Modeling and optimization of photosynthetic hydrogen gas production by green alga Chlamydomonas reinhardtii in sulfur-deprived circumstance

Biological hydrogen production by the green alga Chlamydomonas reinhardtii under sulfur-deprived conditions has attracted great interest due to the fundamental and practical importance of the process. The photosynthetic hydrogen production rate is dependent on various factors such as strain type, nutrient composition, temperature, pH, and light intensity. In this study, physicochemical factors affecting biological hydrogen production by C. reinhardtii were evaluated with response surface methodology (RSM). First, the maximum specific growth rate of the alga associated with simultaneous changes of ammonium, phosphate, and sulfate concentrations in the culture medium were investigated. The optimum conditions were determined as NH(4+) 8.00 mM, PO(4)(3-) 1.11 mM, and SO(4)(2-) 0.79 mM in Tris-acetate-phosphate (TAP) medium. The maximum specific growth rate with the optimum nutrient concentrations was 0.0373 h(-1). Then, the hydrogen production rate of C. reinhardtii under sulfur-deprivation conditions was investigated by simultaneously changing two nutrient concentrations and pH in the medium. The maximum hydrogen production was 2.152 mL of H(2) for a 10-mL culture of alga with density of 6 x 10(6) cells mL(-1) for 96 h under conditions of NH(4)(+) 9.20 mM, PO(4)(3-) 2.09 mM, and pH 7.00. The obtained hydrogen production rate was approximately 1.55 times higher than that with the typical TAP medium under sulfur deficiency.     

Outdoor cultivation of Chlamydomonas reinhardtii for photobiological hydrogen production

Photobiological hydrogen production by the unicellular green alga Chlamydomonas reinhardtii has been studied under laboratory conditions to a vast extend but has not been investigated under outdoor conditions yet. Because the hydrogen-producing hydrogenase is very sensitive to oxygen, the production must be performed in a two-stage process: generation of the required algal biomass under oxygenic photosynthesis, followed by hydrogen biosynthesis under anaerobic conditions. In order to design a sustainable process, cultivation and subsequent hydrogen production under cost-free sunlight was investigated in this work for the first time. First, cells were grown in closed photobioreactors under simulated outdoor conditions according to the light intensities of an idealized summer day (up to 2,000?μmol photons m^?2?s^?1) in order to achieve results independent of varying, and therefore not reproducible, weather conditions. The following outdoor experiments showed comparable growth characteristics and similar cell densities. However, the use of cells grown under outdoor, simulated outdoor, or high light conditions generally resulted in significantly lower hydrogen yields compared to the use of cells cultivated under low and continuous irradiance. In order to lower cultivation costs during the growth phase, the use of 10% CO₂ corresponding to the CO₂ content of flue gas was investigated. By supplying additional CO₂ during growth under the light profile corresponding to an idealized summer day, no significant increase of cell densities could be achieved, but the subsequent hydrogen production increased compared to hydrogen production of cells grown under atmospheric CO₂.     

Synthetic biology for improved hydrogen production in Chlamydomonas reinhardtii

Hydrogen is a clean alternative to fossil fuels. It has applications for electricity generation and transportation and is used for the manufacturing of ammonia and steel. However, today, H₂ is almost exclusively produced from coal and natural gas. As such, methods to produce H₂ that do not use fossil fuels need to be developed and adopted. The biological manufacturing of H₂ may be one promising solution as this process is clean and renewable. Hydrogen is produced biologically via enzymes called hydrogenases. There are three classes of hydrogenases namely [FeFe], [NiFe] and [Fe] hydrogenases. The [FeFe] hydrogenase HydA1 from the model unicellular algae Chlamydomonas reinhardtii has been studied extensively and belongs to the A1 subclass of [FeFe] hydrogenases that have the highest turnover frequencies amongst hydrogenases (21,000 ± 12,000 H₂ s⁻¹ for CaHydA from Clostridium acetobutyliticum). Yet to date, limitations in C. reinhardtii H₂ production pathways have hampered commercial scale implementation, in part due to O₂ sensitivity of hydrogenases and competing metabolic pathways, resulting in low H₂ production efficiency. Here, we describe key processes in the biogenesis of HydA1 and H₂ production pathways in C. reinhardtii. We also summarize recent advancements of algal H₂ production using synthetic biology and describe valuable tools such as high-throughput screening (HTS) assays to accelerate the process of engineering algae for commercial biological H₂ production.     

Eyespot-assembly mutants in Chlamydomonas reinhardtii.

Chlamydomonas reinhardtii is a single-celled green alga that phototaxes toward light by means of a light-sensitive organelle, the eyespot. The eyespot is composed of photoreceptor and Ca(++)-channel signal transduction components in the plasma membrane of the cell and reflective carotenoid pigment layers in an underlying region of the large chloroplast. To identify components important for the positioning and assembly of a functional eyespot, a large collection of nonphototactic mutants was screened for those with aberrant pigment spots. Four loci were identified. eye2 and eye3 mutants have no pigmented eyespots. min1 mutants have smaller than wild-type eyespots. mlt1(ptx4) mutants have multiple eyespots. The MIN1, MLT1(PTX4), and EYE2 loci are closely linked to each other; EYE3 is unlinked to the other three loci. The eye2 and eye3 mutants are epistatic to min1 and mlt1 mutations; all double mutants are eyeless. min1 mlt1 double mutants have a synthetic phenotype; they are eyeless or have very small, misplaced eyespots. Ultrastructural studies revealed that the min1 mutants are defective in the physical connection between the plasma membrane and the chloroplast envelope membranes in the region of the pigment granules. Characterization of these four loci will provide a beginning for the understanding of eyespot assembly and localization in the cell.     

New arginine-requiring mutants in Chlamydomonas reinhardtii

Twelve arginine-requiring mutants of the unicellular green alga Chlamydomonas reinhardtii previously isolated in our laboratory were investigated to find new blocks in the biosynthetic pathway of arginine. In addition to the already described mutants lacking acetylglutamyl phosphate reductase (arg 1), ornithine carbamoyltransferase (arg4) and argininosuccinate lyase (arg7), three new types of mutants were found lacking acetylornithine aminotransferase (arg9-1, arg9-2), acetylornithine glutamate transacetylase (arg10) and argininosuccinate synthetase (arg8-1, arg8-2, arg8-3) respectively. The genetic analysis of these new mutants showed that arg9 and arg8 are unlinked to the other arginine markers and that arg10 probably carries a chromosomal mutation inducing a very high lethality of meiotic products.Abbreviations WT wild-type - mt mating-type - SP spore plating - ZP zygote plating     

Advances in the biotechnology of hydrogen production with the microalga Chlamydomonas reinhardtii

Biological hydrogen production is being evaluated for use as a fuel, since it is a promising substitute for carbonaceous fuels owing to its high conversion efficiency and high specific energy content. The basic advantages of biological hydrogen production over other “green” energy sources are that it does not compete for agricultural land use, and it does not pollute, as water is the only by-product of the combustion. These characteristics make hydrogen a suitable fuel for the future. Among several biotechnological approaches, photobiological hydrogen production carried out by green microalgae has been intensively investigated in recent years. A select group of photosynthetic organisms has evolved the ability to harness light energy to drive hydrogen gas production from water. Of these, the microalga Chlamydomonas reinhardtii is considered one of the most promising eukaryotic H₂ producers. In this model microorganism, light energy, H₂O and H₂ are linked by two excellent catalysts, the photosystem 2 (PSII) and the [FeFe]-hydrogenase, in a pathway usually referred to as direct biophotolysis. This review summarizes the main advances made over the past decade as an outcome of the discovery of the sulfur-deprivation process. Both the scientific and technical barriers that need to be overcome before H₂ photoproduction can be scaled up to an industrial level are examined. Actual and theoretical limits of the efficiency of the process are also discussed. Particular emphasis is placed on algal biohydrogen production outdoors, and guidelines for an optimal photobioreactor design are suggested.     

The role of carbon dioxide in light-activated hydrogen production by Chlamydomonas reinhardtii

Light-activated hydrogen and oxygen evolution as a function of CO₂ concentration in helium were measured for the unicellular green alga Chlamydomonas reinhardtii. The concentrations were 58, 30, 0.8 and 0 ppm CO₂. The objective of these experiments was to study the differential affinity of CO₂/HCO ₃ ^- for their respective Photosystem II and Calvin cycle binding sites vis-à-vis photoevolution of molecular oxygen and the competitive pathways of hydrogen photoevolution and CO₂ photoassimilation. The maximum rate of hydrogen evolution occurred at 0.8 ppm CO₂, whereas the maximum rate of oxygen evolution occurred at 58 ppm CO₂. The key result of this work is that the rate of photosynthetic hydrogen evolution can be increased by, at least partially, satisfying the Photosystem II CO₂/HCO ₃ ^- binding site requirement without fully activating the Calvin-Benson CO₂ reduction pathway. Data are presented which plot the rates of hydrogen and oxygen evolution as functions of atmospheric CO₂ concentration in helium and light intensity. The stoichiometric ratio of hydrogen to oxygen changed from 0.1 at 58 ppm to approximately 2.5 at 0.8 ppm. A discussion of partitioning of photosynthetic reductant between the hydrogen/hydrogenase and Calvin-Benson cycle pathways is presented.Abbreviations PET photosynthetic electron transport - PS Photosystem     

Flagellar morphology in stumpy-flagella mutants of Chlamydomonas reinhardtii

Sixteen new mutants of the biflagellate green alga Chlamydomonas reinhardtii with either stumpy-flagella or no flagella at all were examined by electron microscopy. Four of the mutants were found to carry short bulbous flagella containing amorphous electron-dense material which may represent unassembled flagellar protein. Basal bodies of normal ultrastructure were present in all mutants. Dikaryon dominance tests indicated that the stumpy mutations were recessive to wild-type in all cases tested. Stumpy mutations also conferred a measure of detergent resistance to Chlamydomonas, apparently by affecting the detergent-solubility of the flagellar membrane.     

The effect of light intensity on hydrogen production by sulfur-deprived Chlamydomonas reinhardtii

The effect of light intensity on hydrogen production by sulfur-deprived Chlamydomonas reinhardtii was studied in situ using either long- or short-term experiments, or alternatively, with samples withdrawn from the photobioreactor. Overall hydrogen production by S-deprived culture was shown to depend on the light intensity and to exhibit regions of light limitation and light inhibition. The optimal incident light intensity for hydrogen production was independent of the method of sulfur deprivation or the initial acetate concentration in the medium (12-34 mM). However, it varied with the Chl concentration and the thickness of the photobioreactor. To calculate the average light intensity in the photobioreactor under different experimental conditions, a special mathematics approach was developed. The optimal average light intensity for H(2) production appeared to be 30-40 microE m(-2)s(-1) and was independent of the Chl or acetate concentrations and the method of S deprivation. The inhibitory effect of high light intensity was related to the enhanced O(2) evolution activity during the photosynthetic stage of sulfur deprivation and to the high activity of photosystem II at the beginning of the H(2)-production phase. Data support the major role of photosystem II in supplying reductants through photosystem I to the hydrogenase throughout the H(2)-production phase.     

Gravitaxis in Chlamydomonas reinhardtii studied with novel mutants

Many free-swimming unicellular organisms show negative gravitaxis, i.e. tend to swim upward, although their specific densities are higher than the medium density. To obtain clues to the mechanism of this behavior, we examined how a mutation in motility or behavior affects the gravitaxis in Chlamydomonas. A phototaxis mutant, ptx3, deficient in membrane excitability showed weakened gravitaxis, whereas another phototaxis mutant, ptx1, deficient in regulation of flagellar dominance displayed normal gravitaxis. Two mutants that swim backwards only, mbo1 and mbo2, did not show any clear gravitaxis. We also isolated two novel mutants deficient in gravitaxis, gtx1 and gtx2. These mutants displayed normal motility and physical characteristics of cell body as assessed by the behavior of anesthetized cells. However, these cells were found to have defects in physiological responses involving membrane excitation. These observations are consistent with the idea that the gravitaxis in Chlamydomonas involves a physiological signal transduction system, which is at least partially independent of the system used for phototaxis.     

First crystal structure of Rubisco from a green alga, Chlamydomonas reinhardtii

The crystal structure of Rubisco (ribulose 1,5-bisphosphate carboxylase/oxygenase) from the unicellular green alga Chlamydomonas reinhardtii has been determined to 1.4 A resolution. Overall, the structure shows high similarity to the previously determined structures of L8S8 Rubisco enzymes. The largest difference is found in the loop between beta strands A and B of the small subunit (betaA-betaB loop), which is longer by six amino acid residues than the corresponding region in Rubisco from Spinacia. Mutations of residues in the betaA-betaB loop have been shown to affect holoenzyme stability and catalytic properties. The information contained in the Chlamydomonas structure enables a more reliable analysis of the effect of these mutations. No electron density was observed for the last 13 residues of the small subunit, which are assumed to be disordered in the crystal. Because of the high resolution of the data, some posttranslational modifications are unambiguously apparent in the structure. These include cysteine and N-terminal methylations and proline 4-hydroxylations.     

Time-resolved chlorophyll fluorescence studies on photosynthetic mutants of Chlamydomonas reinhardtii: origin of the kinetic decay components

The room temperature chlorophyll fluorescence decay kinetics of photosynthetic mutants of Chlamydomonas reinhardtii have been measured as a function of Photosystem 2 (PS2) trap closure, DNB-induced quenching at F_M, and time-resolved emission spectra. The overall decays have been analyzed in terms of three or four kinetic components where necessary. A comparison of the characteristics of the decay components exhibited by the mutants with the wild-type has been carried out to elucidate the precise origins of the different emissions in relation to the observed pigment-protein complexes. It is shown that a) charge recombination in PS2 is not necessary for the presence of long-lived decay components, b) there are two rapid PS1-associated emissions (=30 and 150–200 ps), c) a slow PS1 decay is observed (=1.73 ns) in the absence of PS1 reaction centres, d) the two variable components (=0.25–1.2 and 0.5–2.2 ns) observed in the wild-type arise from LHC2 and e) a rapid (=50–250 ps) decay is associated with the PS2 core antenna (CP3 and CP4). These results show that the intact thylakoid membrane system is too complex to distinguish all of the individual kinetic components.Abbreviations Aexp preexponential factor (Amplitude) - chl chlorophyll - DCMU 3-(3,4-dichlorophenyl)-1,1-dimethyl urea - DNB m, dinitrobenzene - F_M maximum chl fluorescence level - F₀ initial chl fluorescence level - F_v variable chl fluorescence (F_M–F₀) - LHC light harvesting chl a/b protein complex - PS photosystem - Q_A primary stable electron acceptor of PS2     

Accumulation of starch in Chlamydomonas reinhardtii flagellar mutants.

Paralyzed flagellar mutants pf-1, pf-2, pf-7, and pf-18 of the green alga Chlamydomonas reinhardtii (Dangeard) were shown to store a significantly greater amount of starch than the motile wild type 137c+. The increase in starch storage was significant relative to protein, chlorophyll, and cell number. Analysis of average cell size revealed that the paralyzed mutants were larger than the wild type. This increase in storage molecule accumulation supports an inverse relationship between chemical energy storage and energy utilization for biomechanical/motile cellular functions. Chlamydomonas reinhardtii provides a useful model for studies of the role of cytoskeletal activity in the energy relationship and balance of organisms.     

Insertional mutagenesis to isolate acetate-requiring mutants in Chlamydomonas reinhardtii

Abstract An arg 7 mutant of the green alga Chlamydomonas reinhardtii was transformed with pARG7.8, a plasmid bearing the wild-type ARG 7 gene. Out of 4100 arg⁺ transformants selected on an arginine-free medium supplemented with acetate, nine failed to grow on acetate-free medium (ac⁻ mutants). The results of the genetic and molecular analysis of several ac⁻ mutants are in agreement with the hypothesis that they originated from insertion of the incoming plasmid into the nuclear genome. These mutants should constitute valuable tools for isolating the corresponding wild-type genes after plasmid rescue into Escherichia coli .     

Efficient H2 production via Chlamydomonas reinhardtii

Molecular hydrogen (H(2)) obtained from biological sources provides an alternative to bulk chemical processes that is moving towards large-scale, economical generation of clean fuel for automotive engines. This opinion article examines recent improvements in H(2) production by wild and mutant strains of Chlamydomonas reinhardtii - the green microalga currently considered the best eukaryotic H(2) producer. Here, we review various aspects of genetic and metabolic engineering of C. reinhardtii, as well as of process engineering. Additionally, we lay out possible scenarios that would lead to more efficient research approaches in the near future, as part of a consistent strategy for sustainable biohydrogen supply.     

Photoautotrophic cultures of Chlamydomonas reinhardtii: sulfur deficiency,anoxia, and hydrogen production

Photosynthesis Research - The aim of this work was a comparative study of S-repleted and S-depleted photoautotrophic cultures of Chlamydomonas reinhardtii under aerobic and anoxic conditions with...