Biodegradation of methyl <Emphasis Type="Italic">tert</Emphasis>-butyl ether by cold-adapted mixed and pure bacterial cultures

An aerobic mixed bacterial culture (CL-EMC-1) capable of utilizing methyl tert-butyl ether (MTBE) as the sole source of carbon and energy with a growth temperature range of 3 to 30°C and optimum of 18 to 22°C was enriched from activated sludge. Transient accumulation of tert-butanol (TBA) occurred during utilization of MTBE at temperatures from 3°C to 14°C, but TBA did not accumulate above 18°C. The culture utilized MTBE at a concentration of up to 1.5 g l⁻¹ and TBA of up to 7 g l⁻¹. The culture grew on MTBE at a pH range of 5 to 9, with an optimum pH of 6.5 to 7.1. The specific growth rate of the CL-EMC-1 culture on 0.1 g l⁻¹ of MTBE at 22°C and pH 7.1 was 0.012 h⁻¹, and the growth yield was 0.64 g (dry weight) g⁻¹. A new MTBE-utilizing bacterium, Variovorax paradoxus strain CL-8, isolated from the mixed culture utilized MTBE, TBA, 2-hydroxy isobutyrate, lactate, methacrylate, and acetate as sole sources of carbon and energy but not 2-propanol, acetone, methanol, formaldehyde, or formate. Two other isolates, Hyphomicrobium facilis strain CL-2 and Methylobacterium extorquens strain CL-4, isolated from the mixed culture were able to grow on C₁ compounds. The combined consortium could thus utilize all of the carbon of MTBE.     

Optimum growth conditions and light utilization efficiency of Spirulina platensis (= Arthrospira fusiformis) (Cyanophyta) from Lake Chitu, Ethiopia

Spirulina platensis (= Arthrospira fusiformis) was isolated from Lake Chitu, a saline, alkaline lake in Ethiopia, where it forms an almost unialgal population. Optimum growth conditions were studied in a turbidostat. Cultures grown in modified Zarrouk's medium and exposed to a range of light intensities (20–500 µmol photons m^–2s^–1) showed a maximum specific growth rate (µ_max) of 1.78 d^–1. Quantum yield for growth (µ) was 3.8% at the optimum light for growth of 330 µmol photons m^–2s^–1, and ranged from 2.8 to 9.4%. With increase in irradiance, the chlorophyll a concentration decreased, and the carotenoids/chlorophyll a ratio increased by a factor of 2.4. The phosphorus to carbon ratio (P/C) showed some variation, while the nitrogen to carbon ratio (N/C) remained relatively constant, thus causing fluctuations in the N:P ratio (7–11) of cells. An optimum N:P ratio of about 7 was attained in cells growing at the optimum light for growth. Results from the continuous culture experiments agreed well with maximum values of photosynthetic efficiency given in the literature for natural populations of S. platensis in the soda lakes of East Africa, Lake Arenguade (Ethiopia), and Lake Simbi (Kenya).     

Effect of culture conditions on astaxanthin production by a mutant of Phaffia rhodozyma in batch and chemostat culture

Temperature and pH had only a slight effect on the astaxanthin content of a Phaffia rhodozyma mutant, but influenced the maximum specific growth rate and cell yield profoundly. The optimum conditions for astaxanthin production were 22°C at pH 5.0 with a low concentration of carbon source. Astaxanthin production was growth-associated, and the volumetric astaxanthin concentration gradually decreased after depletion of the carbon source. The biomass concentration decreased rapidly during the stationary growth phase with a concomitant increase in the cellular content of astaxanthin. Sucrose hydrolysis exceeded the assimilation rates of D-glucose and D-fructose and these sugars accumulated during batch cultivation. D-Glucose initially delayed D-fructose uptake, but D-fructose utilization commenced before glucose depletion. In continuous culture, the highest astaxanthin content was obtained at the lowest dilution rate of 0.043 h^–1. The cell yield reached a maximum of 0.48 g cells·g^–1 glucose utilized between dilution rates of 0.05 h^–1 and 0.07 h^–1 and decreased markedly at higher dilution rates. Correspondence to: J. C. Du Preez     

The effect of mixtures of glucose and formate on the yield and respiration of a chemostat culture of Beneckea natriegens

Beneckea natriegens oxidizes sodium formate constitutively when grown on glucose or glycerol in chemostat culture, but cannot utilize formate as the sole source of carbon and energy for growth. However, when grown on a mixture of glucose and formate (D=0.37 h^-1, pH 7.6) the yield is higher than on glucose alone.The yield, expressed in terms of g bacterial dry weight g^-1 glucose plus formate carbon utilized, gave a linear relationship when plotted against the total heat of combustion of glucose plus formate utilized. Extrapolation of the plot cut the abscissa at a value equivalent to the heat of combustion of formate, which suggests that formate is not utilised as a source of carbon but only energy.In cultures with nitrate as the sole source of nitrogen the yield from glucose was lower than that observed with ammonia but the addition of formate to the culture utilizing nitrate resulted in an increase in the yield from glucose to a value similar to that observed with ammonia.At a culture pH value of 7.65 unused formate (<0.15–227 mM) in the culture supernatant had no effect on respiration spiration or yield, but at a culture pH of 6.7 excess formate caused a marked increase in respiration rate and a large decrease in the yield from glucose; further decrease in the pH value caused washout of the culture. This may be explained by undissociated formic acid causing uncoupling of oxidative phosphorylation.     

Effects of organic carbon sources on cell growth and eicosapentaenoic acid content of <Emphasis Type="BoldItalic">Nannochloropsis</Emphasis> sp.

A strain of Nannochloropsis isolated originally from the East China Sea and obtained from Institute of Hydrobiology, Chinese Academy of Sciences was shown to utilize glucose or ethanol for mixotrophic and heterotrophic growth. The highest cell density, 550 mg L^{− 1} dry weight after culture for 8 days, was obtained during mixotrophic culture with 30 mM glucose. The organic carbon sources had no effect on the net photosynthetic rate, but enhanced the respiratory rate. The addition of an organic carbon source led to an increase in the cell lipid content and a decrease in their eicosapentaenoic acid (EPA) content. The EPA yield was 21.9 mg L^{− 1} using photoautotrophic culture, and 23.4 mg L^{− 1} and 23.0 mg L^{− 1}, respectively, in mixotrophic cultivation with glucose or ethanol as the carbon source.     

The isolation and characterisation of a salicylate-hydroxylase-producing strain of Pseudomonas putida

Summary A salicylate-hydroxylase-producing strain of Pseudomonas putida with an unusual capability to grow at toxic levels of salicylate up to 10 g l^–1 has been isolated. It grew well under continuous culture conditions, with optimum growth at pH 6.5 and a temperature of 25° C. The use of an ammonium salt as a nitrogen source, instead of nitrate, resulted in a 30–40% increase in its biomass yield coefficient. Optimum growth under continuous culture conditions was achieved using 4 g l^–1 salicylate at 25° C, pH 6.5 and 0.2 h^–1 dilution rate. High salicylate hydroxylase enzyme activity [236 units (U) l^–1] and productivity (424.8 U h^–1) were obtained at a dilution rate of 0.45 h^–1 using a mineral medium containing 4 g l^–1 of salicylate. Operating under continuous culture conditions with oxygen limitation and a slight accumulation of residual salicylate (0.2 g l^–1) resulted in a decrease in culture performance and enzyme productivity. Correspondence to: R. Marchant     

Effect of furfural on the growth of lactose-utilizing Candida Blankii 35

The effects of furfural on the growth of the lactose-utilizing yeast Candida blankii 35 were investigated using the method of continuous cultivation under conditions of carbon limitation and at dilution rates of 0.1 and 0.25 h⁻¹. The data obtained at dilution rate 0.1 h⁻¹ and 0.04% furfural showed a decrease in the yield of biomass by 6% and in the RNA content, but the synthesis of cell protein increased with 11.6% compared to the control. Treatment with 0.08% furfural induced significant changes in growth and biosynthesizing ability. A strong inhibitory effect of furfural was observed: the biomass yield decreased by half at 48 h and the culture the reached the control level of protein content. The effect of 0.02% furfural at 0.25 h⁻¹ dilution rate caused a significant reduction of biomass yield (34.4%) and the substrate utilization rate reached values higher by 52.4% at 48 h, but the protein-synthesizing ability of the cells slightly increased. The results showed that a treatment with 0.04 or 0.08% furfural caused significant disturbances of cell functions, the yields of biomass and protein drastically decreased and the culture was washed out. Data showed that the inhibitory effect of furfural on the growth and protein-synthesizing ability of Candida blankii 35 depends on the inhibitor concentration as well as the dilution rate. This revised version was published online in August 2006 with corrections to the Cover Date.     

Influence of acetate on the growth of Candida utilis in continuous culture

Candida utilis was grown on acetate in chemostat cultures that were, successively, carbon and ammonia-limited (30° C; pH 5.5). With carbon(acetate)-limited cultures, the specific rate of oxygen consumption (q _{O 2}) was not a linear function of the growth rate but was markedly stimulated at the higher dilution rates, thus effecting a marked decrease in the Y _O value. This increased respiration rate, and decreased yield value, correlated closely with a marked increase in the extracellular acetate concentration. Under ammonia-limiting conditions, very low Y _O values were found, generally comparable with those found with carbon-limited cultures growing at the higher dilution rates, but these varied markedly with the extracellular acetate concentration. Thus, when the unused acetate concentration was raised progressively from about 5 g/l to about 21 g/l, the Y _O value decreased non-linearly from 11.4 to 5.8. When the extracellular acetate concentration was further increased to 25 g/l, growth was inhibited and the culture washed out. This relationship between respiration rate and the extracellular concentration of unused acetate was also markedly influenced by the culture pH value. Thus, with a fixed extracellular acetate concentration (16±2g/l) and dilution rate (0.14 h^–1), lowering the culture pH value progressively from 6.9 to 5.1 effected a marked and progressive increase in the respiration rate. Further lowering of the culture pH to 4.8, however, caused a complete collapse of respiration. In contrast to this situation, progressively lowering the pH value of an acetatelimited culture from 6.9 to 4.5 affected only slightly the culture respiration rate, and growth was possible even at a pH value of 2.5. These results are discussed in the context of the possible mechanisms whereby acetate exerts its toxic effect on the growth of C. utilis.     

Physiological aspects of l-lysine production: effect of nutritional limitations on a producing strain of Corynebacterium glutamicum

The effect of nutritional limitations, such as phosphorus and carbon, on the production of l-lysine by Corynebacterium glutamicum was studied in continuous culture. We observed that phosphate-limited cultures at low growth rates were favourable to l-lysine production. l-Lysine was produced when a culture at low dilution rate (0.03 h^–1) was established. A dilution rate of about 0.04 h^–1 should be maintained in order to assure good productivity and an l-lysine yield of 0.53 g/g. Under carbon-limiting conditions the maintenance energy and growth yield of 0.03 g/g·g^–1·h^–1 and 0.41 g/g, respectively, have been obtained. Under these limiting conditions the l-lysine production was not favoured even at lower dilution rates.Correspondence to: N. Coello     

Phenol inhibition kinetics for growth of Acetobacter aceti on ethanol

Acetobacter aceti have been grown on ethanol under inhibitory conditions created by high concentrations of phenol. A defined medium with no vitamin or amino acid supplements has been used such that ethanol was the sole carbon substrate. The culture temperature was maintained at 30 °C while the pH was manually controlled to fall within the range 4.5–6.0 during ethanol consumption. Growth on ethanol at a few thousand milligrams per litre (below the known inhibitory level) resulted in a maximum specific growth rate of 0.16 h⁻¹ with a 95% yield of acetic acid, followed immediately by acetic acid consumption at a growth rate of 0.037 h⁻¹. Phenol was found to inhibit growth by decreasing both the specific growth rate and the biomass yield during ethanol consumption. On the other hand, the yield of acetic acid during ethanol consumption and the yield of biomass during acetic acid consumption remained constant, independent of phenol inhibition. A model is presented and is shown to represent the phenol-inhibited growth behaviour of A. aceti during both ethanol and acetic acid consumption. Received: 6 November 1998 / Received revision: 8 February 1999 / Accepted: 12 February 1999     

Growth parameters of Acinetobacter calcoaceticus on acetate and ethanol

Summary The growth parameters of Acinetobacter calcoaceticus, relevant to its mass cultivation on acetate and ethanol, were determined in batch and continuous culture experiments. Acetic acid exhibited a more powerful inhibitory effect on the growth rate than ethanol. In batch culture, the acetate component of an acetate-ethanol substrate pair was preferentially utilized, but diauxic growth as such was not evident. The temperature optimum for growth was in the region of 29°–36°C, and the cell yield did not change appreciably over this temperature range. In carbon-limited chemostat cultures, the maximum specific growth rates on acetate and ethanol were 1.22 h⁻¹ and 0.96 h⁻¹ respectively, and the respective yield coefficients were 0.4 and 0.75. A high maintenance energy requirement was exhibited, especially during acetate-limited growth. The respiratory quotient was dependent on the growth rate, the significance of which is discussed. Part of the material included in this paper was presented at the VIth International Fermentation Symposium, London, Ontario, July 1980     

Kinetic studies of acetate fermentation by Methanosarcina sp. MSTA-1

Summary The effect of three parameters (initial acetate concentration, temperature and pH) on the acetoclastic reaction was studied with the thermophilic methanogenic bacterium Methanosarcina sp. MSTA-1. The optimum temperature for growth ranged around 55° C, and optimum pH was 6.5–7.5, giving a minimum generation time of 12.6–13.9 h (µ_max = 0.050–0.055 h^–1) and a maximum value of the specific acetate consumption rate (q _infs ^supps ) of 14–20 mmol/g cells per hour. Contrary to the methane yield, the growth yield was found to be dependent on culture conditions, especially on incubation temperature. Methanosarcina sp. MSTA-1 showed a low affinity for acetate substrate. Growth at 55° C and at constant pH 7 resulted in a K _m value and a threshold acetate concentration of 10.7 mM and 0.7 mM, respectively. Offprint requests to: R. Moletta     

Conversion of fat into yeast biomass in protein-containing waste-water

Summary Candida tropicalis S001 was grown on the lipid fraction of a protein-containing waste-water in order to (i) remove fat from the water, and (ii) produre yeast biomass for feed. The yeast cells were separated from the waste-water by sedimentation. Defatted waste-water was used for methane production and gave a yield of a 0.3 m³ methane/kg reduced chemical oxygen demand. The maximum specific growth rate (µ_max) of C. tropicalis growing on waste-water fat at pH 4.0 was 0.35 h^–1; the fat content was decreased from 8 g/l to about 0.1 g/l within 24 h. In continous culture a corresponding reduction was maintained at dilution rates up to 0.36 h^–1. The effect on growth of pH, temperature and CO₂ concentration was studied with triolein as the major carbon source. The µ_max was nearly constant (0.16 h^–1) in the pH and temperature range of 3.2–4.0 and 30°–38° C, respectively; 10% CO₂ was optimal for growth. Growth on triolein resulted in a biomass yield of 0.70 g dry weight/g fat. Offprint requests to: S. Rydin     

Growth-associated biosynthesis of astaxanthin in heterotrophic Chlorella zofingiensis (Chlorophyta)

The green microalga Chlorella zofingiensis can produce the ketocarotenoid astaxanthin under heterotrophic culture conditions. Here we report the growth-associated biosynthesis of astaxanthin in this biotechnologically important alga. With glucose as sole carbon and energy source, C. zofinginesis grew fast in the dark with rapid exhaustion of nitrogen and carbon sources from media, leading to a high specific growth rate (0.034 h⁻¹). Cultures started at a cell concentration of about 3.4 × 10⁹ cells l⁻¹ reached, after 6 days, standing biomass values of 1.6 × 10¹¹ cells or 8.5 g dry weight l⁻¹. Surprisingly, the biosynthesis of astaxanthin was found to start at early exponential phase, independent of cessation of cell division. A general trend was observed that the culture conditions benefiting cell growth also benefited astaxanthin accumulation, indicating that astaxanthin was a growth-associated product in this alga. The maximum cell dry biomass and astaxanthin yield were 11.75 g l⁻¹ and 11.14 mg l⁻¹ (about 1 mg g⁻¹), simultaneously obtained in the fed-batch culture with a combined glucose–nitrate mixture addition, which were the highest ever reported in dark-heterotrophic algal cultures. The possible reasons why dark-heterotrophic C. zofingiensis could produce astaxanthin during the course of cell growth were discussed.     

Characterization of a pyridine-degrading branched Gram-positive bacterium isolated from the anoxic zone of an oil shale column

Summary From the anoxic zone of an oil shale leachate column three pyridine-degrading bacterial strains were isolated. Two strains were Gram-negative facultative anaerobic rods and one strain was a branched Gram-positive bacterium. The branched Gram-positive strain had the best pyridine-degrading ability. This organism was aerobic, non-motile, catalase positive, oxidase negative, and had no flagellum. The G+C content of the DNA was 66.5 mol%. The major menaquinone was MK-8(H₂). The main cellular fatty acids were saturated and monounsaturated straight chains. This organism contained mycolic acid, meso-diaminopimelic acid, arabinogalactan and glycolyl residues in the cell wall. Due to morphological, physiological and chemotaxonomic characteristics this strain was placed in the genus Rhodococcus. The optimum culture conditions were as follows: temperature 32° C, pH 8.0 and 0.1% v/v of pyridine as sole carbon, energy and nitrogen source. Utilization of pyridine by a batch fermentor culture of Rhodococcus sp. was characterized by a specific growth rate of 0.13 h^–1, growth yield of 0.61 mg cell·mg pyridine^–1 and a doubling time of 5.3 h^–1. Offprint requests to: S.-T. Lee     

Analysis of a continuous culture of Fibrobacter succinogenes S85 on a standardized glucose medium

Continuous cultures of Fibrobacter succinogenes S85 were performed on a standardized fully synthetic culture medium with glucose as carbon source at a dilution rate (D = 0.02 h⁻¹) in a 5-L bioreactor. The culture was stabilized during 20 days and demonstrated the ability of Fibrobacter succinogenes to grow in this synthetic medium. CO₂ partial pressure and redox potential probes were used to check the anaerobic state of the culture. The biomass yield was calculated 0.206 g (g glucose)⁻¹ and the production yield of succinate, the major end-product, was 0.63 mol (mol glucose)⁻¹. The consistency of the experimental data was checked by proton and mass (C, N) balances. The results were satisfactory (90–110% recovery) leading to derive a stoichiometric equation representative of the growth on glucose. The stoichiometric coefficients were calculated using data reconciliation and linear algebra methods enabling to obtain a complete modeling of all conversion yields possible.     

Metabolic and energetic aspects of the growth of Bacillus stearothermophilus in glucose-limited and glucose-sufficient chemostat culture

With a glucose-limited chemostat culture of Bacillus stearothermophilus, increasing the incubation temperature progressively from 45°C to 63°C led to a progressive marked increase in the maintenance rates of glucose and oxygen consumption. Hence, at a fixed low dilution rate the yield values with respect to glucose and oxygen decreased substantially with increased temperature. However, the apparent Y _glucose ^max and values did not decrease but actually increased with temperature, being highest at 63°C (i.e., close to the maximum growth temperature). With glucose-sufficient cultures growing at a fixed low dilution rate (0.2 h^–1) and at their optimum temperature (55°C), glucose and oxygen consumption rates invariably were higher than that of a corresponding glucose-limited culture. Cation (K⁺ or Mg²⁺)-limited cultures expressed the highest metabolic rates and with the K⁺ limited culture this rate was found to be very markedly temperature dependent. As the temperature was increased from 45°C to 63°C the rate of glucose consumption increased 1.8-fold, and that of oxygen consumption by 3.7-fold. The culture pH value also exerted a noticeable effect on the metabolic rate of a glucose-limited culture, particularly at the extremes of pH tolerance (5.5 and 8.5, respectively). A K⁺-limited culture was less affected with respect to metabolic rate by the culture pH value though the steady state bacterial concentration, and thus the cellular K⁺ content, changed substantially. These results are discussed in relation to previous findings of the behaviour of this organism in batch culture, and to the behaviour of other thermophilic Bacillus species in chemostat culture.     

Environmental control of metabolic fluxes in thermotolerant methylotrophic Bacillus strains

Recently we have isolated a number of thermotolerant, spore-forming methylotrophic bacilli in pure culture. With a methanol-limited chemostat culture of strain Ts1, incremental increases in the incubation temperature from 45°C to 62.5°C revealed an optimum with respect to growth yield of 52.5°C, and a maximum of 62.5°C. Similar investigations revealed a pH optimum of 7.5 and a broad growth rate optimum with respect to growth yield. The organism displayed a low maintenance energy requirement and high growth yield (attained simultaneosly with high growth rates) during growth on methanol. Under all conditions of methanol limitation, substrate was oxidized solely to biomass and CO₂ and carbon recoveries greater than 90% were manifest. Our data suggested that this resulted from an ability of the organism to precisely adjust its catabolic and anabolic pathways to suit prevailing growth conditions. These results are discussed in relation to previously reported data on thermophiles in both batch and chemostat culture.     

Photosynthetic acclimation to photon irradiance and its relation to chlorophyll fluorescence and carbon assimilation in the halotolerant green alga Dunaliella viridis

This work describes the long-term acclimation of the halotolerant microalga Dunaliella viridis to different photon irradiance, ranging from darkness to 1500 μmol m⁻² s⁻¹. In order to assess the effects of long-term photoinhibition, changes in oxygen production rate, pigment composition, xanthophyll cycle and in vivo chlorophyll fluorescence using the saturating pulse method were measured. Growth rate was maximal at intermediate irradiance (250 and 700 μmol m⁻² s⁻¹). The increase in growth irradiance from 700 to 1500 μmol m⁻² s⁻¹ did not lead to further significant changes in pigment composition or EPS, indicating saturation in the pigment response to high light. Changes in Photosystem II optimum quantum yield (F_v/F_m) evidenced photoinhibition at 700 and especially at 1500 μmol m⁻² s⁻¹. The relation between photosynthetic electron flow rate and photosyntetic O₂ evolution was linear for cultures in darkness shifting to curvilinear as growth irradiance increased, suggesting the interference of the energy dissipation processes in oxygen evolution. Carbon assimilation efficiencies were studied in relation to changes in growth rate, internal carbon and nitrogen composition, and organic carbon released to the external medium. All illuminated cultures showed a high capability to maintain a C:N ratio between 6 and 7. The percentage of organic carbon released to the external medium increased to its maximum under high irradiance (1500 μmol m⁻² s⁻¹). These results suggest that the release of organic carbon could act as a secondary dissipation process when the xanthophyll cycle is saturated. This revised version was published online in June 2006 with corrections to the Cover Date.     

Decolourization of anaerobically digested and polyaluminium chloride treated distillery spentwash in a fungal stirred tank aerobic reactor

Decolourization of anaerobically digested and polyaluminium chloride treated distillery spentwash was studied in a fungal stirred tank aerobic reactor without dilution of wastewater. Aspergillus niger isolate IITB-V8 was used as the fungal inoculum. The main objectives of the study were to optimize the stirrer speed for achieving maximum decolourization and to determine the kinetic parameters. A mathematical model was developed to describe the batch culture kinetics. Volumetric oxygen transfer coefficient (k _L a) was obtained using dynamic method. The maximum specific growth rate and growth yield of fungus were determined using Logistic equation and using Luedeking–Piret equation. 150 rpm was found to be optimum stirrer speed for overall decolourization of 87%. At the optimum stirrer speed, volumetric oxygen transfer coefficient (k _L a) was 0.4957 min⁻¹ and the maximum specific growth rate of fungus was 0.224 h⁻¹. The values of yield coefficient (Y _x/s) and maintenance coefficient (m _s) were found to be 0.48 g cells (g substrate)⁻¹ and 0.015 g substrate (g cells)⁻¹ h⁻¹.