Survival and Heat Resistance of Listeria monocytogenes after Exposure to Alkali and Chlorine

A strain of Listeria monocytogenes isolated from a drain in a food-processing plant was demonstrated, by determination of D values, to be more resistant to the lethal effect of heat at 56 or 59°C following incubation for 45 min in tryptose phosphate broth (TPB) at pH 12.0 than to that of incubation for the same time in TPB at pH 7.3. Cells survived for at least 6 days when they were suspended in TPB at pHs 9.0, 10.0, and 11.0 and stored at 4 or 21°C. Cells of L. monocytogenes incubated at 37°C for 45 min and then stored for 48 or 144 h in TPB at pH 10.0 were more resistant to heat treatment at 56°C than were cells stored in TPB at pH 7.3. The alkaline-stress response in L. monocytogenes may induce resistance to otherwise lethal thermal-processing conditions. Treatment of cells in 0.05 M potassium phosphate buffer (pH 7.00 ± 0.05) containing 2.0 or 2.4 mg of free chlorine per liter reduced populations by as much as 1.3 log₁₀ CFU/ml, while treatment with 6.0 mg of free chlorine per liter reduced populations by as much as 4.02 log₁₀ CFU/ml. Remaining subpopulations of chlorine-treated cells exhibited some injury, and cells treated with chlorine for 10 min were more sensitive to heating at 56°C than cells treated for 5 min. Contamination of foods by L. monocytogenes cells that have survived exposure to processing environments ineffectively cleaned or sanitized with alkaline detergents or disinfectants may have more severe implications than previously recognized. Alkaline-pH-induced cross-protection of L. monocytogenes against heat has the potential to enhance survival in minimally processed as well as in heat-and-serve foods and in foods on holding tables, in food service facilities, and in the home. Cells surviving exposure to chlorine, in contrast, are more sensitive to heat; thus, the effectiveness of thermal processing in achieving desired log₁₀-unit reductions is not compromised in these cells.     

Survival of Listeria monocytogenes in commercial food-processing equipment cleaning solutions and subsequent sensitivity to sanitizers and heat

AIMS: To determine the ability of Listeria monocytogenes to survive exposure to commercial food-processing equipment cleaning solutions and subsequent treatment with sanitizers or heat. METHODS AND RESULTS: Cells of five strains of L. monocytogenes were suspended in 1% solutions of eight commercial cleaners (pH 7.1-12.5) or in water (control) and incubated at 4 degrees C for 30 min or 48 h before populations were determined by plating on tryptose phosphate agar. After exposure of cells to cleaning solutions for 30 min, populations of the most resistant strain of L. monocytogenes were reduced by < or = 1.63 log10 cfu ml(-1). In only three highly alkaline cleaning solutions (pH 11.6-12.4) were populations reduced significantly (P < or = 0.05) compared with reductions in water. After 48 h, populations were significantly higher in one cleaning solution (pH 10.4) than in water, while populations in six of the other seven cleaning solutions were reduced by > or = 4.72 log10 cfu ml(-1). Cells exposed to cleaning solutions for 30 min became sensitive to 4.0 or 6.0 mg l(-1) free chlorine and to 50 or 100 mg l(-1) benzalkonium chloride and cetylpyridinium chloride, common components of quaternary ammonium sanitizers. Cells exposed to four of the five test cleaners had D56 degrees C values less than or equal to those of the control cells. CONCLUSIONS: Listeria monocytogenes tolerates exposure to a high concentration of alkaline cleaning solutions but consequently becomes sensitized to sanitizers. SIGNIFICANCE AND IMPACT OF THE STUDY: The elimination of L. monocytogenes surviving exposure to alkaline cleaning solutions widely used for food-processing equipment is essential and the appropriate use of sanitizers for subsequent application to equipment is important in achieving this goal.     

Inactivation of Escherichia coli and Listeria monocytogenes on iceberg lettuce by dip wash treatments with organic acids

AIMS: To study and compare the efficacy of organic acids and chlorine dipping in inactivation of Escherichia coli and Listeria monocytogenes on fresh-cut iceberg lettuce. METHODS AND RESULTS: Fresh-cut iceberg lettuce leaves were inoculated with E. coli or L. monocytogenes. After inoculation, samples were stored at 4 degrees C for 24 h and dipped in organic acid or chlorine solutions for 2 and 5 min. E. coli and L. monocytogenes were enumerated on selective media. Treatment of fresh-cut iceberg lettuce with chlorine solution caused 1.0 and 2.0 log(10) CFU g(-1) reductions in the number of L. monocytogenes and E. coli, respectively. Maximum reduction for E. coli (about 2.0 log(10) CFU g(-1)) was obtained for samples dipped in lactic or citric acids while maximum reduction for L. monocytogenes (about 1.5 log(10) CFU g(-1)) was attained for samples dipped in lactic acid. CONCLUSIONS: Dipping of iceberg lettuce in 0.5% citric acid or 0.5% lactic acid solution for 2 min could be as effective as chlorine for reducing microbial populations on fresh-cut iceberg lettuce. SIGNIFICANCE AND IMPACT OF THE STUDY: Dipping in solutions containing organic acids is shown to be effective to reduce E. coli and L. monocytogenes on fresh-cut iceberg lettuce.     

Pathogenicity of Listeria monocytogenes grown on crabmeat

The pathogenicity of Listeria monocytogenes as influenced by growth on crabmeat at 5 and 10 degrees C was studied. Crabmeat was inoculated with L. monocytogenes V7 (ca. 10(4) CFU/g) and incubated for up to 14 days at 5 and 10 degrees C. At selected incubation times, L. monocytogenes was removed from crabmeat by washing with 0.1 M potassium phosphate buffer (pH 7.0), and populations were determined by surface plating on LiCl-phenylethanol-moxalactam agar. Buffered suspensions were then centrifuged, and the resulting pellets were suspended in phosphate buffer containing 10% glycerol and stored at -18 degrees C. Thawed, diluted suspensions of cells were tested for pathogenicity by intraperitoneal injection into immunocompromised and nonimmunocompromised mice. L. monocytogenes cells recovered from crabmeat and then recultured in tryptose phosphate broth (TPB), as well as cells which had not been passed through crabmeat but had been cultured in TPB, were likewise harvested, suspended in buffered 10% glycerol, frozen, thawed, diluted, and tested for pathogenicity by intraperitoneal injection. Growth on crabmeat at 5 and 10 degrees C did not have a significant effect on pathogenicity. The population of L. monocytogenes necessary to kill about 50% of the immunocompromised mice in each test set within 7 days was about 10(4) CFU, and this result was not significantly affected by storage temperature of the crabmeat or type of substrate, i.e., crabmeat or TPB, on which it had grown.     

Pathogenicity of Listeria monocytogenes grown on crabmeat.

The pathogenicity of Listeria monocytogenes as influenced by growth on crabmeat at 5 and 10 degrees C was studied. Crabmeat was inoculated with L. monocytogenes V7 (ca. 10(4) CFU/g) and incubated for up to 14 days at 5 and 10 degrees C. At selected incubation times, L. monocytogenes was removed from crabmeat by washing with 0.1 M potassium phosphate buffer (pH 7.0), and populations were determined by surface plating on LiCl-phenylethanol-moxalactam agar. Buffered suspensions were then centrifuged, and the resulting pellets were suspended in phosphate buffer containing 10% glycerol and stored at -18 degrees C. Thawed, diluted suspensions of cells were tested for pathogenicity by intraperitoneal injection into immunocompromised and nonimmunocompromised mice. L. monocytogenes cells recovered from crabmeat and then recultured in tryptose phosphate broth (TPB), as well as cells which had not been passed through crabmeat but had been cultured in TPB, were likewise harvested, suspended in buffered 10% glycerol, frozen, thawed, diluted, and tested for pathogenicity by intraperitoneal injection. Growth on crabmeat at 5 and 10 degrees C did not have a significant effect on pathogenicity. The population of L. monocytogenes necessary to kill about 50% of the immunocompromised mice in each test set within 7 days was about 10(4) CFU, and this result was not significantly affected by storage temperature of the crabmeat or type of substrate, i.e., crabmeat or TPB, on which it had grown.     

Pulsed electric field alters molecular chaperone expression and sensitizes Listeria monocytogenes to heat

Pulsed electric field (PEF)-resistant and PEF-sensitive Listeria monocytogenes strains were sublethally treated with electric pulses at 15 kV/cm for 29 micro s and held at 25 degrees C for 5 to 30 min prior to protein extraction. The levels of the molecular chaperones GroEL, GroES, and DnaJ were determined by immunoblotting. After 10 to 20 min after sublethal PEF treatment, a transient decrease in molecular chaperone expression was observed in the PEF-sensitive strain (Scott A). The levels of GroEL and DnaJ increased back to the basal expression level within 30 min. A substantial decrease in GroES expression persisted for at least 30 min after PEF treatment. Chaperone expression was suppressed after PEF treatment to a smaller extent in the PEF-resistant (OSY-8578) than in the PEF-sensitive strain, and no clear expression pattern was identified in OSY-8578. Inactivation of Scott A and OSY-8578 in phosphate buffer was compared when lethal PEF (27.5 kV/cm, 144 micro s) and heat (55 degrees C, 10 min) were applied in sequence. When PEF and heat treatments were applied separately, the populations of L. monocytogenes Scott A and OSY-8578 decreased 0.5 to 0.6 log CFU/ml. Cells treated first with PEF and incubated at 25 degrees C for 10 min showed substantial sensitivity to subsequent heat treatment; the decrease in counts for Scott A and OSY-8578 was 6.1 and 2.8 log CFU/ml, respectively. The sequence and time lapse between the two treatments were crucial for achieving high inactivation rates. It is concluded that PEF sensitized L. monocytogenes to heat and that maximum heat sensitization occurred when chaperone expression was at a minimum level.     

Mild heat treatment of lettuce enhances growth of Listeria monocytogenes during subsequent storage at 5 degrees C or 15 degrees C

AIMS: The objective of this study was to determine the influence of mild heat treatment, storage temperature and storage time on the survival and growth of Listeria monocytogenes inoculated onto cut iceberg lettuce leaves. METHODS AND RESULTS: Before or after inoculation with L. monocytogenes, cut iceberg lettuce leaves were dipped in water (20 or 50 degrees C) containing or not 20 mg l(-1) chlorine, for 90 s, then stored at 5 degrees C for up to 18 days or 15 degrees C for up to 7 days. The presence of 20 mg l(-1) chlorine in the treatment water did not significantly (alpha=0.05) affect populations of the pathogen, regardless of other test parameters. The population of L. monocytogenes on lettuce treated at 50 degrees C steadily increased throughout storage at 5 degrees C for up to 18 days. At day 10 and thereafter, populations were 1.7-2.3 log10 cfu g(-1) higher on lettuce treated at 50 degrees C after inoculation compared with untreated lettuce or lettuce treated at 20 degrees C, regardless of chlorine treatment. The population of L. monocytogenes increased rapidly on lettuce stored at 15 degrees C. At 2 and 4 days, significantly higher populations were detected on lettuce that had been treated at 50 degrees C, compared with respective samples that had been treated at 20 degrees C, regardless of inoculation before or after treatment, or the presence of 20 mg l(-1) chlorine in the treatment water. CONCLUSIONS: The results clearly demonstrated that mild heat treatment of cut lettuce leaves enhances the growth of L. monocytogenes during subsequent storage at 5 or 15 degrees C. SIGNIFICANCE AND IMPACT OF THE STUDY: Mild heat treatment of cut lettuce may result in a prolonged shelf life as a result of delaying the development of brown discoloration. However, heat treatment also facilitates the growth of L. monocytogenes during storage at refrigeration temperature, thereby increasing the potential risk of causing listeriosis.     

Influence of the natural microbial flora on the acid tolerance response of Listeria monocytogenes in a model system of fresh meat decontamination fluids

Depending on its composition and metabolic activity, the natural flora that may be established in a meat plant environment can affect the survival, growth, and acid tolerance response (ATR) of bacterial pathogens present in the same niche. To investigate this hypothesis, changes in populations and ATR of inoculated (10(5) CFU/ml) Listeria monocytogenes were evaluated at 35 degrees C in water (10 or 85 degrees C) or acidic (2% lactic or acetic acid) washings of beef with or without prior filter sterilization. The model experiments were performed at 35 degrees C rather than lower (8.0 log CFU/ml) by day 1. The pH of inoculated water washings decreased or increased depending on absence or presence of natural flora, respectively. These microbial and pH changes modulated the ATR of L. monocytogenes at 35 degrees C. In filter-sterilized water washings, inoculated L. monocytogenes increased its ATR by at least 1.0 log CFU/ml from days 1 to 8, while in unfiltered water washings the pathogen was acid tolerant at day 1 (0.3 to 1.4 log CFU/ml reduction) and became acid sensitive (3.0 to >5.0 log CFU/ml reduction) at day 8. These results suggest that the predominant gram-negative flora of an aerobic fresh meat plant environment may sensitize bacterial pathogens to acid.     

Inactivation of Escherichia coli O157:H7 in biofilm on stainless steel by treatment with an alkaline cleaner and a bacteriophage

AIMS: To determine the effectiveness of an alkaline cleaner used in food-processing plants and a lytic bacteriophage specific for Escherichia coli O157:H7 in killing wild type and rpoS-deficient cells of the pathogen in a biofilm. METHODS AND RESULTS: Wild type and rpoS-deficient cells were attached to stainless steel coupons (c. 7-8 log CFU per coupon) on which biofilms were developed during incubation at 22 degrees C for 96 h in M9 minimal salts media (MSM) with one transfer to fresh medium. Coupons were treated with 100 and 25% working concentrations of a commercial alkaline cleaner (pH 11.9, with 100 microg ml(-1) free chlorine) used in the food industry, chlorine solutions (50 and 100 microg ml(-1) free chlorine), or sterile deionized water (control) at 4 degrees C for 1 and 3 min. Treatment with 100% alkaline cleaners reduced populations by 5-6 log CFU per coupon, a significant (P < or = 0.05) reduction compared with treatment with water. Initial populations (2.6 log CFU per coupon) of attached cells of both strains were reduced by 1.2 log CFU per coupon when treated with bacteriophage KH1 (7.7 log PFU ml(-1)) for up to 4 days at 4 degrees C. Biofilms containing low populations (2.7-2.8 log CFU per coupon) of wild type and rpoS-deficient cells that had developed for 24 h at 22 degrees C were not decreased by more than 1 log CFU per coupon when treated with KH1 (7.5 log PFU ml(-1)) at 4 degrees C. CONCLUSIONS: Higher numbers of cells of E. coli O157:H7 in biofilms are killed by treatment with an alkaline cleaner than with hypochlorite alone, possibly through a synergistic mechanism of alkaline pH and hypochlorite. Populations of cells attached on coupons were reduced by treating with bacteriophage but cells enmeshed in biofilms were protected. SIGNIFICANCE AND IMPACT OF THE STUDY: The alkaline pH, in combination with hypochlorite, in a commercial cleaner is responsible for killing E. coli O157:H7 in biofilms. Treatment with bacteriophage KH1 reduces populations of cells attached to coupon surfaces but not cells in biofilms.     

The effect of temperature and growth rate on the susceptibility of Listeria monocytogenes to environmental stress conditions

R.A. PATCHETT, N. WATSON, P.S. FERNANDEZ AND R.G. KROLL. 1996. The effect of growth temperature and growth rate on the susceptibility to heat and pH stress were investigated in Listeria monocytogenes grown in continuous culture where these two growth variables could be varied independently of each other, and in batch culture. After growth at 30°C or 10°C at constant growth rate, or at 30°C at different growth rates, cells did not differ in their resistance to heat at 55°C. Cells grown at 30°C were more resistant to acid stress at pH 2.5 than cells grown at the same growth rates at 10°C. Cells grown at low growth rate at 30°C gave greater resistance to acid stress than those grown at high growth rate. Growth temperature and growth rate had independent effects on the susceptibility of L. monocytogenes to acid stress conditions. This may have implications for the survival of L. monocytogenes in acidic foods.     

Behavior of Listeria monocytogenes in wiener exudates in the presence of Pediococcus acidilactici H or pediocin AcH during storage at 4 or 25 degrees C.

Exudative fluids were collected from packages of five brands of all-beef wieners and inoculated to contain 10(4) to 10(5) CFU of a three-strain (Scott A, V7, and 101M) mixture of Listeria monocytogenes per ml. Listeriae were inactivated (decrease of 0.61 to 3.8 log10 CFU/ml) in all five exudates held at 4 degrees C for 29 days. L. monocytogenes grew (increase of 1.7 to 3.6 log10 CFU/ml) in two of five exudates held at 25 degrees C for 6 days. Exudate was inoculated with a derivative of Pediococcus acidilactici H (designated JBL1095) or treated with pediocin AcH (a bacteriocin) as a novel approach to control the growth of L. monocytogenes in wiener exudates. Initially, pediocin AcH caused rapid death (decrease of 0.74 log10 CFU/ml in 2 h) of L. monocytogenes in exudate held at 4 degrees C, but thereafter the inactivation was similar to that in control exudate (L. monocytogenes only) or exudate containing L. monocytogenes plus JBL1095. At 25 degrees C, L. monocytogenes grew in the presence of JBL1095 during the first 64 h of incubation, but thereafter the numbers of the pathogen decreased appreciably (5.84 log10 CFU/ml in 3 days). In the presence of pediocin AcH, there was a gradual decrease in numbers of L. monocytogenes throughout the storage period at 25 degrees C. These data indicate that added biopreservatives can potentiate and amplify the intrinsic listeriostatic or listericidal activity of wiener exudate.     

Behavior of Listeria monocytogenes in wiener exudates in the presence of Pediococcus acidilactici H or pediocin AcH during storage at 4 or 25 degrees C

Exudative fluids were collected from packages of five brands of all-beef wieners and inoculated to contain 10(4) to 10(5) CFU of a three-strain (Scott A, V7, and 101M) mixture of Listeria monocytogenes per ml. Listeriae were inactivated (decrease of 0.61 to 3.8 log10 CFU/ml) in all five exudates held at 4 degrees C for 29 days. L. monocytogenes grew (increase of 1.7 to 3.6 log10 CFU/ml) in two of five exudates held at 25 degrees C for 6 days. Exudate was inoculated with a derivative of Pediococcus acidilactici H (designated JBL1095) or treated with pediocin AcH (a bacteriocin) as a novel approach to control the growth of L. monocytogenes in wiener exudates. Initially, pediocin AcH caused rapid death (decrease of 0.74 log10 CFU/ml in 2 h) of L. monocytogenes in exudate held at 4 degrees C, but thereafter the inactivation was similar to that in control exudate (L. monocytogenes only) or exudate containing L. monocytogenes plus JBL1095. At 25 degrees C, L. monocytogenes grew in the presence of JBL1095 during the first 64 h of incubation, but thereafter the numbers of the pathogen decreased appreciably (5.84 log10 CFU/ml in 3 days). In the presence of pediocin AcH, there was a gradual decrease in numbers of L. monocytogenes throughout the storage period at 25 degrees C. These data indicate that added biopreservatives can potentiate and amplify the intrinsic listeriostatic or listericidal activity of wiener exudate.     

Sensitization of heat-treated Listeria monocytogenes to added lysozyme in milk.

Listeria monocytogenes was highly resistant to hen egg white lysozyme in whole milk but was sensitive in media and in phosphate buffer. Methods to sensitize the pathogen to lysozyme in milk were investigated. Treatment of whole milk by cation exchange to remove minerals, particularly Ca2+ and Mg2+, slightly promoted inactivation of L. monocytogenes by lysozyme at 4 degrees C over a period of 6 days. Heat treatment (62.5 degrees C for 15 s) strongly sensitized L. monocytogenes to lysozyme in demineralized milk and in MES [2-(N-morpholino)ethanesulfonic acid] buffer. Addition of Ca2+ or Mg2+ to the demineralized milk restored resistance to lysozyme. Cells were more rapidly heat inactivated at 55 degrees C in demineralized milk containing lysozyme, and addition of Ca2+ to the demineralized milk restored the resistance to heat. The results indicate that minerals or mineral-associated components protect L. monocytogenes from inactivation by lysozyme and heat in milk, probably by increasing cell surface stability. The heat treatment of foods containing added lysozyme can probably play a significant role in producing microbiologically safe foods.     

Inhibition of Listeria monocytogenes by Lactobacillus bavaricus MN in beef systems at refrigeration temperatures.

The ability of Lactobacillus bavaricus, a meat isolate, to inhibit the growth of three Listeria monocytogenes strains was examined in three beef systems: beef cubes, beef cubes in gravy, and beef cubes in gravy containing glucose. The beef was minimally heat treated, inoculated with L. bavaricus at 10(5) or 10(3) CFU/g and L. monocytogenes at 10(2) CFU/g, vacuum sealed, and stored at 4 or 10 degrees C. The meat samples were monitored for microbial growth, pH, and bacteriocin production. The pathogen was inhibited by L. bavaricus MN. At 4 degrees C, L. monocytogenes was inhibited or killed depending on the initial inoculum level of L. bavaricus. At 10 degrees C, at least a 10-fold reduction of the pathogen occurred, except in the beef without gravy. This system showed a transient inhibition of the pathogen during the first week of storage followed by growth to control levels by the end of the incubation period. Bacteriocin was detected in the samples, and inhibition could not be attributed to acidification. Low refrigeration temperatures significantly (P < or = 0.05) enhanced L. monocytogenes inhibition. Moreover, the addition of glucose-containing gravy and the higher inoculum level of L. bavaricus were significantly (P < or = 0.05) more effective in reducing L. monocytogenes populations in most of the systems studied.     

Acid-tolerant Listeria monocytogenes persist in a model food system fermented with nisin-producing bacteria

AIMS: To investigate the induction of the acid tolerance response (ATR) in Listeria monocytogenes and to assess the persistence of the pathogen in broth fermented using a nisin-producing starter culture. METHODS AND RESULTS: Lactic, acetic and hydrochloric acids were used to induce the ATR in L. monocytogenes growing at early exponential phase. Cells were then challenged in medium acidified to pH 3.5 with the same acid. Only lactic acid induced a detectable ATR. ATR+ cells maintained their initial numbers after 1 h exposure while ATR- were reduced by c. 4 log10 CFU. ATR+ or ATR- cells were also inoculated in M17G broth fermented with nisin-producing (nis+) or control (nis-) Lactococcus lactis. When exposed to nisin, the numbers of ATR+ cells were c. 2 log10 CFU higher than non detectable ATR- cells at day 3. In the absence of nisin (nis- culture), L. monocytogenes was recovered from all ATR+ and ATR- samples after 30 days. In contrast, no L. monocytogenes were recovered from any nis+ATR- samples but four of five nis+ATR+ samples were positive for L. monocytogenes after 30 days. CONCLUSIONS: The ATR confers cross-resistance to nisin for at least 30 days in a system fermented by nisin-producing bacteria. SIGNIFICANCE AND IMPACT OF THE STUDY: The cross-resistance induced by the ATR should be considered for the safety of foods fermented with bacteriocin-producing cultures.     

The behaviour of log phase Escherichia coli at temperatures that fluctuate about the minimum for growth

AIMS: To investigate the behaviour of cold-adapted, log phase Escherichia coli exposed to temperatures that fluctuate below and above the minimum for growth. METHODS AND RESULTS: Log phase E. coli cultures were incubated at a constant temperature of 2, 4 or 6 degrees C or with temperatures allowed to increase from those temperatures for 35 min, to 10 degrees C, at 6-, 12- or 24-h intervals, as commonly occurs during retail display of chilled foods. At suitable intervals for each culture, the optical absorbance value was determined using a spectrophotometer, the forward angle light scatter was determined using a flow cytometer, and portions were spread on plate count agar for enumeration of colony forming units (CFU). Numbers of CFU decreased by 3 log units or increased by 1 log unit for cultures incubated at 6 degrees C for 17 days without or with temperatures fluctuations at < or =12-h intervals, respectively. Cells elongated when cultures were incubated at 4 or 2 degrees C with temperatures fluctuating at 6-h intervals, and at 6 degrees C at constant or fluctuating temperatures, but cells did not elongate in cultures incubated at a constant temperature of 2 or 4 degrees C. SIGNIFICANCE AND IMPACT OF THE STUDY: The minimum growth temperature of E. coli is assumed to be > or =7 degrees C. Elongated cells were able to divide when temperatures rose from 6 degrees C to above 7 degrees C for <45 min at < or =12-h intervals. Such temperature fluctuations may be experienced by chilled foods during defrosting cycles of retail display cases. The finding that cells behave differently under fluctuating than at constant temperatures may significantly affect understanding of appropriate temperatures for the safe storage of chilled foods and for predictive modelling of bacterial growth in such foods.     

Sensitivity of nisin-resistant Listeria monocytogenes to heat and the synergistic action of heat and nisin

Nisin, a bacteriocin produced by some strains of Lactococcus lactis, acts against foodborne pathogen Listeria monocytogenes. A single exposure of cells to nisin can generate nisin-resistant (Nisr) mutants, which may compromise the use of nisin in the food industry. The objective of this research was to compare the heat resistance of Nisr and wild type (WT) Listeria monocytogenes. The synergistic effect of heat-treatment (55 degrees C) and nisin (500 IU ml-1) on the Nisr cells and the WT L. monocytogenes Scott A was also studied. When the cells were grown in the absence of nisin, there was no significant (alpha = 0.05) difference in heat resistance between WT and Nisr cells of L. monocytogenes at 55, 60 and 65 degrees C. However, when the Nisr cells were grown in the presence of nisin, they were more sensitive to heat at 55 degrees C than the WT cells. The D-values at 55 degrees C were 2.88 and 2.77 min for Nisr ATCC 700301 and ATCC 700302, respectively, which was significantly (alpha = 0.05) lower than the D-value for WT, 3.72 min. When Nisr cells were subjected to a combined treatment of heat and nisin, there was approximately a four log reduction during the first 7 min of treatment.     

Combined action of S-carvone and mild heat treatment on Listeria monocytogenes Scott A

The combined action of the plant-derived volatile, S-carvone, and mild heat treatment on the food-borne pathogen, Listeria monocytogenes, was evaluated. The viability of exponential phase cultures grown at 8 degrees C could be reduced by 1.3 log units after exposure to S-carvone (5 mmol l-1) for 30 min at 45 degrees C, while individual treatment with S-carvone or exposure to 45 degrees C for 30 min did not result in a loss in viability. Other plant-derived volatiles, namely carvacrol, cinnamaldehyde, thymol and decanal, were also found to reduce the viability of L. monocytogenes in combination with the same mild heat treatment at concentrations of 1.75 mmol l-1, 2.5 mmol l-1, 1.5 mmol l-1 and 2 mmol l-1, respectively. These findings show that essential oil compounds can play an important role in minimally processed foods, and can be used in the concept of Hurdle Technology to reduce the intensity of heat treatment or other individual hurdles.     

Nisin and ALTATM 2341 inhibit the growth of Listeria monocytogenes on smoked salmon packaged under vacuum or 100% CO2

The effects of nisin and ALTA 2341 on the growth of Listeria monocytogenes were assessed on smoked salmon packaged under vacuum or 100% CO2. Smoked salmon slices (pH 6.3) were inoculated with a cocktail of seven L. monocytogenes isolates at a level of approximately 2.5 log10 colony forming units (cfu) g-1. After inoculation, the surface of the smoked salmon slices was treated with either nisin (400 or 1250 IU g-1) or ALTA 2341 (0.1 or 1%). The smoked salmon was packaged and stored at 4 degrees C (28 d) or 10 degrees C (9 d). On untreated vacuum-packaged smoked salmon, L. monocytogenes grew by 3.8 log10 cfu g-1 at 4 degrees C and 5.1 log10 cfu g-1 at 10 degrees C. Growth was reduced on nisin- and ALTA 2341-treated vacuum-packaged smoked salmon. On the nisin-treated samples, L. monocytogenes increased by 2.5 (400 IU g-1) and 1.5 (1250 IU g-1) log10 cfu g-1 at 4 degrees C, and by 4.3 (400 IU g-1) and 2.7 (1250 IU g-1) log10 cfu g-1 at 10 degrees C. With the ALTA 2341-treated samples, L. monocytogenes increased by 2.8 (0.1%) or 1.6 (1.0%) log10 cfu g-1 at 4 degrees C, and 3.3 (0.1%) or 3.6 (1.0%) log10 cfu g-1 at 10 degrees C. The growth of L. monocytogenes was retarded by packaging the smoked salmon in 100% CO2. On untreated smoked salmon, only a 0.8 log10 cycle increase was observed at 10 degrees C. Under all the other conditions tested with 100% CO2, L. monocytogenes was detected but growth was prevented.     

Efficacy of copper and silver ions and reduced levels of free chlorine in inactivation of Legionella pneumophila.

Water disinfection systems utilizing electrolytically generated copper and silver ions (200 and 20, 400 and 40, or 800 and 80 micrograms/liter) and low levels of free chlorine (0.1 to 0.4 mg/liter) were evaluated at room (21 to 23 degrees C) and elevated (39 to 40 degrees C) temperatures in filtered well water (pH 7.3) for their efficacy in inactivating Legionella pneumophila (ATCC 33155). At room temperature, a contact time of at least 24 h was necessary for copper and silver (400 and 40 micrograms/liter) to achieve a 3-log10 reduction in bacterial numbers. As the copper and silver concentration increased to 800 and 80 micrograms/liter, the inactivation rate significantly (P less than or equal to 0.05) increased from K = 2.87 x 10(-3) to K = 7.50 x 10(-3) (log10 reduction per minute). In water systems with and without copper and silver (400 and 40 micrograms/liter), the inactivation rates significantly increased as the free chlorine concentration increased from 0.1 mg/liter (K = 0.397 log10 reduction per min) to 0.4 mg/liter (K = 1.047 log10 reduction per min). Compared to room temperature, no significant differences were observed when 0.2 mg of free chlorine per liter with and without 400 and 40 micrograms of copper and silver per liter was tested at 39 to 40 degrees C. All disinfection systems, regardless of temperature or free chlorine concentration, showed increase inactivation rates when 400 and 40 micrograms of copper and silver per liter was added; however, this trend was significant only at 0.4 mg of free chlorine per liter.