聚乙烯醇-明胶复合膜固定化重组大肠杆菌NAD激酶的研究

为提高烟酰胺腺嘌呤二核苷酸(NAD)激酶的稳定性,采用复合膜对NAD激酶进行固定化研究。选用聚乙烯醇(PVA)、聚乳酸(PLA)、海藻酸钠(SA)和明胶(GEL)膜材料固定化NAD激酶。通过单因素实验确定最佳固定化条件为:PVA∶GEL为4∶1,加酶量为0.6 mL,固定化时间为6h,固定化温度为35℃,此时酶活力回收率达到最高值84%。固定化酶酶学性质分析结果表明,与游离酶进行比较,固定化后NAD激酶的最适温度由50℃提高至55℃,最适pH由8.0降至7.0,NAD激酶的热稳定性和pH稳定性均得到显著提高,但固定化酶的亲和力降低。固定化NAD激酶重复利用6次后,酶活性依然可维持初始酶活性的75%以上,表明聚乙烯醇-明胶复合膜固定化酶具有良好的操作稳定性。     

Continuous production of urocanic acid by immobilized Achromobacter liquidum cells

Several microorganisms having higher L -histidine ammonia-lyase activity were immobilized into polyacrylamide gel lattice. The yield of enzyme activity by immobilization was highest in Achromobacter liquidum IAM 1667. As A. liquidum has urocanase activity, the cells were heat-treated at 70°C for 30 min to inactivate the urocanase. Enzymatic properties of the immobilized A. liquidum cells were investigated and compared with those of the intact cells. No difference was observed between the pH activity curve and optimal temperature for the intact and immobilized cells. The permeability of substrate or product through the cell wall was increased by immobilization of the cells. When an aqueous solution of 0.25M L -histidine (pH 9.0) containing 1mM Mg²⁺ was passed through a column packed with the immobilized A. liquidum cells at a flow rate of SV = 0.06 at 37°C, L -histidine was completely converted to urocanic acid. The L -histidine ammonia-lyase activity of the immobilized cell column was stable over 40 days at 37°C. From the effluent of the immobilized cell column, Urocanic acid was easily obtained in a good yield.     

Enzymatic properties of immobilized Alcaligenes faecalis cells with cell-associated beta-glucosidase activity

Enzymatic properties of Alcaligenes faecalis cells immobilized in polyacrylamide were characterized and compared with those reported for the extracted enzyme, and with those measured for free cells. Many of the properties reflected those of the extracted enzyme rather than those measured in the free whole cells prior to immobilization, suggesting cell disruption during immobilization. These properties included the pH activity profile, a slightly broader pH stability profile, and the activation energy. Electron micrographs showed evidence of cell debris among the polymer matrix. The immobilized cells were not viable, and did not consume glucose. Thermal stability was less after immobilization with a half-life of 16 h at 45 degrees C, and 3.5 h at 50 degrees C. The immobilized preparation was more stable when stored lyophilized rather than in buffer, losing 23 and 52% activity, respectively, after six months. The enzyme was irreversibly inhibited by both acetate and citrate buffers. If the immobilized enzyme is to be used in conjunction with cellulases from Trichoderma reesei for cellulase saccharification, the optimal conditions would be pH 5.5 and 45 degrees C in a buffer containing no carboxylic acid groups.     

Immobilized Aspartase-Containing Microbial Cells: Preparation and Enzymatic Properties

The immobilization of asparatase-containing Escherichia coli was investigated by various methods, and the most active immobilized cells were obtained by entrapment in a polyacrylamide gel lattice. Other asparatase-containing bacteria were also entrapped by the same method, and the enzymatically active immobilized cells were obtained. The aspartase activity of the immobilized E. coli cells was increased nine- to tenfold by autolysis of the cells entrapped in the gel lattice. Enzymatic properties of the immobilized E. coli cells were investigated and compared with those of the intact cells. The optimal pH was 8.5 for the immobilized cells and 10.5 for the intact cells. The aspartase activities of immobilized and intact cells were not activated by Mn(2+), which can activate the immobilized and native aspartases. The heat stability of the immobilized cells was somewhat higher than that of the intact cells. Bivalent metal ions such as Mn(2+), Mg(2+), Ca(2+) protected against thermal inactivation of the aspartase activity of the immobilized and intact cells.     

Glycolytic pathway as an ATP generation system and its application to the production of glutathione and NADP

Efficient ATP generation is required to produce glutathione and NADP. Hence, the generation of ATP was investigated using the glycolytic pathway of yeast. Saccharomyces cerevisiae cells immobilized using polyacrylamide gel generated ATP from adenosine, consuming glucose and converting it to ethanol and carbon dioxide. Under optimal conditions, the ATP-generating activity of immobilized yeast cells was 7.0 μmol h^?1 ml^?1 gel. A column packed with these immobilized yeast cells was used for continuous ATP generation. The half-life of the column was 19 days at a space velocity of (SV) 0.3 h^?1 at 30°C. The properties of glutathione- and NADP-producing reactions coupled with the ATP-generating reaction were investigated. Escherichia coli cells with glutathione synthesizing activity and Brevibacterium ammoniagenes cells with NAD kinase activity were immobilized in a polyacrylamide gel lattice. Under optimal conditions, the immobilized E. coli cells and immobilized B. ammoniagenes cells produced glutathione and NADP at the rates of 2.1 and 0.65 μmol h^?1 ml^?1 gel, respectively, adding ATP to the reaction mixture. In order to produce glutathione and NADP economically and efficiently, the glutathione- and NADP-producing reactions were finally coupled with the ATP-generating reaction catalysed by immobilized S. cerevisiae cells. To compare the productivities of glutathione and NADP, and to compare the efficiency of ATP utilization for the production of these two compounds, the two reactor systems, co-immobilized cell system and mixed immobilized cell system, were designed. As a result, these two compounds were also found to be produced by these two kinds of reactor systems. Using the data obtained, the feasibility and properties of ATP generation by immobilized yeast cells are discussed in terms of the production of glutathione and NADP.     

Preparations of immobilized lysozyme with reversibly soluble polymer for hydrolysis of microbial cells

Hen egg white lysozyme was immobilized by carbodiimide method to form amide bonds with a polymer (AS-L) showing reversibly soluble-insoluble characteristics with pH change. The immobilized enzyme (LY-AS) was soluble above pH 6 and precipitate below pH 4.5, offering advantages in that it can carry out hydrolysis of microbial cells in a soluble form yet be recovered after precipitation at low pH. The maximum specific activity of LY-AS was 66% of that of free lysozyme with M. lysodeikticus cells as substrate, which is much higher than the values reported in the literature using water-insoluble materials as carriers. The effects of pH and temperature on the activity of LY-AS were studied and compared with those of free lysozyme. With repeated pH cycles between 6.6 and 4.5, the operation half-life of immobilized enzyme activity was nine cycles. Repeated batch lysis of microbial cells could be carried out with intermittent enzyme precipitation and recovery steps. In such an operation the insoluble residual cells should be recovered together with the immobilized enzyme to minimize enzyme loss arising from adsorption to cells.     

NADP+ production using thermostable NAD+ kinase of corynebacterium flaccumfaciens AHU-1622

A sonicate of Corynebacterium flaccumfaciens AHU-1622 had the highest NAD+ kinase activity (1.22 mU/mL culture broth) of the strains of bacteria we investigated. This enzyme was thermostable, with activity maintained at 50 degrees C for 1 h. This treatment inactivated phosphatase activity. Resting cells of the bacterium also had NAD+ kinase activity when treated at 60 degrees C for 30 min with 0.2% Triton X-100. NADP+ production was achieved using 8 mumol NAD+, 8 mumol ATP, 16 mumol MgCl2, 1.6 mumol NaN3, and 12 mU NAD+ kinase (0.1 g of permeabilized wet cells) in 2 mL of 0.1 M phosphate buffer, pH 7.5. The conversion ratio of NADP+ from NAD+ was 75% after 10 h of incubation at 50 degrees C, and the amount of accumulated NADP+ was 3 mumol/mL of reaction mixture. The NAD+ kinase activity of the permeabilized cells was stable and did not decrease after repeated use.     

Continuous production of 6-aminopenicillanic acid from penicillin by immobilized microbial cells

Summary For continuous production of 6-aminopenicillanic acid (6-APA) the microbial cells ofEscherichia coli ATCC 9637 having high penicillin amidase (penicillin amidohydrolase, E.C. 3. 5. 1. 11) activity were immobilized by entrapment in a polyacrylamide gel lattice.Enzymatic properties of penicillin amidase of the immobilizedE. coli cells were investigated and compared with those of the intact cells. With regard to optimal pH and temperature, no marked difference was observed. The heat stability was somewhat increased by immobilization of the cells.The enzyme activity of the immobilized cell column was stable, and its half-life was 17 days at 40°C and 42 days at 30°C. From the effluent of the column, 6-APA was easily obtained in a good yield.Abbreviations 6-APA 6-aminopenicillanic acid - BIS N,N-methylenebisacrylamide - DMAPN -dimethylaminopropionitrile - SV space velocity     

Production of NADP by immobilized cells with NAD kinase

By the radiation-copolymerization method with polyethylene glycoldimethacrylate (PGD) as a main polymerizable reagent, microbial cells of Brevibacterium ammoniagenes were immobilized with high specific activity of NAD kinase and high mechanical strength. The reagents used for the immobilization such as PGD, polyvinyl alcohol (PVA), and N,N'-methylenebisacrylamide (Bis) did not inversely affect the enzyme activity. Freezing and irradiation treatment of the cell-reagent solution did not inactivate the enzyme either, but longer freezing time or a lower irradiation dose (less than 400 krad) resulted in the unsatisfactory mechanical strength of the immobilized cells. Almost all of NAD and ATP consumed were converted into NADP within three hours reaction time. The drum reactor was found to be ideal for the reaction of immobilized cells, since it gave little mechanical stress to the immobilized cells for the effective mixing of the cells and the substrates. The immobilized cells were subjected to three hours reaction repeatedly for 30 times without any activity loss.     

Immobilization of Escherichia coli cells containing aspartase activity with kappa-carrageenan. Enzymic properties and application for L-aspartic acid production.

Whole cells of Escherichia coli having high aspartase (L-asparate ammonialyase, EC 4.3.1.1) activity were immobilized by entrapping into a kappa-carrageenan gel. The obtained immobilized cells were treated with glutaraldehyde or with glutaraldehyde and hexamethylenediamine. The enzymic properties of three immobilized cell preparations were investigated, and compared with those of the soluble aspartate. The optimum pH of the aspartase reaction was 9.0 for the three immobilized cell preparations and 9.5 for the soluble enzyme. The optimum temperature for three immobilized cell preparations was 5--10 degrees C higher than that for the soluble enzyme. The apparent Km values of immobilized cell preparations were about five times higher than that of the soluble enzyme. The heat stability of intact cells was increased by immobilization. The operational stability of the immobilized cell columns was higher at pH 8.5 than at optimum pH of the aspartase reaction. From the column effluents, L-aspartic acid was obtained in a good yield.     

NADH production from NAD+ with a formate dehydrogenase system involving immobilized cells of a methylotrophic Arthrobacter strain.

A convenient and economical method of NADH production from NAD+ has been established using a formate dehydrogenase system involving immobilized cells of a methanol-utilizing bacterium. Arthrobacter sp, KM62. Four kinds of cell entrapment were studied. An immobilized cell preparation showing a high NADH production activity was obtained by entrapment in a kappa-carrageenan gel lattice. The NADH-producing activity of the immobilized cells was investigated under various conditions. The NADH-producing activity was evoked on the addition of Triton X-100 to the reaction mixture. The conditions for the continuous production of NADH with an immobilized cell column were also investigated. When a reaction mixture containing 10 mumol (6.63 mg) ml-1 NAD+ was passed through the column (1.2 x 20 cm) containing 1.62 g (as dry weight) of immobilized cells, at a space velocity of 0.125 at 35 degrees C, complete conversion was attained.     

Regeneration of NADH in a bioreactor using yeast cells immobilized in alginate fiber: I. Method and effect of reactor variables

Saccharomyces cerevisiae cells immobilized in a calcium alginate fiber reactor were used as a source of alcohol dehydrogenase for the NAD(+)-to-NADH reaction. The reaction was catalyzed by enzyme in cells on the surface of the fiber. Internal diffusional effects were present. The enzyme cell concentration was optimized by harvesting cells finally grown under anaerobic conditions. The results were expressed as an apparent reaction rate constant that was independent of NAD(+) and excess ethanol concentration, was slightly affected by flow rate above a minimum value, and increased with immobilized cell concentration in the fiber. The reaction was complete after 6 to 7 h under optimal conditions of 36 degrees C and 9.5 pH. The latter was 0.5 pH units above the free enzyme optimum, indicating that microenvironmental effects were in evidence. (c) 1993 John Wiley & Sons, Inc.     

嗜热脂肪地芽孢杆菌NAD激酶克隆表达及酶学性质研究

NAD激酶能催化NAD生成NADP。本研究采用PCR技术从嗜热脂肪地芽孢杆菌基因组中获得NAD激酶基因,以pET30a（＋）为表达载体、E．coliBL21（DE3）为宿主菌,实现其在大肠杆菌中异源表达,并进行酶学性质研究。结果显示,嗜热脂肪地芽孢杆菌中NAD激酶编码基因大小为816bp,酶分子量大约为35kD。酶学性质分析表明,来源于嗜热脂肪地芽孢杆菌的NAD激酶最适反应温度和pH分别为35℃、pH7．5,在35qC中保温2h后仍能保持80％左右的活性。Mn2＋、Ca2＋对该酶有较强的激活作用,在最适反应条件下该酶的比活力为4．43U／mg。动力学性质分析结果显示NAD激酶对底物NAD催化的k和圪。,分别为1．46mmol／L和0．25tzmol／（L·min）。NAD激酶在大肠杆菌的异源表达为以NAD为底物生物合成NADP提供了更多生物资源。     

In vivo inactivation of glycerol dehydrogenase in Klebsiella aerogenes: properties of active and inactivated proteins.

Glycerol:oxidized nicotinamide adenine dinucleotide (NAD+) 2-oxidoreductase (EC 1.1.1.6), an inducible enzyme for anaerobic glycerol catabolism in Klebsiella aerogenes, was purified and found to have a molecular weight of 79,000 by gel electrophoresis. The protein seemed to be enzymatically active either as a dimer of a 40,000-dalton peptide at pH 8.6 or as a tetramer of 160,000 molecular weight at pH 7.0. The enzyme activity was present at high levels in cells growing anaerobically on glycerol, but disappeared with a half-life of about 45 min if molecular oxygen was introduced to the culture. In contrast, no such phenomenon occurred with dihydroxyacetone kinase activity, the second enzyme in the pathway. Immunochemical analysis showed that the inactivation of the oxidoreductase did not involve degradation of the protein. Furthermore, subunits of the active and inactive forms of the enzyme were indistinguishable in size on polyacrylamide gel electrophoresis in the presence of sodium dodecyl sulfate and had similar isoelectric points (pH 4.7). Inactivation did, however, alter the gel filtration properties of the enzyme protein and, more importantly, reduced its affinity for the dye Cibacron F3GA and the coenzyme NAD+.     

Enhancement of starch conversion efficiency with free and immobilized pullulanase and alpha-1,4-glucosidase

Glucoamylase and pullulanase were immobilized on reconstituted bovine-hide collagen membranes using the covalent azide linkage method. A pretanning step was incorporated into the immobilization procedure to enable the support matrix to resist proteolytic activity while accommodating an operating temperature of 50 degrees C. The immobilized glucoamylase and pullulanase activities were 0.91 and 0.022 mg dextrose equivalent (DE) min(-1) cm(-2) of membrane, respectively. Immobilized glucoamylase had a half-life of 50 days while the immobilized pullulanase had a half-life of 7 days. This is a considerably improved stability over that reported by other researchers. The enzymes were studied in their free and immobilized forms on a variety of starch substrates including waxy maize, a material which contains 80% alpha-1-6-glucosidic linkages. Substrate concentrations ranged from 1% to a typical commercial concentration of 30%. Conversion efficiencies of 90-92% DE were obtained with free and immobilized glucoamylase preparations. Conversion enhancements of 4-5 mg of DE above this level were obtained by the use of pullulanase in its free or immobilized forms. Close examination of free pullulanase stability as a function of pH indicated improved thermal stability at higher pH values. At 50 degrees C and pH 5.0, the free enzyme was inactivated after 24 h. At pH 7.0, the enzyme still possessed one-half its activity after 72 h. Studies were conducted in both batch and continuous total recycle reactors. All experiments were conducted at 50 degrees C. Experiments conducted with coimmobilized enzymes proved quite promising. Levels of conversion equivalent to those obtained with the individually immobilized enzymes were realized.     

Effect of aluminium on the NAD+ kinase activity of Euglena gracilis grown heterotrophically

The effect of 2 mM AlCl3 on NAD+ kinase (E.C. 2.7.1.23) activity was studied using Euglena gracilis strain Z grown heterotrophically in darkness at pH 3.5 in the presence of lactate as sole carbon source. The Al-treatment slowed down the culture growth and suppressed the peak of NAD+ kinase activity, which characterizes the beginning of the exponential phase of growth of the control cell cultures. There are two possible explanations of the Al effect: it 1) either prevents the enzyme activation by the Ca-calmodulin (CaM) complex; or 2) suppresses the CaM-dependent NAD+ kinase form. In Euglena cells, a part of the NAD+ kinase activity is enhanced by EGTA and lowered by Ca2+: this peculiar NAD+ kinase activity is unaffected by the Al treatment. This revised version was published online in July 2006 with corrections to the Cover Date.     

Overexpression, purification, and characterization of ATP-NAD kinase of Sphingomonas sp. A1

The NAD kinase gene (nadK) of Sphingomonas sp. A1 was cloned and then overexpressed in Escherichia coli, and the gene product (NadK) was purified from the E. coli cells through five steps with a 25% yield of activity. NadK was a homodimer of 32 kDa subunits, utilized ATP or other nucleoside triphosphates, but not inorganic polyphosphates, as phosphoryl donors for the phosphorylation of NAD, most efficiently at pH 8.0 and 50-55 degrees C, and was designated as ATP-NAD kinase (NadK). NadK showed no NADH kinase activity and was slightly inhibited by NADP(H). Precursors for NAD biosynthesis such as quinolinic acid, nicotinic acid mononucleotide, nicotinic acid adenine dinucleotide, and nicotinic acid had no effect on the NadK activity, as observed in the cases of the NAD kinases of Micrococcus flavus, Mycobacterium tuberculosis, and E. coli. Taken together with the report that the NAD kinase of Bacillus subtilis is activated by quinolinic acid [J. Bacteriol. 185 (2003) 4844], it is indicated that the regulatory patterns of NAD kinases differ even among bacterial NAD kinases.     

Semicontinuous and continuous production of penicillin-G by Penicillium chrysogenum cells immobilized in kappa-carrageenan beads

Conidia of Penicillium chrysogenum were immobilized in K-carrageenan beads and then incubated in a growth-supporting medium to yield a penicillin producing immobilized cell mass. These in situ grown immobilized cells were used for the semicontinuous (replacement cultures)and continuous (fluidized bioreactor culture) production of penicillin-G. When periodically replaced into a minimal production medium, immobilized cells exhibited a half-life for penicillin production which was ninefold greater than that exhibited by free cells. The half-life of penicillin production and the yield of penicillin from glucose in such a replacement culture were greatly affected by the frequency of replacement and by the production medium's pH and concentration of glucose, phosphate, and trace metal nutrients. A penicillin-producing continuous flow bioreactor (150 mL), employing immobilized cells, was operated for up to 16 days. The best specific penicillin productivity (1.2 mg/g cells/h)yield from glucose (7.0 mg/g glucose) and half-life of production (15 days) were obtained when the feed medium contained 10 g/L of glucose, the pH was maintained at 7.0, the relative dissolved oxygen concentration was ca. 40%; and the residence time was 20 h.     

Characterization and immobilization on nickel-chelated Sepharose of a glutamate decarboxylase A from Lactobacillus brevis BH2 and its application for production of GABA

A gene encoding glutamate decarboxylase A (GadA) from Lactobacillus brevis BH2 was expressed in a His-tagged form in Escherichia coli cells, and recombinant protein exists as a homodimer consisting of identical subunits of 53?kDa. GadA was absolutely dependent on the ammonium sulfate concentration for catalytic activity and secondary structure formation. GadA was immobilized on the metal affinity resin with an immobilization yield of 95.8%. The pH optima of the immobilized enzyme were identical with those of the free enzyme. However, the optimum temperature for immobilized enzyme was 5?°C higher than that for the free enzyme. The immobilized GadA retained its relative activity of 41% after 30 reuses of reaction within 30?days and exhibited a half-life of 19 cycles within 19?days. A packed-bed bioreactor with immobilized GadA showed a maximum yield of 97.8% GABA from 50?mM l-glutamate in a flow-through system under conditions of pH 4.0 and 55?°C.     

Topography, purification and characterization of thyroidal NAD+ glycohydrolase

Subcellular fractionation of bovine thyroid tissue by differential pelleting and isopycnic gradient centrifugation in a zonal rotor indicated that NAD(+) glycohydrolase is predominantly located and rather uniformly distributed in the plasma membrane. Comparison of NAD(+) glycohydrolase activities of intact thyroid tissue slices, functional rat thyroid cells in culture (FRT(l)) and their respective homogenates indicated that most if not all of the enzyme (catalytic site) is accessible to extracellular NAD(+). The reaction product nicotinamide was predominantly recovered from the extracellular medium. The diazonium salt of sulphanilic acid, not penetrating into intact cells, was able to decrease the activity of intact thyroid tissue slices to the same extent as in the homogenate. Under the same conditions this reagent almost completely abolished NAD(+) glycohydrolase activity associated with intact thyroid cells in culture. The triazine dye Cibacron Blue F3GA and its high-M(r) derivative Blue Dextran respectively completely eliminated or caused a severe depression in the NAD(+) glycohydrolase activity of FRT(l) cells. The enzyme could be readily solubilized from bovine thyroid membranes by detergent extraction, and was further purified by gel filtration and affinity chromatography on Blue Sepharose CL-6B. The overall procedure resulted in a 1940-fold purification (specific activity 77.6mumol of nicotinamide released/h per mg). The purified enzyme displays a K(m) of 0.40mm for beta-NAD(+), a broad pH optimum around pH7.2 (0.1 m-potassium phosphate buffer) and an apparent M(r) of 120000. Nicotinamide is an inhibitor (K(i) 1.9mm) of the non-competitive type. The second reaction product ADP-ribose acts as a competitive inhibitor (K(i) 2.7mm). The purified enzyme splits beta-NAD(+), beta-NADP(+), beta-NADH and alpha-NAD(+) at rates in the relative proportions 1:0.75:<0.02:<0.02 and exhibits transglycosidase (pyridine-base exchange) activity. Anionic phospholipids such as phosphatidylinositol and phosphatidylserine inhibit the partially purified enzyme. A stimulating effect was observed upon the addition of histones.