Improvement of xylitol production by Candida guilliermondii FTI 20037 previously adapted to rice straw hemicellulosic hydrolysate

AIMS: To evaluate a simple and economical technique to improve xylitol production using concentrated xylose solutions prepared from rice straw hemicellulosic hydrolysate. METHODS AND RESULTS: Experiments were carried out with rice straw hemicellulosic hydrolysate containing 90 g l-1 xylose, with and without the addition of nutrients, using the yeast Candida guilliermondii previously grown on the hydrolysate (adapted cells) or on semi-defined medium (unadapted cells). By this method, the yield of xylitol increased from 17 g l-1 to 50 g l-1, and xylose consumption increased from 52% to 83%, after 120 h of fermentation. The xylitol production rates were very close to that (0.42 g l-1 h-1) attained in a medium simulating hydrolysate sugars. CONCLUSION: Yeast strain adaptation to the hydrolysate showed to be a suitable method to alleviate the inhibitory effects of the toxic compounds. Adapted cells of Candida guilliermondii can efficiently produce xylitol from hydrolysate with high xylose concentrations. SIGNIFICANCE AND IMPACT OF THE STUDY: Yeast adaptation helps the bioconversion process in hydrolysate made from lignocellulosic materials. This low-cost technique provides an alternative to the detoxification methods used for removal of inhibitory compounds. In addition, the use of adapted inocula makes it possible to schedule a series of batch cultures so that the whole plant can be operated almost continuously with a concomitant reduction in the overall operation time.     

Metabolic engineering strategies for improving xylitol production from hemicellulosic sugars

Xylitol is a five-carbon sugar alcohol with potential for use as a sweetener. Industrially, xylitol is currently produced by chemical hydrogenation of d-xylose using Raney nickel catalysts and this requires expensive separation and purification steps as well as high pressure and temperature that lead to environmental pollution. Highly efficient biotechnological production of xylitol using microorganisms is gaining more attention and has been proposed as an alternative process. Although the biotechnological method has not yet surpassed the advantages of chemical reduction in terms of yield and cost, various strategies offer promise for the biotechnological production of xylitol. In this review, the focus is on the most recent developments of the main metabolic engineering strategies for improving the production of xylitol.     

Batch xylitol production from wheat straw hemicellulosic hydrolysate using Candida guilliermondii in a stirred tank reactor

Batch production of xylitol from the hydrolysate of wheat straw hemicellulose using Candida guilliermondii was carried out in a stirred tank reactor (agitation speed of 300 rpm, aeration rate of 0.6 vvm and initial cell concentration of 0.5 g l^–1). After 54 h, xylitol production from 30.5 g xylose l^–1 reached 27.5 g l^–1, resulting in a xylose-to-xylitol bioconversion yield of 0.9 g g^–1 and a productivity of 0.5 g l^–1 h^–1.     

Evaluation of rice straw hemicellulose hydrolysate in the production of xylitol byCandida guilliermondii

Summary Rice straw was used as a lignocellulosic source to provide rich pentose media. By using a well characterized yeast strain,Candida guilliermondii FTI 20037, the hydrolysate obtained was converted to xylitol with an efficiency of 75% and production of 27 g of xylitol per liter in 48 hours. The satisfactory results reported here can be attributed to the low concentrations of toxic components generated throughout the chemical depolymerization of this raw material.     

Organosolvent pretreatment and enzymatic hydrolysis of rice straw for the production of bioethanol

The present study investigates the operational conditions for organosolvent pretreatment and hydrolysis of rice straw. Among the different organic acids and organic solvents tested, acetone was found to be most effective based on the fermentable sugar yield. Optimization of process parameters for acetone pretreatment were carried out. The structural changes before and after pretreatment were investigated by scanning electron microscopy, X-ray diffraction and Fourier transform infrared (FTIR) analysis. The X-ray diffraction profile showed that the degree of crystallinity was higher for acetone pretreated biomass than that of the native. FTIR spectrum also exhibited significant difference between the native and pretreated samples. Under optimum pretreatment conditions 0.458 g of reducing sugar was produced per gram of pretreated biomass with a fermentation efficiency of 39%. Optimization of process parameters for hydrolysis such as biomass loading, enzyme loading, surfactant concentration and incubation time was done using Box–Benhken design. The results indicate that acetone pretreated rice straw can be used as a good feed stock for bioethanol production.     

Optimal experimental condition for hemicellulosic hydrolyzate treatment with activated charcoal for xylitol production

Rice straw was hydrolyzed into a mixture of sugars using diluted H(2)SO(4). During hydrolysis, a variety of inhibitors was also produced, including acetic acid, furfural, hydroxymethylfurfural, and lignin degradation products (several aromatic and phenolic compounds). To reduce the toxic compounds concentration in the hydrolyzate and to improve the xylitol yield and volumetric productivity, rice straw hemicellulosic hydrolyzate was treated with activated charcoal under different pH values, stirring rates, contact times, and temperatures, employing a 2(4) full-factorial design. Fermentative assays were conducted with treated hydrolyzates containing 90 g/L xylose. The results indicated that temperature, pH, and stirring rate strongly influenced the hydrolyzate treatment, temperature and pH interfering with all of the responses analyzed (removal of color and lignin degradation products, xylitol yield factor, and volumetric productivity). The combination of pH 2.0, 150 rpm, 45 degrees C, and 60 min was considered an optimal condition, providing significant removal rates of color (48.9%) and lignin degradation products (25.8%), as well as a xylitol production of 66 g/L, a volumetric productivity of 0.57 g/L.h, and a yield factor of 0.72 g/g.     

Effect of inoculum level on xylitol production from rice straw hemicellulose hydrolysate byCandida guilliermondii

The effect of inoculum level on xylitol production byCandida guilliermondii was evaluated in a rice straw hemicellulose hydrolysate. High initial cell density did not show a positive effect in this bioconversion since increasing the initial cell density from 0.67 g L^–1 to 2.41 g L^–1 decreased both the rate of xylose utilization and xylitol accumulation. The maximum xylitol yield (0.71 g g^–1) and volumetric productivity (0.56 g L^–1 h^–1) were reached with an inoculum level of 0.9 g L^–1. These results show that under appropriate inoculum conditions rice straw hemicellulose hydrolysate can be converted into xylitol by the yeastC. guilliermondii with efficiency values as high as 77% of the theoretical maximum.     

The optimized CO2-added ammonia explosion pretreatment for bioethanol production from rice straw

A CO₂-added ammonia explosion pretreatment was performed for bioethanol production from rice straw. The pretreatment conditions, such as ammonia concentration, CO₂ loading level, residence time, and temperature were optimized using response surface methodology. The response for optimization was defined as the glucose conversion rate. The optimized pretreatment conditions resulting in maximal glucose yield (93.6 %) were determined as 14.3 % of ammonia concentration, 2.2 MPa of CO₂ loading level, 165.1 °C of temperature, and 69.8 min of residence time. Scanning electron microscopy analysis showed that pretreatment of rice straw strongly increased the surface area and pore size, thus increasing enzymatic accessibility for enzymatic saccharification. Finally, an ethanol yield of 97 % was achieved via simultaneous saccharification and fermentation. Thus, the present study suggests that CO₂-added ammonia pretreatment is an appropriate process for bioethanol production from rice straw.     

Optimization of dilute sulfuric acid pretreatment of corn stover for enhanced xylose recovery and xylitol production

Pretreatment steps are necessary for the bioconversion of corn stover (CS) to xylitol. In order to optimize the pretreatment parameters, the sulfuric acid concentration, sulfuric acid residence time, and solid slurry concentration were evaluated, based on the glucose and xylose recovered from CS at the relatively low temperature of 120°C. The optimum conditions were found to be pretreatment with 2.5% (w/v) sulfuric acid for 1.5 h, with a solid slurry concentration of 90 g/L. Under these conditions, the hydrolysis rates of glucan and xylan were approximately 26.0 and 82.8%, respectively. High xylitol production (10.9 g/L) and conversion yield (0.97 g/g) were attained from corn stover hydrolysate (CSH) without detoxification and any nutrient addition. Our results were similar for xylitol production in synthetic medium under the same conditions. The non-necessity of both the hydrolysate detoxification step and nutrient addition to the CSH is undoubtedly promising for scale-up application on an industrial scale, because this medium-based manufacturing process is expected to reduce the production cost of xylitol. The present study demonstrates that value-added xylitol could be effectively produced from CS under optimized pretreatment conditions, especially with CSH as the substrate material.     

发酵性丝孢酵母HWZ004利用水稻秸秆水解液发酵产油脂

为高效利用水稻秸秆中的纤维素和半纤维素产油脂,采用稀酸预处理和酶水解两步法对水稻秸秆进行水解,然后以水解液为碳源,培养发酵性丝孢酵母Trichosporon fermentans HWZ004产微生物油脂。结果表明,经简单overliming法脱毒后水稻秸秆水解液中乙酸、糠醛和5-羟甲基糠醛的浓度分别为0.4 g/L、0.1 g/L和0.05 g/L。只需添加少量氮源和微量CuSO4?5H2O,该水解液即可满足T. fermentans HWZ004发酵产油脂的要求。发酵最适接种量、初始pH和温度分别是5.0％、7.0和25 ℃。T. fermentans HWZ004在优化条件下培养7 d的生物量、油脂含量和油脂产量分别是26.4 g/L,52.2％和13.8 g/L;油脂得率系数为17.0,大大高于驯化前菌株T. fermentans CICC 1368在脱毒水稻秸秆半纤维素水解液中的对应值 (11.9)。所产油脂的脂肪酸组成与植物油相似,不饱和脂肪酸含量达70％以上,宜作为生物柴油的生产原料。     

The influence of aeration and hemicellulosic sugars on xylitol production by Candida tropicalis

The influence of other hemicellulosic sugars (arabinose, galactose, mannose and glucose), oxygen limitation, and initial xylose concentration on the fermentation of xylose to xylitol was investigated using experimental design methodology. Oxygen limitation and initial xylose concentration had considerable influences on xylitol production by Canadida tropicalis ATCC 96745. Under semiaerobic conditions, the maximum xylitol yield was 0.62 g/g substrate, while under aerobic conditions, the maximum volumetric productivity was 0.90 g/l h. In the presence of glucose, xylose utilization was strongly repressed and sequential sugar utilization was observed. Ethanol produced from the glucose caused 50% reduction in xylitol yield when its concentration exceeded 30 g/l. When complex synthetic hemicellulosic sugars were fermented, glucose was initially consumed followed by a simultaneous uptake of the other sugars. The maximum xylitol yield (0.84 g/g) and volumetric productivity (0.49 g/l h) were obtained for substrates containing high arabinose and low glucose and mannose contents.     

Optimization of fermentable sugar production from rape straw through hydrothermal acid pretreatment

Operational conditions for the hydrolysis of rape straw were optimized using the combined severity index (CS), which combines the effects of time, temperature, and acid concentration into a single parameter. The sugar recovery yield was 77.8% of the theoretical yield at a value of CS=1.3. A maximum concentration of xylose of 7.22 g/L was obtained when the straw was treated for 10 min at a low reaction temperature (150 °C) and high acid concentration (pH 1.17). The pentose-rich hydrolyzate exhibited a low concentration of fermentation-inhibiting compounds. The concept of CS can be conveniently and effectively applied for optimization of pretreatments.     

Evaluation of chemical pretreatment for enzymatic solubilization of rice straw

Summary Rice straw was treated with NaOH, peracetic acid (PA), and sodium chlorite (NaClO₂). Quantitative changes in the composition of the treated straw, crystallinity of the treated straw and extracted cellulose, and susceptibility of the treated straw to Trichoderma reesei cellulase were studied. The alkali treatment resulted in a remarkable decrease in hemicellulose as well as lignin. Consequently, the recovery of residual straw after NaOH treatment was lowest among the three chemical reagents evaluated. The treatment with PA or NaCIO₂ resulted in a slight loss in hemicellulose and cellulose in the straw. The three chemical treatments caused little or no breakdown of the crystalline structure of cellulose in the straw. The treated straw was solubilized with the culture filtrate of T. reesei. The degree of enzymatic solubilization relative to the amount of residual straw was 69% after treatment with 0.25 N NaOH, 42% after treatment with 20% PA, and 50% after treatments with NaClO₂ (twice). The degree of enzymatic solubilization relative to the amount of the untreated straw, however, was 30% after treatment with 0.25 N NaOH, 32% after treatment with 20% PA, and 37% after treatments with NaClO₂ (twice).     

Influence of the metabolism pathway on lactic acid production from hemicellulosic trimming vine shoots hydrolyzates using Lactobacillus pentosus

Hemicellulosic hydrolyzates from trimming wastes of vine shoots were proposed as a carbon source for lactic acid production by Lactobacillus pentosus CECT-4023T (ATCC-8041). These hydrolyzates are composed mainly of glucose (12.0 g/L), xylose (17.5 g/L) and arabinose (4.3 g/L). Acetic acid, the main subproduct, started to be produced after all of the glucose was completely depleted, showing that the acetic acid coproduction came only from the xylose and arabinose consumption. In the absence of glucose, the L. pentosus pathway shifts from homo to heterofermentative. Thus, L. pentosus can be considered a facultative heterofermentative organism, degrading hexoses (glucose) via the Embden-Meyerhoff-Parnas pathway and pentoses (xylose and arabinose) via the phosphoketolase pathway. Hydrolyzates were vacuum evaporated to increase the initial sugars concentration up to 35.4 g/L of glucose, 52.3 g/L of xylose, and 13.0 g/L of arabinose. Under these conditions the lactic acid concentration reached 46.0 g/L (Q(P) = 0.933 g/L.h, Y(P/S) = 0.78 g/g; Y(P/S) theoretical = 91.7%) and a clear product inhibition was observed. Additional experiments with synthetic sugars, in the absence of inhibitory compounds, indicate that this inhibition must be attributed to the metabolic pathway but not to the inhibitory compounds present in the fermentation broth.     

Optimization of enzymatic hydrolysis of pretreated rice straw and ethanol production

Cellulase, Tween 80, and β-glucosidase loading were studied and optimized by response surface methodology to improve saccharification. Microwave alkali-pretreated rice straw used as substrate for onsite enzyme production by Aspergillus heteromorphus and Trichoderma reesei. The highest enzymatic hydrolysis (84%) was obtained from rice straw at crude enzyme loading of 10 FPU/gds of cellulase, 0.15% Tween 80, and 100 international unit/g dry solids of β-glucosidase activities. Enzymatic hydrolyzate of pretreated rice straw was used for ethanol production by Saccharomyces cerevisiae, Scheffersomyces stipitis, and by co-culture of both. The yield of ethanol was 0.50, 0.47, and 0.48 g_p/g_s by S. cerevisiae, S. stipitis, and by co-culture, respectively, using pretreated rice straw hydrolyzate. The co-culture of S. cerevisiae and S. stipitis produced 25% more ethanol than S. cerevisiae alone and 31% more ethanol than S. stipitis alone. During anaerobic fermentation 65.08, 36.45, and 50.31 μmol/ml CO₂ released by S. cerevisiae, S. stipitis, and by co-culture, respectively. The data indicated that saccharification efficiency using optimized crude enzyme cocktail was good, and enzymatic hydrolyzate could be fermented to produce ethanol.     

Optimization of microwave-assisted FeCl3 pretreatment conditions of rice straw and utilization of Trichoderma viride and Bacillus pumilus for production of reducing sugars

In this study, Box-Behnken design (BBD) and response surface methodology (RSM) were used to optimize microwave-assisted FeCl₃ pretreatment conditions of rice straw with respect to FeCl₃ concentration, microwave intensity, irradiation time and substrate concentration. When rice straw was pretreated at the optimal conditions of FeCl₃ concentration, 0.14 mol/L; microwave intensity, 160 °C; irradiation time, 19 min; substrate concentration, 109 g/L; and inoculated with Trichoderma viride and Bacillus pumilus, the production of reducing sugars was 6.62 g/L. This yield was 2.9 times higher than that obtained with untreated rice straw. The microorganisms degraded 37.8% of pretreated rice straw after 72 h. The structural characteristic analyses suggest that microwave-assisted FeCl₃ pretreatment damaged the silicified waxy surface of rice straw, disrupted almost all the ether linkages between lignin and carbohydrates, and removed lignin.     

Environmental parameters affecting xylitol production from sugar cane bagasse hemicellulosic hydrolyzate by Candida guilliermondii

The bioconversion of xylose to xylitol by Candida guilliermondii FTI 20037 cultivated in sugar cane bagasse hemicellulosic hydrolyzate was influenced by cell inoculum level, age of inoculum and hydrolyzate concentration. The maximum xylitol productivity (0.75 g L⁻¹ h⁻¹) occurred in tests carried out with hydrolyzate containing 54.5 g L⁻¹ of xylose, using 3.0 g L⁻¹ of a 24-h-old inoculum. Xylitol productivity and cell concentration decreased with hydrolyzate containing 74.2 g L⁻¹ of xylose. Received 02 February 1996/ Accepted in revised form 15 November 1996     

Obtaining hemicellulosic hydrolysate from sugarcane bagasse for microbial oil production by Lipomyces starkeyi

Biotechnology Letters - The extraction of the hemicellulose fraction of sugarcane bagasse (SCB) by acid hydrolysis was evaluated in an autoclave and a Parr reactor aiming the application of the...     

Kinetic behavior of Candida guilliermondii yeast during xylitol production from Brewer's spent grain hemicellulosic hydrolysate

Brewer's spent grain, the main byproduct of breweries, was hydrolyzed with dilute sulfuric acid to produce a hemicellulosic hydrolysate (containing xylose as the main sugar). The obtained hydrolysate was used as cultivation medium by Candidaguilliermondii yeast in the raw form (containing 20 g/L xylose) and after concentration (85 g/L xylose), and the kinetic behavior of the yeast during xylitol production was evaluated in both media. Assays in semisynthetic media were also performed to compare the yeast performance in media without toxic compounds. According to the results, the kinetic behavior of the yeast cultivated in raw hydrolysate was as effective as in semisynthetic medium containing 20 g/L xylose. However, in concentrated hydrolysate medium, the xylitol production efficiency was 30.6% and 42.6% lower than in raw hydrolysate and semisynthetic medium containing 85 g/L xylose, respectively. In other words, the xylose-to-xylitol bioconversion from hydrolysate medium was strongly affected when the initial xylose concentration was increased; however, similar behavior did not occur from semisynthetic media. The lowest efficiency of xylitol production from concentrated hydrolysate can be attributed to the high concentration of toxic compounds present in this medium, resulting from the hydrolysate concentration process.