Production of <Emphasis Type="SmallCaps">l</Emphasis>-phenylalanine from glycerol by a recombinant <Emphasis Type="Italic">Escherichia coli</Emphasis>

The production of l-phenylalanine is conventionally carried out by fermentations that use glucose or sucrose as the carbon source. This work reports on the use of glycerol as an inexpensive and abundant sole carbon source for producing l-phenylalanine using the genetically modified bacterium Escherichia coli BL21(DE3). Fermentations were carried out at 37°C, pH 7.4, using a defined medium in a stirred tank bioreactor at various intensities of impeller agitation speeds (300–500 rpm corresponding to 0.97–1.62 m s⁻¹ impeller tip speed) and aeration rates (2–8 L min⁻¹, or 1–4 vvm). This highly aerobic fermentation required a good supply of oxygen, but intense agitation (impeller tip speed ~1.62 m s⁻¹) reduced the biomass and l-phenylalanine productivity, possibly because of shear sensitivity of the recombinant bacterium. Production of l-phenylalanine was apparently strongly associated with growth. Under the best operating conditions (1.30 m s⁻¹ impeller tip speed, 4 vvm aeration rate), the yield of l-phenylalanine on glycerol was 0.58 g g⁻¹, or more than twice the best yield attainable on sucrose (0.25 g g⁻¹). In the best case, the peak concentration of l-phenylalanine was 5.6 g L⁻¹, or comparable to values attained in batch fermentations that use glucose or sucrose. The use of glycerol for the commercial production of l-phenylalanine with E. coli BL21(DE3) has the potential to substantially reduce the cost of production compared to sucrose- and glucose-based fermentations.     

Factors affecting the production of <Emphasis Type="SmallCaps">l</Emphasis>-xylulose by resting cells of recombinant <Emphasis Type="Italic">Escherichia coli</Emphasis>

Factors affecting the production of the rare sugar l-xylulose from xylitol using resting cells were investigated. An E. coli BPT228 strain that recombinantly expresses a gene for xylitol dehydrogenase was used in the experiments. The ratio of xylitol to l-xylulose was three times lower in the cytoplasm than in the medium. The effects of pH, temperature, shaking speed, and initial xylitol concentration on l-xylulose production were investigated in shaking flasks using statistical experimental design methods. The highest production rates were found at high shaking speed and at high temperature (over 44°C). The optimal pH for both productivity and conversion was between 7.5 and 8.0, and the optimal xylitol concentration was in the range 250–350 g l⁻¹. A specific productivity of 1.09 ± 0.10 g g⁻¹ h⁻¹ was achieved in a bioreactor. The response surface model based on the data from the shake flask experiments predicted the operation of the process in a bioreactor with reasonable accuracy.     

Heterologous expression and characterization of <Emphasis Type="Italic">Bacillus coagulans</Emphasis><Emphasis Type="SmallCaps">l</Emphasis>-arabinose isomerase

Bacillus coagulans has been of great commercial interest over the past decade owing to its strong ability of producing optical pure l-lactic acid from both hexose and pentose sugars including l-arabinose with high yield, titer and productivity under thermophilic conditions. The l-arabinose isomerase (L-AI) from Bacillus coagulans was heterologously over-expressed in Escherichia coli. The open reading frame of the L-AI has 1,422 nucleotides encoding a protein with 474 amino acid residues. The recombinant L-AI was purified to homogeneity by one-step His-tag affinity chromatography. The molecular mass of the enzyme was estimated to be 56 kDa by SDS-PAGE. The enzyme was most active at 70°C and pH 7.0. The metal ion Mn²⁺ was shown to be the best activator for enzymatic activity and thermostability. The enzyme showed higher activity at acidic pH than at alkaline pH. The kinetic studies showed that the K _m, V _max and k _cat/K _m for the conversion of l-arabinose were 106 mM, 84 U/mg and 34.5 mM⁻¹min⁻¹, respectively. The equilibrium ratio of l-arabinose to l-ribulose was 78:22 under optimal conditions. l-ribulose (97 g/L) was obtained from 500 g/l of l-arabinose catalyzed by the enzyme (8.3 U/mL) under the optimal conditions within 1.5 h, giving at a substrate conversion of 19.4% and a production rate of 65 g L⁻¹ h⁻¹.     

Biotechnological production of <Emphasis Type="SmallCaps">l</Emphasis>-ribose from <Emphasis Type="SmallCaps">l</Emphasis>-arabinose

l-Ribose is a rare and expensive sugar that can be used as a precursor for the production of l-nucleoside analogues, which are used as antiviral drugs. In this work, we describe a novel way of producing l-ribose from the readily available raw material l-arabinose. This was achieved by introducing l-ribose isomerase activity into l-ribulokinase-deficient Escherichia coli UP1110 and Lactobacillus plantarum BPT197 strains. The process for l-ribose production by resting cells was investigated. The initial l-ribose production rates at 39°C and pH 8 were 0.46 ± 0.01 g g⁻¹ h⁻¹ (1.84 ± 0.03 g l⁻¹ h⁻¹) and 0.27 ± 0.01 g g⁻¹ h⁻¹ (1.91 ± 0.1 g l⁻¹ h⁻¹) for E. coli and for L. plantarum, respectively. Conversions were around 20% at their highest in the experiments. Also partially purified protein precipitates having both l-arabinose isomerase and l-ribose isomerase activity were successfully used for converting l-arabinose to l-ribose.     

Continuous 2-keto-<Emphasis Type="SmallCaps">l</Emphasis>-gulonic acid fermentation from <Emphasis Type="SmallCaps">l</Emphasis>-sorbose by <Emphasis Type="Italic">Ketogulonigenium vulgare</Emphasis> DSM 4025

A single-stage continuous fermentation process for the production of 2-keto-l-gulonic acid (2KGA) from l-sorbose using Ketogulonigenium vulgare DSM 4025 was developed. The chemostat culture with the dilution rate that was calculated based on the relationship between the 2KGA production rate and the 2KGA concentration was feasible for production with high concentration of 2KGA. In this system, 112.2 g/L of 2KGA on the average was continuously produced from 114 g/L of l-sorbose. A steady state of the fermentation was maintained for the duration of more than 110 h. The dilution rate was kept in the range of 0.035 and 0.043 h⁻¹, and the 2KGA productivity was 3.90 to 4.80 g/L/h. The average molar conversion yield of 2KGA from l-sorbose was 91.3%. Under the optimal conditions, l-sorbose concentration was kept at 0 g/L. Meanwhile, the dissolved oxygen level was changing in response to the dilution rate and 2KGA concentration. In the dissolved oxygen (DO) range of 16% to 58%, it was revealed that the relationship between DO and D possessed high degree of positive correlation under the l-sorbose limiting condition (complete consumption of l-sorbose). Increasing D closer to the critical value for washing out point of the continuous fermentation, DO value tended to be gradually increased up to 58%. In conclusion, an efficient and reproducible continuous fermentation process for 2KGA production by K. vulgare DSM 4025 could be developed using a medium containing baker’s yeast without using a second helper microorganism.     

Characterization of ribose-5-phosphate isomerase of <Emphasis Type="Italic">Clostridium thermocellum</Emphasis> producing <Emphasis Type="SmallCaps">d</Emphasis>-allose from <Emphasis Type="SmallCaps">d</Emphasis>-psicose

The rpiB gene, encoding ribose-5-phosphate isomerase (RpiB) from Clostridium thermocellum, was cloned and expressed in Escherichia coli. RpiB converted d-psicose into d-allose but it did not convert d-xylose, l-rhamnose, d-altrose or d-galactose. The production of d-allose by RpiB was maximal at pH 7.5 and 65°C for 30 min. The half-lives of the enzyme at 50°C and 65°C were 96 h and 4.7 h, respectively. Under stable conditions of pH 7.5 and 50°C, 165 g d-allose l⁻¹ was produced without by-products from 500 g d-psicose l⁻¹ after 6 h.     

Regulation of metabolite production by precursors and elicitors in liquid cultures of <Emphasis Type="Italic">Hypericum perforatum</Emphasis>

Four precursors (l-phenylalanine, l-tryptophan, cinnamic acid and emodin) and one signal elicitor (methyl jasmonate, MeJA) were added to liquid cultures of Hypericum perforatum L. to study their effect on production of hyperforin and hypericins (pseudohypericin and hypericin). The addition of l-phenylalanine (75 to 100 mg l⁻¹) enhanced production of hypericins, but hyperforin levels were decreased. Hypericin, pseudohypericin and hyperforin concentrations were all decreased when l-tryptophan (25 to 100 mg l⁻¹) was added to the medium. However, addition of l-tryptophan (50 mg l⁻¹) with MeJA (100 μM) stimulated hyperforin production significantly (1.81-fold) and resulted in an increased biomass. Cinnamic acid (25, 50 mg l⁻¹) and emodin (1.0 to 10.0 mg l⁻¹) each enhanced hyperforin accumulation in H. perforatum, but did not affect accumulation of hypericins.     

Metabolic engineering of <Emphasis Type="Italic">Escherichia coli</Emphasis> for improving <Emphasis Type="SmallCaps">l</Emphasis>-3,4-dihydroxyphenylalanine (<Emphasis Type="SmallCaps">l</Emphasis>-DOPA) synthesis from glucose

l-3,4-dihydroxyphenylalanine (l-DOPA) is an aromatic compound employed for the treatment of Parkinson's disease. Metabolic engineering was applied to generate Escherichia coli strains for the production of l-DOPA from glucose by modifying the phosphoenolpyruvate:sugar phosphotransferase system (PTS) and aromatic biosynthetic pathways. Carbon flow was directed to the biosynthesis of l-tyrosine (l-Tyr), an l-DOPA precursor, by transforming strains with compatible plasmids carrying genes encoding a feedback-inhibition resistant version of 3-deoxy-d-arabino-heptulosonate-7-phosphate synthase, transketolase, the chorismate mutase domain from chorismate mutase-prephenate dehydratase from E. coli and cyclohexadienyl dehydrogenase from Zymomonas mobilis. The effects on l-Tyr production of PTS inactivation (PTS⁻ gluc⁺ phenotype), as well as inactivation of the regulatory protein TyrR, were evaluated. PTS inactivation caused a threefold increase in the specific rate of l-Tyr production (q _l-Tyr), whereas inactivation of TyrR caused 1.7- and 1.9-fold increases in q _l-Tyr in the PTS⁺ and the PTS⁻ gluc⁺ strains, respectively. An 8.6-fold increase in l-Tyr yield from glucose was observed in the PTS⁻ gluc⁺ tyrR ⁻ strain. Expression of hpaBC genes encoding the enzyme 4-hydroxyphenylacetate 3-hydroxylase from E. coli W in the strains modified for l-Tyr production caused the synthesis of l-DOPA. One of such strains, having the PTS⁻ gluc⁺ tyrR ⁻ phenotype, displayed the best production parameters in minimal medium, with a specific rate of l-DOPA production of 13.6 mg/g/h, l-DOPA yield from glucose of 51.7 mg/g and a final l-DOPA titer of 320 mg/l. In a batch fermentor culture in rich medium this strain produced 1.51 g/l of l-DOPA in 50 h.     

Development of medium for enhanced production of glutaminase-free <Emphasis Type="SmallCaps">l</Emphasis>-asparaginase from <Emphasis Type="Italic">Pectobacterium carotovorum</Emphasis> MTCC 1428

Glutaminase-free l-asparaginase is known to be an excellent anticancer agent. In the present study, statistically based experimental designs were applied to maximize the production of glutaminase-free l-asparaginase from Pectobacterium carotovorum MTCC 1428. Nine components of the medium were examined for their significance on the production of l-asparaginase using the Plackett–Burman experimental design. The medium components, viz., glucose, l-asparagine, KH₂PO₄, and MgSO₄·7H₂O, were screened based on their high confidence levels (P < 0.04). The optimum levels of glucose, l-asparagine, KH₂PO₄, and MgSO₄·7H₂O were found to be 2.076, 5.202, 1.773, and 0.373 g L⁻¹, respectively, using the central composite experimental design. The maximum specific activity of l-asparaginase in the optimized medium was 27.88 U mg⁻¹ of protein, resulting in an overall 8.3-fold increase in the production compared to the unoptimized medium.     

Optimization of the solvent-tolerant <Emphasis Type="Italic">Pseudomonas putida</Emphasis> S12 as host for the production of <Emphasis Type="Italic">p</Emphasis>-coumarate from glucose

A Pseudomonas putida S12 strain was constructed that is able to convert glucose to p-coumarate via the central metabolite l-tyrosine. Efficient production was hampered by product degradation, limited cellular l-tyrosine availability, and formation of the by-product cinnamate via l-phenylalanine. The production host was optimized by inactivation of fcs, the gene encoding the first enzyme in the p-coumarate degradation pathway in P. putida, followed by construction of a phenylalanine-auxotrophic mutant. These steps resulted in a P. putida S12 strain that showed dramatically enhanced production characteristics with controlled l-phenylalanine feeding. During fed-batch cultivation, 10 mM (1.7 g l⁻¹) of p-coumarate was produced from glucose with a yield of 3.8 Cmol% and a molar ratio of p-coumarate to cinnamate of 85:1.     

Biological acidification during grape must fermentation using mixed cultures of <Emphasis Type="Italic">Kluyveromyces thermotolerans</Emphasis> and <Emphasis Type="Italic">Saccharomyces cerevisiae</Emphasis>

Four mixed culture fermentations of grape must were carried out with Kluyveromyces thermotolerans strain TH941 and Saccharomyces cerevisiae strain SCM952. In the first culture, both yeasts were added together, whereas in the remaining three cultures S. cerevisiae was added 1, 2, and 3 days after the inoculation of K. thermotolerans. The growth and survival of the K. thermotolerans strain and the amount of the produced l-lactic acid depend on the time of inoculation of the S. cerevisiae strain and provided an effective acidification during alcoholic fermentation. The four cultures contained, respectively, at the end of fermentation 0.18, 1.80, 4.28, and 5.13 g l-lactic acid l⁻¹. The grape must with an initial pH of 3.50 was effectively acidified (70% increase in titratable acidity, 0.30 pH unit decrease) by the production of 5.13 g l-lactic acid l⁻¹.     

Purification and properties of <Emphasis Type="Italic">Saccharomyces cerevisiae</Emphasis><Emphasis Type="Italic">S</Emphasis>-adenosylmethionine synthetase expressed in recombinant <Emphasis Type="Italic">Pichia pastoris</Emphasis>

An intracellular S-adenosylmethionine synthetase (SAM-s) was purified from the fermentation broth of Pichia pastoris GS115 by a sequence chromatography column. It was purified to apparent homogeneity by (NH₄)₂SO₄ fractionation (30–60%), anion exchange, hydrophobic interaction, anion exchange and gel filtration chromatography. HPLC showed the purity of purified SAM-s was 91.2%. The enzyme was purified up to 49.5-fold with a final yield of 20.3%. The molecular weight of the homogeneous enzyme was 43.6 KDa, as determined by electro-spray ionization mass spectrometry (ESI-MS). Its isoelectric point was approximately 4.7, indicating an acidic character. The optimum pH and temperature for the enzyme reaction were 8.5 and 35 °C, respectively. The enzyme was stable at pH 7.0–9.0 and was easy to inactivate in acid solution (pH ≤ 5.0). The temperature stability was up to 45 °C. Metal ions, such as, Mn²⁺ and K⁺ at the concentration of 5 mM had a slight activation effect on the enzyme activity and the Mg²⁺ activated the enzyme significantly. The enzyme activity was strongly inhibited by heavy metal ions (Cu²⁺ and Ag²⁺) and EDTA. The purified enzyme from the transformed Pichia pastoris synthesized S-adenosylmethionine (SAM) from ATP and l-methionine in vitro with a K _m of 120 and 330 μM and V _max of 8.1 and 23.2 μmol/mg/min for l-methionine and ATP, respectively.     

<Emphasis Type="SmallCaps">l</Emphasis>-Proline nutrition and catabolism in <Emphasis Type="Italic">Staphylococcus saprophyticus</Emphasis>

Staphylococcus saprophyticus strains ATCC 15305, ATCC 35552, and ATCC 49907 were found to require l-proline but not l-arginine for growth in a defined culture medium. All three strains could utilize l-ornithine as a proline source and contained l-ornithine aminotransferase and Δ¹-pyrroline-5-carboxylate reductase activities; strains ATCC 35552 and ATCC 49907 could use l-arginine as a proline source and had l-arginase activity. The proline requirement also could be met by l-prolinamide, l-proline methyl ester, and the dipeptides l-alanyl-l-proline and l-leucyl-l-proline. The bacteria exhibited l-proline degradative activity as measured by the formation of Δ¹-pyrroline-5-carboxylate. The specific activity of proline degradation was not affected by addition of l-proline or NaCl but was highest in strain ATCC 49907 after growth in Mueller–Hinton broth. A membrane fraction from this strain had l-proline dehydrogenase activity as detected both by reaction of Δ¹-pyrroline-5-carboxylate with 2-aminobenzaldehyde (0.79 nmol min⁻¹ mg⁻¹) and by the proline-dependent reduction of p-iodonitrotetrazolium (20.1 nmol min⁻¹ mg⁻¹). A soluble fraction from this strain had Δ¹-pyrroline-5-carboxylate dehydrogenase activity (88.8 nmol min⁻¹ mg⁻¹) as determined by the NAD⁺-dependent oxidation of dl-Δ¹-pyrroline-5-carboxylate. Addition of l-proline to several culture media did not increase the growth rate or final yield of bacteria but did stimulate growth during osmotic stress. When grown with l-ornithine as the proline source, S. saprophyticus was most susceptible to the proline analogues L-azetidine-2-carboylate, 3,4-dehydro-dl-proline, dl-thiazolidine-2-carboxylate, and l-thiazolidine-4-carboxylate. These results indicate that proline uptake and metabolism may be a potential target of antimicrobial therapy for this organism.     

Enzymatic production of <Emphasis Type="SmallCaps">l</Emphasis>-amino acids from the corresponding <Emphasis Type="SmallCaps">dl</Emphasis>-5-substituted hydantoins by <Emphasis Type="Italic">Bacillus fordii</Emphasis> MH602

Bacillus fordii MH602 was newly screened from soil at 45 °C and exhibited high activities of hydantoinase and carbamoylase, efficiently yielding l-amino acids including phenylalanine, phenylglycine and tryptophan with the bioconversion yield of 60–100% from the corresponding dl-5-substituted hydantoins. Hydantoinase activity was found to be cell-associated and inducible. The optimal inducer was dl-5-methylhydantoin with concentration of 0.014 mol L⁻¹ and added to the fermentation medium in the exponential phase of growth. In the production of optically pure amino acids from dl-5-benylhydantoin, the optimal temperature and pH of this reaction were 45–50 °C and 7.5 respectively. The hydantoinase was non-stereoselective, while carmbamoylase was l-selective. The hydantoinase activity was not subject to substrate inhibition, or product inhibition by ammonia. In addition, The activities of both enzymes from crude extract of the strain were thermostable; the hydantoinase and carbamoylase retained about 90% and 60% activity after 6 h at 50 °C, respectively. Since reaction at higher temperature is advantageous for enhancement of solubility and for racemization of dl-5-substituted hydantoins, the relative paucity of l-selective hydantoinase systems, together with the high level of hydantoinase and carbamoylase activity and unusual substrate selectivity of the strain MH602, suggest that it has significant potential applications.     

Effect of growth rate on the production of<Emphasis Type="SmallCaps">l</Emphasis>-proline in the fed-batch culture of<Emphasis Type="Italic">Corynebacterium acetoacidophilum</Emphasis>

Corynebacterium acetoacidophilum RYU3161 was cultivated in al-histidine-limited fed-batch culture. To investigate the effect of cell growth on thel-proline production, 5l fed-batch culture was performed using an exponential feeding rate to obtain the specific growth rates (μ) of 0.04, 0.06, 0.08, and 0.1 h⁻¹. The results show that the highest production ofl-proline was obtained at μ=0.04 h⁻¹. The specificl-proline production rate (Q_p) increased proportionally as a function of the specific growth rate, but decreased after it revealed the maximum value at μ=0.08 h⁻¹. Thus, the highest productivity ofl-proline was 1.66 g L⁻¹ h⁻¹ at μ=0.08 h⁻¹. The results show that the production of L-proline inC. acetoacidophilum RYU3161 has mixed growth-associated characteristics.     

Effect of temperature on <Emphasis Type="SmallCaps">d</Emphasis>-arabitol production from lactose by <Emphasis Type="Italic">Kluyveromyces lactis</Emphasis>

d-Arabitol production from lactose by Kluyveromyces lactis NBRC 1903 has been studied by following the time courses of concentrations of cell mass, lactose, d-arabitol, ethanol, and glycerol at different temperatures. It was found that temperature is a key factor in d-arabitol production. Within temperatures ranging from 25 to 39°C, the highest d-arabitol concentration of 99.2 mmol l⁻¹ was obtained from 555 mmol l⁻¹ of lactose after 120 h of batch cultivation at 37°C. The yield of d-arabitol production on cell mass growth increased drastically at temperatures higher than 35°C, and the yield reached 1.07 at 39°C. Increasing the cell mass concentration two-fold after 24 h of culture growth at 37°C, the d-arabitol concentration further increased to 168 mmol l⁻¹. According to the distribution of the metabolic products, metabolic changes related to growth phase were also discussed. The stationary-phase K. lactis cells in the batch culture that is started with exposing the precultured inoculum to high osmotic stress, high oxidative stress, and high heat stress are found to be preferable for d-arabitol production.     

Cloning and characterization of a novel <Emphasis Type="SmallCaps">l</Emphasis>-arabinose isomerase from <Emphasis Type="Italic">Bacillus licheniformis</Emphasis>

Based on analysis of the genome sequence of Bacillus licheniformis ATCC 14580, an isomerase-encoding gene (araA) was proposed as an l-arabinose isomerase (L-AI). The identified araA gene was cloned from B. licheniformis and overexpressed in Escherichia coli. DNA sequence analysis revealed an open reading frame of 1,422 bp, capable of encoding a polypeptide of 474 amino acid residues with a calculated isoelectric point of pH 4.8 and a molecular mass of 53,500 Da. The gene was overexpressed in E. coli, and the protein was purified as an active soluble form using Ni–NTA chromatography. The molecular mass of the purified enzyme was estimated to be ~53 kDa by sodium dodecyl sulfate–polyacrylamide gel electrophoresis and 113 kDa by gel filtration chromatography, suggesting that the enzyme is a homodimer. The enzyme required a divalent metal ion, either Mn²⁺or Co²⁺, for enzymatic activity. The enzyme had an optimal pH and temperature of 7.5 and 50°C, respectively, with a k _cat of 12,455 min⁻¹ and a k _cat/K _m of 34 min⁻¹ mM⁻¹ for l-arabinose, respectively. Although L-AIs have been characterized from several other sources, B. licheniformis L-AI is distinguished from other L-AIs by its wide pH range, high substrate specificity, and catalytic efficiency for l-arabinose, making B. licheniformis L-AI the ideal choice for industrial applications, including enzymatic synthesis of l-ribulose. This work describes one of the most catalytically efficient L-AIs characterized thus far.     

An efficient succinic acid production process in a metabolically engineered <Emphasis Type="Italic">Corynebacterium glutamicum</Emphasis> strain

A Corynebacterium glutamicum strain (ΔldhA-pCRA717) that overexpresses the pyc gene encoding pyruvate carboxylase while simultaneously exhibiting a disrupted ldhA gene encoding l-lactate dehydrogenase was investigated in detail for succinic acid production. Succinic acid was shown to be efficiently produced at high-cell density under oxygen deprivation with intermittent addition of sodium bicarbonate and glucose. Succinic acid concentration reached 1.24 M (146 g l⁻¹) within 46 h. The yields of succinic acid and acetic acid from glucose were 1.40 mol mol⁻¹ (0.92 g g⁻¹) and 0.29 mol mol⁻¹ (0.10 g g⁻¹), respectively. The succinic acid production rate and yield depended on medium bicarbonate concentration rather than glucose concentration. Consumption of bicarbonate accompanied with succinic acid production implied that added bicarbonate was used for succinic acid synthesis.     

Enhanced <Emphasis Type="SmallCaps">d</Emphasis>-ribose biosynthesis in batch culture of a transketolase-deficient <Emphasis Type="Italic">Bacillus subtilis</Emphasis> strain by citrate

In this study, the effects of citrate addition on d-ribose production were investigated in batch culture of a transketolase-deficient strain, Bacillus subtilis EC2, in shake flasks and bioreactors. Batch cultures in shake flasks and a 5-l reactor indicated that supplementation with 0.2–0.5 g l⁻¹ of citrate enhanced d-ribose production. When B. subtilis EC2 was cultivated in a 15-l reactor in a complex medium, the d-ribose concentration was 70.9 g l⁻¹ with a ribose yield of 0.497 mol mol⁻¹. When this strain was grown in the same medium supplemented with 0.3 g l⁻¹ of citrate, 83.4 g l⁻¹ of d-ribose were obtained, and the ribose yield was increased to 0.587 mol mol⁻¹. Addition of citrate reduced the activities of pyruvate kinase and phosphofructokinase, while it increased those of glucose-6-phosphate dehydrogenase and 6-phosphogluconate dehydrogenase. Metabolic flux distribution in the stationary phase indicated that citrate addition resulted in increased fluxes in the pentose phosphate pathway and TCA cycle, and decreased fluxes in the glycolysis and acetate pathways.     

Production of <Emphasis Type="SmallCaps">l</Emphasis>-alanine by metabolically engineered <Emphasis Type="Italic">Escherichia coli</Emphasis>

Escherichia coli W was genetically engineered to produce l-alanine as the primary fermentation product from sugars by replacing the native d-lactate dehydrogenase of E. coli SZ194 with alanine dehydrogenase from Geobacillus stearothermophilus. As a result, the heterologous alanine dehydrogenase gene was integrated under the regulation of the native d-lactate dehydrogenase (ldhA) promoter. This homologous promoter is growth-regulated and provides high levels of expression during anaerobic fermentation. Strain XZ111 accumulated alanine as the primary product during glucose fermentation. The methylglyoxal synthase gene (mgsA) was deleted to eliminate low levels of lactate and improve growth, and the catabolic alanine racemase gene (dadX) was deleted to minimize conversion of l-alanine to d-alanine. In these strains, reduced nicotinamide adenine dinucleotide oxidation during alanine biosynthesis is obligately linked to adenosine triphosphate production and cell growth. This linkage provided a basis for metabolic evolution where selection for improvements in growth coselected for increased glycolytic flux and alanine production. The resulting strain, XZ132, produced 1,279 mmol alanine from 120 g l⁻¹ glucose within 48 h during batch fermentation in the mineral salts medium. The alanine yield was 95% on a weight basis (g g⁻¹ glucose) with a chiral purity greater than 99.5% l-alanine. Electronic supplementary material The online version of this article (doi:) contains supplementary material, which is available to authorized users.