The reductive reactions of Thiobacillus ferrooxidans on sulphur and selenium

Abstract An investigation into the sulphur oxidation of iron grown Thiobacillus ferrooxidans is reported. A new mechanism for sulphur catabolism in this obligate acidophile, involving the initial reduction of the substrate, is proposed. Evidence to support substrate reduction comes from the evolution of H₂S in both aerobic and anaerobic conditions (O₂ and Fe³⁺ acting as terminal electron acceptors, respectively) and a accurate trapping method of detection is described. Levels of sulphur reduction are such that a role in the full catabolism of sulphur can be envisaged. In addition, red selenium reduction was investigated and the bioenergetic implications for both substrates are discussed.     

Dissolution of sulphur particles by Thiobacillus ferrooxidans: substrate for unattached cells

The growth of Thiobacillus ferrooxidans on sulphur is known to proceed through the attachment of cells to the sulphur particles. Experiments, However, show that the cells in the liquid phase, which are not attached to the sulphur particles, also grow. It has been shown through the use of a two-compartment membrane reactor that this increase is partially due to the release of ions, corresponding to partially oxidized of sulphur, into the solution by the attached cells. The main soluble ion has been found to the thiosulphate, but traces of sulphite have also been detected. (c) 1993 John Wiley & Sons, Inc.     

Morphology of bacterial leaching patterns by Thiobacillus ferrooxidans on synthetic pyrite

Thiobacillus ferrooxidans has been cultivated on synthetic pyrite (FeS₂) single crystals as the only energy source and the pyrite interface investigated with respect to characteristic morphological changes using scanning electron microscopy. Corrosion patterns of bacterial size were identified in different stages of development and correlated with bacterial activity. It appears that bacterial attack of the sulfide interface starts by secretion of organic substances around the contact area between the bacterial cell and the sulfide energy source. They might either be part of a pseudo capsule which shields the contact area or may form a sulfur absorbing and transporting organic film. Degradation of the sulfide occurs in the contact area below the bacterial cell leading to a corrosion pit which the bacterium may abandon after it has reached a depth of bacterial dimension. Electron spectroscopic (XPS) and X-ray fluorescence studies indicate a layer of organic substances covering the sulfide surface under bacterial leaching conditions, which is sufficiently thick for consideration in interfacial chemical mechanisms.     

Identification of two outer membrane proteins involved in the oxidation of sulphur compounds in Thiobacillus ferrooxidans

Abstract: Shift of three Thiobacillus ferrooxidans strains from Fe(II) to S⁰ or thiosulphate liquid medium caused distinctive changes in the outer membrane protein profile. In addition to a new 55-kDa protein which was synthesized only in the presence of sulphur compounds, a higher expression of a 47-kDa protein was observed. This latter protein appeared to be constitutively synthesized, since it was detectable in small amounts even in tile presence of ferrous iron as sole energy source, but its expression was greatly enhanced when elemental sulphur or thiosulphate were present in the growth medium.     

Mechanism of microbial flotation using Thiobacillus ferrooxidans for pyrite suppression

Microbial desulfurization might be developed as a new process for the removal of pyrite sulfur from coal sluries such as coal-water mixture (CWM). An application of iron-oxidizing bacterium Thiobacillus ferrooxidans to flotation would shorten the periods of the microbial removal of pyrite from some weeks by leaching methods to a few minutes. The floatability of pyrite in flotation was mainly reduced by T. ferrooxidans itself rather than by other microbial substances in bacterial culture as additive of flotation liquor. Floatability was suppressed within a few seconds by bacterial contact. The suppression was proportional to increasing the number of cells observed between bacterial adhesion and the suppression of floatability. If 25% of the total pyrite surface area covered with the bacteria, pyrite floatability would be completely depressed. Bacteria that lost their iron-oxidizing activities by sodium cyanide treatment were also able to adhere to pyrite and reduced pyrite floatability as much as normal bacteria did. Thiobacillus ferrooxidans ATCC 23270, T-1, 9, and 11, which had different iron-oxidizing abilities, suppressed floatability to similar-levels. The oxidizing ability of bacteria did not influence the suppressing effect. These results showed the mechanism of the suppression of pyrite floatability by bacteria. Quick bacterial adhesion to pyrite induced floatability suppression by changing the surface property from hydrophobic. The quick adhesion of the bacterium was the novel function which worked to change the surface property of pyrite to remove it from coal. (c) 1993 John Wiley & Sons, Inc.     

Bio-oxidation of iron using Thiobacillus ferrooxidans

The effects of pH, ferrous and ferric ion concentrations on iron oxidation by Thiobacillus ferrooxidans were examined. The initial temperature and bacterial concentration were maintained at 37°C and 2±1×104cells/ml, respectively. The iron oxidation rate increased with increased initial ferrous iron concentration to 4g/l and thereafter decreased. The presence of iron(III) showed a negative effect on the bacterial iron oxidation rate. The increase of pH also showed an increase in the oxidation rate up to pH 1.75. The oxidation rate followed first order kinetics for the parameters studied. A rate equation has been developed.     

Surface chemical studies of Thiobacillus ferrooxidans with reference to copper tolerance

A strain of Thiobacillus ferrooxidans was adapted to grow at higher concentrations of copper by single step culturing in the presence of 20 g/L (0.314 mol/L) cupric ions added to 9K medium. Exposure to copper results in change in the surface chemistry of the microorganism. The isoelectric point of the adapted strain (pI=4.7) was observed to be at a higher pH than that of the wild unadapted strain(pI=2.0). Compared to the wild strain, the copper adapted strain was found to be more hydrophobic and showed enhanced attachment efficiency to the pyrite mineral. The copper adsorption ability of the adapted strain was also found to be higher than that of the wild strain. Fourier transform infrared spectroscopy of adapted cells suggested that a proteinaceous new cell surface component is synthesized by the adapted strain. Treatment of adapted cells with proteinase-K, resulted in complete loss of tolerance to copper, reduction in copper adsorption and hydrophobicity of the adapted cells. These observations strongly suggest a role played by cell surface modifications of Thiobacillus ferrooxidans in imparting the copper tolerance to the cells and bioleaching of sulphide minerals.     

Chemotaxis of chemolithotrophic Thiobacillus ferrooxidans toward thiosulfate

Abstract The chemotactic response of Thiobacillus ferrooxidans toward thiosulfate was observed. The traditional assay technique was modified by direct microscopic enumeration of cells which moved into the attractant solution. The optimum concentration shown by thiosulfate-grown cells, tetrathionate-grown cells as well as iron-grown cells was 10³ times the optimum concentration shown by cells grown on elemental sulfur. Iron-grown cells which lack thiosulfate-oxidizing activity showed increased accumulation at optimum concentration as compared to cells grown on elemental sulfur and other reduced sulfur compounds. This indicated the constitutive nature of chemotaxis by T. ferrooxidans toward thiosulfate.     

氧化亚铁硫杆菌氧化亚硫酸盐的动力学研究

实验用Ms培养基,利用去除铁离子的氧化亚铁硫杆菌(Thiobacillus ferrooxidans)进行了细菌亚硫酸盐的生长代谢研究。实验结果表明氧化亚铁硫杆菌对亚硫酸根具有一定的氧化能力。用Origin 7.0对实验数据进行拟合处理,表明了氧化亚铁硫杆菌催化氧化亚硫酸盐的动力学方程符合Hill方程。氧化亚铁硫杆菌催化氧化亚硫酸盐是一个底物抑制的细胞反应,其KS值随pH值和底物浓度的改变而变化。pH值对反应有很大的影响,pH值越接近中性KS就越小,反应速率就越大。     

氧化亚铁硫杆菌固定化技术研究

在生物脱硫过程中 ,以H - 2软性填料作为氧化亚铁硫杆菌 (Thiobacillusferrooxidans)的固定化载体 ,构建了固定床生化反应器。考察了不同稀释率固定下床生化反应器氧化Fe2 + 的情况 ,在通气量为 330L/h ,稀释率为 0 6h-1条件下 ,Fe2 + 最大氧化速率达 7 6 7g[Fe2 + ]/L·h。该反应器连续运行 10 0d,固定化细胞稳定性良好     

Thermal characterization of different isolates of Thiobacillus ferrooxidans

Abstract Ten different isolates of Thiobacillus ferrooxidans were characterized with respect to temperature in the range 2–35°C. Four of the ten strains oxidized ferrous iron exponentially over the entire range of incubation temperatures, including the lowest temperature tested (2°C), and were therefore characterized as psychrotrophic. Jarosite production was substantially reduced at temperatures less than 10°C and was not observed at 2°C. Energy of activation values were in the range 75.2–96.6 kJ/mol°C and indicated that iron oxidation at low temperatures was governed by both a chemical and a physical control.     

Bioleaching of zinc sulfide concentrate by Thiobacillus ferrooxidans

The kinetics of the bioleaching of ZnS concentrate by Thiobacillus ferrooxidans was studied in a well-mixed batch reactor. Experimental studies were made at 30 degrees C and pH 2.2 on adsorption of the bacteria to the mineral, ferric iron leaching, and bacterial leaching. The adsorption rate of the bacteria was fairly rapid in comparison with the bioleaching rate, indicating that the bacterial adsorption is at equilibrium during the leaching process. The adsorption equilibrium data were correlated by the Langmuir isotherm, which is a useful means for predicting the number of bacteria adsorbed on the mineral surface. The rate of chemical leaching varied with the concentration of ferric iron, and the first-order reaction rate constant was determined. Bioleaching in an iron-containing medium was found to take place by both direct bacterial attack on the sulfide mineral and indirect attack via ferric iron. In this case, the ferric iron was formed from the reaction product (ferrous iron) through the biological oxidation reaction. To develop rate expressions for the kinetics of bacterial growth and zinc leaching, the two bacterial actions were considered. The key parameters appearing in the rate equations, the growth yield and specific growth rate of adsorbed bacteria, were evaluated by curve fitting using the experimental data. This kinetic model allowed us to predict the liquid-phase concentrations of the leached zinc and free cells during the batch bioleaching process.     

Influence of lipopolysaccharides on the attachment of Thiobacillus ferrooxidans to minerals

The loss of part of the lipopolysaccharides (LPS) of the outer membrane of T. ferrooxidans negatively influenced the attachment of the bacteria to minerals and the bioleaching process. LPS previously extracted from T. ferrooxidans and which had come into contact with pyrite inhibited the attachment of cells to minerals and also negatively affected the bioleaching. These results suggest that LPS play an important role in the attachment of the microorganisms and therefore, its presence or absence could affect the bioleaching process.     

Anaerobic growth on elemental sulfur using dissimilar iron reduction by autotrophic Thiobacillus ferrooxidans

Abstract Anaerobic growth on elemental sulfur using dissimilar iron reduction by Thiobacillus ferrooxidans has been demonstrated. The ferric ion reducing activity (FIR) of the anaerobic cells was double that of the aerobic cells. Significant differences in inhibition of FIR by respiratory inhibitors were observed between aerobic and anaerobic cells. A higher amount of cytochrome was detected in anaerobic cells compared to aerobic cells. Absorption minima developed with the addition of ferric sulfate in the dithionite reduced cell suspension demonstrated that the ferric ion could accept electrons from the cytochrome system of this bacterium. The possibility of two different electron transport chains in ferric ion reduction is discussed.     

Resistance to heavy metals in different strains of Thiobacillus ferrooxidans

Ten different isolates of Thiobacillus ferrooxidans were studied with regard to their degree of resistance to the metals copper, nickel, uranium, and thorium. Inhibitory concentrations for a particular metal were those which showed a statistically-significant decrease in the amount of ferrous iron oxidized by the bacterium compared to an untreated control. The different isolates had different susceptibilities to the metals tested, and none of the metals had a stimulatory effect. Uranium and thorium were 20 to 40 times more toxic to ferrous iron oxidation than either copper or nickel.     

Use of Thiobacillus ferrooxidans for iron oxidation and precipitation

Fe(II) oxidation reaction was carried out using an acidophilic microorganism, Thiobacillus ferrooxidans. Four different parameters such as pH, Fe(II), Fe(III) and biomass concentration were studied. The oxida-tion reaction follows a pseudo first order rate equation. Apparent reaction rate constants were calculated. Unified rate equation was developed using the four parameters. Along with oxidation, a part of the iron also was precipitated. The extent of Fe(III) precipitation in each case was calculated. © Rapid Science 1998     

氧化亚铁硫杆菌及其硫氧化机理

烟气SO2引起的酸雨污染是当代世界面临的重大环境问题之一。对烟道气脱硫用微生物—氧化亚铁硫杆菌(Thiobacillus ferrooxidans,T.f)进行了介绍,并在文献分析的基础上,对T.f催化氧化S(IV)机理进行了讨论。     

氧化亚铁硫杆菌的形态及对Fe2+的氧化研究

在纯培养的条件下,对江西德兴铜矿酸性矿坑水中分离出的一株氧化亚铁硫杆菌(Thiobacillus ferrooxidans)的细胞形态、生长条件以及对Fe2 的氧化进行了初步研究。透射电子显微镜检查的结果表明,其成熟菌体大小均一,有较好的运动性;采用光学显微镜对微生物进行菌群观测和利用血小板计数器法对细菌计数的结果表明,在摇床转速为160r/min的条件下,T.f.菌在9K液体培养基中最适生长条件为温度30℃左右,最佳初始pH 2.0;用重铬酸钾滴定法测定铁的结果表明,在摇床转速为160r/min的条件下,pH值1.7,温度30℃时T.f.菌对Fe2 的氧化速率最大,约为0.58g/L·h。     

氧化亚铁硫杆菌培养过程中沉淀的研究

为了减少氧化亚铁硫杆菌培养过程中产生的沉淀,对氧化亚铁硫杆菌培养过程中产生的沉淀物进行了研究,确定了在pH为1．5,K2HPO4用量为0．25g/l,KH2PO4为0．195g/l时菌体可以保持其最高氧化活性,同时产生最少量沉淀物的培养条件,并发现沉淀物对菌体的生长和氧化Fe^2 没有影响。利用饥饿状态的氧化亚铁硫杆菌证明了菌体在一定条件下可以利用黄铁钒沉淀中的部分离子进行生长繁殖。     

Sulfur colloids as temporary energy reservoirs for Thiobacillus ferrooxidans during pyrite oxidation

Thiobacillus ferrooxidans was cultivated on 100-nm-thick synthetic pyrite (FeS₂) films. The steps of biooxidation were studied with high-resolution transmission electron microscopy. The crystallized sulfide was transformed into colloidal sulfur (4–70 nm, depending on the age of the cell and the degree of substrate oxidation; 70nm initially and 4nm after oxidation of the pyrite substrate), which was taken up and distributed over an organic capsule around the bacteria. This colloidal sulfur acted as intermediate energy storage and was transferred by contact to daughter cells not directly attached to the sulfide substrate.