<Emphasis Type="SmallCaps">d</Emphasis>-Psicose production from <Emphasis Type="SmallCaps">d</Emphasis>-fructose using an isolated strain, <Emphasis Type="Italic">Sinorhizobium</Emphasis> sp.

Sinorhizobium sp., which can convert d-fructose into d-psicose, was isolated from soil. The optimal pH, temperature, and cell concentration for d-psicose production with the isolated strain were 8.5, 40°C, and 60 mg/ml, respectively. The toluene-treated cells showed 2.5- and 4.8-fold increases in the d-psicose concentration and productivity compared with untreated washed cells. Under the optimal conditions, the toluene-treated cells produced 37 g d-psicose/l from 70% (w/v) (3.9 M) d-fructose after 15 h.     

Highly efficient production of <Emphasis Type="SmallCaps">d</Emphasis>-lactic acid from chicory-derived inulin by <Emphasis Type="Italic">Lactobacillus bulgaricus</Emphasis>

Inulin is a readily available feedstock for cost-effective production of biochemicals. To date, several studies have explored the production of bioethanol, high-fructose syrup and fructooligosaccharide, but there are no studies regarding the production of d-lactic acid using inulin as a carbon source. In the present study, chicory-derived inulin was used for d-lactic acid biosynthesis by Lactobacillus bulgaricus CGMCC 1.6970. Compared with separate hydrolysis and fermentation processes, simultaneous saccharification and fermentation (SSF) has demonstrated the best performance of d-lactic acid production. Because it prevents fructose inhibition and promotes the complete hydrolysis of inulin, the highest d-lactic acid concentration (123.6 ± 0.9 g/L) with a yield of 97.9 % was obtained from 120 g/L inulin by SSF. Moreover, SSF by L. bulgaricus CGMCC 1.6970 offered another distinct advantage with respect to the higher optical purity of d-lactic acid (>99.9 %) and reduced number of residual sugars. The excellent performance of d-lactic acid production from inulin by SSF represents a high-yield method for d-lactic acid production from non-food grains.     

Improvement of <Emphasis Type="SmallCaps">d</Emphasis>-lactate productivity in recombinant <Emphasis Type="Italic">Escherichia coli</Emphasis> by coupling production with growth

Coupling lactate fermentation with cell growth was investigated in shake-flask and bioreactor cultivation systems by increasing aeration to improve lactate productivity in Escherichia coli CICIM B0013-070 (ackA pta pps pflB dld poxB adhE frdA). In shake-flasks, cells reached 1 g dry wt/l then, cultivated at 100 rpm and 42°C, achieved a twofold higher productivity of lactic acid compared to aerobic and O₂-limited two-phase fermentation. The cells in the bioreactor yielded an overall volumetric productivity of 5.5 g/l h and a yield of 86 g lactic acid/100 g glucose which were 66% higher and the same level compared to that of the aerobic and O₂-limited two-phase fermentation, respectively, using scaled-up conditions optimized from shake-flask experiments. These results have revealed an approach for improving production of fermentative products in E. coli.     

Fermentation of <Emphasis Type="SmallCaps">d</Emphasis>-glucose and <Emphasis Type="SmallCaps">d</Emphasis>-xylose mixtures by <Emphasis Type="Italic">Candida tropicalis</Emphasis> NBRC 0618 for xylitol production

The fermentation of d-glucose and d-xylose mixtures by the yeast Candida tropicalis NBRC 0618 has been studied under the most favourable operation conditions for the culture, determining the most adequate initial proportion in these sugars for xylitol production. In all the experiments a synthetic culture medium was used, with an initial total substrate concentration of 25 g L⁻¹, a constant pH of 5.0 and a temperature of 30 °C. From the experimental results, it was deduced that the highest values of specific rates of production and of overall yield in xylitol were achieved for the mixtures with the highest percentage of d-xylose, specifically in the culture with the initial d-glucose and d-xylose concentrations of 1 and 24 g L⁻¹, respectively, with an overall xylitol yield of 0.28 g g⁻¹. In addition, the specific rates of xylitol production declined over the time course of the culture and the formation of this bioproduct was favoured by the presence of small quantities of d-glucose. The sum of the overall yield values in xylitol and ethanol for all the experiments ranged from 0.26 to 0.56 g bioproduct/g total substrate.     

Membrane-bound <Emphasis Type="SmallCaps">l</Emphasis>- and <Emphasis Type="SmallCaps">d</Emphasis>-lactate dehydrogenase activities of a newly isolated <Emphasis Type="Italic">Pseudomonas stutzeri</Emphasis> strain

Pseudomonas stutzeri SDM was newly isolated from soil, and two stereospecific NAD-independent lactate dehydrogenase (iLDH) activities were detected in membrane of the cells cultured in a medium containing dl-lactate as the sole carbon source. Neither enzyme activities was constitutive, but both of them might be induced by either enantiomer of lactate. P. stutzeri SDM preferred to utilize lactate to growth, when both l-lactate and glucose were available, and the consumption of glucose was observed only after lactate had been exhausted. The Michaelis–Menten constant for l-lactate was higher than that for d-lactate. The l-iLDH activity was more stable at 55°C, while the d-iLDH activity was lost. Both enzymes exhibited different solubilization with different detergents and different oxidation rates with different electron acceptors. Combining activity staining and previous proteomic analysis, the results suggest that there are two separate enzymes in P. stutzeri SDM, which play an important role in converting lactate to pyruvate. Ma and Gao contributed equally to this work.     

<Emphasis Type="SmallCaps">d</Emphasis>-Hexosaminate production by oxidative fermentation

Microbial production of d-hexosaminate was examined by means of oxidative fermentation with acetic acid bacteria. In most strains of acetic acid bacteria, membrane-bound d-glucosamine dehydrogenase (synonymous with an alternative d-glucose dehydrogenase distinct from quinoprotein d-glucose dehydrogenase) oxidized d-hexosamines to the corresponding d-hexosaminates in a stoichiometric manner. Conversion of d-hexosamines to the corresponding d-hexosaminates was observed with growing cells of acetic acid bacteria, and d-hexosaminate was stably accumulated in the culture medium even though d-hexosamine was exhausted. Since the enzyme responsible is located on the outer surface of the cytoplasmic membrane, and the enzyme activity is linked to the respiratory chain of the organisms, resting cells, dried cells, and immobilized cells of acetic acid bacteria were effective catalysts for d-hexosaminate production. d-Mannosaminate and d-galactosaminate were also prepared for the first time by means of oxidative fermentation, and three different d-hexosaminates were isolated from unreacted substrate by a chromatographic separation. In this paper, d-hexosaminate production by oxidative fermentation carried out mainly with Gluconobacter frateurii IFO 3264 is exemplified as a typical example.     

Characterization of <Emphasis Type="SmallCaps">d</Emphasis>-tagatose-3-epimerase from <Emphasis Type="Italic">Rhodobacter sphaeroides</Emphasis> that converts <Emphasis Type="SmallCaps">d</Emphasis>-fructose into <Emphasis Type="SmallCaps">d-</Emphasis>psicose

A non-characterized gene, previously proposed as the d-tagatose-3-epimerase gene from Rhodobacter sphaeroides, was cloned and expressed in Escherichia coli. Its molecular mass was estimated to be 64 kDa with two identical subunits. The enzyme specificity was highest with d-fructose and decreased for other substrates in the order: d-tagatose, d-psicose, d-ribulose, d-xylulose and d-sorbose. Its activity was maximal at pH 9 and 40°C while being enhanced by Mn²⁺. At pH 9 and 40°C, 118 g d-psicose l⁻¹ was produced from 700 g d-fructose l⁻¹ after 3 h. Electronic supplementary material  The online version of this article (doi:) contains supplementary material, which is available to authorized users.     

Continuous <Emphasis Type="SmallCaps">d</Emphasis>-lactic acid production by a novelthermotolerant <Emphasis Type="Italic">Lactobacillus delbrueckii</Emphasis> subsp. <Emphasis Type="Italic">lactis</Emphasis> QU 41

We isolated and characterized a d-lactic acid-producing lactic acid bacterium (d-LAB), identified as Lactobacillus delbrueckii subsp. lactis QU 41. When compared to Lactobacillus coryniformis subsp. torquens JCM 1166 ^T and L. delbrueckii subsp. lactis JCM 1248 ^T, which are also known as d-LAB, the QU 41 strain exhibited a high thermotolerance and produced d-lactic acid at temperatures of 50 °C and higher. In order to optimize the culture conditions of the QU 41 strain, we examined the effects of pH control, temperature, neutralizing reagent, and initial glucose concentration on d-lactic acid production in batch cultures. It was found that the optimal production of 20.1 g/l d-lactic acid was acquired with high optical purity (>99.9% of d-lactic acid) in a pH 6.0-controlled batch culture, by adding ammonium hydroxide as a neutralizing reagent, at 43 °C in MRS medium containing 20 g/l glucose. As a result of product inhibition and low cell density, continuous cultures were investigated using a microfiltration membrane module to recycle flow-through cells in order to improve d-lactic acid productivity. At a dilution rate of 0.87 h⁻¹, the high cell density continuous culture exhibited the highest d-lactic acid productivity of 18.0 g/l/h with a high yield (ca. 1.0 g/g consumed glucose) and a low residual glucose (<0.1 g/l) in comparison with systems published to date.     

Characterization of ribose-5-phosphate isomerase of <Emphasis Type="Italic">Clostridium thermocellum</Emphasis> producing <Emphasis Type="SmallCaps">d</Emphasis>-allose from <Emphasis Type="SmallCaps">d</Emphasis>-psicose

The rpiB gene, encoding ribose-5-phosphate isomerase (RpiB) from Clostridium thermocellum, was cloned and expressed in Escherichia coli. RpiB converted d-psicose into d-allose but it did not convert d-xylose, l-rhamnose, d-altrose or d-galactose. The production of d-allose by RpiB was maximal at pH 7.5 and 65°C for 30 min. The half-lives of the enzyme at 50°C and 65°C were 96 h and 4.7 h, respectively. Under stable conditions of pH 7.5 and 50°C, 165 g d-allose l⁻¹ was produced without by-products from 500 g d-psicose l⁻¹ after 6 h.     

Strain improvement of <Emphasis Type="Italic">Lactobacillus lactis</Emphasis> for <Emphasis Type="SmallCaps">d</Emphasis>-lactic acid production

Three mutants, isolated by repeated UV mutagenesis of Lactobacillus lactis NCIM 2368, produced increased d-lactic acid concentrations. These mutants were compared with the wild type using 100 g hydrolyzed cane sugar/l in the fermentation medium. One mutant, RM2-24, produced 81 g lactic acid/l which was over three times that of the wild type. The highest d-lactic acid (110 g/l) in batch fermentation was obtained with 150 g cane sugar/l with a 73% lactic acid yield. The mutant utilizes cellobiose efficiently, converting it into d-lactic acid suggesting the presence of cellobiase. Thus, this strain could be used to obtain d-lactic acid from cellulosic materials that are pre-hydrolyzed with cellulase.     

The effect of<Emphasis Type="Italic"> pfl</Emphasis> gene knockout on the metabolism for optically pure <Emphasis Type="SmallCaps">d</Emphasis>-lactate production by<Emphasis Type="Italic"> Escherichia coli</Emphasis>

The effect of gene knockout on metabolism in the pflA^–, pflB^–, pflC^–, and pflD^– mutants of Escherichia coli was investigated. Batch cultivations of the pfl ^– mutants and their parent strain were conducted using glucose as a carbon source. It was found that pflA^– and pflB^– mutants, but not pflC^– and pflD^– mutants, produced large amounts of d-lactate from glucose under the microaerobic condition, and the maximum yield was 73%. In order to investigate the metabolic regulation mechanism, we measured enzyme activities for the following eight enzymes: glucose 6-phosphate dehydrogenase, 6-phosphogluconate dehydrogenase, glyceraldehyde 3-phosphate dehydrogenase (GAPDH), pyruvate kinase, lactate dehydrogenase (LDH), phosphoenolpyruvate carboxylase, acetate kinase, and alcohol dehydrogenase. Intracellular metabolite concentrations of glucose 6-phosphate, fructose 1,6-bisphosphate, phosphoenolpyruvate, pyruvate, acetyl coenzyme A as well as ATP, ADP, AMP, NADH, and NAD⁺ were also measured. It was shown that the GAPDH and LDH activities were considerably higher in pflA^– and pflB^– mutants, which implies coupling between NADH production and consumption between the two corresponding reactions. The urgent energy requirement was shown by the lower ATP/AMP level due to both oxygen limitation and pfl gene knockout, which promoted significant stepping-up of glycolysis when using glucose as a carbon source. It was shown that the demand for energy is more important than intracellular redox balance, thus excess NADH produced through GAPDH resulted in a significantly higher intracellular NADH/NAD⁺ ratio in pfl ^– mutants. Consequently, the homolactate production was achieved to meet the requirements of the redox balance and the energy production through glycolysis. The effect of using different carbon sources such as gluconate, pyruvate, fructose, and glycerol was investigated.     

Effect of temperature on <Emphasis Type="SmallCaps">d</Emphasis>-arabitol production from lactose by <Emphasis Type="Italic">Kluyveromyces lactis</Emphasis>

d-Arabitol production from lactose by Kluyveromyces lactis NBRC 1903 has been studied by following the time courses of concentrations of cell mass, lactose, d-arabitol, ethanol, and glycerol at different temperatures. It was found that temperature is a key factor in d-arabitol production. Within temperatures ranging from 25 to 39°C, the highest d-arabitol concentration of 99.2 mmol l⁻¹ was obtained from 555 mmol l⁻¹ of lactose after 120 h of batch cultivation at 37°C. The yield of d-arabitol production on cell mass growth increased drastically at temperatures higher than 35°C, and the yield reached 1.07 at 39°C. Increasing the cell mass concentration two-fold after 24 h of culture growth at 37°C, the d-arabitol concentration further increased to 168 mmol l⁻¹. According to the distribution of the metabolic products, metabolic changes related to growth phase were also discussed. The stationary-phase K. lactis cells in the batch culture that is started with exposing the precultured inoculum to high osmotic stress, high oxidative stress, and high heat stress are found to be preferable for d-arabitol production.     

Purification and characterization of <Emphasis Type="SmallCaps">l</Emphasis>-arabinose isomerase from <Emphasis Type="Italic">Lactobacillus plantarum</Emphasis> producing <Emphasis Type="SmallCaps">d</Emphasis>-tagatose

l-arabinose isomerase (EC5.3.1.4. AI) mediates the isomerization of d-galactose into d-tagatose as well as the conversion of l-arabinose into l-ribulose. The AI from Lactobacillus plantarum SK-2 was purified to an apparent homogeneity giving a single band on SDS–PAGE with a molecular mass of 59.6 kDa. Optimum activity was observed at 50°C and pH 7.0. The enzyme was stable at 50°C for 2 h and held between pH 4.5 and 8.5 for 1 h. AI activity was stimulated by Mn²⁺, Fe³⁺, Fe²⁺, Ca²⁺ and inhibited by Cu²⁺, Ag⁺, Hg²⁺, Pb²⁺. d-galactose and l-arabinose as substrates were isomerized with high activity. l-arabitol was the strongest competitive inhibitor of AI. The apparent Michaelis–Menten constant (K _m), for galactose, was 119 mM. The first ten N-terminal amino acids of the enzyme were determined as MLSVPDYEFW, which is identical to L. plantarum (Q88S84). Using the purified AI, 390 mg tagatose could be converted from 1,000 mg galactose in 96 h, and this production corresponds to a 39% equilibrium.     

Identification and characterization of a novel <Emphasis Type="SmallCaps">l</Emphasis>-arabinose isomerase from <Emphasis Type="Italic">Anoxybacillus flavithermus</Emphasis> useful in <Emphasis Type="SmallCaps">d</Emphasis>-tagatose production

d-Tagatose is a highly functional rare ketohexose and many attempts have been made to convert d-galactose into the valuable d-tagatose using l-arabinose isomerase (l-AI). In this study, a thermophilic strain possessing l-AI gene was isolated from hot spring sludge and identified as Anoxybacillus flavithermus based on its physio-biochemical characterization and phylogenetic analysis of its 16s rRNA gene. Furthermore, the gene encoding l-AI from A. flavithermus (AFAI) was cloned and expressed at a high level in E. coli BL21(DE3). l-AI had a molecular weight of 55,876 Da, an optimum pH of 10.5 and temperature of 95°C. The results showed that the conversion equilibrium shifted to more d-tagatose from d-galactose by raising the reaction temperatures and adding borate. A 60% conversion of d-galactose to d-tagatose was observed at an isomerization temperature of 95°C with borate. The catalytic efficiency (k _cat /K _m) for d-galactose with borate was 9.47 mM⁻¹ min⁻¹, twice as much as that without borate. Our results indicate that AFAI is a novel hyperthermophilic and alkaliphilic isomerase with a higher catalytic efficiency for d-galactose, suggesting its great potential for producing d-tagatose.     

Improved xylanase production by<Emphasis Type="Italic"> Trichoderma reesei</Emphasis> grown on <Emphasis Type="SmallCaps">l</Emphasis>-arabinose and lactose or <Emphasis Type="SmallCaps">d</Emphasis>-glucose mixtures

Trichoderma reesei Rut C-30 was grown on eight different natural or rare aldopentoses as the main carbon source and on mixtures of an aldopentose with d-glucose or lactose. The fungal cells consumed all aldopentoses tested, except l-xylose and l-ribose. The highest total xylanase and cellulase activities were achieved when cells were grown on l-arabinose as the main carbon source. The total xylanase activity produced by cells grown on l-arabinose was even higher than that produced by cells grown on an equal amount of lactose. In co-metabolism of d-glucose (15 g l^–1) and l-arabinose (5 g l^–1), the total volumetric and specific xylanase productivities were improved (derepressed) approximately 23- and 18-fold, respectively, compared to a cultivation on only d-glucose (20 g l^–1). In a similar experiment, in which cells were grown on a mixture of lactose and l-arabinose, the xylanase productivity was approximately doubled, compared to a cultivation on only lactose. The cellulase productivities, however, were not improved by the addition of l-arabinose. Compared with a typical industrial fungal enzyme production process with lactose as the main carbon source, better volumetric and specific xylanase productivities were achieved both on a lactose/arabinose mixture and on a glucose/arabinose mixture.     

Biotransformation of glycerol to <Emphasis Type="SmallCaps">d</Emphasis>-glyceric acid by <Emphasis Type="Italic">Acetobacter tropicalis</Emphasis>

Bacterial strains capable of converting glycerol to glyceric acid (GA) were screened among the genera Acetobacter and Gluconacetobacter. Most of the tested Acetobacter and Gluconacetobacter strains could produce 1.8 to 9.3 g/l GA from 10% (v/v) glycerol when intact cells were used as the enzyme source. Acetobacter tropicalis NBRC16470 was the best GA producer and was therefore further investigated. Based on the results of high-performance liquid chromatography analysis and specific rotation, the enantiomeric composition of the produced GA was d-glyceric acid (d-GA). The productivity of d-GA was enhanced with the addition of both 15% (v/v) glycerol and 20 g/l yeast extract. Under these optimized conditions, A. tropicalis NBRC16470 produced 22.7 g/l d-GA from 200 g/l glycerol during 4 days of incubation in a jar fermentor.     

Production of <Emphasis Type="SmallCaps">d</Emphasis>-arabitol by a newly isolated <Emphasis Type="Italic">Zygosaccharomyces rouxii</Emphasis>

A newly isolated Zygosaccharomyces rouxii NRRL 27,624 produced d-arabitol as the main metabolic product from glucose. In addition, it also produced ethanol and glycerol. The optimal conditions were temperature 30°C, pH 5.0, 350 rpm, and 5% inoculum. The yeast produced 83.4 ± 1.1 g d-arabitol from 175 ± 1.1 g glucose per liter at pH 5.0, 30°C, and 350 rpm in 240 h with a yield of 0.48 g/g glucose. It also produced d-arabitol from fructose, galactose, and mannose. The yeast produced d-arabitol and xylitol from xylose and also from a mixture of xylose and xylulose. Resting yeast cells produced 63.6 ± 1.9 g d-arabitol from 175 ± 1.8 g glucose per liter in 210 h at pH 5.0, 30°C and 350 rpm with a yield of 0.36 g/g glucose. The yeast has potential to be used for production of xylitol from glucose via d-arabitol route. Mention of trade names or commercial products in this article is solely for the purpose of providing specific information and does not imply recommendation or endorsement by the U.S. department of Agriculture.     

<Emphasis Type="Italic">Pseudomonas stutzeri</Emphasis> as a novel biocatalyst for pyruvate production from<Emphasis Type="SmallCaps"> DL</Emphasis>-lactate

Pseudomonas stutzeri SDM oxidized dl-lactic acid (25.5 g l^-1) into pyruvic acid (22.6 g l^-1) over 24 h. Both NAD⁺-independent d-lactate dehydrogenase and NAD⁺-independent l-lactate dehydrogenase were found for the first time in the bioconversion of lactate to pyruvate based on the enzyme activity assay and proteomic analysis. Jianrong Hao and Cuiqing Ma contributed equally to this work     

Production of <Emphasis Type="SmallCaps">d</Emphasis>-alanine from <Emphasis Type="SmallCaps">dl</Emphasis>-alanine using immobilized cells of <Emphasis Type="Italic">Bacillus subtilis</Emphasis> HLZ-68

Immobilized cells of Bacillus subtilis HLZ-68 were used to produce d-alanine from dl-alanine by asymmetric degradation. Different compounds such as polyvinyl alcohol and calcium alginate were employed for immobilizing the B. subtilis HLZ-68 cells, and the results showed that cells immobilized using a mixture of these two compounds presented higher l-alanine degradation activity, when compared with free cells. Subsequently, the effects of different concentrations of polyvinyl alcohol and calcium alginate on l-alanine consumption were examined. Maximum l-alanine degradation was exhibited by cells immobilized with 8% (w/v) polyvinyl alcohol and 2% (w/v) calcium alginate. Addition of 400 g of dl-alanine (200 g at the beginning of the reaction and 200 g after 30 h of incubation) into the reaction solution at 30 °C, pH 6.0, aeration of 1.0 vvm, and agitation of 400 rpm resulted in complete l-alanine degradation within 60 h, leaving 185 g of d-alanine in the reaction solution. The immobilized cells were applied for more than 15 cycles of degradation and a maximum utilization rate was achieved at the third cycle. d-alanine was easily extracted from the reaction solution using cation-exchange resin, and the chemical and optical purity of the extracted d-alanine was 99.1 and 99.6%, respectively.     

Phosphoenolpyruvate-supply module in <Emphasis Type="Italic">Escherichia coli</Emphasis> improves <Emphasis Type="Italic">N</Emphasis>-acetyl-<Emphasis Type="SmallCaps">d</Emphasis>-neuraminic acid biocatalysis

Objectives

N-Acetyl-d-neuraminic acid (Neu5Ac) is often synthesized from exogenous N-acetylglucosamine (GlcNAc) and excess pyruvate. We have previously constructed a recombinant Escherichia coli strain for Neu5Ac production using GlcNAc and intracellular phosphoenolpyruvate (PEP) as substrates (Zhu et al. Biotechnol Lett 38:1–9, 2016).

Results

PEP synthesis-related genes, pck and ppsA, were overexpressed within different modes to construct PEP-supply modules, and their effects on Neu5Ac production were investigated. All the PEP-supply modules enhanced Neu5Ac production. For the best module, pCDF-pck-ppsA increased Neu5Ac production to 8.6 ± 0.15 g l^?1, compared with 3.6 ± 0.15 g l^?1 of the original strain. Neu5Ac production was further increased to 15 ± 0.33 g l^?1 in a 1 l fermenter.

Conclusions

The PEP-supply module can improve the intracellular PEP supply and enhance Neu5Ac production, which benefited industrial Neu5Ac production.