MDCK单克隆细胞库的建立及检定

目的:建立甲型H1N1流感病毒疫苗株高适应MDCK单克隆细胞库,用于培养生产流感病毒疫苗,为细胞代替鸡胚制备流感病毒疫苗提供保证。方法:用有限稀释法将MDCK细胞进行单克隆化,通过血凝和TCID50筛选甲型H1N1流感病毒疫苗株的高适应性单克隆化细胞株,扩大培养建立细胞库并进行检定。结果:共制备了97株单克隆化MDCK细胞,筛选到甲型H1N1流感病毒疫苗株高适应性MDCK单克隆细胞株,扩大培养建立了细胞库,经检定符合《中华人民共和国药典.三部》(2010版)对细胞库的要求。结论:建立了甲型H1N1流感病毒疫苗株高适应性MDCK单克隆细胞库,为细胞培养生产流感病毒疫苗奠定了基础。     

Trypsin promotes efficient influenza vaccine production in MDCK cells by interfering with the antiviral host response

Trypsin is commonly used in Madin–Darby canine kidney (MDCK) cell culture-based influenza vaccine production to facilitate virus infection by proteolytic activation of viral haemagglutinin, which enables multi-cycle replication. In this study, we were able to demonstrate that trypsin also interferes with pathogen defence mechanisms of host cells. In particular, a trypsin concentration of 5 BAEE U/mL (4.5 μg/mL porcine trypsin) used in vaccine manufacturing strongly inhibited interferon (IFN) signalling by proteolytic degradation of secreted IFN. Consequently, absence of trypsin during infection resulted in a considerably stronger induction of IFN signalling and apoptosis, which significantly reduced virus yields. Under this condition, multi-cycle virus replication in MDCK cells was not prevented but clearly delayed. Therefore, incomplete infection can be ruled out as the reason for the lower virus titres. However, suppression of IFN signalling by overexpression of viral IFN antagonists (influenza virus PR8-NS1, rabies virus phosphoprotein) partially rescued virus titres in the absence of trypsin. In addition, virus yields could be almost restored by using the influenza strain A/WSN/33 in combination with fetal calf serum (FCS). For this strain, FCS enabled trypsin-independent fast propagation of virus infection, probably outrunning cellular defence mechanisms and apoptosis induction in the absence of trypsin. Overall, addition of trypsin provided optimal conditions for high yield vaccine production in MDCK cells by two means. On the one hand, proteolytic degradation of IFN keeps cellular defence at a low level. On the other hand, enhanced virus spreading enables viruses to replicate before the cellular response becomes fully activated.     

H1N1流感病毒在微载体培养MDCK细胞上增殖的研究

目的探索MDCK细胞在微载体上的培养条件,并研究H1N1型流感病毒在MDCK细胞上的增殖条件。方法在微载体上培养好MDCK细胞上用H1N1型流感病毒在不同的病毒感染复数(MOI)、胰酶浓度两个关键的病毒增殖条件进行流感病毒在细胞上的增殖研究。结果微载体质量浓度为6 g/L时,MDCK细胞培养密度可以达到4.5×106cells/mL。在MOI为0.05接种流感病毒,胰酶质量浓度4μg/mL,流感病毒在MDCK细胞上可获得较高的滴度。结论 MDCK细胞用微载体培养可以达到较高的细胞密度,可以作为规模化生产新型流感病毒疫苗的主要细胞基质进行进一步的研究。     

Overexpression of the alpha-2,6-sialyltransferase in MDCK cells increases influenza virus sensitivity to neuraminidase inhibitors

No reliable cell culture assay is currently available for monitoring human influenza virus sensitivity to neuraminidase inhibitors (NAI). This can be explained by the observation that because of a low concentration of sialyl-alpha2,6-galactose (Sia[alpha2,6]Gal)-containing virus receptors in conventional cell lines, replication of human virus isolates shows little dependency on viral neuraminidase. To test whether overexpression of Sia(alpha2,6)Gal moieties in cultured cells could make them suitable for testing human influenza virus sensitivity to NAI, we stably transfected MDCK cells with cDNA of human 2,6-sialyltransferase (SIAT1). Transfected cells expressed twofold-higher amounts of 6-linked sialic acids and twofold-lower amounts of 3-linked sialic acids than parent MDCK cells as judged by staining with Sambucus nigra agglutinin and Maackia amurensis agglutinin, respectively. After transfection, binding of a clinical human influenza virus isolate was increased, whereas binding of its egg-adapted variant which preferentially bound 3-linked receptors was decreased. The sensitivity of human influenza A and B viruses to the neuraminidase inhibitor oseltamivir carboxylate was substantially improved in the SIAT1-transfected cell line and was consistent with their sensitivity in neuraminidase enzyme assay and with the hemagglutinin (HA) receptor-binding phenotype. MDCK cells stably transfected with SIAT1 may therefore be a suitable system for testing influenza virus sensitivity to NAI.     

High Yield Production of Influenza Virus in Madin Darby Canine Kidney (MDCK) Cells with Stable Knockdown of IRF7

Influenza is a serious public health problem that causes a contagious respiratory disease. Vaccination is the most effective strategy to reduce transmission and prevent influenza. In recent years, cell-based vaccines have been developed with continuous cell lines such as Madin-Darby canine kidney (MDCK) and Vero. However, wild-type influenza and egg-based vaccine seed viruses will not grow efficiently in these cell lines. Therefore, improvement of virus growth is strongly required for development of vaccine seed viruses and cell-based influenza vaccine production. The aim of our research is to develop novel MDCK cells supporting highly efficient propagation of influenza virus in order to expand the capacity of vaccine production. In this study, we screened a human siRNA library that involves 78 target molecules relating to three major type I interferon (IFN) pathways to identify genes that when knocked down by siRNA lead to enhanced production of influenza virus A/Puerto Rico/8/1934 in A549 cells. The siRNAs targeting 23 candidate genes were selected to undergo a second screening pass in MDCK cells. We examined the effects of knockdown of target genes on the viral production using newly designed siRNAs based on sequence analyses. Knockdown of the expression of a canine gene corresponding to human IRF7 by siRNA increased the efficiency of viral production in MDCK cells through an unknown process that includes the mechanisms other than inhibition of IFN-α/β induction. Furthermore, the viral yield greatly increased in MDCK cells stably transduced with the lentiviral vector for expression of short hairpin RNA against IRF7 compared with that in control MDCK cells. Therefore, we propose that modified MDCK cells with lower expression level of IRF7 could be useful not only for increasing the capacity of vaccine production but also facilitating the process of seed virus isolation from clinical specimens for manufacturing of vaccines.     

应用抑制性消减杂交技术筛选流感病毒感染宿主应答基因

从宿主系统寻找病毒感染特异性相关的生物大分子是研究病毒药物靶标和诊断标志物的新方向 .为了筛选宿主细胞中流感病毒感染特异性基因 ,采用抑制性消减杂交技术 (SSH) ,以流感病毒A 鲁防 93 9(H3N2 )感染MDCK细胞及正常MDCK细胞为材料 ,构建病毒感染特异性差减cDNA文库 ,PCR法扩增鉴定其中插入片段大小 .从差减文库中随机挑取 10 0个克隆进行测序 ,用生物信息学方法对其同源性和基因功能进行分析和预测 .结果显示 ,成功构建了流感病毒感染特异性差减cDNA文库 ,文库中cDNA片段长度在 2 5 0～ 10 0 0bp之间 .从文库中随机选取 10 0个克隆测序 ,获得了 95个有效序列 ,经blast同源性分析发现 ,大部分基因为参与宿主细胞能量代谢和蛋白质生物合成过程中的基因 ;其中 19个为无任何功能线索的新基因片段 .流感病毒感染特异性差减cDNA文库的建立和筛选出病毒感染应答候选新基因cDNA片段 ,为发现新型流感病毒药靶和诊断标志物以及病毒感染机制研究打下基础     

Modulation of glycosylation and transport of viral membrane glycoproteins by a sodium ionophore

Analysis of viral glycoprotein expression on surfaces of monensin- treated cells using a fluorescence-activated cell sorter (FACS) demonstrated that the sodium ionophore completely inhibited the appearance of the vesicular stomatitis virus (VSV) G protein on (Madin- Darby canine kidney) MDCK cell surfaces. In contrast, the expression of the influenza virus hemagglutinin (HA) glycoprotein on the surfaces of MDCK cells was observed to occur at high levels, and the time course of its appearance was not altered by the ionophore. Viral protein synthesis was not inhibited by monensin in either VSV- or influenza virus-infected cells. However, the electrophoretic mobilities of viral glycoproteins were altered, and analysis of pronase-derived glycopeptides by gel filtration indicated that the addition of sialic acid residues to the VSV G protein was impaired in monensin-treated cells. Reduced incorporation of fucose and galactose into influenza virus HA was observed in the presence of the ionophore, but the incompletely processed HA protein was cleaved, transported to the cell surface, and incorporated into budding virus particles. In contrast to the differential effects of monensin on VSV and influenza virus replication previously observed in monolayer cultures of MDCK cells, yields of both viruses were found to be significantly reduced by high concentrations of monensin in suspension cultures, indicating that cellular architecture may play a role in determining the sensitivity of virus replication to the drug. Nigericin, an ionophore that facilitates transport of potassium ions across membranes, blocked the replication of both influenza virus and VSV in MDCK cell monolayers, indicating that the ion specificity of ionophores influences their effect on the replication of enveloped viruses.     

Adaptation of high-growth influenza H5N1 vaccine virus in Vero cells: implications for pandemic preparedness

Current egg-based influenza vaccine production technology can't promptly meet the global demand during an influenza pandemic as shown in the 2009 H1N1 pandemic. Moreover, its manufacturing capacity would be vulnerable during pandemics caused by highly pathogenic avian influenza viruses. Therefore, vaccine production using mammalian cell technology is becoming attractive. Current influenza H5N1 vaccine strain (NIBRG-14), a reassortant virus between A/Vietnam/1194/2004 (H5N1) virus and egg-adapted high-growth A/PR/8/1934 virus, could grow efficiently in eggs and MDCK cells but not Vero cells which is the most popular cell line for manufacturing human vaccines. After serial passages and plaque purifications of the NIBRG-14 vaccine virus in Vero cells, one high-growth virus strain (Vero-15) was generated and can grow over 10(8) TCID(50)/ml. In conclusion, one high-growth H5N1 vaccine virus was generated in Vero cells, which can be used to manufacture influenza H5N1 vaccines and prepare reassortant vaccine viruses for other influenza A subtypes.     

MDCK细胞的悬浮驯化及初步应用

目的：驯化MDCK细胞使之适应悬浮培养,以之作为生产流感病毒疫苗的介质,为以细胞代替鸡胚制备流感病毒疫苗提供保证。方法：通过直接法和间接法分别驯化MDCK细胞,放大培养能悬浮生长的MDCK细胞,并以之作为介质培养流感病毒。结果：获得了能悬浮培养的MDCK细胞,其在悬浮条件下生长良好;以之作为载体培养流感病毒,可获得较高产量的病毒。结论：建立了悬浮培养的MDCK细胞,以之作为载体培养流感病毒可获得较高病毒滴度,为细胞培养生产流感病毒疫苗奠定了基础。     

用8质粒病毒拯救系统产生H9N2/WSN重组A型流行性感冒病毒

把禽流行性感冒(流感)病毒A／Chicken／Shanghai／F／98(H9N2)的血凝素(HA)和神经氨酸酶(NA)基因cDNA克隆至polⅠ-pol Ⅱ双向转录和表达载体pHW2000,用这两种质粒与8质粒病毒拯救系统中流感病毒A／WSN／33(H1N1)6个内部基因cDNA的质粒组合(6 2重排),共转染COS-1细胞,产生了能在鸡胚中高滴度增殖的H9N2／、WSN重组病毒。用A／WSN／33的8个基因cDNA质粒作对照,也产生了转染子病毒。经过EID50测定和MDCK感染实验,新基因型H9N2／WSN病毒感染鸡胚的能力强(EID50为10^-11／0．2m1),而且对鸡胚的毒力弱,在不加胰酶的情况下不使MDCK细胞产牛病变。经电镜观察,两个转染子病毒的形态与野生型流感病毒相似。反向遗传操作技术的建立,为对禽流感病毒基因功能和疫苗构建等方面的研究提供了新的手段。     

MDCK细胞微载体悬浮培养放大工艺研究

MDCK细胞对各种流感病毒具有高度敏感性,广泛应用于流感病毒的分离和疫苗制备.通过探索培养基中促进细胞贴壁的关键组分,并筛选水解物,开发了适合MDCK细胞生长的低血清培养基.发现钙、镁离子是细胞贴壁不可缺少的物质,麦麸水解物可以部分代替培养基中的血清.利用该低血清培养基,经过消化转移将MDCK细胞从5L反应器放大至25 L反应器,微载体上细胞贴附均匀、生长旺盛,25 L反应器中培养48 h细胞密度可达30.5×105 cells/ml.研究结果为工业规模反应器微载体悬浮培养MDCK细胞生产流感病毒奠定了基础.     

The expression of essential components for human influenza virus internalisation in Vero and MDCK cells

MDCK and Vero cell lines have been used as substrates for influenza virus replication. However, Vero cells produced lower influenza virus titer yield compared to MDCK. Influenza virus needs molecules for internalisation of the virus into the host cell, such as influenza virus receptor and clathrin. Human influenza receptor is usually a membrane protein containing Sia(α2,6) Gal, which is added into the protein in the golgi apparatus by α2,6 sialyltransferase (SIAT1). Light clathrin A (LCA), light clathrin B (LCB) and heavy clathrin (HC) are the main components needed for virus endocytosis. Therefore, it is necessary to compare the expression of SIAT1 and clathrin in Vero and MDCK cells. This study is reporting the expression of SIAT1 and clathrin observed in both cells with respect to the levels of (1) RNA by using RT-PCR, (2) protein by using dot blot analysis and confocal microscope. The results showed that Vero and MDCK cells expressed both SIAT1 and clathrin proteins, and the expression of SIAT1 in MDCK was higher compared to Vero cells. On the other hand, the expressions of LCA, LCB and HC protein in MDCK cells were not significantly different to Vero cells. This result showed that the inability of Vero cells to internalize H1N1 influenza virus was possibly due to the lack of transmembrane protein receptor which contained Sia(α2,6) Gal.     

Comparison of Different Cell Substrates on the Measurement of Human Influenza Virus Neutralizing Antibodies

Eight cell lines were systematically compared for their permissivity to primary infection, replication, and spread of seven human influenza viruses. Cell lines were of human origin (Caco-2, A549, HEp-2, and NCI-H292), monkey (Vero, LLC-MK2), mink (Mv1 Lu), and canine (MDCK). The influenza viruses included seasonal types and subtypes and a pandemic virus. The MDCK, Caco-2, and Mv1 Lu cells were subsequently compared for their capacity to report neutralization titers at day one, three and six post-infection. A gradient of sensitivity to primary infection across the eight cell lines was observed. Relative to MDCK cells, Mv1 Lu reported higher titers and the remaining six cell lines reported lower titers. The replication and spread of the seven influenza viruses in the eight cell substrates was determined using hemagglutinin expression, cytopathic effect, and neuraminidase activity. Virus growth was generally concordant with primary infection, with a gradient in virus replication and spread. However, Mv1 Lu cells poorly supported virus growth, despite a higher sensitivity to primary infection. Comparison of MDCK, Caco-2, and Mv1 Lu in neutralization assays using defined animal antiserum confirmed MDCK cells as the preferred cell substrate for influenza virus testing. The results observed for neutralization at one day post-infection showed MDCK cells were similar (<1 log₂ lower) or superior (>1 log₂ higher) for all seven viruses. Relative to Caco-2 and Mv1 Lu cells, MDCK generally reported the highest titers at three and six days post-infection for the type A viruses and lower titers for the type B viruses and the pandemic H9N2 virus. The reduction in B virus titer was attributed to the complete growth of type B viruses in MDCK cells before day three post-infection, resulting in the systematic underestimation of neutralization titers. This phenomenon was also observed with Caco-2 cells.     

Comparative Study of Influenza Virus Replication in MDCK Cells and in Primary Cells Derived from Adenoids and Airway Epithelium

Although clinical trials with human subjects are essential for determination of safety, infectivity, and immunogenicity, it is desirable to know in advance the infectiousness of potential candidate live attenuated influenza vaccine strains for human use. We compared the replication kinetics of wild-type and live attenuated influenza viruses, including H1N1, H3N2, H9N2, and B strains, in Madin-Darby canine kidney (MDCK) cells, primary epithelial cells derived from human adenoids, and human bronchial epithelium (NHBE cells). Our data showed that despite the fact that all tissue culture models lack a functional adaptive immune system, differentiated cultures of human epithelium exhibited the greatest restriction for all H1N1, H3N2, and B vaccine viruses studied among three cell types tested and the best correlation with their levels of attenuation seen in clinical trials with humans. In contrast, the data obtained with MDCK cells were the least predictive of restricted viral replication of live attenuated vaccine viruses in humans. We were able to detect a statistically significant difference between the replication abilities of the U.S. (A/Ann Arbor/6/60) and Russian (A/Leningrad/134/17/57) cold-adapted vaccine donor strains in NHBE cultures. Since live attenuated pandemic influenza vaccines may potentially express a hemagglutinin and neuraminidase from a non-human influenza virus, we assessed which of the three cell cultures could be used to optimally evaluate the infectivity and cellular tropism of viruses derived from different hosts. Among the three cell types tested, NHBE cultures most adequately reflected the infectivity and cellular tropism of influenza virus strains with different receptor specificities. NHBE cultures could be considered for use as a screening step for evaluating the restricted replication of influenza vaccine candidates.     

Homologous interference mediated by defective interfering influenza virus derived from a temperature-sensitive mutant of influenza virus.

A temperature-sensitive group II mutant of influenza virus, ts-52, with a presumed defect in viral RNA synthesis, readily produced von Magnus-type defective interfering virus (DI virus) when passed serially (four times) at high multiplicity in MDBK cells. The defective virus (ts-52 DI virus) had a high hemagglutinin and a low infectivity titer, and strongly interfered with the replication of standard infectious viruses (both ts-52 and wild-type ts+) in co-infected cells. Progeny virus particles produced by co-infection of DI virus and infectious virus were also defective and also had low infectivity, high hemagglutinating activity, and a strong interfering property. Infectious viruses ts+ and ts-52 were indistinguishable from ts-52 DI viruses by sucrose velocity or density gradient analysis. Additionally, these viruses all possessed similar morphology. However, when the RNA of DI viruses was analyzed by use of polyacrylamide gels containing 6 M urea, there was a reduction in the amount of large RNA species (V1 to V4), and a number of new smaller RNA species (D1 to D6) with molecular weights ranging from 2.9 X 10(5) to 1.05 X 10(5) appeared. Since these smaller RNA species (D1 to D6) were absent in some clones of infectious viruses, but were consistently associated with DI viruses and increased during undiluted passages and during co-infection of ts-52 with DI virus, they appeared to be a characteristic of DI viruses. Additionally, the UV target size of interfering activity and infectivity of DI virus indicated that interfering activity was 40 times more resistant to UV irradiation than was infectivity, further implicating small RNA molecules in interference. Our data suggest that the loss of infectivity observed among DI viruses may be due to nonspecific loss of a viral RNA segment(s), and the interfering property of DI viruses may be due to interfering RNA segments (DIRNA, D1 to D6). ts-52 DI virus interfered with the replication of standard virus (ts+) at both permissive (34 degrees C) and nonpermissive temperatures. The infectivity of the progeny virus was reduced to 0.2% for ts+ and 0.05% for ts-52 virus without a reduction in hemagglutinin titer. Interference was dependent on the concentration of DI virus. A particle ratio of 1 between DI virus (0.001 PFU/cell) and infectious virus (1.0 PFU/cell) produced a maximal amount of interference. Infectious virus yield was reduced 99.9% without any reduction of the yield of DI viruses Interference was also dependent on the time of addition of DI virus. Interference was most effective within the first 3 h of infection by infectious virus, indicating interference with an early function during viral replication.     

Differential effect of monensin on enveloped viruses that form at distinct plasma membrane domains

We have observed a striking differential effect of the ionophore, monensin, on replication of influenza virus and vesicular stomatitis virus (VSV) in Madin-Darby canine kidney (MDCK) and baby hamster kidney (BHK21) cells. In MDCK cells, influenza virus is assembled at the apical surfaces, whereas VSV particles bud from the basolateral membranes; no such polarity of maturation is exhibited in BHK21 cells. A 10(-6) M concentration of monensin reduces VSV yields in MDCK cells by greater than 90% as compared with controls, whereas influenza virus yields are unaffected. In BHK21 cells, monensin also inhibits VSV production, but influenza virus is also sensitive to the ionophore. Immunofluorescent staining of fixed and unfixed MDCK monolayers indicates that VSV glycoproteins are synthesized in the presence of monensin, but their appearance on the plasma membrane is blocked. Electron micrographs of VSV-infected MDCK cells treated with monensin show VSV particles aggregated within dilated cytoplasmic vesicles. Monensin-treated influenza virus-infected MDCK cells also contain dilated cytoplasmic vesicles, but virus particles were not found in these structures, and numerous influenza virions were observed budding at the cell surface. These results indicate that influenza virus glycoprotein transport is not blocked by monensin treatment, whereas there is a block in transport of VSV G protein. Thus it appears that at least two distinct pathways of transport of glycoproteins to the plasma membrane exist in MDCK cells, and only one of them is blocked by monensin.     

MDCK and Vero cells for influenza virus vaccine production: a one-to-one comparison up to lab-scale bioreactor cultivation

Over the last decade, adherent MDCK (Madin Darby canine kidney) and Vero cells have attracted considerable attention for production of cell culture-derived influenza vaccines. While numerous publications deal with the design and the optimization of corresponding upstream processes, one-to-one comparisons of these cell lines under comparable cultivation conditions have largely been neglected. Therefore, a direct comparison of influenza virus production with adherent MDCK and Vero cells in T-flasks, roller bottles, and lab-scale bioreactors was performed in this study. First, virus seeds had to be adapted to Vero cells by multiple passages. Glycan analysis of the hemagglutinin (HA) protein showed that for influenza A/PR/8/34 H1N1, three passages were sufficient to achieve a stable new N-glycan fingerprint, higher yields, and a faster increase to maximum HA titers. Compared to MDCK cells, virus production in serum-free medium with Vero cells was highly sensitive to trypsin concentration. Virus stability at 37 °C for different virus strains showed differences depending on medium, virus strain, and cell line. After careful adjustment of corresponding parameters, comparable productivity was obtained with both host cell lines in small-scale cultivation systems. However, using these cultivation conditions in lab-scale bioreactors (stirred tank, wave bioreactor) resulted in lower productivities for Vero cells.     

Defective interfering influenza viruses and host cells: establishment and maintenance of persistent influenza virus infection in MDBK and HeLa cells.

WSN (H0N1) influenza virus upon undiluted passages in different species of cells, namely, bovine kidney (MDBK), chicken embryo (CEF), and HeLa cells, produced a varying amount of defective interfering (DI) virus which correlated well with the ability of the species of cell to produce infectious virus. However, the nature of the influenza DI viral RNA produced from a single clonal stock was essentially identical in all three cells types, suggesting that these cells do not exert a great selective pressure in the amplification of specific DI viral RNAs either at early or late passages. DI viruses produced from one subtype (H0N1) could interfere with the replication of infectious viruses belonging to other subtypes (H1N1, H3N2). DI viral RNAs could also replicate with the helper function of other subtype viruses. The persistent infection of MDBK and HeLa cells could be initiated by coinfecting cells with both temperature-sensitive mutants (ts-) and DI influenza viruses. Persistently infected cultures cultures at early passages (up to passage 7) showed a cyclical pattern of cell lysis and virus production (crisis), whereas, at later passages (after passage 20), they produced little or no virus and were resistant to infection by homologous virus but not by heterologous virus. The majority of persistently infected cells, however, contained the complete viral genome since they expressed viral antigens and produced infectious centers. Selection of a slow-growing temperature-sensitive variant rather than the presence of DI virus or interferon appears to be critical in maintaining persistent influenza infection in these cells.