Streptomyces aureofaciens strains as hosts for cloning of genes affecting antibiotic production

Summary Several mutants ofStreptomyces aureofaciens strain were used for protoplast regeneration and plasmid transformation. All tested mutants (excepting R 8/26) were transformable by number of plasmids and shuttle vectors. The transformation of the CTC production strains by plasmid containing cloned CTC resistance gene resulted in 1,1–4 times higher antibiotic production. From the restriction analysis of plasmid, phage and chromosomal DNAs it was estimated, that all tested mutants normally contain the modification system analogous toNae I (Roberts, 1987). Mutant R 8/26 expresses not only complete restriction-modification system mentioned above but also potential second system restricting several actinophages.     

Dual aerobic hollow-fiber bioreactor for cultivation of Streptomyces aureofaciens

Streptomyces aureofaciens (ATCC 12416c) was grown in the interstitial region formed by a parallel arrangement of three hollow silicone tubules contained within a microporous polypropylene hollow fiber. Liquid-soluble nutrients were supplied by diffusion across the polypropylene fiber to the interstitial cell-containing region whereas air or oxygen was provided by diffusion from the silicone tubule lumina to the cell mass. In this bioreactor, S. aureofaciens grew to high cell densities (greater than 10(11) cells/cm(3)) and the culture so-obtained continously synthesized the secondary metabolite tetracycline. The volumetric productivity of tetracycline based on the interstitial volume was 90 mug/ml/h and based on the total reactor volume was 5.5 mug/mL/h. The high surface area-to-volume ratio afforded by the cylindrical configuration together with spatially distinct conduits to continuously transport liquids and gases, each of which may be nutrients or products of biosynthesis, to or from a tissuelike cell mass provides an alternative to the conventional air- or oxygen-sparged fermentation vessel. High volumetric reactor productivities may be achieved by virute of the concentrated stationary cell mass and by the appropriate selection of fiber sizes and materials so as to ensure adequate supplies of liquid and gaseous substrates to, as well as removal of metabolites from, most cells in the culture. This reactor topology is quite general and may be adapted to most microbial as well as mammalian and plant cell systems.     

Metabolic and genetic aspects of the relationship between growth and tetracycline production in Streptomyces aureofaciens

Summary A mutant of S. aureofaciens characterized by lower growth and higher tetracycline production than its parent strain is described. The mutant has a limited degree of temperature-sensitivity and shows a lower efficiency in the utilization of phosphate for growth and a higher cellular content of RNA. The data are in accordance with a possible mutation impairing some aminoacyl RNA synthetases. This kind of mutation might explain the lower growth in phosphate limited conditions and the higher content of RNA.     

Oleandomycin content of mycelium and fermentation solution during cultivation of Streptomyces antibioticus

The time-course of the oleandomycin content in the mycelium and fermentation broth-filtrate was studied by the microbiological assay at different periods of cultivation of strains 471 and 961 in fermenters and flasks containing a rich soybean-corn medium. It was shown that centrifugation of the mycelium over the sucrose density gradient induced a 25-80 per cent decrease in its moist weight at the expense of removal of the admixture components of the rich medium. Addition of glucose (2 per cent) to the culture-grown in a lactose medium by the 72nd hour of fermentation had no effect on further increase of the cell biomass. However, it lowered the content of the mycelium-fixed and excreted antibiotic at all the subsequent fermentation periods. The content of oleandomycin in the untreated mycelium was only 0.36 per cent of its content in the fermentation broth filtrate. After centrifugation of the mycelium over the sucrose density gradient and its intensive washing with distilled water the content of the mycelium-fixed antibiotic decreased still more. The time-course of the content of the mycelium-fixed and excreted oleandomycin was characterized by the presence of two activity peaks; by the 80-110th and by the 140-170th hour of cultivation.     

Crystallization and preliminary diffraction studies of malate dehydrogenase from Streptomyces aureofaciens

Purified malate dehydrogenase (MDH) of Streptomyces aureofaciens was crystallized either in the absence or in the presence of NADH or NADPH coenzymes by hanging-drop vapour-diffusion method. An X-ray study has shown, that MDH crystals belong to space group C222(1) with unit-cell parameters a = 53.2 A, b = 104.6 A, c = 520.0 A, alpha = beta = gamma = 90( degrees ), MDH-NADH crystals to space group C2 with unit-cell parameters a = 51.5 A, b = 51.5 A, c = 256 A, alpha = beta = gamma = 90( degrees ), and MDH-NADPH crystals to space group C222(1) with unit-cell parameters a = 72, A b = 72 A, c = 520 A, alpha = beta = gamma = 90( degrees ). The crystal of native MDH diffracted to 2.1 A resolution.     

Inhibition studies of glucose-6-phosphate dehydrogenase from tetracycline-producing Streptomyces aureofaciens

NAD-linked activity of glucose-6-phosphate dehydrogenase from both low-producing and high-producing strains of Streptomyces aureofaciens was inhibited by ATP, ADP, AMP and Pi. The inhibition constants indicate that ADP was the most potent inhibitor. The NADP-linked activity remained unaffected even at relatively high concentrations of these inhibitors. All inhibitions of the NAD-linked activity were competitive with respect to NAD and noncompetitive with respect to glucose-6-phosphate. The results represent a possible new regulatory mechanism of glucose-6-phosphate dehydrogenase from a streptomycete and emphasize its involvement in the regulation of the biosynthesis of tetracyclines.     

Mechanism of the incidental production of a melanin-like pigment during 6-demethylchlortetracycline production in Streptomyces aureofaciens

The secondary metabolite 6-demethylchlortetracycline (6-DCT), which is produced by Streptomyces aureofaciens, is used as a precursor of semisynthetic tetracyclines. Strains that produce 6-DCT also produce a melanin-like pigment (MP). The correlation between MP production and 6-DCT production was investigated by using S. aureofaciens NRRL 3203. Production of both MP and 6-DCT was repressed by phosphate or ammonium ions, suggesting that syntheses of these compounds are controlled by the same regulators. Ten chlortetracycline-producing recombinants were derived from 6-DCT-producing mutant NRRL 3203 by gene replacement. All of the recombinants produced chlortetracycline but not MP, indicating that MP production is the results of a defect in the 6-methylation step and suggesting that the polyketide nonaketideamide is a common intermediate leading to MP as well as 6-DCT. To further examine the possibility that MP might be synthesized via the 6-DCT-biosynthetic pathway, mutants defective in 6-DCT biosynthesis were derived from a 6-DCT producer. Some of these mutants were able to produce MP, while others, including mutants with mutations in the gene encoding anhydrotetracycline oxygenase, an enzyme catalyzing the penultimate step in the pathway, produced neither 6-DCT nor MP. Production of 6-DCT and production of MP were restored simultaneously by integrative transformation with the corresponding 6-DCT-biosynthetic genes, indicating that some of 6-DCT-biosynthetic enzymes are indispensable for MP production. These findings suggest that a defect in the 6-methylation step results in redirection of carbon flux from a certain intermediate in the 6-DCT-biosynthetic pathway to a shunt pathway and results in MP production.     

The effect of aureomycin on the growth and metabolism of the pig

The effect of dietary aureomycin on the growth of the pig has been studied under conditions of full-feeding and equalized feed intake. The growth response to aureomycin appeared to be dependent upon an increased daily feed intake. Such factors as hemoglobin level, efficiency of feed utilization, nitrogen balance, and energy balance did not seem to be influenced by feeding aureomycin under the conditions imposed by this experiment.     

Expression of the Csp protein family upon cold shock and production of tetracycline in Streptomyces aureofaciens

The biosynthesis of the steroidal molting hormone, 20-hydroxyecdysone, of arthropods involves a series of cytochrome P450-catalyzed hydroxylations. None of the many sequences of insect cytochromes P450, known to date, is related to ecdysteroid pathways. Here, we report the cloning and sequencing of a full-length cDNA of a new cytochrome P450, classified as CYP6H1, from malpighian tubules of the locust, Locusta migratoria. The 1854 bp DNA contained an open reading frame coding for a protein of 542 amino acids, a 5'-leader sequence and a 3'-untranslated region containing a polyadenylation signal and a poly(A) tail. The encoded protein had been isolated as an ecdysone-binding cytochrome P450 from microsomes of the same tissue in previous work. The closest homolog of CYP6H1 was CYP6A2 from Drosophila with 42.1% identity. According to Northern analysis, CYP6H1 is predominantly expressed at larval instars and in malpighian tubules. Evidence is presented for a functional assignment of CYP6H1 to microsomal ecdysone 20-hydroxylase of the locust.     

Restoration of aerial mycelium and antibiotic production in a Streptomyces griseoflavus arginine auxotroph

An arginine auxotrophic mutant was obtained from Streptomyces griseoflavus (bicozamycin-producing strain). The mutant grew on synthetic agar supplemented with either arginine, ornithine, citrulline or argininosuccinate, but produced massive aerial mycelium and bicozamycin only with citrulline. In liquid culture, citrulline also completely restored the ability of the mutant to produce bicozamycin. Culture with arginine or ornithine markedly changed intracellular pools of these ornithine-cycle amino acids, but did not affect the other amino acid pools. The ability to produce antibiotic (but not that to form aerial mycelium) was partially restored by certain mutations to ethionine resistance (Eth-1 and Eth-2). These mutations caused decreased or increased S-adenosylmethionine synthetase activity, but both resulted in a 4.5-8-fold increase in the intracellular S-adenosylmethionine pool. Exogenous addition of S-adenosylmethionine (0.5-3 mM) also partially restored the antibiotic-producing ability of the arginine auxotroph. No difference in the S-adenosylmethionine pool was observed in organisms grown with arginine and citrulline. It was suggested that citrulline and S-adenosylmethionine are somehow involved in the initiation of differentiation and secondary metabolism of S. griseoflavus.     

Effect of culture media on protease and oxytetracycline production with mycelium and protoplasts of Streptomyces rimosus

For the simultaneous production of protease and oxytetracycline, mycelium and protoplasts of Streptomyces rimosus TM-55 were cultivated in basal medium containing soluble starch, corn steep liquid, ammonium sulphate, calcium carbonate, sodium chloride and soybean oil. Protease and oxytetracycline production increased with decreasing in ratio of culture broth to vessel volume from 1:2 to 1:5. Each ml of broth with 0.286 mg fresh mycelia yielded 168–204 units of protease and 785–972 g of oxytetracycline after replacement of corn steep liquor, sodium chloride and soybean oil with beef extract and sunflower oil, while each ml of broth with 7.5 × 10⁷ protoplasts produced 141–153 units of protease and 504–615 g of oxytetracycline. Protease and oxytetracycline production were low when the pH was 5.1 or 9.0. Soluble starch and ammonium sulphate were the best carbon and nitrogen sources, respectively. Supplementation with calcium carbonate enhanced protease and oxytetracycline production. The productivity of protoplasts decreased sharply when the incubation temperature increased from 28 to 34 °C, while the productivity of mycelium was almost unchanged.     

Significance of agitation-induced shear stress on mycelium morphology and lavendamycin production by engineered Streptomyces flocculus

Lavendamycin methyl ester (LME) is a derivative of a highly functionalized aminoquinone alkaloid lavendamycin and could be used as a scaffold for novel anticancer agent development. This work demonstrated LME production by cultivation of an engineered strain of Streptomyces flocculus CGMCC4.1223 ΔstnB1, while the wild-type strain did not produce. To enhance its production, the effect of shear stress and oxygen supply on ΔstnB1 strain cultivation was investigated in detail. In flask culture, when the shaking speed increased from 150 to 220 rpm, the mycelium was altered from a large pellet to a filamentous hypha, and the LME production was almost doubled, while no significant differences were observed among varied filling volumes, which implied a crucial role of shear stress in the morphology and LME production. To confirm this suggestion, experiments with agitation speed ranging from 400 to 1,000 rpm at a fixed aeration rate of 1.0 vvm were conducted in a stirred tank bioreactor. It was found that the morphology became more hairy with reduced pellet size, and the LME production was enhanced threefolds when the agitation speed increased from 400 to 800 rpm. Further experiments by varying initial k _L a value at the same agitation speed indicated that oxygen supply only slightly affected the physiological status of ΔstnB1 strain. Altogether, shear stress was identified as a major factor affecting the cell morphology and LME production. The work would be helpful to the production of LME and other secondary metabolites by filamentous microorganism cultivation.