Effect of seed sludge and operation conditions on performance and archaeal community structure of low-temperature anaerobic solvent-degrading bioreactors

Two laboratory-scale expanded granular sludge bed (EGSB) anaerobic bioreactors (R1 and R2) were inoculated with biomass from different mesophilic (37 °C) treatment plants, and used for the treatment of an organic solvent-based wastewater at 9–14 °C at applied organic loading rates (OLRs) of 1.2–3.6 kg chemical oxygen demand (COD) m⁻³ d⁻¹. Replicated treatment performance was observed at 10–14 °C, which suggested the feasibility of the process at pilot-scale. Stable and efficient COD removal, along with high methane productivity, was demonstrated at 9 °C at an applied OLR of 2.4 kg COD m⁻³ d⁻¹. Clonal libraries and fluorescence in situ hybridization (FISH) indicated that the seed sludges were dominated (>60%) by acetoclastic Methanosaeta-like organisms. Specific methanogenic activity (SMA) profiles indicated shifts in the physiological profiles of R1 and R2 biomass, including the development of psychrotolerant methanogenic activity. Acetoclastic methanogenesis represented the primary route of methane production in R1 and R2, which is in contrast with several previous reports from low-temperature bioreactor trials. A reduction in the abundance of Methanosaeta-like clones (R2), along with the detection of hydrogenotrophic methanogenic species, coincided with altered granule (sludge) morphology and the development of hydrogenotrophic SMA after prolonged operation at 9 °C.     

Laboratory scale examination of the effects of overloading on the anaerobic digestion by glycerol

The anaerobic digestion of pure glycerol, which produces a baseline acetic acid to propionic acid ratio of 0.2, was studied in laboratory scale reactors (3 l working volume) at mesophilic temperature (37 °C) with 3000 mg chemical oxygen demand (COD) l⁻¹d⁻¹. During the experiment tVFA and C2-C6 VFA analysis and daily biogas yield measurement were carried out. Following 10 days of a 15% d⁻¹ increase in the organic loading rate (OLR) of 3.0-10.5 g COD l⁻¹d⁻¹, the concentration of propionic acid increased to 6200-8000 mg l⁻¹. Then the inoculum was divided into three parts feeding with 100% glycerol, 50% glycerol + 50% acetic acid, and 50% glycerol + 50% thick stillage, (presented in % of 2.60 g COD l⁻¹d⁻¹ OLR), respectively. The application of co-substrates reduced the recovery period by 5 days compared to feeding with pure glycerol. When the reactors were loaded with glycerol again (10% OLR raise per day) the previously applied co-substrates had a positive effect on the VFA composition and the biogas yield as well.     

Evaluation of the hydrolytic–acidogenic step of a two-stage mesophilic anaerobic digestion process of sunflower oil cake

The influence of the hydraulic retention time (HRT) and organic loading rate (OLR) on the performance of the hydrolytic–acidogenic step of a two-stage anaerobic digestion process of sunflower oil cake (SuOC) were assessed. The experiments were performed in laboratory-scale completely stirred tank reactors at mesophilic (35 °C) temperature. Six OLR (ranging from 4 to 9 g VS L⁻¹ d⁻¹) for four HRTs (8, 10, 12 and 15 days) were tested to check the effect of each operational variable. Based on the results obtained, it can be concluded that the hydrolysis yields obtained for all HRTs and OLRs assayed were in the range of 20.5–30.1%. In addition, the acidification degree of the substrate was mainly influenced by the OLR but not by the HRTs, the highest value (83.8%) being achieved for an HRT of 10 days and an OLR of 6 g VS L⁻¹ d⁻¹.     

Potential for methane production from anaerobic co-digestion of swine manure with winery wastewater

This work examines the methane production potential for the anaerobic co-digestion of swine manure (SM) with winery wastewater (WW). Batch and semi-continuous experiments were carried out under mesophilic conditions. Batch experiments revealed that the highest specific methane yield was 348 mL CH₄ g⁻¹ COD added, obtained at 85.4% of WW and 0.7 g COD g⁻¹ VS. Specific methane yield from SM alone was 27 mL CH₄ g⁻¹ COD added d⁻¹. Furthermore, specific methane yields were 49, 87 and 107 mL CH₄ g⁻¹ COD added d⁻¹ for the reactors co-digesting mixtures with 10% WW, 25% WW and 40% WW, respectively. Co-digestion with 40% WW improved the removal efficiencies up to 52% (TCOD), 132% (SCOD) and 61% (VSS) compared to SM alone. These results suggest that methane can be produced very efficiently by the co-digestion of swine manure with winery wastewater.     

Feasibility of biogas production from anaerobic co-digestion of herbal-extraction residues with swine manure

The objective of this work was to examine the feasibility of biogas production from the anaerobic co-digestion of herbal-extraction residues with swine manure. Batch and semi-continuous experiments were carried out under mesophilic anaerobic conditions. Batch experiments revealed that the highest specific biogas yield was 294 mL CH₄ g⁻¹ volatile solids added, obtained at 50% of herbal-extraction residues and 3.50 g volatile solids g⁻¹ mixed liquor suspended solids. Specific methane yield from swine manure alone was 207 mL CH₄ g⁻¹ volatile solid added d⁻¹ at 3.50 g volatile solids g⁻¹ mixed liquor suspended solids. Furthermore, specific methane yields were 162, 180 and 220 mL CH₄ g⁻¹ volatile solids added d⁻¹ for the reactors co-digesting mixtures with 10%, 25% and 50% herbal-extraction residues, respectively. These results suggested that biogas production could be enhanced efficiently by the anaerobic co-digestion of herbal-extraction residues with swine manure.     

Vertical tubular photobioreactor for semicontinuous culture of Cyanobium sp

We evaluated the kinetic culture characteristics of the microalgae Cyanobium sp. grown in vertical tubular photobioreactor in semicontinuous mode. Cultivation was carried out in vertical tubular photobioreactor for 2 L, in 57 d, at 30 °C, 3200 Lux, and 12 h light/dark photoperiod. The maximum specific growth rate was found as 0.127 d⁻¹, when the culture had blend concentration of 1.0 g L⁻¹, renewal rate of 50%, and sodium bicarbonate concentration of 1.0 g L⁻¹. The maximum values of productivity (0.071 g L⁻¹ d⁻¹) and number of cycles (10) were observed in blend concentration of 1.0 g L⁻¹, renewal rate of 30%, and bicarbonate concentration of 1.0 g L⁻¹. The results showed the potential of semicontinuous cultivation of Cyanobium sp. in closed tubular bioreactor, combining factors such as blend concentration, renewal rate, and sodium bicarbonate concentration.     

Autotrophic denitrification using hydrogen generated from metallic iron corrosion

Hydrogenotrophic denitrification was demonstrated using hydrogen generated from anoxic corrosion of metallic iron. For this purpose, a mixture of hydrogenated water and nitrate solution was used as reactor feed. A semi-batch reactor with nitrate loading of 2000 mg m⁻³ d⁻¹ and hydraulic retention time (HRT) of 50 days produced effluent with nitrate concentration of 0.27 mg N L⁻¹ (99% nitrate removal). A continuous flow reactor with nitrate loading of 28.9 mg m⁻³ d⁻¹ and HRT of 15.6 days produced effluent with nitrate concentration of ∼0.025 mg N L⁻¹ (95% nitrate removal). In both cases, the concentration of nitrate degradation by-products, viz., ammonia and nitrite, were below detection limits. The rate of denitrification in the reactors was controlled by hydrogen availability, and hence to operate such reactors at higher nitrate loading rates and/or lower HRT than reported in the present study, hydrogen concentration in the hydrogenated water must be significantly increased.     

The role of phase separation and feed cycle length in leach beds coupled to methanogenic reactors for digestion of a solid substrate (Part 1): Optimisation of reactors' performance

A two-phase system composed by a leach bed and a methanogenic reactor was modified for the first time to improve volumetric substrate degradation and methane yields from a complex substrate (maize; Zeamays). The system, which was operated for consecutive feed cycles of different durations for 120 days, was highly flexible and its performance improved by altering operational conditions. Daily substrate degradation was higher the shorter the feed cycle, reaching 8.5 g TS_destroyed d⁻¹ (7-day feed cycle) but the overall substrate degradation was higher by up to 55% when longer feed cycles (14 and 28 days) were applied. The same occurred with volumetric methane yields, reaching 0.839 m³ (m³)⁻¹ d⁻¹. The system performed better than others on specific methane yields, reaching 0.434 m³ kg⁻¹ TS_added, in the 14-day and 28-day systems. The UASB and AF designs performed similarly as second stage reactors on methane yields, SCOD and VFA removal efficiencies.     

Electricity generation in single-chamber microbial fuel cells using a carbon source sampled from anaerobic reactors utilizing grass silage

Production of electricity from samples obtained during anaerobic digestion of grass silage was examined using single-chamber air-cathode mediator-less microbial fuel cells (MFCs). The samples were obtained from anaerobic reactors at start-up conditions after 3 and 10 days of operation under psychrophilic (15 °C) and mesophilic (37 °C) temperatures. Electricity was directly produced from all samples at a concentration of 1500 mg COD L⁻¹. Power density obtained from the samples, as a sole carbon source, ranged from 56 ± 3 W m⁻³ to 31 ± 1 W m⁻³ for the mesophilic and psychrophilic samples, respectively. Coulombic efficiencies ranged from 18 ± 1% to 12 ± 1% for the same samples. The relationship between the maximum voltage output and initial COD concentration appeared to follow saturation kinetics at the external resistance of 217 Ω. Chemical oxygen demand (COD) removal was over 90% and total phenolics removal was in the range of 30-75% for all samples tested, with a standard amount of 60 mg L⁻¹ total phenolics removed for every sample. Our results indicate that generating electricity from solution samples of anaerobic reactors utilizing grass silage is possible, opening the possibility for combination of anaerobic digestion with MFC technology for energy generation.     

Cultivation of microalgae for oil production with a cultivation strategy of urea limitation

The microalgae, Chlorella sp., were cultivated in various culture modes to assess biomass and lipid productivity in this study. In the batch mode, the biomass concentrations and lipid content of Chlorella sp. cultivated in a medium containing 0.025–0.200 g L⁻¹ urea were 0.464–2.027 g L⁻¹ and 0.661–0.326 g g⁻¹, respectively. The maximum lipid productivity of 0.124 g d⁻¹ L⁻¹ occurred in a medium containing 0.100 g L⁻¹ urea. In the fed-batch cultivation, the highest lipid content was obtained by feeding 0.025 g L⁻¹ of urea during the stationary phase, but the lipid productivity was not significantly increased. However, a semi-continuous process was carried out by harvesting the culture and renewing urea at 0.025 g L⁻¹ each time when the cultivation achieved the early stationary phase. The maximum lipid productivity of 0.139 g d⁻¹ L⁻¹ in the semi-continuous culture was highest in comparison with those in the batch and fed-batch cultivations.     

Modelling mono-digestion of grass silage in a 2-stage CSTR anaerobic digester using ADM1

This paper examines 174 days of experimental data and modelling of mono-digestion of grass silage in a two stage wet process with recirculation of liquor; the two vessels have an effective volume of 312 L each. The organic loading rate is initiated at 0.5 kg VS m⁻³ d⁻¹ (first 74 days) and subsequently increased to 1 kg VS m⁻³ d⁻¹. The experimental data was used to generate a mathematical model (ADM1) which was calibrated over the first 74 days of operation. Good accuracy with experimental data was found for the subsequent 100 days. Results of the model would suggest starting the process without recirculation and thus building up the solids content of the liquor. As the level of VFA increases, recirculation should be employed to control VFA. Recirculation also controls solids content and pH. Methane production was estimated at 88% of maximum theoretical production.     

Seed germination of Lasia spinosa as a function of temperature,light, desiccation,and storage

Lasia spinosa seeds were not dormant at maturity in early spring. The most favorable temperatures for germination were between 25 and 30 °C, and final percentage and rate of germination decreased with an increase or decrease in temperature. When L. spinosa seeds were transferred to 25 °C, after 60 days at 10 °C (where none of the seeds germinated), final germination increased from 0% to 78%. Seeds germinated to high percentage both in light and in dark, although dark germination took more than twice as long as in the light. During desiccation of seeds at 15 °C and 45% relatively humidity, moisture loss decreased exponentially from 2.02 to 0.13 g H₂O g⁻¹ dry wt within 16 days, and only a few seeds (12%) survived 0.13 g H₂O g⁻¹ dry wt moisture content. Seeds stored at 0.58 g H₂O g⁻¹ dry wt moisture content at four constant temperatures (4, 10, 15, and −18 °C) for up to 6 months exhibited a well-defined trend of decreasing viability with decreasing temperature. Thus, we concluded that freshly harvested L. spinosa seeds are non-dormant and recalcitrant. Also, the seeds with 0.58 g H₂O g⁻¹ dry wt moisture content could be effectively stored for a few months between 10 and 15 °C although the most appropriate temperature for wet storage appears to be 10 °C, as it is close to the minimum temperature for germination and so there will be less pre-sprouting compared to 15 °C.     

The treatment of cheese whey wastewater by sequential anaerobic and aerobic steps in a single digester at pilot scale

The treatment of reconstituted whey wastewater was performed in a 400 L digester at 20 °C, with an anaerobic digestion step, followed by a step of aerobic treatment at low oxygen concentration in the same digester. In a first set of 48 cycles, total cycle time (T_C) of 2, 3 and 4 days were tested at varying organic loading rates (OLR). The COD removal reached 89 ± 4, 97 ± 3 and 98 ± 2% at T_C of 2, 3 and 4 days and OLR of 0.56, 1.04 and 0.78 gCOD L⁻¹ d⁻¹, respectively. The activity of the biomass decreased for the methanogenic population, while increasing by 400% for the acidogens, demonstrating a displacement in the predominant trophic group in the biomass bed. A second set of 16 cycles was performed with higher soluble oxygen concentration in the bulk liquid (0.5 mg L⁻¹) during the aerobic treatment at a T_C of 2 days and an OLR of 1.55 gCOD L⁻¹ d⁻¹, with a soluble COD removal of 88 ± 3%. The biomass specific activities showed a compartmentalization of the trophic group with methanogenic activity maintained in the biomass bed and a high acidogenic activity in the suspended flocs.     

Reevaluation of the nutrient mineralization process by infaunal bivalves (Ruditapes philippinarum) in a shallow lagoon in Hokkaido, Japan

Previous estimations of nutrient mineralization in the water column by infaunal bivalves might have been overestimated because of underestimation of the uptake process by microphytobenthos in the field. We conducted field surveys of environmental conditions and quantitative sampling of Ruditapes philippinarum in a shallow lagoon system (Hichirippu Lagoon, eastern Hokkaido, Japan) in August 2006. We recorded the spatial distribution pattern and the molar ratio of dissolved inorganic nutrients to determine the limiting nutrients for microphytobenthos, to evaluate the input and output of nutrients at the entrance of the lagoon station, and to estimate potential nutrient mineralization by R. philippinarum. Our aim was to reevaluate the nutrient mineralization process by infaunal bivalve species. In this study, the mean standing stock of microphytobenthos inhabiting surface sediment (5 mm thick) on the tidal flats was 100 times higher than that of phytoplankton (1 m depth). Low N/P and high Si/N ratios (mean = 2.6 and 17.6, respectively) near the entrance of the lagoon compared to those of microphytobenthos (N:P:Si = 10.1:1:18) clearly suggest N deficiency. The flux of NH₄-N coming into the lagoon was 3.4 kmolN d^− 1, and the flux out was − 3.7 kmolN d^− 1. Thus, assuming that there would have been no phytoplankton and microphytobenthos uptake during the day, 0.3 kmolN d^− 1 of NH₄-N was produced within the lagoon. However, the NH₄-N mineralization rate of the clams has been estimated to be approximately 7.7 ± 6.8 kmolN d^− 1. Thus, 96% (7.4 kmolN d^− 1, i.e., 7.7 kmolN d^− 1 minus 0.3 kmolN d^− 1) of the NH₄-N mineralized by the clam was consumed by microphytobenthos. In contrast, if all the NH₄-N inflow (3.1 kmolN d^− 1) was consumed by the microalgae before outflow, 52% (4.0 kmolN d^− 1, i.e., 7.7 kmolN d^− 1 minus 3.7 kmolN d^− 1) of the NH₄-N mineralized by the clams should have been consumed by microphytobenthos. Microphytobenthos on the tidal flats (11.3 ± 11.8 kmolN) used all of the surplus nutrients (between 4.0 and 7.4 kmolN d^− 1), and the temporal division rate [=(NH₄-N uptake)/(standing stock of microphytobenthos)] of microphytobenthos would have to be between 0.35 and 0.65 d^− 1. Residual NH₄-N (0.3 - 3.7 kmolN d^− 1) was the water-column source and accounted for 12-148% of NH₄-N in the water column near the entrance of the lagoon (2.5 ± 1.4 kmolN) per day. This is the first field-based observation with a quantitative evaluation of nutrient mineralization by infaunal bivalves and nutrient uptake by microphytobenthos.     

Influence of ammonium sulphate feeding time on fed-batch Arthrospira (Spirulina) platensis cultivation and biomass composition with and without pH control

Previous work demonstrated that a mixture of NH₄Cl and KNO₃ as nitrogen source was beneficial to fed-batch Arthrospira (Spirulina) platensis cultivation, in terms of either lower costs or higher cell concentration. On the basis of those results, this study focused on the use of a cheaper nitrogen source mixture, namely (NH₄)₂SO₄ plus NaNO₃, varying the ammonium feeding time (T = 7-15 days), either controlling the pH by CO₂ addition or not. A. platensis was cultivated in mini-tanks at 30 °C, 156 μmol photons m⁻² s⁻¹, and starting cell concentration of 400 mg L⁻¹, on a modified Schlösser medium. T = 13 days under pH control were selected as optimum conditions, ensuring the best results in terms of biomass production (maximum cell concentration of 2911 mg L⁻¹, cell productivity of 179 mg L⁻¹ d⁻¹ and specific growth rate of 0.77 d⁻¹) and satisfactory protein and lipid contents (around 30% each).     

Aerobic granular sludge formation for high strength agro-based wastewater treatment

The present study investigates the formation of aerobic granular sludge in sequencing batch reactor (SBR) fed with palm oil mill effluent (POME). Stable granules were observed in the reactor with diameters between 2.0 and 4.0 mm at a chemical oxygen demand (COD) loading rate of 2.5 kg COD m⁻³ d⁻¹. The biomass concentration was 7600 mg L⁻¹ while the sludge volume index (SVI) was 31.3 mL g SS⁻¹ indicating good biomass accumulation in the reactor and good settling properties of granular sludge, respectively. COD and ammonia removals were achieved at a maximum of 91.1% and 97.6%, respectively while color removal averaged at only 38%. This study provides insights on the development and the capabilities of aerobic granular sludge in POME treatment.     

Does scope for growth change as a result of salinity stress in the amphipod Gammarus oceanicus?

Physiological performance (feeding, metabolism, growth and excretion) across a broad range of salinity (5-30 psu) were determined for the benthic amphipod Gammarus oceanicus, a species of marine origin inhabiting brackish waters of the southern Baltic Sea. Feeding rates decreased with increasing salinity, whereas the nutritive absorption efficiency increased. Faeces production and ammonia excretion rates decreased strongly from the lowest to the highest salinity by 60% and 58%, respectively. Increasing salinity was accompanied by a reduction in the metabolic rate from 438 J g^− 1 dry wt d^− 1 (5.1 mW g^− 1) at 5 psu to 245 J g^− 1 (2.8 mW g^− 1) at 30 psu. Individuals were able to maintain a positive energy balance at all experimental salinities. The greatest values for scope for growth were recorded at the environmental salinity (7 psu) with a mean of 769 J g^− 1 dry wt d^− 1 (8.7 mW g^− 1).     

Treatment of industrial wastewater with two-stage constructed wetlands planted with Typha latifolia and Phragmites australis

Industrial wastewater treatment comprises several processes to fulfill the discharge permits or to enable the reuse of wastewater. For tannery wastewater, constructed wetlands (CWs) may be an interesting treatment option. Two-stage series of horizontal subsurface flow CWs with Phragmites australis (UP series) and Typha latifolia (UT series) provided high removal of organics from tannery wastewater, up to 88% of biochemical oxygen demand (BOD₅) (from an inlet of 420 to 1000 mg L⁻¹) and 92% of chemical oxygen demand (COD) (from an inlet of 808 to 2449 mg L⁻¹), and of other contaminants, such as nitrogen, operating at hydraulic retention times of 2, 5 and 7 days. No significant (P < 0.05) differences in performance were found between both the series. Overall mass removals of up to 1294 kg COD ha⁻¹ d⁻¹ and 529 kg BOD₅ ha⁻¹ d⁻¹ were achieved for a loading ranging from 242 to 1925 kg COD ha⁻¹ d⁻¹ and from 126 to 900 kg BOD₅ ha⁻¹ d⁻¹. Plants were resilient to the conditions imposed, however P. australis exceeded T. latifolia in terms of propagation.     

Evaluation of a lab-scale tidal flow constructed wetland performance: Oxygen transfer capacity, organic matter and ammonium removal

Oxygen transfer capacity and removal of ammonium and organic matter were investigated in this study to evaluate the performance of a lab-scale tidal flow constructed wetland. Average oxygen supply under tidal operation (350 g m⁻² d⁻¹) was much higher than in conventional constructed wetlands (<100 g m⁻² d⁻¹), resulting in enhanced removal of BOD₅ and NH₄⁺. Theoretical oxygen demand from BOD₅ removal and nitrification was approximately matched by the measured oxygen supply, which indicated aerobic consumption of BOD₅ and NH₄⁺ under tidal operation. When BOD₅ removal increased from 148 g m⁻² d⁻¹ to 294 g m⁻² d⁻¹, neither exhausted oxygen from the aggregate matrix during feeding period (111 g m⁻² d⁻¹) nor effluent dissolved oxygen (DO) concentration (2.8 mg/L) changed significantly, demonstrating that the oxygen transfer potential of the treatment system had not been exceeded. However, even though DO had not been exhausted, inhibition of nitrification was observed under high BOD loading. The loss of nitrification was attributed to excessive heterotrophic biofilm growth believed to induce oxygen transfer limitations or oxygen competition in thickened biofilms.     

Two-stage anaerobic digestion of biodegradable municipal solid waste using a rotating drum mesh filter bioreactor and anaerobic filter

A rotating drum mesh filter bioreactor (RDMFBR) with a 100 μm mesh coupled to an anaerobic filter was used for the anaerobic digestion of biodegradable municipal solid waste (BMW). Duplicate systems were operated for 72 days at an organic loading rate (OLR) of 7.5 gVS l⁻¹ d⁻¹. Early in the experiment most of the methane was produced in the 2nd stage. This situation gradually reversed as methanogenesis became established in the 1st stage digester, which eventually produced 86–87% of the total system methane. The total methane production was 0.2 l g⁻¹ VS_added with 60–62% volatile solids destruction. No fouling was experienced during the experiment at a transmembrane flux rate of 3.5 l m⁻² h⁻¹. The system proved to be robust and stably adjusted to a shock loading increase to 15 gVS l⁻¹ d⁻¹, although this reduced the overall methane production to 0.15 l g⁻¹ VS_added.