Ferric iron reduction-linked growth yields of Shewanella putrefaciens MR-1

The anaerobic reduction of ferric citrate by Shewanella putrefaciens MR-1 cells was inhibited markedly by p -chloromercuriphenylsulphonate, moderately by potassium cyanide, and to a small extent by 2-heptyl-4-hydroxyquinolone- N -oxide. Iron reduction was accompanied by increases in total cellular protein, with values of 0.33-7.54 g cell protein produced per mol Fe(III) reduced. The growth yields were dependent upon the growth conditions of the inoculum and the initial concentration of Fe(III) citrate in the medium. Specifically, maximum growth yields were obtained when the inoculum was pregrown anaerobically and when the initial Fe(III) citrate concentrations were 5–10 mmol l^-1. Lower growth yields were obtained with initial Fe(III) citrate concentrations of 20–30 mmol l^-1, suggesting that cell growth was partially inhibited by higher concentrations of Fe(III) or Fe(II). Maximal growth yields were also observed early (6–24 h), after which continued increases in cell protein were minimal.     

Fungus β-glycosidases: immobilization and use in alkyl-β-glycoside synthesis

Production of β-glycosidases: β-xylosidase and β-glucosidase by the fungus Sclerotinia sclerotiorum was optimized in the presence of different carbon sources. Immobilization supports with different physico-chemical characteristics were evaluated for use in continuous reactors. Immobilization and activity yields were calculated. Among the adsorption on Duolite, Amberlite, Celite and DEAE-sepharose, and entrapment in polyacrylamide gel or reticulation using glutaraldehyde, highest yields were obtained when β-xylosidase was adsorbed on Duolite A 7 and when β-glucosidase was adsorbed on DEAE-sepharose.

Enzyme preparations from S. sclerotiorum cultures were used in a biphasic (alcohol/aqueous) medium for the synthesis of alkyl-glycosides by trans-glycosylation of sugars and long-chain alcohols. The synthesis was studied under different conditions with primary and secondary alcohols as substrates, in the presence of free or immobilized enzyme. Xylan and cellobiose were used for the synthesis of alkyl-xylosides and alkyl-glucosides, respectively. The majority of the immobilized preparations were unable to catalyze the synthesis of alkyl-glycosides.

Highest yields were obtained when using xylan and C₄–C₆-alcohols. The reaction produced alkyl-β-xyloside and alkyl-β-xylobioside, as confirmed by MS/MS. Up to 22 mM iso-amyl-xyloside and 14 mM iso-amyl-xylobioside were produced from iso-amyl alcohol and xylan.     

High ethanol yields using Aspergillus oryzae koji and corn media

Summary High ethanol and stillage solids have been achieved using whole corn mashes. Ethanol yields of 14% (v/v) (89.5% of theory) and stillage levels of approximately 23% (w/v) were obtained in 74–90 hours using mild acid pretreatment with Aspergillus oryzae wheat bran koji saccharification. High ethanol yields were also obtained with bacterial amylase, instead of the acid treatment, when the sterilization step was omitted. The implications of ethanol fermentation process modifications are explored.     

Relative Efficacy of Selected Volatile and Nonvolatile Nematicides for Control of Meloidogyne incognita on Tobacco

Root-knot nematode control and tobacco yields in plots infested with Meloidogyne incognita and treated with the nonvolatile nematicides, aldicarb, Mocap ®, or Nemacur ® were greater than those on similar plots treated with volatile nematicides such as DD, DD + MENCS, SD14647 or tetrachlorothiophene. Root-knot control and tobacco yields in plots treated with carbofuran or Dasanit ® were eqtual to that obtained with DD + MENCS, but less than that obtained with the other volatile soil nematicides. The most efficient dosage was 3.4 kg/hectare active ingredient for aldicarb and Mocap ® and 10.0 kg/hectare for Dasanit ®. Carbofuran and Nemacur ® were equally as effective at 4.2 kg/hectare as they were at higher dosages. The most efficient dosage of DD and SD14647 was 84 liters/hectare. Aldicarb and Dasanit ® resulted in better nematode control and tobacco yields when incorporated into the top 15-20 cm of soil than when incorporated into the top 5-10 cm of soil. Nemacur ® and Mocap ® performed better when incorporated into the top 5-10 cm of soil, and carbofuran performed better when applied in the seed furrow (placed 15-20 cm deep in a 5-cm band and bedded).     

The use of deionised date syrup as a substrate for citric acid fermentation

Summary Production of citric acid from date syrup by fermentation has been undertaken usingAspergillus niger as the producer organism. Poor yields were obtained when untreated and ferrocyanide treated date syrup were used. However, acceptable yields, in excess of 60% were obtained when the date syrup was deionised using an ion exchange column at 80°C.     

Bee population returns and cherry yields in an orchard pollinated with Osmia lignaria (Hymenoptera: Megachilidae)

During 1998-2003, we used populations of the solitary bee Osmia lignaria Say to pollinate a commercial sweet cherry orchard in northern Utah. Bee densities released each year ranged from 1290 to 1857 females/ha, with approximately twice as many males. Female progeny produced each year were greater than parental populations released, except in 2003, when nesting was poor due to bird predation. Despite poor weather during bloom, and in contrast to most other local producers, the study orchard produced harvestable crops in 1999 (2,964 kg/ha) and 2001 (3,154 kg/ha). In 1998 and 2000, record yields were obtained (10,625 and 12,096 kg/ha, respectively). Including only those years with harvestable crops, average production was 2.2 times higher in 1998-2003 (when O. lignaria populations were used) compared with 1992-1997 (when 10 Apis mellifera hives were used). This is the first study reporting multiyear cherry yields in an orchard pollinated with O. lignaria in North America.     

Encystation of Entamoeba invadens IP-1 is induced by lowering the osmotic pressure and depletion of nutrients from the medium

Trophozoites of Entamoeba invadens IP-1 can be induced to encyst in simple solutions composed of semipermeable constituents (buffer, salts, or sugars) provided that their osmotic pressure is in the range of 60-160 mosmol/kg. Optimal yield of mature cysts was obtained when the osmotic pressure of the medium was 110 mosmol/kg. Encystation could be obtained in the absence of serum although higher yields were obtained in its presence. No difference in the yield of mature cysts was found when either dialyzed or full serum was used. High yields of encystation were obtained (greater than 70%) in the presence of 5% serum in solutions of NaCl, KCl, or MgSO4, suggesting that the mechanism of encystation is not induced via sodium or potassium channels. Cysts were obtained in the presence of 72 mM glucose, indicating that depletion of a carbon source is not the only requirement for encystation. A rapid change in the density of the Entamoeba cells was observed upon transfer of trophozoites (density 1.061-1.073 g/ml) from growth medium to the low osmotic pressure encystation solutions. Within the first 2 min their density decreased (to 1.050 g/ml), but it soon increased, reaching within 30 min a density higher than 1.120 g/ml. As the encystation process continued to completion, the density of the cells gradually decreased, the mature cysts reaching a density of 1.049-1.061 g/ml.     

Comparison between immobilized Kluyveromyces fragilis and Saccharomyces cerevisiae coimmobilized with beta-galactosidase, with respect to continuous ethanol production from concentrated whey permeate

Kluyveromyces fragilis immobilized in calcium alginate gel was compared to Saccharomyces cerevisiae coimmobilized with beta-galactosidase, for continuous ethanol production from whey permeate in packed-bed-type columns. Four different whey concentrations were studied, equivalent to 4.5, 10, 15, and 20% lactose, respectively. In all cases the coimmobilized preparation produced more ethanol than K. fragilis. The study went on for more than 5 weeks. K. fragilis showed a decline in activity after 20 days, while the coimmobilized preparation was stableduring the entrire investigation. Under experimental conditions theoretical yields of ethanol were obtained from 4.5 and 10% lactose substrates with the coimmobilized system. Using 15% lactose substrate, theoretical yields were only obtained when a galactose-adapted immobilized S. cerevisiae column was run in series with the coimmobilized column. Then a maximum of 71 g/L ethanol was produced with a productivity of 2.5 g/L h. The coimmobilized column alone gave a maximum ethanol concentration of 52 g/L with a productivity of 4.5 g/L h, whereas immobolized K. fragilis only produced 13 g/L ethanol with a productivity of 1.1 g/L h. It was not possible to obtain theoretical yields of ethanol from the highest substrate concentration.     

Optimization of fermentation conditions for ethanol production from whey

Summary Optimal conditions for ethanol production in 7% whey solutions by the yeast Candida pseudotropicalis ATCC 8619 included initial pH of 4.57 and 30°C. Complete fermentation of the available lactose took place without supplementary nutrients; additions of nitrogen or phosphorus salts, yeast extract or corn steep liquor resulted in increased yeast production and lower ethanol yields. A positive correlation was observed between increases in yeast inocula and lactose utilization and ethanol production rates; 8.35 g/l of ethanol was obtained within 22 h by using yeast inoculum of 13.9 g/l. No differences in fermentation rates or ethanol yields were observed when whole or deproteinized whey solutions were used. Concentrated whey permeates, obtained after removal of the valuable proteins from whey, can be effectively fermented for ethanol production.     

Optimization of Clostridium thermocellum growth on cellulose and pretreated wood substrates

Summary Two strains of Clostridium thermocellum ATCC 27405 and NRCC 2688 demonstrated similar product yields and cellulase activities when grown on solka floc. A sequential culture of C. thermocellum and Zymomonas anaerobia supplemented with cellobiase could produce 1.8 mg/ml of ethanol when grwon on 1% solka floc. Different media were evaluated for their ability to enhance the product and cellulase yields of C. thermocellum grown on cellulose substrates. Ethanol and reducing sugar values of 1.5 and 3.8 mg/ml respectively and an endoglucanase activity of 3 IU/ml were obtained after growth of Clostridium thermocellum in a modified medium containing 1% solka floc. Three different pretreated wood fractions were assessed as substrates for growth. A steam exploded wood fraction gave comparable values to those obtained after growth on solka floc. Sequential cultures of C. thermocellum and Zymomonas anaerobia grown on a 1% steam exploded wood fraction could produce 1.6 mg/ml ethanol after 3 days growth.     

Encystation of Entamoeba invadens IP-1 Is Induced by Lowering the Osmotic Pressure and Depletion of Nutrients from the Medium1

ABSTRACT. Trophozoites of Entamoeba invadens IP-1 can be induced to encyst in simple solutions composed of semipermeable constituents (buffer, salts, or sugars) provided that their osmotic pressure is in the range of 60–160 mosmol/kg. Optimal yield of mature cysts was obtained when the osmotic pressure of the medium was 110 mosmol/kg. Encystation could be obtained in the absence of serum although higher yields were obtained in its presence. No difference in the yield of mature cysts was found when either dialyzed or full serum was used. High yields of encystation were obtained (>70%) in the presence of 5% serum in solutions of NaCl, KCl, or MgSO₄, suggesting that the mechanism of encystation is not induced via sodium or potassium channels. Cysts were obtained in the presence of 72 mM glucose, indicating that depletion of a carbon source is not the only requirement for encystation. A rapid change in the density of the Entamoeba cells was observed upon transfer of trophozoites (density 1.061–1.073 g/ml) from growth medium to the low osmotic pressure encystation solutions. Within the first 2 min their density decreased (to 1.050 g/ml), but it soon increased, reaching within 30 min a density higher than 1.120 g/ml. As the encystation process continued to completion, the density of the cells gradually decreased, the mature cysts reaching a density of 1.049–1.061 g/ml.     

Enhanced polygalacturonase production by Aspergillus niger NRRL-364 grown on supplemented citrus pectin

Enhanced levels of extracellular polygalacturonase activity were obtained when Aspergillus niger NRRL-364 was grown on pectic substances as sole carbon sources in a submerged culture. Among the factors affecting enzyme production those of carbon source concentration, nitrogen source, initial pH and time of cultivation were found to be the most important ones. Under optimum growth and activity conditions yields as high as 14.5 U (measured as reducing groups) ml^-1 of growth medium were obtained, comparing favourably with those reported for fungi grown under similar conditions and used in food processes.     

Fractionation of sugar beet pulp into pectin, cellulose, and arabinose by arabinases combined with ultrafiltration.

Incubation of beet pulp with two arabinases (alpha-L-arabinofuranosidase and endo-arabinase), used singularly or in combination at different units of activity per gram of beet pulp, caused the hydrolysis of arabinan, which produced a hydrolyzate consisting mainly of arabinose. Pectin and a residue enriched with cellulose were subsequently separated from the incubation mixture. The best enzymatic hydrolysis results were obtained when 100 U/g of beet pulp of each enzyme worked synergistically with yields of 100% arabinose and 91.7% pectin. These yields were higher than those obtained with traditional chemical hydrolysis. The pectin fraction showed a low content of neutral sugar content and the cellulose residue contained only a small amount of pentoses. Semicontinuous hydrolysis with enzyme recycling in an ultrafiltration unit was also carried out to separate arabinose, pectin, and cellulose from beet pulp in 7 cycles of hydrolysis followed by ultrafiltration. The yields of separation were similar to those obtained in batch experiments, with an enzyme consumption reduced by 3.5 times and some significant advantages over batch processes.     

The mutagenic activity of aflatoxin B1 in the Cricetulus griseus hamster and Macaca mulatta monkey

Chromosome aberrations were scored in bone marrow cells of Cricetulus griseus hamsters and Macaca mulatta monkeys given a single i.p. injection of aflatoxin B1 (AFB1). The mutagenic activity of AFB1 was assessed by the percentage of cells bearing aberrations and by the total frequency of chromosome and chromatid breaks. Chinese hamsters were treated with five different doses of AFB1 ranging from 1 microgram to 5 mg/kg (LD50/30 = 12.2 mg/kg) and the aberration yields at each AFB1 dose level tested were determined at 24 h intervals for 5 consecutive days. Compared to controls the increase in the two types of chromosome abnormalities was significant in all tests. At 5 mg/kg of AFB1 the tests were carried out over a period of 92 days to assure the analysis of aberration yields with time. All chromosome aberration assays conducted during this period showed significant increases in the frequencies of aberrant cells and chromosome and chromatid breaks in comparison to controls. Macaque monkeys were treated in the same fashion using 0.1 and 1.0 mg/kg of AFB1 and the dynamics of chromosome aberration yields was analyzed for a period of 730 days. Similarly as in the case of Chinese hamsters the percentage of cells with aberrations and the frequency of chromosome and chromatid breaks were always higher in this period than the control value. Long-term aberration yield data obtained experimentally were expressed in the form of analytical curves which allowed to establish the time when the yields of aberrant cells reached their maxima and when they returned to the control level. In both animal species tested the courses of analytical curves had a similar dynamics. Factors that might be responsible for a long-term persistence and relatively great fluctuations of the chromosome aberration yields encountered after a single injection of AFB1 are discussed in detail.     

The production of the enzyme dextransucrase using nonaerated fermentation techniques

High yields of the enzyme dextransucrase have been produced repeatedly by fed-batch fermentation techniques. Activities in excess of 21.9 U/cm(3) have been obtained by culturing Leuconostoc mesenteroides NRRL B-512(F) under nonaerated fed-batch fermentation conditions. Aerobic fermentations carried out under identical conditions have consistently produced enzyme of less than 17 U/cm(3), but with no difference in the final cell concentration in the broth. Different types of yeast extract have been found to have significant effect on the final cell concentration and more especially on the enzyme activity with enzyme yields varying by as much as 50% when different types of yeast extracts were used.     

Effect of acyl donor chain length and sugar/acyl donor molar ratio on enzymatic synthesis of fatty acid fructose esters

Lipase-catalyzed synthesis of fatty acid sugar esters through direct esterification was performed in 2-methyl 2-butanol as solvent. Fructose and saturated fatty acids were used as substrates and the reaction was catalyzed by immobilized Candida antarctica lipase. The effect of the initial fructose/acyl donor molar ratio and the carbon-chain length of the acyl donor as well as their reciprocal interactions on the reaction performance were investigated. For this purpose, an experimental design taking into account variations of the molar ratio (from 1:1 to 1:5) and the carbon-chain length of the fatty acid (from C8 to C18) was employed. Statistical analysis of the data indicated that the two factors as well as their interactions had significant effects on the sugar esters synthesis. The obtained results showed that whatever the molar ratio used, the highest concentration (73 g l⁻¹), fructose and fatty acid conversion yields (100% and 80%, respectively) and initial reaction rate (40 g l⁻¹ h⁻¹) were reached when using the C18 fatty acid as acyl donor. Low molar ratios gave the best fatty acid conversion yields and initial reaction rates, whereas the best total sugar ester concentrations and fructose conversion yields were obtained for high molar ratios.     

The synthesis of tris(hydroxymethyl)acetic acid by fermentation of pentaerythritol

A process was devised for the synthesis of tris(hydroxymethyl)acetic acid by means of bio-oxidation of pentaerythritol. A flavobacterium able to grow on pentaerythritol was isolated from the soil. Mutants were obtained that, were deficient, in their pentaerythritol oxidation system. These mutants could not grow on pentaerythritol, but when grown on an assimilable carbon source; they oxidized pentaerythritol to tris(hydroxymethyl)acetic acid. This conversion readily took place in a medium consisting of 20 g pentaerythritol, 10 g yeast extract, and 2 g acetic acid (neutralized) per liter. Since the mutants were unable to metabolize tris(hydroxymethyl)acetic acid, theoretical conversion yields were attainable. When pentaerythritol was added stepwise and the acid formed was neutralized continuously, 95–100% yields were obtained in concentrations of the order of 60 g/l.     

Production of xylanolytic enzymes by Streptomyces flavogriseus

Summary Cultures of Streptomyces flavogriseus produced considerable amounts of xylanase when grown on xylan containing media. Comparatively lower yields of this enzyme were obtained when hay or avicel served as main carbon source, -xylosidase was synthesized intracellularly and appeared less dependent on the fermentation substrate. The strain produced simultaneously various enzymes of the cellulase complex and the xylose induced glucose isomerase.     

Growth yields of microorganisms on methanol and methane. A theoretical study

An attempt was made to calculate growth yields of microorganisms on methanol and methane on the basis of known biochemical pathways of C₁ metabolism. Since 3-phosphoglycerate is a key intermediate in the assimilation pathways of C₁ compounds, the calculations were based on the assumption that the synthesis of cell material from C₁ substrates can be regarded as a two step process. When Y_ATP on 3-phosphoglycerate was taken as 10.5, a maximal cell yield of organisms of the composition C₄H₈O₂N on methanol was found to be 0.73 g cells/g substrate. For growth on methane a value of 0.91 g cells/g substrate was calculated when a mixed function oxidase was implicated in methane oxidation. These yields were calculated on the basis of the ribulose phosphate pathway of formaldehyde fixation as the major pathway of C₁ assimilation. Yields calculated on the basis of the serine pathway were on an average 20% lower. The calculations disclosed that for growth on methane, at least for Methylococcus capsulatus, a reversed electron transport system is required when methane is oxidized by a mixed function oxidase. The theoretical cell yields on methanol and methane have been compared with experimentally obtained yields and the validity of the estimations of growth yields on the basis of the present calculations is discussed.     

Direct fermentation of potato starch to ethanol by cocultures of Aspergillus niger and Saccharomyces cerevisiae

Direct fermentation of unhydrolyzed potato starch to ethanol by monocultures of an amylolytic fungus, Aspergillus niger, and cocultures of A. niger and Saccharomyces cerevisiae was investigated. Amylolytic activity, rate and amount of starch utilization, and ethanol yields increased several-fold in coculture versus the monoculture due to the synergistic metabolic interactions between the species. Optimal ethanol yields were obtained in the pH range 5 to 6 and amylolytic activity was obtained in the pH range 5 to 8. Ethanol yields were maximal when fermentations were conducted anaerobically. Increasing S. cerevisiae inoculum in the coculture from 4 to 12% gave a dramatic increase in the rate of ethanol production, and ethanol yields of greater than 96% of the theoretical maximum were obtained within 2 days of fermentation. These results indicate that simultaneous fermentation of starch to ethanol can be conducted efficiently by using cocultures of the amylolytic fungus A. niger and a nonamylolytic sugar fermenter, S. cerevisiae.