Optimisation of initial cell concentration enhances freeze-drying tolerance of Pseudomonas chlororaphis

The freeze-drying tolerance of Pseudomonas chlororaphis, an antifungal bacterium used as biocontrol agent was investigated. P. chlororaphis is freeze-drying sensitive and the viability drops more than 3 log units in the absence of protective freeze-drying medium. Of the freeze-drying media tested, lactose, sucrose, trehalose, glutamate, sucrose with glutamate, skimmed milk, and skimmed milk with trehalose, skimmed milk gave the lowest survival (0.6+/-0.2%) and sucrose the highest (6.4+/-1.2%). Cellular accumulation of sucrose from the freeze-drying medium and the protective effect of sucrose were dependent on sucrose concentration. The effect of initial cell concentration, from 1 x 10(7) to 5 x 10(10) CFU/ml, on survival after freeze-drying was studied for carbon starved cells with sucrose as freeze-drying medium. The highest freeze-drying survival values, 15-25%, were obtained for initial cell concentrations between 1 x 10(9) and 1 x 10(10) CFU/ml. For cell concentrations outside this window more than 10 times lower survival values were observed. P. chlororaphis was cultivated to induce stress response that could confer protection against freeze-drying inactivation. Carbon starvation and, to a lesser extent, heat treatment enhanced freeze-drying tolerance. By combining optimal cell concentration, optimal sucrose concentration and carbon starvation the survival after freeze-drying was 26+/-6%.     

Engineering trehalose synthesis in Lactococcus lactis for improved stress tolerance

Trehalose accumulation is a common cell defense strategy against a variety of stressful conditions. In particular, our team detected high levels of trehalose in Propionibacterium freudenreichii in response to acid stress, a result that led to the idea that endowing Lactococcus lactis with the capacity to synthesize trehalose could improve the acid tolerance of this organism. To this end, we took advantage of the endogenous genes involved in the trehalose catabolic pathway of L. lactis, i.e., trePP and pgmB, encoding trehalose 6-phosphate phosphorylase and β-phosphoglucomutase, respectively, which enabled the synthesis of trehalose 6-phosphate. Given that L. lactis lacks trehalose 6-phosphate phosphatase, the respective gene, otsB, from the food-grade organism P. freudenreichii was used to provide the required activity. The trehalose yield was approximately 15% in resting cells and in mid-exponential-phase cells grown without pH control. The intracellular concentration of trehalose reached maximal values of approximately 170 mM, but at least 67% of the trehalose produced was found in the growth medium. The viability of mutant and control strains was examined after exposure to heat, cold or acid shock, and freeze-drying. The trehalose-producing strains showed improved tolerance (5- to 10-fold-higher survivability) to acid (pH 3) and cold shock (4°C); there was also a strong improvement in cell survival in response to heat shock (45°C), and no protection was rendered against dehydration. The insight provided by this work may help the design of food-grade strains optimized for the dairy industry as well as for oral drug delivery.     

Acclimation of entomopathogenic nematodes to novel temperatures: trehalose accumulation and the acquisition of thermotolerance

The effect of thermal acclimation on trehalose accumulation and the acquisition of thermotolerance was studied in three species of entomopathogenic nematodes adapted to either cold or warm temperatures. All three Steinernema species accumulated trehalose when acclimated at either 5 or 35 degrees C, but the amount of trehalose accumulation differed by species and temperature. The trehalose content of the cold adapted Steinernema feltiae increased by 350 and 182%, of intermediate Steinernema carpocapsae by 146 and 122% and of warm adapted Steinernema riobrave by 30 and 87% over the initial level (18.25, 27.24 and 23.97 microg trehalose/mg dry weight, respectively) during acclimation at 5 and 35 degrees C, respectively. Warm and cold acclimation enhanced heat (40 degrees C for 8h) and freezing (-20 degrees C for 4h) tolerance of S. carpocapsae and the enhanced tolerance was positively correlated with the increased trehalose levels. Warm and cold acclimation also enhanced heat but not freezing tolerance of S. feltiae and the enhanced heat tolerance was positively correlated with the increased trehalose levels. In contrast, warm and cold acclimation enhanced the freezing but not heat tolerance of S. riobrave, and increased freezing tolerance of only warm acclimated S. riobrave was positively correlated with the increased trehalose levels. The effect of acclimation on maintenance of original virulence by either heat or freeze stressed nematodes against the wax moth Galleria mellonella larvae was temperature dependent and differed among species. During freezing stress, both cold and warm acclimated S. carpocapsae (84%) and during heat stress, only warm acclimated S. carpocapsae (95%) maintained significantly higher original virulence than the non-acclimated (36 and 47%, respectively) nematodes. Both cold and warm acclimated S. feltiae maintained significantly higher original virulence (69%) than the non-acclimated S. feltiae (0%) during heat but not freezing stress. In contrast, both warm and cold acclimated S. riobrave maintained significantly higher virulence (41%) than the non-acclimated (14%) nematodes during freezing, but not during heat stress. Our data indicate that trehalose accumulation is not only a cold associated phenomenon but is a general response of nematodes to thermal stress. However, the extent of enhanced thermal stress tolerance conferred by the accumulated trehalose differs with nematode species.     

Effects of ice-seeding temperature and intracellular trehalose contents on survival of frozen Saccharomyces cerevisiae cells

Freezing tolerance is an important characteristic for baker’s yeast, Saccharomyces cerevisiae, as it is used to make frozen dough. The ability of yeast cells to survive freezing is thought to depend on various factors. The purpose of this work was to study the viability of yeast cells during the freezing process. We examined factors potentially affecting their survival, including the growth phase, ice-seeding temperature, intracellular trehalose content, freezing period, and duration of supercooling. The results showed that the ice-seeding temperature significantly affected cell viability. In the stationary phase, trehalose accumulation did not affect the viability of yeast cells after brief freezing, although it did significantly affect the viability after prolonged freezing. In the log phase, the ice-seeding temperature was more important for cell survival than the presence of trehalose during prolonged freezing. The importance of increasing the extracellular ice-seeding temperature was verified by comparing frozen yeast survival rates in a freezing test with ice-seeding temperatures of −5 °C and −15 °C. We also found that the cell survival rates began to increase at 3 h of supercooling. The yeast cells may adapt to subzero temperatures and/or acquire tolerance to freezing stress during the supercooling.     

Freeze-drying of live attenuated Vibrio anguillarum mutant for vaccine preparation

Vibrio anguillarum MVAV6203 is a mutant strain as a candidate of live attenuated vaccine. In vaccine preparation, the freeze-drying conditions of the strain were investigated to improve the survival after freeze-drying, including the protectant, rehydration medium, freezing temperature, and initial cell concentration. Vibrio anguillarum MVAV6203 is sensitive to freeze-drying and the viability was only 0.03% in the absence of protectant. Of the tested protectants, 5% trehalose with 15% skimmed milk gave the highest viability of 34.2%. Higher cell survival was obtained by quick freezing at -80 degrees C than slow freezing at -20 degrees C. Initial cell concentration was another important factor, preferable for 1-3 x 10(10)CFU/ml. The supplementation of 10% skimmed milk in rehydration medium improved obviously freeze-drying viability. The combination of the optimal conditions achieved 51.4% cell viability after freeze-drying.     

Commercial baker's yeast stability as affected by intracellular content of trehalose, dehydration procedure and the physical properties of external matrices

The effects of vacuum-drying and freeze- drying on the cell viability of a commercial baker's yeast, Saccharomyces cerevisiae, strain with different endogenous contents of trehalose were analyzed. An osmotolerant Zygosaccharomyces rouxii strain was used for comparative purposes. Higher viability values were observed in cells after vacuum-drying than after freeze-drying. Internal concentrations of trehalose in the range 10–20% protected cells in both dehydration processes. Endogenous trehalose concentrations did not affect the water sorption isotherm nor the T _g values. The effect of external matrices of trehalose and maltodextrin was also studied. The addition of external trehalose improved the survival of S. cerevisiae cells containing 5% internal trehalose during dehydration. Maltodextrin (1.8 kDa) failed to protect vacuum-dried samples at 40 °C. The major reduction in the viability during the freeze-drying process of the sensitive yeast cells studied was attributed to the freezing step. The suggested protective mechanisms for each particular system are vitrification and the specific interactions of trehalose with membranes and/or proteins. The failure of maltodextrins to protect cells was attributed to the fact that none of the suggested mechanisms of protection could operate in these systems. Received: 6 December 1999 / Received revision: 8 May 2000 / Accepted: 19 May 2000     

Effect of temperature on freezing and heat stress tolerance of cultured plant cells

The relationship between freezing and heat tolerance was investigated with suspension-cultured pear (Pear cammunis cv. Bartlett) cells. This culture showed considerable capacity for both cold and heat acclimation. Growth at 2 °C (Cold acclimation) and at 30 °C (heat acclimation) both increased the freezing tolerance [measured via triphenyltetrazolium chloride (TTC) reduction]of pear cells. However, heat acclimation induced by heat shock treatment did not significantly effect freezing tolerance. Although growth at 30 °C increased freezing tolerance (relative to 22 °C-grown controls), growth at 2 °C (cold acclimation) decreased heat tolerance substantially. Thus, the only similarity detected between cold and heat acclimation was that both processes conferred freezing resistance to TTC-reducing system(s) in pear cells. The pear suspension culture will be a useful tool to further investigate cold acclimation via comparisons between heat and freezing acclimation and injury.     

Construction of Saccharomyces cerevisiae strains that accumulate relatively low concentrations of trehalose, and their application in testing the contribution of the disaccharide to stress tolerance

Genetically related diploid strains of Saccharomyces cerevisiae that accumulate varied amounts of trehalose during starvation for nitrogen have been constructed. Strains that produced greater than 5% trehalose (dry cell weight) were more tolerant of thermal, or freeze-thaw stresses than strains that produced less than 4% trehalose. Thus trehalose appears to play a role in stress tolerance of yeast. The significance of these results is that, for the first time, a series of related, unmutated strains have been used to test the effect of trehalose on thermotolerance. Previous studies employed either heat shock treatment, or mutated strains to provide trehalose variations, and as such the contribution of the disaccharide to stress tolerance could not necessarily be separated from other factors such as heat shock proteins.     

Accumulation of trehalose by overexpression of tps1, coding for trehalose-6-phosphate synthase, causes increased resistance to multiple stresses in the fission yeast schizosaccharomyces pombe

Recent studies have shown that heat shock proteins and trehalose synthesis are important factors in the thermotolerance of the fission yeast Schizosaccharomyces pombe. We examined the effects of trehalose-6-phosphate (trehalose-6P) synthase overexpression on resistance to several stresses in cells of S. pombe transformed with a plasmid bearing the tps1 gene, which codes for trehalose-6P synthase, under the control of the strong thiamine-repressible promoter. Upon induction of trehalose-6P synthase, the elevated levels of intracellular trehalose correlated not only with increased tolerance to heat shock but also with resistance to freezing and thawing, dehydration, osmostress, and toxic levels of ethanol, indicating that trehalose may be the stress metabolite underlying the overlap in induced tolerance to these stresses. Among the isogenic strains transformed with this construct, one in which the gene coding for the trehalose-hydrolyzing enzyme, neutral trehalase, was disrupted accumulated trehalose to a greater extent and was more resistant to the above stresses. Increased trehalose concentration is thus a major determinant of the general stress protection response in S. pombe.     

Combined effects of endo- and exogenous trehalose on stress tolerance and biocontrol efficacy of two antagonistic yeasts

Effects of endo- and exogenous trehalose on viability of two antagonistic yeasts, Cryptococcus laurentii (Kuffer.) Skinner and Rhodotorula glutinis (Fresen.) Harrison, were investigated after being treated with rapid-freezing, slow-freezing and freeze-drying, respectively. The accumulation of intracellular trehalose in the two yeasts was induced by culturing the yeast cells in trehalose-containing medium, which significantly enhanced viabilities of both yeasts in the slow-freezing test. Trehalose, as an exogenous protectant, at the concentration of 5% or 10% could markedly increase survivals of the two yeasts when subjected to freeze-drying. When combined with exogenous trehalose as a protective substance, the yeasts containing high intracellular trehalose level showed higher viabilities as compared to those containing low levels under both freezing and freeze-drying stresses. The highest survival of C. laurentii and R. glutinis were 90% and 97% after freeze-drying, respectively, compared to 63% and 28% for the yeasts with lower intracellular trehalose levels. These results may be due to the fact that a combined effect occurred between endo- and exogenous trehalose of yeast cells. The combined effect on C. laurentii and R. glutinis also resulted in the highest level of biocontrol efficacy against blue mold in apple fruit caused by Penicillium expansum Link, and reduced the disease indexes to 45 and 56, respectively, compared to 94 and 81 in the untreated control. Meanwhile, the combination of endo- and exogenous trehalose significantly increased population of both yeasts in apple wounds, especially at the first 48 h after inoculation, which might explain the reason of the improvement in biocontrol effects of the two yeasts.     

The freeze-thaw stress response of the yeast Saccharomyces cerevisiae is growth phase specific and is controlled by nutritional state via the RAS-cyclic AMP signal transduction pathway.

The ability of cells to survive freezing and thawing is expected to depend on the physiological conditions experienced prior to freezing. We examined factors affecting yeast cell survival during freeze-thaw stress, including those associated with growth phase, requirement for mitochondrial functions, and prior stress treatment(s), and the role played by relevant signal transduction pathways. The yeast Saccharomyces cerevisiae was frozen at -20 degrees C for 2 h (cooling rate, less than 4 degrees C min-1) and thawed on ice for 40 min. Supercooling occurred without reducing cell survival and was followed by freezing. Loss of viability was proportional to the freezing duration, indicating that freezing is the main determinant of freeze-thaw damage. Regardless of the carbon source used, the wild-type strain and an isogenic petite mutant ([rho 0]) showed the same pattern of freeze-thaw tolerance throughout growth, i.e., high resistance during lag phase and low resistance during log phase, indicating that the response to freeze-thaw stress is growth phase specific and not controlled by glucose repression. In addition, respiratory ability and functional mitochondria are necessary to confer full resistance to freeze-thaw stress. Both nitrogen and carbon source starvation led to freeze-thaw tolerance. The use of strains affected in the RAS-cyclic AMP (RAS-cAMP) pathway or supplementation of an rca1 mutant (defective in the cAMP phosphodiesterase gene) with cAMP showed that the freeze-thaw response of yeast is under the control of the RAS-cAMP pathway. Yeast did not adapt to freeze-thaw stress following repeated freeze-thaw treatment with or without a recovery period between freeze-thaw cycles, nor could it adapt following pretreatment by cold shock. However, freeze-thaw tolerance of yeast cells was induced during fermentative and respiratory growth by pretreatment with H2O2, cycloheximide, mild heat shock, or NaCl, indicating that cross protection between freeze-thaw stress and a limited number of other types of stress exists.     

Cold shock response of yeast cells: induction of a 33 kDa protein and protection against freezing injury.

Cold shock (10 degrees C) treatment to Saccharomyces cerevisiae cells normally grown at 30 degrees C resulted in splitting of vacuoles and retarded membrane fluidity as detected by phase contrast microscopy and in vivo nuclear magnetic resonance (NMR) studies, respectively. The treatment was found to impart protection against subsequent freezing as studied by cell viability and colony forming efficiency. We have earlier reported similar protection and retarded membrane fluidity as a result of heat shock treatment to these cells (Obuchi et al., 1990). This suggests that cold shock and heat shock treatments to yeast cells evoke some analogous responses. However, biochemically a new 33 kDa protein (CSP 33) was detected upon cold shock treatment which is distinct from heat shock induced family of proteins (Kaul et al., 1992). We present here the first report of this kind and its practical implications for protection against freezing.     

Accumulation of Trehalose by Overexpression of tps1, Coding for Trehalose-6-Phosphate Synthase, Causes Increased Resistance to Multiple Stresses in the Fission Yeast Schizosaccharomyces pombe

Recent studies have shown that heat shock proteins and trehalose synthesis are important factors in the thermotolerance of the fission yeast Schizosaccharomyces pombe. We examined the effects of trehalose-6-phosphate (trehalose-6P) synthase overexpression on resistance to several stresses in cells of S. pombe transformed with a plasmid bearing the tps1 gene, which codes for trehalose-6P synthase, under the control of the strong thiamine-repressible promoter. Upon induction of trehalose-6P synthase, the elevated levels of intracellular trehalose correlated not only with increased tolerance to heat shock but also with resistance to freezing and thawing, dehydration, osmostress, and toxic levels of ethanol, indicating that trehalose may be the stress metabolite underlying the overlap in induced tolerance to these stresses. Among the isogenic strains transformed with this construct, one in which the gene coding for the trehalose-hydrolyzing enzyme, neutral trehalase, was disrupted accumulated trehalose to a greater extent and was more resistant to the above stresses. Increased trehalose concentration is thus a major determinant of the general stress protection response in S. pombe.     

Genome-wide expression analysis of yeast response during exposure to 4°C

Adaptation to temperature fluctuation is essential for the survival of all living organisms. Although extensive research has been done on heat and cold shock responses, there have been no reports on global responses to cold shock below 10°C or near-freezing. We examined the genome-wide expression in Saccharomyces cerevisiae, following exposure to 4°C. Hierarchical cluster analysis showed that the gene expression profile following 4°C exposure from 6 to 48 h was different from that at continuous 4°C culture. Under 4°C exposure, the genes involved in trehalose and glycogen synthesis were induced, suggesting that biosynthesis and accumulation of those reserve carbohydrates might be necessary for cold tolerance and energy preservation. The observed increased expression of phospholipids, mannoproteins, and cold shock proteins (e.g., TIP1) is consistent with membrane maintenance and increased permeability of the cell wall at 4°C. The induction of heat shock proteins and glutathione at 4°C may be required for revitalization of enzyme activity, and for detoxification of active oxygen species, respectively. The genes with these functions may provide the ability of cold tolerance and adaptation to yeast cells.     

Stress tolerance in a yeast sterol auxotroph: role of ergosterol, heat shock proteins and trehalose

The role of ergosterol in yeast stress tolerance, together with heat shock proteins (hsps) and trehalose, was examined in a sterol auxotrophic mutant of Saccharomyces cerevisiae. Ergosterol levels paralleled viability data, with cells containing higher levels of the sterol exhibiting greater tolerances to heat and ethanol. Although the mutant synthesised hsps and accumulated trehalose upon heat shock to the same levels as the wild-type cells, these parameters did not relate to stress tolerance. These results indicate that the role of ergosterol in stress tolerance is independent of hsps or trehalose.     

Cold shock response in Lactococcus lactis ssp. diacetylactis: a comparison of the protection generated by brief pre-treatment at less severe temperatures

Acquired freeze–thaw tolerance was investigated for Lactococcus lactis ssp. diacetylactis. Pre-treatment of microorganisms at less severe temperatures to initiate cold tolerance gave L. lactis ssp. diacetylactis improved cell viability after successive freezings and thawings. The ability of cells to survive freezing–thawing was dependent on factors experienced prior to freezing. Factors affecting lactic acid bacteria survival during freezing–thawing cycles include different diluents, growth phase, and cold temperatures. Viability experiments showed that this strain displaying cold shock cryotolerance had an improved survival capacity in stationary phase. The plasmid contents of lactic acid bacteria isolated from different types, strains DRC-2 and DRC-2C, were examined and compared with the plasmid contents of culture collection strains both before and after cold shock treatment. Using agarose gel electrophoresis, no obvious correlation between the cold shock response and the number of plasmids in the cell could be observed.     

Thermal stress responses in Antarctic yeast, Glaciozyma antarctica PI12, characterized by real-time quantitative PCR

Living organisms have some common and unique strategies to response to thermal stress. However, the amount of data on thermal stress response of certain organism is still lacking, especially psychrophilic yeast from the extreme habitat. Therefore, it is not known whether psychrophilic yeast shares the common responses of other organisms when exposed to thermal stresses. In this work, the cold shock and heat shock responses in Antarctic psychrophilic yeast Glaciozyma antarctica PI12 which had an optimal growth temperature of 12 °C were determined. The expression levels of 14 thermal stress-related genes were measured using real-time quantitative PCR (qPCR) when the yeast cells were exposed to cold shock (0 °C), mild cold shock (5 °C), and heat shock (22 °C) conditions. The expression profiles of the 14 genes at these three temperatures varied indicating that these genes had their specific roles to ensure the survival of the yeast. Under cold shock condition, the afp4 and fad genes were over-expressed possibly as a way for the G. antarctica PI12 to avoid ice crystallization in the cell and to maintain the membrane fluidity. Under the heat shock condition, hsp70 was significantly up-regulated possibly to ensure the proteins fold properly. Among the six oxidative stress-related genes, MnSOD and prx were up-regulated under cold shock and heat shock, respectively, possibly to reduce the negative effects caused by oxidative stress. Interestingly, it was found that the trehalase gene, nth1 that plays a role in degrading excess trehalose, was down-regulated under the heat shock condition possibly as an alternative way to accumulate trehalose in the cells to protecting them from being damaged.     

海藻糖载入红细胞及其冷冻干燥的实验研究

冷冻干燥保存是长期保存人体红细胞的理想方案之一。冻干保护剂海藻糖渗入细胞内后,对细胞膜和细胞内物质有保护作用,其中的一个作用是增加细胞质的浓度,使冻干过程容易形成稳定的玻璃态。应用高渗法处理红细胞,通过考察胞内海藻糖含量、红细胞冻干后的存活率、腺苷三磷酸酶(ATPase)、超氧化物歧化酶(SOD)活力以及细胞形态变化,研究胞内海藻糖含量对红细胞冻干后活性的影响。结果显示:海藻糖对红细胞冻干具有明显的保护作用,随胞内海藻糖浓度升高,其保护性能逐渐增强;43.8mmol/L的胞内海藻糖浓度对红细胞保护最好,细胞存活率达到53.6%,形态保持良好,ATP和SOD活力均在正常的范围内。     

Cold shock response inLactococcus lactis ssp.diacetylactis

The acquired freeze-thaw tolerance was investigated forLactococcus lactis ssp.diacetylactis. Pretreatment of microorganisms at less severe temperatures to initiate cold tolerance gaveL. lactis ssp.diacetylactis improved cell viability after successive freezings and thawings. The ability of cells to survive freeze-thaw was dependent on factors experienced prior to freezing. Factors affecting lactic acid bacteria survival during freeze-thaw cycles were found to be different diluents, growth phase, and different cold temperatures. Viability experiments showed that this strain displaying cold shock cryotolerance had an improved survival capacity in stationary phase. The plasmid contents of lactic acid bacteria isolated from different types, DRC-2 and DRC-2C, were examined and compared with the plasmid contents of culture collection strains both before and after cold shock treatment. Using agarose gel electrophoresis, no obvious correlation between the cold shock response and the number of plasmids in the cell could be observed.