Methyl jasmonate enhanced production of rosmarinic acid in cell cultures of Satureja khuzistanica in a bioreactor

The growing interest in rosmarinic acid (RA), an ester of caffeic acid and 3,4‐dihydroxyphenyl lactic acid, is due to its biological activities, which include cognitive‐enhancing effects, slowing the development of Alzheimer's disease, cancer chemoprotection, and anti‐inflammatory activity. Inspired by the challenge of meeting the growing demand for this plant secondary metabolite, we developed a biotechnological platform based on cell suspension cultures of Satureja khuzistanica. The high amounts of RA produced by this system accumulated mainly inside the cells. To further improve production, two elicitors, 100 μM methyl jasmonate (MeJA) and 40 mM cyclodextrin (CD), were tested, separately and together. MeJA increased RA productivity more than 3‐fold, the elicited cultures achieving an RA production of 3.9 g L^?1 without affecting biomass productivity. CD did not have a clear effect on RA production, and under the combined treatment of MeJA + CD only a small amount of RA was released to the medium. When the cell culture was transferred from a shake flask to a wave‐mixed bioreactor, a maximum RA production of 3.1 g L^?1 and biomass productivity of 18.7 g L^?1 d^?1 was achieved under MeJA elicitation, demonstrating the suitability of S. khuzistanica cell suspensions for the biotechnological production of this bioactive plant secondary metabolite.     

Rhodospirillum rubrum: utilization of condensed corn solubles for poly-(3-hydroxybutyrate-co-3-hydroxyvalerate) production

Aims: This study sought to develop a less expensive medium for growth of the polyhydroxyalkanoate-producing bacterium Rhodospirillum rubrum from the ethanol production coproduct, condensed corn solubles (CCS). Methods and Results: Small-scale trials using R. rubrum were performed in aerated or anaerobic stoppered serum bottles filled with media. The CCS (240 g l⁻¹) achieved a maximum cell density and growth rate comparable with the defined supplemented malate-ammonium medium (mSMN) or tryptic soy broth. Microaerophilic solubles medium cultures exhibited significantly higher maximum cell densities and growth rates than did strictly anaerobic cultures; while illumination, nickel or biotin addition had no effect. Growth of R. rubrum in a pH controlled bioreactor was significantly better in CCS (240 g l⁻¹) than in mSMN medium and supported production of 0·36% (cell dry weight) poly-(3-hydroxybutyrate-Co-3-hydroxyvalerate) after 24 h. Conclusions: A CCS medium was devised that supported R. rubrum growth for biopolymer production as effective as the defined medium. Significance and Impact of the Study: This study demonstrates that a more economical medium can be developed for biopolymer production using a low value coproduct from ethanol production. The impact is that this inexpensive solubles medium may make it more economical to produce the biopolymer on a commercial scale.     

Growth and production characteristics of permeabilized Coleus blumei cells in immobilized fed-batch culture

Summary Permeabilized Coleus blumei cells were cultivated in an immobilized state to study the effect of dimethyl sulfoxide (DMSO) concentrations and growth regulators on cell growth and rosmarinic acid (RA) production characteristics. Luffa (the fibrous skeleton of mature fruit of Luffa cylindrica) was a good support matrix for cell immobilization because of its high void volume. Maximum cell loading capacity was 1.33 g dry cell weight (DCW)/g dry Luffa. The experiments were done in shake flasks with no free medium. The medium was supplied in a fed-batch mode to avoid the flotation of Luffa pieces. The sucrose in the medium was completely hydrolyzed to glucose and fructose without any sugar accumulation in the medium. The cell viability was slightly higher in the cells on top of the Luffa than those in the middle. Cell growth rate and rosmarinic acid (RA) production were approximately half that obtained in cell suspension cultures. Cell yield (g DCW/g glucose) was similar to that of cell suspension cultures. The absence of growth regulators did not promote an increase of RA production but did decrease the cell mass. The second step preconditioning with 0.5% DMSO did not improve the cell's adaptability to higher DMSO concentrations and the cell mass did not increase with 2.5% DMSO.     

Physiological characterization and cultivation strategies of the pentachlorophenol-degrading bacteria Sphingomonas chlorophenolica RA2 and Mycobacterium chlorophenolicum PCP-1

The physiological characteristics of growth and pentachlorophenol degradation of the bacteria Sphingomonas chlorophenolica RA2 and Mycobacterium chlorophenolicum PCP-1 were studied quantitatively in liquid culture under various conditions of pH, temperature, pO₂, pCO₂ and PCP concentration. Concerning their metabolic properties, RA2 and PCP-1 can be regarded as r-strategist and K-strategist, respectively. RA2 showed a higher activity concerning growth and PCP degradation than PCP-1 under optimum conditions. However, PCP-1 performed better under extreme conditions. Maximum growth rates or RA2 and PCP-1 on glucose were 0.21 h⁻¹ and 0.024 h⁻¹ and maximum PCP degradation rates 315 and 40 μmol (g of dry cells)⁻¹ h⁻¹, respectively. Optimized cultivation for RA2 on a technical scale led to the production of 40 g L⁻¹ of cell dry mass within 55 h. The cultivation strategy including pH-controlled ammonium feeding can be used to effectively produce sufficient biomass of both strains for both research and application as inoculants in soil clean-up. Received 28 July 1998/ Accepted in revised form 30 November 1998     

Rosmarinic acid production by <Emphasis Type="Italic">Coleus forskohlii</Emphasis>hairy root cultures

Coleus forskohlii hairy root cultures were found to produce forskolin and rosmarinic acid (RA) as the main metabolites. The growth and RA production by C. forskohlii hairy root cultures in various liquid media were examined. The hairy root cultures showed good growth in hormone-free Murashige and Skoog medium containing 3% (w/v) sucrose (MS medium), and Gamborg B5 medium containing 2% (w/v) sucrose (B5 medium). RA yield reached 4.0 mg (MS medium) and 4.4 mg (B5 medium) after 5 weeks of culture in a 100 ml flask containing 20 ml of each medium. Hairy root growth and RA were also investigated after treatment with various concentrations of yeast extract (YE), salicylic acid (SA) and methyl jasmonic acid (MJA). RA production in a 100 ml flask containing 20 ml B5 medium reached 5.4 mg (1.9 times more than control) with treatment of 0.01 or 1% (w/v) YE, 5.5 mg (2.0 times more than control) with treatment of 0.1 mM SA, and the maximum RA content with 9.5 mg per flask (3.4 times more than control) was obtained in the hairy roots treated with 0.1 mM MJA. These results suggest that MJA is an effective elicitor for production of RA in C. forskohlii hairy root cultures.     

Elicitation with methyl-jasmonate stimulates peruvoside production in cell suspension cultures of <Emphasis Type="Italic">Thevetia peruviana</Emphasis>

Thevetia peruviana is a small tree that produces several compounds with pharmaceutical application, among which peruvoside could be highlighted. However, these compounds are produced in low concentration in the plant, making it important to develop strategies such as plant cell culture and elicitation to obtain higher quantities of the desired product. In this work, cell suspension cultures of T. peruviana were established in four different culture media: Murashige–Skoog (MS), half Murashige–Skoog (half MS), Schenk–Hildebrandt (SH), and Gamborg (B5) to study their effect on cell growth. Cell growth kinetics were studied in SH medium, and the extracellular peruvoside production during the culture time was determined. The best culture medium for the establishment of cell suspension cultures was MS with a growth index of 3.17 ± 0.2 g g⁻¹ inoculum. The cell growth kinetics showed the four characteristic growth phases of a cell culture (lag, exponential, stationary, and death), and during none of these phases was it possible to observe peruvoside production. The elicitor effect of methyl-jasmonate (MeJ) was studied in cell suspension cultures established in SH medium. The effect of MeJ concentration and the time in which it should be applied were determined. The best results were obtained at a concentration of 100 mg l⁻¹ of MeJ applied at the beginning of the culture, which induced a peruvoside production of 8.93 mg l⁻¹ medium. The current results are the first report of an in vitro peruvoside production system.     

Effect of Cultivation Conditions on Growth and Adhesion of Bacillus licheniformis

Adhesion to glass of actively growing cells of the thermophilic Bacillus licheniformis, isolated from the Medyaginskaya test borehole (Yaroslavl' oblast), was studied. The reversible adhesion (RA) manifests itself in a decline of cell density (without cell lysis) in the liquid culture over the first 20–40 min of growth followed by normal exponential growth. The RA is minimal under favorable growth conditions but increases when cells are transferred to a new medium, especially one with a pH, temperature, salinity, or concentration of Ca²⁺ ions nonoptimal for the given species. Under unfavorable growth conditions, the adhesion becomes irreversible. The obtained data suggest that RA represents an adaptation mechanism important for population survival.     

Growth rate control in fed-batch cultures of recombinant Saccharomyces cerevisiae producing hepatitis B surface antigen (HBsAg)

Summary A recombinant Saccharomyces cerevisiae producing hepatitis B surface antigen (HBsAg) exhibited growth-assciated product formation. By controlling the medium feed rate, based on the calculated amount of medium required for 1 h, a constant specific growth rate was obtained in the range of 1.12-0.18 h^–1. In order to prolong the exponential growth phase, the medium feed rate was increased exponentially. A fedbatch cultivation method based on the production kinetics of batch culture enhanced HBsAg production ten times more than in batch culture. The reason for the increase can be explained by the fact that the production of HBsAg is expressed as an exponential function of time when the specific growth rate is controlled to a constant value in growth-associated product fromation kinetics. In the scale-up of this culture to 91, the specific growth rate could also be maintained constant and the HBsAg production trend was similar to that in a 1-l culture. However, ethanol accumulation occurred at a late stage in fed-bach culture. Ethanol produced was not reutilized and inhibited further cell growth. Offprint requests to: M. B. Gu     

Influence of the carbon source on growth and rosmarinic acid production in suspension cultures of Coleus blumei

Suspension cultures of Coleus blumei were characterized with respect to growth and rosmarinic acid formation in media with different sugars and various sugar concentrations. Sucrose is the sugar with the highest stimulating effect on growth and rosmarinic acid accumulation, followed by glucose and fructose. The sugar alcohol mannitol cannot be metabolized by the plant cells. Sucrose is cleaved into glucose and fructose by the Coleus cells. Sucrose concentrations from 1 to 5% have an increasing positive effect on growth and rosmarinic acid synthesis in the cell cultures with a maximum rosmarinic acid content of 12% of the dry weight in medium with 5% sucrose; in medium with 6% sucrose rosmarinic acid accumulation obviously did not reach its highest level in the culture period of 14 days. A very high yield of rosmarinic acid (2 mg ml^-1 suspension) could also be achieved by maintaining a sucrose concentration of 2% during the whole culture period. The start of rosmarinic acid synthesis by the cell cultures seems to be regulated by the growth limitation when a nutrient, e.g. phosphate is depleted from the medium. The rate of rosmarinic acid accumulation is related to the amount of carbon left in the medium when growth ceases.Abbreviations RA rosmarinic acid     

Influence of water activity on Streptococcus diacetylactis metabolism

During the cheese-making process, water activity (a_w) is one of the essential environmental parameters acting on bacterial growth and metabolic pathways. The influence of a_w on Streptococcus diacetylactis growth and lactic acid production was studied. The specific growth rate was linearly related to water availability in the milk medium. The cell behaviour was quite different above and below a_w=0.95, which can be considered a limiting value. Below this value, the lactic acid production reached 1.4–6.1 mg·g^–1, whereas the specific productivity was 2.0–2.6 mg·10^–10 cells·h^–1. Changes in the consumption of lactose and amino acids during the different growth phases was completely modified by decreasing the water availability in the medium. Correspondence to: N. Cochet     

Regulation of anthocyanin and lignin synthesis in Petunia hybrida cell suspensions

In Petunia hybrida cv. Violet 30 cell suspensions the phenylpropanoid pathway can be induced to produce lignin and anthocyanins. Orthovanadate addition leads to lignin accumulation, subculturing the cells using small inoculum sizes (<2 g fresh weight l^-1) gives rise to both anthocyanin and lignin production. Orthovanadate has a negative effect on cell growth. By replacing the medium, one day after orthovanadate addition, by medium without elicitor, we were able to restore growth without disturbing the lignin accumulation. The activity of phenylalanine ammonia-lyase (PAL) increased immediately after orthovanadate addition; this increase stopped upon medium replacement without affecting the lignin production. Reduction of the NAA concentration from 2 mg l^-1 to 0.1 mg l^-1, subsequent to the elicitation by orthovanadate or dilution stress, gave rise to a further increase in the production of lignin and anthocyanins respectively. Decreasing the NAA concentration without a prior elicitation, didn't have any effect on either PAL activity or product formation.Abbreviations 2,4-D 2,4 dichlorophenoxyacetic acid - BSA bovine serum albumine - FW fresh weight - NAA naphthaleneacetic acid - PAL phenylalanine ammonia-lyase - PPP phenyl propanoid pathway     

Optimization of lipid production in the oleaginous yeastApiotrichum curvatum in wheypermeate

Summary Lipid production of the oleaginous yeastApiotrichum curvatum was studied in wheypermeate to determine optimum operation conditions in this medium. Studies on the influence of the carbon to nitrogen ratio (C/N-ratio) of the growth medium on lipid production in continuous cultures demonstrated that cellular lipid content in wheypermeate remained constant at 22% of the cell dry weight up to a C/N-ratio of about 25. The maximal dilution rate at which all lactose is consumed in wheypermeate with excess nitrogen was found to be 0.073 h^-1. At C/N-ratios higher than 25–30 lipid content gradually increased to nearly 50% at C/N=70 and the maximal obtainable dilution rate decreased to 0.02 h^-1 at C/N=70. From these studies it could be derived that maximal lipid production rates can be obtained at C/N-ratios of 30–35 in wheypermeate. Since the C/N-ratio of wheypermeate normally has a value between 70 and 101, some additional nitrogen is required to optimize the lipid production rate. Lipid production rates ofA. curvatum in wheypermeate were compared in four different culture modes: batch, fed-batch, continuous and partial recycling cultures. Highest lipid production rates were achieved in culture modes with high cell densities. A lipid production rate of nearly 1 g/l/h was reached in a partial recycling culture. It was calculated that by using this cultivation technique lipid production rates of even 2.9 g/l/h may be reached when the supply of oxygen can be optimized.Nomenclature C/N-ratio carbon to nitrogen ratio of the growth medium (g/g) - C/N_crit C/N-ratio at which there is just enough nitrogen to allow all carbon source to be converted to biomass - D dilution rate=volume of incoming medium per unit time/volume of medium in the culture vessel (h^-1) - D_max maximum dilution rate (h^-1) - DW cell dry weight - L lipid yield (g storage lipid/g carbon source) - specific growth rate (h^-1) - _max maximum specific growth rate (h^-1) - Q_L lipid production rate (g/l/h) - Y_i molecular fraction of carbon substrate that is converted to storage carbohydrate (C-mol/C-mol) - Y_ls maximal amount of storage lipid that can be produced per mol carbon source (C-mol/C-mol)     

Establishment of Orthosiphon stamineus Cell Suspension Culture for Cell Growth

Callus of Orthosiphon stamineus could be induced successfully from petiole, leaf and stem tissues but not roots when cultured on MS medium containing different concentration of NAA (0–4.0 mg l^–1) and 2,4-D (0–2.0 mg l^–1). Highest fresh weight callus production was obtained from leaf explants and those with best friability were obtained on MS medium plus 1.0 mg l^–1 2,4-D plus 1.0 mg l^–1 NAA. Cell suspension cultures were established from these cultures. The appropriate cell inoculum size for the best cell growth was 0.75 g of cells in 20 ml culture medium. Cell suspension culture using MS medium supplemented with 1.0 mg l^–1 2,4-D promoted the best cell growth with maximum biomass of 8.609 g fresh weight and 0.309 g dry weight 24 days after inoculation. Cells that grew in MS medium supplemented with 1.0 mg l^–1 2,4-D reached the stationary growth phase in 15 days as compared to the cells that grew in MS medium supplemented with 1.0 mg l^–1 2,4-D + 1.0 mg l^–1 NAA reached the stationary phase in 24 days. MS medium supplemented with 1.0 mg l^–1 2,4-D was considered as the maintenance medium for maintaining the optimum cell growth of O. stamineus in the cell suspension cultures with 2-week interval subculture.     

Enhancement of Sf9 Cells and Baculovirus Production Employing Grace’s Medium Supplemented with Milk Whey Ultrafiltrate

Animal cells can be cultured both in basal media supplemented with fetal bovine serum (FBS) and in serum-free media. In this work, the supplementation of Grace’s medium with a set of nutrients to reduce FBS requirements in Spodoptera frugiperda (Sf9) cell culture was evaluated, aiming the production of Anticarsia gemmatalis nucleopolyhedrovirus (AgMNPV) at a cost lower than those for the production using Sf900 II medium. In Grace’s medium supplemented with glucose, Pluronic F68 (PF68) and yeast extract (YE), the effects of FBS and milk whey ultrafiltrate (MWU) on cell concentration and viability during midexponential and stationary growth phase were evaluated. In spite of the fact that FBS presented higher statistical effects than MWU on all dependent variables in the first cell passage studies, after cell adaptation, AgMNPV polyhedra production was comparable to that in Sf900 II. Batch cultivation in Grace’s medium with 2.7 g l⁻¹ glucose, 8 g l⁻¹ YE and 0.1% (w/v) PF68 supplemented with 1% (w/v) MWU and 3% (v/v) FBS increased viable cell concentration to about 5-fold (4.7×10⁶ cells ml⁻¹) when compared to Grace’s containing 10% (v/v) FBS (9.5×10⁵ cells ml⁻¹). AgMNPV polyhedra (PIBs) production was around 3-fold higher in the MWU supplemented medium (1.6×10⁷ PIBs ml⁻¹) than in Grace’s medium with 10% FBS (0.6×10⁷ PIBs ml⁻¹). This study therefore shows a promising achievement to significantly reduce FBS concentration in Sf9 insect cell media, keeping high productivity in terms of cell concentration and final virus production at a cost almost 50% lower than that observed for Sf900 II medium. C.A. Pereira is recipient of a CNPq fellowship.     

Selection of cell lines for the production of rosmarinic acid from cell suspension cultures of Orthosihon stamineus benth

Summary Cell suspension cultures of Orthosiphon stamineus were established from friable calluses produced from leaf pieces of in vitro plantlets that were derived from nodal segments of the mother plants collected from three different geographical locations. Eight lines were eventually selected after seven subculture cycles based on the growth characteristic (plant height) of the plantlets from the three locations: two fast-growing lines (>5.1 cm tall), three intermediate-growing lines (3.1–5.0 cm tall), and three slow-growing lines (<3.0 cm tall). All eight lines grew well in liquid Murashige and Skoog medium supplemented with 4.5 μM 2,4-dichlorophenoxyacetic acid (2,4-D) and 5.4 μM 1-naphthaleneacetic acid (NAA). All cell lines exhibited the same growth pattern but produced different maximum cell biomass when cultured in this medium. The time of harvesting the plant cells from the culture medium and the geographical source of the original plant material were both found to affect the production of rosmarinic acid (RA) in cell cultures. Two cell lines were successfully selected and identified to produce high amounts of RA. These cell lines were a fast-growing cell line from Air Itam, Penang and an intermediate-growing cell line from Relau Agriculture Research Centre, Penang which could produce 5% [(w/w) dry weight] and 4.5% [(w/w) dry weight] of RA, respectively.     

Production of lithospermic acid B and rosmarinic acid in hairy root cultures of Salvia miltiorrhiza

Hairy root cultures of Salvia miltiorrhiza were established by infecting sterile plantlets with Agrobacterium rhizogenes ATCC 15834, and the transformation was proved by direct detection of the inserted T-DNA by the polymerase chain reaction. As determined by HPLC, these hairy root cultures had the ability to produce lithospermic acid B (LAB), rosmarinic acid (RA) and other related phenolic compounds, the water-soluble active components of the plant. The effect of five different basal media, MS, MS-NH<INF>4</INF> (MS without ammonium nitrate), B5, WPM and 6,7-V on the root growth and phenolic compound production was studied. It was found that MS-NH<INF>4</INF> and 6,7-V media were superior to MS, B5 and WPM media in terms of both root growth and phenolic compound production. The time course of biomass accumulation and phenolic compound formation was also examined in the culture using MS-NH<INF>4</INF>medium. During cultivation, the content of RA in the roots was stable being approximately 0.48% of dry weight while the content of LAB fluctuated between 0.73% and 1.61% of dry weight, and decreased gradually at the stationary phase of growth. The highest production of LAB and RA was about 64 mg L⁻¹ and 23 mg L⁻¹, respectively. Received 05 November 1998/ Accepted in revised form 06 February 1999     

Insulin-like growth factors modulate the growth inhibitory effects of retinoic acid on MCF-7 breast cancer cells

Retinoids are currently being tested for the treatment and prevention of several human cancers, including breast cancer. However, the anti-cancer and growth inhibitory mechanisms of retinoids are not well understood. All-trans retinoic acid (RA) inhibits the growth of the estrogen receptor-positive (ER+) breast cancer cell line, MCF-7, in a reversible and dose-dependent manner. In contrast, insulin-like growth factors (IGF-I,IGF-II) and insulin are potent stimulators of the proliferation of MCF-7 and several other breast cancer cell lines. Pharmacologic doses of RA (≤10^?6M) completely inhibit IGF-I-stimulated MCF-7 cell growth. Published data suggest that the growth inhibitory action of RA on IGF-stimulated cell growth is linear and dose-dependent, similar to RA inhibition of unstimulated or estradiol-stimulated MCF-7 cell growth. Surprisingly, we have found that IGF-I or insulin-stimulated cell growth is increased to a maximum of 132% and 127%, respectively, by cotreatment with 10^?7 M RA, and that 10^?9–10^?7 M RA increase cell proliferation compared to IGF-I or insulin alone. MCF-7 cells that stably overexpress IGF-II are also resistant to the growth inhibitory effects of 10^?9–10^?7 M RA. Treatment with the IGF-I receptor blocking antibody, αIR-3, restores RA-induced growth inhibition of IGF-I-treated or IGF-II-overexpressing MCF-7 cells, indicating that the IGF-I receptor is mediating these effects. IGFs cannot reverse all RA effects since the altered cell culture morphology of RA-treated cells is similar in growth-inhibited cultures and in IGF-II expressing clones that are resistant to RA-induced growth inhibition. These results indicate that RA action on MCF-7 cells is biphasic in the presence of IGF-I or insulin with 10^?9–10^?7 M RA enhancing cell proliferation and ≥ 10^?6M RA causing growth inhibition. As IGF-I and IGF-II ligands are frequently detectable in breast tumor tissues, their potential for modulation of RA effects should be considered when evaluating retinoids for use in in vivo experimental studies and for clinical purposes. Additionally, the therapeutic use of inhibitors of IGF action in combination with RA is suggested by these studies. © 1995 Wiley-Liss Inc.     

Influence of Cultivation Parameters on Growth and Microcystin Production of Microcystis aeruginosa (Cyanophyceae) Isolated from Lake Chao (China)

Microcystis aeruginosa isolated in 2005 from the shallow eutrophic Lake Chao (Anhui, China) was investigated in terms of growth parameters and microcystin production under varying nutrient concentrations (P, N) and pH values (abiotic factors) as well as under the influence of spent medium of the non-toxic cyanobacterium Synechocystis sp. (biotic factors). Stimulating effects on growth were observed at the alkaline pH value (10.5), whereas toxin production was significantly increased under phosphate-P limitation (0.6 mg L⁻¹ medium). Within a broad range of nitrate–N concentrations (41.2–247.2 mg L⁻¹ medium), no significant influence on cell growth and microcystin production was observed; however, N-starvation resulted in a typical decrease of growth and toxicity. In addition, cryopreservation of M. aeruginosa evidenced the decrease of toxin production by time-dependent exposure with the cryoprotectant dimethyl sulfoxide under thawing conditions without affecting the growth of the cyanobacterial cells.     

An interchangeable system of hairy root and cell suspension cultures ofCatharanthus roseus for indole alkaloid production

Hairy roots ofCatharanthus roseus obtained by co-cultivation of hypocotyl segments withAgrobacterium rhizogenes, and cultured in SH (Schenk and Hildebrandt) basal medium, formed two types of calli when subcultured in SH medium with 1 mg/1 -naphthaleneacetic acid and 0.1 mg/l kinetin. One of them, a compact callus, when re-subcultured in SH basal medium gave rise to hairy roots again. A rhizogenic cell suspension culture was established from this type of callus. When cultured in SH medium with growth regulators, the rhizogenic callus produced catharanthine at a level of 41% of the level in the initial hairy roots. Upon transfer to SH basal medium, regenerated hairy roots produced this alkaloid at the original level of 1.5 mg/g dry wt. Using this cell/hairy root interchange system a new management system for hairy root culture in bioreactors has been devised and examined involving production of biomass in the form of a cell suspension in medium supplemented with growth regulators, and catharanthine production by hairy roots regenerated from these cells in medium without growth regulators.Abbreviations NAA -naphthaleneacetic acid - SH Schenk and Hildebrandt - SHNK SH medium + 1 mg 1^–1 NAA + 0.1 mg 1^–1 kinetin     

Biotechnological aspects of the production of the anticancer drug podophyllotoxin

The natural lignan podophyllotoxin, a dimerized product of two phenylpropanoid moieties which occurs in a few plant species, is a pharmacologically important compound for its anticancer activities. It is used as a precursor for the chemical synthesis of the anticancer drugs etoposide, teniposide and etopophose. The availability of this lignan is becoming increasingly limited because of the scarce occurrence of its natural sources and also because synthetic approaches for its production are still commercially unacceptable. Biotechnological production using cell culture may be considered as an alternative source. Selection of the best performing cell line, its maintenance and stabilization are necessary prerequisites for its production in bioreactors and subsequent scale-up of the cultivation process to the industrial level. Scale-up of growth and product yield depends on a multitude of factors, such as growth medium, physicochemical conditions, seed inoculum, type of reactor and processing conditions. The composition of the growth medium, elicitors and precursors, etc. can markedly influence the production. Optimum levels of parameters that facilitate high growth and product response in cell suspensions of Podophyllum hexandrum have already been determined by statistical design. P. hexandrum cells have successfully been cultivated in a 3-l stirred-tank bioreactor under low shear conditions in batch and fed-batch modes of operation. The batch kinetic data were used to identify the mathematical model which was then used to develop nutrient-feeding strategies for fed-batch cultivation to prolong the productive log phase of cultivation. An improvement in the production of podophyllotoxin to 48.8 mg l^–1 in a cell culture of P. hexandrum was achieved, with a corresponding volumetric productivity of 0.80 mg l^–1 day^–1, when the reactor was operated in continuous cell-retention mode. Efforts are being made to further enhance its production levels by the development of hairy root culture or by varying the channeling of precursors towards the desired biosynthetic pathway by molecular approaches.