The use of the bacteriocin, nisin, as a preservative in ricotta-type cheeses to control the food-borne pathogen Listeria monocytogenes

The efficacy of nisin to control the food-borne pathogen Listeria monocytogenes in ricotta-type cheeses over long storage (70 d) at 6–8°C was determined. Cheeses were prepared from unpasteurized milk by direct acidification with acetic acid (final pH 5·9) and/or calcium chloride addition during heat treatment. Nisin was added in the commercial form of Nisaplin^® pre-production to the milk. Each batch of cheese was inoculated with 10²–10³ cfu g⁻¹ of a five-strain cocktail of L. monocytogenes before storage. Shelf-life analysis demonstrated that incorporation of nisin at a level of 2·5 mg l⁻¹ could effectively inhibit the growth of L. monocytogenes for a period of 8 weeks or more (dependent on cheese type). Cheese made without the addition of nisin contained unsafe levels of the organism within 1–2 weeks of incubation. Measurement of initial and residual nisin indicated a high level of retention over the 10-week incubation period at 6–8°C, with only 10–32% nisin loss.     

Effect of heat treatment on Listeria monocytogenes and Gram-negative bacteria in sheep, cow and goat milks

Sheep milk, compared with cow and goat milk, had a protective effect on Gram-negative bacteria and Listeria spp. heated at 65°C in a test-tube method. This effect was not solely due to fat content as cow milk artificially reconstituted to 10% homologous fat was not as protective. Listeria monocytogenes in whole sheep, cow and goat milks at an inoculum level of 1 times 10⁶ cfu ml^-1 was heated at 68°C for 15 s in the plate pasteurizer and survival was only detected in whole sheep milk after heating. Whole sheep, cow and goat milks containing high levels of L. monocytogenes (1 times 10⁶ cfu ml^-1) could not survive the current HTST plate pasteurization protocol.     

Use of the polymerase chain reaction for direct detection of Listeria monocytogenes in soft cheese

The polymerase chain reaction (PCR) amplification technique was investigated as a tool for direct detection of Listeria monocytogenes in soft cheeses. Different sets of oligonucleotide primers were used, and parts of the L. monocytogenes Dth18-gene could be amplified specifically when either a plasmid vector carrying the cloned gene or chromosomal DNA was used as a template. The detection limit for L. monocytogenes in dilutions of pure cultures was between 1 and 10 colony-forming units. In extracts from soft cheeses containing L. monocytogenes DNA, the amplification was strongly inhibited. This inhibition could be reduced by an additional purification step. Despite this the detection limit showed a large variation, depending on the brand of cheese used. In some cheeses 10³ cfu/0.5 g could be visualized whereas in others the presence of 10⁸ cfu/0.5 g did not yield a detectable quantity of amplified product.     

Inhibition of Listeria monocytogenes by enterocin 4 during the manufacture andripening of Manchego cheese

The inhibitory effect of enterocin 4, a bacteriocin produced by Enterococcus faecalis INIA 4, on Listeria monocytogenes strains Ohio and Scott A during themanufacture and ripening of Manchego cheese was investigated. Raw ewe's milk wasinoculated with ca 10⁵ cfu ml⁻¹ of L.monocytogenes and with 1% of a commercial lactic starter, 1% of an Ent. faecalis INIA 4 culture, or 1% of each culture. Manchego cheeses were manufactured according tousual procedures. Listeria monocytogenes Ohio counts decreased by 3 log units after8 h and by 6 log units after 7 d in cheese made from milk inoculated with Ent. faecalis INIA 4 or with both cultures, whereas no inhibition was recorded after 60 d in cheese made frommilk inoculated with commercial lactic starter. Listeria monocytogenes Scott A wasnot inhibited by enterocin 4 during cheese manufacture, but decreases of 1 log unit after 7 d andof 2 log units after 60 d were achieved in cheese made from milk inoculated with bothcommercial lactic starter and Ent. faecalis INIA 4.     

Growth and enterotoxin production of Staphylococcus aureus during the manufacture and ripening of Camembert-type cheeses from raw goats' milk

Tests were carried out to determine the effect of manufacturing procedures for a Camembert-type cheese from raw goats' milk on the growth and survival of Staphylococcus aureus organisms added to milk at the start of the process, and to study the possible presence of staphylococcal enterotoxin A in these cheeses. The initial staphylococcal counts were, respectively, 2, 3, 4, 5 and 6 log cfu ml⁻¹. Cheese was prepared following the industrial specifications and ripened for 41 d. Detection of enterotoxins was done by the Vidas SET test and by an indirect double-sandwich ELISA technique using antienterotoxin monoclonal antibodies. Generally, numbers of microbes increased at a similar rate during manufacture in all cheeses until salting. During the ripening period, the aerobic plate count population and Staph. aureus levels remained stable and high. There was an approximately 1 log reduction of Staph. aureus in cheeses made with an initial inoculum of Staph. aureus greater than 10³ cfu ml⁻¹ at the end of the ripening period (41 d) compared with the count at 22 h. The level of staphylococcal enterotoxin A recovered varied from 1 to 3·2 ng g⁻¹ of cheese made with an initial population of 10³–10⁶ cfu ml⁻¹. No trace of enterotoxin A was detected in cheeses made with the lowest Staph. aureus inoculum used in this study.     

Factors affecting the growth of Listeria monocytogenes on minimally processed fresh endive

The influence of various factors on the fate of Listeria monocytogenes on cut leaves of broad-leaved endive has been studied. Factors considered were temperature, characteristics of the leaves (age, quantity and quality of the epiphytic microflora) and characteristics of the L. monocytogenes inoculum (concentration, strain). The increases in numbers of L. monocytogenes were lower than those of the aerobic mesophilic microflora at 3°, 6°, 10° and 20°C. Doubling times of the populations of L. monocytogenes were in the same order of magnitude as those of aerobic bacteria at 10° and 20°C, but longer at 3° and 6°C. There were positive significant correlations between growth of L. monocytogenes and populations of aerobic bacteria, and between growth of L. monocytogenes and extent of spoilage on the leaves.
Of 225 bacteria isolated from the leaves, 84% were identified as fluorescent pseudomonads; there was no difference in the species isolated from leaves that showed a low growth of L. monocytogenes and leaves that showed a high growth of L. monocytogenes. Populations of L. monocytogenes increased faster during the first 2 and 4 d of storage at 10°C on leaves inoculated with 10–10³ cfu g^-1 than on leaves inoculated with about 10⁵ cfu g^-1, but the population reached after 7 d was lower. The behaviour of L. monocytogenes was similar among the three strains tested.     

Enterobacteriaceae, coliforms, faecal coliforms and salmonellas in raw ewes'milk

Thirty-nine samples of freshly drawn ewes' milk collected at 13 farms, and 120 samples of raw ewes' milk collected on arrival at a dairy were examined. Farm samples had geometric mean counts of 4.4 × 10² Enterobacteriaceae/ml, 3.9 × 10² coliforms/ml and 2.0 × 10² faecal coliforms/ml, whereas the respective mean counts were 6.2 × 10³/ml, 5.4 × 10³/ml and 1.3 × 10³/ml for dairy samples. Salmonellas were not detected by enrichment procedures in any of the 159 samples examined. Escherichia coli (47.5% strains), Enterobacter cloacae (17.7%), Ent. agglomerans (11.3%), Hafnia alvei (6.5%) and Klebsiella oxytoca (6.0%) were the predominant species in 434 Enterobacteriaceae strains isolated from farm samples. Levels and species of Enterobacteriaceae found in the present work in raw ewes' milk imply a considerable risk of early blowing in cheese-making from unpasteurized milk.     

Incidence of pathogenic bacteria in raw milk in Ireland

Raw milk from 70 farms was sampled over 13 months for salmonellas, listerias, Escherichia coli, Staphylococcus aureus and mastitic streptococci; total bacterial counts (TBC), coliforms and somatic cells were also counted. TBC ≤30000/ml were obtained in 63% of samples. High count milks were found mainly during the winter months: 13% of samples had > 10⁴ mastitis pathogens/ml of milk. The mean somatic cell count varied from 4.0 × 10⁵ to 8.0 × 10⁵/ml throughout the year with highest counts during the late lactation period. Coliforms were present in all samples, but 65–71% of samples had < 100 coliforms/ml. Up to 60% of supplies had ≤10 E. coli /ml. One of the 589 samples tested (0.1%) was positive for salmonellas. Yersinia enterocolitica and Y. enterocolitica -like organisms were isolated from 39% of samples with up to 68% of samples positive at some sampling periods. A total of 222 strains of yersinias were isolated; Y. enterocolitica (59%) was the most common strain followed by Y. fredriksenii (35%), Y. kristensenii (1.0%), Y. intermedia (4.5%) and Y. aldovae (0.5%). Listerias were isolated from 8.3% of samples tested; 4.9% were Listeria monocytogenes and 3.4% were L. innocua. There was a significant rise in the isolation rate between December and April from a base line of 0–5% during the spring and summer to 35–37% during the winter months while the cows were indoors. Of 66 silage samples tested from the farms involved in the survey 9% of samples were positive for listerias; 3% of these were L. monocytogenes and 6% were L. innocua. Only half of the farms feeding contaminated silage produced milk containing listerias.     

Fate of pathogenic and non-pathogenic Escherichia coli strains in two fermented milk products

F eresu , S. & N yati , H. 1990. Fate of pathogenic and non-pathogenic Escherichia coli strains in two fermented milk products. Journal of Applied Bacteriology 69 , 814–821.
The growth and survival of pathogenic and non-pathogenic strains of Escherichia coli was determined in traditionally fermented pasteurized and unpasteurized milk and in Lacto, an industrially fermented milk. Each milk treatment was incubated at 20C for 24 h and then stored at either 20C or 5C for 96 h.
Lacto inhibited all the three E. coli strains. Two strains could not be recovered and the third survived only in very low numbers after 24 h storage of Lacto at both 20C and 5C. All three E. coli strains survived and multiplied to maximum cell numbers in the range 10⁷-10⁹/ml during traditional fermentation of unpasteurized milk. Cell numbers decreased to 10³-10⁶ and 10²-10⁵ during storage of the fermented product at 20C and 5C respectively. Higher maximum numbers, 10⁹-10¹⁰, of the three strains of E. coli were attained during traditional fermentation of pasteurized milk. The numbers decreased to 10⁵-10⁸ and 10⁴-10⁷ during storage of the fermented product at 20C and 5C respectively. Generally, fewer E. coli survived when the fermented milk products were stored at refrigeration temperature.     

Semi-automated counting of bacteria and somatic cells in milk using epifluorescence microscopy and television image analysis

An epifluorescent microscope fitted with a 'Chalnicon' closed circuit television camera linked to an Optomax System III image analyser was used to count bacteria and somatic cells on membrane filters prepared from milk by the direct epifluorescent filter technique (DEFT). For both bacteria and somatic cells, the semi-automated DEFT count of low count milk exceeded the visual DEFT count but this difference became proportionately less as the count increased. There was close agreement between the semi-automated and visual DEFT counts over the range 10⁵-5 times 10⁶/ml for bacteria and 3 times 10⁵-5 times 10⁶/ml for somatic cells. The semi-automated DEFT count of bacteria and somatic cells correlated well with the plate count and Coulter count respectively, with correlation coefficients of 0.83 and 0.81.     

Effect of high-temperature, short-time (HTST) pasteurization on milk containing low numbers of Mycobacterium paratuberculosis

The efficacy of high-temperature, short-time (HTST) pasteurization (72 °C/15 s) when low numbers (≤ 10³ cfu ml ⁻¹ ) of Mycobacterium paratuberculosis are present in milk was investigated. Raw cows' milk spiked with Myco. paratuberculosis (10³ cfu ml⁻¹, 10² cfu ml⁻¹, 10 cfu ml⁻¹, and 10 cfu 50 ml⁻¹) was subjected to HTST pasteurization using laboratory pasteurizing units. Ten bovine strains of Myco. paratuberculosis were tested in triplicate. Culture in BACTEC Middlebrook 12B radiometric medium detected acid-fast survivors in 14·8% and 10% of HTST-pasteurized milk samples at the 10³ and 10² cfu ml⁻¹ inoculum levels, respectively, whereas conventional culture on Herrold's egg yolk medium containing mycobactin J detected acid-fast survivors in only 3·7% and 6·7% of the same milk samples. IS900-based PCR confirmed that these acid-fast survivors were Myco. paratuberculosis . No viable Myco. paratuberculosis were isolated from HTST-pasteurized milk initially containing either 10 cfu ml⁻¹ or 10 cfu 50 ml⁻¹.     

Survival of Listeria monocytogenes in yogurt during storage at 4°C

Cows' milk was inoculated with ca 10³and 10⁷cfu/ml Listeria monocytogenes. After fermentation at 42°C for 0–5 h, the yogurt was stored at 4°C. Low and high inocula survived for 48 h and 7 d, respectively; L. monocytogenes cells were not detectable by direct plating or cold-enrichment after 5 and 15 d, respectively. In low inoculum samples, initial pH at the time of refrigeration was 4·9; the final pH at the time of last sampling was 4·2. In the samples with high inoculum the pH decreased from 5·0 to 4·2.     

Thermal inactivation of Listeria monocytogenes during a process simulating temperatures achieved during microwave heating

Conventional heating was used to expose cells of Listeria monocytogenes , either in broth or in situ on chicken skin, to the mean times and temperatures that are achieved during a 28 min period of microwave cooking of a whole chicken. Heating L. monocytogenes by this method in culture broth resulted in a reduction in viable cell numbers by a factor of greater than 10⁶ upon reaching 70°C. Simulated microwave cooking of L. monocytogenes in situ , on chicken skin, resulted in more variability in the numbers of survivors. Heating for the full cook time of 28 min, however, resulted in a mean measured temperature of 85°C and no surviving listerias were detected. This indicated a reduction in viable numbers of greater than 10⁶. To reduce temperature variation, cells were heated on skin in a submerged system in which exposure to 70°C for 2 min resulted in a reduction in viable cell numbers of all strains of listerias tested of between 10⁶ and 10⁸. These results show that when a temperature of 70°C is reached and maintained for at least 2 min throughout a food there is a substantial reduction in the numbers of L. monocytogenes . The survival of this organism during microwave heating when temperatures of over 70°C are reported is probably due to uneven heating by microwave ovens resulting in the presence of cold spots in the product. The heat resistance of L. monocytogenes is comparable with that of many other non-sporing mesophilic bacteria.     

Isolation and characterization of nisin-producing Lactococcus lactis subsp. lactis from bean-sprouts

Bacterial isolates from bean-sprouts were screened for anti- Listeria monocytogenes bacteriocins using a well diffusion method. Thirty-four of 72 isolates inhibited the growth of L.monocytogenes Scott A. One, HPB 1688, which had the biggest inhibition zone against L.monocytogenes Scott A, was selected for subsequent analysis. Both ribotyping and DNAsequencing of 16S ribosomal RNA gene demonstrated that the isolate was Lactococcus lactis subsp. lactis . Polymerase chain reaction and nucleotide sequencing revealed that thegenomic DNA of the bean-sprout isolates contained a nisin Z structural gene. In MRS broth,bean-sprout isolate HPB 1688 survived at 3–4·5°C for at least 20 d, grew at 4°Cand produced anti-listerial compoundsat 5°C. When co-cultured with L. monocytogenes in MRS broth, the isolate inhibited thegrowth of L. monocytogenes at 4°C after 14d and at 10°C after 2 d. When co-inoculatedwith 10²cells g⁻¹ of L.monocytogenes on fresh-cut ready-to-eat Caesar salad, L. lactis subsp. lactis (10⁸cells g⁻¹) was able to reduce the number of L. monocytogenes by 1–1·4 logs after storage for 10 d at 7° and 10°C. A bacteriocin-producing Enterococcusfaecium was also able to reduce the numbers of L. monocytogenes onCaesar salad, butdid not act synergistically when co-inoculated with L. lactis subsp. lactis .     

The planktonic and benthic bacterial populations of Lough Neagh

The planktonic and benthic bacterial populations of Lough Neagh, Northern Ireland, were studied over a one-year period. Direct counts of bacteria in the water column averaged 6 times 10⁷/ml with limited spatial or temporal variation; viable counts, however, showed a pronounced late spring maximum of 1.7 times 10⁶/ml and were consistently higher at a littoral sampling station. Direct counts of bacteria in the profundal sediments averaged 8 times 10⁹/ml whilst viable benthic counts rose steeply during spring to reach a June maximum of 1 times 10⁸/ml. Direct: viable count ratios were much greater in the more sandy littoral zone. The predominant benthic isolate was an Aeromonas sp. which was also common in samples from the water column. These results confirm the eutrophic status of Lough Neagh indicated by other biological and chemical surveys.     

Effect of growth temperature on virulence of strains of Listeria monocytogenes in the mouse: evidence for a dose dependence

Growth of Listeria monocytogenes at 4°C significantly increased its virulence for mice by the intravenous route and the effect was dose-dependent. Virulence was apparent only at a dose of about or above 10⁴ viable listerias. At slightly lower doses of about 10³, no such effect was observed. Growth at 4°C did not increase the virulence of the strains for mice by oral-gastric challenge when given at doses of approximately 10¹⁰.     

The use of direct epifluorescent microscopy (DEM) and the direct epifluorescent filter technique (DEFT) to assess microbial populations on food contact surfaces

Two rapid methods, direct epifluorescent microscopy (DEM) and the direct epifluorescent filter technique (DEFT) on swab resuspension fluids, were compared with the traditional total viable count (TVC) on swab resuspension fluids for their ability to enumerate surface populations of attached bacteria. The degree of error in estimating surface populations was shown to be significantly less with DEM than DEFT followed by TVC. DEM estimated populations in the range 3 times 10³ to 5 times 10⁷ colonies/cm² whilst DEFT enumerated populations above 3 times 10⁴ colonies/cm² and TVC above 3 times 10⁵ colonies/cm² (as measured by DEM). Swabbing was shown to remove a constant proportion of organisms from the surface populations tested, although below 3 times 10⁵ colonies/cm² most of the organisms remained in the cotton matrix and were difficult to resuspend. DEFT was more able to enumerate swab resuspension fluids obtained from surface populations below 3 times 10⁵ colonies/cm² than was TVC.     

A 20–24 H MICROCOLONY-IMMUNOBLOT TECHNIQUE to DIRECTLY DETECT and ENUMERATE LISTERIA MONOCYTOGENES INOCULATED INTO FOODS

A microcolony-immunoblot technique (MCIBI) was developed to directly enumerate, in less than 24 h, very low numbers of Listeria monocytogenes (8–12 colony forming units: CFU/g or mL) inoculated into foods. Four meat and poultry and two dairy products were artificially inoculated with L. monocytogenes V7 diluted and plated on Oxford agar medium. Each plate was overlaid with an Immobilon-P membrane and incubated for 18–20 h at 37C. Blot-transferred colonies on these membranes were probed with C11E9 monoclonal antibody (MAb) and developed using peroxidase conjugated goat antimo use Ig G and a water insoluble substrate (3,3-diaminobenzidin tetrahydmchloride; (DAB-HCI), Nickel chloride and H₂O₂). the MCIBT gave L. monocytogenes counts that were not significantly lower than direct colony counts on selective agars. This technique allowed the recovery of 94–100% of L. monocytogenes cells inoculated into foods containing natural background flora counts of 3 × 10⁴ to 8 × 10⁶ CFU/g or mL. Using a 2 h resuscitation period on nonselective agar before overlay with Oxford media, the MCIBT allowed detection of sublethally heat injured cells of strain V7.     

Behaviour of Staphylococcus aureus strains, producers of enterotoxins C1 or C2, during the manufacture and storage of Burgos cheese

Burgos cheese was manufactured from pasteurized ewes milk inoculated with Staphylococcus aureus strains FRI 137 and FRI 361, at levels of ca 10³ and 10⁵ cfu/ml and stored at 4°, 10° and 15°C and at room temperature (10°-15°C). Populations of Staph. aureus and mesophilic aerobes, pH, and production of thermonuclease and enterotoxins C₁ and C₂ were investigated. Aerobic counts increased during cheese-making and storage. With both test strains, important growth was observed only during the storage period, the larger levels corresponding to the higher temperatures. Although Staph. aureus strains attained populations of over 10⁸ cfu/g, no enterotoxin was detected. Strain FRI 361 reached 10⁷ cfu/g without production of a detectable amount of thermonuclease. With strain FRI 137, the minimal population associated with enzyme activity was influenced by the inoculum size. Staphylococcus aureus counts are better indicators of staphylococcal growth in Burgos cheese than the thermonuclease test.     

COMPARISON OF THREE POLYMERASE CHAIN REACTION-BASED METHODS FOR THE DETECTION OF LISTERIA MONOCYTOGENES IN FOOD

Three PCR-based methods for the detection of Listeria monocytogenes in food (BAX for Screening, Probelia and a method according to Kaclíková et al. (2003) were compared on the basis of the determination of detection limits for 15 artificially contaminated food products. Detection limits of all methods for all samples were 10⁰ cfu per 10 g, with the exception of three cheese samples which did not produce valid results because of the inhibition of Probelia PCR. Detection limits for nonviable L. monocytogenes cells were sufficiently high ( 10⁹ cfu per 10 g) for BAX and the method according to Kaclíková et al. (2003), but considerably low ( 10⁶ cfu per 10 g) for Probelia. The results demonstrate that BAX for Screening as well as the Kaclíková et al. (2001) method fulfill the sensitivity requirements for a rapid alternative method for the detection of L. monocytogenes in food, which would be equivalent to the standard method EN ISO 11290–1.