Effect of acidic treatment of the chemical composition and bacterial oxidation of arsenic-bearing gold concentrate

Effect of acidic pretreatment of arsenic-bearing gold concentrate, a promising gold source, on its chemical composition and efficiency of its bacterial oxidation (BO) was studied. The titer of sulfobacilli during BO of the concentrate after high-temperature acidic treatment was 9.0 × 10⁷ cells/ml, the degree of arsenic sulfide oxidation being 71.1%, and in the control, 6.5 × 10⁷ cells/ml with the oxidation degree as low as 48.7%. Deeper oxidation of the main gold-containing mineral, arsenic sulfide, would allow more efficient gold recovery from the concentrate.     

A Biosurfactant-Producing Pseudomonas aeruginosa Strain

A Pseudomonas aeruginosa strain producing an extracellular surfactant (biosurfactant) was isolated. The growth of this strain, referred to as 50.3, on a mineral glycerol-containing medium produces an emulsifying activity (60%) and decreases the surface tension of the culture liquid by a factor of 2.8 (to 25 mN/m). The optimum conditions for its growth and production of biosurfactants are intense aeration, pH 7.0–8.0, and the presence of Mg²⁺. The optimum biosurfactant properties were achieved when glucose was used as the only source of carbon and energy and NH₄Cl was used as a source of nitrogen. The biosurfactant was isolated from the culture liquid by extraction and precipitation.     

Biodegradation of cyanides, cyanates and thiocyanates to ammonia and carbon dioxide by immobilized cells of Pseudomonas putida

Pseudomonas putida utilizes cyanide as the sole source of carbon and nitrogen. Agar, alginate, and carrageenan were screened as the encapsulating matrices for P. putida. Alginate-immobilized cells of P. putida degraded sodium cyanide (NaCN) more efficiently than non-immobilized cells or cells immobilized in agar or carrageenan. The end products of biodegradation of cyanide were identified as ammonia (NH₃) and carbon dioxide (CO₂). These products changed the medium pH. In bioreactors, the rate of cyanide degradation increased with an increase in the rate of aeration. Maximum utilization of cyanide was observed at 200 ml min⁻¹ of aeration. Immobilized cells of P. putida degraded cyanides, cyanates and thiocyanates to NH₃ and CO₂. Use of Na[¹⁴C]-CN showed that 70% of carbon of Na[¹⁴C]-CN was converted into ¹⁴CO₂ and only 10% was associated with the cell biomass. The substrate-dependent kinetics indicated that the K _m and V _max values of P. putida for the substrate, NaCN were 14 mM and 29 nmol of oxygen consumed mg protein⁻¹ min⁻¹ respectively. Received 29 January 1996/ Accepted in revised form 19 September 1997     

Effects of anoxia and inhibitors of energy metabolism on potassium and sodium homeostasis in neurons of gastropod mollusk

The effect of anoxia and inhibitors of energy metabolism on intracellular concentrations of potassium and sodium, membrane potentials, permeability, active and passive ouabain-sensitive transport of potassium (determined with⁸⁶Rb) was studied in neurons of the freshwater planorbis mollusk (Planorbarius corneus). X-ray microanalysis showed that incubation of isolated ganglia in oxygen-free medium induced no change in intracellular concentrations of potassium and sodium. In the presence of cyanide, absorption of oxygen by the ganglia ceased, but accumulation of⁸⁶Rb decreased insignificantly. The membrane potential and permeability did not depend on addition of cyanide. Desoxyglucose, an inhibitor of glycolysis, decreased⁸⁶Rb accumulation more than cyanide did. In the presence of inhibitors of both glycolysis and respiration, which excluded the possibility of mutual compensation of oxidation and glycolytic sources of energy supply,⁸⁶Rb accumulation decreased to the highest degree. A hypothesis was formulated on the paramount importance of glycolytic ATP for maintaining ion homeostasis of the nerve cells. The problem of functionally facilitated compartmentation of intracellular energy sources is discussed.Institute of Evolutionary Physiology and Biochemistry, Academy of Sciences of the USSR, Leningrad. Translated from Neirofiziologiya, Vol. 23, No. 3, pp. 313–321, May–June, 1991.     

Role of cell attachment in leaching of chalcopyrite mineral by Thiobacillus ferrooxidans

Summary Experiments on the leaching of copper from chalcopyrite mineral by the bacterium Thiobacillus ferrooxidans show that, in the presence of adequate amounts of sulphide, iron-grown bacteria preferentially oxidise sulphur in the ore (through direct attachment) rather than ferrous sulphate in solution. At 20% pulp density, the leaching initially takes place by a predominantly direct mechanism. The cell density in the liquid phase increases, but the Fe²⁺ is not oxidised. However, in the later stages when less solid substrate is available and the cell density becomes very high, the bacteria start oxidising Fe²⁺ in the liquid phase, thus contributing to the indirect mechanism of leaching. Contrary to expectations, the rate of leaching increased with increasing particle size in spite of the decreasing specific surface area. This has been found to be due to increasing attachment efficiency with increase in particle size. Offprint requests to: R. Kumar     

Oxidation of stibnite byThiobacillus ferrooxidans

Optimum pH, temperature and pulp density for microbiological leaching of museum-grade stibnite mineral has been investigated using a stibnite-adapted strain ofThiobacillus ferrooxidans. Optimum conditions were found to be pH 1.75, 35 C and 12 g solid substrate per 100 ml of basal salts medium as the initial dose. The energy of activation was determined to be 16.8 kcal per mole, and the temperature coefficient 2.2. The highest total dissolved-antimony concentration, [Sb_t] = [Sb⁺³] + [Sb⁺⁵] + [SbO⁺] + [SbO₂ ⁺], was about 1400 mg/litre, due to relatively low solubility of (SbO)₂SO₄ and (SbO₂)₂SO₄.     

Stimulation of heterotrophic and autotrophic growth ofSphaerotilus discophorus by manganous ions

Growth ofS. discophorus in a casamino acids-mineral salts medium was stimulated 3-fold on addition of 0.05% MnSO₄·H₂O to the medium. Growth was measured by determinations of total nitrogen, protein and DNA on the washed cellular material.Autotrophic growth ofS. discophorus strain 43-R was obtained in an inorganic mineral salts medium supplemented with trace amounts of the essential vitamins, thiamin, biotin and cyanocobalamin and with Mn⁺⁺ as the sole available source of energy. A gas mixture of 5% CO₂-95% air was bubbled continuously through the cultures during incubation. Concomitant with growth, Mn⁺⁺ disappeared from the cultures and MnO₂ was formed.     

Detoxification of cyanide using titanium dioxide and hydrocyclone sparger with chlorine dioxide

Abstract

The extraction of gold and silver from minerals and concentrates with cyanide is an important hydrometallurgy process that has been studied for more than 120 years. This technology, which consists of the dissolutions of the precious metals in cyanide solutions, followed by the recovery of the values by cementation, activated carbon or ion exchange resin. Most of the wastes in the industrial effluents’ milling are known to contain high contents of free cyanide as well as metallic cyanide complexes, which give them a high degree of toxicity. Appropriate methods for the treatment of cyanide solutions include cyanide destruction by oxidation using a photoelectrocatalytic detoxification technique with titanium dioxide microelectrodes. This is one of the most innovative ways for the treatment of wastewater containing cyanide. Another is the use of chlorine dioxide (ClO₂) with a gas-sparged hydrocyclone as the reactor. The results show that photodegradation of cyanide was 93% in 30 minutes using a 450 W halogen lamp, and in the case of ClO₂ the destruction of cyanides was 99% in 1 minute. In both cases, excellent performances can be achieved with the high capacity of these technologies.     

Dependence of the Phenotypic Characteristics of <Emphasis Type="Italic">Acidithiobacillus ferrooxidans</Emphasis> on the Physical,Chemical, and Electrophysical Properties of Pyrites

Comparison of Acidithiobacillus ferrooxidans strains TFV-1 and TFBk with respect to their capacity to oxidize pyrite 1, with an electron-type (n-type) conductivity, or pyrite 2, with hole-type (p-type) conductivity, showed that, at a pulp density of 1%, both before and after its adaptation to the pyrites, strain TFBk, isolated from a substrate with a more complex mineral composition, grew faster and oxidized the pyrites of both conductivity types more efficiently than strain TFV-1, which was isolated from a mineralogically simple ore. At a pulp density of 3–5%, the oxidation of pyrite 2 by strain TFV-1 and both of the pyrites by strain TFBk began only after an artificial increase in Eh to 600 mV. If the pulp density was increased gradually, strain TFBk could oxidize the pyrites at its higher values than strain TFV-1, with the rate of pyrite 2 oxidation being higher than that of pyrite 1. During chemical oxidation of both of the pyrites, an increase was observed in the absolute values of the coefficients of thermoelectromotive force (K_TEMF); during bacterial-chemical oxidation, the K_TEMF of pyrite 1 changed insignificantly, whereas the K_TEMF of pyrite 2 decreased.     

The growth of a cyanide-utilising strain of Pseudomonas fluorescens in liquid culture on nickel cyanide as a source of nitrogen

Pseudomonas fluorescens strain NCIMB11764 is able to utilise cyanide as a source of nitrogen for growth. When KCN(≡ HCN) is the source of nitrogen it has to be supplied as the limiting nutrient in fed-batch cultures [1]. In this study it has been shown that metal-complexed cyanide, as nickel cyanide (Ni(CN)²⁻₄), can be used as the source of nitrogen when it is added directly to the growth medium in batch cultures. Ni(CN)²⁻₄ could also be used as the source of nitrogen in nitrogen-limited continuous cultures. In both batch and continuous cultures, growth on Ni(CN)²⁻₄ was associated with induction of cyanide oxygenase activity. An assay for cyanide has been developed utilising its binding to nickel.     

Effects of nitrogen source and concentration on growth rate and fatty acid composition of Ellipsoidion sp. (Eustigmatophyta)

In order to study the effects of different nitrogen source and concentrationon the growth rate and fatty acid composition, a marine microalga Ellipsoidion sp. with a high content of eicosapentaenoic acid (EPA) wascultured in media with different nitrogen sources and concentrations.During the pre-logarithmic phase, the alga grew faster with ammoniumas N source than with nitrate, but the reverse applied during thepost-logarithmic phase. The alga grew poorly in N-free mediumor medium with urea as the sole N source. In the same growth phase,ammonium medium resulted in higher yield of total lipid, but the EPA yielddid not differ significantly different from that using nitrate medium. Themaximum growth rate occurred in medium containing 1.28 mmolL^-1 sodium nitrate, while maximum EPA and total lipid contents werereached at 1.92 mmol L^-1, when EPA accounted for 27.9% totalfatty acids. The growth rate kept stable when NH₄Cl ranged from0.64 to 2.56 mmol L^-1, and the maximum content of total lipidand EPA occurred in the medium with 2.56 mmol L^-1NH₄Cl. The EPA content was higher in the pre- thanpost-logarithmic phase, though the total lipid content was lower. Thehighest EPA content expressed as percent total fatty acid was 27.9% innitrate medium and and 39.0% in ammonium medium.     

KVOPO4: A New High Capacity Multielectron Na‐Ion Battery Cathode

Sodium ion batteries have attracted much attention in recent years, due to the higher abundance and lower cost of sodium, as an alternative to lithium ion batteries. However, a major challenge is their lower energy density. In this work, we report a novel multi‐electron cathode material, KVOPO₄, for sodium ion batteries. Due to the unique polyhedral framework, the V³⁺ ? V⁴⁺ ? V⁵⁺ redox couple was for the first time fully activated by sodium ions in a vanadyl phosphate phase. The KVOPO₄ based cathode delivered reversible multiple sodium (i.e. maximum 1.66 Na⁺ per formula unit) storage capability, which leads to a high specific capacity of 235 Ah kg^?1. Combining an average voltage of 2.56 V vs. Na/Na⁺, a high practical energy density of over 600 Wh kg^?1 was achieved, the highest yet reported for any sodium cathode material. The cathode exhibits a very small volume change upon cycling (1.4% for 0.64 sodium and 8.0% for 1.66 sodium ions). Density functional theory (DFT) calculations indicate that the KVOPO₄ framework is a 3D ionic conductor with a reasonably, low Na⁺ migration energy barrier of ≈450 meV, in line with the good rate capability obtained.     

Isolation and characterization of novel Serratia marcescens (AY927692) for pentachlorophenol degradation from pulp and paper mill waste

Seven aerobic bacterial strains were isolated from pulp paper mill waste and screened for pentachlorophenol (PCP) tolerance on PCP containing mineral salt agar medium (MSM). The organism was characterized by 16S rDNA sequencing which showed 99.7% sequence similarity with Serratia marcescens. PCP degradation was routinely monitored with spectrophotometric analysis and further confirmed by HPLC analysis. Among seven strains, ITRC S₇ was found to degrade up to 90.33% of 1.127 mM (300 mg/l) of PCP and simultaneous release of chloride ion (2.435 mM) emphasized the bacterial dechlorination in the medium in presence of glucose as an additional carbon and energy source under optimized condition within 168 h incubation. In absence of glucose bacterium was unable to utilize PCP indicating the phenomenon of co-metabolism. Bacterium was identified as S. marcescens (AY927692), was a novel and potential aerobic bacterial strain capable of degrading PCP in axenic condition. Further, this strain may be used for bioremediation of PCP containing pulp paper mill waste in the environment.     

Studies on the mechanism of NADPH oxidation by the granule fraction isolated from human resting polymorphonuclear blood cells

Various factor affecting NADPH-oxidation by resting human leucocyte granules (LG) at acid pH, have been investigated.It was found that:

1) oxidation of NADPH by LG was increasingly inhibited by increased cyanide concentrations in the medium and was abolished by 4 mM cyanide.

2) with or without cyanide in the incubation medium, LG omitted, Mn⁺⁺, in the presence of NADPH induced superoxide anion (O¯₂) production, as evidenced by oxygen consumption and H₂O₂ production, which were abolished (in the absence of cyanide) by cytochrome C (a potent O¯₂ scavenger).

3) Both NADPH oxidation in the presence of 2 mM cyanide (cyanide-resistant) and in its absence (cyanide-sensitive) by LG occured only in the presence of Mn⁺⁺, and both were inhibited by superoxide dismutase.

4) Cyanide-resistant NADPH oxidation by LG generated H₂O₂, was inhibited by H₂O₂ and was not modified by «active catalase. The ratio of cyanide-resistant NADPH oxidation/O₂ uptake was 1 up to 1.25 mM NADPH, and increased above this concentration.

5) Cyanide-sensitive NADPH oxidation was inhibited by catalase and increased upon addition of H₂O₂. The ratio of cyanide-sensitive NADPH oxidation/O₂ uptake was 2.

It was concluded that after initiation by O¯₂, produced independently of LG, two sequential types of LG dependent NADPH oxidations occur. First, an O¯₂-dependent protein mediated NADPH oxidation (cyanide-resistant) which generates H₂O₂ and O¯₂ occurs. Second, NADPH peroxidation (cyanide-sensitive) which utilizes H₂O₂ takes place.     

Optimization and maintenance of soluble methane monooxygenase activity inMethylosinus trichosporium OB3b

Soluble methane monooxygenase (sMMO) maximization studies were carried out as part of a larger effort directed towards the development and optimization of an aqueous phase, multistage, membrane bioreactor system for treatment of polluted groundwater. A modified version of the naphthalene oxidation assay was utilized to determine the effects of methane:oxygen ratio, nutrient supply, and supplementary carbon sources on maximizing and maintaining sMMO activity inMethylosinus trichosporium OB3b.Methylosinus trichosporium OB3b attained peak sMMO activity (275–300 nmol of naphthol formed h^–1 mg of protein^–1 at 25°C) in early stationary growth phase when grown in nitrate mineral salts (NMS) medium. With the onset of methane limitation however, sMMO activity rapidly declined. It was possible to define a simplified nitrate mineral salts (NMS) medium, containing nitrate, phosphate and a source of iron and magnesium, which allowed reasonably high growth rates (_max 0.08 h^–1) and growth yields (0.4–0.5 g cells/g CH₄) and near maximal activities of sMMO. In long term batch culture incubations sMMO activity reached a stable plateau at approximately 45–50% of the initial peak level and this was maintained over several weeks. The addition of d-biotin, pyridoxine, and vitamin B₁₂ (cyanocobalamin) increased the activity level of sMMO in actively growing methanotrophs by 25–75%. The addition of these growth factors to the simplified NMS medium was found to increase the plateau sMMO level in long term batch cultures up to 70% of the original peak activity.Abbreviations sMMO soluble methane monooxygenase - pMMO particulate methane monooxygenase - NMS nitrate mineral salts - TCE trichloroethene - NADH reduced nicotinamide adenine dinucleotide     

含无机盐沉淀菌悬液中微生物生长量的快速测定

目的:消除菌悬液中无机盐沉淀对比浊法测定生长量的干扰。方法:以嗜有机甲基杆菌ME25为材料,采用比浊法,研究了EDTA对菌悬液中无机沉淀物的清除效应以及对菌体生物量测定的影响。结果:在室温、pH 4~11,1.25×10^-2 mol/L EDTA与菌悬液样品作用1min,即可去除样品中无机盐沉淀,样品稳定,在1h内不影响样品中菌体吸光度的测定;实际样品和理论样品测定,相对误差小于3.0%,回收率为98%~100%,RSD均小于0.5%。结论:采用螯合剂EDTA可快速去除菌悬液中的无机盐沉淀,有效地消除沉淀物的干扰,明显提高了比浊法测定生长量的准确度,简便易行,具有较高的实用价值。     

Biogenic production of cyanide and its application to gold recovery

Chromobacterium violaceum is a cyanogenic (cyanide-producing) microorganism. Cyanide is used on an industrial scale to complex and recover gold from ores or concentrates of ores bearing the precious metal. A potentially useful approach in gold mining operations could be to produce cyanide biologically in relatively small quantities at the ore surface. In this study, C. violaceum grown in nutrient broth formed a biofilm and could complex and solubilize 100% of the gold on glass test slides within 4–7 days. Approximately 50% of the cyanide-recoverable gold could be mobilized from a biooxidized sulfidic-ore concentrate. Complexation of cyanide in solution by gold appeared to have a beneficial effect on cell growth — viable cell counts were nearly two orders of magnitude greater in the presence of gold-coated slides or biooxidized ore substrates than in their absence. C. violaceum was cyanogenic when grown in alternative feedstocks. When grown in a mineral salt solution supplemented with 13.3% v/v swine fecal material (SFM), cells exhibited pigmentation and suspended cell concentrations comparable to cultures grown in nutrient broth. Glycine supplements stimulated production of cyanide in 13.3% v/v SFM. In contrast, glycine was inhibitory when added at the time of inoculation in the more concentrated SFM, decreasing cell numbers and reducing ultimate bulk-solution cyanide concentrations. However, aeration and addition of glycine to stationary phase cells grown on 13.3% v/v SFM anaerobically resulted in rapid production and high concentrations (up to 38 mg l⁻¹) of cyanide. This indicates that biogenesis of cyanide may be supported in remote areas using locally produced and inexpensive agricultural feedstocks in place of commercial media. Journal of Industrial Microbiology & Biotechnology (2001) 26, 134–139. Received 06 June 2000/ Accepted in revised form 30 September 2000     

Leaching of Pyrites of Various Reactivities by Thiobacillus ferrooxidans

Wide variations were found in the rate of chemical and microbiological leaching of iron from pyritic materials from various sources. Thiobacillus ferrooxidans accelerated leaching of iron from all of the pyritic materials tested in shake flask suspensions at loadings of 0.4% (wt/vol) pulp density. The most chemically reactive pyrites exhibited the fastest bioleaching rates. However, at 2.0% pulp density, a delay in onset of bioleaching occurred with two of the pyrites derived from coal sources. T. ferrooxidans was unable to oxidize the most chemically reactive pyrite at 2.0% pulp density. No inhibition of pyrite oxidation by T. ferrooxidans occurred with mineral pyrite at 2.0% pulp density. Experiments with the most chemically reactive pyrite indicated that the leachates from the material were not inhibitory to iron oxidation by T. ferrooxidans.     

Soil environmental variables affecting the flux of methane from a range of forest, moorland and agricultural soils

Measurements of the net methane exchange over a range of forest, moorland, and agricultural soils in Scotland were made during the period April to June 1994 and 1995. Fluxes of CH₄ ranged from oxidation –12.3 to an emission of 6.8 ng m^–2 s^–1. The balance between CH₄ oxidation and emission depended on the physical conditions of the soil, primarily soil moisture. The largest oxidation rates were found in the mineral forest soils, and CH₄ emission was observed in several peat soils. The smallest oxidation rate was observed in an agricultural soil. The relationship between CH₄ flux and soil moisture observed in peats (Flux_{CH 4} = 0.023 × %H₂O (dry weight) – 7.44, p > 0.05) was such that CH₄ oxidation was observed at soil moistures less than 325%( ± 80%). CH₄ emission was found at soil moistures exceeding this value. A large range of CH₄ oxidation rates were observed over a small soil moisture range in the mineral soils. CH₄ oxidation in mineral soils was negatively correlated with soil bulk density (Flux_{CH 4} = –37.35 × bulk density (g cm^–3) + 48.83, p > 0.05). Increased nitrogen loading of the soil due to N fixation, atmospheric deposition of N, and fertilisation, were consistently associated with decreases in the soil sink for CH₄, typically in the range 50 to 80%, on a range of soil types and land uses.     

Impact of nutritional conditions on yields,germination rate and shelf-life of Plectosporium alismatis conidia and chlamydospores as potential candidates for the development of a mycoherbicide of weeds in rice crops

The effect of nutritional conditions on spore qualities was investigated in order to select which propagules, conidia or chlamydospores, would be most suitable for mycoherbicide development. Plectosporium alismatis was grown in a liquid basal medium supplemented with glucose and a mineral nitrogen source (sodium nitrate) or an organic nitrogen source (casamino acids). Conidial and chlamydospore yields, germination rate and shelf-life were compared. Two growth models were developed: on one hand, sodium nitrate added as the sole nitrogen source was partially utilised (8%), resulting in poor growth (1.77±0.02 mg mL^?1; 6±1.7×10⁵ conidia mL^?1). Under these conditions, P. alismatis produced dense, melanised-like aggregates that contained chlamydospores (12.4±0.7×10⁴ chlamydospores mL^?1). Germination rates of chlamydospores and conidia produced under these conditions was high (80%). Twenty percent of chlamydospores were able to germinate after 4 months storage at 25°C, while survival of conidia declined rapidly (<2%). When casamino acids were added to the liquid medium as the sole nitrogen source, P. alismatis produced sparser pellets resulting in high dry weights (5.37±0.09 mg mL^?1 and high conidia numbers (9.6±1.5×10⁶ conidia mL^?1), while no chlamydospore were observed. The germination rate of conidia produced in casamino acids was low (33±13%) after 8 h incubation and microcycle conidiation occurred. Five percent of these conidia germinated after 4 months storage. These data indicate that chlamydospores may be suitable for mycoherbicide development, provided further optimisation of yields is achieved.