Evaluation of a new model system for studying the formation of heterocyclic amines

Heterocyclic amines (HAs) are an important class of food mutagens and carcinogens, which can be found in cooked meat and fish. Increasing heating temperatures and times usually increase mutagenic activity in meat and meat extracts during cooking. We developed a model system, which allows to examine the effects of precursor composition and heating conditions (time and temperature) on the formation of HAs in meat. Homogenized and freeze dried meat samples (beef, pork chops, chicken breast and turkey breast) are heated with diethylene glycol in closed vials under stirring in a thermostated heating block. After an appropriate sample preparation (extraction and clean-up) ten different HAs were measured by HPLC analyses with gradient elution and mass selective detection. The time courses of HA-formation in the different kinds of meat at varying heating temperatures were determined up to heating times of 30 min. 2-amino-1-methyl-6-phenylimidazo[4,5-b]pyridine (PhIP) was the most abundant HA in these experiments and reached the highest concentrations in the beef meat samples, as did the other HAs (MeIQ, AalphaC) at 220 degrees C in the heating block under stirred conditions. Additionally the influence of the antioxidant TBHQ (t-butylhydroquinone) on the formation of HAs in the model system was tested. However TBHQ effected only slight reductions of HA formation in all kinds of meat.     

Thermostability of Ochratoxin A in wheat under two moisture conditions.

The decomposition of ochratoxin A (OTA) was examined, under different temperature and moisture conditions. The calculated half-lives, corresponding to 50% values, were 707, 201, 12, and 6 min, respectively, at 100, 150, 200, and 250 degrees C for dry wheat and 145, 60, and 19 min, respectively, at 100, 150, and 200 degrees C for wheat heated under wet conditions. The presence of water (50%) increased the decomposition of OTA at 100 and 150 degrees C; the opposite was observed at 200 degrees C. Complete destruction of OTA within the limits of this study (100 to 250 degrees C) was not obtained.     

Formation of 2-amino-3,8-dimethylimidazo[4,5-f]quinoxaline in a model system by heating creatinine, glycine and glucose

A mixture of creatinine, glucose and glycine was heated in diethylene glycol containing 14% water for 2 h at 128 degrees C, and the mutagens formed were purified by XAD-2 column chromatography, acid-base partition, Sephadex LH-20 column chromatography, 'blue cotton' treatment and HPLC. Two mutagenic substances were isolated by HPLC. The major mutagen was identified by its UV absorption and mass and NMR spectra as 2-amino-3,8- dimethylimidazo [4,5-f]quinoxaline, which was originally isolated from fried beef. This finding supported the idea that creatinine, amino acids and sugars present in meat are precursors in the formation of the mutagenic imidazoquinoxaline derivative.     

Heat-induced fragmentation of human plasma fibronectin

Human plasma fibronectin was found to undergo fragmentation during heat-denaturation, leading to artifacts in SDS-polyacrylamide gel electrophoretic analyses. Electrophoretic patterns of heated samples showed a progressive decrease in intact fibronectin chains (225 kDa) which coincided with the appearance of increasing amounts of numerous smaller components having molecular weights ranging from 10 000 to 200 000. The fragmentation was temperature-dependent, being undetectable after 2 h at 60 degrees C, but detectable after 30 min at 70 degrees C or as little as 2 min at 100 degrees C. After 2 h at 100 degrees C, the intact monomer was no longer visible. Neither mercaptoethanol nor SDS was required for fragmentation. Sterile filtration or pretreatment with inhibitors of proteolytic enzymes had no effect. Treatment with amines did not diminish the degradation, indicating that the process differs from heat-fragmentation of alpha 2-macroglobulin and complement proteins, which occurs at a reactive internal thiolester bond. Fibronectin fragmentation was highly pH-dependent, being markedly accelerated under acidic conditions, suggesting that autolytic cleavage of the peptide chain at acid-labile aspartyl bonds was responsible for this phenomenon.     

Formation of heterocyclic aromatic amines in model systems

Heterocyclic aromatic amines (HAs) are mutagenic and carcinogenic substances that are formed in significant amounts during heating of meat or fish at temperatures of at least 150 degrees C. To investigate the chemistry lying behind the formation of these harmful substances model systems were established. The first aim was to identify the naturally occurring precursors, namely creatinine, amino acids and carbohydrates. Later these model systems were used to develop strategies for a reduction of the content of the heterocyclic aromatic amines and for the evaluation of the reaction mechanisms that lead to the formation of these substances. All these aspects are discussed in this review.     

Effects of heating time and antioxidants on the formation of heterocyclic amines in marinated foods

The effect of heating time and antioxidants on the heterocyclic amine (HAs) formation in marinated foods were studied. Food samples were cooked at 98 +/- 2 degrees C for 1, 2, 4, 8, 16 and 32 h in a closed pan in the presence of water, soy sauce and rock candy with or without antioxidants. The various HAs in marinated food samples and juice were analyzed by HPLC with photodiode-array detection. Results showed that the amount of HAs formed during heating followed an increased order for each increasing heating time. A larger variety and higher amount of HAs were generated in marinated pork when compared to marinated eggs and bean cake. In marinated juice, the levels of HAs were present in greater amount than in marinated foods. The incorporation of antioxidants Vitamin C, Vitamin E and BHT were found to be effective towards HAs inhibition, however, the effect was minor.     

Antidiabetic activity of aqueous extract and non polysaccharide fraction of Cynodon dactylon Pers

Petroleum ether (60 degrees-80 degrees C), chloroform, acetone, ethanol, aqueous and crude hot water extracts of the whole plant of C. dactylon and the two fractions of aqueous extract were tested for antihyperglycaemic activity in glucose overloaded hyperglycemic rats and in alloxan induced diabetic model at two-dose levels, 200 and 400 mg/kg (po) respectively. The aqueous extract of C. dactylon and the non polysaccharide fraction of aqueous extract were found to exhibit significant antihyperglycaemic activity and only the non polysaccharide fraction was found to produce hypoglycemia in fasted normal rats. Treatment of diabetic rats with aqueous extract and non polysaccharide fraction of the plant decreased the elevated biochemical parameters, glucose, urea, creatinine, serum cholesterol, serum triglyceride, high density lipoprotein, low density lipoprotein, haemoglobin and glycosylated haemoglobin significantly. Comparatively, the non polysaccharide fraction of aqueous extract was found to be more effective than the aqueous extract.     

Production and characterization of functional substances from a by-product of rice bran oil and protein production by a compressed hot water treatment

A by-product of rice bran oil and protein production was treated with water and compressed hot water at 20 degrees C to 260 degrees C for 5 min, and at 200 degrees C and 260 degrees C for 5 to 120 min. Each extract was evaluated for its yield, radical scavenging activity, carbohydrate, protein, total phenolic and furfural contents, molecular-mass distribution and antioxidative activity. The maximum yield was obtained at 200 degrees C. The radical scavenging activity and the protein, total phenolic and furfural contents of the extract increased with increasing temperature. However, the carbohydrate content abruptly decreased when treated at above 200 degrees C. The extract treated at 260 degrees C for 5 min exhibited suppressive activity toward the autoxidation of linoleic acid. Each extract obtained at temperatures lower than or equal to 200 degrees C exhibited emulsifying ability.     

Evaluation of the ability of primary selective enrichment to resuscitate heat-injured and freeze-injured Listeria monocytogenes cells.

Resuscitation rates of injured Listeria monocytogenes on conventional selective Listeria enrichment broth and nonselective Trypticase soy broth containing 0.6% yeast extract were compared. Cells were heated to 60 degrees C for 5 min or frozen at -20 degrees C for 7 days. Inoculation of Trypticase soy broth-yeast extract with the stressed cells resulted in growth that was superior to that in Listeria enrichment broth. Injured cells were fully recovered at 6 to 8 h.     

Evaluation of the ability of primary selective enrichment to resuscitate heat-injured and freeze-injured Listeria monocytogenes cells.

Resuscitation rates of injured Listeria monocytogenes on conventional selective Listeria enrichment broth and nonselective Trypticase soy broth containing 0.6% yeast extract were compared. Cells were heated to 60 degrees C for 5 min or frozen at -20 degrees C for 7 days. Inoculation of Trypticase soy broth-yeast extract with the stressed cells resulted in growth that was superior to that in Listeria enrichment broth. Injured cells were fully recovered at 6 to 8 h.     

Effect of prior heat shock on heat resistance of Listeria monocytogenes in meat

The effect of prior heat shock on the thermal resistance of Listeria monocytogenes in meat was investigated. A sausage mix inoculated with approximately 10(7) L. monocytogenes per g was initially subjected to a heat shock temperature of 48 degrees C before being heated at a final test temperature of 62 or 64 degrees C. Although cells heat shocked at 48 degrees C for 30 or 60 min did not show a significant increase in thermotolerance as compared with control cells (non-heat shocked), bacteria heat shocked for 120 min did, showing an average 2.4-fold increase in the D64 degrees C value. Heat-shocked cells shifted to 4 degrees C appeared to maintain their thermotolerance for at least 24 h after heat shock.     

Effect of prior heat shock on heat resistance of Listeria monocytogenes in meat.

The effect of prior heat shock on the thermal resistance of Listeria monocytogenes in meat was investigated. A sausage mix inoculated with approximately 10(7) L. monocytogenes per g was initially subjected to a heat shock temperature of 48 degrees C before being heated at a final test temperature of 62 or 64 degrees C. Although cells heat shocked at 48 degrees C for 30 or 60 min did not show a significant increase in thermotolerance as compared with control cells (non-heat shocked), bacteria heat shocked for 120 min did, showing an average 2.4-fold increase in the D64 degrees C value. Heat-shocked cells shifted to 4 degrees C appeared to maintain their thermotolerance for at least 24 h after heat shock.     

Effect of heating on properties of some soils from Southern Nigeria and growth of rice

Summary The effect of heating on the properties of Apomu (Psammentic Usthorthent), Egbeda (Oxic Paleustalf) and Gambari (Typic Plinthustalf) surface soils were studied under laboratory conditions. Heating at low temperatures (100°C) have no detrimental effects on soil properties, on the contrary it increased the soil extractable P, Mg, Fe, Mn and Zn levels. Pronounced reductions in total N, Org. C, Org. P and extractable Ca and Mg levels and marked increases in extractable P, Zn, Mn and Fe were observed by heating to 200°C. Heating to 500° had an adverse effect on soil chemical and physical properties.Plant height and dry matter yeild of rice plants were higher when grown on Egbeda soil previously heated to 100°C. With addition of N, P and K there was no observed beneficial effect of the heating treatment. Rice plants grown on Egbeda soil previously heated to 200°C showed high uptake of Mn. Plants grew badly in soil previously heated to 500°C.     

Formation of mutagens, 2-amino-3,8-dimethylimidazo[4,5-f]quinoxaline (MeIQx) and 2-amino-3,4,8-trimethylimidazo[4,5-f]quinoxaline (4,8-DiMeIQx), in heated fish meats

Fish meats were heated under conditions close to those used for cooking and processing. The mutagenic activity of the heated fish meats was estimated toward Salmonella typhimurium TA98 with metabolic activation after extraction with boiling water and adsorption to blue cotton. The numbers of His+ revertant colonies/5 g of the meat heat-dried without charring at 220 degrees C for 15 min were about 3000 for bonito, about 1000 for tunny, less than 500 for mackerel, salmon, swordfish, sardine, horse mackerel and cod, and 0 for cuttlefish. The mutagens in the heat-dried bonito meat were purified by thin-layer chromatography (TLC) and high-performance liquid chromatography (HPLC). They were identified as 2-amino-3,8-dimethylimidazo[4,5-f]quinoxaline (MeIQx) and 2-amino-3,4,8-trimethylimidazo[4,5-f]quinoxaline (4,8-DiMeIQx) by comparison with the authentic specimen with respect to Rf values in TLC, retention times in HPLC, ultraviolet absorption spectra and mass spectra. The contents of MeIQx and 4,8-DiMeIQx in the bonito meat were estimated to be 5.2 and 5.4 ng/g, respectively. The major mutagens produced in the bonito, tunny and mackerel meats heated without charring at 100 degrees C for 48 h and at 220 degrees C for 15 min were found to be MeIQx and 4,8-DiMeIQx. It is interesting to note that the bonito and sardine meats grilled with charring for 15 min contained MeIQx and 4,8-DiMeIQx but higher mutagenicity was observed in the fraction that may contain 2-amino-3-methylimidazo[4,5-f] quinoline (IQ), 2-amino-3,4-dimethylimidazo[4,5-f]quinoline (MeIQ) and/or 2-aminodipyrido[1,2-a: 3',2'-d]imidazole (Glu-P-2).     

Effect of temperature and duration of hyperthermia on HSP72 induction in rat tissues

The aim of the present study was to determine whether heat shock protein 72 (HSP72) is induced in a heated rat model at rectal temperatures below 42 degrees C. Rats were divided into a control group and six groups (n = 6) heated to different rectal temperatures: 39 degrees C for 1 h (39), 40.0 degrees C for either 15 min (40S) or 1 h (40L), 41.0 degrees C for either 15 min (41S) or 1 h (41L) and 42.0 degrees C for 15 min (42). Tissues were sampled 4 h after heating. Following 1 h at 40.0 degrees C, HSP72 was significantly elevated in heart (p < 0.005), but not in gut or liver tissue. In all three tissues, HSP72 was significantly elevated under the conditions 41L and 42 compared to control tissue (p < 0.005). Marked differences were found in the amount of HSP72 induced in different tissues in response to the same heat stress. Duration of heating was important in modulating HSP72 induction, with a significantly greater induction of HSP72 following 1 h compared to 15 min at 41 degrees C in all three tissues (p < 0.02). A correlation was found between thermal load and HSP72 content in liver, heart (both p < 0.01) and gut (p < 0.001) for the rats heated to 41 and 42 degrees C. These data show that HSP72 is induced at temperatures below 42 degrees C, with striking differences between tissues.     

Extraction of protein and amino acids from deoiled rice bran by subcritical water hydrolysis

This study investigated the production of value-added protein and amino acids from deoiled rice bran by hydrolysis in subcritical water (SW) in the temperature range between 100 and 220 degrees C for 0-30 min. The results suggested that SW could effectively be used to hydrolyze deoiled rice bran to produce useful protein and amino acids. The amount of protein and amino acids produced are higher than those obtained by conventional alkali hydrolysis. The yields generally increased with increased temperature and hydrolysis time. However, thermal degradation of the product was observed when hydrolysis was carried out at higher temperature for extended period of time. The highest yield of protein and amino acids were 219 +/- 26 and 8.0 +/- 1.6 mg/g of dry bran, and were obtained at 200 degrees C at hydrolysis time of 30 min. Moreover, the product obtained at 200 degrees C after 30 min of hydrolysis exhibited high antioxidant activity and was shown to be suitable for use as culture medium for yeast growth.     

Surface decontamination of beef inoculated with Salmonella Typhimurium DT104 or Escherichia coli O157:H7 using dry air in a novel heat treatment apparatus

AIMS: To determine the effectiveness of a novel dry air decontamination apparatus in the deactivation of Salmonella serotype Typhimurium DT104 or Escherichia coli O157:H7 on beef surfaces. METHODS AND RESULTS: A laboratory scale dry air decontamination apparatus, capable of producing repeatable and known heating time-temperature cycles on food surfaces was used in decontamination trials. Beef samples were surface inoculated with 7-8 log10CFU cm(-2) of S. Typhimurium DT104 or E. coli O157:H7 and heated at 60, 75, 90 and 100 degrees C using fast and slow heating rates and subsequently held at these temperatures for up to 600 s. A substantial reduction in pathogen numbers was achieved at higher temperatures (90 and 100 degrees C, 4.18-6.06 log10CFU cm(-2)) using both heating rates, but cell survival at these temperatures was also observed. At the lower temperatures, deactivation was small at 60 degrees C in particular it was less than one log unit after 3 min heating. No significant differences were observed when total reductions in pathogen counts were compared for all the temperature/heat up time combinations tested. During slow heating at 90 degrees C, and both heating rates at 100 degrees C, the pattern of deactivation of S. Typhimurium DT104 or E. coli O157:H7 was triphasic. CONCLUSIONS: This study has shown that heating meat surfaces with dry air can achieve substantial reductions in S. Typhimurium DT104 or E. coli O157:H7. As surface decontamination of beef surfaces with dry air had a negative effect on beef colour and appearance, such a decontamination apparatus would be unsuitable for producing meat for retail sale but it could be used to produce safer meat for use in the catering trade. SIGNIFICANCE AND IMPACT OF THE STUDY: This study provides researchers and food processors with data on the dynamic changes in S. Typhimurium DT104 and E. coli O157:H7 counts on intact beef surfaces during heating with dry air under realistic (time-varying) temperature conditions.     

The thermal polymerization of amino acids in the presence of sand.

Sand was tested as a model of a common "impurity" that could have influenced the formation of thermal prebiotic protein. Increasing proportions of sand (0-16 g) in admixture with one set of reactant amino acids (1g), when heated at 175 degrees C for 1.5 h, resulted in increasing yields of polyamino acids of increasing size and color intensity; amino acid composition was not greatly affected. Similar results were noted for three of five other sets of reactant amino acids (8 g sand per g amino acids). In no case did sand prevent the amino acids from polymerizing. The results are interpreted to indicate a broader range of conditions conducive to the formation of prebiotic protein and to further emphasize that environmental parameters should be considerided in the experimental modeling of prebiotic processes.     

Effects of industrially produced flavours with pro- and antioxidative properties on the formation of the heterocyclic amine PhIP in a model system

PhIP (2-amino-1-methyl-6-phenylimidazo[4,5-b]pyridine) is a heterocyclic aromatic amine belonging to a class of mutagens found in food. This project studied the effects of commercially available flavours of spices on the formation of PhIP, one of the most common heterocyclic aromatic amines in heated meat and fish products. The model reactions were carried out in diethylene glycol. Highest amounts of PhIP were obtained at 200 degrees C, a heating time of 60 min and an equivalent molar ratio of phenylalanine and creatinine. With this model system, the influence of Monascus red and flavours extracted from thyme, marjoram and rosemary on the formation of PhIP was tested. The flavours were added to the model system in different amounts. The oxidative properties were determined with the rancimat method. It was shown that all tested products, independent of their pro- or antioxidative properties, increased PhIP in the model system.     

A note on the microbial spoilage of undercooked chub-packed luncheon meat

Contrary to expectations slight undercooking 968.5 degrees C instead of 70 degrees C for 90 min) dramatically increased the shelf-life of chub-packed luncheon meat stored at 25 degrees C. The pH of undercooked chubs fell rapidly to below 5.0 as a result of the growth of enterococci. The accumulated acid prevented the growth of Bacillus spores and gave the luncheon meat a not unpleasant tangy flavour. Degradative changes associated with the spoilage of commercially cooked chub-packed luncheon meat did not occur, even after 42 d storage. Apparently, post-cooking fermentation by enterococci can effectively convert a perishable product into a 'shelf stable' one by lowering the pH below 5.0.