic">Trichoderma</Emphasis> sp. RCK65 under SSF and its evaluation in saccharification of cellulosic substrates

Trichoderma sp. is a potential cellulase producing mesophilic fungi which grow under mild acidic condition. In this study, growth and nutritional conditions were manipulated for the maximum and cost-effective production of cellulase using lab strain Trichoderma sp. RCK65 and checked for its efficiency in hydrolysis of Prosopis juliflora (a woody substrate). Preliminary studies suggested that when 48 h old secondary fungal culture (20 % v/w) was inoculated in wheat bran moistened with mineral salt solution (pH 4.5 and 1:3 solid to moisture ratio), incubated at 30 °C and after 72 h, it produced maximum cellulase (CMCase 145 U/gds, FPase 38 U/gds and β-glucosidase 105 U/gds). However, using statistical approach a S:L ratio (1:1) was surprisingly found to be optimum that improved cellulase that is CMCase activity by 6.21 %, FPase activity by 23.68 % and β-glucosidase activity by 37.28 %. The estimated cost of crude enzyme (Rs. 5.311/1000 FPase units) seems to be economically feasible which may be due to high enzyme titre, less cultivation time and low media cost. Moreover, when the crude enzyme was used to saccharify pretreated Prosopis juliflora (a woody substrate), it resulted up to 83 % (w/w) saccharification.     

Semicontinuous enzymatic hydrolysis of lignocelluloses

Lignocelluloses (steamed hardwood and hardwood kraft pulp) were semicontinuously hydrolyzed on a large scale [2-2. 5 kg of substrate vs. 20, 000 IU filter paperase (FPase)] using a 10-L hydrolysis reactor with an ultrafiltration unit for the recovery and reuse of cellulases. The substrate was added to the reactor at appropriate intervals to keep a concentration of approximately 5% (w/v). All of the enzyme was added at the beginning and no further addition was done. The ultrafiltration unit was operated intermittently rather than continuously due to its enough capacity (dilution rate of 2.5 h(-1)) and making the enzyme durable. The enzyme required to produce one gram of reducing sugar in this reactor was 27.3 FPase IU/g RS for steamed hardwood and 7.4 FPase IU/g RS for hardwood kraft pulp. The sugar composition of hydrolyzate was unaltered virtually from beginning to end of the hydrolysis in spite of the progressive loss of enzyme activities. The analysis of the enzyme composition in the hydrolyzate during hydrolysis revealed that an exo-beta-D-glucanase component was adsorbed selectively at the stages of advanced hydrolysis extent.