Antimutagenicity of some citrus fruits in Salmonella typhimurium

The antimutagenic effect of 10 citrus fruit juices was observed against the mutagenicity of N-nitro-o-phenylenediamine (NPD) in TA97a and sodium azide in TA100 tester strains of Salmonella typhimurium using the Ames test. It was noticed that the juices of all these fruits reduced significantly the NPD and sodium azide induced revertant colonies. The inhibitory activity was enhanced if the mutagen and juice were co-incubated for about 30 min at 37 degrees C prior to performing the mutagenicity assay. Dilution with distilled water led to the reduction in the inhibitory activity. The antimutagenic activity of synthetic ascorbic acid or citric acid or combined ascorbic acid and citric acid was also seen. But the results with fruit juices tempted us to believe that in addition to ascorbic acid and citric acid, the presence of other factor(s) possessing antimutagenic properties cannot be ruled out.     

Noncatalytic hydrolysis of guar gum under hydrothermal conditions

Guar gum, a naturally occurring heteropolysaccharide made of mannose and galactose, was hydrolytically degraded without a catalyst in a batch reactor to produce water-soluble (WS) saccharides including mono- and oligosaccharides. The degradation was carried out under hydrothermal conditions over ranges of temperature from 180 to 240 degrees C and of reaction time from 3 to 60min. Guar gum was readily dissolved and hydrolyzed, and the major products identified in the WS components were oligosaccharides with degrees of polymerization up to about 20, monosaccharides containing mannose and galactose, and 5-hydroxymethyl-2-furaldehyde (5-HMF). At 200 degrees C, the oligosaccharide yield, obtained from the difference between the yields of the total WS saccharides and monosaccharides, showed the highest value of 94.4% at 7min among all conditions studied, on the basis of the saccharide content in the initial sample. The oligosaccharide yield decreased with reaction time, and the yield of monosaccharides correspondingly increased, and reached the highest value of 34.5% (mannose 22.8%, galactose 11.7%) at 60min. The monosaccharides produced were further decomposed to secondary products such as 5-HMF. The maximum yield of 5-HMF obtained was 26.3% at 220 degrees C and 30min. The production and the decomposition of galactose somewhat preceded those of mannose.     

固定化果胶酶澄清果汁的条件及效果

利用固定化果胶酶对四种不同果汁澄清条件及效果进行研究,结果表明,固定化果胶酶澄清四种不同果汁的效果明显,其中澄清桔汁的果胶酶重复使用20次以上,酶活力及透光率仍可维持在80%以上,其最适反应条件是:果汁浓度50%;pH 3.0~3.5;温度45~50℃;反应时间2小时;酶量每毫升果汁0.05 g固定化果胶酶;澄清时间20小时。     

Inactivation of Escherichia coli and Shigella in acidic fruit and vegetable juices by peroxidase systems

AIMS: To study the bactericidal properties of the lactoperoxidase (LPER)-thiocyanate and soybean peroxidase (SBP)-thiocyanate systems at low pH, their efficiency for inactivation of Escherichia coli and Shigella in acidic fruit and vegetable juices, their effect on colour stability of the juices and interaction with ascorbic acid. METHODS AND RESULTS: Three-strain cocktails of E. coli and Shigella spp. in selected juices were supplemented with the LPER or SBP system. Within 24 h at 20 degrees C, the LPER system inactivated both cocktails by > or = 5 log10 units in apple, 2-5 log10 units in orange and < or = 1 log10 unit in tomato juices. In the presence of SBP, browning was significant in apple juice and white grape juice, slight in pink grape juice and absent in orange or tomato juice. Ascorbic acid protected E. coli and Shigella against inactivation by the LPER system, and peroxidase systems significantly reduced the ascorbic acid content of juices. CONCLUSIONS: Our results suggest a different specificity of LPER and SBP for SCN-, phenolic substrates of browning and ascorbic acid in acidic juices. The LPER system appeared a more appropriate candidate than the SBP system for biopreservation of juices. SIGNIFICANCE AND IMPACT OF THE STUDY: This work may open perspectives towards the development of LPER or other peroxidases as biopreservatives in acidic foods.     

Biochemical characterization of blood orange,sweet orange,lemon, bergamot and bitter orange

This paper reports on the composition of aroma compounds and fatty acids and some physico-chemical parameters (juice percentage, acidity and total sugars) in five varieties of citrus: blood orange, sweet orange, lemon, bergamot and bitter orange. Volatile compounds and methyl esters have been analyzed by gas chromatography. Limonene is the most abundant compound of monoterpene hydrocarbons for all of the examined juices. Eighteen fatty acids have been identified in the studied citrus juices, their quantification points out that unsaturated acids predominate over the saturated ones. Mean concentration of fatty acids varies from 311.8 mg/l in blood orange juice to 678 mg/l in bitter orange juice.     

Effect of inhibitors released during steam-explosion treatment of poplar wood on subsequent enzymatic hydrolysis and SSF

Steam-exploded (SE) poplar wood biomass was hydrolyzed by means of a blend of Celluclast and Novozym cellulase complexes in the presence of the inhibiting compounds produced during the preceding steam-explosion pretreatment process. The SE temperature and time conditions were 214 degrees C and 6 min, resulting in a log R(0) of 4.13. In enzymatic hydrolysis tests at 45 degrees C, the biomass loading in the bioreactor was 100 g(DW)/L (dry weight) and the enzyme-to-biomass ratio 0.06 g/g(DW). The enzyme activities for endo-glucanase, exo-glucanase, and beta-glucosidase were 5.76, 0.55, and 5.98 U/mg, respectively. The inhibiting effects of components released during SE (formic, acetic, and levulinic acids, furfural, 5-hydroxymethyl furfural (5-HMF), syringaldehyde, 4-hydroxy benzaldehyde, and vanillin) were studied at different concentrations in hydrolysis runs performed with rinsed SE biomass as model substrate. Acetic acid (2 g/L), furfural, 5-HMF, syringaldehyde, 4-hydroxybenzaldehyde, and vanillin (0.5 g/L) did not significantly effect the enzyme activity, whereas formic acid (11.5 g/L) inactivated the enzymes and levulinic acid (29.0 g/L) partially affected the cellulase. Synergism and cumulative concentration effects of these compounds were not detected. SSF experiments show that untreated SE biomass during the enzymatic attack gives rise to a nonfermentable hydrolysate, which becomes fermentable when rinsed SE biomass is used. The presence of acetic acid, vanillin, and 5-HMF (0.5 g/L) in SSF of 100 g(DW) /L biomass gave rise to ethanol yields of 84.0%, 73.5%, and 91.0% respectively, with respective lag phases of 42, 39, and 58 h.     

Role of Alicyclobacillus acidoterrestris in the development of a disinfectant taint in shelf-stable fruit juice

AIMS: This study was undertaken to identify the bacterium and metabolic products contributing to a disinfectant taint in shelf-stable fruit juice and to determine some of the growth conditions for the organism. METHODS AND RESULTS: Microbiological examination of tainted and untainted fruit juice drinks detected low numbers of acid-dependent, thermotolerant, spore-forming bacteria in the tainted juices only. The presence of omega-cyclohexyl fatty acids was confirmed in two of the isolates by cell membrane fatty acid analysis. The isolates were subsequently identified as Alicyclobacillus acidoterrestris by partial 16S rDNA sequencing. Studies on the isolates showed growth at pH 2.5-6.0 and 19.5-58 degrees C. Gas chromatography/mass spectrometry (GC/MS) was used to identify and quantify 2,6-dibromophenol (2,6-DBP) and 2,6-dichlorophenol (2,6-DCP) in the tainted juice. Challenge studies in a mixed fruit drink inoculated with the two isolates and the type strain of A. acidoterrestris, incubated at 44-46 degrees C for 4 d, showed the production of both metabolites, which were confirmed and quantified by GC/MS. CONCLUSIONS: The results show that A. acidoterrestris can produce 2,6-DBP and 2,6-DCP in shelf-stable juices. SIGNIFICANCE AND IMPACT OF THE STUDY: This is the first report detailing experimental methodology showing that A. acidoterrestris can produce 2,6-DCP in foods. Control of storage temperatures (to < 20 degrees C) immediately after processing may provide an effective control measure for the fruit juice industry to prevent spoilage by A. acidoterrestris.     

L-ascorbic acid microencapsulated with polyacylglycerol monostearate for milk fortification

Efficiency was examined of microencapsulating L-ascorbic acid by polyglycerol monostearate (PGMS), and changes in the chemical and sensorial aspects of L-ascorbic acid and/or iron-fortified milk during storage were evaluated. The selected core materials were ferric ammonium sulfate and L-ascorbic acid. The highest efficiency (94.2%) of microencapsulation was found with the ratio of 5:1 as the coating to core material. The release of ascorbic acid from the microcapsules increased sharply from 1.6 to 6.7% up to 5 d of storage. The TBA value was the lowest in the milk sample with added encapsulated iron and unencapsulated L-ascorbic acid up to 5 d of storage in comparison with the other treated samples. A sensory analysis showed that most aspects were not significantly different between the control and fortified samples encapsulated with ascorbic acid after 5 d of storage. The results indicate that L-ascorbic acid microencapsulated with PGMS can be applied to fortify milk and acceptable milk products can be prepared with microencapsulated L-ascorbic acid and iron.     

Growth from spores of nonproteolytic Clostridium botulinum in heat-treated vegetable juice

Unheated spores of nonproteolytic Clostridium botulinum were able to lead to growth in sterile deoxygenated turnip, spring green, helda bean, broccoli, or potato juice, although the probability of growth was low and the time to growth was longer than the time to growth in culture media. With all five vegetable juices tested, the probability of growth increased when spores were inoculated into the juice and then heated for 2 min in a water bath at 80 degrees C. The probability of growth was greater in bean or broccoli juice than in culture media following 10 min of heat treatment in these media. Growth was prevented by heat treatment of spores in vegetable juices or culture media at 80 degrees C for 100 min. We show for the first time that adding heat-treated vegetable juice to culture media can increase the number of heat-damaged spores of C. botulinum that can lead to colony formation.     

Evaluation of different growth media for the recovery of the species of Alicyclobacillus

AIMS: Five different isolation media, namely potato dextrose agar (PDA), orange serum agar (OSA), K agar, yeast-starch-glucose agar and Bacillus acidocaldarius medium were evaluated for the recovery of Alicyclobacillus spp. from inoculated diluted and undiluted fruit-juice concentrates. METHODS AND RESULTS: Plates of PDA (pH 3.7), spread with vegetative cells (3.9 x 10(6) CFU ml(-1)) of Alicyclobacillus acidoterrestris from single-strength pear juice, recovered 2.9 x 10(6 )CFU ml(-1) after 5 days at 50 degrees C (74% recovery). The recovery of endospores from single-strength pear juice, after a heat treatment at 80 degrees C for 10 min, was higher on spread plates of OSA (pH 5.5) at 50 degrees C for 5 days (97% recovery). CONCLUSIONS: PDA (pH 3.7) and OSA (pH 5.5) at 50 degrees C for 3-5 days recovered the highest numbers of vegative cells and endospores of Alicyclobacillus spp. from sterilized fruit juices and concentrates. SIGNIFICANCE AND IMPACT OF THE STUDY: The most appropriate synthetic media for the recovery of Alicyclobacillus species from inoculated fruit juices and concentrates are shown.     

Patulin production by Byssochlamys spp. in fruit juices.

Ten strains of Byssochlamys fulva and three strains of B. nivea were cultured in a laboratory medium and tested for their ability to produce patulin. Two strains of B. fulva and all three strains of B. nivea produced the mycotoxin. One strain of B. fulva produced patulin in 11 of 13 processed fruit juices, with greatest amounts being produced in blueberry, red raspberry, and boysenberry juices, whereas no patulin was detected in prune or tomato juices. Grown in Concord grape juice at 18, 25, 30, and 38 degrees C, this strain produced the highest patulin concentration at 18 degrees C after 25 days, whereas biomass production was greatest at 25 and 30 degrees C after 20 and 25 days.     

Patulin production by Byssochlamys spp. in fruit juices

Ten strains of Byssochlamys fulva and three strains of B. nivea were cultured in a laboratory medium and tested for their ability to produce patulin. Two strains of B. fulva and all three strains of B. nivea produced the mycotoxin. One strain of B. fulva produced patulin in 11 of 13 processed fruit juices, with greatest amounts being produced in blueberry, red raspberry, and boysenberry juices, whereas no patulin was detected in prune or tomato juices. Grown in Concord grape juice at 18, 25, 30, and 38 degrees C, this strain produced the highest patulin concentration at 18 degrees C after 25 days, whereas biomass production was greatest at 25 and 30 degrees C after 20 and 25 days.     

The interaction of L-ascorbic acid with the active center of myrosinase.

Only L-ascorbic acid activated plant myrosinase (thioglucoside glucohydrolase, EC 3.2.3.1), whereas ascorbic acid analogs did not. The enzyme protein was conformationally changed by the addition of L-ascorbic acid to the spectrophotometric analysis, approx. 1.5 amino residues appeared on the surface of the enzyme and about 2.3 tryptophan residues were buried in the molecule when 1 mM L-ascorbic acid was added. Optimum temperature for the myrosinase activity was approx. 55 degrees C without L-ascorbic acid, but with L-ascorbic acid it was about 35 degrees C; that for beta-glucosidase activity was the same (55 degrees C) with or without L-ascorbic acid. The effect of chemical modification of the functional groups of myrosinase on the interaction of L-ascorbic acid was investigated and the interaction of L-ascorbic acid with the active center of the enzyme is proposed.     

5-hydroxymethylfurfural-forming proteins in the renal glomeruli of control and streptozotocin-diabetic rats

Nonenzymatic glycosylatin of renal and erythrocyte proteins was measured by the formation of 5-hydroxymethylfurfural (5-HMF) after mild acid and heat treatments. Two weeks after the injection of streptozotocin (SZO), diabetic rats showed significantly higher levels of 5-HMF formation in hemolysates, but not in renal glomerular extracts, than the control rats. However, both the hemolysates and the renal glomerular extracts showed higher levels of nonenzymatic glycosylation in diabetic rats than in control rats 8 weeks after SZO-injection. 5-HMF-forming protiens were found in all subcellular fractions although the microsomal proteins showed the highest specific activity of 5-HMF-formation per mg.     

Isomerization of feruloylputrescine in orange juice by light exposure

Exposure to light may adversely affect the quality of foods. This investigation of how light exposure affects citrus (orange and mandarin blend) juice in polyethylene terephthalate (PET) bottles demonstrated that the isomeric form of a compound in the juice changed during storage. This compound was identified as feruloylputrescine (FP; CAS: 501-13-3; C₁₄H₂₀N₂O₃) using LC/MS (Q-TOF). LC/MS and NMR measurements showed that the content of the original form, trans-FP, decreased as it isomerized to cis-FP during storage. This phenomenon could be observed in citrus fruit juices containing FP, such orange and grapefruit juices. Therefore, determining the content of these two isomers of FP could be used to indicate the level of light exposure experienced by citrus fruit products.     

Acid tolerance of Shigella sonnei and Shigella flexneri

AIMS: Determination of the behaviour of Shigella sonnei and Sh. flexneri under acid conditions. METHODS AND RESULTS: The growth and survival of Shigella spp. (9 isolates) in acidified Brain Heart Infusion (BHI) (pH 5.0-3.25 with pH intervals of 0.25) was determined after 6, 24 and 30 h incubation at 37 degrees C. Subsequently, survival of shigellae was studied in apple juice and tomato juice stored at 7 degrees C and 22 degrees C for up to 14 days and in strawberries and a fresh fruit salad, kept at 4 degrees C for 4 and 48 h. CONCLUSIONS: The minimum pH for growth in acidified BHI for Sh. flexneri and Sh. sonnei was, respectively, pH 4.75 and pH 4.50. Survival in fruit juices and fresh fruits depended upon their pH, the type of strain and the incubation temperature. Shigella spp. Survived for up to 14 days in tomato juice and apple juice stored at 7 degrees C. The shortest survival time (2-8 d) was observed in apple juice at 22 degrees C. Sh. sonnei but not Sh. flexneri was recovered after 48 h from strawberries and fruit salad kept at 4 degrees C. SIGNIFICANCE AND IMPACT OF THE STUDY: Acid foods, especially if kept at refrigeration temperatures, support survival of Shigella spp. and may cause Shigella food poisoning.     

Production, characterization and application of a thermostable polygalacturonase of a thermophilic mould Sporotrichum thermophile Apinis

The production of polygalacturonase (PGase) by Sporotrichum thermophile Apinis in stirred submerged fermentation (SmF) was high in comparison with that in static conditions. Yeast extract (0.25%) and citrus pectin (2%) at pH 7.0 and 45 degrees C supported a high enzyme production in flasks agitated at 200 rpm. An overall 1.75-fold enhancement in PGase production was achieved as a result of optimization. The enzyme was optimally active at pH 7.0 and 55 degrees C, and exhibited t(1/2) of 4 h at 65 degrees C. The Km and Vmax values of the enzyme (for pectin) were 0.416 mg ml(-1) and 0.52 micromol mg(-1)min(-1), respectively. The PGase activity was stimulated by Mn(2+) and Fe(2+), but inhibited strongly by Mg(2+), and slightly by Tween 80 and Triton X-100. Among the additives tested, beta-mercaptoethanol exerted a strong inhibitory effect, suggesting a critical role of disulphide linkages in maintaining a suitable conformation of the enzyme. An increase in the yield of banana, grape and apple juices was recorded due to the treatment of fruit pulps with the mixture of enzymes (pectinase, xylanases and cellulase) of S. thermophile as compared to that with only pectinase. The yield of fruit juices did not increase with enhanced titre of cellulase in the enzyme mixture.     

Pectin Methylesterase of Datura species,purification, and characterization from Datura stramoniumand its application

Pectin methylesterases (PME; EC 3.1.1.11) involved in de-esterification of pectin and have applicability in food, textiles, wines, pulp, and paper industries. In the present study, we compared PME activity of different parts of 3 Datura species and found that fruit coat showed maximum PME activity followed by leaf and seed. PME from leaves of D. stramonium (DsPME) was purified and characterized. DsPME showed optimum activity at 60 °C and pH 9 in the presence of 0.3 M NaCl. DsPME was stable at 70 °C and retained more than 40% activity after 60 min of incubation. However, enzyme activity completely abolished at 80 after 5 min of incubation. It follows Michaelis-Menten enzyme kinetics. Km and Vmax with citrus pectin were 0.008 mg/ml and 16.96 µmol/min, respectively. DsPME in combination with polygalactourenase (PGA) increased the clarity of orange, apple, pomegranate and pineapple juices by 2.9, 2.6, 2.3, and 3.6 fold, respectively in comparison to PGA alone. Due to very high de-esterification activity, easy denaturation and significant efficacy in incrementing clarification of fruit juice makes DsPME useful for industrial application.     

Effects of thermal treatments on pectinesterase activity determined in blood oranges juices

The citrus processing industry aims to maintain turbidity and attractive colour of the juice obtained from Sicilian blood oranges. Nevertheless, the presence of pectinesterase (PE, E.C. 3.1.1.11) causes the loss of these peculiar characteristics, due to precipitation of colloids and very fine pieces of pulp in suspension, with negative effects on colour and clarification of the juices. This study compares total PE activity of Sicilian blood oranges (Sanguinello, Moro, Tarocco) with the blonde cultivar Navel, checking enzyme stability with various pasteurisation times and temperatures conditions. Decimal reduction time and temperature (D and z) as well as the kinetic constant (k) were established to optimise and increase the shelf-life of the pasteurised juice. Finally, a heat treatment (85 °C × 3 min) of both microbiological and enzymatic efficacy has been developed that does not compromise anthocyanin stability; this treatment could be used by the citrus fruit processing industry as a valid alternative in the production of blood orange juices.     

SEC-MALS characterization of microbial polyhydroxyalkanoates

Characterization of poly-3-hydroxybutyric acid (PHB) and poly-3-hydroxybutyric-co-valeric acid (PHBV, 13% valerate) in chloroform was performed using size exclusion chromatography coupled to a multi-angle light scattering detector (SEC-MALS). Absolute molar mass averages, molar mass distribution, and the radius of gyration were determined. Three sample preparation methods were examined: dissolution in chloroform (1) at room temperature, (2) at 60 degrees C, and (3) after thermal pretreatment of samples (annealing at 180 degrees C with subsequent quenching in liquid nitrogen). Dissolution at 60 degrees C and dissolution of thermally pretreated samples gave molecularly dissolved PHB and PHBV. At 60 degrees C using acid free chloroform, there was no indication of degradation for up to 120 min dissolution time, whereas thermal degradation of polymers did take place during annealing at 180 degrees C. The degradation rate constants for number and weight average degree of polymerization at 180 degrees C were slightly higher for PHB (5.19 x 10(-5) min(-1), 4.95 x 10(-5) min(-1)) than for PHBV (4.99 x 10(-5) min(-1), 4.54 x 10(-5) min(-1)). The dependence of the radii of gyration on molar mass showed that both polymers form random coils in chloroform. The relationship between the absolute molar masses and relative SEC results was determined. DSC and NMR characterization also gave evidence of the progress of degradation.