Formation and degradation of gluconate by Zymomonas mobilis

Summary Zymomonas mobilis ATCC 29191 is able to degrade gluconate but cannot use it as a single carbon and energy source. Gluconate is phosphorylated by a gluconate kinase (EC 2.7.1.12) and the resulting 6-phosphogluconate is further catabolized to yield about 0.8 mol ethanol per mol of gluconate, considerable amounts of acetate and acetoin. This product spectrum agrees with the theoretical yield of only one reduction equivalent if gluconate is phosphorylated by a kinase and subsequently metabolized via the Entner-Doudoroff pathway.Furthermore, Z. mobilis contains a membrane-bound enzyme system which is able to oxidize glucose to gluconate. Cell-free extracts were active in an assay system with Wurster's blue as electron acceptor, and various aldoses as well as maltose, mannitol and sorbitol could be oxidized. The affinity for sorbitol was very low (K _m =330 mM) but reasonable for glucose (K _m =2.8 mM). The pH optimum for the glucose-oxidizing reaction was 6.5, while that for sorbitol oxidation was 5.5.Dedicated to Prof. Dr. H. Dörfel on the occasion of his 60th birthday     

Fermentation and metabolic characteristics of Gluconacetobacter oboediens for different carbon sources

The metabolism of Gluconacetobacter oboediens was investigated in relation to different carbon sources for the continuous cultures at the dilution rate of 0.05 h⁻¹. The ¹³C-flux result implies the formation of metabolic recycles for the case of using glucose and acetate as carbon sources. When glucose and ethanol were used as carbon sources, the specific ethanol uptake rate and the specific acetate production rate increased as the feed ethanol concentration was increased from 40 to 60 g/l, while the specific CO₂ production rate and the biomass concentration decreased, where the ¹³C-metabolic flux result indicates that the glycolysis, oxidative PP pathway, and the tricarboxylic acid (TCA) cycle were less active, resulting in less biomass concentration. The flux result also implies that oxaloacetate decarboxylase flux became negative, so that oxaloacetate is backed up by this pathway, resulting in less activity of glyoxylate pathway. When gluconate was added for the case of using glucose and ethanol as carbon sources, the acetate and cell concentrations as well as gluconate concentrations increased. The glucose and ethanol concentrations decreased concomitantly with the increased feed gluconate concentration. In accordance with these fermentation characteristics, the enzyme activity result indicates that glucose dehydrogenase and glucose-6-phosphate dehydrogenase pathways became less active, while the glycolysis and the TCA cycle was activated as the feed gluconate concentration was increased.     

Analysis of growth of Gluconobacter oxydans in glucose containing media

Gluconobacter oxydans oxidizes glucose via alternative pathways: one involves the non-phosphorylative, direct oxidation route to gluconic acid and ketogluconic acids, and the second requires an initial phosphorylation and then oxidation via the pentose phosphate pathway enzymes. During growth of G. oxydans in glucose-containing media, the activity of this pathway is strongly influenced by (1) the pH value of the environment and (2) the actual concentration of glucose present in the culture. At pH values below 3.5 the activity of the pentose phosphate pathway was completely inhibited resulting in an increased requirement of the organism for nutrient substances, and a poor cell yield. At pH 5.5 a triphasic growth response was observed when G. oxydans was grown in a defined medium. Above a threshold value of 5–15 mM glucose, oxidation of both glucose and gluconate by the pentose phosphate pathway enzymes was repressed, causing a rapid accumulation of gluconic acid in the culture medium. When growing under these conditions, a low affinity for the oxidation of glucose was found (K _s=13 mM). Below this threshold glucose concentration, pentose phosphate pathway enzymes were synthesized and glucose was actively assimilated via this pathway. It was shown that de novo enzyme synthesis was necessary for increased pentose phosphate pathway activity and that assimilation of gluconate by washed cell suspensions was inhibited by glucose.     

Characterization of enzymes involved in the central metabolism of Gluconobacter oxydans

Gluconobacter oxydans is an industrially important bacterium that lacks a complete Embden–Meyerhof pathway (glycolysis). The organism instead uses the pentose phosphate pathway to oxidize sugars and their phosphorylated intermediates. However, the lack of glycolysis limits the amount of NADH as electron donor for electron transport phosphorylation. It has been suggested that the pentose phosphate pathway contributes to NADH production. Six enzymes predicted to play central roles in intracellular glucose and gluconate flux were heterologously overproduced in Escherichia coli and characterized to investigate the intracellular flow of glucose and gluconates into the pentose phosphate pathway and to explore the contribution of the pentose phosphate pathway to NADH generation. The key pentose phosphate enzymes glucose 6-phosphate dehydrogenase (Gox0145) and 6-phosphogluconate dehydrogenase (Gox1705) had dual cofactor specificities but were physiologically NADP- and NAD-dependent, respectively. Putative glucose dehydrogenase (Gox2015) was NADP-dependent and exhibited a preference for mannose over glucose, whereas a 2-ketogluconate reductase (Gox0417) displayed dual cofactor specificity for NAD(P)H. Furthermore, a putative gluconokinase and a putative glucokinase were identified. The gluconokinase displayed high activities with gluconate and is thought to shuttle intracellular gluconate into the pentose phosphate pathway. A model for the trafficking of glucose and gluconates into the pentose phosphate pathway and its role in NADH generation is presented. The role of NADPH in chemiosmotic energy conservation is also discussed.     

Effects of edd and pgi Disruptions on Inosine Accumulation in Escherichia coli

Using an inosine-producing mutant of Escherichia coli, the contributions of the central carbon metabolism for overproducing inosine were investigated. Sodium gluconate instead of glucose was tested as a carbon source to increase the supply of ribose-5-phosphate through the oxidative pentose phosphate pathway. The edd (6-phosphogluconate dehydrase gene)-disrupted mutant accumulated 2.5 g/l of inosine from 48 g/l of sodium gluconate, compared with 1.4 g/l of inosine in the edd wild strain. The rpe (ribulose phosphate 3-epimerase gene)-disrupted mutant resulted in low cell growth and low inosine production on glucose and on gluconate. The disruption of pgi (glucose-6-phosphate isomerase gene) was effective for increasing the accumulation of inosine from glucose but resulted in low cell growth. The pgi-disrupted mutant accumulated 3.7 g/l of inosine from 40 g/l of glucose when 8 g/l of yeast extract was added to the medium. Furthermore, to improve effective utilization of adenine, the yicP (adenine deaminase gene)-disrupted mutant was evaluated. It showed higher inosine accumulation, of 3.7 g/l, than that of 2.8 g/l in the yicP wild strain when 4 g/l of yeast extract was added to the medium.     

Identification of GntR as regulator of the glucose metabolism in Pseudomonas aeruginosa

In contrast to Escherichia coli, glucose metabolism in pseudomonads occurs exclusively through the Entner‐Doudoroff (ED) pathway. This pathway, as well as the three routes to generate the initial ED pathway substrate, 6‐phosphogluconate, is regulated by the PtxS, HexR and GtrS/GltR systems. With GntR (PA2320) we report here the identification of an additional regulator in Pseudomonas aeruginosa PAO1. GntR repressed its own expression as well as that of the GntP gluconate permease. In contrast to PtxS and GtrS/GltR, GntR did not modulate expression of the toxA gene encoding the exotoxin A virulence factor. GntR was found to bind to promoters P_gntR and P_gntP and the consensus sequence of its operator was defined as 5′‐AC‐N‐AAG‐N‐TAGCGCT‐3′. Both operator sites overlapped with the RNA polymerase binding site and we show that GntR employs an effector mediated de‐repression mechanism. The release of promoter bound GntR is induced by gluconate and 6‐phosphogluconate that bind with similar apparent affinities to the GntR/DNA complex. GntR and PtxS are paralogous and may have evolved from a common ancestor. The concerted action of four regulatory systems in the regulation of glucose metabolism in Pseudomonas can be considered as a model to understand complex regulatory circuits in bacteria.     

Novel inositol catabolic pathway in Thermotoga maritima

myo‐inositol (MI) is a key sugar alcohol component of various metabolites, e.g. phosphatidylinositol‐based phospholipids that are abundant in animal and plant cells. The seven‐step pathway of MI degradation was previously characterized in various soil bacteria including Bacillus subtilis. Through a combination of bioinformatics and experimental techniques we identified a novel variant of the MI catabolic pathway in the marine hyperthermophilic bacterium Thermotoga maritima. By using in vitro biochemical assays with purified recombinant proteins we characterized four inositol catabolic enzymes encoded in the TM0412–TM0416 chromosomal gene cluster. The novel catabolic pathway in T. maritima starts as the conventional route using the myo‐inositol dehydrogenase IolG followed by three novel reactions. The first 2‐keto‐myo‐inositol intermediate is oxidized by another, previously unknown NAD‐dependent dehydrogenase TM0412 (named IolM), and a yet unidentified product of this reaction is further hydrolysed by TM0413 (IolN) to form 5‐keto‐l ‐gluconate. The fourth step involves epimerization of 5‐keto‐l ‐gluconate to d ‐tagaturonate by TM0416 (IolO). T. maritima is unable to grow on myo‐inositol as a single carbon source. The determined in vitro specificity of the InoEFGK (TM0418–TM0421) transporter to myo‐inositol‐phosphate suggests that the novel pathway in Thermotoga utilizes a phosphorylated derivative of inositol.     

The influence of the culture pH value on the direct glucose oxidative pathway in Klebsiella pneumoniae NCTC 418

Klebsiella pneumoniae NCTC 418 was cultured aerobically in chemostat cultures (D=0.3 h^-1; 35°C) under respectively carbon-, phosphate-, potassium-, sulphate-, and ammonia-limited conditions with glucose as the sole carbon and energy source. The effect of the external pH value on glucose metabolism and on the enzymes of the direct glucose oxidative pathway was examined. The pH value of the medium had a profound influence on both the activity and the synthesis of the glucose dehydrogenase and the gluconate dehydrogenase. At pH values ranging from pH 5.5 to pH 6.0 maximal activity and synthesis of these enzymes resulted in a more than 80% conversion of the glucose consumed into gluconate and 2-ketogluconate under potassium-or phosphate-limited conditions. On the other hand, no gluconate and/or 2-ketogluconate production could be detected when K. pneumoniae was cultured at pH 8.0. Whereas the synthesis of gluconate dehydrogenase seemingly was completely repressed, still some glucose dehydrogenase was present. The lack of glucose dehydrogenase activity at pH 8.0 was shown not to be due to the dissociation of the cofactor PQQ from the enzyme.Abbreviations DCIP dichlorophenol indophenol - PQQ pyrroloquinoline quinone [2,7,9-tricarboxy-1H-pyrrolo (2,3-f) quinoline-4,5-dione] - WB Wurster's Blue [1,4-bis-(dimethylamino)-benzene perchlorate]     

Determination of relative bioavailability of zinc in a petit suisse cheese using weight gain and bone zinc content in rats as markers

The aim of the study was to determine the relative bioavailability of zinc gluconate stabilized with glycine in a Petit Suisse cheese from an infant dessert. Weight gain and bone zinc content were the nutritional responses evaluated for the diets of different zinc content: 2 ppm (basal) and 5, 10, and 30 ppm from zinc gluconate stabilized with glycine and zinc sulfate. Nonlinear regression analysis of the fitted curves for weight gain determined a relative zinc bioavailability of 100% for the Y _max ratio and 96% for Y _max/t _1/2 ratio for zinc gluconate stabilized with glycine (R ²=0.7996 for zinc sulfate and 0.8665 for zinc gluconate stabilized with glycine). The slope ratio analysis from linear regression of femur zinc determined a relative zinc bioavailability of 93% for zinc gluconate stabilized with glycine (R ²=0.8693 for zinc sulfate and 0.8307 for zinc gluconate stabilized with glycine). Zinc gluconate stabilized with glycine has similar bioavailability as zinc sulfate in a Petit Suisse cheese nutritional matrix, with the advantage that the stabilized compound does not modify the sensorial characteristics of the fortified cheese.     

Regulation of gluconate and ketogluconate production in Gluconobacter oxydans ATCC 621-H

Gluconobacter spp. possess the enzymic potential for two pathways of direct glucose oxidation. It has been proposed that the major part of glucose is oxidized to gluconate via NADP-dependent glucose dehydrogenase and that reoxidation of NADPH under these conditions proceeds via recycling of gluconate through ketogluconates. This hypothesis was tested in experiments in which Gluconobacter oxydans ATCC 621-H was grown in glucose-yeast extract medium containing [¹⁴C]2-ketogluconate. As expected, glucose was almost quantitatively oxidized to gluconate, without further accumulation of 2- and 5-ketogluconate. Interestingly, the total amount of neither [¹⁴C]2-ketogluconate nor [¹⁴C]gluconate did change significantly during this oxidation phase, indicating that recycling of gluconate through ketogluconates did not occur. An analysis of enzyme activities in cell-free extracts of glucose-grown cells of G. oxydans ATCC 621-H showed that the membrane-bound glucose dehydrogenase was far more active than the NADP-linked glucose dehydrogenase. The activity of the latter enzyme constituted only 10–15% of that of quinoprotein glucose dehydrogenase and was far too low to match the in vivo rates of gluconate production in batch cultures of G. oxydans. It is concluded that under these conditions glucose is mainly oxidized to gluconate via the membrane-bound glucose dehydrogenase. Implications of these results for the regulation of ketogluconate formation are discussed.Abbreviations DCPIP 2,6-dichlorophenolindophenol - PMS phenazine methosulphate - PQQ pyrrolo-quinoline quinone     

The carbon source influences the energetic efficiency of the respiratory chain of N2-fixing Acetobacter diazotrophicus

Acetobacter diazotrophicus is a diazotrophic bacterium that colonizes sugarcane tissues. Glucose is oxidized to gluconate in the periplasm prior to uptake and metabolism. A membrane-bound glucose dehydrogenase quinoenzyme [which contains pyrroloquinoline quinone (PQQ) as the prosthetic group] is involved in that oxidation. Gluconate is oxidized further via the hexose monophosphate pathway and tricarboxylic acid cycle. A. diazotrophicus PAL3 was grown in a chemostat with atmospheric nitrogen as the sole N source provided that the dissolved oxygen was maintained at 1.0–2.0% air saturation. The biomass yields of A. diazotrophicus growing with glucose or gluconate with fixed N were very low compared with other heterotrophic bacteria. The biomass yields under N-fixing conditions were more than 30% less than with ammonium as the N source using gluconate as the carbon source but, surprisingly, were only about 14% less with glucose. The following scheme for the metabolism of A. diazotrophicus through the different pathways emerged: (1) the respiratory chain of this organism had a different efficiency of ATP production in the respiratory chain (P:O ratio) under different culture conditions; and (2) N fixation was one (but not the sole) condition under which a higher P:O ratio was observed. The other condition appears to be the expression of an active PQQ-linked glucose dehydrogenase. Received: 6 December 1999 / Received revision: 22 March 2000 / Accepted: 7 April 2000     

Pyruvate production by Enterococcus casseliflavus A-12 from gluconate in an alkaline medium

A newly isolated lactic acid bacterium, Enterococcus casseliflavus A-12, produced pyruvic acid (16 g/l) during aerobic culture in an alkaline medium containing sodium gluconate (50 g/l) as the carbon source. The production was dependent on the pH of the culture, the optimum initial pH being 10.0. With static culture, the organism produced lactic acid (2.7 g/l) from both gluconate and glucose. Pyruvate did not accumulate in growing cultures on glucose, but resting cells obtained from a culture on gluconate produced pyruvate from glucose as well as gluconate. The enzyme profiles of the organism, which grew on gluconate and glucose, suggested that gluconate was metabolized via the Entner-Doudoroff and Embdem-Meyerhof-Parnas pathways in aerobic culture, and that glucose was oxidized mainly via the latter pathway under both aerobic and anaerobic conditions. Gluconokinase, a key enzyme in the aerobic metabolism of gluconate, was partially purified from this strain and characterized.     

Ketogluconate formation by Gluconobacter species

Summary When G. oxydans ATCC 621-H was grown in batch culture in a complex medium with glucose, ketogluconates were produced when the pH in the culture was maintained at 5.5. Without pH control gluconate was the only product of glucose oxidation, but at pH 5.5 the gluconate so produced was further oxidized to ketogluconates. Production of ketogluconates started when glucose was almost completely exhausted. It was shown that the actual glucose and gluconate concentrations in the culture do not determine the onset of ketogluconate formation during growth. Both 2 and 5 ketogluconate were produced. Addition of CaCO₃ to the medium favored the production of 5 ketogluconate. However, under these conditions minor quantities of 2 ketogluconate were also formed. The sequential production of gluconate and ketogluconates from glucose was not only restricted to G. oxydans ATCC 621-H. A number of G. oxydans strains when grown under standard conditions in a pH controlled batch culture, all produced ketogluconates from glucose via an intermediate accumulation of gluconate. Although the ratios of the ketogluconates produced varied from strain to strain, all strains produced both 2 and 5 ketogluconate.     

Dual-substrate inhibition kinetic studies for recombinant human interferon gamma producing Pichia pastoris

Pichia pastoris is considered as one of the prominent host extensively used as a platform for heterologous protein production. In the present study, the growth inhibition kinetics of recombinant P. pastoris expressing human interferon gamma was studied under different initial substrate concentrations of gluconate (10–100?g?L^?1) and methanol (2–50?g?L^?1) in modified FM22 medium. The highest specific growth rate of 0.0206 and 0.019?hr^?1 was observed at 60?g?L^?1 of gluconate and 10?g?L^?1 of methanol, respectively. Various three- and four-parametric Monod-variant models were chosen to analyze the inhibition kinetics. The model parameters as well as goodness of fit were estimated using nonlinear regression analysis. The three-parameter Haldane model was found to be best fit for both gluconate (R²?=?0.95) and methanol substrate (R²?=?0.96). The parameter sensitivity analysis revealed that µ_max, K_i, and K_s are the most sensitive parameters for both methanol and gluconate. Different substrate inhibition models were fitted to the growth kinetic data and the additive form of double Webb model was found to be the best to explain the growth kinetics of recombinant P. pastoris.     

Role of the pentose phosphate pathway and the Entner–Doudoroff pathway in glucose metabolism of Gluconobacter oxydans 621H

Glucose catabolism by the obligatory aerobic acetic acid bacterium Gluconobacter oxydans 621H proceeds in two phases comprising rapid periplasmic oxidation of glucose to gluconate (phase I) and oxidation of gluconate to 2-ketogluconate or 5-ketogluconate (phase II). Only a small amount of glucose and part of the gluconate is taken up into the cells. To determine the roles of the pentose phosphate pathway (PPP) and the Entner–Doudoroff pathway (EDP) for intracellular glucose and gluconate catabolism, mutants defective in either the PPP (Δgnd, Δgnd zwf*) or the EDP (Δedd–eda) were characterized under defined conditions of pH 6 and 15 % dissolved oxygen. In the presence of yeast extract, neither of the two pathways was essential for growth with glucose. However, the PPP mutants showed a reduced growth rate in phase I and completely lacked growth in phase II. In contrast, the EDP mutant showed the same growth behavior as the reference strain. These results demonstrate that the PPP is of major importance for cytoplasmic glucose and gluconate catabolism, whereas the EDP is dispensable. Reasons for this difference are discussed.     

Gluconate accumulation and enzyme activities with extremely nitrogen-limited surface cultures of Aspergillus niger

Batch cultures of Aspergillus niger grown from conidia on a medium with high C/N ratio accumulated gluconate from glucose with a yield of 57%. During almost the whole time of accumulation there was no net synthesis of total protein in the mycelium but the activity per flask and the specific activity of glucose oxidase (EC 1.1.3.4) in mycelial extracts increased whereas both values decreased for glucose dehydrogenase (EC 1.1.99.10) gluconate 6-phosphatase (cf. EC 3.1.3.1, 3.1.3.2), gluconokinase (EC 2.7.1.12), glucose 6-phosphate and phosphogluconate dehydrogenases (EC 1.1.1.49, EC 1.1.1.44), phosphoglucomutase (EC 2.7.5.1), and most enzymes of the Embden-Meyerhof pathway and the tricarboxylic acid cycle. Gluconate dehydratase (EC 4.2.1.39), gluconate dehydrogenase (EC 1.1.99.3) and enzymes of the Entner-Doudoroff pathway could not be detected. By cycloheximide the increase of glucose oxidase activity was inhibited. It is concluded that the high yield of gluconate was due mainly to the net (de novo) synthesis of glucose oxidase which occurred during protein turnover after the exhaustion of the nitrogen source, and which was not accompanied by a net synthesis of the other enzymes investigated. Some gluconate may also have been formed by hydrolytic cleavage of gluconate 6-phosphate.Abbreviations GOD glucose oxidase - GD glucose dehydrogenase - PP pentose phosphate - EM Embden-Meyerhof - TCA tricarboxylic acid     

Microbiological Studies of Coli-aerogenes Bacteria

The presence of glucose-6-phosphate markedly stimulated the anaerobic utilization of glyoxylate by either cell-free extracts or partially purified enzyme preparations of coli-aerogenes bacteria. The enzymic reduction of glyoxylate to glycollate was found to occur in the presence of TPN with the following substrates; glucose-6-phosphate, glucose plus ATP, gluconate plus ATP, glucose-1-phosphate or malate. The data indicated that the reduction of glyoxylate to glycollate was coupled to the oxidation of glucose-6-phosphate via the hexose monophosphate shunt pathway. It was propounded that the operation of the hexose monophosphate oxidative pathway might be controlled by TPN-linked glyoxylic reductase, and the mechanisms of enzymic regulation in microbial respiration were also discussed.     

Effect of temperature on diauxic growth with glucose and organic acids in Pseudomonas fluorescens

Growth of Pseudomonas fluorescens in batch culture with glucose and organic acids resulted in typical diauxic responses at 30° C but no detectable diauxic lag at 5° C.At 30° C, organic acids were preferentially utilized during the first growth phase. Glucose utilization was delayed unitl onset of the second growth phase. Systems involved in direct uptake and catabolism of glucose responded in a manner compatible with respression by malate and/or its metabolites and induction by glucose and/or its metabolites. The oxidative non-phosphorylated pathway, through gluconate and 2-ketogluconate (2-KG) as intermediates, was not induced during either growth phase.At 5° C, growth with glucose and organic acids was biphasic but without diauxic lag. Organic acids were preferentially utilized during the first growth phase. Although carbon from glucose was not fully catabolized until onset of the second growth phase, glucose was oxidized to and accumulated extracellularly as gluconate and 2-KG during the first growth phase. No significant repression of glucose-catabolizing enzymes was observed during growth with organic acids in the presence of glucose. However, uptake activities for gluconate and 2-KG did not increase significantly until onset of the second growth phase.Thus, at low temperatures, psychrotrophic P. fluorescens oxidized glucose to extracellular 2-KG, while growing on preferred carbon sources. The 2-KG was then catabolized after depletion of the organic acid.     

Studies on gluconate metabolism in Aspergillus niger

Summary A citric acid accumulating strain of Aspergillus niger adapted to grow on gluconic acid lactone as sole carbon source was studied with regards to the enzymatic changes occurring during its adaptive growth and compared with those of the parent strain cultivated on sucrose.Glucose oxidase, glucose dehydrogenase, gluconate dehydrogenase and enzymes of Entner Doudoroff pathway could not be detected in the strain. Gluconokinase was detected in the strain and its inducible nature was established. An adaptive increase of gluconokinase, phosphogluconate dehydrogenase and ribose phosphate isomerase was observed. While the levels of the above enzymes were significantly higher, that of glucose 6-phosphate dehydrogenase were significantly low indicating the repression of the enzyme. Levels of hexokinase and fructose diphosphate aldolase remained more or less the same as that of parent strain. It was inferred from the results that gluconate metabolism occurs via the pentose phosphate pathway following initial phosphorylation.Part of this work was presented at the 8th Annual Microbiological Congress of Association of Microbiologists of India, held in New Delhi 1967.