Modified use of a commercial ELISA kit for deoxynivalenol determination in rice and corn silage

The analysis of deoxynivalenol (DON) in silage samples using enzyme-linked immunosorbent assay (ELISA) often leads to an overestimation. To better analyze DON in rice and corn silages using a commercially available ELISA kit, a cleanup method using a MultiSep #226 column was developed. As a result, overestimation of DON by the influence of specific cross-reaction with acetyldeoxynivalenol (AcDON) was confirmed. In samples where AcDON was not detected by liquid chromatography with mass spectrometry (LC-MS), no samples showed a significant difference (P?<?0.05) in DON amounts between ELISA with cleanup and LC-MS analysis. For the recovery study, blank silage was spiked with 0.5 or 1.0 mg/kg DON. The mean recoveries of DON determined by ELISA with cleanup and LC-MS analysis were 112 and 96 %, respectively, and the relative standard deviation for the repeatability (RSD_r) were 8.2 and 9.8 %, respectively. No samples showed a significant difference (P?<?0.05) in DON concentration determined by either ELISA or LC-MS analysis. A collaborative study to validate this rapid method was carried out using four samples, two rice and two corn silage, by 10 participating laboratories. Each sample was analyzed using blind duplicates. The mean values of DON detected were 1.5–2.3 mg/kg, RSD_r and the relative standard deviation for the reproducibility (RSD_R) were 4.1–12.7 and 7.6–23.4 %, respectively, and the HorRat values were 0.5–1.6. Therefore, the overestimation of DON by the influence of nonspecific cross-reaction with sample matrix was reduced by the cleanup method using a MultiSep #226 column, and analysis of DON in silage was improved. This use of this method for estimation of DON contamination in silage allows rapid detection at the place of use that is likely to result in improved animal health.     

Determination of deoxynivalenol in cereals by immunoaffinity clean-up and ultra-high performance liquid chromatography tandem mass spectrometry

An immunoaffinity column (IAC) was prepared with a new deoxynivalenol (DON) monoclonal antibody and used as a clean-up tool before ultra-high performance liquid chromatography tandem mass spectrometry (UPLC-MS/MS) analysis of DON in cereals. The developed IAC clean-up method showed high recoveries for DON. They ranged from 61% to 103% in wheat, rice, and millet with intra-day and inter-day variations below 19% and 17%, respectively. The column capacity was 2.86μg DON per mL of gel, and it maintained above 0.68μg/mL of gel after 10 cycles of usage at 2 days intervals. The limit of detection (LOD) and limit of quantification (LOQ) were 0.3 and 0.8μg/kg, respectively. Twenty-one out of 40 analyzed commercial cereal samples were positive at DON concentrations from 7 to 534μg/kg.     

Simple method for isolation of 4-deoxynivalenol from rice inoculated with Fusarium graminearum.

A new method for preparative isolation of 4-deoxynivalenol (DON) is presented. This method avoids the loss of material during purification on silica gel by column chromatography. DON and 3-acetyldeoxynivalenol in crude extracts of rice inoculated with Fusarium graminearum were converted to triacetyldeoxynivalenol; the acetylated product was easier to purify by silica gel chromatography than DON is. After hydrolysis and further purification on a charcoal-alumina column, the 71% pure DON was recovered in yields as high as 450 mg of DON per kg of rice. Subsequent separation on a Sephadex LH20 column yielded DON that was greater than 90% pure.     

Bestimmung von Deoxynivalenol und Deepoxy-Deoxynivalenol in Milch

A HPLC method with UV/diode array detection for the determination of deoxynivalenol (DON) and deepoxy-deoxynivalenol (DOM-1) in milk was developed. Milk was incubated with β-glucuronidase and then defatted. After purification by immunoaffinity chromatography, DON and DOM-1 were separated on a C18 reversed phase column with acetonitril/water (10/90) as the mobile phase and detected at 218 nm. Limits of quantification were 1 μg/l for both toxins, with mean recoveries (1–10 μg/l) of 97% (DON) and 84% (DOM-1), respectively. Milk samples (pasteurized, UHT; n=32) from German retail shops were analysed by this method. Neither DON/DOM-1 nor their glucuronides were found in any sample. These results are consistent with published studies indicating that in lactating cows, DON and DOM-1 are mostly eliminated through urine, and that the carry-over into milk is negligible.     

Humic substances failed to prevent the systemic absorption of deoxynivalenol (DON) and its adverse effects on piglets

The aim of this study was to examine the effects of a control diet (CON, 0.25?mg DON/kg diet) or a Fusarium toxin-contaminated diet (FUS, 4.49?mg DON/kg diet) without and with humic substances (HS) (CON-HS and FUS-HS, 0.23 and 4.56?mg DON/kg diet, respectively) on piglets during a 5-week growth trial starting after weaning (6.7?±?0.9?kg live weight, n?=?20/group). Feed intake was significantly reduced by feeding the FUS containing diets by approximately 21% compared with the CON diet irrespective of HS supplementation. The decrease in live weight gain paralleled the feed intake depression and amounted to approximately 26%. Feeding the FUS diet was clearly reflected by the DON levels in blood. While only traces of DON with median concentrations of 3?ng/ml (2?C5?ng/ml) and 2?ng/ml (0?C3?ng/ml) were detected in piglets fed the CON and CON-HS diets, respectively, significantly higher levels of 22.5?ng/ml (7?C30?ng/ml) and 23.5?ng/ml (15?C32?ng/ml) were found in piglets fed the FUS and FUS-HS diet, respectively. The urinary excretion of DON and its metabolite de-epoxy-DON as percentage of DON intake was not significantly influenced by HS supplementation and amounted to 24.1 and 20.2% for groups FUS and FUS-HS, respectively. In conclusion, the tested HS preparation cannot be recommended as a DON inactivating feed supplement for pigs.     

Analysis of Fusarium Graminearum Mycotoxins in Different Biological Matrices by LC/MS

The purpose of this study was to develop an LC/MS assay to accurately detect three mycotoxins produced by Fusarium graminearum in various matrices. Using different LC conditions, deoxynivalenol (DON), 15-acetyldeoxynivalenol (15-ADON), and zearalenone (ZEN) were detected in four different matrices (fungal liquid cultures, maize grain, insect larvae and pig serum). The sensitivity of MS detection allowed us to detect concentrations as low as 8 ppb of DON and 12 ppb of ZEN. A very small quantity of matrix was therefore necessary for successful analysis of these toxins and a variety of experimental situations were successfully investigated using this technique. Production of 15-ADON and butenolide was monitored in a liquid culture of F. graminearum under controlled conditions. Using simple extraction procedures, the differential accumulation of DON and 15-ADON was followed in inoculated maize genotypes varying in susceptibility to F. graminearum. Toxicokinetic studies were carried out with maize insect pests reared continually on artificial diets containing ZEN and suggested that larvae may possess the ability to degrade ZEN. Finally, persistence of DON was assessed in pigs fed diet supplemented with DON, results indicated that DON accumulates quickly in pig blood and then levels decline progressively for 12 hours thereafter. The LC/MS study reported here is very useful and flexible for the detection of these mycotoxins in different media and at very low concentrations.     

Effects of deoxynivalenol and lipopolysaccharide on electrophysiological parameters in growing pigs

Deoxynivalenol (DON) is a major B-trichothecene that draws importance from its natural occurrence in cereals worldwide. It has many effects on rapidly dividing cells. Lipopolysaccharide (LPS) is an endotoxin released from most Gram-negative bacteria, which plays a major role in induction of inflammation and sepsis under certain conditions. In our experiments we aimed to study the effects of different concentrations of DON (up to 8,000?ng/ml) on the electrogenic transport of nutrients and on tissue conductances in growing pigs using the Ussing chamber technique. The effect of DON-contaminated feed (2.9?mg/kg feed) on the respective parameters, as well as the interactions between DON and intraperitoneal (i.p.) LPS were assessed using porcine jejunal tissues. In vitro DON inhibited the absorption of alanine and glucose across the pig jejunum at concentrations of 4,000 and 8,000?ng/ml, suggesting that DON had an inhibitory effect on the electrogenic transport of nutrients across porcine small intestines. Electrogenic transport of alanine and glucose across porcine small intestines varied regionally among intestinal segments with higher response in ileal tissues. A synergistic effect was observed between DON in feed and injected LPS on tissue conductance. In response, glucose with higher short circuit currents was observed across porcine jejunal mucosa in nutrient stimulated conditions.     

A study of the suitability of gas chromatography-electron capture detection for the analysis of deoxynivalenol in cereals

A gas chromatographic-electron capture detection (GC-ECD) method for the analysis of deoxynivalenol (DON) in cereals was investigated. The sample was extracted with a mixture of acetonitrile-water and purified with a MycoSep #225 column. The silylation was performed with Tri-Sil-TBT reagent, followed by dilution with hexane and a washing step with buffer. By using Tri-Sil-TBT reagent no double peaks were observed for DON in the gas chromatograms, in comparison with two other silylation reagents TMSI and Tri-Sil-Z. The use of trichothecolone (TRI) as an internal standard for DON was studied in order to indicate possible problems in the derivatisation reaction. TRI proved to be a relatively good internal standard for DON in cereal samples, as well as 1,1-bis-(4-chlorophenyl)-2,2-dichloroethylene (DDE), which was used as a GC standard for ensuring the function of GC-ECD. During the study, a matrix effect was clearly observed between the cereal matrix-assisted calibration curve and the calibration curve prepared without cereal matrix. The results of spiked and reference material samples, quantified with the calibration curve prepared without and with matrix, demonstrated that the matrix affects the results. However, after recovery correction the results were comparable. The validation results demonstrated that the GC-ECD method for DON analysis in cereals is sufficiently reliable.     

Carry-over of deoxynivalenol into eggs of laying hens — Preliminary results

Carry-over of deoxynivalenol (DON) into eggs was investigated within the scope of a 16-week experiment with laying hens, in which the birds were fed a maize-based diet containing DON at 11.9 mg/kg dry matter. Eggs were collected during weeks 2, 4, 8, and 16. DON and its metabolite deepoxy-DON were analysed separately in freeze-dried yolk and albumen. Yolk was extracted with water and the extract was purified using an immunoaffinity column (IAC). Albumen was extracted with acetonitrile-water and the extract was pre-cleaned before applying an IAC. All albumen and some yolk samples were incubated with β-glucuronidase prior to extraction. DON and de-epoxy-DON were determined by high performance liquid chromatography (HPLC) with diode array detection (DAD). The detection limits of both toxins were 20 ng/g and 15 ng/g in freezedried yolk and albumen, respectively, corresponding to approximately 10 ng/g and 2 ng/g in fresh samples. The recovery of DON/de-epoxy-DON in spiked samples (50–200 ng/g) was 87/83% (yolk) and 87/77% (albumen) with coefficients of variation of 4–15%. Neither DON nor de-epoxy-DON were detected in any of the samples. In order to achieve lower detection limits, the methods are currently optimized. However, these preliminary results indicate that eggs do not contribute significantly to the dietary DON intake of the consumer. Presented at the 26^th Mykotoxin-Workshop in Herrsching, Germany, May 17–19, 2004     

A comparison of deoxynivalenol intake and urinary deoxynivalenol in UK adults

The relationship between deoxynivalenol (DON) intake and first morning urinary DON was examined in UK adults to validate the latter as a biomarker of human exposure. DON was assessed in first morning samples collected during a period of normal diet, a wheat-restriction intervention diet, and partial wheat-restriction intervention in which bread was allowed. During the partial intervention duplicate bread portions were collected for DON analysis. During the normal diet, partial intervention and full intervention, urinary DON was detected in 198/210 (geometric mean 10.1?ng DON mg^?1 creatinine, 95% confidence interval (CI) 8.6–11.6?ng mg^?1; range nd–70.7?ng mg^?1), in 94/98 (5.9?ng mg^?1, 95% CI 4.8–7.0?ng mg^?1; range nd–28.4?ng mg^?1), and 17/40 (0.5?ng mg^?1, 95% CI 0.3–0.7?ng mg^?1; range nd–3.3?ng mg^?1) volunteers, respectively. A strong correlation between DON intake and the urinary biomarker was observed (p <0.001, adjusted r²?=?0.83) in models adjusting for age, sex and body mass index. These data demonstrate a quantitative correlation between DON exposure and urinary DON, and serve to validate the use of urinary DON as an exposure biomarker.     

Investigation on the biodegradability of mycotoxins nivalenol (NIV) and deoxynivalenol (DON) in a rusitec fermentor and their monitoring by HPLC/MS

Biodegradation of two B-trichothecenes nivalenol (NIV) and deoxynivalenol (DON) have been studied in a RUSITEC (rumen simulation technique) system. The fermentation studies were carried out in vessels containing the rumen fluid. To reach steady state an adaptation period of one week was carried out. The mycotoxin standards were then added into the fermentor in a concentration of 1ppm NIV and 2ppm DON. The kinetics of NIV and DON biodegradability during the fermentation process were monitored by using a rapid HPLC method combined with a mass spectrometer and an atmospheric pressure chemical ionisation (APCI^-) interface. Also the effect of mycotoxin addition on different parameters such as ammonia production, pH, gas production and volatile fatty acids have been studied.     

On the toxicokinetics and the metabolism of deoxynivalenol (don) in the pig

Eleven castrated male pigs weighing 88.1?±?3.9?kg on average were adapted to a diet containing DON (4.2?mg DON/kg) over a period of 7 days. Feed was given restrictively with 1.1?kg per meal (two meals per day). On the day of measurement, all pigs were slaughtered at different time intervals following the morning meal containing DON (1, 2, 3, 4, 5, 6, 8, 15, 18 and 24?h after feeding), with the exception of one pig which was slaughtered unfed. DON and de-epoxy-DON were analysed in serum and digesta from consecutive segments of the digestive tract (stomach, small intestine divided into three parts of a similar length, caecum, colon, rectum). DON was rapidly and nearly completely absorbed while passing through the stomach and the proximal small intestine. Maximum serum concentration appeared 4.1?h after the DON-containing meal and half of the systemically absorbed DON was eliminated after 5.8?h. De-epoxy-DON appeared in increasing proportions from the distal small intestine and reached approximately 80% of the sum of DON plus de-epoxy-DON in faeces collected from the rectum. It was concluded that de-epoxydation of DON, which primarily occurs in the hindgut, probably does not contribute much to a detoxification in the pig.     

Development of a liquid chromatography tandem mass spectrometry method for the simultaneous determination of zearalenone,deoxynivalenol and their metabolites in pig serum

A sensitive and selective liquid chromatography tandem mass spectrometry method using negative electrospray ionisation (LC-ESI-MS/MS) was developed for the simultaneous determination of zearalenone (ZEN), deoxynivalenol (DON) and their metabolites α-zearalenol, β-zearalenol, zearalanone, α-zearalanol, β-zearalanol and de-epoxy-deoxynivalenol in pig serum. For method development, different sample preparation columns were tested for their suitability for extraction and clean up. Finally, preparation of serum samples was carried out using Oasis? HLB solid-phase extraction (SPE) columns. The analyte concentrations were determined by the use of isotopically labelled internal standards (IS). The method was in-house validated for all analytes. Calibration graphs (0.3–480 ng/ml) were prepared and high degree of linearity was achieved (r?≥?0.99). Results for method precision ranged between 2.7 and 21.5 % for inter-day and between 1.1 and 11.1 % for intra-day. The recoveries were in the range of 82–131 %. Limits of detection and quantification ranged 0.03–0.71 and 0.08–2.37 ng/ml, respectively. The method has been successfully used for quantitative determination of ZEN, DON and their metabolites in pig serum from a feeding trial with practically relevant ZEN and DON concentrations. This method is precise and reproducible and can be used as a multi-biomarker method to assess animal exposure to these mycotoxins and for diagnosis of intoxications.     

Sample clean-up methods,immunoaffinity chromatography and solid phase extraction,for determination of deoxynivalenol and deepoxy deoxynivalenol in swine serum

Concentrations of deoxynivalenol (DON) and deepoxy deoxynivalenol (DOM-1) in animal blood are important parameters for studies in toxicology and biological detoxification of DON. Clean-up methods, using either immunoaffinity chromatography (IAC) or solid phase extraction (SPE), were compared in order to determine the free form of DON or DOM-1 and the sum amount (free form plus glucuronide conjugated form of DON or DOM-1), respectively, in swine serum. Detection was achieved by high performance liquid chromatography with ultraviolet detection (HPLC-UV). Compared with the SPE-HPLC method, the IAC-HPLC method provided lower quantitation limit (DON: 18 vs 42 ng/ml; DOM-1: 21 vs 30 ng/ml) and higher recoveries (DON: 93.4–102.7% vs 63.7–85.3%; DOM-1: 85.5–91.1% vs 68.0–82.6%). Compared with previously published methods, the developed IAC-HPLC method removed analytical interferences from swine serum in one quick and easy step, and eliminated steps of extraction with organic solvent and/or pre-purification using SPE cartridges. This IAC-HPLC method was used to analyze swine serum samples collected from pigs that were evaluated in a feeding trial of a microbiological detoxification of DON. No DON or DOM-1 were detected in serum samples from pigs given a toxin-free diet or a microbial control diet. In serum samples from pigs given a DON diet (5 mg/kg of DON), free form DON and sum free DON + conjugated DON were 38.8 ± 13.7 and 49.8 ± 14.1 ng/ml, respectively. In serum samples from those given a detoxified-DON diet (DON was transformed to DOM-1), free form DOM-1 was detected but not quantified, and the sum DOM-1 was found as 47.5 ± 6.3 ng/ml.     

Nocardioides sp. strain WSN05-2, isolated from a wheat field, degrades deoxynivalenol, producing the novel intermediate 3-epi-deoxynivalenol

The mycotoxin deoxynivalenol (DON) causes serious problems worldwide in the production of crops such as wheat and barley because of its toxicity toward humans and livestock. A bacterial culture capable of degrading DON was obtained from soil samples collected in wheat fields using an enrichment culture procedure. The isolated bacterium, designated strain WSN05-2, completely removed 1,000???g/mL of DON from the culture medium after incubation for 10?days. On the basis of phylogenetic studies, WSN05-2 was classified as a bacterium belonging to the genus Nocardioides. WSN05-2 showed significant growth in culture medium with DON as the sole carbon source. High-performance liquid chromatography analysis indicated the presence of a major initial metabolite of DON in the culture supernatant. The metabolite was identified as 3-epi-deoxynivalenol (3-epi-DON) by mass spectrometry and ¹H and ¹³C nuclear magnetic resonance analysis. The amount of DON on wheat grain was reduced by about 90% at 7?days after inoculation with WSN05-2. This is the first report of a Nocardioides sp. strain able to degrade DON and of the yet unknown 3-epi-DON as an intermediate in the degradation of DON by a microorganism.     

LC-MS/MS method for simultaneous determination of valproic acid and major metabolites in human plasma

A rapid and sensitive method using liquid chromatography-tandem mass spectroscopy (LC-MS/MS) was developed and validated for simultaneous quantitative determination of valproic acid and three major metabolites (3-OH-valproic acid, 4-ene-valproic acid and 5-OH-valproic acid) in human plasma. The analytes and internal standard were isolated from 200 μL samples by solid phase extraction using a ZORBAX SB-C? column (3.5 μm, 2.1×100 mm) with an isocratic mobile phase consisting of methanol-10mM ammonium acetate (80:20, v/v) containing 0.1% formic acid at a flow rate of 0.3 mL/min. The method had a chromatographic total run time of 2.0 min. The lower limit of quantification of valproic acid, 3-OH-valproic acid, 4-ene-valproic acid and 5-OH-valproic acid of the method was 2030, 51.5, 50.15 and 51.25 ng/mL, respectively. The method was linear for valproic acid and the three metabolites with correlation coefficients >0.995 for all analytes. The intra-day and inter-day accuracy and precision of the assay were less than 15.0%. This analytical method was successfully used to assay plasma concentrations of valproic acid and the three metabolites in human plasma from epileptic patients.     

Simultaneous determination of major B-trichothecenes and the de-epoxy-metabolite of deoxynivalenol in pig urine and maize using high-performance liquid chromatography-mass spectrometry

A selective analytical method based on high-performance liquid chromatography (HPLC), combined with atmospheric pressure chemical ionisation (APCI-) mass spectrometry (MS), has been developed for simultaneous determination of B-trichothecenes and the major metabolites of deoxynivalenol. The method allows simultaneous analysis of nivalenol (NIV), deoxynivalenol (DON), 15-acetyldeoxynivalenol (15-AcDON), 3-acetyldeoxynivalenol (3-AcDON), fusarenon X (Fus-X) and de-epoxydeoxynivalenol (DOM-1). The method is based on one-step sample clean-up using a multifunctional MycoSep column. A linear gradient mobile phase system, consisting of water:acetonitrile:methanol (H2O:ACN:MeOH) at a flow-rate of 1 ml/min, and a Polar-RP C18 column, were utilised to obtain the best resolution of all tested compounds along with column and equilibrating within 30 min. Dexamethasone (Dex) was used as internal standard. The developed method shows good repeatability for inter- and intra-day precisions as well as good linearity of calibration curves (r2 ranged from 0.9936 to 0.9998). Average recoveries for tested compounds in both matrices have been determined ranging from 63.7 to 102.3% and limit of quantification (LOQ) ranged from 25 to 150 ng/g. The utility and practical impact of the method is demonstrated using contaminated pig urine and maize samples.     

Determination of deoxynivalenol (DON) in blood, bile, urine and excrement samples from swine using immunoaffinity chromatography and LC-UV-detection

A work up procedure is described by which DON concentrations in blood, bile, urine and excrements from swine can be quantified by HPLC and UV- detection at λ = 220 nm. The central step thereby is the purification and concentration of DON by means of an immunoaffinity column. While, in our experiments, the quantification of DON in blood and urine was straightforward an additional purification step by a preparative HPLC run prior to immunoaffinity chromatography was needed when bile and excrements were investigated. However, when low DON concentrations in blood and urine are expected, a preparative HPLC run prior to immunoaffinity chromatography is recommended as well, because larger amounts of sample materials should be analyzed and more impurities interfere with the column proteins. In our study, using spiked samples, recoveries ranged from 75—90% and limits of detection were 0.01 to 0.02 μg/ml.     

Screening for basic drugs in equine urine using direct-injection differential-gradient LC-LC coupled to hybrid tandem MS/MS

A rapid, selective and robust direct-injection LC/hybrid tandem MS method has been developed for simultaneous screening of more than 250 basic drugs in the supernatant of enzyme hydrolysed equine urine. Analytes, trapped using a short HLB extraction column, are refocused and separated on a Sunfire C(18) analytical column using a controlled differential gradient generated by proportional dilution of the first column's eluent with water. Independent data acquisition (IDA) was configured to trigger a sensitive enhanced product ion (EPI) scan when a multiple reaction monitoring (MRM) survey scan signal exceeded the defined criteria. The decision on whether or not to report a sample as a positive result was based upon both the presence of a MRM response within the correct retention time range and a qualitative match between the EPI spectrum obtained and the corresponding reference standard. Ninety seven percent of the drugs targeted by this method met our detection criteria when spiked into urine at 100 ng/ml; 199 were found at 10 ng/ml, 83 at 1 ng/ml and 4 at 0.1 ng/ml.     

A fast LC-APCI/MS method for analyzing benzodiazepines in whole blood using monolithic support

A simple and fast procedure was developed for the simultaneous determination of eight benzodiazepines (BZDs) in whole blood using liquid chromatography-atmospheric pressure chemical ionization-mass spectrometry (LC-APCI-MS). Sample pretreatment was carried out using a simple liquid-liquid extraction (LLE) with n-butylchloride, and chromatographic separation was performed using a monolithic silica column to speed up the analytical process. APCI and electrospray ionization (ESI) were compared. Whereas both ionization techniques appeared suitable for BZDs, APCI was found to be slightly more sensitive, especially for the determination of frequently low-dosed compounds. The method was validated according to the guidelines of the "Société Fran?aise des Sciences et Techniques Pharmaceutiques" (SFSTP) in the concentration range of 2.5-500 microg/L. The limit of quantification (LOQ) was 2.5 microg/L for all the compounds. Validation data including linearity, precision, and trueness were obtained, allowing subtherapeutic quantification of frequently low-dosed BZDs. The high selectivity of the mass spectrometer, along with the properties of the monolithic support, allowed unequivocal analysis of the eight compounds in less than 5 min. To demonstrate the potential of the method, it was used for the analysis of benzodiazepines in postmortem blood samples.