Effect of temperature on ethanol tolerance of a thermophilic anaerobic ethanol producer Thermoanaerobacter A10: modeling and simulation

The low ethanol tolerance of thermophilic anaerobic bacteria (<2%, v/v) is a major obstacle for their industrial exploitation for ethanol production. The ethanol tolerance of the thermophilic anaerobic ethanol-producing strain Thermoanaerobacter A10 was studied during batch tests of xylose fermentation at a temperature range of 50-70 degrees C with exogenously added ethanol up to approximately 6.4% (v/v). At the optimum growth temperature of 70 degrees C, the strain was able to tolerate 4.7% (v/v) ethanol, and growth was completely inhibited at 5.6% (v/v). A higher ethanol tolerance was found at lower temperatures. At 60 degrees C, the strain was able to tolerate at least 5.1% (v/v) ethanol. A generalized form of Monod kinetic equation proposed by Levenspiel was used to describe the ethanol (product) inhibition. The model predicted quite well the experimental data for the temperature interval 50-70 degrees C, and the maximum specific growth rate and the toxic power (n), which describes the order of ethanol inhibition at each temperature, were estimated. The toxic power (n) was 1.33 at 70 degrees C, and corresponding critical inhibitory product concentration (P(crit)) above which no microbial growth occurs was determined to be 5.4% (v/v). An analysis of toxic power (n) and P(crit) showed that the optimum temperature for combined microbial growth and ethanol tolerance was 60 degrees C. At this temperature, the toxic power (n), and P(crit) were 0.50, and 6.5% (v/v) ethanol, respectively. From a practical point of view, the model may be applied to compare the ethanol inhibition (ethanol tolerance) on microbial growth of different thermophilic anaerobic bacterial strains.     

Combined effects of sulfites, temperature, and agitation time on production of glycerol in grape juice by Saccharomyces cerevisiae.

Analysis of variance was used to evaluate the simultaneous effects of strain, incubation temperature (15 to 25 degrees C), agitation time (0 to 24 h), and initial sulfite concentration (100 to 300 ppm) on glycerol production in grape juice by Saccharomyces cerevisiae. Fourteen strains were studied to determine their growth patterns in the presence of sulfites and ethanol. Baker's yeast strains were more sensitive to sulfite than wine strains, and little growth occurred at initial sulfite levels greater than 150 ppm. Sensitivity to sulfite increased with increasing levels of ethanol. Three strains exhibiting the best growth in the presence of sulfites and ethanol were selected for interaction studies. Fermentations were carried out until the solids content had decreased to less than 6 degrees Brix, which was the point that glycerol content became stable. For the three strains used, the greatest level of glycerol production was observed in the presence of 300 ppm of sulfite for most incubation temperatures and agitation times. There was significant interaction between the strain, incubation temperature, and agitation time parameters for glycerol synthesis, and a response surface method was used to predict the optimal conditions for glycerol production. Under static conditions, the highest level of glycerol production was observed at 20 degrees C, while incubation at 25 degrees C gave the best results when the cultures were agitated for 24 h. Response surface equations were used to predict that the optimum conditions for glycerol production by S. cerevisiae Y11 were a temperature of 22 degrees C, an initial sulfite concentration of 300 ppm, and no agitation, which yielded 0.68 g of glycerol per 100 ml.     

High ethanol tolerance of new isolates of Clostridium thermocellum strains SS21 and SS22

Clostridium thermocellum strains SS21 and SS22, producing high yields of ethanol, were tolerant to 4.0 and 5.0% (v/v) ethanol, respectively. This is the highest ethanol tolerance so far reported by wild type strains of C. thermocellum. In the presence of added ethanol, both the strains had extended period of growth arrest. On addition of ethanol at different culture ages increase in ethanol tolerance upto 7.0 and 8.0% (v/v) by strains SS21 and SS22, respectively was observed. The optimum growth temperature for strain SS21 decreased as the concentration of ethanol in the medium increased and remained constant for strain SS22. Both the strains were tolerant to various solvents and acetic acid indicating that high ethanol tolerance of the strains is due to the general solvent tolerance of the organisms.     

Characteristics of growth and changes in the ultrafine structure of bacteria in the course of continuous cultivation on media containing ethanol

A large number of bacterial strains assimilating chemical ethanol has been isolated using an original technique. Active growth of strains belonging to the genera Pseudomonas and, particularly, Acinetobacter was registered on mineral media containing ethanol. A mathematical model was constructed select a strain of Acinetobacter calcoaceticus K-9 during its continuous cultivation on media containing ethanol. The model makes it possible to determine conditions for producing a present amount of the biomass, the percentage of its yield, and the produc;iveness as a function of the dilution rate, temperature, and the concentration of ethanol and phosphoric acid in the medium. The main characteristics of the growth process in the studied factor space were established. The optimum conditions were calculated for growth of the strain with respect to each of the criteria. Under various conditions of bacterial growth, changes in the morphology and ultra-fine structure of the cells correlated with their physiological activity. The volume of the cells increased with the rate of dilution of the medium: the process can be described by a saturation curve. The presence of mesosomal structures is typical of the cells growing at low flow rates.     

Enhancement of Pyrroloquinoline Quinone Production and Polyvinyl Alcohol Degradation in Mixed Continuous Cultures of Pseudomonas putida VM15A and Pseudomonas sp. Strain VM15C with Mixed Carbon Sources

In a mixed continuous culture of Pseudomonas putida VM15A and Pseudomonas sp. strain VM15C with polyvinyl alcohol (PVA) as the sole source of carbon, growth of the PVA-degrading bacterium VM15C and, hence, PVA degradation were limited by the growth factor, pyrroloquinoline quinone, produced by VM15A. Feeding of a carbon source for VM15A, ethanol, with PVA enhanced pyrroloquinoline quinone production and caused increases in the VM15C population and PVA degradation in a mixed continuous culture. There was an optimum range for PVA degradation of the ethanol concentration, although pyrroloquinoline quinone concentrations in continuous mixed cultures increased with increasing ethanol concentration.     

Methanosarcina baltica,sp. nov., a novel methanogen isolated from the Gotland Deep of the Baltic Sea

A novel methanogen, Methanosarcina baltica GS1-AT, DSM 14042, JCM 11281, was isolated from sediment at a depth of 241 m in the Gotland Deep of the Baltic Sea. Cells were irregular, monopolar monotrichous flagellated cocci 1.5-3 microm in diameter often occurring in pairs or tetrads. The catabolic substrates used included methanol, methylated amines, and acetate, but not formate or H2/CO2. Growth was observed in a temperature range between 4 degrees and 27 degrees C with an optimum at 25 degrees C. The doubling time with methanol as substrate was 84 h at 25 degrees C, 120 h at 9 degrees C, and 167 h at 4 degrees C. The doubling time with acetate as substrate was 252 h at 25 degrees C and 425 h at 20 degrees C. After the transfer of methanol-grown cultures, long lag phases were observed that lasted 15-20 days at 25 degrees C and 25 days at 4 degrees -9 degrees C. The NaCl optimum for growth was 2%-4%, and the fastest growth occurred within a pH range of 6.5-7.5. Analysis of the 16S rDNA sequence revealed that the strain was phylogenetically related to Methanosarcina. The sequence similarity to described species of <95.7% and its physiological properties distinguished strain GS1-A(T) from all described species of the genus Methanosarcina.     

The effect of temperature,pH, and initial glucose concentration on the kinetics of ethanol production by Zymomonas mobilis in batch fermentation

Summary Zymomonas mobilis, strain ATCC 10988, was used to evaluate the effects of pH (5.0 to 8.0), temperature (30°C to 40°C), and initial glucose concentration (75 g/l to 150 g/l) on the kinetics of ethanol production from glucose using batch fermentation. Specific ethanol production rate was maximum and nearly constant over a pH range of 6.0 to 7.5. End-of-batch ethanol yield and specific growth rate were insensitive to pH in the range of 5.0 to 7.5. End-of-batch ethanol yield was maximum and nearly constant between 30°C and 37°C but decreased by 24% between 37°C and 40°C. All other kinetic parameters are greatest at 34°C. End-of-batch ethanol yield is maximum at an initial glucose concentration of 100 g/l. Specific growth rate reaches a maximum at 75 g/l, but specific ethanol production rate decreases throughout the range. The optimum initial glucose concentration of 100 g/l gives the highest ethanol yield at a specific ethanol production rate less than 10% below the maximum observed.     

Involvement of oxygen and mitochondrial function in the metabolism of D-xylulose by Saccharomyces cerevisiae

Mitochondrial function associated with oxygen was required for growth of Saccharomyces cerevisiae on D-xylulose. The requirement was shown by (i) the inhibition of growth of a wild-type strain under anaerobic conditions, (ii) the inhibition of aerobic growth after treatment with inhibitors of mitochondrial function, and (iii) the lack of aerobic and anaerobic growth of nuclear and cytoplasmic petites. The mitochondrial function was associated with the channeling of catabolites of D-xylulose to growth processes, since ethanol was formed even when growth was inhibited. Mitochondrial function was implicated as well in determining the extent of growth and the concentration of ethanol in aerobic cultures of the wild-type. In such cultures, the concentration of ethanol decreased and growth increased concomitantly as aeration rate increased. A factor in this relation was considered to be the relatively poor ability of D-xylulose to inhibit the oxidative utilization of ethanol.     

Fuel alcohol biosynthesis by Zymomonas anaerobia: Optimization studies

The optimum operating conditions for growth and ethanol production of Zymomonas anaerobia ATCC 29501 were established. The optimum pH range and temperature were found to be 5.0-6.0 and 35 degrees C, respectively. Based on the results obtained from the temperature optimization study, an Arrhenius-type temperature relationship for the specific growth rate was developed. The growth and ethanol production of this microbe also have been optimized in terms of concentrations of glucose, essential nutrients, and minerals. With optimum medium and operating conditions, an ethanol concentration of 96 g/L was obtained in 23 h. Both growth and ethanol yield coefficients in dependence on initial glucose concentrations were determined.     

Temperature effects on ethanol and isopropanol utilization by Candida krusei

Candida Krusei has a optimum growth temperature of 37°C on SASOL ethanol-isopropanol mixture. The organism was unable to grow on isopropanol, but oxidized it partially to acetone in the presence and absence of ethanol. Growth at 40°C in the alcohol mixture was slightly faster than at 30°C over an ethanol concentration range of 0.43 to 3.6% (v/v), although at both temperatures the growth rate declined continuously with increasing concentration. At an ethanol concentration greater than 3.6% (v/v), the mixture was much more inhibitory to growth at 40 and 30°C. The inhibitory effect was due to the ethanol rather than the isopropanol. Metabolites such as acetate, acetaldehyde, and ethyl acetate accumulated in the medium, but the degree of accumulation depended upon the temperature and alcohol mixture concentration. At 40°C, acetaldehyde and acetate accumulated to a greater extent than 30°C on a 4.0% (v/v) synthetic alcohol mixture and this may also cause the greater inhibition at this temperature. The alcohol mixture is unsuitable for single cell protein (SCP) production in batch culture because of the low cell densities observed at all alcohol concentrations.     

Influence of environmental parameters on polyphosphate accumulation inAcinetobacter sp.

The regulation of and the optimum conditions for polyphosphate accumulation inAcinetobacter sp. were determined.Acinetobacter strain 210A accumulated polyphosphate in the presence of an intra- or extracellular energy source. The accumulation of polyphosphate during endogenous respiration was stimulated by streptomycin and inhibited by KCN. The highest amount of polyphosphate was found in cells in which energy supply was not limited, namely at low growth rates under sulphur limitation, and in the stationary phase of growth when either the nitrogen or the sulphur source was depleted. The phosphorus accumulation was not affected by the pH between 6.5 and 9. There was a pronounced effect of the temperature on phosphorus accumulation but is varied from strain to strain.Acinetobacter strain 210A accumulated more phosphate at low temperatures, strain B8 showed an optimum accumulation at 27.5° C, while strain P accumulated phosphorus independently of the temperature. The optimum temperature for growth ofAcinetobacter strains tested ranged from 25 to 33° C, and the optimum pH was between 6 and 9.     

Thermoanaerobacterium thermostercus sp. nov., a new anaerobic thermophilic hydrogen-producing bacterium from buffalo-dung

A novel thermophilic, anaerobic, rod-shaped bacterium strain, designated Buff, was isolated from buffalo-dung samples collected from a buffalo-farm located in Caserta (Campania, south of Italy). Strain Buff was Gram-positive, motile and no spore-forming. The growth temperature range was 40–65°C with an optimum at 60°C, while pH growth range at 60°C was 5.5–8.0 with an optimum at about pH 6.5. NaCl growth concentration ranged from 0 to 2.0% with an optimum at 0.5% (w/v); no growth was observed with the presence of NaCl 3.0% (w/v). The strain produced ethanol, acetate, lactate, H₂, H₂S and CO₂ by glucose fermentation. The DNA G + C content was 34.4 mol%. As determined by 16S rRNA sequence analysis, this organism belonged to the genus Thermoanaerobacterium. On the basis of the physiological and molecular properties, we propose for strain Buff the new species designation Thermoanaerobacterium thermostercus sp. nov. This novel organism represents the first species of the genus Thermoanaerobacterium isolated from buffalo-dung. The type strain is Buff (=DSM 22141 = ATCC BAA-1776).     

Growth and fermentation characteristics of new selected strains of Saccharomyces at high temperatures and high cell densities

Maintenance of high cell viability was the main characteristic of our new strains of thermotolerant Saccharomyces. Total sugar conversion to ethanol was observed for sugarcane juice fermentation at 38-40 degrees C in less than 10 h and without continuous aeration of the culture. Invertase activity differed among the selected strains and increased during fermentation but was not dependent on cell viability. Invertase activity of the cells and optimum temperature for growth, as well as velocity of ethanol formation, were dependent on medium composition and the type of strain used. At high sugarcane syrup concentrations, the best temperature for ethanol formation by strain 781 was 35 degrees C. Distinct differences among the velocities of ethanol production using selected strains were also observed in sugarcane syrup at 35-38 degrees C.     

Optimum pH and temperature conditions for xylose fermentation by Pichia stipitis

Pichia stipitis NRRL Y-7124 is a xylose-fermenting yeast able to accumulate ca. 57 g/L ethanol. Because optimum process conditions are important, data were collected to determine the effects of temperature and pH on growth and fermentation rates and product accumulations. Temperatures (26-35 degrees C) providing optimum biomass and ethanol productivities did not necessarily provide maximum ethanol accumulation. Xylitol and residual xylose concentrations increased with temperature. Maximum ethanol selectivity was achieved at 25-26 degrees C with minimal sacrifice to production rates. The temperature optimum for xylose could not be generalized to glucose fermentations, in which ethanol productivity and accumulation were optimum at 34 degrees C. The optimum pH range for growth and fermentation on xylose was 4-7 at 25 degrees C.     

Effect of Temperature of the Culture Medium on Growth and Nitrogen Fixation of Inoculated Legumes and Rhizobia

Two pea (Pisum sativum L.) cultivars and a kidney bean (Phaseolus vulgaris L.) cultivars were grown in water cultures at different diurnal temperatures (15, 20, 24, 27, 30°C) or at 10°C night temperature combined with various day temperatures (20, 24, 27, 33 or 35°C) in the root medium. The inoculated plants were, more sensitive to the extreme temperatures than the plants supplied with combined nitrogen (KNO₃). The middle-European pea cv. Violetta was adapted to somewhat higher root temperatures than the northern one cv. Torsdag II, the latter showing better growth at lower temperatures, when the plants were inoculated with the same Finnish Rhizobinm strain (HA1). Especially at optimum day temperatures the nitrogen fixation and consequently the dry weights of the inoculated plants were greatly increased when the night temperature was lowered. The optimum temperature for the growth of free-living Rhizobium strains (HA1 and H43) for peus was found to be 25°C and that of a strain (P103) for beans somewhat higher. Effective nitrogen fixation by nodulated legumes without a supply of combined nitrogen is achieved only when the optimum temperature range for root function is very close to the optimum for the rhizobia.     

Conversion of D-xylose to ethanol by the yeast Pachysolen tannophilus

The yeast Pachysolen tannophilus was found to be capable of converting D-xylose to ethanol. Batch cultures initially containing 50 g/L D-xylose yielded 0.34 g of ethanol per gram of pentose consumed. Aerobic conditions were required for cell growth but not for ethanol production. Both alcohol formation and growth were optimum when incubation temperature was 32 degrees C, when pH was near 2.5, and when D-xylose and ethanol concentrations did not exceed 50 and 20 g/L, respectively.     

Genome shuffling to improve thermotolerance,ethanol tolerance and ethanol productivity of <Emphasis Type="Italic">Saccharomyces cerevisiae</Emphasis>

Genome shuffling is a powerful strategy for rapid engineering of microbial strains for desirable industrial phenotypes. Here we improved the thermotolerance and ethanol tolerance of an industrial yeast strain SM-3 by genome shuffling while simultaneously enhancing the ethanol productivity. The starting population was generated by protoplast ultraviolet irradiation and then subjected for the recursive protoplast fusion. The positive colonies from the library, created by fusing the inactivated protoplasts were screened for growth at 35, 40, 45, 50 and 55°C on YPD-agar plates containing different concentrations of ethanol. Characterization of all mutants and wild-type strain in the shake-flask indicated the compatibility of three phenotypes of thermotolerance, ethanol tolerance and ethanol yields enhancement. After three rounds of genome shuffling, the best performing strain, F34, which could grow on plate cultures up to 55°C, was obtained. It was found capable of completely utilizing 20% (w/v) glucose at 45–48°C, producing 9.95% (w/v) ethanol, and tolerating 25% (v/v) ethanol stress.     

Isolation from soil and properties of the extreme thermophile Clostridium thermohydrosulfuricum.

Thirteen strains of a strict anaerobic, extreme thermophilic bacterium were isolated from soil samples of moderate temperature, from a sewage plant in Georgia, and from hot springs in Utah and Wyoming. They were identified as strains of Clostridium thermohydrosulfuricum. The guanosine + cytosine content (moles percent) was 37.6 (determined by buoyant density) and 34.1 (determined by melting temperature). All strains required a factor present in yeast extract or tryptone growth. Growth characteristics were as follows: a pH range of 5 to 9, with the optimum between 6.9 to 7.5, in a temperature range of 40 to 78 degrees C, with the optimum at 68 degrees C. The doubling time, when grown on glucose at temperature and pH optima, was 1.2 h. The main products of glucose fermentation were ethanol, lactate, acetate, CO2, and H2. The fermentation was inhibited by H2. Formation of spores occurred easily on glucose-agar medium or when cultures growing at temperatures above 65 degrees C were allowed to cool to temperature below 55 degrees C. C. thermohydrosulfuricum occurs widely distributed in the natural environment.     

Influence of ethanol and temperature on the cellular fatty acid composition of Zygosaccharomyces bailii spoilage yeasts

Changes in the fatty acid profile of Zygosaccharomyces bailii strains, isolated from different sources, after growth at increasing concentrations of ethanol and/or decreasing temperatures were determined. Differences in fatty acid composition between Zygosaccharomyces bailii strains at standard conditions (25°C, 0% initial ethanol) were observed and could be related to ethanol tolerance. Zygosaccharomyces bailii strain isolated from wine showed the highest ethanol tolerance in relation to growth rate. Surprisingly, an increase in ethanol concentration or a decrease in growth temperature caused a decrease in the degree of unsaturation of total cellular fatty acids. On the other hand, the mean chain length increased (high ethanol concentration) or decreased (low temperature) depending on the stress factor. When both stress situations (high ethanol concentration and low temperature) were present at the same time, the degree of unsaturation remained approximately constant. With decreasing temperatures, the C16/C18 ratio increased in studies of initial ethanol content below 5%, and above 5% ethanol, decreased.