Protease activation of the entomocidal protoxin of Bacillus thuringiensis subsp. kurstaki

Two isolates of Bacillus thuringiensis subsp. kurstaki were examined which produced different levels of intracellular proteases. Although the crystals from both strains had comparable toxicity, one of the strains, LB1, had a strong polypeptide band at 68,000 molecular weight in the protein from the crystal; in the other, HD251, no such band was evident. When the intracellular proteases in both strains were measured, strain HD251 produced less than 10% of the proteolytic activity found in LB1. These proteases were primarily neutral metalloproteases, although low levels of other proteases were detected. In LB1, the synthesis of protease increased as the cells began to sporulate; however, in HD251, protease activity appeared much later in the sporulation cycle. The protease activity in strain LB1 was very high when the cells were making crystal toxin, whereas in HD251 reduced proteolytic activity was present during crystal toxin synthesis. The insecticidal toxin (molecular weight, 68,000) from both strains could be prepared by cleaving the protoxin (molecular weight, 135,000) with trypsin, followed by ion-exchange chromatography. The procedure described gave quantitative recovery of toxic activity, and approximately half of the total protein was recovered. Calculations show that these results correspond to stoichiometric conversion of protoxin to insecticidal toxin. The toxicities of whole crystals, soluble crystal protein, and purified toxin from both strains were comparable.     

Purification of the mosquitocidal and cytolytic proteins of Bacillus thuringiensis subsp. israelensis.

Two proteins from parasporal crystals of Bacillus thuringiensis subsp. israelensis were purified to electrophoretic homogeneity by gel filtration and anion-exchange chromatography. The larger of the two proteins (molecular weight, 68,000) was not cytolytic, whereas the smaller protein (molecular weight, 28,000) was highly cytolytic when assayed against rat erythrocytes. When these proteins were assayed against larvae of the yellow fever mosquito, Aedes aegypti, the larger protein was at least 100-fold more toxic than the smaller protein. Although proteolytic activity was not detected in solubilized crystals nor in purified protein preparations, the toxin (molecular weight, 68,000) was readily degraded to smaller, nontoxic molecules, even when maintained at 4 degrees C. Mixtures of the two purified proteins were significantly more toxic to mosquito larvae than was either protein alone. Thus, it is likely that both the mosquitocidal and the cytolytic protein play roles in the overall insecticidal action of the parasporal crystal produced by this bacterium.     

Purification of the mosquitocidal and cytolytic proteins of Bacillus thuringiensis subsp. israelensis

Two proteins from parasporal crystals of Bacillus thuringiensis subsp. israelensis were purified to electrophoretic homogeneity by gel filtration and anion-exchange chromatography. The larger of the two proteins (molecular weight, 68,000) was not cytolytic, whereas the smaller protein (molecular weight, 28,000) was highly cytolytic when assayed against rat erythrocytes. When these proteins were assayed against larvae of the yellow fever mosquito, Aedes aegypti, the larger protein was at least 100-fold more toxic than the smaller protein. Although proteolytic activity was not detected in solubilized crystals nor in purified protein preparations, the toxin (molecular weight, 68,000) was readily degraded to smaller, nontoxic molecules, even when maintained at 4 degrees C. Mixtures of the two purified proteins were significantly more toxic to mosquito larvae than was either protein alone. Thus, it is likely that both the mosquitocidal and the cytolytic protein play roles in the overall insecticidal action of the parasporal crystal produced by this bacterium.     

Identification and purification of the 69-kDa intracellular protease involved in the proteolytic processing of the crystal delta-endotoxin of Bacillus thuringiensis subsp. tenebrionis

The dynamics of appearance of intracellular proteases in relation to the synthesis of crystal delta-endotoxin was studied to identify the native intracellular protease(s) involved in the proteolytic processing of the 73-kDa protoxin of Bacillus thuringiensis subsp. tenebrionis. In vitro proteolytic activation of the 73-kDa protoxin indicated the possible role of 69-kDa protease in the proteolytic processing of 73-kDa protoxin. The purified 69-kDa protease was able to cause the proteolytic activation of the 73-kDa protoxin to 68-kDa toxin and this conversion was inhibited by ethylenediamine tetraacetic acid and 1,10-phenanthroline.     

Characterization and comparison of midgut proteases of Bacillus thuringiensis susceptible and resistant diamondback moth (Plutellidae: Lepidoptera)

The midgut proteases of the Bacillus thuringiensis resistant and susceptible populations of the diamondback moth, Plutella xylostella L. were characterized by using protease specific substrates and inhibitors. The midgut contained trypsin-like proteases of molecular weights of 97, 32, 29.5, 27.5, and 25 kDa. Of these five proteases, 29.5 kDa trypsin-like protease was the most predominant in activation of protoxins of Cry1Aa and Cry1Ab. The activation of Cry1Ab protoxin by midgut protease was fast (T(1/2) of 23-24 min) even at a protoxin:protease ratio of 250:1. The protoxin activation appeared to be multi-step process, and at least seven intermediates were observed before formation of a stable toxin of about 57.4 kDa from protoxin of about 133 kDa. Activation of Cry1Aa was faster than that of Cry1Ab on incubation of protoxins with midgut proteases and bovine trypsin. The protoxin and toxin forms of Cry proteins did not differ in toxicity towards larvae of P. xylostella. The differences in susceptibility of two populations to B. thuringiensis Cry1Ab were not due to midgut proteolytic activity. Further, the proteolytic patterns of Cry1A protoxins were similar in the resistant as well as susceptible populations of P. xylostella.     

Characterization of the entomocidal parasporal crystal of Bacillus thuringiensis.

The parasporal crystalline protoxin of Bacillus thuringiensis contains a single glycoprotein subunit that has a molecular weight of approximately 1.2 X 10(5). The carbohydrate consists of glucose (3.8%) and mannose (1.8%). At alkaline pH, the proendotoxin is apparently solubilized and activated by an autolytic mechanism involving an inherent sulfhydryl protease that renders the protoxin insecticidal. Activation generates protons, degraded polypeptides, sulfhydryl group reactivity, proteolytic activity, and insect toxicity. Chemical modification of the sulfhydryl groups inhibits the proteolytic and insecticidal activities, suggesting that cysteine residues may be present in the active site of the protein.     

Activation pattern and toxicity of the Cry11Bb1 toxin of Bacillus thuringiensis subsp. medellin

Bacillus thuringiensis protoxins undergo proteolytic processing in the midgut of susceptible insects to become active. The ability to process the Cry11Bb1 protoxin by trypsin and Culex quinquefasciatus larval gut extracts was tested. The protease activity indicated by the appearance of proteolytic products increased with an increment in pH, with the highest activity being observed at pH 10.6. A time course study showed the proteolysis of the 94-kDa Cry11Bb protein ending with the production of fragments of relative molecular mass of 30 and 35 kDa within 5 min. In vitro, gut proteases extract cleaved the solubilized toxin between Ser59 and Ile60 and between Ala395 and Asn396, generating a 30-kDa N-terminal and a 35-kDa C-terminal fragment, respectively. Similarly, mosquito larvae processed in vivo the parasporal inclusions, generating the same fragments as those observed in vitro. The Cry11Bb1 protoxin activated with trypsin or gut proteases showed larvicidal activity against C. quinquefasciatus first instar larvae. The data suggest that gut proteases participate in the activation of CryllBbl protoxin, generating at least two different fragments on which the activity could reside.     

Purification of the insecticidal toxin from the parasporal crystal of Bacillus thuringiensis subsp. kurstaki

The insecticidal toxin of $\text{Bacillus}\text{thuringiensis}$ subsp. $\text{kurstaki}$ was isolated from parasporal crystals. The toxin, which is stable for several months, is a glycoprotein with an apparent molecular weight of 68,000 that is generated upon solubilization and activation of a higher molecular weight protoxin (MW_app = 1.3 × 10⁵) at alkaline pH. The toxin was purified by gel filtation and anion exchange chromatography and its molecular weight was established by gel filtration chromatography and SDS polyacrylamide gel electrophoresis.     

Secreted proteases from Photorhabdus luminescens: separation of the extracellular proteases from the insecticidal Tc toxin complexes

Photorhabdus luminescens secretes both high molecular weight insecticidal toxin complexes and also a range of extracellular proteases into culture broth. Previous studies by others have suggested that insecticidal activity of the broth is associated with these proteases. However, by gene cloning and targeted knock-out, we have previously shown that oral insecticidal activity is associated with high molecular weight 'toxin complexes' (Tc) encoded by toxin complex or tc genes. Here we further clarify this distinction by biochemically separating the protease fractions away from the oral insecticidal activity of the Tc proteins. We purified three distinct protease fractions from the broth: one consisting of a single species of 55 kDa and two of several putatively related species of approximately 40 kDa. All of these clearly separate from the oral insecticidal activity associated with the high molecular weight Tc proteins and also show no effect on insect weight gain following injection into the haemocoel. Here we examine the substrate preferences and inhibitor profiles of these protease fractions and discuss their relationship with those previously described from other P. luminescens strains and phase variants.     

Detection of chromosomally located and plasmid-borne genes on 20 kb DNA fragments in parasporal crystals from <Emphasis Type="Italic">Bacillus thuringiensis</Emphasis>

The association of 20 kb heterologous DNA fragments with the parasporal crystals from native and recombinant Bacillus thuringiensis strains was analyzed, respectively. The cry2Aa10 gene cloned in plasmid pHC39 was transformed into B. thuringiensis subsp. kurstaki strains CryˉB and HD73, producing recombinant strains CryˉB(pHC39) and HD73(pHC39). SDS-PAGE and scanning electron microscopy analyses demonstrated that the recombinant CryˉB(pHC39) produced cuboidal crystals of Cry2Aa10 protoxin, while recombinant HD73(pHC39) produced both bipyramidal crystals of Cry1Ac1 protoxin and cuboidal crystals of Cry2Aa10 protoxin. Bioassay results proved that recombinant HD73(pHC39) showed higher insecticidal activity to Helicoverpa armigera than CryˉB(pHC39). It was found that 20 kb DNA fragments were present in bipyramidal and cuboidal crystals from both native and recombinant strains, and the 20 kb heterologous DNAs contained chromosome-specific and resident large plasmid-borne DNA fragments, suggesting the 20 kb heterologous DNA fragment embodied in crystals came randomly from the bacterial chromosomal and plasmid genome. This was the first investigation devoted exclusively on the origin of 20 kb DNA fragments in the parasporal crystals of B. thuringiensis. The data provides a basis for further investigation of the origin of 20 kb DNAs in the crystals and the interaction of DNA and protoxins.     

Lectin-like binding of Bacillus thuringiensis var. kurstaki lepidopteran-specific toxin is an initial step in insecticidal action

The two delta-endotoxins comprising the Bacillus thuringiensis var. kurstaki HD1 insecticidal protein crystal were separated. The lepidopteran-specific protoxin was activated in vitro and its mechanism of action investigated. Toxicity towards Choristoneura fumiferana CF1 cells was specifically inhibited by preincubation of the toxin with N-acetylgalactosamine and N-acetylneuraminic acid. The lectins soybean agglutinin and wheat germ agglutinin, which bind N-acetylgalactosamine, also inhibited toxicity. Since N-acetylneuraminic acid is not known to occur in insects, these results suggest that the toxin may recognise a specific plasma membrane glycoconjugate receptor with a terminal N-acetylgalactosamine residue.     

The interactions between soybean trypsin inhibitor and delta-endotoxin of Bacillus thuringiensis in Helicoverpa armigera larva

No significant difference in larval mortality was observed when a sublethal dose of Bacillus thuringiensis (Bt) var. kurstaki HD-1 crystal was supplemented with soybean trypsin inhibitor (STI) in the artificial diet fed to Helicoverpa armigera in the laboratory, but supplementing a nonlethal dose of crystal with STI in the diet led to a pronounced reduction of larval growth. This concentration of crystal and two lower concentrations of STI alone had no significant effects on larval growth. The results of substrate-gel electrophoresis demonstrated that the proteases in the H. armigera midgut fluid responsible for the degradation of protoxin consisted of at least four proteases with molecular weights of 71, 49, 36, and 30 kDa. All four proteases could utilize casein also as the substrate. When larvae were fed with STI or Bt + STI, the proteolytic activities of the 49-kDa enzyme disappeared, and the activities of the other three enzymes were reduced. Enzyme assays also indicated that feeding larvae with diets containing Bt, STI, or Bt + STI significantly decreased the specific activities of larval general proteases and the trypsin-like enzyme. The protein concentration of midgut fluid was elevated, especially in the larvae fed on the diets containing STI and Bt + STI. Both in vitro and in vivo studies showed that the degradation of protoxin and toxin could be inhibited by soybean trypsin inhibitors, but when the incubation time was prolonged, the protoxin could be degraded completely, while the degradation of toxin was inhibited further. This suggested that the retention time of toxins in the larval midgut was extended and synergism between insecticidal crystal protein and soybean trypsin inhibitor occurred, which showed as the inhibition of H. armigera larval growth.     

Intracellular proteases in sporulated Bacillus thuringiensis subsp. kurstaki and their role in protoxin activation

The intracellular proteases in sporulated Bacillus thuringiensis subsp. kurstaki were studied to identify the endogenous proteases involved in the activation of protoxin. The proteases obtained with 30% ammonium sulfate saturation were analysed by both gelatin zymography and azocasein hydrolysis. Three proteases with molecular mass 92 kDa, 78 kDa and 69 kDa were identified on gelatin gel and their gelatinolytic activity was inhibited by ethylenediamine tetraacetic acid. Significantly, 1,10-phenanthroline caused an inhibition of the azocasein hydrolytic activity by 98% and ethylenediamine tetraacetic acid by 28%. The three proteases were heat-stable at 65 °C, while the 69-kDa protease was active up to 75 °C. Intracellular protease-deficient mutants (ethyl methanesulfonate mutagenesis) could not generate the active toxin suggesting the existence of a specific enzyme affecting the conversion of protoxin to toxin.     

Selection and characterization of a proteo-chitinolytic strain of Bacillus thuringiensis,able to grow in shrimp waste media

This paper reports the selection and characterization of Bacillus thuringiensis strains, with ability to grow in a proteo-chitinaceous substrate (milled shrimp waste) as the sole ingredient. Selected strains were able to produce crystal proteins, as well as proteases and chitinases as fermentation by-products. By a preliminary, qualitative screening of 152 B. thuringiensis strains, grown on media rich in protein and chitin, eight strains were selected. These strains were cultured in a liquid medium containing milled shrimp waste and their kinetics of protease production were followed. The two most active proteolytic strains (Bt-103 and Bt-112) were characterized by their crystal protein content, plasmid profiles, crystal ultrastructure, and toxicity towards Manduca sexta, Aedes aegypti and Leptinotarsa texana. The only activity recorded in these species was moderate toxicity of strain Bt-112 against Manduca sexta first instar larvae, as well as the highest proteolytic and chitinolytic activities. Its bipyramidal crystals were associated with semi-cuboidal inclusions and although its crystal proteins were similar to those of B. thuringiensis kurstaki (HD-1), its plasmid content was quite different. Serotyping of Bt-112 indicated that it belongs to serovar. tolworthi. Further studies with a similar strategy might render more strains with ability to grow in a rich waste by-product like the shrimp waste, which may show not only higher insecticidal activity, but also with the ability to produce extracellular enzymes with biotechnological applications.     

Monoclonal Antibody Analysis and Insecticidal Spectrum of Three Types of Lepidopteran-Specific Insecticidal Crystal Proteins of Bacillus thuringiensis

We have investigated the protein composition and the insecticidal spectrum of crystals of 29 Bacillus thuringiensis strains active against lepidopteran larvae. All crystals contained proteins of 130 to 140 kilodaltons (kDa) which could be grouped into three types by the molecular weight of the protoxin and the trypsin-activated core fragment. Proteins of the three types showed a characteristic insecticidal spectrum when tested against five lepidopteran species. Type A crystal proteins were protoxins of 130 or 133 kDa, which were processed into 60-kDa toxins by trypsin. Several genes encoding crystal proteins of this type have been cloned and sequenced earlier. They are highly conserved in the N-terminal half of the toxic fragment and were previously classified in three subtypes (the 4.5-, 5.3-, and 6.6-kilobase subtypes) based on the restriction map of their genes. The present study shows that different proteins of these three subtypes were equally toxic against Manduca sexta and Pieris brassicae and had no detectable activity against Spodoptera littoralis. However, the 4.5-, 5.3-, and 6.6-kilobase subtypes differed in their toxicity against Heliothis virescens and Mamestra brassicae. Type B crystal proteins consisted of 140-kDa protoxins with a 55-kDa tryptic core fragment. These were only active against one of the five insect species tested (P. brassicae). The protoxin and the trypsin-activated toxin of type C were 135- and 63-kDa proteins, respectively. Proteins of this type were associated with high toxicity against S. littoralis and M. brassicae. A panel of 35 monoclonal antibodies was used to compare the structural characteristics of crystal proteins of the three different types and subtypes. Each type of protein could be associated with a typical epitope structure, indicating an unambiguous correlation between antigenic structure and insect specificity.     

Photorhabdus luminescens W-14 insecticidal activity consists of at least two similar but distinct proteins. Purification and characterization of toxin A and toxin B

Both the bacterium Photorhabdus luminescens alone and its symbiotic Photorhabdus-nematode complex are known to be highly pathogenic to insects. The nature of the insecticidal activity of Photorhabdus bacteria was investigated for its potential application as an insect control agent. It was found that in the fermentation broth of P. luminescens strain W-14, at least two proteins, toxin A and toxin B, independently contributed to the oral insecticidal activity against Southern corn rootworm. Purified toxin A and toxin B exhibited single bands on native polyacrylamide gel electrophoresis and two peptides of 208 and 63 kDa on SDS-polyacrylamide gel electrophoresis. The native molecular weight of both the toxin A and toxin B was determined to be approximately 860 kDa, suggesting that they are tetrameric. NH2-terminal amino acid sequencing and Western analysis using monospecific antibodies to each toxin demonstrated that the two toxins were distinct but homologous. The oral potency (LD50) of toxin A and toxin B against Southern corn rootworm larvae was determined to be similar to that observed with highly potent Bt toxins against lepidopteran pests. In addition, it was found that the two peptides present in toxin B could be processed in vitro from a 281-kDa protoxin by endogenous P. luminescens proteases. Proteolytic processing was shown to enhance insecticidal activity.     

Active form of dipteran-specific insecticidal protein cryllA produced by Bacillus thuringiensis subsp. israelensis

The nucleotide sequence of the cry11A gene from Bacillus thuringiensis subsp. israelensis strain HD522 was analyzed and the molecular characterization of CryllA toxin was done. The 70-kDa CryllA protoxin was processed in vitro into 36- and 32-kDa fragments by trypsin and into 34- and 32-kDa fragments by gut proteases from C. pipiens. These two processed fragments are associated together to form the heterodimer. The results of the binding assay with BBMV and the bioassay toward C. pipiens larvae suggested that the heterodimer was biologically as active as the non-digested CryllA toxin and the intramolecular cleavage did not promote the insecticidal activity. These results suggested that a probable complex of the 36- or 34-kDa and 32-kDa fragments was also one of the possible active forms of Cry11A, and that the biological functions of CryllA was not essentially affected by the intramolecular cleavage of the 70-kDa protein.     

Characterization of the toxicity and cytopathic specificity of a cloned Bacillus thuringiensis crystal protein using insect cell culture

An insecticidal protein gene from Bacillus thuringiensis var. aizawai was cloned in Escherichia coli. The cloned gene expressed at a high level and the synthesized protein appeared as an insoluble, phase-bright inclusion in the cytoplasm. These inclusions were isolated by density gradient centrifugation, the isolated protein was activated in vitro by different proteolytic regimes and the toxicity of the resulting preparations was studied using insect cells grown in tissue culture. The inclusions consisted of a 130 kDa polypeptide which was processed to a protease-resistant 55 kDa protein by tryptic digestion. This preparation lysed lepidopteran (Choristoneura fumiferana) CF1 cells but not dipteran (Aedes albopictus) cells. When the crystal protein was activated by sequential treatment, first with trypsin and then with Aedes aegypti gut proteases, the resulting 53 kDa polypeptide was now toxic only to the dipteran cells and not to the lepidopteran cells. Thus the dual specificity of this var. aizawai toxin results from differential proteolytic processing of a single protoxin. The trypsin-activated preparation was weakly active against Spodoptera frugiperda cells. Membrane binding studies of the trypsin-activated toxin revealed a 68 kDa protein in the lepidopteran cell membranes, which may be the receptor for this toxin.     

Cloning of the nprA gene for neutral protease A of Bacillus thuringiensis and effect of in vivo deletion of nprA on insecticidal crystal protein.

The nprA gene, encoding Bacillus thuringiensis neutral protease A, was cloned by the use of gene-specific oligonucleotides. The size of neutral protease A deduced from the nprA sequence was 566 amino acids (60,982 Da). The cloned nprA gene was partially deleted in vitro, and the deleted allele, designated nprA3, was used to construct an nprA3 strain (neutral protease A-deficient strain) of B. thuringiensis. Growth and sporulation of the nprA3 strain were similar to those of an isogenic nprA+ strain, although the extracellular proteolytic activity of the nprA3 strain was significantly less than that of the nprA+ strain. The nprA3 strain produced insecticidal crystal proteins that were more stable than those of the isogenic nprA+ strain after solubilization in vitro, and sporulated cultures of the nprA3 strain contained higher concentrations of full-length insecticidal crystal proteins than did those of its isogenic counterpart. The absence of neutral protease A did not affect the insecticidal activity of a lepidopteran-specific crystal protein of B. thuringiensis. These results indicate that crystal protein stability and yield may be improved by deletion of specific proteases from B. thuringiensis.     

Effects of pH on conformational properties related to the toxicity of Bacillus thuringiensis delta-endotoxin.

The delta-endotoxin of Bacillus thuringiensis subspecies kurstaki is an intracellular crystalline proteinaceous inclusion which, upon ingestion, is toxic to lepidopteran insects. Upon dissolution at pH > 9 it yields a protein subunit called protoxin. Under appropriate conditions, protoxin is hydrolyzed to a toxin molecule, which is responsible for killing the insect. It is known that this toxic activity decreases considerably above pH 10. In this study, circular dichroism spectroscopy has been used to examine the secondary structures of the protoxin and toxin molecules at different pH values to determine if there are detectable conformational changes associated with their pH-dependent functional properties. At pH 10, where toxic activity is approximately maximal, both the protoxin and toxin molecules were found to assume a conformation that is on an average approx. 26% alpha-helix and approx. 45% beta-structure. As the pH was increased above 10, where the insecticidal activity decreases, the magnitude of the CD spectrum at 222 nm decreased for protoxin and the calculated alpha-helix contents of both protoxin and toxin molecules decreased. The net secondary structure did not change significantly at pH values below 10. Significant conformational differences are observed between the secondary structure of the protoxin and toxin molecules at different pH values. The pH-dependent changes in secondary structure of the protoxin and toxin can be correlated with the effects of pH on the insecticidal activity of these proteins.